SKY5024 + SKY5025
Ver. 1
INSTRUCTION
MANUAL
Ride-On Jeep with Dual Seats
bestchoiceproducts.com
Charge for 15-18 hrs
before initial use.
After initial charge,
follow the normal
recommended
charging time.
Pg. 3
Please retain these instructions for future reference.
SAFETY
BATTERY WARNINGS
This vehicle must be assembled by an adult who has read and understood the instructions in this manual.
Keep the packaging and bags away from children and dispose of all packaging before use. Always use
common sense and safe practices when operating this vehicle. This product contains or emits chemicals
known in the state of California to cause cancer or birth defects or other reproductive harm.
NOTE: For best performance, only use this vehicle on flat and hard surfaces.
Age Range: 3 to 8 years old
Weight Capacity: 130 lbs. (combined)
The following safety hazards may result in serious injury or death:
• This product contains small parts. Keep children away during assembly. Make sure to remove all
packaging material and parts from underneath the vehicle body.
• Never open the battery. Batteries contain lead and lead compounds (acids) that are toxic and corrosive,
and known to the state of California to cause cancer and reproductive harm.
• Limbs, hair, and clothing can get caught in moving parts. Always wear shoes, keep limbs away from
moving parts, and do not wear loose clothing while operating this vehicle.
• This vehicle does not have brakes or braking capability. Do not leave a child unattended during
operation. Do not use this in a location that may require braking capability, as this could result in loss
of control, which may cause serious injury or death.
• Use of this vehicle near streets, motor vehicles, steps, bodies of water, sloped surfaces, hills, wet areas,
flammable vapors, in alleys, at night, or in the dark could result in an unexpected accident.
• Use of this vehicle in unsafe conditions such as snow, rain, loose dirt, mud, sand, or gravel may result in
an unexpected accident such as tipping over, and could damage the electrical system or battery.
• Do not operate this vehicle in an unsafe manner. Examples include but are not limited to:
- Pulling the vehicle with another vehicle or similar device
- Allowing more than two children to ride
- Pushing the user
- Traveling at an unsafe speed
The following safety hazards may result in serious injury or death:
• Use of a battery or charger other than the supplied rechargeable battery and charger may cause a fire
or explosion. Only use the supplied battery and charger.
• Use of the rechargeable battery and charger for any other product may result in overheating, fire,
or explosion. Never use the supplied rechargeable battery and charger with another product.
• Explosive gases are created during charging. Charge the battery in a well-ventilated area. Do not charge
the battery near heat or flammable materials.
• Contact between the positive and negative terminals may result in fire or explosion. Avoid direct contact
between the terminals. Picking up the battery by the wires or charger can cause damage to the battery
and may result in a fire. Always pick up the battery by its case or handles.
• Liquids on the battery may cause fire or electric shock. Always keep all liquids away from the battery
and keep the battery dry. Contact or exposure to battery leakage (lead acid) may cause serious injury.
If contact or exposure occurs immediately call your physician. If the chemical is on the skin or in the
eyes, flush with cool water for 15 minutes. If the chemical was swallowed, immediately give the person
water or milk. Do not give water or milk if the patient is vomiting or has a decreased level of alertness.
Do not induce vomiting.
• Battery posts, terminals, and related accessories contain lead and lead compounds (acid) – chemicals
known to the State of California to cause cancer, reproductive harm, and are toxic and corrosive. Never
open the battery.
• Tampering or modifying the electric circuit system may cause a shock, fire or explosion and permanently
damage the system. Exposed wiring and circuitry in the charger may cause electric shock. Always keep
the charger housing closed.
Pg. 4
USER WARNINGS
SPECIFICATIONS
The following safety hazards may result in serious injury or death:
• Never leave a child unattended.
• Always sit in the seat when using this vehicle.
• Keep your hands, hair, and clothes away from moving parts.
• Always wear shoes when operating this vehicle.
• Maximum of two children are allowed in the vehicle at a time
• Children under 3 years of age cannot use the vehicle.
• Only drive on level ground.
• Do not go near swimming pools or other bodies of water, drop-os, or up and down steep inclines.
• Do not drive the vehicle into loose dirt, mud, sand, fine gravel, or on wet surfaces.
• Do not drive the vehicle on streets or near cars.
Overall Dimensions
Weight
Weight Capacity
Age Range
Max Speed
Charging Time
Run Time
Battery Type
Electric Motor
Charger
Material
60"(L) x 35.5"(W) x 30"(H)
70.5 lbs.
130 lbs. (combined)
3 – 8 years old
Low: 1.4 mph., High: 2.2 mph.
