Black & Decker 5148276-00, FS1800HV User Manual

Battery storage and carrying caps are provided for use whenever the battery is out of the

tool or charger. Remove cap before placing battery in charger or tool.

WARNING: Do not store or carry battery so that metal objects can contact exposed

battery terminals. For example, do not place battery in aprons, pockets, tool boxes, product kit boxes, drawers, etc. with loose nails, screws, keys, etc. without battery cap. Transporting batteries can possibly cause fires if the battery terminals inadvertently come in contact with conductive materials such as keys, coins, hand tools and the like. The US Department of Transportation Hazardous Material Regulations (HMR) actually prohibit transporting batteries in commerce or on airplanes (i.e. packed in suitcases and carryon luggage) UNLESS they are properly protected from short circuits. So when transporting individual batteries, make sure that the battery terminals are protected and well insulated from materials that could contact them and cause a short circuit.

IMPORTANT CHARGING NOTES

1. Longest life and best performance can be obtained if the battery pack is charged when the air temperature is between 65°F and 75°F (18°- 24°C). DO NOT charge the battery pack in an air temperature below +40°F(+4.5°C), or above +105°F (+40.5°C). This is important and will prevent serious damage to the battery pack.

2. The charger and battery pack may become warm to touch while charging. This is a normal condition, and does not indicate a problem.

3. If the battery pack does not charge properly — (1) Check power at receptacle by plugging in a lamp or other appliance. (2) Check to see if receptacle is connected to a light switch which turns power off when you turn out the lights. (3) Move charger and battery pack to a location where the surrounding air temperature is approximately 65°F - 75°F (18°- 24°C). (4) If charging problems persist, take or send the tool, battery pack and charger to your local service center.

4. The battery pack should be recharged when it does not produce sufficient power on jobs which were easily done previously. DO NOT CONTINUE use under these conditions. Follow the charging procedures. You may also charge a partially used pack whenever you desire with no adverse affect on the battery pack.

5. Black & Decker battery packs that are labeled “NiMH” should only be used with chargers labeled “NiMH“ or “NiCd/NiMH.”

6. Under certain conditions, with the charger plugged into the power supply, the exposed charging contacts inside the charger can be shorted by foreign material. Foreign materials of a conductive nature such as, but not limited to, steel wool, aluminum foil, or any buildup of metallic particles should be kept away from charger cavities. Always unplug the charger from the power supply when there is no battery pack in the cavity. Unplug charger before attempting to clean.

7. Do not immerse charger in water or any other liquid.

8. The charger supplied with this product is intended to be plugged in such that it is correctly

orientated in a vertical or floor mount position.

OPERATION

This product is for dry pick-up only. FIG. B • To start, slide the On/Off switch forward (i.e. “O”= Off, “I” = On). To stop, slide the

switch back.

When using electrical appliances, basic safety precautions should always be followed, including the following: PLEASE READ AND UNDERSTAND ALL INSTRUCTIONS CAREFULLY

BEFORE USING THE UNIT.

WARNING: Some household dust contains chemicals known to the State of

California to cause cancer, birth defects or other reproductive harm such as asbestos and lead in lead based paint.

WARNING: To reduce the risk of fire, electrical shock or injury:

• Close supervision is necessary when any appliance is used by or near children. Do not allow to be used as a toy.

• To protect against risk of electrical shock, do not put unit or charging base in water or other liquid.

• Do not use Cordless Hand vacuum to pick up liquids, toxic substances, flammable or combustible liquids such as gasoline or use in areas where they may be present.

• Do not use wet/dry hand vacs to pick up toxic substances, flammable or combustible liquids such as gasoline or use in areas where they may be present.

• Do not operate in the presence of explosives and/or flammable fumes or liquids.

• Do not operate any appliance with a damaged cord or charger or after the appliance malfunctions, is left outdoors, dropped into water or is damaged in any manner. Return the appliance to any authorized service facility.

• Do not use Cordless Hand Vacuum outdoors or on wet surfaces. Do not use the wet/dry hand vacs outdoors.

• Do not abuse the cord. Never carry the charger or base by the cord or yank to disconnect from an outlet; instead grasp the charger and pull to disconnect. Keep cord away from heated surfaces. Do not pull cord around sharp edges or corners.

• Do not allow the cord to hang over the edge of a table or counter or touch hot surfaces. The unit should be placed or mounted away from sinks and hot surfaces.

• Do not use an extension cord. Plug the charger directly into an electrical outlet.

• Use the charger only in a standard electrical outlet (120V/60Hz).

• Do not attempt to use the charger with any other product; do not attempt to charge this product with any other charger. Use only the charger supplied by the manufacturer to recharge.

