Bond BH5002-1 Owner's Manual
1
READ BEFORE USE!
Improper installation,
adjustment,alteration,service or maintenance can cause
injury or property damage. Read the owner's manual
thoroughly before installing or servicing this
equipment. If the information in this manual is not
followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
WARNING
USE PROPANE GAS ONLY!
-Do not store or use gasoline or other
flammable vapors in the vicinity of this or any other
appliance.
- Service must be performed by a qualified installer, service
agency or the gas supplier.
OWNER'S MANUAL
Factory No.: BH5002-1 Style No.: 66601
WARNING
For Outdoor Use Only! Use Propane Gas Only !
Propane cylinders sold separately.
WARNING
WARNING
WARNING
For use with cylinders marked PROPANE only.DO NOT
connect to a remote gas supply.
If the firebowl is stored indoors, detach and leave propane
cylinder outdoors.
WARNING
This firebowl must be attended at all times!
Design certified under ANS Z21.97 • CSA 2.41-(2012)
Requirements for Outdoor Gas Fireplaces
WARNING
An LP-cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
The propane cylinder must be disconnected
when this firebowl is not use.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the appliance
and immediately call your gas supplier or fire
department.
2
DANGER
*Do not use this firebowl for cooking.
*Do not burn any other materials than are supplied with and intended for use in this firebowl.
*Do not pour water into firebowl.
*The installation of this product must conform with local codes or, in the absence of local codes, with either the National
Fuel Gas Code,AN SI Z223.1/NFPA 54, OR CAN/CGA-B149.1, National Gas and Propane Installation Code.
*Do not use this firebowl if any part has been under water.
*Do not store a spare or disconnected propane cylinder under or near this firebowl.
*After a period of storage, and/or non use, the propa ne firebowl should be checke d for gas leaks and burner obstructions before
use.
*Do not operate the propane firebowl if there is a ga s leak present.
*Never use a flame to check for gas leaks.
*Combustible materials should never be within 72 inches of the top, back or sides of your propane firebowl.
*Do not put any othe r firebowl cover or a nything flamma ble on, or beneath the firebowl.
*The propane firebowl should never be used by children. Children must be supervised when they a re anywher e near the appliance.
*Users should be alerted to the hazards of high surface te mperatures and keep a sa fe distance to avoid burning or c lothing
ignition.
*Pay attention w hen operating the firebowl. It is hot in use and should never be left una ttended. Do not transit it while in
operation.
*Should fire go out while burning, turn the gas valve off. Follow the instruction and wait five minutes before attempting to relight.
*Never use charcoal or any other solid fuel in the firebowl. Never parch clothing or othe r flammable materials on or near the
firebowl.
*Never lean over the open firebowl or plac e hands or fingers on the upper portion of an operational unit.
*Keep ventilation openings in cylinder enclosure(FIREBOWL BODY) free and cle ar of debris.
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious
bodily injury or death, or in a fire or an explosion causing damage to property.
*The max inlet supply pressure "Max.g as supply 11 inch w.c. (2.74kPa).
*Use LP cylinders only with these required measurements: 12"(30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.)
capacity maximum.
WARNING
*Do not rest feet on the firebowl.
*Do not enlarge valve orifices or burner por ts when cleaning the valve or burner.
*Cylinder supply system must be arranged for vapor withdrawal.
*Propane Tank used must include a collar to protect the cylinder valve.
*Never fill the cylinder beyond 80% full.
*Propane gas is not natural gas. Only use pr opane for this firebowl.
*The conversion or attempted use of natural gas in a propane unit or propane gas in a natural g as unit is dangerous.
*Do not use this firebowl on vehicles or boats. Always operate the appliance on flat ground outdoors.
*Keep any e lectrical supply cor d and the fuel supply hose away from a ny heated surfac es.
*Do not use this firebowl unless all parts are in place.
