Blueair BBB23-1S-HC, BBB69-3B-HC, BBB59-2B-HC, BBB59-2S-HC, BBB90-4B-HC Installation & Operation Manual

Installation & Operation Manual

Back bar & Direct Darw Beer Dispenser (R290)

Please read this manual completely before installing or operating this unit!

Blueair FSE reserves the right to make product modification at any time.

Specifications and Designs are subject to change without notice.

IMPORTANT SAFETY INSTRUCTION (SAVE THESE INSTRUCTIONS)

Visit our website at

www.blueairfse.com

BBB23-1B/1S-HC
BBB59-2B/2S-HC
BBB69-3B/3S-HC
BBB90-4B/4S-HC

BBB23-1BG/1SG-HC
BBB59-2BG/2SG-HC
BBB69-3BG/3SG-HC
BBB90-4BG/4SG-HC

BDD23-1B/1S-HC
BDD59-2B/2S-HC
BDD69-3B/3S-HC
BDD90-4B/4S-HC

2

________________

Service Contack

______________

Blueair FSE has a Nationwide Service Network

To provide timely service to our customer’s needs.

Please call or fax us at the following numbers.

Blueair FSE Nationwide Sevice Network

Toll Free, 1-866-677-8500

TEL, [phone]

FAX, [phone]

Visit our website at www.blueairfse.com

◆ Specifications _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 3

◆ Installation _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 5

◆ Maintenance & Cleaning _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ _ _ _ _ 6

◆ Operation & Caution “Important _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 6

◆ Air Hose & Tower Installation Schematic Diagram _ _ _ _ _ 7

◆ Beer Line & CO2Line Installation Schematic Diagram _ _ _ 8

◆ Troubleshooting _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 9

3

CAUTION – Risk of Fire or Explosion. Flammable Refrigerant Used. Consult instruction

manual/repair manual/owner’s guide before attempting to install or service this product.

Dispose of properly in accordance with federal or local regulations.

CAUTION – Risk of fire or explosion due to flammable refrigerant used. Follow handling

instructions carefully in compliance with U.S. and Canadian government.

Product Back bar Refrigeration

Model (Solid Door)

BBB23-1B

/1S-HC

BBB59-2B

/2S-HC

BBB69-3B

/3S-HC

BBB90-4B

/4S-HC

Model (Glass Door)

BBB23-1BG

/1SG-HC

BBB59-2GB

/2SG-HC

BBB69-3GB

/3SG-HC

FBB90-4GB

/4SG-HC

Capacity (cu.ft) 7.9 19.4 23.4 31.6

Exterior

Dimensions

(W) 23 3/8” 59” 69 1/8” 90 3/8”

(D) 31 1/8 ” 27 1/8 ”

(H)* 39 1/8” 37”

Doors 1 2 2 3

Shelves 2 4 4 6

Condensing Unit Size 1/4 HP 3/8 HP 3/8HP 3/8HP

Electrical Characteristics 115V/60Hz

NEMA Plug Configuration NEMA 5-15P

Amps 3.0 3.5 3.5 3.5

Range of Temperature +32˚Ｆ to +41˚Ｆ

Refrigerant R290

12oz. Can Capacity 386 1,084 1,299 1,786

Net Weight (lbs) - Solid 128 220 251 309

Net Weight (lbs) - Glass 132 236 262 331

◆ BDD23-1B/1S-HC exterior height is include 4" for castor height.

◆ Specifications and Designs are subject to change without notice.

◆ The name plate (including Serial No.) is located on the upper left side of the cabinet interior.

4

◆ BDD23-1B/1S-HC exterior height is include 4" for castor height.

◆ Specifications and Designs are subject to change without notice.

◆ The name plate (including Serial No.) is located on the upper left side of the cabinet interior.

CAUTION – Risk of Fire or Explosion. Flammable Refrigerant Used. Consult instruction

manual/repair manual/owner’s guide before attempting to install or service this product.

Dispose of properly in accordance with federal or local regulations.

CAUTION – Risk of fire or explosion due to flammable refrigerant used. Follow handling

instructions carefully in compliance with U.S. and Canadian government.

PRODUCT Direct Darw Beer Dispenser Refrigeration

Model (Solid Door)

BDD23-1B

/1S-HC

BDD59-2B

/2S-HC

BDD69-3B

/3S-HC

BDD90-4B

/4S-HC

Capacity (cu.ft) 7.9 19.4 23.4 31.6

Exterior

Dimensions

(W) 23 3/8” 59” 69 1/8” 90 3/8”

(D) 31 1/8 ” 27 1/8 ”

(H)* 39 1/8” 37”

Doors 1 2 2 3

Keg Capacity 1

2

(+ Slim 1)

3

4

(+ Slim 1)

Condensing Unit Size 1/4 HP 3/8 HP 3/8HP 3/8HP

Electrical Characteristics 115V/60Hz

NEMA Plug Configuration NEMA 5-15P

Amps 3.0 3.5 3.5 3.5

Range of Temperature +32˚Ｆ to +41˚Ｆ

Refrigerant R290

Net Weight (lbs) 126 216 240 298

5

DANGER – Risk of fire or explosion. Flammable refrigerant used. To be repaired only

by trained service personnel. Do not use mechanical devices to defrost refrigerator.
Do not puncture refrigerant tubing. Risk of Fire or Explosion due to puncture of

refrigerant tubing; Follow handling instructions carefully.

1. To maintain proper refrigeration performance, the condenser fins should be checked

monthly and clean with a soft brush or vacuum cleaner as needed.

2. Wait at least 6 minutes after unplugging the unit before plugging in.

3. The interior and exterior of the unit can be cleaned using plugging in water.

1) Do not use an abrasive cleaners to avoid scratches on the surfaces.

