BlueStar RGTNB606FTV2 Maintance Manual
USE & CARE MANUAL
Rangetops
RNB
Heritage Classic
Platinum™
1
BlueStar® Rangetop Use & Care Manual
MODELS RNB, Heritage Classic, Platinum™
THIS APPLIANCE WAS DESIGNED FOR EASE OF INSTALLATION AND OPERATION. HOWEVER, WE RECOMMEND
THAT YOU READ ALL SECTIONS OF THIS MANUAL BEFORE YOU BEGIN INSTALLATION. INSTALLATION MUST BE
PERFORMED BY AN APPROVED GAS INSTALLER OR GAS SERVICE TECHNICIAN OR THE WARRANTY IS VOID. IN
THE COMMONWEALTH OF MASSACHUSETTS A LICENSED PLUMBER OR GAS FITTER CAPABLE OF
REVIEWING AND PERFORMING THE MANUFACTURER’S INSTALLATION CHECKLIST SHOULD INSTALL THIS
APPLIANCE. THE INSTALLATION CHECKLIST IS INCLUDED AT THE REAR OF THIS BOOKLET.
DO NOT REMOVE PERMANENTLY AFFIXED LABELS, WARNINGS OR DATA PLATES FROM YOUR APPLIANCE. THIS
MAY VOID THE MANUFACTURER’S WARRANTY AND/OR HINDER EFFECTIVE SERVICING AND MAINTENANCE.
THESE INSTRUCTIONS ARE TO REMAIN WITH THE APPLIANCE AND THE CONSUMER IS TO RETAIN THEM FOR
FUTURE REFERENCE.
WARNING: If the information in this manual is not followed
exactly, a fire or explosion may result causing property damage,
personal injury or death.
- Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
- WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance
Do not touch or activate any electrical switch
Do not use any phone in your building
Immediately call your gas supplier from a neighbor’s phone.
Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the fire department
- Installation and service must be performed by a qualified
installer, service agency or the gas supplier.
NOTE: WARRANTY SERVICE MUST BE PERFORMED BY AN AUTHORIZED SERVICE AGENT. YOU MAY
REQUEST WARRANTY SERVICE BY CALLING 800-449-8691. YOU MAY ALSO REQUEST SERVICE VIA THE
INTERNET BY SUBMITTING THE SERVICE REQUEST FORM AT WWW.BLUESTARCOOKING.COM
In the Commonwealth of Massachusetts, gas connections must be performed by a licensed plumber or licensed gas
fitter.
Proposition 65 Warning
WARNING AND IMPORTANT SAFETY NOTICE RELATING TO CARBON MONOXIDE: The California Safe
Drinking Water and Toxic Enforcement Act requires the Governor of California to publish a list of substances known to
the state to cause cancer, birth defects or other reproductive harm, and requires businesses to warn customers of potential
exposure to such substances. Carbon Monoxide is one such substance known to the state to cause birth defects or other
reproductive harm. Operation of this product could expose you to carbon monoxide if the air shutter are not adjusted
properly. Directions on how to adjust the air shutters properly can be found in more detail in the MAINTENANCE
section of the Use & Care Manual.
© Copyright 2014 Prizer –Painter Stove Works, Inc. All specifications are subject to change without prior notification
2
THANK YOU & WELCOME
Thank you for your purchase and welcome to the BlueStar® Family!
BlueStar® rangetops are designed for discerning home chefs who demand restaurant-quality
results in their own kitchens. As the owner of a new BlueStar® rangetop you can look forward
to years of culinary excellence. You will prepare meals with the speed and accuracy of a
professional chef right in your own kitchen. All equipment is designed and manufactured to the
highest quality standards in the industry specifically to meet the needs of the world’s most
demanding chef: you. From simmering to sautéing, these versatile rangetops provide the
flexibility you need in any cooking application. Please review and familiarize yourself with this
Use & Care Guide which includes operating and cleaning instructions as well as tips for getting
the most out of your rangetop.
Since 1880, we have been handcrafting the highest quality ranges at our Reading, Pennsylvania
factory. If your rangetop ever needs attention, please be sure to use a BlueStar® certified
service provider recommended by our sales service team.
We hope you enjoy your new rangetop,
The BlueStar® Team
3
SERVICE INFORMATION
Date of Purchase
Model Number
Serial Number
Dealer Name
Dealer Phone
Dealer Address
Date of Installation
Installer Name
Installer Phone
Installer Address
Our service team can be reached at 1-800-449-8691 or serviceteam@bluestarcooking.com. Please take a few moments
now to fill in the Service Information above for your future reference. In the event you require parts or service, this
information will be needed to ensure you receive the highest quality service we can provide.