3
Caution:
Only use the pre ssure regulator and hose assem bly supplied with this firebowl. Replacement pressur e regulator and hose
assemblies must be specified or supplied by BOND MANUFACTURING CO.
WARNING: Improper installation, adjustment, alte ration, service or maintenance can cause injury or property damage. Refe r to
the owner’s information manual provided with this appliance. For assistance or additional information consult a qualified
installer, service agency or the gas supplier.
The LP-gas supply cylinder must be disconnected when this appliance is not in use
• Storage of an appliance indoors is permissible only if the cylinder is disconne cted and removed from the appliance. Cy linders
must be stored outdoors in a well-ventilated area out of rea ch of children. Disconnected cylinders must have threaded valve plugs
tightly installed and m ust not be stored in a building, garage or any other enclosed area.
Children and adults should be alerted to the hazards of high surface temperatures and should stay away to
avoid burns or clothing ignition.
• Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least
annually by a qualified service person. More frequent cleaning may be r equired as necessary. It is imperative that control
compartment, burners and c irculating air passageways of the applia nce be kept clean.
• Young children should be carefully superv ised when they ar e in the area of the appliance.
• Instructions to the effect that this appliance shall be used only outdoors in a well-ventilate d space and shall not be used in a
building, garage or any other enclosed area.
FOR PROPANE GAS UNITS
• The gas pressure regulator provide with the propane fire bowl must be used.
• Do not attempt to disconnect the gas regulator or any gas fitting while your firebowl is in operation.
• A dented or rusty propane cylinder may be hazardous and should be checked by your gas supplier prior to use.
• Do not use a propane cylinder with a damaged valve and any other worn out parts.
• Transit and store the empty gas cylinders carefully and properly.
* If you see, smell or hear the hiss of escaping gas from the propane cylinder:
1. Turn off the gas supply and get away from the gas cylinder and the firebowl at once.
2. Do not attempt to correct the problem yourself.
3. Get to your gas supplier and/or the fire department for help.
• Clothing or other flammable materials should not be hung from the appliance, or placed on or near the appliance.
•How to disconnect a gas bottle
Turn OFF control knob and L P cylinder valv e. Turn coupling nut counterclockwise by hand only - do not use tools to
disconnect .Loosen cylinder screw benea th bottom shelf, then lift LP cylinder up and out of shelf. Place dust cap on cylinder
valve outlet whenever the cylinder is not in use.
• Any guard or other protective device removed for servicing the appliance must be replaced prior to operating the appliance.
• Specific size and capacity of the cylinder to use used.
Immediately call a qualified service te chnician to inspect the appliance and to re place any part of the control system and a ny gas
control which has been under water.”
• A statement that the LP-gas supply cylinder to be used must be constructed and marked in acc ordance with the specifications f or
LP-gas cylinders of the U.S. Department of Transportation ( DOT).
Only cylinder marked “propane” shall be used.
4
PART DESCRIPTION QTY
A Table 1
B Knob 1
C Leg support 1
D Leg 4
E Lava rock 2 boxes
F Cylinder holder 1
G Rain cover 1
Accessories
WARNING !
* Do not light or use gas unit if lava rockss are wet. Ensure lava rockss are completely dry before igniting as intense heat
could cause the rock to crack.
* lava rockss could hit somebody's face or eyes during initial start of this unit , so please keep away from the firebowl for
the first 20 minutes after it has been ignited.
5
ASSEMBLY INSTRUCTIONS
* Please keep these owner's manual for future reference.
* Before beginning assembly of product, make sure all parts are present. Compare parts with
package contents list. If any part is missing or damaged, do not attempt to assemble the product.
Estimated Assembly Time: 20 minutes
Tools Required for Assembly (included): Screwdriver (DD)
NOTE: You must follow all steps to properly assemble the firepit. Make sure the gas valve is turned
“OFF” before assembling. Do NOT attempt to assemble without proper tools.
1. Insert legs (D) into holes on the corner of
the leg support (C).
