Bbq-pro Bq04023-2 Owner's Manual

Grill Guide

For Model BQ04023-2

LP Gas Barbecue Grill

FOR YOUR SAFETY:

1. Read this Grill Guide before attempting to assemble or operate your grill.

2. Follow all safety instructions.

3. Check for leaks according to directions in this Grill Guide before operating your grill,
even if a retailer assembled this grill.

4. Keep this Grill Guide for future reference.

5. Contact 1-800-933-0527 should you need assembly assistance or have any questions.

TO THE INSTALLER OR PERSON ASSEMBLYING THIS GRILL:

Leave this Grill Guide with the grill for future reference.

THIS GRILL IS FOR OUTDOOR USE ONLY.

If stored indoors, then detach and leave propane cylinder outside.

POUR UTILIZATION A L’EXTERIEUR SEULEMENT.

Si Appareil est entrepose a l’intérieur; enlever les bouteilles et les laisser a Pexterieur.

1

Safety Precautions

pp

f

Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this Grill
Guide. Failure to do may result in serious bodily injury or death, or in a fire or an explosion causing
damage to property.

1. Grill installation must conform with local codes, or in their absence, with either the National Fuel
Gas Code, ANSI Z223.1, or CAN/CGA-B149.1 Natural Gas Installation Code or CAN/CGA­B149.2, Propane Installation Code.

2. Handling and storage of LP cylinders must conform to LP Gas Code NFPA/ANSI 58 or
CAN/CGA-B149.2.

3. This gas grill is not intended to be installed in or on recreational vehicles and/or boats.

4. This grill is safety certified for use in the United States and Canada only. Do not modify for use in
any other location. Modification will result in a safety hazard.

5. Never use any other type of fuel for this grill other than LP gas.

6. Only use the pressure regulator with a type 1 connector that is supplied with this gas grill.

7. Check all gas hoses for fraying, cracking, or excessive wear. Replace any with those signs before
using the grill.

8. Always perform a Leak Test before operating your grill.

1. Do not store or use gasoline or other

2. An LP cylinder not connected for use shall

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, immediately call your

! FOR YOUR SAFETY !

flammable vapors and liquids in the
vicinity of this or any other appliance.

not be stored in the vicinity of this or any
other appliance.

! FOR YOUR SAFETY !

gas supplier or your fire department.

1. Ne pas entreposer Ni utiliser de l’essence

2. Une bouteille de propane qui n’est pas

S’il y a une odeur de gaz:

1. Coupez l’admission de gaz de l’appareil.

2. Éteindre toute flamme nue.

3. Ouvrir le couvercle.

4. Si l’odeur persiste, appeler immédiatement

! WARNING !

Combustion by-products produced when using this product contain chemicals known to the State o
California to cause cancer, birth defects, and other reproductive harm.

! AVERTISSEMENT !

ni d’autres vapeurs on liquids
inflammables dans le voisinage de
l’appareil, ni de tout autre appareil.

recordée en vue de son utilisation, ne doit
pas être entreposée dans le voisinage de cet

areil ou de tout antre appareil.

a

! AVERTISSEMENT !

votre compagnie de gaz ou votre
department des incendies.

2

Table of Contents

Safety Precautions……….……………………………..……………...…………...…… 2

Table of Contents…………………….…………………………………..……….……...3

Warranty……………………………….………………………………………….…….. 4

Customer Support Center……………….………………………………………….…….4

Assembly Instructions...…………………………………………………………..…..5-15

General Information and Operation………………..………………………………..16-24

Trouble Shooting Guide……………………………………………….................….25-26

Owner Registration Card……………….……………………………………...........27-28

Write down here and keep for future
reference

Date of Purchase: _________________

Serial Number: ___________________

The serial number may be found on the placard located on the back of
the grill

Visit us at: www.kmart.com

Kmart Corporation

3100 West Big Beaver Road

Troy MI 48084-3163

1-248-463-1000

3

Limited Warranty

The manufacturer warrants to the original
consumer-purchaser that this product shall be

free from defects in workmanship and materials
under normal and reasonable use when
assembled and operated according to this Grill
Guide from date of purchase as follows:

Stainless Steel and Die Cast Parts - 99 years

Stainless Steel Burners - 10 years

Remaining Parts – 2 years

The manufacturer will, at its option, refinish or
replace any product or part found to be defective
during the limited warranty period. The
manufacturer may require you to return the
part(s) claimed to be defective for its inspection,
freight or postage prepaid. Contact our Customer
Support Center as shown below before returning
any part(s).

Additional information can be obtained by
writing:

Barbecue Grills
Warranty Dept.

1375 Mitchell Blvd

Schaumburg, IL 60193

The manufacturer will require reasonable proof

of purchase. We strongly recommend you keep
your sales receipt and register your grill. You
can attach your receipt to this guide.

This limited warranty does not cover the cost of
any inconvenience or property damage due to
failure of the product and does not cover damage
due to misuse, abuse, alteration, improper or
failure to perform normal and routine

maintenance, discoloration, accident, or damage
arising out of transportation of the product. This
limited warranty will not apply to any grill used
for commercial use.