• Keep hair, loose clothing, and all parts of body away from openings and moving parts.

• Do not insert accessories when unit is running.

• Do not handle plug or appliance with wet hands.

• Do not put any object into unit openings. Do not use with any openings blocked; keep free of dust, lint, hair, and anything that may reduce air flow.

• Do not operate the unit without a filter in place. Replace a damaged filter promptly.

• Do not vacuum burning or smoking materials, such as lit cigarette butts, matches or hot ashes.

• Do not use on or near hot surfaces.

• Use extra caution when cleaning on stairs.

• This appliance is intended for household use only and not for commercial or industrial use.

• Use only as described in this manual. Use only manufacturer’s recommended attachments.

• Unplug the charger from outlet before any routine cleaning or maintenance.

• This product includes rechargeable nickel cadmium batteries. Do not incinerate batteries as they will explode at high temperatures.

• Leaks from battery cells can occur under extreme conditions. If the liquid, which is a 20-35% solution of potassium hydroxide, gets on the skin (1) wash quickly with soap and water or (2) neutralize with a mild acid such as lemon juice or vinegar. If the liquid gets into the eyes, flush them immediately with clean water for a minimum of 10 minutes. Seek medical attention.

Catalog No. FS1800HV FORM NO. 5148276-00 REV. 1

VEA EL ESPAÑOL EN LA CONTRAPORTADA.

SAVE THIS MANUAL FOR FUTURE REFERENCE.

INSTRUCTIVO DE OPERACIÓN, CENTROS DE SERVICIO Y PÓLIZADE GARANTÍA. ADVERTENCIA: LÉASE ESTE INSTRUCTIVO ANTES DE USAR EL PRODUCTO.

INSTRUCTION MANUAL

IMPORTANT SAFEGUARDS

How To Use

Catalog No. FS1800HV

SAVE THESE INSTRUCTIONS

Product Features

FIG. A 1. On/Off switch 3. Dust bowl 5. Slide pack battery

2. Release button 4. Exhaust Filter

Battery Cap

FS1800HV tool can accept any of the following 18V slide pack batteries and 18V slide pack chargers seen in the chart below. Please see the individual charger manuals for all safety and operating instructions.

BEFORE RETURNING THIS PRODUCT

FOR ANY REASON PLEASE CALL

1-800-544-6986

BEFORE YOU CALL, HAVE THE CATALOG No. AND DATE CODE AVAILABLE. IN MOST CASES, A

BLACK & DECKER REPRESENTATIVE CAN RESOLVE THE PROBLEM OVER THE PHONE. IF YOU HAVE A SUGGESTION OR COMMENT, GIVE US A CALL. YOUR FEEDBACK IS VITAL TO

BLACK & DECKER.

HANK

YOU

FOR

CHOOSING

LACK

&&D

ECKER

OOTTOOWWW

WWW

LACKAND

ECKER

COM

WNER

TTOOREGISTER

YOUR

NEW

PRODUCT

18V Slide Pack Batteries

18V Firestorm Battery 18V FSXtreme Battery 18V FSXtreme Battery 3 terminal 18V FSXtreme Battery Silver Series 18V Black & Decker Battery

FSB18 FS180BX FS18BX

FS18SBX

HPB18

Cat. # Description

18V Slide Pack Chargers

18V Cup Charger 18V Dual Port Charger 18V Radio Charger 18V Three Port Charger

9.6V-18V Fast Charger

9.6V-24V One Hour Charger

9.6V-24V Dual Port One Hour Charger

FS18C FS180DC FS18RC 5104211-00 FSMVC FS240FC FS2400DC

Cat. # Description

CLEANING THE PRODUCT

WARNING: Never use the Cordless Hand Vacuum without its filters. NOTE: The filters are re-usable, do not confuse them with disposable dust bags, and do not

throw them away when the product is emptied. We recommend that you replace the filters every 6-9 months.

FIG. C • Remove the dust bowl by pressing the dust bowl release button and pulling the

bowl down and out. To replace the bowl, place it back onto the handle and click firmly into position.

FIG. D • Empty the dust from the bowl and wash if necessary. FIG. E • To remove the filter twist it in a clockwise direction. Shake or lightly brush any

loose dust off the filter.

FIG. F • Wash the filter regularly using warm, soapy water and ensure that it is

completely dry before using it again. The cleaner the filters are, the better the product will perform. It is very important that the filter is correctly in position before use. The dust bowl can also be washed in warm soapy water. Ensure that it is dry before re-attaching.

FIG. F1-2 • Exhaust filter - On bottom of unit, between battery and bowl is an exhaust filter.

