Page 1
SAFETY DATA SHEET
BBJ Micro Coil Clean
HVAC System Cleaner
TM
BBJ Environmental Solutions
"The standard of care for indoor air"
1.1 Product identifier
Product Name: BBJ Micro Coil Clean
Product Codes(s):
Synonym(s): Aqueous cleaning solution
REACH Registration Number:
510-XX, 550-XX, 555-XX04
SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION
TM
No data available
1.2 Relevant identified uses of the substance or mixture and uses advised against
General use:
Uses advised against:
Alkaline coil cleaner
No uses advised against
1.3 Details of the supplier and of the safety data sheet
Distributor
Atlantic Chemical & Equipment
3471 Atlanta Industrial Parkway, Suite 200
Atlanta, GA 30331 USA
Toll free: +1-800-929-2436
1.4 Emergency telephone number: Chemtrec (24 hours) +1-800-424-9300; International: +1-703-527-3887
SECTION 2 - HAZARDS IDENTIFICATION
2.1 Classification of substance or mixture
Product definition:
Classification in accordance with 28 CFR 1910 (OSHA HCS) and Regulation (EC) No 1272/2008
Skin Irritant (Category 2) [H315]
Eye Irritant (Category 2A) [H319]
2.2 Label Elements
Mixture
Hazard Symbols:
GHS07
Signal Word:
Hazard Statement(s):
Precautionary Statements:
[Prevention]
[Response]
Warning
H315 - Causes skin irritation
H319 - Causes serious eye irritation
P264 - Wash hands or other skin areas contacting this product thoroughly after handling.
P280 - Wear protective gloves and eye protection.
P261 - Avoid breathing mist and spray.
P302 + P352 - IF ON SKIN: Wash with plenty of soap and water.
P321 - Specific treatment: Refer to Section 4.2 of this SDS and seek medical attention.
P332 + P313 - If skin irritation occurs: Get medical attention.
P362 - Take off contaminated clothing and wash before reuse.
P305 + P351 + P338 - IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing.
P337 + P313 - If eye irritation persists: Get medical attention.
SECTION 3 - COMPOSITION/INFORMATION ON INGREDIENTS
3.1 Substances
Not applicable
3.2 Mixtures
% by Weight
>70
3 - 8
3 - 5
<5
There are no additional ingredients present which, within the current knowledge of the supplier and in the concentrations applicable, are classified
as hazardous to health or the environment and hence require reporting in this section.
C8-10 Alcohols, Ethoxylated
Tetrasodium ethylenediamine tetraacetate
Ingredient
Water
Sodium Metasilicate
CAS Number
7732-18-5
68439-46-3
6834-92-0
64-02-8
EC Number
--------------- --------------215-181-3
229-912-9
200-573-9
Index Number
---------------
--------------014-010-00-8
607-428-00-2
GHS Classification
H302, H318
H314, H335
H302, H318
BBJ Micro Coil Clean (Ace)
Page 1 of 6
Page 2
SECTION 4 - FIRST AID MEASURES
4.1 Description of first aid measures
Inhalation:
irregular, administer oxygen; if respiratory arrest occurs, start artificial respiration by trained personnel. Loosen tight clothing such as a collar, tie,
belt or waistband. If symptoms persist, seek medical attention.
Eyes: Immediately flush eyes with large amounts of water for 15 minutes. Remove contact lenses if present, after the first 5 minutes and continue
rinsing, occasionally lifting upper and lower lids. Obtain immediate medical attention, preferably from an ophthalmologist.
Skin:
if irritation persists, if rash develops or if you feel unwell.
Ingestion:
vomiting unless directed to do so by medical personnel. Do not leave victim unattended. To prevent aspiration of swallowed product, lay victim
on one side with the head lower than the waist. Vomiting may occur spontaneously. If vomiting occurs and the victim is conscious, give water to
further dilute material. Never give anything by mouth to an unconscious person. Get medical attention immediately.
If product mist causes respiratory irritation or distress, move the exposed person to fresh air immediately. If breathing is difficult or
.
Wash affected area with soap and water. Wash contaminated clothing and shoes thoroughly before reuse. Seek prompt medical attention
Rinse mouth with water. Remove dentures if present. If conscious and alert drink 2 - 3 cupfuls of milk or water. Do not induce
4.2 Most important symptoms and effects, both acute and delayed
Potential health symptoms and effects
Causes moderate to severe eye irritation. Symptoms include redness, stinging, tearing and swelling.
Eyes:
May cause mild to moderate irritation. Repeated and prolonged use may result in drying or cracking of skin or dermatitis.
Skin:
Inhalation:
Ingestion:
Chronic:
4.3 Indication of any immediate medical attention and special treatment needed
Advice to Doctor and Hospital Personnel:
Inhalation of mist or spray may cause mild irritation of the respiratory tract.
