Bradley MF2922, MF2933, MF2939, MF2944, MF2949 Parts And Service Manual
MF2922 (AST shown)
Parts & Service
Terreon Multi-Fount Washfountain
Discontinued Models Prior to
February 1, 2013
MF2922
Corner-Fount
MF2933
Tri-Fount
MF2939
Tri-Fount, Wall-Hung
MF2944
Quadra-Fount
™
™
™
MF2939 (AST shown)
MF2933 (AST shown)
MF2944 (AST shown)
MF2949
Quadra-Fount™, Wall-Hung
Table of Contents
Infrared ......................................................................................... 2
Air Metering (AST4) ..................................................................... 8
AST4 and IR Supply and Mixing Valve ...................................... 14
Battery Infrared (BIR) ................................................................ 16
TouchTime (TT) ......................................................................... 24
Thermostatic Mixing Valve Troubleshooting ............................... 27
Soap System ............................................................................. 30
Drain Spud and Strainer ............................................................ 33
Floor Pedestal Assembly ........................................................... 34
Wall Mount Pedestal Assembly ................................................. 35
Sprayhead Covers .................................................................... 35
Pedestal Panels ......................................................................... 37
Bowl Assembly ........................................................................... 38
Terreon® Cleaning and Maintenance ......................................... 39
Part numbers are subject to
change without formal notice.
MF2949 (AST shown)
215-1448 Rev. C; ECN 17-00-014
© 2017 Bradley
Page 1 of 39 9/28/2017
Menomonee Falls, WI 53052 USA
P.O. Box 309
800 BRADLEY (800 272 3539)
+1 262 251 6000
bradleycorp.com
Terreon Multi-Fount Washfountains Parts and Service
Infrared (IR) — Sprayhead (24V Plug-In Transformer)
1
10
4
5
3
1
2
6
7
8
9
Parts List — Infrared Sensor and Sprayhead Assembly
Item Part No. Description
1 269-1608 Sensor - Adaptive 2 3 4
- P10-569 Hook and Loop Fastener Strip (sensor mounting) 2 3 4
2 269-1190 Window 4 6 8
3 115-131 Sprayhead 2 3 4
4 176-119 Threaded Rod 4 6 8
5 140-748 Backplate 2 3 4
6 161-026 Nut 4 6 8
7 142-002BS Lockwasher 4 6 8
8 269-871 Fitting Straight (front sprayhead) - 1 2
9 269-628 Fitting Swivel 90° (side sprayheads) 2 2 2
10 R68-60011-R Tubing 1/4", Red * * *
10 R68-600011-G Tubing 1/4", Green * * *
10 R68-600011-B Tubing 1/4", Black * * *
10 R68-600011-Y Tubing 1/4", Yellow * * *
* Specify length in feet
Corner Tri Quad
Qty. Qty. Qty.
2
9/28/2017 Bradley • 215-1448 Rev. C; ECN 17-00-014
Parts and Service Terreon Multi-Fount Washfountains
Infrared (IR) — Valves (24V Plug-In Transformer)
Prior to February 1, 2013
13
9
8
1
4
2
5
3
6
7
14
10
Black Supply Tube
(From Sprayhead)
Green Supply Tube
(From Sprayhead)
White Jumper
Terminals
Tri-Fount Shown
Red Supply Tube
(From Sprayhead)
12
11
Red Spade
Terminal
Green Spade
Terminal
Black Spade
Terminal
15
Parts List — Solenoid Valve Assembly and Valve Parts
Item Part No. Description
1 S45-2084 IR TMA Dual valve Assembly (includes items 7-13) 1 - -
2 S45-2085 IT TL Dual Valve Assembly (includes items 8-14) 1 - -
3 S45-2090 IR TMA Tri Valve Assembly (includes items 7-13) - 1 -
4 S45-2091 IR TL Tri Valve Assembly (includes items 8-14) - 1 -
5 S45-2162 IR TMA Quad Valve Assembly (includes items 7-13) - - 1
6 S45-2163 IR TL Quad Valve Assembly (includes items 8-14) - - 1
7 S01-520 Vernatherm Valve, 4 GP 1 1 1
8 140-928 Bracket, Ganged Valve 1 1 1
9 P18-054 Screw 10-24 x 3/8 PN 2 2 2
10 S07-068A Solenoid Valve, 24 VAC, through 1 2 3
11 S07-068 Solenoid Valve, 24 VAC, closed 1 1 1
12 110-231 Compression Nut, 1/4" 2 3 4
13 160-447 Screw 8-16 x 5/8 PN 2 3 4
14 S39-685 Adapter, Valve Inlet 1 1 1
15 S83-152 Transformer 1 1 1
Bradley • 215-1448 Rev. C; ECN 17-00-014 9/28/2017
Corner Tri Quad
Qty. Qty. Qty.
