Black Box VLC36SK-HD, VLC36SK-BIN1-HD, VLC36SK-WP-ILC, VLC36SK-HD-ILC, VLC36SK-BIN1-WP User Manual
...
User Manual
Store and charge up to 36 iPad®, tablets, Chromebook™, or laptop
computers.
36-Device iPad® and Chromebook™ Basic Charging Carts
Order toll-free in the U.S. or for FREE technical support 24/7: Call 877-877-BBOX
(outside U.S. call 724-746-5500)
www.blackbox.com • info@ blackbox.com
Contact
Information
VLC36SK-HD VLC36SK-HD-ILC VLC36SK-BIN1-HD
VLC36SK-WP VLC36SK-WP-ILC VLC36SK-BIN1-WP
Page 2
877-877-2269 | blackbox.com
VLC36SK-HD
Trademarks Used in this Manual
Trademarks Used In This Manual
Black Box and the Double Diamond logo are registered trademarks of
BB Technologies, Inc.
Any other trademarks mentioned in this manual are acknowledged to be
the property of the trademark owners.
Page 3
877-877-2269 | blackbox.com
VLC36SK-HD
Important Safety Instructions
Important Safety Information
WARNING! Death or serious injury may occur when children climb on the
Cart. The cart can tip over onto the child.
WARNING! Avoid uneven loading of equipment onto the cart. Uneven
weight distribution could cause the cart to tip when the cart is moving.
Ensure devices are distributed evenly within the cart. Excess weight on
sides of cart could cause the cart to tip while in motion.
• Only adults should move the cart.
• Do not leave the cart unattended in areas where children have access.
• Do not block the air vent openings.
• The Cart can be very heavy when fully loaded with laptops and should be
moved about by persons physically able to do so.
• The Cart should only be used for the storage and transport of tablets, laptops,
and other similar devices.
• Misuse, incorrect operation, or inadequate repair of the Cart will void the
warranty.
Electrical Precautions
DANGER! Failure to observe the following electrical safety precautions can
result in fire or death by electric shock.
• The power switch must be in the “OFF” position before plugging the Cart
into a wall receptacle.
• The Cart must ONLY be connected to a 110–120-volt AC, 15-amp power
supply.
• The Cart must only be used by adults or with adult supervision.
• Never pull the Cart by the power cord.
• Do not plug the Cart in if the switch, receptacle(s), or power cord has been
damaged. All electrical components on this product must be repaired by a qualified electrician.
• Do not use an extension cord in conjunction with the Cart.
• Do not use liquids in or around the Cart environment.
Page 4
877-877-2269 | blackbox.com
VLC36SK-HD
Important Safety Instructions
• Inadequate repair or modifications can create significant hazards to users and is
not covered by warranty.
• For your safety, we recommend that a qualified electrician test the circuit you
will be plugging the Cart into. The circuit should be checked for ground integrity
and appropriate branch circuit protection.
• The Cart ground prong must be present for safe operation. If the plug is
damaged or if the ground prong has been removed, it should be replaced by
a qualified electrician.
• The use of the Cart, including plugging or unplugging laptops, plugging or
unplugging the Cart, operating the control switch, and engaging or releasing
the directional and locked casters, must be done with adult supervision.
