BBQTek GSF3016A Owner's Manual
GSF3016A
Owner’s Manual
0
4-Burner LP Gas Grill
Model# GSF3016A
WARNING
Improper installation,
adjustment, alteration, service or
maintenance can
cause injury or
proper ty damage.
Read the installation ,
operation and maintenance
instructions thoroughly before
installing or servicing
this
equipment.
DANGER
Failure to follow these
instructions could result
in
fire
or explo si o n that
could cause
property damage, personal
injury or death.
DANGER
DO NOT use gas grill for indoor
cooking or heating. TOXIC
fumes can accumulate and
cause asphyxiation. DO NOT
use in or on boats or
recreational
vehicles.
PROPOSITION 65 WARNING
Chemicals known to the State of
California to
cause cancer, birth
defects or other
reproductive
harm
are created by the
combustion of
propan
e.
WARNING
FOR YOUR SAFETY :
For Outdoor Use Only
(outside any enclosure)
SAVE THESE INSTRUCTIONS FOR FUTURE
REFERENCE. IF YOU ARE ASSEMBLING THIS
UNIT FOR SOMEONE ELSE, GIVE THIS
MANUAL TO HIM OR HER TO SAVE FOR
FUTURE REFERENCE.
FOR CUSTOMER SERVICE, EMAIL TO
SERVICE@BBQTEK.COM
OR
CALL 1-877-885-8225 (TOLL-FREE),
7:00 A.M. – 4:00 P.M.(PST), MONDAY-FRIDAY.
GSF3016A
Owner’s Manual
1
Grill Operation 1-2-3
Before Grilling,
Step 1 Keep your grill a safe distance away from your property.
Step 2 Always Perform a Leak Test on all connections and hoses.
Step 3 Keep children away from the grill.
During Grilling,
(To avoid tripping safety valves, please follow these instructions carefully!)
Step 1 First open lid and turn gas tank on slowly.
Step 2 Turn only one knob on at a time when lighting up the grill.
Step 3 Use protective gloves when grill gets hot.
Step 4 Never leave a lit grill unattended.
After Grilling,
Step 1 Always burn grill for 10-15 minutes to burn off food residues after use.
Step 2 Wait until the grill is completely cooled before closing lid.
Step 3 Clean up grease build-up to avoid grease fire and cover your grill to prevent rust.
Always read and understand the
WARNINGS
and
INSTRUCTIONS
that are contained in this manual before
attempting to use this gas barbecue grill to prevent possible bodily injury or property damage.
Always keep this manual for convenient future reference.
WARNING
1. Do not store or use gasoline or other
flammable liquids or vapor in the vicinity of
this or any other appliance.
2.
An LP cylinder not connected for use shall
not be stored in the vi
cinity of this or any
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the appliance
and immediately call your gas supplier or your fire
department.
GSF3016A
Owner’s Manual
2
Table of Contents
For Your Safety................................................................................................3
Illustrated Parts List ........................................................................................5
Hardware List....................................................................................................6
Assembly Instructions......................................................................................7
Operating Your Grill.........................................................................................13
Connecting Gas Cylinder.................................................................................13
Checking for Leaks..........................................................................................14
Lighting Your Grill............................................................................................14
Excess flow safety valve reset procedure.........................................................16
Rotisserie Operating Instruction.....................................................................17
Care and Maintenance......................................................................................18
Award-Winning Barbecue Recipes..................................................................20
Troubleshooting.................................................................................................21
Warranty Program.............................................................................................23
GSF3016A
Owner’s Manual
3
For Your Safety
Dear Valued Customer,
Congratulations on your new barbecue grill purchase! You’ve made the right choice. In this manual, you will find
assembly instruction s, suggestions for
grilling and helpful hints, as well as guidelines for the safe operation , proper
care
and use of your grill. Our expert staff strives to provide you with an easy-to-assemble product. Should you have
any
questions or problems with this product, please call our customer serv ice department at 1-877-885-8225
7:00 am –
4:00 pm (PST), Monday through Friday.
NOTE: The use and installation of this product must conform to local codes. In the absence of local codes, use the
National Fuel Gas Code, ANSI Z223.1/ NFPA54. Reference to Natural Gas and Propane Installation code CSA
B149.1 or Propane Storage and Handling code B149.2
IMPORTANT NOTICE: READ ALL INSTRUCTIONS PRIOR TO ASSEM BL Y AND USE
Safety First!
Read and understand all warnings and precautions prior to operating your grill.