May be harmful if swallowed. May cause gastrointestinal irritation with nausea, vomiting, abdominal cramps and diarrhea.
No information available.
Treat symptomatically and supportively.
SECTION 5 - FIRE FIGHTING MEASURES
5.1 Extinguishable media
Suitable methods of extinction:
Unsuitable methods of extinction:
5.2 Special hazards arising from the substance or mixture
Closed containers may explode due to the buildup of pressure when exposed to extreme heat. During emergency conditions overexposure
to decomposition products may cause a health hazard. Symptoms may not be immediately apparent. Obtain medical attention.
5.3 Advice for firefighters
Full protective equipment including self-contained breathing apparatus should be used. Water may be used to cool closed containers to prevent
pressure buildup and possible autoignition or explosion when exposed to extreme heat. If possible, firefighters should control runoff water to
prevent environmental contamination.
Use extinguishing media suitable for surrounding fire.
None known
SECTION 6 - ACCIDENTAL RELEASE MEASURES
6.1 Personal precautions, protective equipment and emergency procedures
Wear appropriate protective clothing designated in Section 8. Ventilate the area.
6.2 Environmental precautions
Avoid dispersal of spilled material or runoff and prevent contact with soil and entry into drains, sewers or waterways.
6.3 Methods and materials for containment and cleaning up
Cover drains and contain spill. Cover with a large quantity of inert absorbent. Collect product using a shovel or broom and into place into an
approved container for proper disposal. Observe possible material restrictions (Sections 7.2 and 10.5). Clean contaminated area with soap and
water. Dispose of in accordance with federal, state and local regulations.
6.4 Reference to other sections
For indications about waste treatment, see Section 13.
SECTION 7 - HANDLING AND STORAGE
7.1 Precautions for safe handling
Observe label precautions. Wear all appropriate protective equipment specified in Section 8. Keep containers closed when not in use.
Advice on protection against fire and explosion
Keep away from heat, sparks and flame. Solutions containing glycol ethers in water can form flammable vapors with air if heated sufficiently.
7.2 Conditions for safe storage, including any incompatibilities
Keep in cool, dry, ventilated storage areas in closed containers. Transfer only to approved containers having correct labeling. Containers that
have been opened should be carefully resealed and kept upright to prevent leakage. Do not take internally. Keep out of reach of children.
7.3 Specific end uses
Apart from the uses mentioned in Section 1.2, no other specific uses are stipulated.
SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION
8.1 Control parameters
Contains no substances with occupational exposure values.
BBJ Micro Coil Clean (Ace)
Page 2 of 6
Page 3
8.2 Exposure controls
Engineering Measures:
equipment. Use adequate ventilation. Local exhaust is preferable. Refer to See Section 7.1.
Individual protection measures:
selected specifically for the workplace, depending on concentrations and quantities of hazardous substances handled. The chemical resistance
of the protective equipment should be enquired at the representative supplier.
Hygiene measures:
clothing. Preventive skin protection is recommended. Wash hands thoroughly after use, before eating, drinking or using the lavatory.
Eye/face protection:
or European Standard EN 166.
Hand Protection:
impermeable to chemicals and oil. Breakthrough time of selected gloves must be greater than the intended use period.
Other protective equipment:
Respiratory Protection:
assessment shows air-purifying respirators are appropriate use a full-faced respirator with multi-purpose combination (US) or type ABEK
(EN 14387) respirator cartridges as a backup to engineering controls. If the respirator is the sole means of protection, use a full-face supplied air
respirator. Use respirators and components tested and approved under appropriate government standards such as NIOSH (US) or CEN (EU).
Environmental exposure controls:
Technical measures and appropriate working operations should be given priority over the use of personal protective
Wear protective clothing to prevent repeated or prolonged contact with product. Protective clothing needs to be
Facilities storing or using this material should be equipped with an eyewash station and safety shower. Change contaminated
Wear protective goggles or safety glasses with unperforated side shields during use. Refer to 29 CFR 1910.133, ANSI Z87.1
Wear rubber gloves or gloves recommended by glove supplier for protection against materials in Section 3. Gloves should be
Protective clothing. Wear protective boots if the situation requires.
None required with normal use. Always use an approved respirator when vapor/aerosols are generated. Where risk
Do not empty into drains.
