Blue Rhino GAD860SP User Manual

OWNER’S MANUAL

Made from 70% Bagasse

(Environmentally Friendly Sugar

Cane Pulp By-product)

LP Gas Outdoor Fireplace

Model No. GAD860SP

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only (outside any enclosure) Do Not Use For Cooking.

WARNING

FOR YOUR SAFETY:

If the information in this manual is not followed

exactly, a fire or explosion may result causing property damage, personal injury or loss of life.

Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

• Do not try lighting any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call your gas supplier from a neighbor’s phone.

• Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a

qualified installer, service agency or gas supplier.

Improper installation, adjustment, alteration,

service or maintenance can cause injury or property damage.

Read the installation, operation, and maintenance

instructions thoroughly before installing or servicing this equipment.

Save these instructions for future reference.

If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.

Table of Contents

Dangers and Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2

Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Installing LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Insert LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Secure LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Connect LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Disconnect LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Turning Off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Inspecting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Storing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

The use and installation of this product must conform to local codes. In absence of local codes, use the latest edition of the National Fuel Gas Code, ANSI Z223.1/NFPA 54, CAN/CGA-B149.1,

Natural Gas and Propane Installation Code.

For installation in Canada - these instructions, while generally acceptable do not necessarily comply with the Canadian installation codes, particularly with piping above and below ground. In Canada the installation of this appliance must comply with local codes and/or standard CAN/CGA B149.1 (installation code for propane burning appliances and equipment).

California Proposition 65: Chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.

Manufactured in China for: Blue Rhino Global Sourcing, Inc Winston-Salem, NC 27105 USA

1.800.762.1142, www.bluerhino.com

LP Gas Outdoor Fireplace Model No. GAD860SP

DANGERS and WARNINGS: FOR YOUR SAFETY

DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

WARNING:

This appliance is for outdoor use only, and shall NOT be used in a building, garage, or

any other enclosed area.

Do NOT operate, light or use this appliance within 8 feet of walls, structures or

buildings.

Do NOT use this outdoor fireplace for indoor heating. TOXIC carbon monoxide fumes

can accumulate and cause asphyxiation.

This outdoor fireplace is NOT for commercial use.

This outdoor fireplace is for use with liquid propane (LP) gas only. The conversion to or

attempted use of natural gas in this outdoor fireplace is dangerous and will void your warranty.

LP gas Characteristics:

a. LP gas is flammable and hazardous if handled improperly. Become aware of the

characteristics before using any LP gas product.

b. LP gas is explosive under pressure, heavier than air, and settles and pools in low

areas.

c. LP gas in its natural state has no odor. For your safety, an odorant is added that

smells like rotten cabbage.

d. Contact with LP gas can cause freeze burns to skin.

LP gas tank needed to operate. Only tanks marked “propane” may be used.

a. The LP gas supply tank must be constructed and marked in accordance with the

Specifications for LP gas LP gas tanks of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, LP gas tanks, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.

b. LP gas tank must be arranged for vapor withdrawal.

c. The LP gas tank must have a listed overfilling prevention device (OPD) and a QCCI or

Type I (CGA810) LP gas tank connection.

d. The LP gas tank must have a tank collar to protect the tank valve.

e. Never use an LP gas tank with a damaged body, valve, collar, or footing.

f. Dented or rusted LP gas tanks may be hazardous and should be checked by your LP

gas supplier prior to use.

g. The LP gas tank should not be dropped or handled roughly.

h. Tanks must be stored outdoors out of the reach of children and must not be stored

in a building, garage, or any other enclosed area. Your LP gas tank must never be stored where temperatures can reach over 125°F.

i. Never keep a filled LP gas tank in a hot car or car trunk. Heat will cause the gas

pressure to increase, which may open the relief valve and allow gas to escape.

j. Place dust cap on valve outlet whenever the LP gas tank is not in use. Only install the

type of dust cap on the LP gas tank valve outlet that is provided with the LP gas tank valve. Other types of caps or plugs may result in leakage of propane.

k. Do not store a spare LP gas tank under or near this appliance.

l. Never fill the tank beyond 80 percent full.

