Betco 1941200 User Manual
Extreme Ultra
Not available.
Liquid.
Chemtrec (800) 424-9300 24 hour
SAFETY DATA SHEET
GHS product identifier
Other means of
identification
Product type
Emergency telephone
number (with hours of
operation)
Section 1. Identification
:::
:
Supplier's details
: Betco Corporation
Extreme Ultra
Relevant identified uses of the substance or mixture and uses advised against
Not applicable.
Section 2. Hazards identification
ACUTE TOXICITY (oral) - Category 4
SKIN CORROSION - Category 1
SERIOUS EYE DAMAGE - Category 1
Classification of the
substance or mixture
:
Signal word
:
Danger
Hazard statements
:
Harmful if swallowed.
Causes severe skin burns and eye damage.
Hazard pictograms
:
Precautionary statements
Prevention
:
Wear protective gloves: > 8 hours (breakthrough time): butyl rubber. Wear eye or face
protection: Recommended: splash goggles. Wear protective clothing: Recommended:
safety apron. Do not eat, drink or smoke when using this product. Wash hands
thoroughly after handling.
Response
:
IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Immediately call a POISON CENTER or physician. IF SWALLOWED: Immediately call
a POISON CENTER or physician. Rinse mouth. Do NOT induce vomiting. IF ON
SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water or
shower. Wash contaminated clothing before reuse. Immediately call a POISON
CENTER or physician. IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a
POISON CENTER or physician.
Storage
:
Store locked up.
Disposal
:
Dispose of contents and container in accordance with all local, regional, national and
international regulations.
GHS label elements
OSHA/HCS status
:
This material is considered hazardous by the OSHA Hazard Communication Standard
(29 CFR 1910.1200).
Hazards not otherwise
classified
:
None known.
Date of issue/Date of revision
:
6/7/2017
Date of previous issue
:
2/8/2017
Version
:31/13
400 Van Camp Road
Bowling Green, Ohio 43402
www.betco.com
888-462-3826
Extreme Ultra
Section 3. Composition/information on ingredients
benzyl alcohol
≥50 - <75
100-51-6
2-butoxyethanol
≥10 - <25
111-76-2
Monoethanolamine
≥10 - <20
141-43-5
4-Nonylphenol, branched, ethoxylated
≥3 - <5
127087-87-0
Fatty acids, tall-oil, compds. with ethanolamine
≥1 - <3
68132-47-8
Ingredient name
CAS number
%
There are no additional ingredients present which, within the current knowledge of the supplier and in the
concentrations applicable, are classified as hazardous to health or the environment and hence require reporting
in this section.
Other means of
identification
:
Not available.
CAS number
:
Not applicable.
Substance/mixture
Product code
:
194
CAS number/other identifiers
:
Occupational exposure limits, if available, are listed in Section 8.
Mixture
Any concentration shown as a range is to protect confidentiality or is due to batch variation.
Get medical attention immediately. Call a poison center or physician. Wash out mouth
with water. Remove dentures if any. Remove victim to fresh air and keep at rest in a
position comfortable for breathing. If material has been swallowed and the exposed
person is conscious, give small quantities of water to drink. Stop if the exposed person
feels sick as vomiting may be dangerous. Do not induce vomiting unless directed to do
so by medical personnel. If vomiting occurs, the head should be kept low so that vomit
does not enter the lungs. Chemical burns must be treated promptly by a physician.
Never give anything by mouth to an unconscious person. If unconscious, place in
recovery position and get medical attention immediately. Maintain an open airway.
Loosen tight clothing such as a collar, tie, belt or waistband.
Get medical attention immediately. Call a poison center or physician. Immediately flush
eyes with plenty of water, occasionally lifting the upper and lower eyelids. Check for and
remove any contact lenses. Continue to rinse for at least 10 minutes. Chemical burns
must be treated promptly by a physician.
Get medical attention immediately. Call a poison center or physician. Flush
contaminated skin with plenty of water. Remove contaminated clothing and shoes.
Wash contaminated clothing thoroughly with water before removing it, or wear gloves.
Continue to rinse for at least 10 minutes. Chemical burns must be treated promptly by a
physician. Wash clothing before reuse. Clean shoes thoroughly before reuse.
Get medical attention immediately. Call a poison center or physician. Remove victim to
fresh air and keep at rest in a position comfortable for breathing. If it is suspected that
fumes are still present, the rescuer should wear an appropriate mask or self-contained
breathing apparatus. If not breathing, if breathing is irregular or if respiratory arrest
occurs, provide artificial respiration or oxygen by trained personnel. It may be
dangerous to the person providing aid to give mouth-to-mouth resuscitation. If
unconscious, place in recovery position and get medical attention immediately. Maintain
an open airway. Loosen tight clothing such as a collar, tie, belt or waistband. In case of
inhalation of decomposition products in a fire, symptoms may be delayed. The exposed
person may need to be kept under medical surveillance for 48 hours.
Section 4. First aid measures
Eye contact
Skin contact
Inhalation
Ingestion
:
:
:
:
Description of necessary first aid measures
Most important symptoms/effects, acute and delayed
Inhalation
:
No known significant effects or critical hazards.
Skin contact
:
Causes severe burns.
Causes serious eye damage.
:
Eye contact
Potential acute health effects
Date of issue/Date of revision
:
6/7/2017
Date of previous issue
:
2/8/2017
Version
:32/13
Extreme Ultra
Section 4. First aid measures
Protection of first-aiders
:
No action shall be taken involving any personal risk or without suitable training. If it is
suspected that fumes are still present, the rescuer should wear an appropriate mask or
self-contained breathing apparatus. It may be dangerous to the person providing aid to
give mouth-to-mouth resuscitation. Wash contaminated clothing thoroughly with water
before removing it, or wear gloves.
