Blue Air BACRF14 Installation Manual

Installation & Operation Manual

Ice Cream Freezers

Please read this manual completely before installing or operating this unit!

BACF11
BACF15

BACRF14

Blue Air reserves the right to make product modification at any time. Specifications and Designs are subject to change without notice.

IMPORTANT SAFETY INSTRUCTION ( SAVE THESE INSTRUCTIONS )

Visit our website at www.blueairinc.com

Contents

Fax, (310) 808

-

0242/0262

♦ Specifications …………………….
♦ Cautions & Warnings …………..
♦ Installation Guide ………………..
♦ Maintenance & Cleaning ……….
♦ Operation ………………………….
♦ Trouble-Shooting ………………..

Service Contact

2
3
4
5
6
7

Blue Air Refrigeration has a Nationwide Service Network

to provide timely services to our customer’s needs.

Please call or fax us at the following numbers.

Blue Air Refrigeration Nationwide Service Network

Toll Free, 1-866-677-8500

TEL, [phone]

1

Specifications

W4551

51

1/2

g

Rear

2 Casters

R-134a

R-134a

R-404a

Model BACF11 BACRF14 BSCF15

Gross Capacity (cu.ft) 11 14 15

Exterior Dimensions

(Including Casters)

D 22 1/4 23 1/2 25 3/4

[in]

H 36 1/2 35 1/2 37

Net Weight (lbs) 128 139 170

Type of refrigeration system Direct cooling

Control Thermostat Control

Casters
or Legs

Front 2 Casters

Basket 1EA 1EA 1EA

Number of Doors 2 Door/top sliding

Rated Voltage AC115V /60Hz

Type of Power Cord NEMA 5-15

Amps 2.7A 4.7A 3.7A

Compressor (HP) 1/5 HP 3/8 HP 3/8 HP

Refrigerant

(6.3 oz) (9.9 oz) (9.9 oz)

Range of Temperature Below 0°F

♦ Specifications and Designs are subject to change without notice.
♦ The name plate (including Serial No.) is located on the upper left side of the cabinet interior.

2

Cautions & Warnings

p

pyp

• All units are intended for indoor use only.
Use of the product outdoor may cause
extensive damages.

• To reduce the risk of shock or fire,
do not use flammable product near the unit.

• To reduce the risk of shock or fire,
do not expose the unit to excessive water.

• Keep the unit located away from equipments
that causes heat & moisture.

• Avoid direct exposure of the sun.

• When cleaning the unit

- Unplug the power cord

- Do not handle the cord wit wet hand.

- Do not use abrasive cleaner or solvents

• When the unit is not in use;

Leave the power cord unplugged
Clean inside with dry cloth, then leave
the door

artially open to eliminate odor.

3

Installation Guide

plugg

(

)

pgg g

(g,ggg)

Wait! 1 hour

• Install the unit only on a floor that is leveled
and strong enough to hold the weight of the
unit and its contents.

• Unleveled floor may cause noise.

• To reduce the risk of shock or fire,
unit should be plugged into a dedicated
electrical circuit.

• Do not use extension cords.

• To reduce the risk of shock or fire, the unit
must be properly grounded.
All units are equipped with three-prong
grounding plug on the power cord.

• Do not ground to the tapping pipes or as pipes.

• The refrigeration system performs best when
installed in an area with cool, dry air circulation .

• There must be at least 7 inches of clearance
on all side of the unit.

7 inches

• Do not plug in as soon as delivered the unit
Wait at least 1 hour after installed the unit
If not, it can be a cause of serious problems.

Not cooling, clogging…

40 minutes

7 inches

• Wait at least 6 minutes after unpluggin g
the unit before plugging it in again.
Compressor failure may occur if the unit is

ed in before the 6 minutes waiting time.

Wait! 6 Minutes

4

7 inches

Maintenance & Cleaning

Compressor warranty will be voided if the damage was due to a lake of maintenance

Wait 6 minutes before re

plugging

Cautions

!

Warranty is void if ventilation is insufficient.
Compressor warranties are void if compressor burns out due to low or high voltage.

 All storage items should be kept away from the interior wall at least 2

inches for cold air circulation.

 Make sure to put the casters on a locking point (If equipped) for safety.
 Do not set the temperature too low if not necessary.

.

 Cleaning the interior & exterior ; Please unplug before cleaning.

-. Wash the unit with warm and soapy water,

-. Dry up the unit after cleaning.

-. Clean the gasket frequently.

-. Dew can ne dropping in rainy season, Please wipe it with a dry clothes.

 How to defrost; Please unplug before defrost.

-. Remove door,

-. Move stored item to another freezer while defrosting.

-. Defrosting usually takes a few hours.

-. Never use a knife or other metal instrument to remove the ice from the
interior wall of the freezer.

-. Place a pan or container under drain hose to collect the defrosted water.

-. Open the cap which is located at bottom of interior to vent defrosted water.
(If the drain cap is not equipped, wipe the water with cloth.)

-. Dry the unit and close the cap what you open.

-. Assemble the door.

-.

!

-

!

.

