Baumatic BHG300.5SS Instruction manual
BHG300.5SS BHG604.5SS/W
BHG610.5SS BHG710.5SS
BHG900.5SS
GAS HOB
1
Ng a User Manual for the
User Manual for your Baumatic
BHG300.5SS
BHG604.5SS/W
BHG610.5SS
BHG710.5SS
BHG900.5SS
GAS HOB
NOTE: This User Instruction Manual contains important
information, including safety & installation points, which will
enable you to get the most out of your appliance. Please keep it
in a safe place so that it is easily available for future reference; for
you or any person not familiar with the operation of the appliance.
JW 18/07/12
2
Contents
Environmental note 4
Important safety information 5-7
Specifications 8-13
Product details/specifications/dimensions:
o BHG300.5SS 8
o BHG604.5SS/W 9
o BHG610.5SS 10
o BHG710.5SS 11
o BHG900.5SS 12
Electrical details 13
Gas details 13
Using the gas hob 14-16
Before first use 14
The gas hob 14
Automatic ignition with flame failure safety device 15
Energy saving tips 16
Cleaning 17-18
Cleaning the hob top 17
After each use 17
Cleaning the hob burners 17
Maintaining the enamelled pan stands 18
Maintaining the cast iron pan stands 18
Installation 19-29
Positioning 20-21
Unpacking the appliance 21
Installing the appliance 22-23
Gas connection 24
Ventilation requirements 24
Gas Safety (Installation and Use) Regulations 25
Gas Adjustment (Conversion to LPG) 26
Minimum flow adjustment for hob gas taps 27
Gas tap maintenance 28
Electrical connection 29
Replacing the mains supply cable 29
My appliance isn’t working correctly 30
Baumatic consumables 31
Contact details 32
3
Environmental note
o The packaging materials that Baumatic uses are environmentally
friendly and can be recycled.
o Please discard
environment.
all packaging material with due regard for the
4
Important safety information
Your safety is of the utmost importance to Baumatic.
Please make sure that you read this instruction booklet
before attempting to install or use the appliance. If you
are unsure of any of the information contained in this
booklet, please contact the Baumatic Customer Care
Departm
General Information
This appliance is designed for domestic houso
the cooking and frying of domestic foodstuffs.
o IMPORTANT: The adjacent furniture and all materials used in
the installation must be able to withstand a minimum
temperature of 85°C above the
room it is located in, whilst in use.
o Certain types of vinyl or laminate kitchen furniture are
particularly prone to heat damage or di
temperatures below the guidelines given above.
o Any damage caused by the appliance being installed in
contravention
the owner.
o Your new appliance is guaranteed against electrical or
mechanical defects, subject to certain exclusions that are noted
in Baumatic’s Conditions Of
affect your statutory rights.
o The use of this appliance for any other purpose or in any other
environment without the express agreeme
invalidate any warranty or liability claim.
o You shou
surface.
o No modifications to the appliance are permitted by Baumatic Ltd.
o You should not store or place flammable or highly flammable
liquids/materials on top of or near the appliance. Items made
from aluminium, plastic or plastic film should also be
from the appliance, as they may fuse to the surface.
o Repairs may only be carried out by Baum
Enginee
ld not use this appliance to store items on or as a work
rs or their authorised service agent.
ent.
ehold use and for
ambient temperature of the
scolouration at
of this temperature limit, will be the liability of
Guarantee. The foregoing does not
nt of Baumatic Ltd will
kept away
atic Service
5
C
hild Safety
o Baumatic strongly recommend that babies and young children
are prevented from being near to the appliance and not allowed
to touch the applian
surfaces will be hot.
o If it is necessary for younger family members to be in the
kitchen, plea
at all times.
o Older children sho
when supervised.
eneral Safety
G
o The appliance should only b
GASSAFE registered installer.
o Care should be taken to ensure that the units and work surfaces
that you b
standards.
uring use
D
o Any film or stickers that are present on the
is delivered should be removed before use.