Turn around the leg to match with the mounting hole,
tighten by flat washers (BB), spring washers (AA) and
M6 x 12 mm screws (CC)
HARDWARE CONTENTS
6
3. Attach the knob (B) to the valve stem on
the table (A).
2. Attach the assembled legs (D) to the table (A)
with flat washers (BB), spring washers (AA) and
M6 x 12 mm screws (CC)
4. Place lava rocks (E) into table (A).
7
1. Control knob must be in the “OFF” position.
2. Connect propane cylinder (See Manual), open cylinder valve.
3. Push in knob in fully and rotate about 1/4 turn “counter clockwise” until a click is heard.
4. If ignition does not occur, repeat step 3 in rapid succession for no more than 5 seconds or until burner ignites.
If ignition still does not occur, immediately turn the burner control off, wait 5 minutes for the gas to clear and repeat
lighting procedure.
5. After ignition, continue to push and hold the control knob for 45 seconds to heat the thermocouple. Burner flame will
remain lit. If not, repeat lighting procedure.
6. Adjust flame to desired flame with the control knob.
TO LIGHT
Cover must be removed when burner is in operation.
Firebowl and propane gas cylinder minimum distance
must be over 60'' (as per the right side photo)
5. This item requires a 20 lb. propane
tank (not included) in order to operate
correctly. To install the tank to the body
(B), first turn the cylinder valve on the
tank clockwise to close the gas supply
on the gas cylinder. Then, screw the
regulator coupling from inside the
body (B) onto the valve clockwise by
hand only. Make sure it is fastened.
Perform leak test in a well-ventilated area outsid e and where no sour ce of spark can occur. DO NOT
cover firepit dir e ctly after flame is out. Wait 5 minutes for firepit to cool prior to pla c ing lid on firepit.
Connect tank cylinder to regulator. Turn the on/off valve at the unit to the ‘OFF’ position to pressurize
the control system. Use a soapy water solution to check all the connection leaks before attempting to
light the appliance.
If a leak is found or you smell gas, disconnect cylinder and turn valve off and do
not use the appliance until repairs can be made.
OPERATING INSTRUCTIONS
8
ROUTINE CARE
STUBBORN STAINS
PLEASE CALL BOND TOLL FREE #
1-866-771-BOND(2663) OR TO BETTER
※Store the firebowl in a cool dry place away from direct sunlight.
※
The propane cylinder must be disconnected and removed from the firebowl before the appliance can be stored indoors.
※Use Manufacturer approved or supplied replacement parts and accessories only. Otherwise may void the warranty of
this product and result in a hazardous condition.
※Please contact the Manufacturer for information regarding replacement hoses, ignitors, lava rockss, etc.
※Stubborn stains, discoloration and possibly rust pitting can occur from exposure to harsh outdoor conditions.
※Be careful not let any powder or solvent come in contact with painted or plastic components as damage may occur.
Observe flame height when lit:
Flame should possibly be a yellow/blue color between
2 to 10 inches high.
TO EXTINGUISH
MAINTENANCE
1. Turn and push the control knob clockwise to the OFF position.
2. Close cylinder valve, disconnect propane cylinder.
CAUTION: Disconnect Propane cylinder when this appliance is not use.
※ Keep your firebowl free and clear from combustible materials.
※ Visually inspect burner from obstructions, keep firebowl free and clear from debris.
※ After the burner and lava rockss are completely cooled down, use a soft brush to get rid of the mild stains, loose dirt
and soil. Wipe with a soft cloth.
BOND MANUFACTURING CO.
1700 West 4th Street Antioch, CA 94509 USA
customerservice@bondmfg.com
OR LOG IN TO OUR WEBSITE UNDER CUSTOMER SERVICE SUPPORT
www.bondmfg.com
IF YOU HAVE QUESTIONS OR CONCERNS
EXPEDITE YOUR REQUEST FEEL FREE TO EMAIL US
Loading...