Page 5
877-877-2269 | blackbox.com
VLC36SK-HD
Table of Contents
Table of Contents
1. Specifications ...................................................................................................... 6
1.1 Comparison Chart ............................................................................... 6
1.2 Dimensional Diagrams ....................................................................... 10
2. Overview............ ............................................................................................... 11
2.1 Introduction ....................................................................................... 11
2.2 What‘s Included ................................................................................ 11
2.3 Hardware Description ........................................................................ 13
3. Using the Intelligent Charging System Module .................................................. 14
4. Basket Distribution System ................................................................................. 18
5. Using Your iPad and Chromebook Basic Charging Cart ....................................... 19
5.1 Charging Your Computers ................................................................ 19
5.2 Moving Your iPad and Chromebook Basic Charging Cart .................... 19
5.3 Locking the Cart Doors ...................................................................... 20
Page 6
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 1: Specifications
1. Specifications
1.1 Comparison Chart
Comparison Chart: 36-Device iPad and Chromebook Basic
Charging Carts
Part # VLC36SK-HD VLC36SK-WP
Approvals UL® approved power strip
Assembled Yes
Cable Access SIde sections each have a 1.41" diameter hole
Color Gray
Construction 22-gauge steel with vented sides
Locking Key: Locking front door and rear access panel for easy cable man-
agement (keyed differently)
Power (Input) (3) 6-foot attached power cords
w/ 5-15P, 110-120 VAC, 50/60
Hz
(3) 6-foot attached power cords
w/ 5-15P, 110-120 VAC,
50/60 Hz,accommodates
oversize wall transformers
Power Outlets (36) 5-15R outlets, via (3)
12-outlet power strips
(72) 5-15R outlets, via (6)
12-outlet power strips,
accomodates oversize
wall transformers
On/Off Switch (3) on/off switches (6) on/off switches
Dimensions (Cart) 43"H x 23"W x 23"D (109.2 x 58.4 x 58.4 cm)
Shelves 3
Device Capacity (36) total, (12) per shelf
Maximum Device
Dimensions
10.5"H x 1.28"W x 14.5"D (26.67 cm x 3.25 x 36.83 cm)
Laminate Top No
Shipping Carton
Dimensions
51"H x 32"W x 32"D (129.5 x 81.3 x 81.3 cm)
Weight Capacity
on Top Surface
150 lb. (68.2 kg), stationary
Warranty Carts: Lifetime;
Electronics: 3 years
Page 7
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 1: Specifications
Comparison Chart: 36-Device iPad and Chromebook Basic
Charging Carts with Intelligent Charging Unit
Part # VLC36SK-HD-ILC VLC36SK-WP-ILC
Approvals UL
®
approved power strip
Assembled Yes
Cable Access Side sections each have a 1.41" diameter hole
Color Gray
Construction 22-gauge steel with vented sides
Locking Key: Locking front door and rear access panel for easy cable man-
agement (keyed differently)
Power (Input) (1) 12-foot power cord w/ 5-15P,
110-120VAC, 50/60 Hz,
Intelligent Charging Unit
(1) 12-foot power cord w/ 5-15P,
110-120VAC, 50/60 Hz,
Intelligent Charging Unit
Power Outlets (36) 5-15R outlets, via (3)
12-outlet power strips
(72) 5-15R outlets, via (6)
12-outlet power strips,
accomodates oversize
wall transformers
On/Off Switch (3) on/off switches (6) on/off switches
Dimensions (Cart) 43"H x 23"W x 23"D (109.2 x 58.4 x 58.4 cm)
Shelves 3
Device Capacity (36) total, (12) per shelf
Maximum Device
Dimensions
10.5"H x 1.28"W x 14.5"D (26.67 cm x 3.25 x 36.83 cm)
Laminate Top No
Shipping Carton
Dimensions
51"H x 32"W x 32"D (129.5 x 81.3 x 81.3 cm)
Weight Capacity
on Top Surface
150 lb. (68.2 kg), stationary
Warranty Carts: Lifetime;
Electronics: 3 years
Page 8
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 1: Specifications
Comparison Chart: 36-Device iPad and Chromebook Basic
Charging Carts with Basket Distribution System
Part # VLC36SK-BIN1-HD VLC36SK-BIN1-WP
Approvals UL
®
approved power strip
Assembled Yes
Cable Access Side sections each have a 1.41" diameter hole
Color Gray
Construction 22-gauge steel with vented sides
Locking Key: Locking front door and rear access panel for easy cable man-
agement (keyed differently)
Power (Input) (3) 6-foot attached power cords