3
Terreon Multi-Fount Washfountains Parts and Service
Infrared (IR) — Sprayhead (24V Plug-In Transformer)
Prior to June 13, 2005
18
3 Station Shown
15
14
Parts List — Solenoid Assembly and Valve Parts
Item Part No. Description
* S08-088 2 Valve Assembly with Bracket 1 - -
- S08-344 3 Valve Assembly with Bracket - 1 -
* S08-345 4 Valve Assembly with Bracket - - 1
*15 269-1365 Hose (Supply Inlet) 1 1 1
16 S83-152 Transformer 24 VAC
(269-901 no terminals)
*17 S83-145A Wire Harness 2 Solenoid 1 - -
17 S83-144 Wire Harness 3 Solenoid - 1 -
*17 S83-144B Wire Harness 4 Solenoid - - 1
*18 S83-144A Wire Harness 2 Sensor 1 - -
18 S83-145 Wire Harness 3 Sensor - 1 -
*18 S83-145B Wire Harness 4 Sensor - - 1
* Not Shown
Corner Tri Quad
Qty. Qty. Qty.
1 1 1
17
16
4
9/28/2017 Bradley • 215-1448 Rev. C; ECN 17-00-014
Parts and Service Terreon Multi-Fount Washfountains
Infrared (IR) Valve Assembly - Solenoid Valve S07-068 (Closed Body)
and S07-068A (Thru Body) Prior to February 1, 2013
8
Solenoid Valve Parts List
Item Part No. Description Qty
7
8
6
5
4
1 118-307 Valve Body, 1/4" Closed 1
1 118-307A Valve Body, 1/4", Through 1
2 269-983 Diaphragm 1
3 269-577 Armature 1
4 269-578 Spring 1
5 269-1729 Armature Housing 1
6 269-1730 clamp, Armature Housing 1
7 269-579 Coil, Solenoid Valve 1
8 160-447 Screw #8 x 5/8 3
9 125-165 O-Ring, #2-013 1
10 125-160 Flow Restrictor, 0.5 GPM 1
11 S65-113 Repair Kit 1
3
2
10
1
9
Problem Cause Solution
An individual
operating station
fails to shut off and
drips.
There is debris
trapped between
the diaphragm and
the valve seat.
Remove debris between diaphragm and the valve seat.
1. Remove the three #8 Phillips-head screws that hold the solenoid valve assembly together. Be
careful not to lose the armature or spring (see previous page).
2. Remove the diaphragm. Remove any particles that have been trapped between the diaphragm
and the valve seat. Rinse off the diaphragm and inspect for damage. Make sure the center orifice
and both small side orifices are open.
3. Reassemble in reverse order, being careful not to overtighten the Phillips-head screws or you
may crack the plastic valve body. Tighten until the armature plate makes contact with the plastic
body.
4. Reconnect the wiring per diagram.
An individual
operating station
fails to turn on.
A failed coil for
the valve or
loose electrical
connection to the
terminal.
Test the station to determine cause.
1. Disconnect the wires from the coil of an adjacent valve. Disconnect the wires from the problem
valve and reconnect to the adjacent valve.