8 – 12 hours
Initial Charge Time 15 – 18 hours
1 – 2 hours
1 - Rechargeable SLA - 12V 10AH
Double drive: 12V
Output: DC 12V
PP Plastic, Metal
Pg. 5
130 LBS
CAPACITY
(COMBINED)
LBS
APPROXIMATELY
75 MIN.
ASSEMBLY
2 PERSON
ASSEMBLY
TOOLS REQUIRED
PARTS
4 AAA BATTERIES
(FOR REMOTE/
STEERING WHEEL)
+
AAA
-
2 M10 SPANNERS
(PROVIDED)
PHILLIPS HEAD
SCREWDRIVER
HARDWARE
1
38 PCS
SCREW
2
2 PCS
WASHER
3
2 PCS
PIN
1 PC
FRONT BUMPER
1 SET 1 SET
FRONT SIDE
BUMPER (L/R)
2 PCS
FRONT WHEEL
D
1 SET
REAR SIDE
BUMPER (L/R)
A
B
FE
1 PC
REAR BUMPER
1 SET
GEAR BOX (L/R)
G
2 PCS
REAR WHEEL
IH
4 PCS
HUB CAP
STEP (L/R)
C
Pg. 6
PARTS
1 PC
REAR AXLE
1 PC 1 PC
WINDSHIELD/
DASHBOARD
2 PCS
SEAT
M
1 PC
STEERING WHEEL
J
K
O
N
1 SET
SIDE MIRRORS (L/R)
STEERING ROD
L
1 SET
SIDE FRAME (L/R)
1 PC 1 PC
MIDDLE FRAME
S
1 PC
REMOTE CONTROL
P
Q
12V CHARGER
R
Attach two part B front side bumpers
with eight part 1 screws.
Attach two part D rear side bumpers
with eight part 1 screws.
Attach two part C steps with six part 1 screws.
Attach part E rear bumper with seven part 1 screws.
NOTE: This step requires a total of 36 screws.
Flip the car over and lay it on a level surface. Attach the
part A front bumper with seven part 1 screws.
Pg. 7
PRODUCT ASSEMBLY
1
x6
x16
x7
E
DD
C
C
B
A
B
1
1
1
x7
1
Pg. 8
PRODUCT ASSEMBLY
Remove the nuts/washers from the part J rear axle, then slide in the axle.
Slide a part I gear box onto the axle and route the wires from the gear box through the body of the car
and into the seat.
Slide on a part G rear wheel and replace the nut/washer to secure the wheel. Repeat on the other side.
Snap on two part H hub caps.
Remove the nuts/washers from the front axle.
Slide a washer and part F front wheel onto the axle, then replace
the nut/washer to secure the wheel. Repeat on the other side.
Snap on two part H hub caps.
2
3
Use the provided
plastic spanner to
tighten the nuts.
R L
B
F F
G G
H
H H
H
I
I
J
Open car doors to install the part K windshield/dashboard.
Join the connectors to the corresponding
connectors from the vehicle.
Place the windshield/dashboard and
secure it with two part 1 screws.
Pg. 9
TOOLS REQUIREDPRODUCT ASSEMBLY
4
K
1
x2
Pg. 10
Flip the car onto its wheels. Under the dashboard, slide a washer
onto the steering rod and secure it with a pin. Insert the steering
rod into the steering mount.
Install 2 AAA batteries in the part M steering wheel.
Remove the nut and bolt from the steering wheel, slide it onto
the steering mount, and then replace the nut and bolt to secure
the steering wheel.
Flip the car on its side. Slide the part L steering rod into the steering gear box.
Hook the top onto the tab on the front axle and secure it with a part 2 washer and part 3 pin.
NOTE: Angle the steering rod while inserting it into the steering gear box.
5
PRODUCT ASSEMBLY
UNDERNEATH CAR
UNDER DASHBOARD
2
2
3
3
M
L
Pg. 11
PRODUCT ASSEMBLY
6
7
Within the seat, join the connectors from the gear boxes to the corresponding connectors,
then connect the gear boxes to the battery.
Insert the set of part N side mirrors (L/R).
N
I
I
Pg. 12
PRODUCT ASSEMBLY
8
9
x2
O
P
Q
LOCK UNLOCK
Install two part O seats by hooking them onto the car,
then secure them by turning the built-in locks.
Assemble the rear frame with
the part P side frame set and
part Q middle frame.
Insert the rear frame.
Pg. 13
CHARGING INSTRUCTIONS
• The charging port is located underneath the seat. Remove the driver’s seat and disconnect the
connector from the battery. Join the connector from the part R charger to the battery and plug
the other end into a wall outlet.
• Charge the battery 15 to 18 hours before initial use.
• On average, you will need to charge the battery between 8 and 12 hours. Do not charge the
battery for more than 20 hours. Failure to charge the battery as directed could cause permanent
damage to the battery and void the warranty.
• Damage to the battery may occur if it is allowed to drain completely. Do not allow the battery to
drain completely.
• Check the battery and charger (supply cord, connector) for wear and damage before charging.
Do not charge the battery if damage has occurred.
• Only an adult who has read and understood the safety warnings should handle, charge and
recharge the battery.