w/ 5-15P, 110-120 VAC,
50/60 Hz
(3) 6-foot attached power cords
w/ 5-15P, 110-120 VAC,
50/60 Hz,accommodates
oversize wall transformers
Power Outlets (36) 5-15R outlets, via (3)
12-outlet power strips
(72) 5-15R outlets, via (6)
12-outlet power strips,
accomodates oversize
wall transformers
On/Off Switch (3) on/off switches (6) on/off switches
Dimensions (Cart) 43"H x 23"W x 23"D (109.2 x 58.4 x 58.4 cm)
Baskets 6
Device Capacity (36) total, (3) shelves, (2) baskets per shelf, (6) devices per basket
Maximum Device
Dimensions
9.5"H x 1"W x 9"D (24.13 cm x 2.54 x 22.86 cm)
Basket Dimensions 1"W x 9"D
Laminate Top No
Shipping Carton
Dimensions
51"H x 32"W x 32"D (129.5 x 81.3 x 81.3 cm)
Weight Capacity
on Top Surface
150 lb. (68.2 kg), stationary
Warranty Carts: Lifetime;
Electronics: 3 years
Page 9
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 1: Specifications
Top
Right side
Page 10
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 1: Specifications
Dimensional Diagrams
Front closed Front open
Page 11
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 2: Overview
2. Overview
2.1 Introduction
The 36-Device iPad and Chromebook Basic Charging Cart is designed to store,
charge, and transport tablets, e-readers, laptops, netbooks, and other similar devices.
The Cart has 36 storage slots (three shelves with 12 storage slots on each shelf).
Each unit plugs into a typical 120-volt 15-amp outlet. Both VLC36SK-HD and
VLC36SK-WP have standard 5-15P and 5-15R plugs and outlets, and the VLC36SKWP accommodates oversize wall transformers. The cart has locking solid-steel doors.
Please read these operating instructions carefully. They contain important advice
concerning the use and safety of your cart. This Cart must only be used for its
intended purpose in accordance with these operating instructions.
2.2 What‘s Included
• 36-Device iPad and Chromebook Charging Cart; assembled
• Heavy-duty 3" casters (installed), including: (2) locking swivel casters and
(2) non-locking fixed casters
•
(3) 12-outlet, 15 A max. p
ower distribution units, PDUs (installed)
• This user‘s manual
• (2) sets of keys
Page 12
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 2: Overview
This user manual/installation guide can be downloaded from the Black Box Web
site.
To download from the Web site:
1. Go to www.blackbox.com
2. Enter the part number (for example, VLC36SK-HD or VLCSK-36SK-WP) in the
search box:
3. Click on the “Resources” tab on the product page, and select the document
you wish to download.
If you have any trouble accessing the Black Box site to download the manual, you
can contact our Technical Support at 877-877-2269 or info@blackbox.com.
Page 13
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 2: Overview
2.3 Hardware Description
Split front
door
Locking Swivel
Casters
Non-locking
Casters
Removable
Rear Door
Handle
Figure 2-1. Front and back of cart.
Page 14
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 3: Using the Intelligent Charging System Module
3. Using the Intelligent Charging System (-ILC at end of product code)
The Intelligent Charging System Module arrives installed in your cabinet.
3.1 Display Tour
Charging
Port LEDs
USB Port
Manage
Button
LED Display
Reset Button
Power
Icon
Charge
Button
AUX Button
Figure 3-1. Front of SDILCU4.
Back
Power
Connector
Auxiliary
Outlet
Charging Ports
Figure 3-2. Back of SDILCU4.
Page 15
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 3: Using the Intelligent Charging System Module
3.2 To Begin Charging
• Connect to Power
• Select Charging Mode (Choose from Charge Mode or Manage Mode.)
CHARGE MODE: Best used if all devices are powered off and connected at the
same time. Power is discontinued when batteries reach full charge to conserve
energy.
MANAGE MODE: Best used if all or some devices are left on or are returned at
different times. Charging continues until it is
manually stopped.
NOTE: The charging system should always be in MANAGE mode in order to
charge iPads and devices that remain in sleep mode.
Page 16
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 3: Using the Intelligent Charging System Module
3.3 Basic Functions
Charge Button
Pressing the CHARGE button will start charge mode. This is best used when all
devices are powered down and returned to the cart at the same time. Charging
will automatically stop when all batteries are 100% charged. You can also stop
charging at any time by pressing the CHARGE button a second time.