This limited warranty is the sole warranty given
by the manufacturer and is in lieu of all other
warranties; express or implied, including implied
warranty of merchantability or fitness for a
particular purpose. Neither manufacturer dealers
nor the retail establishment selling this product
have any authority to make any warranties or to
promise remedies in addition to or inconsistent
with those stated above.

This limited warranty applies only to products
sold at retail, and is not transferable.

The manufacturer's maximum liability, in any
event, shall not exceed the purchase price of the
product paid by the original consumer-purchaser.
Some states do not allow the exclusion or
limitation of incidental or consequential
damages. Therefore, the above limitations or
exclusions may not apply to you. This warranty
gives you specific legal rights and may also have
other rights, which vary from state to state.

Customer Support Center

Thanks for purchasing a BBQ Pro™ Grill. We’re here to help you maximize your enjoyment and appreciation
of your new grill. Please don’t hesitate to contact us should you have any questions regarding assembly,

performance, warranty, or accessories. Please have your model number ready before you contact us. We’re here
to serve You!

• If you need assistance or to order parts: Call 1-800-933-0527 or send a FAX to 1-847-252-1001.

• Business hours: Monday through Friday; 8:30AM-5:00PM Central Time.

• Visit us on the web at: www.omahagrills.com

4

r

n

d

Assembly Instructions

This page will give you an overview of information to assemble your grill. The following pages will show in
step-by-step detail how to do so. We offer the following suggestions to make your grill assembly as easy as
possible.

1.) Read through the entire Assembly Instructions before you begin.

2.) Choose an area large enough to comfortably lay out all the parts and hardware with enough room to easily
maneuver.

3.) Have an area with a non-abrasive surface where you can lay parts without scratching them.

4.) Use 2 people to remove the Cabinet and Firebox Assembly from the carton. You will also need 2 people to
attach the Casters to the Cabinet and Firebox Assembly.

5.) Lay all parts and hardware out and ensure you have everything listed on the Parts and Hardware page before
you begin assembly. See the Customer Support Page for contact information should any parts be damaged or
missing.

6.) A Phillips Head Screwdriver has been provided for assembly. You will not need any additional tools.

7.) Do not use a Power Screwdriver for assembly as you could strip the threads on the Nuts and Bolts.

8.) The propane tank for this grill is sold separately. See the LP Gas and Cylinder Information later in this
guide.

! WARNING !

Failure to follow all Danger,
Warnings, and For Your Safety
notices in this Grill Guide may
result in serious bodily injury o
death, or in a fire or an explosio
causing damage to property.

! CAUTION !

Perform the Leak Test explaine
later in this Grill Guide before
operating your grill.

BQ04023-2

5

BQ04023-2 Detail Parts List

1. Thermometer 36.Side Burner Shelf Frame

2. Thermometer Seat 37.Side Burner Inside Frame

3. Stainless Steel Lid - Outer 38.Side Burner Cover Support

4. Logo Plate 39.Side Burner Electrode

5. Name Plate 40.Side Burner

6. Lid Side Panel - Right 41.Side Burner Rear Bracket

7. Lid Side Panel - Left 42.Side Burner Front Bracket

8. Hood Handle 43.Side Burner Front Panel

9. Handle Connector 44.Grease Pan

10. Stainless Steel Lid - Inner 45.Grease Pan Handle

11. Firebox - Back

12. Firebox - Right Side 47.Right Side Table Front Panel

13. Firebox - Left Side 48.Right Side Table Rear Bracket

14. Heat Shield for Firebox - Inner 49."S" Hooks

15. Electrode 50.Right Side Table Front Bracket

16. Firebox - Front 51.Cabinet - Back Side Panel

17. Heat Shield for Control Panel - Inner 52.Cabinet Crossbar

18. Heat Shield for Control Panel - Outer 53. Door Stopper Plate

19. Bottom Heat Shield 54.Magnetic Door Stopper

20. Heat Diffuser 55.Cabinet - Right Side Panel

21. Burner 56.Cabinet - Left Side Panel

22. Cotter Pin

23. Main Burner Bracket 58.Cabinet Door - Right

24. Gas Manifold Assembly 59.Cabinet Door Handle

25. Gas Hose 60. Condiment Basket

26. Regulator and Hose 61.Cabinet - Bottom Shelf

27. Control Panel 62. Caster Cap

28. Control Knob 63.Standard Caster

29. Control Knob Seat 64.Locking Caster

30. Electric Igniter 65.Cylinder Support Ring

31. Side Burner Valve 66.Manual Igniter

32. Warming Rack

33. Cooking Grate

34. Side Burner Cover

35. Pan Support

46.Right Side Table

57.Cabinet Door - Left

6

7

! WARNING !

DO NOT DISPOSE OF BATTERIES IN FIRE.
BATTERIES MAY EXPLODE OR LEAK.

8

9