R
Pg. 14
REMOTE CONTROL DIAGRAM
LED LIGHT
TURN RIGHT
TURN LEFT
REVERSE
/CONNECT
FORWARD
PARK
TOGGLE SPEED
• Insert 2 AAA batteries into the remote control
• After 10 seconds of non-operation, the remote will go into power-saving mode.
Linking the remote control:
1. Press and hold the reverse button for 2 to 4 seconds. The light will flash.
2. Turn the vehicle on. The light will turn solid to indicate a successful link.
3. If the light continues to flash (indicating an unsuccessful link), remove and reinsert the batteries and
repeat steps 1 and 2.
DASHBOARD DIAGRAM
• Push down on the pedal to drive forward/reverse. Release the pedal to slow down and stop.
POWER SWITCH FORWARD/REVERSE
HIGH/LOW SPEED
REMOTE/
MANUAL CONTROL
HORN ENGINE SOUNDS
LIGHTS
This device complies with part 15 of the FCC rules. Operation is subject to the following two conditions: (1)
This product may not cause harmful interference, and (2) this device must accept any interference
received, including interference that may cause undesired operation.
NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against
harmful interference in a residential installation.
This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in
accordance with the instructions, may cause harmful interference to radio communications. However, there
is no guarantee that interference will not occur in a particular installation.
If this equipment does cause harmful interference to radio or television reception, which can be determined
by turning the equipment o and on, the user is encouraged to try to correct the interference by one or
more of the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment to an outlet on a circuit dierent from that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.
WARNING: Any changes or modifications to this unit not expressly approved by the party responsible for
compliance could void the user's authority to operate the equipment.
Responsible party (contact for FCC matters only):
Quality Control Dept.
5642 Ontario Mills Parkway
Ontario, CA 91764
FCC COMPLIANCE STATEMENT
TROUBLESHOOTING
REASON
Low battery
Electrical protection
Switch not in the correct position
Battery connectors disconnected
Low battery
Overloaded vehicle
Uneven or sloped road
Loose connection to motor
Battery connectors disconnected
Charger not connected
to socket or outlet
Battery does not have a full charge
Normal
PROBLEM
Battery is warm and
makes a slight noise
while charging
Slow speed
Vehicles shakes
while driving
Battery does not last
Battery does not recharge
Vehicle does not move
SOLUTION
Fully charge the battery
Stop use for several minutes and restart
Completely press in switches
Plug in battery connectors
Fully charge the battery
Reduce the weight on the vehicle
Drive on flat pavement
Ensure the motor is properly
connected to the battery
Plug in battery connectors
Completely plug in the charger
Fully charge the battery
Normal
Diculty shifting between
forward/reverse
Only shift when the vehicle is at a stop
Forward and reverse
switch is flipped
Make sure the L gear box is on the left
and R gear box is on the right
Attempting to shift while
vehicle in motion
Gear boxes are
installed incorrectly
Pg. 15
All items can be returned for any reason within 60 days of the receipt and will receive a full refund as long as the
item is returned in its original product packaging and all accessories from its original shipment are included. All
returned items will receive a full refund back to the original payment method. All returned items will not be charged
a re-stocking fee.
All returned items require an RA (Return Authorization) number, which can only be provided by a Best Choice
Products Customer Service Representative when the return request is submitted. Items received without an RA
may not be accepted or may increase your return processing time. Once an item has been received by Best Choice
Products, refunds or replacements will be processed within 5 business days.
All returns must be shipped back to the Best Choice Products Return Center at the customer’s expense. If the
reason for return is a result of an error by Best Choice Products then Best Choice Products will provide a pre-paid
shipping label via email. Boxes for return shipping will not be provided by Best Choice Products, and is the
customer’s responsibility to either use the original shipping boxes or purchase new boxes.
Pictures may be required for some returns to ensure an item is not damaged prior to its return. Items returned are
not considered undamaged until they are received by Best Choice Products and verified as such. All damages to
items are the customer’s responsibility until the item has been received by and acknowledge by Best Choice
Products as undamaged.
CONTACT US; WE’RE HERE 7 DAYS A WEEK TO HELP YOU!
WARNING
Manufacturer and seller expressly disclaim any and all liability for personal injury, property damage or
loss, whether direct, indirect, or incidental, resulting from the incorrect attachment, improper use,
inadequate maintenance, or neglect of this product.
PRODUCT WARRANTY INFORMATION
bestchoiceproducts.com customerservice@
bestchoiceproducts.com
844.948.8400
LEARN MORE!
CARING FOR YOUR RIDE-ON
• Park the vehicle indoors or cover it with a tarp to protect it from wet weather.
• Do not leave the vehicle in the sun for long periods of time or fading may occur.
Store in shade or cover with tarp.
• Do not wash the vehicle with a hose.
• Do not wash the vehicle with soap.
• Charge battery at least once a month to prolong the life of the battery.
Loading...