Blaze BLZSB1LP User Manual
BLAZE Instructional Book
Page | 1
USE & CARE GUIDE
SINGLE SIDE BURNER MODEL
SINGLE SIDE BURNER MODEL BLZ-SB1(NG/LP)
DANGER - IF YOU SMELL GAS:
I) Shut off the gas supply to the appliance at its source.
2) Extinguish any open flames.
3) If a gas odor persists, keep away from your
appliance and contact your gas supplier or fire
department immediately.
ATTENTION:
WARNING
I) Do not store or use gasoline or other flammable
liquids or vapor in the vicinity of this or any other
appliance.
2) An LP cylinder not connected for use shall not be
stored in the vicinity of this or any other appliances.
INSTALLER: PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER.
CONSUMER: PLEASE READ & RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AND BEFORE
INSTALLING AND OPE RATI NG.
- CONTACT INFORMATION -
Blaze Outdoor Products: 6620 Greenwell Springs Rd, Baton Rouge, LA
70805 USA
email: CustomerService@BlazeGrills.com
WWW.
Phone: 866-976-9510
BLAZEGRILLS.COM
BLAZE Instructional Book
Page | 2
Table of Contents
I. Burner Specifications 4
II. General Safety and Instal l ati on Warnings 5-8
i. Location of Appliance 8-10
III. Electrical Safety and Installation Warnings 11-12
IV. Gas Safety and Installation Warnings 12-13
i. Checking for Gas Leaks 14-16
ii. Unpacking Unit 16
V. Gas Connections 17
i. Natural Gas Requirements 17
ii. Liquid Propane Gas and Tank Requirements 17-18
iii. Transporting and Storing LP Gas 18-19
VI. Installing the Appliance in a BBQ Island 20
i. Outdoor Kitchen Ventilation 21-23
ii. Building BBQ Specifications + Instruction Diagrams 23-24
VII. First Time Operation 25
i. Lighting the Appliance 25-26
ii. Manually Lighting the Appliance 26
iii. Flame Adjustment 26-27
BLAZE Instructional Book
Page | 3
VIII. Cleaning your Appliance 27-28
IX. Fuel Conversion 28
i. Gas Regulator 28-29
ii. Burners 30
X. Troubleshooting 30
XI. Warranty Registration 31
XII. Parts 32
XIII. Product Serial Number 33
XIV. BLAZE Product Registration 34
BLAZE Instructional Book
Page | 4
THIS MANUAL APPLIES TO THE FOLLOWING BLAZE PRODUCT:
SINGLE SLIDE IN SIDE BURNER
PRODUCT SPECIFICATIONS
NOTE: ALWAYS have equipment measured by Contractor before beginning
any project.
Single Side Burner Cut Out
11 1/4" W x 18” D
(Allow for 2 13/16" of drop-in clearance into your island)
BLAZE Instructional Book
Page | 5
IMPORTANT SAFETY INFORMATION
Please read this manual carefully and before using your BLAZE burner to ensure proper operation,
installation, servicing and to reduce the risk of fire, burn hazard and or other injury. This manual
should be retained for your information.
NOTE:
Improper installation and service or maintenance may cause property damage, injury or death.
Do not operate this appliance without having read this manual.
All gas installations and gas conversions must be performed by a qualified technician or aut h ori zed service
agent.
NOTE: This appliance is not intended for commercial use.
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, immediately
call your gas supplier or your fire department.
General Safety and Installation Warnings
Safe operation of the BLAZE burner depends upon its proper installation.
and service technician must perform adjustments and service of the burner. Prop er location and proper use is
essential to insure safe and continued trouble-free operation.
appliance will void the product’s warranty.
NOTE: The manufacturer cannot be held responsible for damage or injury caused by improper use of this
appliance.
Any non-approved alterations made to the
Only a qualified professional installer
BLAZE Instructional Book
Page | 6
When using your BLAZE appliance, please read and follow these basic precautions:
To reduce the risk of fire, electric shock, or injury, read and follow these basic pr ec autions before
appliance.
installing/operatin g your
APPLIANCE INSTALLATION
This gas appliance must be installed in accordance with all local codes.
If installation is planned in an area with no local codes, the gas appliance must be installed in accord with the
National
CSA
Fuel Gas Code ANSI Z223.1 and storage and handling of liquefied petroleum gases, ANSI/NFPA 58 or
B149.1 natural gas and propane installation code.
