Blue Rhino CBT672B User Manual
OWNER’S MANUAL
Outdoor Charcoal Barbecue Grill
Model No. CBT672B
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury, or death.
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2
Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Initial Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Cooking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Tips. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Save these instructions for future reference.
If you are assembling this unit for someone else,
give this manual to him or her to read and save
for future reference.
Manufactured in China for:
Blue Rhino Global Sourcing, LLC
Winston-Salem, NC USA
1.800.762.1142, www.bluerhino.com
© 2006 Blue Rhino Global Sourcing, LLC. All Rights Reserved
BBQ grillware™ is a registered trademark of LF, LLC. All Rights Reserved CBT672B-OM-105 ES
Outdoor Charcoal Barbecue Grill Model No. CBT672B
WARNING
FOR YOUR SAFETY
1. This grill is for outdoor use only, and shall not be used in a building,
garage, or any other enclosed area.
2. Do NOT operate, light or use this appliance within 8 feet of walls,
structures or buildings.
3. This grill is NOT for commercial use.
4. This is not a tabletop grill. Therefore, do not place this grill on any
type of tabletop surface
5. Do not use grill for indoor cooking or heating. Toxic carbon monoxide
fumes can accumulate and cause asphyxiation.
6. Do not use gasoline, kerosene, or alcohol for lighting.
7. Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
8. Do not store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62 m) of this appliance.
9. Instant light charcoal can burn at very high temperatures during
initial startup. Make sure lid is open until charcoal turns to hot coals.
10. Keep all combustible items and surfaces at least 21 inches (53 cm)
away from the grill at all times. DO NOT use this grill or any gas
product under any overhead or near any unprotected combustible
constructions.
11. Do not alter grill in any manner.
12. Do not use the grill unless it is completely assembled and all parts
are securely fastened and tightened.
13. This grill should be thoroughly cleaned and inspected on a regular
basis.
14. Use only Blue Rhino Global Sourcing, LLC. factory authorized parts.
The use of any part that is not factory authorized can be dangerous.
This will also void your warranty.
15. Do not use this appliance without reading “Operating Instructions” in
this manual.
16. Do not touch metal parts of grill until it has completely cooled (about
45 min.) to avoid burns, unless you are wearing protective gear (pot
holders, gloves, BBQ mittens, etc.).
17. Never touch grates (charcoal or cooking), ashes or coals to see if
they are hot.
19. Do not use in or on boats or recreational vehicles.
20. Position grill so wind can not carry ashes to combustible surfaces.
21. Do not use in high winds.
22. Never lean over the grill when lighting.
23. Do not leave a lit grill unattended, especially keep children and pets
away from grill at all times.
24. Do not attempt to move grill when in use. Allow the grill to cool
before moving or storing.
25. Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
26. Always place your grill on a hard, non combustible level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
27. Do not remove the ashes until they are completely and fully
extinguished.
28. Live hot briquettes and coals can create a fire hazard.
29. Always empty the ash catcher and grill after each use. Do not
remove the ashes until they are completely and fully extinguished.
30. Do not place fuel (charcoal briquets, wood or lump charcoal) directly
into bottom of grill. Place fuel only on the charcoal pan/grid.
31. Check to make sure the air vents are free of debris and ash before
and while you are using the grill.
32. Make sure ash catcher is securely and completely in place before
using the grill.
33. Always wear protective gloves when adding fuel to retain desired
heat level.
34. Keep all electrical cords away from a hot grill.
35 Always use a meat thermometer to ensure food is cooked to a safe
temperature.
36. Never cover entire cooking area with aluminum foil.
37. Please use protective gloves when assembling this product.
38. Do not force parts together as this can result in personal injury or
damage to the product.
39. Deaths, serious injury or damage to property may occur if the above
is not followed exactly.
18. Do not use on wooden decks, wooden furniture or other combustible
surfaces.
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
page no.
3
Parts List
1
Handle
2
Branding Plate
3
Vent Knob
4
Lid
5
Air Vent
6
Warming Rack
7
Cooking Grid
8
Charcoal Grid
9
Top Hinge (2)
10
Bottom Hinge (2)
11
Bottom Bowl
12
Leg (2)
13
Ash Receiver Assembly
Exploded View
2
1
3
4
6
5
7
14
Latch (2)
9
8
10
11
12
13
12
Hardware
A
B
C
D
E
Screw
Screw
Wing Nut
Wing Nut
Washer
M4x10 Zinc Plated Phillips Truss Head
M5x12 Zinc Plated Phillips Truss Head
M4 Steel
M5 Steel
ø4 Zinc Plated
14
4 pcs
13 pcs
4 pcs
18 pcs
4 pcs
Tools Required for Assembly (Included)
#2 Phillips Head Screwdriver
F
G
H
J
K
I
Washer
Washer
Lock Washer
Lock Washer
Pin
Cotter Pin
ø5 Zinc Plated
ø6 Heat Resistant
ø4 Zinc Plated
ø5 Zinc Plated
ø6 x 100 Black Coated
ø1.4 x 30 Zinck Plated
17 pcs
16 pcs
4 pcs
18 pcs
2 pcs
2 pcs
Assembly Instructions
Outdoor Charcoal Barbecue Grill Model No. CBT672B
DO NOT RETURN PRODUCT TO STORE.
For assistance call 1.800.762.1142 toll free. Please have your owner’s manual and serial
number available for reference.
Attach Air Vent and Vent Knob
1
For Easiest Assembly:
• To avoid losing any small components or hardware, assemble your product on a hard level
surface that does not have cracks or openings.
Attach Branding Plate
2
5
B
D
Attach Bottom Hinges
x 1
x 2
F
x 2
x 2
G
x 2
I
x 2
D
x 1
F
I
x 2
Attach Latches
6
B
D
x 4
x 4
F
G
I
x 4
x 4
x 4
A
C
x 4
E
x 4
H
x 4
x 4
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
page no.
5
• Clear an area large enough to layout all components and hardware.
• When applicable, tighten all hardware connections by hand first. Once the step is completed,
go back and fully tighten all hardware.
Attach Handle
3
• Follow all steps in order to properly assemble your product.
Estimated assembly time: 20 to 30 minutes
Attach Top Hinges
4
7
D
F
Attach Legs
x 2
x 2
G
B
D
x 2
I
x 2
Attach Lid
x 2
x 2
F
G
x 2
x 2
I
x 2
8
B
D
x 6
x 6
F
G
I
x 6
x 6
x 6
J
x 2
K
x 2
Loading...