Your installer should complete the Performance Checklist, found in the Installation Manual or in the back of this manual,
before leaving your residence. Mail the completed checklist to: Warranty Department Prizer-Painter Stove Works Inc. 600
Arlington Street Reading, PA 19611 or Fax (610) 376-2596.
NOTE: ALL RANGETOPS SHOULD BE INSPECTED UPON ARRIVAL. PER THE WARRANTY ANY
COSMETIC ISSUES MUST BE REPORTED TO YOUR DEALER WITHIN 7 DAYS OF DELIVERY. THE
PERFROMANCE CHECKLIST (PAGE 30) MUST BE COMPLETED BY THE CERTIFIED INSTALLER
WITHIN 15 DAYS OF INSTALLATION AND SEND IN.
WARRANTY SERVICE MUST BE PERFORMED BY AN AUTHORIZED SERVICE AGENT. YOU MAY
REQUEST WARRANTY SERVICE BY CALLING 800-449-8691. YOU MAY ALSO REQUEST SERVICE VIA
THE INTERNET BY SUBMITTING THE SERVICE REQUEST FORM AT
WWW.BLUESTARCOOKING.COM
In the Commonwealth of Massachusetts, gas connections must be performed by a
licensed plumber or licensed gas fitter.
4
IMPORTANT SAFETY INSTRUCTIONS
If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or
death.
Do not store gasoline, aerosol cans, sealed containers or any flammable vapors and liquids in the vicinity of this or any other
appliance.
If You Smell Gas
Do not try to light any appliance.
Do not touch or activate any electrical switch.
Do not use any phone in your building.
Immediately call your gas supplier from outside your home. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the fire department.
Installation must be performed by an approved gas installer or gas service technician or the warranty is void. In the Commonwealth of
Massachusetts a licensed plumber or gas fitter capable of reviewing and performing the manufacturer’s installation should ins tall this
appliance.
WARNING
SAVE THESE INSTRUCTIONS
Read all instructions before using your appliance. Follow these important safety precautions to reduce the risk of fire, electric shock,
personal injury or property damage.
Do not remove permanent labels, warnings or data plates or the serial number from your appliance. Removal may void the
manufacturer’s warranty and/or hinder effective servicing and maintenance.
5
GENERAL SAFETY INSTRUCTIONS
Your appliance should be installed by a qualified gas installation technician. Have the technician show you the exact
location of the gas shutoff valve on the incoming gas line so you know how to turn off the gas if necessary.
Never use this appliance as a space heater to warm a room. Doing so may result in carbon monoxide poisoning.
Do not touch the hot surfaces of the rangetop including the burners, burner grates, cooktop, and backguard.
Before any maintenance or repairs are performed, disconnect the appliance from the electric supply.
In the event of a power failure, do not attempt to operate the appliance or light any of the burners. This is a gas fired
appliance that uses electrical components such as the ignition and safety devices.
Do not attempt to repair or replace any part of this appliance unless specifically instructed to do so in this manual. In-
warranty service must be performed by an authorized service agency.
Only use this appliance for the intended purposes described in this user manual.
This appliance should be operated with a properly sized and operational ventilation hood.
The ventilation and flue ways of this appliance must remain unobstructed at all times.
Additional care should be exercised if your appliance is equipped with a high-shelf. During heavy or continued use this
shelf may become hot. Do not place combustible materials or plastics on this shelf.
Do not sit, stand, or climb on any part of the appliance including the cooktop. Serious injury may occur.
Do not store items of interest to children above the appliance.
Never leave the appliance unattended during use. Boil-overs may occur, causing spills which may ignite.
WARNING
KEEP FLAMMABLE MATERIALS AWAY FROM THE RANGETOP
Do not store flammable materials on, in or near the appliance. Keep the appliance area clean and free of combustible
materials, gasoline and other flammable vapors and liquids, aerosol and sealed containers like baby food jars. Check
before each use to make sure that no hazardous materials are in the area.
Never wear loose fitting clothing or garments with loose sleeves or strings while using this appliance.
Use care when reaching over the rangetop.
Do not let cooking grease accumulate in or near the rangetop, since it may ignite.
Clean the grease drip trays and ventilation hood filters frequently to prevent grease build-up.