4. The door gasket should be cleaned to avoid maintain proper sealing.

1. INDOOR USE ONLY

1) This unit is intended for indoor use only.

2. FOR LOCATION

1) Be sure that the location is strong enough to support the total weights of unit and the
content.

2) Keep the unit away from sunlight and other heat generating equipment.

3) The minimum clearance between the back of the unit and wall should be 7 inches at least

3. INSTALLING CASTERS

1) Be sure that casters with brake should be installed in front.

4. LEVELING

1) The unit should be leveled to provide adequate drainage.

5. ELECTRICAL CONNECTION

1) The unit should be plugged into a 115V/60Hz, grouned wall receptacle to prevent

electrical shock and fire hazards.

2) Do not plug other electrical units into same wall receptacle this unit is plugged into.

3) Do not use an extension cord.

4) Compressor warranties are void if the compressor bums out due to low voltage.

6. INSTALLING SHELF

1) Install shelves using shelf-clips provided in accessory.

6

1. The temperature controller (thermostat) is located on the
upper left of the back side of the cabinet interior.

2. The controller has been preset “NORMAL” position at the

factory.

3. Set the control knob toward “COOL” for higher temperature

and “COLD” for lower temperature.

4. The thermostat controls compressor’s “ON/OFF” by sensing

inside temperatures of cabinet.

5. The unit is equipped with an off-cycle defrost.

※ Excessively opening the door will cause the breakdown.
※ Handle with care as shutting the door.

7

8

※ Assemble Beer Line & CO2Line as above drawing.

9

DANGER – Risk of fire or explosion. Flammable refrigerant used. To be repaired only

by trained service personnel. Do not use mechanical devices to defrost refrigerator.

Do not puncture refrigerant tubing. Risk of Fire or Explosion due to puncture of

refrigerant tubing; Follow handling instructions carefully.

※ The following is not an indication of problem or malfunction.

A water-flowing sound can be heard when the unit in operating.

This is the sound of refrigerant flowing.

Problem Possible Solutions

Compressor

Failure to Start

· Check the power cord and make sure it is plugged in.

· Check the temperature controller. If it is in the “OFF” position,

turn it clockwise to set a desired temperature.

Performance

Issue

· Move the unit from direct sunlight.

· Move the unit away from heat generating devices.

· Install the unit in a well ventilated area, with at least 7 Inches of

clearance on all sides.

· Clean the condenser if heavy dust is collected.

· Clear contents from blocking the air duct in the interior.

· Check the temperature controller for incorrect setting.

· Check the refrigerant level, it may need to be charged.

· Check the door and be sure it is completely closed.

Unusual Noise

· Check fan blades to see if they are contacting anything.

· Maintain 7 inches of clearance from the wall.

· Check for loose part or mounting.

· Keep the tubing free from any contact to avoid rattle.

Condensation on

Cabinet exterior

and/or floor

· Reduce humidity where the unit is installed.

· Repair or replace the gasket on the door.

· Check the drain line to make sure it is not disconnected inside the

cabinet and it drains into the drain pan in the compressor area.

10

11

※ The Warranty becomes void if the attached warranty card is not filled out and returned to Blueair within 12 days from the purchase date.

Cut along dotted line and mail it back to ; Blueair Customer Service Dept. 223 W. Rosecrans Ave, Gardena, CA 90248

※ The Warranty becomes void if the attached warranty card is not filled out

and returned to Blueair FSE within 12 days from the purchase date.

Cut along dotted line and mail it back to ;

Blueair FSE Customer Service Dept.

223 W. Rosecrans Ave, Gardena, CA 90248

Customer
Name:______________________________________________

Telephone :

( )__________________________________________

Address (Customer)

Street :

______________________________________________________

City:______________
___

Place of
Purchase:___________________________________________

Model

Name:_______________________________________________

__

Warranty Registration Card

TITAN REFRIGERATION.

7460 Warren Pkwy Suite 100 Frisco, TX 75034

Business

Name:_______________________________________________

Telephone :

( )__________________________________________

Address (Business or Installation Site)

Street:__________________________________________________________

State:________Zip:__________

__

City:______________
___

State:_______
_

Date
Installed:____________

Date Purchased:_________________

Product Serial

No.:______________________________________________

Extended Warranty Option

Additional 1 Year Parts & Labor extended Warranty available.

Please make check payable to TITAN and Return with this registration card

口 Yes, I would like the extended warranty. / 口 No, I would not like the extended warranty.

Signature of Business Owner:______________________________

Date:_____________________

Zip:________
__

Customer Name : _____________________________________

Telephone : ( ) ________________________________

Address (Customer)

Street : _____________________________________________

City : ______________ State : ________ Zip : __________

Place of Purchase : ____________________________________

Model Name:___________________________________________

Warranty Registration Card

Blueair FSE, LLC

223 W. Rosecrans Ave, Gardena, CA 90248

Toll Free, 1-866-677-8500

TEL, [phone], Fax, [phone]

Extended Warranty Option

Additional 1 Year Parts & Labor extended Warranty available.

Please make check payable to GIO Refrigeration and Return with this registration card

口 Yes, I would like the extended warranty. / 口 No, I would not like the extended warranty.

Signature of Business Owner:______________________________

Date:_____________________

Business Name : _________________________________________

Telephone : ( ) ___________________________________

Address (Business or Installation Site)

Street : ________________________________________________

City : ______________ State : __________ Zip : __________

Date Purchased : ___________ Date Installed : __________

Product Serial No. : _____________________________________

Blueair FSE, LLC

223 W. Rosecrans Ave. Gardena, CA 90248

Toll Free, 1-866-677-8500

TEL, [phone]

FAX, [phone]

Visit our website at www.blueairfse.com