Bbq Grillware Ggp-2501 Owner's Manual
MASTER FEREiE*
A
oarucen
lf
you
smell
gas:
'l
.
Shut off
gas
to the appliance.
2. Extinguish any
open
flame.
3. Open
lid.
4. lf odor continues, keep away from
the appliance
and immediately
call
your gas
supplier or
your
fire
department.
A wnnnrruc
1
. Do not store
or use
gasoline
or
other flammable liquids
or
vapors in the vicinity
of this or
any other appliance.
2. An LP cylinder not connected
for use shall not
be stored
in
the
vicinity
of this or any other
appliance.
3. This
grill
is for
outside use only,
and should not
be used
in
a
building,
garage,
under
overhangs or
any other
enclosed area.
4. Do not leave
a
lit
grill
unattended. Keep
children and
pets
away from
the
grill
at all
times.
CALIFORNIA PROPOSITION
65
('1
)
Combustion by-products
produced
when
using
this
product
contain chemicals known
to the
State of California to cause
cancer, birth
defects, and other
reproductive harm-
(2)
This
product
contains chemicals,
including lead and lead
compounds, known to the State
of California to
cause cancer,
birth defects or
other
reproductive harm.
Wash
your
hands
after
handling
this
product
|TEM # 0296449
4-Burner
LP Gas Grill
with Side Burner
MODEL # GGP-2501
SAVE THIS INSTRUCTION
MANUAL.
IF YOU
ARE
ASSEMBLING THIS GRILL FOR
SOMEONE
ELSE,
LEAVE THIS MANUAL FOR THEM.
Questions,
problems,
missing
parts?
Before returning to
your
retailer, call our customer
service department at 1-800-963-0211
,8
a.m.
-
6
p.m.,
EST, M-TH, I a.m.
-
5
p.m.,
EST,
Friday
TABLE OF CONTENTS
Safety lnformation
Package
Contents
lllustrated Parts List
Hardware Contents
Preparation
2
4
5
7
7
8
18
21
23
26
27
Assembly lnstructions
Operation lnstructions
Care and Maintenance
Troubleshooting
Warranty
Replacement Parts
List
A
snrerv
TNFoRMATToN
Please
read
and understand
this
entire manual
before
attempting
to assemble,
operate
or install
the
product.
lf
you
have
any
questions
regarding
the
product,
please
call
customer
service
at
1-800-963-021'1
,8
a.m. - 6
p.m.,
EST,
M-TH,
B a.m. -
5
p.m.,
EST, Friday
1. DO
NOT
store or
use
gasoline
or any
other flammable
vapors
and liquids
within 25 feet
(8m)
of this
or any other
appliance.
2. When cooking
with
oil/grease, do not
allow the
oil/grease to
exceed 3S0. F
(177.C).
Do not
store
or use extra cooking
oil in the vicinity
of this or
any other appliance.
3. An LP Cylinder
not connected
for use
should be stored
a minimum of 10 feet
(3m)
away from
this or any
other appliance.
4. lf
you
smell
gas:
-
Shut off
gas
to the
grill.
- Extinguish
any open flame.
-
Open lid.
-
lf
odor continues,
immediately
call
your
gas
supplier or fire
department.
5. This
grill
is for
use with
propane
gas
only
(propane
gas
cylinder not included).
6. Never attempt
to attach this
grill
to the
self-contained
propane
system of a camper
trailer,
motor home
or house.
7. Never use
charcoal
or
lighter
fluid with
the
grill.
8. Do not use
gasoline,
kerosene
or alcohol for
lighting. The
LP-gas supply
cylinder must
be
constructed
and marked in accordance
with the
specifications for
propane
gas
cylinders of the
U.S. Depariment
of Transportation
(DOT)
CFR 49. This
grill
is not intended to be
used in or
installed
on
recreation
vehicles and/or
boats.
9. Do not attempt to move the
grill
while it is lit.
10. Do not use the
grill
unless it is completely assembled
and
all
parts
are securely
fastened
and tightened.
11. Keep all
combustible items and surfaces at least 20 inches
(50.8
cm) away from the
grill
at
all
times.
12. DO
NOT
use this
gas
grill
or any
gas product
near unprotected combustible constructions.
13. Do not use in an explosive atmosphere. Keep
grill
area clear and free from combustible
materials,
gasoline
and other flammable vapors and liquids.
14. Do not touch metal
parts
of
grill
until it has completely
cooled
(about
45 minutes) to avoid
burns, unless
you
are wearing
protective gear
(pot
holders,
gloves,
BBQ mittens, etc.).
15. Do not alter this
grill
in any manner.