To ensure optimum performance of unit, this filter should be cleaned regularly. To clean the filter press tab (end nearest battery) and pull up (fig F1). The filter should now be exposed. Remove filter (fig F2) and rinse with warm, soapy water. Ensure filter is completely dry before replacing. When putting filter back into place, put black side of filter towards the outside of unit. If taken care of properly, filter should last life of unit.

IMPORTANT: Maximum dust collection will only be obtained with clean filters and an empty dust bowl. If dust begins to fall back out of the product after it is switched off, this indicates that the bowl is full and requires emptying.

FIG. G • Never immerse the product in water. A damp cloth and soapy water should be

used to clean the exterior of the motor section. Always ensure the product is completely dry before re-use or storing.

RUN TIME

• When fully charged, the average effective usage times are between 10-15 minutes.

• It may take several chargings before these times can be achieved.

OTHER INFORMATION

If the product does not work, check the following:

• The charger was correctly plugged in for recharge. ( It feels slightly warm to the touch.)

• The charger cord is not damaged and is correctly attached to the base.

• The charger is plugged into a working electrical outlet.

BATTERY REMOVAL AND DISPOSAL

This product uses nickel-cadmium (Ni-Cd) rechargeable and recyclable batteries. When the batteries no longer hold a charge, they should be removed from the Vac and recycled. They must not be incinerated or composited. The batteries can be taken for disposal to a Black & Decker, Company-Owned or Authorized Service Center. Some local retailers are also participating in a national recycling program (see “RBRC

Seal”). Call your local retailer for details. If you bring the batteries to a Black & Decker Company-Owned or Authorized Service Center, the Center will arrange to recycle old batteries. Or, contact your local municipality for proper disposal instructions in your city/town.

MAINTENANCE

Use only mild soap and damp cloth to clean the vac. Never let any liquid get inside the vac; never immerse any part of the vac into a liquid.

NOTE: Make sure the vacuum is completely dry before using it. IMPORTANT: To assure product SAFETY and RELIABILITY, repairs, maintenance and

adjustment (other than those listed in this manual) should be performed by authorized service centers or other qualified service organizations, always using identical replacement parts.

THE RBRC™ SEAL

The RBRC™ (Rechargeable Battery Recycling Corporation) Seal on the nickelcadmium battery (or battery pack) indicates that the costs to recycle the battery (or battery pack) at the end of its useful life have already been paid by Black & Decker. In some areas, it is illegal to place spent nickel-cadmium batteries in the trash or municipal solid waste stream and the RBRC program provides an environmentally conscious alternative. RBRC in cooperation with Black & Decker and other battery users, has established programs in the United States and Canada to facilitate the collection of spent nickelcadmium batteries. Help protect our environment and conserve natural resources by returning the spent nickel-cadmium battery to an authorized Black & Decker service center or to your local retailer for recycling. You may also contact your local recycling center for information on where to drop off the spent battery, or call 1-800-8-BATTERY.

SERVICE INFORMATION

Black & Decker offers a full network of company-owned and authorized service locations throughout North America. All Black & Decker Service Centers are staffed with trained personnel to provide customers with efficient and reliable power tool service. Whether you need technical advice, repair, or genuine factory replacement parts, contact the Black & Decker location nearest you. To find your local service location, refer to the yellow page directory under “Tools—Electric” or call: 1-800-544-6986.

FULL TWO-YEAR HOME USE WARRANTY

Black & Decker (U.S.) Inc. warrants this product for two years against any defects in material or workmanship. The defective product will be replaced or repaired at no charge in either of two ways. The first, which will result in exchanges only, is to return the product to the retailer from whom it was purchased (provided that the store is a participating retailer). Returns should be made within the time period of the retailer’s policy for exchanges (usually 30 to 90 days after the sale). Proof of purchase may be required. Please check with the retailer for their specific return policy regarding returns that are beyond the time set for exchanges. The second option is to take or send the product (prepaid) to a Black & Decker owned or authorized Service Center for repair or replacement at our option. Proof of purchase may be required. Black & Decker owned and authorized Service Centers are listed under “ToolsElectric” in the yellow pages of the phone directory. This warranty does not apply to accessories. This warranty gives you specific legal rights and you may have other rights which vary from state to state. Should you have any questions, contact the manager of your nearest Black & Decker Service Center. This product is not intended for commercial use.

oubleshooting

Problem

Possible Cause

Possible Solution

• Unit will not start. • Battery not installed properly. • Check battery installation.

• Battery not charged. • Check battery charging requirements.

• Battery will not charge. • Battery not inserted into charger. • Insert battery into charger until red LED appears.