2. Turn on electrical and water supplies to the unit. Place hands in front of sensor for the problem
station; the adjacent station should turn on.
If the adjacent station turns on and cycles normally, replace the coil on the problem valve.
If the adjacent valve fails to turn on, inspect the wires from the sensor cable and do the following:
• make sure there are no breaks and that the fully insulated disconnect terminals are firmly
crimped in place;
• turn off the electrical and water supplies;
• reconnect to the adjacent valve and turn on the water supplies to the unit;
• place hands in front of sensor. If the station still fails to turn on, replace the sensor.
11
Turn off water supplies to unit before troubleshooting.
Bradley • 215-1448 Rev. C; ECN 17-00-014 9/28/2017
5
Terreon Multi-Fount Washfountains Parts and Service
Infrared (IR) Valve Assembly (24V Plug in Transformer) -
Solenoid Valve S07-040 Individual (End), S07-041 Ganged
Prior to June 13, 2005
1
2
Parts List — Solenoid Assembly and Valve Parts
Item Part No. Description
- S07-040 Valve Individual
(includes items 1-9)
- S07-041 Valve Ganged
(includes items 1-10)
1 160-066 Screw 10-24 x 1/4 RD 2 3 4
2 142-002AZ Washer Stainless Steel 2 3 4
3 269-579 Coil - Solenoid Valve 2 3 4
4 110-194 Nut - Bonnet 2 3 4
5 121-028 Bonnet 2 3 4
6 269-578 Spring 2 3 4
7 269-577 Armature 2 3 4
8 269-580 Diaphragm 2 3 4
9 118-237 Valve Body Individual (C) 1 1 1
9 118-238 Valve Body Ganged (A & B) 1 2 3
10 125-145 O-Ring (for ganged valve body) 1 2 3
11 110-224 Nut 2 3 4
12 S88-065 Tailpiece Assembly 2 3 4
13 110-195 Tailpiece Nut 2 3 4
14 145-089 Connector 2 3 4
Corner Tri Quad
Qty. Qty. Qty.
1 1 1
1 2 3
4
Tailpiece
Assembly
5
6
7
8
9
10
Solenoid valve S07-041 for "Ganged"
applications is identical to the S07040 "Individual" (End - opposite
supply inlet) valve. Except this end
has an o-ring (Item 10) for sealing
and the inner wall has been removed
to permit water to flow through to
adjacent valve.
3
11
12
13
14
6
9/28/2017 Bradley • 215-1448 Rev. C; ECN 17-00-014
Parts and Service Terreon Multi-Fount Washfountains
Infrared (IR) - Sensor and Valve Troubleshooting
Prior to June 13, 2005
Problem Cause Solution
The center station
(B) will not shut
off.
Problem with a
sensor or solenoid
valve.
1. Disconnect the sensor wires to the center solenoid valve (B) and set them out of the way.
2. Disconnect the sensor wires to the left solenoid valve (A). Set these wires out of the way and make
sure they will not make contact with each other or any metal or framework.
3. Connect the wires from the center solenoid valve (B) to the left solenoid valve (A).
4. Reconnect the transformer to the wall outlet for power. Be sure to wait 2 minutes before trying
to activate the sensor after disconnecting power, as the sensor has to reset and adapt to the
environment.
5. Use your hands to activate the center station (B) and watch for the water to come out of the left
station (A).
If the left station works and shuts off, then the solenoid for the center station is the problem. There may
be debris between the valve seat and diaphragm. To remove the debris:
1. Disconnect the wires from the solenoid.
2. Loosen and remove the screw on top of the coil of the solenoid valve.
3. Unscrew the bonnet nut (counterclockwise) and tip forward to remove from the valve body.
4. Remove the diaphragm (269-580).
5. Remove any particles that may have been trapped between the diaphragm and the valve seat.
6. Rinse off the diaphragm and inspect for damage.
7. Make sure both orifices in the diaphragm are open.
8. Reassembly and retry the solenoid valve.
If there is still a problem, replace the solenoid valve. If ordering replacement solenoid valves, be careful
to order correctly, either an "individual" or a "ganged" solenoid valve.