CALIFORNIA PROPOSITION 65 WARNING
WARNING: This produc t can expose you to chem icals includin g Chromium (hexavalent compounds ), which are
known to the State of California to cause cancer and birth defects or other reproductive harm. For more information
go to: www.P65Warnings.ca.gov
WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property
damage. Read the installation, operating and maintenance instructions thoroughly before installing or servicing
this equipment.
EXPLOSION HAZARD
Do not use the appliance as storage area for flammable materials. Keep area clear and free from combustible
materials, gasoline, and other flammable vapors and liquids. Failure to do so can result in death, explosion, or fire.
In Massachusetts: All gas products must be installed using a “Massachusetts” licensed plumber or gas f itter. A
“T” handle type manual gas valve must be installed in the gas supply line to this appliance. This applies to
permanently installed natural gas and propane installations.
installations using a 20 pound tank.
This does not apply to propane portable
BLAZE Instructional Book
Page | 7
Have an ABC Fire Extinguisher accessible at all times. Never attempt to extinguish a grease fire
with water or other liquids.
IMPORTANT: Consult the AHJ (Authority Having Jurisdiction) or local contractor of any
uncertainty.
This unit is for outdoor use only!
Do not operate in a building, garage or any other enclosed areas. This could result in carbon monoxide buildup
could result in injury or death.
goes into the house.
Side burners are not designed or intended for installation near a window or vent that
which
For proper operation, burners must be aligned with the valve orifice and seated in the burner ho using. F ailure to
do so could result in a fire and injury.
BEWARE OF SPIDERS
CAUTION: BURNER TUBES MUST BE INSPECTED AND CLEANED BEFORE EACH USE.
Spiders and small insects occasionally spin webs or make nests in the burner tubes. These webs can lead to a gas flow obstruction, which
could result in a fire in and around the burner tubes. This type of fire is known as “FLASH-BACK” and can cause serious damage to your
appliance and create an unsafe operating condition for the user. Although an obstructed burner tube is not the only cause of “FLASHBACK” it is the most common cause, and frequent inspection and cleaning of the burner tubes is necessary.
BLAZE Instructional Book
Page | 8
FOR YOUR SAFETY
NOTE: Check with City and Fire department for Local Building Codes. A Permit may be
required for outdoor kitchen construction.
Do not attempt to heat unopened containers on the burner as pressure may build up and cause the container to explode.
Never use charcoal or any other solid fuel in the appliance.
Never cook without the drip pan in place.
Never operate this appliance while under the influence of alcohol or drugs.
Location of Appliance
Most importantly, this is an outdoor appli ance. Ensure your appliance is positioned safely away from
anything that can catch fire. Under no circumstance is this appliance to be used indoors. This includes
garages or any other enclosed area. This outdoor cooking gas appliance is not approved to be installed in
or on any recreational vehicles and /or boats. BLAZE burners are for single family/residential u se on ly.
When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths
and keeping any gas supply lines as short as possible.
Do not store combustible materials, gasoline or flammable liquids or vapors around the appliance.
This BLAZE burner must be located outdoors only. As with any gas appliance, harmful carbon
monoxide is produced during the combustion process that should not be allowed to accumulate in a
confined space.
locations should be avoided. Do not locate the BLAZE burner where an overhang or awning may cover
it.
Please note since hot air rises above the BLAZE burner while in operation, covered
BLAZE Instructional Book
Page | 9
DO NOT obstruct the flow of combustion and ventilation air to this appliance.
Keep any electrical supply cords and the fuel supply hoses away from any heated surfaces and/or sharp
and aggressive edges.
Non-Combustible Enclosure: The BLAZE burner must be installed in a NON-COMBUSTIBLE
ENCLOSURE ONLY. The determination of whether a location is combustible or non-combustible
construction is made by the local fire marshal, building inspector or the local safety authority having
jurisdiction.
Clearance from Combustibles: Ensure your appliance remains at a distance of at least 16” from sides
& 16” from back from any
combustible materials,
Adequate Ventilation: Ensure there is adequate ventilation for both the appliance and/or island
cavity. This is required not only for proper combustion, but also to prevent gas build up. While the
amount of venting required varies on a case by case basis, consult with your local licensed
professional and local code for adequate venting requirements. Keep the ventilation openings of the
enclosure free and clear from any debris.
Firm Level Surface: Use your appliance only on a firm level surface. This appliance is not designed for
recreational vehicles, and should not be installed on a boat or marine craft.
Protection from Weather: Keep the appliance protected from adverse weather, including rain and winds.
combustible material such as wood, gyprock, paper and plants. Do not store
gasoline or flammable liquids or vapors around the appliance.
Wind can back up the heat behind the control panel potentially creating a gas leak, damage to the
product, and injury.