WARNING
1.
This grill is for outside use only. It should not be used in a building, garage or any other enclosed area.
2.
The use of alcoh ol , pr es cr i p t io n or non-prescription drugs may impair an individual’s ability to properly
assemble or safely operate this appliance.
3.
Always open the grill lid carefully and slowly as heat and steam trapped within the grill could cause severe burns.
4.
Always place your grill on a hard and level surface far away from combustible materials and structures. An
asphalt or blacktop surface may not be acceptable for this purpose.
5.
Do not leave a lit grill unattended.
6. Keep childre n a nd pet s away from the grill at all times.
7.
This is not a tabletop grill. Do not place this grill on any type of tabletop surface.
8.
Do not use the grill in high winds.
9. This grill must be used
with propane gas only (propane gas cylinder not included).
10. Do not attempt to
attach this grill to the self-contained propane system of a camper, trailer, motor home or house.
1 1 . Do
not use charcoal or lighter fluid.
12 Do
not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be constructed and
marked
in
accordance with the specifications for propane gas cylinders of the U.S. Department of
Transportation (DOT) CFR
49.
13. This outdoor gas appliance is not intended to be installed in or on recreation vehicl es and/or boats.
14. Do
not attempt to move the grill while it is lit.
15. Do
not use the grill unless it is COMPLETELY
assembled and all parts are securely fastened and tightened.
16. Keep combustible items and surfaces at least 24 inches away
from the grill at all times. DO NOT use this gas grill
or any gas product under any overhead enclosure or near any unprotected combustible constructi ons.
17. Do not use in an
explosive atmosphere. Keep grill area clear and free from combustible ma terials,
gasoline and other flammable vapors and liquids.
18. Do not attempt to use or assemble with missing or damaged parts. Contact customer service for a replacement.
CAUTION-Prevention of Burns
1. To avoid burns, do not touch metal parts of the grill until they have completely cooled for at least 45 minutes
or
unless you are wearing protective gear such as pot holders, protective gloves or mittens.
2.
Do not alter the grill in any manner.
3.
Clean and inspect the hose before each use. If there is evid enc e of ab ras i on , wear, cuts or leaks, the hose must
be replaced prior to
operation. The replacement hose assembly should be in accordance with
the
manufacturer’s specifications.
4. Move gas hoses as far away as possible from hot surfaces and dripping hot grease.
5.
Never keep a filled gas container in a hot car or car trunk. Heat will cause the gas pressure to increase, which
could open the relief valve and allow gas to escape.
GSF3016A
Owner’s Manual
4
Safe Locations For Use Of This Outdoor Grill
DANGER
Never use this outdoor grill inside any building, garage, shed or breezeway, or inside any boat, trailer or recreational
vehicle to prevent a possible fire and to prevent the possibility of carbon monoxide poisoning or asphyxiation.
WARNINGS
Do not use this appliance under overhead combustible surface or covered area (e.g., awnings, umbrellas, porches or
gazeboes).
Always confirm that this grill is not positioned under the overhang of a house, a garage or other structure before lighting it.
An overhang will serve to deflect flare-ups and radiated heat into the structure itself, which could result in a fire.
Always confirm that this grill is positioned more than 6 feet ( 2 m ) away from any
building or combustible materials or surface before lighting it, and that no gasoline
or other volatile substances are stored in the vicinity of this grill.
(See diagram to right). The temperature of a grease fire or of the radiated heat
might otherwise be sufficient to ignite nearby combustible or volatile substances.
Always locate this grill where there will be ample combustion and ventilation air,
but never position it in the direct path of a strong wind.
Never allow the grill to operate while unattended to prevent uncontrolled
grease fires from erupting.
Never attempt to move this grill while it is in operation or while it is still hot to prevent possible personal injury.
Never store or use gasoline or other flammable or volatile substances in the vicinity of this grill or in the vicinity of any other
heat-generating appliance because of the danger of starting a fire.
Always confirm that the installation of this grill conforms with the requirements of all local codes or, in the absence of
applicable local codes, with either the National Fuel Gas Code, ANSI Z223. NFPA 54 or CAN/CGA-B149.2.
DANGER – Gas Safety
Liquid propane (LP) gas is flammable and hazardous if handled improperly. Become aware of its
characteristics before using any propane product.
•
Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in pools in low
areas.
• In its natural state, propane has no odor. For your safety, an odorant has been added.
• Contact with propane could cause freeze burns to the skin.
•
This grill is shipped from the factory for propane gas use only.
