BE Pressure supply AC708RB User Manual
AC708RB
operation manual
CAUTION READ THIS MANUAL CAREFULLY before operating or servicing this
air compressor, to familiarize yourself with the proper safety, operation, and standard
operating procedures of this unit. FAILURE TO COMPLY WITH INSTRUCTIONS IN
THIS MANUAL COULD RESULT IN THE VOIDING OF YOUR WARRANTY, AND
PERSONAL INJURY, AND/OR PROPERTY DAMAGE. THE MANUFACTURER
OF THIS AIR COMPRESSOR WILL NOT BE LIABLE FOR ANY DAMAGE
BECAUSE OF FAILURE TO FOLLOW THE INSTRUCTIONS IN THIS MANUAL.
By following the instructions and recommendations in this manual you will ensure a
longer and safer service life of your air compressor.
table of contents
Introduction
4 Using the Operators Manual
Specifications
4 Specifications
Product Identification
5 Record Identification Numbers
Safety
6 Safety Instructions
7 Safety Rules
7 Hazard Symbols and Meanings
10 General Safety Information
Safety & Installation
11 Spraying Precautions
11 Hose Precautions
11 Installation and Location
11 Extension Cords
Assembly Instructions
12 Assembly
Product Features
13 Automatic ON/OFF
13 Regulator
13 Tank Pressure Gauge
13 Safety Valve
13 Tank Drain Fitting
13 Safety Guard
2
table of contents
Operating Instructions
14 Initial Start Up
14 Start Up
14 Storage
14 Shut Down
Maintenance
15 When performing any maintenance or service
15 Daily
15 Weekly
15 Monthly
15 Six Months or 250 Operating Hours
15 Oil Change
Troubleshooting
16 Troubleshooting Chart
Parts List
17 Parts Diagram
17 Parts List
19 Pump Parts Diagram
20 Pump Parts List
3
introduction
Attention: Read through the complete manual
prior to the initial use of your compressor.
Using the Operator’s manual
Thank you for choosing our compressor. The manual gives information
with respect to operation and maintenance of the Compressor and be
sure to read it carefully first before operation.
Following the manual can ensure the user’s safety and get the best
results from the compressor. All information and diagrams in this manual
are in accordance with the newest products at the publishing time. We
strive for accuracy and this manual is accurate for the models described
at the time of printing. We reserve the right to make improvements or
changes at any time without notice or obligation.
Please keep this manual with the engine permanently, even if the engine
ownership is transferred.
Specifications
SPECIFICATIONS AC708RB
· 8 Gallon = 2 x 4 Tank Design
· Oil Lubricated for Extended Durability
· 210cc, 4 stroke, OHV gas engine
· Air Delivery: 13.8 CFM output @ 90 PSI and 12.7 CFM output @ 100 PSI
· Maximum Pressure: 125 PSI
· High Flow regulator and Dual Pressure Gauges for Precision Air Flow
Control
4
product identification
Record Identification Numbers
COMPRESSOR
If you need to contact an Authorized Dealer or Customer Service line
(1-866-850-6662) for information on servicing, always provide the
product model and identification numbers.
You will need to locate the model and serial number for the machine and
record the information in the places provided below.
Date of Purchase:
Dealer Name:
Dealer Phone:
Product Identification Numbers
Model Number:
Serial Number:
5
safety
Safety Instructions
· Carefully read through the entire owners manual before operating this
compressor.
· Keep manual with important records for safety instructions, operating
procedures and warranty.
· After unpacking your new air compressor, please inspect it carefully for
any damage that may have occurred during transit.
· Do not operate this air compressor if damaged during shipment,
handling or misuse.
· Damage may result in bursting, which can cause serious injury or
property damage.
· All damaged parts must be repaired or replaced as needed prior to
operating this air compressor.
· Check to see that all nuts, bolts and fittings are secure.
· Check to see that the proper lubrication oil, which has been included
with the air compressor, is used to fill the compressor crankcase to the
proper level.
· Please contact our customer service department at the numbers listed
on the back of this instruction manual for any questions or comments
regarding this air compressor.
6
safety
Save these Instructions
SAFETY RULES
This is the safety alert symbol. It is used to alert
you to potential personal injury hazards. Obey
all safety messages that follow this symbol to
avoid possible injury or death.
The safety alert symbol ( ) is used with a signal word (DANGER,
CAUTION, WARNING), a pictorial and/or a safety message to alert
you to hazards.
DANGER indicates a hazard which, if not avoided, will result in death
or serious injury.
WARNING indicates a hazard which, if not avoided, could result in
death or serious injury.
CAUTION indicates a hazard which, if not avoided, might result in
minor or moderate injury.
NOTICE indicates a situation that could result in equipment damage.
Follow safety messages to avoid or reduce the risk of injury or
death.
HAZARD SYMBOLS AND MEANINGS
explosion
kickback
fall fluid
fire electric
hot
surface wear eye
injection moving parts read manual
shock toxic fumes
slippery
protection
7
safety
WARNING
AIR TANK WARNING: Drain liquid from air tank daily,
or after each use, using the drain valve located on the
bottom of the lower air tank. Failure to properly drain
liquid from the tank will cause rust from moisture buildup, which weakens the tank and could lead to a violent
tank explosion, Periodically inspect the tanks for unsafe
conditions such as corrosion.
Never attempt to repair or make modifications to the tank or its attachments. Welding, drilling or any other modifications may weaken
the tank, which may result in damage from rupture or explosion. Never
remove or attempt to adjust the pressure switch, safety valve, or other
factory set operating pressures.
WARNING
FIRE WARNING: Avoid dangerous environments. Do
not use compressor near gasoline or other flammable
materials. Keep work area well lit. Normal sparking of
a motor or sparking from grinding metal could ignite
fumes. Do not spray flammable materials in the vicinity
of an open flame or other ignition source, including the
air compressor itself. Do not direct paint or other spray
material towards the compressor.
Read and follow all safely instructions for the material you are spraying. Be sure to use an approved respirator designed for use with your
specific application.
WARNING
BREATHABLE AIR WARNING: This air compressor in
not designed, nor intended for the supply of breathable
quality air. Air produced by this unit may contain carbon
monoxide or other toxic vapors.
Do not inhale air from the compressor or from a breathing device connected to it.
8
Loading...