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
9.1 Information on basic physical and chemical properties
Appearance Clear yellow liquid
Odor Mild
Odor Threshold Not determined
Molecular Weight Not applicable
Chemical Formula Not applicable
pH
Freezing/Melting Point
Initial Boiling Point
Evaporation Rate Not determined
Flammability (solid, gas) Not applicable
Flash Point Not determined
Autoignition Temperature Not determined
Decomposition Temperature Not determined
Lower Explosive Limit (LEL) Not determined
Upper Explosive Limit (UEL) Not determined
Vapor Pressure
Vapor Density Not determined
Specific Gravity
Viscosity Not determined
Solubility in Water Dispersible
Partition Coefficient: n-octanol/water Not determined
Volatiles by Volume @ 21 ºC >80%
9.2 Other data
No data available
>12 @ 20 °C (68 °F)
<0 °C (<32 °F)
100 °C (212 °F)
Not determined
1.020
SECTION 10 - STABILITY AND REACTIVITY
10.1 Reactivity
No special reactivity has been reported.
10.2 Chemical stability
Stable under recommended storage conditions.
10.3 Possibility of hazardous reactions
Hazardous polymerization will not occur.
10.4 Conditions to avoid
Extreme temperatures. Contact with incompatible materials.
10.5 Incompatible materials
Strong oxidizing agents
10.6 Hazardous decomposition products
Thermal decomposition products include oxides of carbon, oxides of nitrogen, oxides of sulfur
SECTION 11 - TOXICOLOGICAL INFORMATION
11.1 Information on toxicological effects
Acute oral toxicity
LD50 - Rat: 1,900 mg/kg
BBJ Micro Coil Clean (Ace)
Page 3 of 6
Page 4
Acute inhalation toxicity
LC50 - Rat: >2.013 mg/l
Acute dermal toxicity
LD50 - Rat: >2,000 mg/kg
Skin irritation
May cause mild skin irritation.
Eye irritation
Causes moderate to severe eye irritation.
Sensitization
No data available
Genotoxicity in vitro
No data available
Mutagenicity
No data available
Specific organ toxicity - single exposure
No data available
Specific organ toxicity - repeated exposure
No data available
Aspiration hazard
No data available
11.2 Further information
None of the components in this product are listed as carcinogens by ACGIH, IARC, NTP or OSHA. No data is available regarding the mutagenicity
or teratogenicity of this product, nor is there any available data that indicates that it causes adverse developmental or fertility effects.
Handle in accordance with good industrial hygiene and safety practice.
SECTION 12 - ECOLOGICAL INFORMATION
12.1 Toxicity
This product is expected to have low acute toxicity to aquatic organisms.
12.2 Persistence and degradability
Product is expected to be readily biodegradable.
12.3 Bioaccumulation potential
Material is not expected to bioaccumulate.
12.4 Mobility
The components in this product are water soluble and highly mobile in soil.
12.5 Results of PBT and vPvB assessment
No data available
12.6 Other adverse effects
Additional ecological information
Do not allow material to run into surface waters, wastewater, sewers or soil.
An environmental hazard cannot be excluded in the event of unprofessional handling or disposal.
SECTION 13 - DISPOSAL CONSIDERATIONS
13.1 Waste treatment methods
Methods of disposal:
product residues. This material and its container must be disposed of in a safe way. Dispose of surplus and non-recyclable products via a
licensed waste disposal contractor. Disposal of this product, solutions and any by-products should at all times comply with the requirements of
environmental protection and waste disposal legislation and any regional local authority requirements. Avoid dispersal of spilt material and runoff
and contact with soil, waterways, drains and sewers.
Hazardous waste:
The generation of waste should be avoided or minimized whenever possible. Empty containers or liners may retain some
The classification of this product may meet the criteria for a hazardous waste.
SECTION 14 - TRANSPORT INFORMATION
Note:
Transportation information provided is for reference only. Customer is urged to consult 49 CFR 100 - 177, IMDG, IATA, EC, United Nations
TDG and WHMIS (Canada) TDG information manuals for detailed regulations and exceptions covering specific container sizes, packaging materials
and methods of shipping.
SEE BILL OF LADING FOR SHIPPING DATA
SECTION 15 - REGULATORY INFORMATION
15.1 Safety, health and environmental regulations/legislation specific for substance or mixture
U. S. Federal Regulations
OSHA Hazard Communication Standard:
OSHA Process Safety Management Standard:
EPA Risk Management Planning Standard:
TSCA Status:
BBJ Micro Coil Clean (Ace)
All components of this product are listed on the TSCA Inventory. This product is not subject to TSCA 12(b) Export Notification.
This material is classified as hazardous in accordance with OSHA 29 CFR 1910.1200.
Components of this product are not regulated under OSHA PSM Standard 29 CFR 1910.119.
Components of this product are not regulated under EPA RMP Standard (RMP) 40 CFR Part 68.
Page 4 of 6
Page 5
Superfund Amendments and Reauthorization Act (SARA)
SARA Section 311/312 Hazard Categories:
SARA 313 Information:
None of the chemicals in this product exceed the threshold (de minimis) reporting levels established by Section 313 of
Acute Health Hazard
the Emergency Planning and Community Right-to Know Act of 1986.
