Bosch HBL 742A UC, HBL 732A UC, HBL 745A UC, HBL 746A UC, HBL 752A UC Installation Instructions Manual
...
INSTALLATION INSTR UCTION MANUAL for
Bosch Electric Built-in Single & Double Oven
Models HBL 73../74../75../76.. and Models HBN 74../75../76..
BEFORE YOU BEGIN, READ THESE INSTRUCTIONS COMPLETELY AND CAREFULLY
IMPORTANT: Save these instructions for the local electrical inspector’s use.
INSTALLER: Please leave this manual with owner for future reference.
OWNER: Please keep this manual for future reference.
VEUILLEZ LIRE ATTENTIVEMENT CE MANUEL AVANT DE COMMENCER L’INSTALLATION
IMPORTANT: Conservez ce manuel pour l’inspecteur électrique local.
INSTALLATEUR: Veuillez remettre ce manue! au proprietaire de l’appareil
PROPRIÉTAIRE: Veuillez garder ce manuel et vous en servir pour
pour référence.
référence.
© 2002 BSH Home Appliances Corp.
1
Table Of Contents
Introduction .............................................................................................................. 3
T ools Y ou Will Need ........................................................................................... 3
Power Requirements........................................................................................... 3
Choosing Oven Location .................................................................................... 3
Steps For Installation .......................................................................................... 3
Technical Data..................................................................................................... 4 – 5
HBL Models: Single Oven, Double Oven.......................................................... 4
HBN Models: Single Oven, Double Oven ......................................................... 5
Undercounter Installation........................................................................................ 6
Single Oven ........................................................................................................ 6
Wall Installation.................................................................................................. 7 – 8
Single Oven ........................................................................................................ 7
Double Oven....................................................................................................... 8
Electrical Supply............................................................................................... 9 – 10
Wiring Requirements.................................................................................. 9 – 10
Connecting To 208 Volt Circuit ........................................................................ 10
Electrical Connections............................................................................................ 11
3-Wire Branch Circuit ...................................................................................... 11
4-Wire Branch Circuit ...................................................................................... 11
Final Checklist ........................................................................................................ 12
PB
INTRODUCTION
Please read these instructions COMPLETELY
AND CAREFULLY. They will save you time and
effort and help to ensure optimum oven performance.
Be sure to observe all WARNINGS.
These installation instructions are intended for
use by a qualified installer. In addition to these
instructions, the oven shall be installed:
• In the United States, in accordance with the National Electric Code/State and Municipal codes
and/or local codes.
• In Canada, in accordance with Canadian Electric
Code C22.1-latest edition/Provincial and Municipal codes and/or local codes.
These shall be carefully followed at all times.
Note: If installing your oven in Canada please
check to make sure that you have a model
with the UL Canadian listing mark, as
shown below:
The UL Canadian listing mark consists of the
circled UL symbol preceded by the letter “C,” as
shown. This should appear on the ov en’ s rating plate
along with the UL United States listing mark, which
is the circled UL symbol above but not preceded by
the letter “C.”
TOOLS YOU WILL NEED
The following tools are needed to install your
new oven:
• Tape measure and straightedge or ruler
• Pencil
• Phillips screwdriver
•Level
• Wire cutters and wire stripper
• 1-inch hole saw
• Hand or saber saw
POWER REQUIREMENTS
The oven must be supplied with the proper voltage and frequency. The oven is manufactured to be
connected to a three-wire or four-wire, single phase,
240 Volt, 60 Hz AC electrical supply on a separate
circuit fused on both sides of the line. If a 208 Volt
circuit must be used, see Connecting to 208 Volt
Circuit, in this manual. A circuit breaker or timedelay fuse sized not to exceed the circuit rating of
the appliance specified on the rating plate located
on the frame behind the door of the oven is recommended.
The oven must be supplied with copper wires
ONLY.
It is recommended that you have the electrical
wiring and hook-up of your oven performed by a
qualified electrician. After installation is complete
have the electrician show you where the main disconnect is and which of the circuit breakers/fuses
are for the oven.
CHOOSING OVEN LOCATION
Carefully select the location where the oven will
be placed. The oven should be located for convenient use in the kitchen, but away from strong drafts.
Strong drafts may be caused by open doors or windows, or by heating and/or air conditioning vents or
fans. Make sure that electrical power can be provided to the location selected.
STEPS FOR INSTALLATION
The following pages provide the necessary information for proper installation of the oven arranged
as follows:
• Technical Data
• Installation Cutout Dimensions, Required Clear-
ances and Mounting instructions for:
> Undercounter Installation, Single Oven
> Wall Installation, Single Oven
> Wall Installation, Double Oven
• Electrical Supply and W iring Requirements, Pro-
gramming required if connecting to 208 Volt Cir-
cuit. Electrical Connections for 3-wire or 4-wire
Branch Circuit.
• Final Checklist
3
TECHNICAL DATA for HBL 73../74../75../76..
SINGLE OVEN
For cutout dimensions see following section titled:
Preparing Location
Electrical Ratings
and Maximum Connected Load
Single Oven Amperes Watts Convection
Models Volts Hertz @240V/208V @240V/208V Oven
HBL 732A UC 240/208 60 15.4/17.2 3,600/3,500 No
HBL 735A UC 240/208 60 15.4/17.2 3,600/3,500 No
HBL 736A UC 240/208 60 15.4/17.2 3,600/3,500 No
HBL 742A UC 240/208 60 15.8/17.6 3,650/3,550 Yes
HBL 745A UC 240/208 60 15.8/17.6 3,650/3,550 Yes
HBL 746A UC 240/208 60 15.8/17.6 3,650/3,550 Yes
SINGLE O VEN
29-1/4" width
22-13/16"
22" depth
DOUBLE OVEN
29-1/4" width
23-1/4" height
22" depth
DOUBLE OVEN
For cutout dimensions see following section titled:
Preparing Location
Electrical Ratings
and Maximum Connected Load Convection
Double Oven Amperes Watts Oven
Models Volts Hertz @240V/208V @240V/208V (top/bottom)
HBL 752A UC 240/208 60 31.2/34.8 7,250/7,050 Yes/No
HBL 755A UC 240/208 60 31.2/34.8 7,250/7,050 Yes/No
HBL 756A UC 240/208 60 31.2/34.8 7,250/7,050 Yes/No
HBL 765A UC 240/208 60 31.6/35.2 7,300/7,100 Yes/Yes
48" height
PB
Loading...