If the left station does not shut off, then the sensor for the center station is the problem. The sensor will
have to be replaced. It cannot be repaired or adjusted in any way.
Bradley • 215-1448 Rev. C; ECN 17-00-014 9/28/2017
7
Terreon Multi-Fount Washfountains Parts and Service
Air Metering Valve (AST4) - Pushbutton and Sprayhead
3
2
1
4
16
11
15
14
10
9
7
6
13
22
23
5
26
24
14
12
27
17
18
21
26
19
20
25
8
9/28/2017 Bradley • 215-1448 Rev. C; ECN 17-00-014
Parts and Service Terreon Multi-Fount Washfountains
Parts List — AST4 Pushbutton and Sprayhead
Item Part No. Description
1 S08-340 Pushbutton Assembly (Includes Items 2 thru 4) 2 3 4
2 128-090 Pushbutton Only 2 3 4
3 179-104 Guide for Pushbutton 2 3 4
4 147-034 Shoulder Screw for Pushbutton 2 3 4
5 182-110 Spacer 2 3 4
6 140-743 Brackey 2 3 4
7 110-115 Nut 2 3 4
- S65-168 Actuator Assembly (Includes Items 9 thru 14) 2 1 2
- S65-168A Actuator Assembly (Includes Items 9 thru 15) - 2 2
9 119-227A Piston 2 3 4
10 125-099 U-Cup 2 3 4
11 135-065 Spring 2 3 4
12 118-279 Actuator Body 2 3 4
13 198-010 Duckbill Check 2 3 4
14 169-890 Tube Connector 1/8" Straight 2 3 4
15 269-1186 Fitting Adj J - 2 2
16 160-165 Screw 4 6 8
17 R68-600008-R Tubing 1/8" OD, Red * * *
17 R68-600008-G Tubing 1/8" OD, Green * * *
17 R68-600008-B Tubing 1/8" OD, Black * * *
17 R68-600008-Y Tubing 1/8" OD, Yellow * * *
18 115-131 Sprayhead 2 3 4
19 176-119 Threaded Rod 4 6 8
20 269-1190 Window Hole Plug 4 6 8
21 140-748 Backplate 2 3 4
22 161-026 Nut 4 6 8
23 142-002BS Lockwasher 4 6 8
24 269-871 Fitting Straight (Front Sprayhead) - 1 2
25 269-628 Fitting Swivel 90° (Side Sprayheads) 2 2 2
26 R68-600011-R Tubing 1/4" ID, Red * * *
26 R68-600011-G Tubing 1/4" ID, Green * * *
26 R68-600011-B Tubing 1/4" ID, Black * * *
26 R68-600011-Y Tubing 1/4" ID, Yellow * * *
27 130-023 Spanner Wrench 1 1 1
Corner Tri Quad
Qty. Qty. Qty.
* Specify length in feet.
Bradley • 215-1448 Rev. C; ECN 17-00-014 9/28/2017
9
Terreon Multi-Fount Washfountains Parts and Service
Air Metering Valve (AST4) - Assembly
Prior to February 1, 2013
13
9
7
8
1
2
3
4
5
6
Parts List — Air Metering Valve Assembly
12
11
10
14
Item Part No. Description
1 S08-452TMA TMA Dual Valve Assembly (Includes Items 7 thru 13) 1 - -
2 S08-452TL TL Dual Valve Assembly (Includes Items 8 thru 14) 1 - -
3 S08-453TMA TMA Tri Valve Assembly (Includes Items 7 thru 13) - 1 -
4 S08-453TL TL Tri Valve Assembly (Includes Items 8 thru 14) - 1 -
5 S08-454TMA TMA Quad Valve Assembly (Includes Items 7 thru 13) - - 1
6 S08-454TL TL Quad Valve Assembly (Includes Items 8 thru 14) - - 1
7 S01-520 Vernatherm Valve, 4 GP 1 1 1
8 140-928 Bracket, Ganged Valve 1 1 1
9 P18-054 Screw 10-24 x 3/8 PN 2 2 2
10 S07-078A AST4 Valve, Through 1 2 3
11 S07-078 AST4 Valve, Closed 1 1 1
12 110-231 Compression Nut, 1/4" 2 3 4
13 160-447 Screw 8-16 x 5/8 PN 2 3 4
14 S39-685 Adapter, Valve Inlet 1 1 1
10
9/28/2017 Bradley • 215-1448 Rev. C; ECN 17-00-014
Corner Tri Quad
Qty. Qty. Qty.