Manage Button
Pressing MANAGE button will start manage mode and turn on the auxiliary
power. This mode will continuously monitor and distribute power until manually
stopped. This mode is best used if some of the devices may be left on when connected or if devices are connected at different times. Press the button again to
stop manage mode.
Auxiliary Power Button
Controls power to any peripherals that are plugged into the AUX power strip in
the back of the cart. If the AUX devices must be operational during charging then
the system must be in manage mode. Be aware that this may lengthen charging
time.
Page 17
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 3: Using the Intelligent Charging System Module
Charging Port LEDs
Indicates which sections of the cart are active. The charging unit controls this
automatically, ensuring that all devices inside are charged in the fastest, most efficient way possible. When all four quadrant LEDs are solid green, charging is complete.
Power Icon
Indicates when the cart is connected to power and is ready.
Reset Button
The Intelligent Charging System is protected with its own circuit breaker. If it
encounters misuse such as plugging in unsupported devices or if there is a power
surge, the circuit will trip and the reset button will pop out. To reset the cart simply press it back in. Please first ensure that everything is plugged in properly and
that only supported devices are connected before resetting.
Page 18
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 4: Basket Distribution System
4. Basket Distribution System
VLC carts with baskets (UCCBIN1KIT) instead of slots include:
• VLC36SK-BIN1-HD
• VLC36SK-BIN1-WP
The bins can also be ordered separately:
• UCCBIN1KIT
Figures 4-1 through 4-3 show the UCCBIN1KIT basket.
Figure 4-1. Baskets installed in cart.
Figure 4-2. Basket, side view.
Figure 4-3. Basket, top view.
Page 19
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 5: Using Your iPad and Chromebook Basic Charging Cart
5. Using Your iPad and Chromebook Basic Charging Cart
5.1 Charging Your Computers
• After the devices have been loaded into the Cart, plug the power cord of the Cart
into a suitable receptacle.
• Locate the power switches on the power strips of the Cart and push the switches
to the ON position.
5.2 Moving Your iPad and Chromebook Basic Charging Cart
• Turn OFF the power strips.
• Remove the Cart plug from the wall receptacle and wrap the cord around the cord
wrap or handle.
• Close and secure solid-steel doors.
• Your Cart comes equipped with two fixed casters and two locking swivel casters.
Unlock the casters before moving the Cart to a new location.
Locking caster
Figure 5-1. Locking caster on the cart.
• When you reach your desired destination, lock the casters to prevent the cart from
moving and plug the Cart into a wall receptacle.
Page 20
877-877-2269 | blackbox.com
VLC36SK-HD
Chapter 5: Using Your iPad and Chromebook Basic Charging Cart
5.3 Locking the Cart Doors
When the cart is not in use, you can lock the front and back doors of the cart for
security. Figure 5-2 shows the lock on the front of the cart.
Lock on
front door
Figure 5-2. Lock on the front door of the cart.
Page 21
877-877-2269 | blackbox.com
VLC36SK-HD
FCC and IC RFI Statements
FEDERAL COMMUNICATIONS COMMISSION AND
INDUSTRY CANADA RADIO FREQUENCY INTERFERENCE STATEMENTS
This equipment generates, uses, and can radiate radio-frequency energy,
and if not installed and used properly, that is, in strict accordance with the
manufacturer’s instructions, may cause inter ference to radio communication.
It has been tested and found to comply with the limits for a Class A computing
device in accordance with the specifications in Subpart B of Part 15 of FCC rules,
which are designed to provide reasonable protection against such interference
when the equipment is operated in a commercial environment. Operation of
this equipment in a residential area is likely to cause interference, in which case
the user at his own expense will be required to take whatever measures may be
necessary to correct the interference.
Changes or modifications not expressly approved by the party responsible
for compliance could void the user’s authority to operate the equipment.
This digital apparatus does not exceed the Class A limits for radio noise
emis sion from digital apparatus set out in the Radio Interference Regulation
of Industry Canada.