5

Operation

•

Set the knob position at the temperature level you want

overload or other problems

• Temperature range : below 0°F

• T emperature controller (Control Knob) is located on the front lower side of
the cabinet exterior

.

1) The preset controller position by the factory is “5” .

2) The higher number you set, the lower the cabinet temperature will be.

• Do not set the temperature too low if not necessary. It can be cause of

.

CONSTANT

TEMPERATURE

BACF11/BACRF14/BACF15

POWER

5

4

3

2

6

COLDEST

OFF

1

6

Trouble-shootings

b

(C

ill b

around frame

Problems Cause, Possible Solutions

• Compressor
won’t run

• Doesn’t get cool • Temperature set point

• Noise • Loosen parts • Make it tight

• Noise from

compressor

•Condensation of

• Loose plug or cables

• Compressor is controlled
y systems

is too high

• Loading of too much warm • Before loading,

or moist product cool down the product.

• Not enough air circulation • Make space around

• Dust on Condenser • Clean the condenser

• Loosen parts

• Dust on the condenser

• Door is open slightly. •Close the door firmly.

• Make it tight

• Not a problem
omp w

automatically)

• Adjust the knob

(setting temperature)

the unit as shown
installation guide

• Make it tight

• Clean the Condenser

e restart

.

☞ The following conditions are normal, and don’t need a service call.

1.The surface temperature of compressor dome can be rise to a range
70~80°C(158~176°F) it’s not a problem. but, you can help it cool down by
cleaning up the condenser

2.the sounds of flowing water can be heard when the unit is operating
this is the sounds of flowing refrigerant.

7

WARRANTY CERTIFICATE

Warranty Valid Only In the USA

This warranty is subject to all of the terms and conditions listed below. On-line warranty registration or Warranty card furnished with this unit must be
properly executed and returned to BLUE AIR immediately after installation. Failure to complete on-line registration or, to return the warranty registration
card to provided location will automatically void all warranties.

Standard Warranty

One(1) Year Parts & Labor Warranty: (On Selected Products – Chest Freezers)

BLUE AIR warrants to the original purchaser of the BLUE AIR unit sold and all parts thereof to be free from defects in material or workmanship, under
normal use and service for a period of one (1) year from the date of sale by Distributor or Dealer, or fifteen (15) months from date of shipment by Blue
Air, whichever occ
F.O.B. factory any of such products that prove to be defective and which our examination shall disclose to our satisfaction to be defective.

Two (2) Years Parts and Labor Warranty: (On Selected Products – All refrigeration equipment except Chest Freezers)

BLUE AIR warrants to the original purchaser the BLUE AIR unit sold and all parts thereof to be free from defects in material or workmanship, under
normal use and service for a period of one and two years from the date of sale or twenty one (27) months from date of shipment by Blue Air, whichever
occurs first. Unit lamps are NOT included in the warranty. Our obligation under this warranty shall be limited
of such products that prove to be defective and which our examination shall disclose to our satisfaction to be defective

A) Any part returned to the company under the terms of this warranty must be accompanied by the record of the cabinet model number,

B) Improper operation due to low voltage condition, inadequate wiring and accident damages are not manufacturing defects and are

C) Condenser coils must be cleaned at regular intervals. Failure to do so may cause the compressor to malfunction and will void the

Extended Warranty

One (1) year extended warranty for parts & labor is available for purchase at the time of purchasing equipment from our dealers.

Five-Year Compressor Warranty

BLUE AIR warrants the hermetically sealed compressor for an 60 months, for the

PREP UNDERCOUNTERS, CHEFBASES, UNDERBAR REFRIGERATION EQUIPMENT, GLASS DOOR REACH-INS, CHEST
FREEZERS/COOLERS and COUNTER TOP REFRIGERATION EQUIPMENT. Not to exceed sixty three(63) months from the date of

shipment from Blue Air warehouse, provided upon receipt of the comp
Lack of maintenance will result in a voided warranty. This extended warranty does not apply for any electrical controls, accumulator or wiring harnesses
which are covered by the standard warranty.

Warranty Claims

All labor claims or parts must include copy of original invoice submitted directly to Blue Air. All claims must included: a copy of original invoice (Customer
Name, address, model name, and Date of Sale) Customer Name, Phone Number, Model & Serial No of unit, date of sale, Distributors or Dealers name
and brief description of complaint. On all compressor warranties the compressor model tag must
information. All claims must be reported to Blue Air within one (1) year of occurrence. All compressors have five (5) years warranty coverage. This
warranty will not be effective unless the warranty card is returned or registered (www.blueairinc.com) to Blue Air within 12 days of installation. Confirm
receipt of warranty registration by contacting Blue

Non Warranty Claims

Blue Air’s warranty service is limited to labor of repairing merchandise and/or parts replaced. This warranty does not authorize any person(s) to assume
any obligation or liability other than what the warranty permits. This warranty will be void if such action occurs. Any attempt to repair BLUE AIR products
without an official job number issued by BLUE AIR will not be covered by warranty and the
apply to any part, which has been subject to misuse, neglect, alteration, accident, or to any visible or concealed damage caused by transportation, flood,
fire, acts of God, etc.