Parts and Service Terreon Multi-Fount Washfountains
Air Metering Valve (AST4) - Assembly
Prior to June 13, 2005
Parts List — Air Metering Valve Assembly
Item Part No. Description
1 S67-202
1 S67-181
1 S67-180
2 S07-058 Air Valve 2 3 4
3 169-168 Pipe Plug 1/2" 1 1 1
4 S45-1967
5 125-020 Flow Control 2 3 4
6 169-890 Tube Connector 1/8" Straight 2 3 4
7 169-639 Elbow 90° 1/2" 1 1 1
8 113-006DH Nipple 1/2" 1 2 3
Metering Valve Assembly Corner-Fount
Metering Valve Assembly -
Tri-Fount
Metering Valve Assembly Quadra-Fount
Tube Connector 1/4" x 3/8" with
Flow Control
Corner Tri Quad
Qty. Qty. Qty.
1 - -
- 1 -
- - 1
2 3 4
AST4 Valve Repair Kits
Prior to February 1, 2013
Parts List — AST4 Valve Repair Kits
4
1
Metering Valve Assembly
S67-181 Tri-Fount (Shown)
S67-180 Quadra-Fount
S67-202 Corner-Fount
5
6
7
14
8
2
3
Item Part No. Description
1 125-165 O-Ring
2 118-307A Valve Body - Manifolded
3 118-307 Valve Body - Closed
4 269-983 Diaphragm
5 269-577 Armature, Valve
6 269-578 Spring, Valve
7 118-309 Cover, AST4 Valve
8 107-538 Cover, AST4 Valve Timer
9 S27-305 Timer, ASM, AST4 Valve
10 125-001BY O-Ring
11 110-234 Compression Nut, 1/8"
12 S39-591 Magnet/Diaphragm Assembly
13 107-535 Cover, AST4 Valve
14 110-233 Clamp Nut, AST4 Valve
15 160-449 Screw 8-16 x 7/8"
16 S65-261 Repair Kit - AST4 Valve
17 S65-262 Repair Kit - AST4 Valve - Upper
18 S65-260 Repair Kit - AST4 Valve - Complete
18
8
10
17
16
9
7
1
13
12
11
6
5
4
15
3
2
Bradley • 215-1448 Rev. C; ECN 17-00-014 9/28/2017
11
Terreon Multi-Fount Washfountains Parts and Service
Parts List — Air Metering Valve Repair Kit
Prior to June 13, 2005
1
3
4
5
6
2
10
9
11
12
Parts List — Air Metering Valve S07-058
Item Part No. Description Qty.
1 118-183 Valve Body Lower 1
2 117-036 Valve Seat 1
3 269-665 Rubber Diaphragm 1
4 269-664 Seat Guide 1
5 179-082 Armature with Grommet 1
6 135-053 Spring 1
* S65-110
8 S73-054A
9 S27-254 Timer Assembly 1
10 169-890 Tube Connector 1/8" Straight 1
11 142-002CR Lockwasher #8 4
12 160-313 Screw 4
Small Parts Kit
(includes items 3-6)
Large Parts Kit (includes items
7-12) (includes Small Parts Kit)
1
1
8
12
9/28/2017 Bradley • 215-1448 Rev. C; ECN 17-00-014
Loading...