Bond HYFP50095-53 Owner's Manual

READ BEFORE USE!

Im

OWNER'S MANUAL

Factory No.: HYFP50095-53 Item No.: 67531

WARNING

For Outdoor Use On ly! Use Propane Gas On ly !

Propane cylinders sold separately.

WARNING

WARNING

DANGER

Improper installation, adjustment,alteration,service
or maintenance can cause injury or property damage. Read
the owner's manual thoro u gh ly before installing or serv icin g
this equipment. If the info rmation in th is manu al is n o t
followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.

WARNING

Battery may contain mercury.Do not deposit in fire or put in
trash.Recycle manage as hazardous waste.

WARNING

For use with cylinders marked PROPANE only.
DO NOT connect to a remote gas supply.

If the firebowl is stored indoors, detach and leave
propane cylinder outdoors.

USE PROPANE GAS ONLY!

-Do not store or use gasoline or other
flammable vapors in the vicin ity of this or any
other appliance.

- Service must be performed by a qualified
installer, service agency or the gas supplier.

Turn off gas supply when the firebowl is not in use.

Design certified under ANSI Z21.97 • CSA 2.41­(2012) Requirements for Ou tdoor Gas Fireplaces

1

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious
bodily injury or death, or in a fire or an explosion causing damage to property.

WARNING

*Do not use this firebowl for cooking.
*Remove the PVC Cover from the firebowl before opening the appliance.
*Do not lay the PVC Cover over the firebowl until it is turned off and completely cooled down.
*Do not burn any other materials than are supplied with and intended for use in this firebowl.
*Do not pour water into firebowl.
*The installation of this product must conform with local codes or, in the absence of local codes, with either the National
Fuel Gas Code,ANSI Z223.1/NFPA 54, OR CAN/CGA-B149.1, National Gas and Propane Installation Code.
*Do not use this firebowl if any part has been under water.
*Do not store a spare or disconnected propane cylinder under or near this firebowl.
*After a period of storage, and/or non use, the propane firebowl should be checked for gas leaks and burner obstructions before use.
*Do not operate the propane firebowl if there is a gas leak present.
*Never use a flame to check for gas leaks.
*Combustible materials should never be within 48 inches of the top, back or sides of your propane firebowl.
*Do not put any other fireplace cover or anything flammable on, or beneath the firebowl.
*The propane firebowl should never be used by children. Children must be supervised when they are anywhere near the appliance.
*Users should be alerted to the hazards of high surface temperatures and keep a safe distance to avoid burning or clothing ignition.
*Pay attention when operating the firebowl. It is hot in use and should never be left unattended. Do not transit it while in operation.
*Should fire go out while burning, turn the gas valve off. Follow the instruction and wait five minutes before attempting to relight.
*Never use charcoal or any other solid fuel in the firebowl. Never parch clothing or other flammable materials on or near the
firebowl.
*Never lean over the open firebowl or place hands or fingers on the upper portion of an operational unit.
*Keep ventilation openings in cylinder enclosure(FIREBOWL BODY) free and clear of debris.
*Inspect the burner before each use of the appliance. If there is evidence of damage, the burner must be replaced prior to the

*Do not rest feet on the firebowl.
*Please take out the battery when not using the firebowl for an extended length of time.
*Do not enlarge valve orifices or burner ports when cleaning the valve or burner.
*Cylinder supply system must be arranged for vapor withdrawal.
*Propane Tank used must include a collar to protect the cylinder valve.
*Never fill the cylinder beyond 80% full.
*Propane gas is not natural gas. Only use propane for this firebowl.
*The conversion or attempted use of natural gas in a propane unit or propane gas in a natural gas unit is dangerous.
*Do not use this firebowl on vehicles or boats. Always operate the appliance on flat ground outdoors.
*Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
*Do not use this firebowl unless all parts are in place.

appliance being put into operation. Use Manufacturer approved or supplied replacement burner only.

DANGER

*The maximum gas supply pressure is 250psi.
*Use LP cylinders only with these required measurements: 12"(30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) capacity
maximum.

*Clean the battery contacts and also those of the device prior to battery installation.
*Remove batteries from equipment which is not to be used for an extended period of time.
*Remove used batteries promptly.

2

Children and adults should be alerted to the hazards of high surface temperatures and should stay away to
avoid burns or clothing ignition.

• Young children should be carefully supervised when they are in the area of the appliance.

• Clothing or other flammable materials should not be hung from the appliance, or placed on or near the appliance.

• Any guard or other protective device removed for servicing the appliance must be replaced prior to operating the appliance.

FOR PROPANE GAS UNITS

*The gas pressure regulator provided with the propane fire bowl must be used.
*Do not attempt to disconnect the gas regulator or any gas fitting while your firebowl is in operation.
*A dented or rusty propane cylinder may be hazardous and should be checked by your gas supplier prior to use.
*Do not use a propane cylinder with a damaged valve and any other worn out parts.
*Transit and store the empty gas cylinders carefully and properly.
*If you see, smell or hear the hiss of escaping gas from the propane cylinder:

1. Turn off the gas supply and get away from the gas cylinder and the firebowl at once.

2. Do not attempt to correct the problem yourself.

3. Get to your gas supplier and/or the fire department for help.

• A statement that the LP-gas supply cylinder to be used must be constructed and marked in accordance with the specifications for
LP-gas cylinders of the U.S. Department of Transportation (DOT).

• Instructions to the effect that this appliance shall be used only outdoors in a well-ventilated space and shall not be used in a
building, garage or any other enclosed area.

•How to disconnect a gas bottle
Turn OFF control knob and LP cylinder valve. Turn coupling nut counterclockwise by hand only - do not use tools to
disconnect .Loosen cylinder screw beneath bottom shelf, then lift LP cylinder up and out of shelf. Place dust cap on cylinder
valve outlet whenever the cylinder is not in use.

• Storage of an appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance. Cylinders must
be stored outdoors in a well-ventilated area out of reach of children. Disconnected cylinders must have threaded valve plugs tightly
installed and must not be stored in a building, garage or any other enclosed area.

• Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least
annually by a qualified service person. More frequent cleaning may be required as necessary. It is imperative that control
compartment, burners and circulating air passageways of the appliance be kept clean.

• Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least
annually by a qualified service person.

Immediately call a qualified service technician to inspect the appliance and to replace any part of the control system and any gas
control which has been under water.”

• Specific size and capacity of the cylinder to be used.

Inspect the hose before each use of the appliance. If the hose shows signs of cracks, abrasions, cuts or damage of any kind, do not
operate the appliance. Fix or replace the hose as required before using the appliance. For assistance with repair or replacement of
the hose, call Bond Manufacturing at 1-866-771-2663. Use only replacement parts from the manufacturer.

WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the
owner’s information manual provided with this appliance. For assistance or additional information consult a qualified installer,
service agency or the gas supplier.

The LP-gas supply cylinder must be disconnected when this appliance is not in use

Only cylinder marked “propane” shall be used.

Caution:
Only use the pressure regulator and hose assembly supplied with this firebowl. Replacement pressure regulator and hose assemblies
must be specified or supplied by BOND MANUFACTURING CO.

3