• Charger not plugged in. • Plug charger into a working outlet. Refer to “Important Charging Notes” for more details.

For assistance with your product, visit our website www.blackanddecker.com for the loca- tion of the service center nearest you or call the BLACK & DECKER help line at

1-800-544-6986.

Special WARRANTY Note to Contractors:

FIRESTORM

branded products are offered as high end consumer home use tools and carry a HOME USE WARRANTY. These tools are designed, manufactured and tested to meet or exceed the needs of the do-it-yourselfer in the execution of projects and repairs in and around the home. With proper use they will provide the home owner with step up power and performance well beyond their two year warranty. However, if you use tools for a living and use FIRESTORM

branded products or any of Black & Decker’s other Consumer Home

Use tools ON THE JOBSITE you should know that they CANNOT BE COVERED UNDER

OUR WARRANTY.

Lorsqu’on utilise un appareil électrique, il faut toujours respecter certaines règles de sécurité fondamentales, notamment les suivantes. LIRE ATTENTIVEMENT ET COMPRENDRE TOUTES LES

DIRECTIVES AVANT D’UTILISER L’APPAREIL.

AVERTISSEMENT : Certaines poussières domestiques contiennent des produits

chimiques reconnus par l’État de la Californie comme étant cancérogènes et pouvant entraîner des anomalies congénitales et d’autres risques pour la reproduction tels que l’amiante et le plomb contenu dans les peintures au plomb.

AVERTISSEMENT : Afin de minimiser les risques d’incendie, de secousses électriques ou

de blessures, faire ce qui suit.

• Exercer une étroite surveillance lorsqu’on utilise l’appareil près d’un enfant ou que ce dernier s'en sert. Il ne s’agit pas d’un jouet.

• Afin d’éviter les risques de secousses électriques, ne pas immerger l’appareil ni son chargeur.

• Ne pas se servir d’un aspirateur portatif sans fil afin d’aspirer des liquides, des substances toxiques, des liquides inflammables ou combustibles (de l’essence, par exemple), ni s’en servir dans un endroit renfermant de tels produits.

• Ne pas se servir d’un aspirateur portatif pour déchets secs ou humides pour aspirer des substances toxiques, des liquides inflammables ou combustibles (de l’essence, par exemple), ni s’en servir dans un endroit renfermant de tels produits.

• Ne pas se servir de l’appareil en présence de vapeurs explosives ou inflammables.

• Ne pas utiliser un appareil dont le cordon ou le chargeur est endommagé, ni un appareil qui ne fonctionne pas bien, qui est tombé, endommagé, resté à l’extérieur ou a été immergé. Le confier à un centre de service autorisé.

• Ne pas utiliser un aspirateur portatif sans fil à l’extérieur ni sur des surfaces mouillées. Ne pas utiliser un aspirateur portatif pour déchets secs ou humides à l’extérieur.

• Manipuler le cordon avec soin. Ne jamais transporter le chargeur ni le socle par le cordon ni tirer sur le cordon pour le débrancher. Saisir plutôt la fiche et tirer dessus. Éloigner le cordon des surfaces chaudes. Ne pas tirer sur le cordon lorsqu’il est autour d’un coin ou d’un rebord tranchant.

• Ne pas laisser pendre le cordon d’une table ou d’un comptoir, ni le laisser entrer en contact avec une surface chaude. Placer ou installer l’appareil loin des éviers ou des surfaces chaudes.

• Ne pas utiliser de cordon de rallonge. Brancher le chargeur directement dans une prise.

• Brancher le chargeur seulement dans une prise standard (120 V, 60 Hz).

• Ne pas utiliser le chargeur avec un autre appareil; ni tenter de charger le produit avec un autre chargeur. Utiliser seulement le chargeur fourni par le fabricant.

• Éloigner les cheveux, les vêtements amples et les membres du corps des orifices et des pièces mobiles de l’appareil.

• Ne pas installer d’accessoires lorsque l’appareil fonctionne.

• Ne pas manipuler la fiche ni l’appareil avec les mains mouillées.

• Ne pas insérer d’objets dans les ouvertures de l’appareil. Ne pas utiliser l’appareil lorsqu’une de ses ouvertures est bloquée. Enlever la poussière, la charpie, les cheveux et toute autre matière

susceptible de réduire le débit d’air.

• Ne pas faire fonctionner l’appareil sans filtre. Remplacer sans tarder le filtre s’il est endommagé.

• Ne pas se servir de l’appareil pour aspirer des substances en combustion, comme des mégots allumés, des allumettes ou des cendres chaudes provenant d’un foyer.