Concealed Damage Example

Styrofoam may hide any hidden dents on the shipment that may not be completely visible. You must inspect all corners and grills thoroughly. If the
carrier stacks any contents on the units this can cause glass on the glass door units to break from the inside. All units are checked for any damages
before they are released.

urs first. Unit lamps are NOT included in the warranty. Our obligation under this warranty shall be limited to repairing or replacing

to repairing or replacing F.O.B. factory any

.

serial number, return authorization number and such return shall be on the basis of TRANSPORTATION C

strictly the responsibility of the purchaser.

warranty. This contract does not apply outside the limits of the U.S.A. nor
neglect, alteration, accident or to any damage caused by transportation, flood, fire, or the acts of God. This contract is not effective
unless the BLUE AIR Warranty Card, furnished with each unit, is properly filled out and mailed back to BLUE AIR within twelve (12)
days from the date of installation. The term “Original Purchaser” as used her
association, or company for whom the refrigeration unit refers to herein is originally installed.

does it to any part which has been subject of misuse,

ein shall be deemed to refer to that person, firm,

HARGES PREPAID.

STAINLESS STEEL REACH-INS, PREP TABLES, PIZZA

ressor manufacturer examination shows the sealed compressor to be defective.

be returned to Blue Air along with the above

Air directly (1-866-677-8500)

services will not be compensated. This warranty does not

8

No claims can be made against this warranty for lost product.

W

hat Is Not Covered By This Warranty

S

l

d

f

m

W

h

a

I

e

o

O

r

u

I

m

e

N

t

p

g

i

R

f

t

e

c

poilage of Product - No claims can be made against this warranty for any spoilage of products, such as food, loss of sales, or consequentia

amages. BLUE AIR is not responsible for the repair or replacement of any parts that BLUE AIR determines have been subjected after the date o

anufacture to alteration, neglect, abuse, misuse, accidents, damage during transit or installation, fire, flood, or acts of God.

arranty Is Non Transferable - This warranty is not assignable and applies only to the original purchaser/user to whom delivered. Any suc

ssignment or transfer will void this warranty and all other warranties implied.

mproper Usage - BLUEAIR is not liable in any way for parts or labor coverage for component failure or other damages resulting from improper usag

r installation or failure to clean and/or maintain product as mentioned in the warranty packet provided with the unit.

utside U.S. (Including Alaska) - This warranty does not apply to, and BLUE AIR is not responsible for, any warranty claims made on products sold o

sed outside the United States.

mproper Electrical Connections - BLUE AIR is not responsible for the repair or replacement of failed or damaged components resulting fro

lectrical power failure, the use of extension cords, low voltage, or voltage interference to the unit.

o Implied Warranty of Merchantability or Fitness for a Particular Purpose - There are no other warranties, expressed, implied or statutory, excep

arts and labor warranty and compressor warranty as described above. These warranties are exclusive and in lieu of all other warranties, includin

mplied warranty and merchantability or fitness for a particular purpose. There are no warranties, which extend beyond this mentioned description.

emote Condensers - BLUE AIR warrants the original purchaser of the remote cabinet one year parts and labor coverage for all cabinet parts thereo

o be free from defects in material or workmanship, under proper use and maintenance service, as specified by BLUE AIR. This warranty is limited to th

abinet only. BLUE AIR is not liable for remote condensing units.

BLUE AIR Commercial Refrigeration Inc.

223 W. Rosecrans Ave, Gardena, CA 90248

Phone: [phone]), (310-808-0102),

Fax:[phone]

Email: [e-mail]

9

Warranty R egistration Card

Blue Air Commercial Refrigeration Inc.

223 W. Rosecrans Ave. Gardena, CA 90248

Tel, 310-808-0102, Fax, 310-808-0242

Customer Name Business Name

Telephone : ( ) Telephone : ( )

Address (Customer) Address (Business or Installation Site)

Street Street

City State Zip City State Zip

Place of Purchase Date Purchased Date Installed

Model Name Product Serial No.

Extended Warranty Option

Additional 1 Year Parts & Labor extended Warranty available

If you are interested, please contact Blue Air Customer Service Dept.

□ Yes, I would like the extended warranty. / □ No, I would not like the extended warranty.

Signature of Business Owner Date

※

The Warranty becomes void if the attached warranty card is not filled out and returned to Blue Air within 15 days from the purchase date.

Cut along dotted line and mail it back to ; BLUE AIR Customer Service Dept. 223 W. Rosecrans Ave. Gardena, CA 90248

※

The Warranty becomes void if the attached warranty card is not filled out

and returned to Blue Air within 15 days from the purchase date.

Cut along dotted line and mail it back to ;

BLUE AIR Customer Service Dept.

223 W. Rosecrans Ave. Gardena, CA 90248

BLUE AIR

Fax, (310) 808

0242/0262

223 W. Rosecrans Ave. Gardena, CA 90248

Toll Free, 1-866-677-8500

TEL, [phone]

-

Visit our website at www.blueairinc.com