WARNING
IN THE EVENT OF FIRE, TAKE THE FOLLOWING STEPS TO PREVENT INJURY AND FIRE SPREADING
Do not use water on grease fires. Never pick up a flaming pan. Turn off the controls and smother the flaming pan with a
fitted lid, cooking sheet or large flat tray.
It is recommended you purchase a multi-purpose dry chemical or foam-type fire extinguisher for your home. Store it in
close proximity to your appliance.
WARNING
SAVE THESE INSTRUCTIONS
IMPORTANT SAFETY INFORMATION
SAVE THESE INSTRUCTIONS
6
COOKTOP SAFETY INSTRUCTIONS
The push-in and turn control knobs on this appliance are designed to be child-safe, however are not a guarantee of safe
operation.
Do not leave children alone or unattended in the kitchen while the appliance is in use.
When flaming liquor or other spirits, and if your appliance is installed under a ventilation hood, TURN THE FAN OFF. The
draft created could cause the flames to spread.
Turn pot and pan handles inward so they do not extend over adjacent burners or the front of the rangetop to reduce the risk of
burns, igniting flammable materials, and spillage.
After use do not touch the rangetop surface until completely cooled.
Never leave the surface burners unattended at medium or high heat settings. Foods, especially oily foods, may ignite
resulting in fire that could spread to surrounding cabinets.
Never leave oil unattended while frying. If allowed to heat beyond its smoking point, oil may ignite resulting in fire that may
spread to surrounding cabinets. Use a deep fry thermometer whenever possible to monitor oil temperature and operate with
safe limits.
To avoid oil spillover and fire, use a minimum amount of oil when shallow pan-frying and avoid cooking frozen foods with
excessive amounts of ice.
Use proper pan size and avoid pans that are unstable or easily tipped. Select cookware that is matched to the size of the
burner. Burner flames should be adjusted so that they do not extend beyond the bottom of the pan. Excessive flames may be
hazardous.
When using glass/ceramic cookware, make sure it is suitable for cooktop service. Some materials may break because of
sudden change in temperature.
Do not use cookie sheets or aluminum foil to cover the grates or line any part of the cooktop. Doing so may result in carbon
monoxide build-up and poisoning, over heating the cooktop surfaces, or a potential fire hazard.
WARNING
IMPORTANT SAFETY INFORMATION
SAVE THESE INSTRUCTIONS
WARNING AND IMPORTANT SAFETY NOTICE RELATING TO CARBON MONOXIDE: The California Safe
Drinking Water and Toxic Enforcement Act requires the Governor of California to publish a list of substances known to
the state to cause cancer, birth defects or other reproductive harm, and requires businesses to warn customers of potential
exposure to such substances. Carbon Monoxide is one such substance known to the state to cause birth defects or other
reproductive harm. Operation of this product could expose you to carbon monoxide if the air shutter are not adjusted
properly. Directions on how to adjust the air shutters properly can be found in more detail in the MAINTENANCE
section of the Use & Care Manual.
Proposition 65 Warning
7
GETTING STARTED
ATTENTION
ATTENTION
We know you are excited to start cooking with your new BlueStar® rangetop. Before you begin, it is essential that you follow these
steps for safe and optimal use.
Become familiar with all the parts of your rangetop.
Remove and properly discard all temporary labels and packaging material from the cooktop, burners, and burner grates. Remove
all: cardboard, zip ties, paper and plastic sheathing used as packaging.
Do not remove zip ties beneath the burners. These are needed to hold the igniter wires in place.
Wash all removable parts including ring grates, and top grates in hot, soapy water. Rinse well and dry thoroughly. See the Care
and Cleaning section.
Register your appliance by mailing the Performance Checklist, completed by your installer, to the address below. The
Performance Checklist can be found in the Installation Manual or in the back of this manual.
Warranty Department
Prizer-Painter Stove Works Inc.
600 Arlington Street
Reading, PA 19611
Season your griddle or French Top before first use
8
COOKTOP
ATTENTION
BURNERS
BEFORE YOU BEGIN
Each of your burners has a specific BTU (British Thermal Unit) rating. Before disassembly, note the location of
each burner. If a burner is replaced in the wrong position it may not function correctly.
Become familiar with the location of your burners. Below are the standard burner configurations.
RNB Models – 24”, 30”, 36”, 48”, 60”
Platinum™ Series Models – 24”, 30”, 36”, 48”, 60”
9
Loading...