Your outdoor fireplace has been checked at all factory connections for leaks. Recheck

all connections, as movement in shipping can loosen connections.

Check for leaks even if your unit was assembled for you by someone else.

Do not operate if gas leak is present. Gas leaks may cause a fire or explosion.

You must follow all leak-checking procedures before operating. To prevent fire or

explosion hazard when testing for a leak:

a. Always perform leak test before lighting the outdoor fireplace and each time the

tank is connected for use.

b. No smoking. Do not use or permit sources of ignition in the area while conducting a

leak test.

c. Conduct the leak test outdoors in a well-ventilated area.

d. Do not use matches, lighters, or a flame to check for leaks.

e. Do not use outdoor fireplace until any and all leaks are corrected.

If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.

Do not store or use gasoline or other flammable liquids or vapors within 25 feet

(7.62 m) of this appliance.

Do not use in an explosive atmosphere. Keep outdoor fireplace area clear and free

from combustible materials, gasoline and other flammable vapors and liquids.

This outdoor fireplace is NOT to be operated by children.

This outdoor fireplace is NOT to be used in or on boats or recreational vehicles.

Always use in accordance with all applicable local, state and national codes. Contact

your local fire department for details on outdoor burning.

When using this outdoor fireplace, exercise the same precautions you would with any

open fire.

The use of alcohol, prescription or non-prescription drugs may impair the consumer’s

ability to properly assemble or safely operate this outdoor fireplace.

Do NOT use this outdoor fireplace without reading the entire “Owner’s Manual”.

Do NOT burn solid fuels such as: wood, charcoal briquets, lump charcoal,

manufactured logs, driftwood, trash, leaves, paper, cardboard, plywood, painted or stained or pressure treated wood in this outdoor fireplace.

It is essential to keep the outdoor fireplace’s valve compartment, burners, and

circulating air passages clean. Inspect outdoor fireplace before each use.

Do NOT alter this outdoor fireplace in any manner.

Do NOT use this outdoor fireplace until it is COMPLETELY assembled and all parts are

securely fastened and tightened.

Do NOT store another LP gas tank within 10 feet (3.05 m) of this outdoor fireplace

while it is in operation.

Do NOT use this outdoor fireplace near automobiles, trucks, vans or recreational

vehicles.

Do NOT use this outdoor fireplace under any overhead or near any unprotected

combustible constructions. Avoid using near or under overhanging trees and shrubs.

Always use this outdoor fireplace on a hard, level non-combustible surface such a

concrete, rock or stone. An asphalt or blacktop surface may not be acceptable for this purpose.

Do NOT use this outdoor fireplace for cooking.

Do NOT use this outdoor fireplace if any part has been under water. Immediately call a

qualified service technician to inspect the appliance and to replace any part or control system and any gas control which has been under water.

Do NOT wear flammable or loose clothing when operating this outdoor fireplace.

Do NOT use in windy conditions.

Do NOT use this outdoor fireplace unless burner and log set are securely in place.

Keep all electrical cords away from a hot outdoor fireplace.

Certain areas of this outdoor fireplace when in use will become too hot to touch. To

avoid burns, do not touch hot surfaces until the unit has cooled unless you are wearing protective gear (insulated pot holder or heat resistant gloves or mittens).

Do NOT leave a lit outdoor fireplace unattended, especially around children and pets.

Children and adults should be alerted to the hazards of high surface temperatures and

should stay away to avoid burns or clothing ignition.

Young children should be carefully supervised when they are in the area of the

appliance.

Clothing or other clammable materials should not be hung from the appliance or

placed on or near the appliance.

Any guard or other protective device removed for servicing the appliance must be

replaced prior to operating the appliance.

Do NOT attempt to move or store this outdoor fireplace until all parts are cool.

Do NOT lean over this outdoor fireplace when lighting or when in use.