• Ne pas utiliser l’appareil sur des surfaces chaudes ni près de celles-ci.

• Faire preuve de prudence lorsqu’on nettoie les escaliers.

• L’appareil est conçu pour une utilisation domestique seulement et non industrielle ou commerciale.

• Utiliser l’appareil seulement de la manière décrite dans le présent guide. Utiliser seulement les accessoires recommandés par le fabricant.

• Débrancher le chargeur avant de le nettoyer.

• L’appareil renferme des piles rechargeables au nickel-cadmium. Ne pas incinérer les piles. La chaleur des flammes peut les faire exploser.

• Il peut se produire une légère fuite du liquide excitateur des piles dans des conditions extrêmes. Toutefois, si ce liquide (solution d’hydrogène de potassium à 20-35 p. 100) atteint la peau, il faut :

1) laver immédiatement à l’eau et au savon ou 2) neutraliser à l’aide d’un acide doux comme du jus de citron ou du vinaigre. Si le liquide excitateur atteint les yeux, rincer immédiatement à l’eau claire pendant au moins dix minutes et consulter un médecin.

FIG. A

1. Interrupteur 3. Bac à poussière 5. Bloc-pile

2. Bouton de dégagement 4. Filtre d'évacuation

Le bloc-pile comporte des bouchons pour le rangement et le transport, ou à utiliser lorsque celui-ci n'est pas dans l'appareil, ni dans le chargeur.

AVERTISSEMENT : S’assurer, au moment de ranger ou de transporter un bloc-pile ou une

pile, qu’aucun objet métallique n’entre en contact avec leurs bornes à découvert de celui-ci. Par exemple, il faut éviter de placer un bloc-pile ou une pile sans capuchon dans un tablier, une poche, une boîte à outils ou un tiroir (etc.) contenant des objets tels que des clous, des vis ou des clés, car tout contact entre les bornes à découvert et un objet métallique comme une clé, une pièce de monnaie, un outil à main. etc. pourrait causer un incendie. En effet, les règlements américains Hazardous Material Regulations (HMR) du US Department of Transportation interdisent le transport d’un bloc-pile ou d’une pile dans tout moyen de transport commercial ou aéronef (que ce soit dans une valise ou le bagage de cabine) SAUF s’ils sont bien protégés contre les courts-circuits. On doit donc s’assurer, lorsqu’on transporte un bloc-pile ou une pile séparément, de bien protéger et isoler les bornes contre tout matériau qui risque d’entrer en contact avec eux et de causer un court-circuit.

IMPORTANTES MISES EN GARDE

CONSERVER CES DIRECTIVES.

Bouchon du bloc-pile

Utilisation

See ‘Tools-Electric’

– Yellow Pages –

for Service & Sales

Imported by

Black & Decker (U.S.) Inc.,

701 E. Joppa Rd.

Towson, MD 21286 U.S.A.

Composants

AAAAVVVVAAAANNNNTTTT DDDDEEEE RRRREEEETTTTOOOOUUUURRRRNNNNEEEERRRR CCCCEEEE PPPPRRRROOOODDDDUUUUIIIITTTT PPPPOOOOUUUURRRR QQQQUUUUEEEELLLLQQQQUUUUEE

RRRRAAAAIIIISSSSOOOONNNN QQQQUUUUEEEE CCCCEEEE SSSSOOOOIIIITTTT,,,, CCCCOOOOMMMMPPPPOOOOSSSSEEEERRRR LLLLEEEE NNNNUUUUMMMMÉÉÉÉRRRROOOO

SSSSUUUUIIIIVVVVAAAANNNNTTTT :::: 1111 888800000000 555544444444----66

66999988886666

MMMMEEEERRRRCCCCIIII DDDD’’’’AAAAVVVVOOOOIIIIRRRR CCCCHHHHOOOOIIIISSSSIIII BBBBLLLLAAAACCCCKK

KK &&&& DDDDEEEECCCCKKKKEEEERRRR!!!!

VVVVIIIISSSSIIIITTTTEEEEZZZZ WWWWWWWWWWWW....BBBBLLLLAAAACCCCKKKKAAAANNNNDDDDDDDDEEEECCCCKKKKEEEERRRR....CCCCOOOOMMMM////NNNNEEEEWWWWOOOOWWWWNNNNEEEERR

PPPPOOOOUUUURRRR EEEENNNNRRRREEEEGGGGIIIISSSSTTTTRRRREEEERRRR VVVVOOOOTTTTRRRREEEE NNNNOOOOUUUUVVVVEEEEAAAAUUUU PPPPRRRROOOODDDDUUUUIIIITTTT..

+ 3 hidden pages