Maintenance Access: When your appliance is installed, you should be able to access the gas supply
line including the gas piping or hose, gas regulator, gas cylinder and any shut off valves. Allow clear
access to the entire gas supply hose and regulator.
Partial Enclosures: Many backyards have areas that are partially closed off, such as balconies and
pergolas. In some cases, it is hard to decide whether these partially enclosed areas should be classified as
indoor areas, particularly in terms of permanent (non-closable) ventilation. Consult the AHJ (Authority
Having Jurisdiction) or local contractor of any uncertainty. This outdoor cooking gas appliance shall not be
located under overhead construction.
Please read all instructions before installing or operating your gas appliance to prevent injury and appliance damage.
All gas appliances will get hot during use. Use extreme caution when operating the appliance.
Do not touch hot surfaces.
Close supervision is necessary when this or any appliance is used near children. Keep children away
from the appliance during operation and until the appliance has cooled off.
Do not store any LP cylinder or tank not connected for use with the appliance, in the area of this
appliance or any other appliance. Never store an LP cylinder or tank indoors, or within the reach of
children.
BLAZE Instructional Book
Page | 10
Never test the appliance for gas leaks using a lighted match or any other open flame; see leak test
procedures using soap/water solutions – see section on Leak Testing.
The use of accessories, regulators, or components not recommended by the appliance manufacturer
may cause injuries and will void warranty.
Never light the appliance with the stainless steel cover in place and be certain that the burners are
positioned and seated
Never lean over the cooking surface when lighting or operating the appliance.
Use cooking utensils with wood handles and insu lat ed ove n m itts when operat ing t he appliance.
Do not store anything in the appliance. Make sure food is not forgotten in the appliance; forgotten items
over the gas valves and on the burner support.
could melt or catch fire when the appliance is turned on.
To prevent injuries, do not use accessories that are not recommended by the manufacturer.
Before cleaning the appliance, disconnect the transformer and "trip" the circuit breaker.
Never use the appliance in windy conditions. If located in a consistently windy area (oceanfront,
mountaintop, etc.) a wind break will be required. Winds blowing into or across the burner can cause poor
performance.
Never operate the burner with the lid in place.
Children should not be left alone or unattended in an area where any appliance is in use. They should
never be allowed to touch, sit or stand on any part of the appliance.
Do not store items of interest to children in cabinets above the appliance or in the appliance. Children
climbing on the appliance to reach these items could be seriously injured.
Wear proper clothing when operating this appliance. Loose-fitting or hanging garments shou ld never be
worn while using the appliance.
Do not leave the appliance unattended while in use.
Do not use water on grease fires! A violent steam explosion may result. Instead, smother the fire with a
multipurpose ABC extinguisher.
BLAZE Instructional Book
Page | 11
Electrical Safety and Installation Warnings
Extension cords may be used if care is exercised in their use.
If an extension cord is used:
The marked electrical rating of the cord set or extension cord should be at least as great as the electrical
rating of the appliance.
The cord should be arranged so that it will not touch hot surfaces, sharp edges or drape over the
countertop or tabletop (where it can be pulled or tripped over unintentionally).
Outdoor extension cords should be used with products suited for outdoor use. They are surface marked with
suffix letters "W" or "W-A" and with a tag stating "Suitable for Use with Outdoor Appliances".
To protect against electrical shock, the power cord and plug should be kept dry and off of the ground.
Do not clean this product with water spray; do not spray cleaners into the lamp socket area.
Gasoline, lighter fluid or other flammable liquids and vapors should never be stored in the area of this appliance
or any other appliance.
Before installation or service, disconnect the power supply to the work area by removing the fuse, "tripping" the
circuit breaker, or unplugging the unit.
NOTE: Use a 15 AMP Breaker with GFI protection.
NOTE: This grill uses a “Transformer” to provide power to the LED lights and internal lights. This diagram
provides you with connection information.
Keep any electrical supply cord and fuel supply hose away from any heated surfaces, sharp edges and
dripping
Be certain your appliance is properly installed and grounded by a qualified technician in accordance with
applicable codes. To guarantee the electrical safety of this appliance, continuity must exist between the
appliance and an effective grounding system. It is imperative that this basic safety requirement be met. The
manufacturer cannot be held responsible for damages caused by the lack or inadequacy of an effective
grounding system.
Do not operate any applia nce with a dam aged power cord or po wer plug, and do not oper ate any appliance
after
to the
grease.
the appliance malfunctions or has been damaged in any manner. If this should occur, return the appliance
nearest authorized service facility for examination, repair or adjustment.
Loading...