This outdoor fireplace should be thoroughly inspected and cleaned on a regular basis.

This outdoor fireplace should be thoroughly cleaned and inspected on a regular basis.

Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into operation.

Use only the regulator and hose assembly provided. The replacement regulator and

hose assembly shall be that specified by the manufacturer.

Use only Blue Rhino Global Sourcing, Inc factory authorized parts. The use of any part

that is NOT factory authorized can be dangerous and will void your warranty.

Storage of this outdoor fireplace indoors is permissible only if the tank is

disconnected, removed from the outdoor fireplace and properly stored outdoors.

Do not attempt to disconnect the gas regulator from the tank or any gas fitting while

the outdoor fireplace is in use.

If the outdoor fireplace is not in use, the gas must be turned off at the supply tank.

The pressure regulator is set for 10.5 inches of water column (pressure).

The maximum inlet gas pressure for this outdoor fireplace is 11 inches of water

column pressure.

Do NOT sit on the mantle when the unit is in operation.

Do not throw anything onto the fire when the unit is in operation.

Fire logs and lava rock are very hot, please keep the children or pets away at a safe

distance.

The opening of the tank collar should face toward the door side for easy access.

Do NOT store any combustible materials in the base enclosure.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

page no.

Parts List

Cement Log (4)

55-05-432, 55-05-433, 55-05-434, 55-05-435

Lava Rock

55-05-443

Lava Rock Grid

55-05-444

Side Panel (6)

58-05-028

Bowl Assembly

55-05-430

Burner

55-05-431

Igniter

55-05-441

Control Knob

55-05-436

Regulator/Hose Assembly

55-05-452

Hearth

58-05-025

Back Leg (2)

55-05-694

Middle Support Leg (3)

55-05-702

Tank Guard

55-05-458

LP Gas Tank Retaining Chain

55-05-447

LP Gas Tank Tray Peg

55-05-449

Base Support Bar

55-05-429

Left Front Leg

55-05-700

Left Door

58-05-026

Door Support Leg

55-05-698

Right Door

58-05-027

Right Front Leg

55-05-704

Door Knob (2)

55-05-697

Base

55-05-428

LP Gas Tank Tray

55-05-448

LP Gas Tank Shield

55-05-458

Foot (4)

55-05-692

Cover (not shown)

55-05-693

Exploded View

Hardware

A B C D E

Screw

Wing Nut

AA Battery

M5x10 Black Nickel Plated Truss Head

M5x10 Black Nickel Plated Hex

ø4x16 Black Nickel Plated Truss Head

ø5 Black Nickel Plated

1.5 V AA Battery

68 pcs

9 pcs

2 pcs

3 pcs

1 pc

Tools Required for Assembly (Included)

M5 Allen Wrench

Tools Required for Assembly (Not Included)

#2 Phillips Head Screwdriver

Assembly Instructions

LP Gas Outdoor Fireplace Model No. GAD860SP

DO NOT RETURN PRODUCT TO STORE.

For assistance call 1.800.762.1142 toll free. Please have your owner’s manual and serial number available for reference.

For Easiest Assembly:

• To avoid losing any small components or hardware, assemble your product on a hard level surface that does not have cracks or openings.

• Clear an area large enough to layout all components and hardware.

• When applicable, tighten all hardware connections by hand first. Once the step is completed go back and fully tighten all hardware.

• Follow all steps in order to properly assemble your product.

To complete assembly you will need:

• (1) Leak Detection Solution (Instructions on how to make solution are included in step Operations Section)

• (1) Precision Filled LP Gas Grill Tank with Acme Type 1 external threaded valve connection (4-5 gallon size)

Note: You must follow all steps to properly assemble heater.

Attach Bowl Assembly

Typical assembly: approximately 1 (one) hour.

Attach LP Gas Tank Shield

Attach Side Panels, Back Legs and Middle Support Leg

x 4

x 12

x 3

+ 8 hidden pages