Notes to physician
:
In case of inhalation of decomposition products in a fire, symptoms may be delayed.
The exposed person may need to be kept under medical surveillance for 48 hours.
Specific treatments
:
No specific treatment.
Harmful if swallowed.
:
Ingestion
Over-exposure signs/symptoms
Skin contact
Ingestion
Inhalation
No specific data.
Adverse symptoms may include the following:
stomach pains
Adverse symptoms may include the following:
pain or irritation
redness
blistering may occur
:
:
:
Eye contact
:
Adverse symptoms may include the following:
pain
watering
redness
See toxicological information (Section 11)
Indication of immediate medical attention and special treatment needed, if necessary
Section 5. Fire-fighting measures
Promptly isolate the scene by removing all persons from the vicinity of the incident if
there is a fire. No action shall be taken involving any personal risk or without suitable
training.
Hazardous thermal
decomposition products
Specific hazards arising
from the chemical
Decomposition products may include the following materials:
carbon dioxide
carbon monoxide
nitrogen oxides
In a fire or if heated, a pressure increase will occur and the container may burst.
Fire-fighters should wear appropriate protective equipment and self-contained breathing
apparatus (SCBA) with a full face-piece operated in positive pressure mode.
Special protective
equipment for fire-fighters
Use an extinguishing agent suitable for the surrounding fire.
Extinguishing media
:
:
:
None known.
Suitable extinguishing
media
:
Unsuitable extinguishing
media
:
Special protective actions
for fire-fighters
:
Section 6. Accidental release measures
Personal precautions, protective equipment and emergency procedures
:
No action shall be taken involving any personal risk or without suitable training.
Evacuate surrounding areas. Keep unnecessary and unprotected personnel from
entering. Do not touch or walk through spilled material. Do not breathe vapor or mist.
Provide adequate ventilation. Wear appropriate respirator when ventilation is
inadequate. Put on appropriate personal protective equipment.
For non-emergency
personnel
Date of issue/Date of revision
:
6/7/2017
Date of previous issue
:
2/8/2017
Version
:33/13
Extreme Ultra
Section 6. Accidental release measures
Environmental precautions
Stop leak if without risk. Move containers from spill area. Approach release from
upwind. Prevent entry into sewers, water courses, basements or confined areas. Wash
spillages into an effluent treatment plant or proceed as follows. Contain and collect
spillage with non-combustible, absorbent material e.g. sand, earth, vermiculite or
diatomaceous earth and place in container for disposal according to local regulations
(see Section 13). Dispose of via a licensed waste disposal contractor. Contaminated
absorbent material may pose the same hazard as the spilled product. Note: see
Section 1 for emergency contact information and Section 13 for waste disposal.
:
Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains
and sewers. Inform the relevant authorities if the product has caused environmental
pollution (sewers, waterways, soil or air).
Large spill
:
Stop leak if without risk. Move containers from spill area. Dilute with water and mop up
if water-soluble. Alternatively, or if water-insoluble, absorb with an inert dry material and
place in an appropriate waste disposal container. Dispose of via a licensed waste
disposal contractor.
Small spill
:
Methods and materials for containment and cleaning up
For emergency responders
:
If specialized clothing is required to deal with the spillage, take note of any information in
Section 8 on suitable and unsuitable materials. See also the information in "For nonemergency personnel".
Section 7. Handling and storage
Advice on general
occupational hygiene
Conditions for safe storage,
including any
incompatibilities
Eating, drinking and smoking should be prohibited in areas where this material is
handled, stored and processed. Workers should wash hands and face before eating,
drinking and smoking. Remove contaminated clothing and protective equipment before
entering eating areas. See also Section 8 for additional information on hygiene
measures.
Store in accordance with local regulations. Store in original container protected from
direct sunlight in a dry, cool and well-ventilated area, away from incompatible materials
(see Section 10) and food and drink. Store locked up. Separate from acids. Keep
container tightly closed and sealed until ready for use. Containers that have been
opened must be carefully resealed and kept upright to prevent leakage. Do not store in
unlabeled containers. Use appropriate containment to avoid environmental
contamination.
:
:
Protective measures
Put on appropriate personal protective equipment (see Section 8). Do not get in eyes or
on skin or clothing. Do not breathe vapor or mist. Do not ingest. If during normal use
the material presents a respiratory hazard, use only with adequate ventilation or wear
appropriate respirator. Keep in the original container or an approved alternative made
from a compatible material, kept tightly closed when not in use. Keep away from acids.
Empty containers retain product residue and can be hazardous. Do not reuse container.
:
Precautions for safe handling
benzyl alcohol
AIHA WEEL (United States, 10/2011).
TWA: 10 ppm 8 hours.
2-butoxyethanol
OSHA PEL 1989 (United States, 3/1989).
Absorbed through skin.
TWA: 25 ppm 8 hours.
TWA: 120 mg/m³ 8 hours.
NIOSH REL (United States, 10/2013).
Absorbed through skin.
TWA: 5 ppm 10 hours.
TWA: 24 mg/m³ 10 hours.
Section 8. Exposure controls/personal protection
Ingredient name
Exposure limits
Control parameters
Occupational exposure limits
Date of issue/Date of revision
:
6/7/2017
Date of previous issue
:
2/8/2017
Version
:34/13
Loading...