SARA 302/304 Extremely Hazardous Substance
No components of the product exceed the threshold (de minimis) reporting levels established by of these sections of Title III of SARA.
SARA 302/304 Emergency Planning & Notification:
No components of the product exceed the threshold (de minimis) reporting levels established by of these sections of Title III of SARA.
Comprehensive Response Compensation and Liability Act (CERCLA):
This product contains the following CERCLA reportable substances:
Sodium Hydroxide (CAS #1310-73-2), RQ - 453.6 kg (1,000 lbs)
Clean Air Act (CAA)
This product does not contain any chemicals that are listed as Hazardous Air Pollutants (HAPs) designated in CAA Section 112 (b).
This product does not contain any Class 1 Ozone depletors.
This product does not contain any Class 2 Ozone depletors.
Clean Water Act (CWA)
Sodium Hydroxide (CAS #1310-73-2) is listed as Hazardous Substances under the CWA.
None of the chemicals in this product are listed as Priority Pollutants under the CWA.
None of the chemicals in this product are listed as Toxic Pollutants under the CWA.
U.S. State Regulations
California Prop 65, Safe Drinking Water and Toxic Enforcement Act of 1986
This product contains no chemical(s) known to the state of California to cause cancer, birth defects or other reproductive harm.
Other U.S. State Inventories
Sodium Hydroxide (CAS #1310-73-2) is listed on the following State Hazardous Substance Inventories, Right-to-Know lists and/or Air Quality/
Air Pollutants List(s): CA, DE, ID, MA, MN, NJ, PA, WA, WI.
Trisodium Nitrilotriacetate (CAS #5064-31-3) is listed on the following State Hazardous Substance Inventories, Right-to-Know lists and/or Air
Quality/Air Pollutants List(s): MA
Canada
WHMIS Hazard Symbol and Classification
D2B - Eye irritation - toxic - other
Canadian National Pollutant Release Inventory (NPRI):
None of the chemicals in this product are listed on the NPRI.
European Economic Community
Labeling (67/548/EEC to 1999/45/EC)
Xi - Irritant
Risk Phrases:
Safety Phrases:
R36/38 - Irritating to eyes and skin.
S2 - Keep out of the reach of children.
S26 - In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
S37/39 - Wear suitable gloves and eye/face protection.
WGK, Germany (Water danger/protection):
2
Global Chemical Inventory Lists
Country
Canada:
Canada:
Europe:
United States:
Australia:
New Zealand:
China:
Japan:
Korea:
Philippines:
*Yes - All components of this product are in compliance with the inventory requirements administered by the governing country.
No - one or more components of this product are not on the inventory and are not exempt from listing.
Inventory Name
Domestic Substance List (DSL).
Non-Domestic Substance List (NDSL).
Inventory of New and Existing Chemicals (EINECS)
Toxic Substance Control Act (TSCA)
Australian Inventory of Chemical Substances (AICS)
New Zealand Inventory of Chemicals (NZIoC)
Inventory of Existing Chemical Substances in China (IECSC)
Inventory of Existing and New Chemical Substances (ENCS)
Existing Chemicals List (ECL)
Philippines Inventory of Chemicals and Chemical Substances (PICCS)
15.2 Chemical safety assessment
For this product a chemical safety assessment was not carried out.
Inventory Listing*
Yes
No
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Hazardous Material Information System (HMIS)
Health
Flammability
Physical Hazard
Personal Protection
BBJ Micro Coil Clean (Ace)
2
0
0
B
SECTION 16 - OTHER INFORMATION
HMIS Hazard Rating Legend
* = Chronic Health Hazard
0 = INSIGN IFICANT
1 = S LIGHT
2 = MODERATE
3 = HIGH
4 = EXTREME
Page 5 of 6
Page 6
National Fire Protection Association (NFPA)
Flammability
NFPA Hazard Rating Legend
0 = INSIGN IFICANT
1 = S LIGHT
2 = MODERATE
3 = HIGH
4 = EXTREME
Health
0
Instability
0
2
Special
Full text of GHS Hazard Phrases referenced in Section 3 (not covered in Section 2)
H302 - Harmful if swallowed
H314 - Causes severe skin burns and eye damage
H318 - Causes serious eye damage
H335 - May cause respiratory irritation
Atlantic Chemical & Equipment assumes no legal responsibility or liability form the described product's use. All chemicals possess unknown potential hazards. The information
herein should be used only to supplement the end user's existing knowledge. Read directions for proper use. This SDS was written for the product as packaged. Cleaning
Contractors shall comply with all applicable OSHA regulations.
Preparation Date: 26 May 2016
BBJ Micro Coil Clean (Ace)
Page 6 of 6
Loading...