Le présent appareil numérique n’émet pas de bruits radioélectriques dépassant les
limites applicables aux appareils numériques de la classe A prescrites dans le
Règlement sur le brouillage radioélectrique publié par Industrie Canada.
Page 22
877-877-2269 | blackbox.com
VLC36SK-HD
NOM Statement
Normas Oficiales Mexicanas (NOM)
Electrical Safety Statement
INSTRUCCIONES DE SEGURIDAD
1. Todas las instrucciones de seguridad y operación deberán ser leídas antes
de que el aparato eléctrico sea operado.
2. Las instrucciones de seguridad y operación deberán ser guardadas para
referencia futura.
3. Todas las advertencias en el aparato eléctrico y en sus instrucciones de
operación deben ser respetadas.
4. Todas las instrucciones de operación y uso deben ser seguidas.
5. El aparato eléctrico no deberá ser usado cerca del agua—por ejemplo,
cerca de la tina de baño, lavabo, sótano mojado o cerca de una alberca,
etc.
6. El aparato eléctrico debe ser usado únicamente con carritos o pedestales
que sean recomendados por el fabricante.
7. El aparato eléctrico debe ser montado a la pared o al techo sólo como sea
recomendado por el fabricante.
8. Servicio—El usuario no debe intentar dar servicio al equipo eléctrico más allá
lo descrito en las instrucciones de operación. Todo otro servicio deberá ser
referido a personal de servicio calificado.
9. El aparato eléctrico debe ser situado de tal manera que su posición no
interfiera su uso. La colocación del aparato eléctrico sobre una cama, sofá,
alfombra o superficie similar puede bloquea la ventilación, no se debe
colocar en libreros o gabinetes que impidan el flujo de aire por los orificios
de ventilación.
10. El equipo eléctrico deber ser situado fuera del alcance de fuentes de calor
como radiadores, registros de calor, estufas u otros aparatos (incluyendo
amplificadores) que producen calor.
11. El aparato eléctrico deberá ser connectado a una fuente de poder sólo del
tipo descrito en el instructivo de operación, o como se indique en el
aparato.
Page 23
877-877-2269 | blackbox.com
VLC36SK-HD
NOM Statement
12. Precaución debe ser tomada de tal manera que la tierra fisica y la
polarización del equipo no sea eliminada.
13. Los cables de la fuente de poder deben ser guiados de tal manera que no
sean pisados ni pellizcados por objetos colocados sobre o contra ellos,
poniendo particular atención a los contactos y receptáculos donde salen
del aparato.
14. El equipo eléctrico debe ser limpiado únicamente de acuerdo a las
recomendaciones del fabricante.
15. En caso de existir, una antena externa deberá ser localizada lejos de las
lineas de energia.
16. El cable de corriente deberá ser desconectado del cuando el equipo no sea
usado por un largo periodo de tiempo.
17. Cuidado debe ser tomado de tal manera que objectos liquidos no sean
derramados sobre la cubierta u orificios de ventilación.
18. Servicio por personal calificado deberá ser provisto cuando:
A: El cable de poder o el contacto ha sido dañado; u
B: Objectos han caído o líquido ha sido derramado dentro del aparato; o
C: El aparato ha sido expuesto a la lluvia; o
D: El aparato parece no operar normalmente o muestra un cambio en su
desempeño; o
E: El aparato ha sido tirado o su cubierta ha sido dañada.
Black Box Tech Support: FREE! Live. 24/7.
Tech support the
way it should be.
Great tech support is just 60 seconds away at
877-877-2269 or blackbox.com.
877-877-2269 | blackbox.com
About Black Box
Black Box Network Services is your source for an extensive range of networking
and infrastructure products. You’ll find everything from cabinets and racks and
power and surge protection products to media converters and Ethernet switches
all supported by free, live 24/7 Tech support available in 60 seconds or less.
© Copyright 2016. Black Box Corporation. All rights reserved.
VLC36SK-HD_VLC36SK-WP user manual, version 2
Loading...