BBQTek SQ200 Owner's Manual
SQ200
Owner’s Manual
1
Portable Gas Barbecue Grill
WARNING
Im
p
roper
installation, adjustment,
alteration, se
r
vice or maintenance
can cause in
jur
y
or propert
y
damage.
Read the installation, o
per
ation
and maintenance instructions
thorou
g
hlybefore installingo
r
servicingthis equipment.
DANGER
Failure to follow these
instructions could result in fire
o
r
explosion that could cause
property damage, personal
injury or death.
DANGER
DO NOT use gas grill for indoor
cooking or heating. TOXIC fumes
can accumulate and cause
asphyxiation. DO NOT usein or on
boats or recreational vehicles.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(Outside any enclosure)
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
IF YOU ARE ASSEMBLING THIS UNIT FOR SOMEONE
ELSE, GIVE THIS MANUAL TO HIM OR HER TO SAVE FOR
FUTURE REFERENCE.
FOR CUSTOMER SERVICE：
CALL 1-877-885-8227 (TOLL-FREE)
10:00 A.M. – 7:00 P.M. (EST), MONDAY-FRIDAY
E-MAIL: SERVICE@BBQTEK.COM
LOG ON: WWW.BBQTEK.COM
MODEL# SQ200
SQ200
Owner’s Manual
2
Grill Operation 1-2-3
Before Grilling
Step 1 Keep your grill a safe distance away from your property.*
Step 2 Always perform a Leak Test on all connections *
Step 3 Keep children away from the grill.
During Grilling
(To avoid tripping safety valves, please follow these instructions carefully.)
Step 1 First open lid and connect gas cylinder slowly.
Step 2 Use protective gloves when grill gets hot.
Step 3 Never leave a lit grill unattended.
After Grilling
Step 1 Always burn grill for 10-15 minutes to burn off food residues after use.
Step 2 Wait until the grill is completely cooled before closing lid.
Step 3 Clean up grease build-up to avoid grease fire, and cover your grill to prevent rust.
* Please refer to the owner’s manual for details.
NOTE: This grill must be used with propane gas only (propane gas cylinder not included).
Installer: Leave this manual with the consumer.
Consumer: Retain this manual for future reference.
WARNING
1. Do not store or use gasoline or
other flammable liquids or vapour
in the vicinity of this or any other
appliance.
2.
An LP cylinder not connected for
use shall not be stored in the
vi
cinity of this or any other
appliance.
3. Never refill disposable cylinder.
4. Never allow oil or grease to get
hotter than 400
℉
or 200℃.Ifthe
temperature exceeds 400
℉
(200℃) or if oil begins to smoke,
immediately turn the bur ner or
gas supply off.
DANGER
If you smell gas:
1. Turn off gas.
2. Extinguish any open flame.
3. Open lid.
4. Ifodor continues, keep away from
the appliance and immediately
call your gas supplier or your fire
department.
DANGER
1. Never operate this appliance
unattended.
2. Never operate this appliance within
10 ft (3 m) of any structure,
combustible material or other gas
cylinder.
3. Never operate this appliance within
25 ft (7.5 m) of any flammable liquid.
4. If a fire should occur, keep away from
the appliance an immediately call
your fire department. Do not attempt
to extinguish an oil or grease fire with
water.
Always read and understand the WARNINGS and INSTRUCTIONS that are contained in this manual before
attempting to use this gas barbecue grill to prevent possible bodily injury or property damage.
SQ200
Owner’s Manual
3
Table of Contents
For Your Safty ........................................................................................................4
Illustrated Part List.................................................................................................6
Assembly Instructions............................................................................................7
Operating Your Grill...............................................................................................9
Connecting Gas Cylinder......................................................................................9
Checking
for
Leaks
................................................................................................9
Lighting Your Grill
.................................................................................................10
Care and Maintenance..........................................................................................11
Troubleshooting...................................................................................................12
Warranty Program.................................................................................................13
SQ200
Owner’s Manual
4
For Your Safety
Dear Valued Customer,
Congratulations on your new barbecue grill purchase! You’ve made the right choice. In this manual, you will find
assembly instructions,suggestions for grilling and helpful hints, as well as guidelines for the safe operation, proper care
and use of your grill. Our expert staff strives to provide you with an easy-to-assemble product. Should you have any
questionsor problems with this product, please call our customer service department a t 1-877-885-8227 (10:00 am –
7:00 pm (EST), Monday through Friday.). You can also e-mail to service@bbqtek.com
NOTE:
The use and installation of this product must conform to local codes. In the absence of local codes, use the National
Fuel Gas Code, ANSI Z223.1/ NFPA54. Reference to Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA58;
or CSA B149.1, Natural Gas and Propane Installation Code
IMPORTANT NOTICE: READ ALL INSTRUCTIONS PRIOR TO ASSEMBLY AND USE.
SafetyFirst!
Read and understand all warnings and precautions prior to operating your grill.
W
ARNING
1.
Cylinders must be stored outdoors out of the reach of children and must not be stored in a building, garage or any other
enclosed area.
2. The use of alcohol, prescription or non-prescription drugs may impair an individual’s ability to properly
assemble or safely operate this appliance.
3. Always open the grill lid carefully and slowly as heat and steam trapped within the grill could cause severe burns.
4. Always place your grill on a hard and level surface far away from combustible materials and structures. An
asphalt or blacktop surface may not be acceptable for this purpose.
5. Do not leave a lit grill unattended.
6. Keep children and pets away from the grill at all times.
7. Do not use the grill in high winds.
8. This grill must be used with propane gas only (propane gas cylinder not included).
9. Do not attempt to attach this grill to the self-contained propane system of a camper
,
trailer, motor home or house.
10.
Do not use charcoal or lighter fluid.
11. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be constructed and marked in
accordance with the specifications for
LP-gas cylinder of the US Department of Transportation (DOT) or the National
Standard of Canada, CAN/CSA-B139.Cylinder, Spheres and Tubes for the Transportation of Dangerous Goods and
commission.
12. This outdoor gas appliance is not intended to be installed in or on recreation vehicles and/or boats.
13. Do not attempt to move the grill while it is lit.
14. Do not use the grill unless it is
COMPLETELY
assembled and all parts are securely fastened and tightened.
15. Keep combustible items and surfaces at least 6 feet away from the grill at all times. DO NOT use this gas grill or any gas
product under any overhead enclosure or near any unprotected combustible constructions.
16. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials,
gasoline and other flammable vapours and liquids.
17. Do not attempt to use or assemble with missing or damaged parts. Contact customer service for replacement part.
CAUTION ‐ Prevention of Burns
1. To avoid burns, do not touch metal parts of the grill until they have completely cooled for at least 45 minutes or unless
you are wearing protective gear such as pot holders, protective gloves or mittens.
2. Do not alter the grill in any manner.
3. Clean before each use. If there is evidence of abrasion, wear, cuts or leaks, the hose must be replaced prior to operation.
The replacement hose assembly should be in accordance with the manufacturer’s specifications.
4. Never keep a filled gas container in a hot car or car trunk. Heat will cause the gas pressure to increase, which could
open the relief valve and allow gas to escape.
Loading...