• Never use a propane cylinder with a damaged body, valve, c ollar or footing.
• Dented or rusted propane cylinders may be hazardous and should be checked by your propane gas supplier.
CAUTION
It is essential to keep the grill’s valve compartment, burners and circulating air passag es cl ean .
Inspect the grill before each use
.
Step 1. Inspect all hoses and connections and make certain they are secure.
Step 2. Check and clean the burner venturi tubes for insects and insect nests by removing the burner and inserting a
bottle brush cleaner into each tube to make sure the passage is clear.
*** A clogged tube can lead to a fire beneath the grill. ***
Step 3. Ensure that the valve nozzle is pointing straight and completely inserted into the venturi tube.
GENERAL
INFORMATION
1. A propane gas cylinder
is
required for operation.
2. This gas grill is NOT intended for commercial u
se.
6 feet
6 feet
GSF3016A
Owner’s Manual
5
Illustrated parts list
AA. Left ca rt front le g ..... .....1 pc BB. Ri ght ca rt fro n t l eg........1 pc
EE. Cart fro n t pane l.......1 pc
FF. Low e r cart back be a m........1 pc
NN. Body assem b ly................1 pc
O
O
.
L
e
f
t
s
i
d
e
s
h
e
l
f
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
p
c
PP. R igh t s ide sh e lf ...............1 pc Q Q. Side b u rner assem b ly........1 pc RR . H e at p late .................4 pcs
SS. Coo king g rid ...... ............3 pcs TT. War min g grid...................1 pc
UU . Cup sup p ort................1 pc
VV. G rease cu p ......... .............1 pc
WW. Side burner k nob...........1 pc
XX. Sid e kn o b se a t......... ...1 pc
CC. Left cart bac k le g ..........1 pc
DD. Ri g h t c a rt ba ck leg... .....1 pc
G G. Upper cart back beam......1 pc
HH. Upper cart side beam .... 2 pcs
II. Lower cart side b eam. ......2 pcs
JJ. Whe e l.. ......2 pcs .......
KK. Whee l ca p ......2 pcs ..... LL. Ax le.... ..1 pc ..............
YY. Tank Cl ip..........1 pc
ZZ . Spar e tank s topper..........1 pc
MM . Tank holder.............1 pc
AA . ......1A S pare tank stopper pc
GSF3016A
Owner’s Manual
6
Hardware List
Hardware listed above is scaled to actual size. This does not apply to the screwdriver and wrench.
(A Screwdriver is required on assembly and is included for your convenience).
A: 10 PCS
B: 4 PCS
C: 14 PCS
M6 x 15 Bolt
M6 × 20 Bolt
M6 Spring Washer
D: 14 PCS
E: 6 PCS
F: 4 PCS
M6 Flat Washer
M4 x 12 Bolt
M4 Flat Washer
G: 4 PCS
H: 1 PC
I: 2 PCS
M4 Nut
M6 × ￠5 × 13 Stopper
M10 Lock Nut
J: 2 PCS
K: 1 PC
L: 2 PCS
￠20 collar
Screwdriver
Wrench
GSF3016A
Owner’s Manual
7
Assembly Instructions
Remove all
contents from the carton packaging. Make sure all parts are present be fore attempting assembly. Once the
grill is fully assembled, go back and check to make certa in all the bolts a re secu re. Tighten again
using the screwdriver
provided if necessary.
Estimated Assembly
Time: 30 minutes.
Step 1
a) Loosen the two bolts (pre-installed) on the left cart
front leg (AA) and allow the 1/4 bolt’s length to
extend from the cart left front leg. Align the holes on
the cart front panel (EE) with the extended bolts from
the left cart front leg (AA).
b) Push down on the cart front panel (EE) until it locks
into
place. Tighten bolts by hand until secured.
c) Repeat the procedure for the right cart front leg (BB).
d) Go back and tighten all the bolts using the
screwdriver provided.
EE
A
A
Pre installed BoltX4
-
DD
CC
GG
FF
Pre installed Bolt x4
-
Step 2
a) Loosen the four bolts on the right cart back leg
(DD) and the left cart back leg (CC), and allow
1/4 bolt’s length to extend from the legs.
b) Align the holes on the lower cart back beam
(FF) with the extended bolts from the legs
(DD) & (CC). Push down on the lower cart
back beam (FF) until it locks into place, then
tighten all the bolts using screwdriver
provided.Repeat the procedure for the upper
cart back beam (GG).
BB
Loading...