16. Clean and inspect the
hose
before each use.
lf there is
evidence
of abrasion, wear, cuts, or
leaks,
replace the hose
prior
to operating the appliance. The replacement
hose
assembly will be that which is specified by the
manufacturer.
17. Move
gas
hoses as far away as
possible
from hot surfaces and dripping
hot
grease.
18.
Never keep a filled container in a hot car or car trunk. Heat
will cause the
gas
pressure
to
increase,
which may
open
the relief valve and allow
gas
to
escape.
19. Keep the
grill's
valve
compartment,
burners and circulating
air
passages
clean.
lnspect the
grill
before each
use.
20. This
grill
is for
outside use only, and should
not
be
used in a building,
garage,
under
overhangs
or any other enclosed area.
21 . The use of alcohol,
prescription
or non-prescription drugs
may impair the operator's ability
to
properly
assemble or safely operate the
grill.
22. Always open
grill
lid slowly and carefully as heat and steam trapped within
the
grill
can
burn
you
severely.
23. Always
place
your grill
on a
hard, level
surface
far
away
from
combustibles.
An asphalt or
blacktop surface may not be acceptable for this
purpose.
24. Do not leave
a
lit
grill
unattended. Keep children and
pets
away
from the
grill
at all
times.
25. Do
not
place
this
grill
on any type of tabletop surface.
26. Do not
use
the
grill
in high winds.
27.
Minimum clearance from sides and back of unit to combustible construction, 36 inches from
sides
and back.
es
..b
{o
i
nch
NOTE: The
installation
must
confirm with local codes or, in the absence
of
local codes, with
either
the National Fuel Gas Code, ANSI Z 223.1|NFPA
54,
Natural
Gas and
Propane lnstallation
Code,
CSA B'149.1
,
or Propane
Storage and
Handling
Code, 8149.2, or the Standard for Recreational
Vehicles,
ANSI A 119.2/ NFPA 1192, and
CSAZ240 RV Series, Recreational Vehicle
Code, as
applicable.
3
PACKAGE
CONTENTS
Part
Description
Quantity
A
Directional caster 2
B
Left side base
panel
1
c
Caster
2
D
Riqht side base
panel
1
E
Left side
panel
1
F
Middle side
panel
1
G
Right
side
panel
1
H
Front
side
panel
1
Back
side
panel
1
J
Drip
pan
1
K
Grease collection
pan
1
L
Grill
housing assembly
1
M
Drawer track
1
4
Part
Description
Quantity
N
Knob
bezel
1
o
Knob
1
P
Door handle
2
o
Door
1
R
Door
bracket
I
S
Drawer assembly
1
T
Head shield
4
U
Cookinq
qrate
2
Warmino rack
1
Side table assembly 1
X
Tank reta iner wire
1
Side control
panel
1
ILLUSTRATED PARTS LIST
Left side base
panel
Caster
. .\
o-y
Right side
base
panel
Left side
panel
Right side
panel
Front side
panel
Back side
panel
o
Drip
pan
o
Grease collection
pan
Grill housrng assembly
Side
table
assembly Drawer track
@
Knob bezel
ILLUSTRATED
PARTS LIST
Door handle
o
Door bracket
@L-
Drawer
assembly
o
Heat shield
o
Cooking
grate
o
Warming rack
o
Tank retainer wire
o
Side control
panel
b
HARDWARE CONTENTS
Part
Description
Quantity
Picture
Part
Description
Quantity
Picture
@
@
@
@
@
o
M6x12
Screw
M6x12
Screw
M6x8
Screw
M4x10
Screw
$*
$*
N
0*
0*
)N
Flat
Washer
Washer
Spring
Washer
36
2
6
11
Spring
Axis
16
4
25
2
-
M4x10
Screw
M4x10
Screw
2
PREPARATION
Before beginning
assembly
of
product,
make
sure all
parts
are
present.
Compare
parts
with
package
contents list and diagram above. lf any
part
is missing or damaged,
do
not attempt to
assemble the
product.
Contact customer service
for replacement
parts.
Estimated Assembly Time: 35-45 minutes
Tools Required for Assembly
(sold
separately):
7
ASSEMBLY
INSTRUCTIONS
Step
1
lnstall
two
directional
casters
(A)
on the left
side
base
panel (B)
of cabinet:
use
eight screws
(AA)
and eight flat
washers
(FF)
and eight spring
washers
(HH).
Step
2:
lnstall
two casters
(C)
on
the right side base
panel (D)
of cabinet: use eight
screws
(M)
and
eight
flat washers
(FF)
and
eight spring
washers
(HH)
Hardware
Used
M6x12
Screw
Spring Washer
Flat Washer
$*
@
@
x8
x8
xB
Hardware Used
M6x12
Screw
Spring
Washer
Flat Washer
S*
o
@
x8
x8
x8
Loading...