o Care should be taken when utilising
there is a risk of burns being caused.
o You should not allow the electrical connection cables to come
into contac
cookware.
o If fat and oil overheats, then it can ignite extremely quickly. For
this reason, when cooki
not be left unattended.
o Make
use.
leaning
C
Cleaning of the hob should be carried out on a regular basis.
o
o IMPORTANT: Before attempting to clean the
should be disconnected from the mains and cool.
sure that all of the cooking zones are switched off after
se ensure that they are kept under close supervision
uild the appliance into, meet with the relevant
t with the hob surface when it is hot or any hot
ce at any time. During and after use, all
uld only be allowed to utilise the appliance
e installed and connected by a
hob surface when it
the appliance, otherwise
ng with fat and oil the appliance should
appliance, it
6
o Great care should be taken whilst using this appliance and when
following the cleaning procedure.
o You should not use a steam jet or any other high pressure
cleaning equipment to clean the appliance.
Installation
This appliance must be correctly installed by a
GASSAFE registered installer, strictly in
accordance with the manufacturer’s instructions
and the relevant British Standards. Please see the
specific section of this booklet that refers to
installation.
o Baumatic Ltd declines any responsibility for injury or
damage, to person or property, as a result of improper
use or installation of this appliance.
o If the appliance is being used in a Leisure Accommodation
Vehicle, the requirements of N 721 MUST be followed.
o Baumatic Ltd DOES NOT recommend that this appliance is
installed on any type of marine vessel.
Declaration of conformity
This appliance complies with the following European Directives:
-2006/95/CE General regulations / Low tension
-2009/142/CE Concerning gas appliances
-1935/2004/CE 90/128/EEC This appliance is suitable to come in
contact with food
-2004/108/CE Electromagnetic compatibility
The manufacturer declares that the hob is built using certified
materials and requires the appliance to be installed in accordance with
the standards currently in force. This appliance must be used by a
trained person for domestic purposes only.
7
Specifications – BHG300.5SS
Product dimensions:
Depth: 510 mm
Width: 288 mm
Height: 45 mm
Product specifications:
o 1 x 3.00 kW rapid burner
o 1 x 1.00 kW auxiliary burner
o Front control operation
o Enamelled pan stands
o Automatic ignition
o Flame failure safety device on each burner
Standard accessories:
o LPG conversion jets
Gas hob surface layout
1 = 1.00 kW auxiliary burner
2 = 3.00 kW rapid burner
Aperture dimensions:
Depth: 494 mm
Width: 270 mm
8
Specifications – BHG604.5SS/W
Product dimensions:
Depth: 510 mm
Width: 620 mm
Height: 50 mm
Product specifications:
o 1 x 3.00 kW rapid burner
o 2 x 1.75 kW semi-rapid burners
o 1 x 1.00 kW auxiliary burner
o Front control operation
o Enamelled pan stands
o Automatic ignition
o Flame failure safety device on each burner
Standard accessories:
o LPG conversion jets
Gas hob surface layout
1 = 1.75 kW semi-rapid burner
2 = 1.75 kW semi-rapid burner
3 = 3.00 kW rapid burner
4 = 1.00 kW auxiliary burner
Aperture dimensions:
Depth: 480 mm
Width: 560 mm
9
Specifications – BHG610.5SS
Product dimensions: Aperture dimensions:
Depth: 510 mm
Width: 620 mm
Height: 50 mm
Depth: 480 mm
Width: 560 mm
Product specifications:
o 1 x 3.50 kW triple crown (wok) burner
o 1 x 1.75 kW semi-rapid burners
o 1 x 3.00 kW rapid burner
o 1 x 1.00 kW auxiliary burner
o Front control operation
o Heavy duty cast iron pan stands
o Automatic ignition
o Flame failure safety device on each burner
Standard accessories:
o LPG conversion jets
Gas hob surface layout
1 = 3.50 kW triple crown burner
2 = 1.75 kW semi-rapid burner
3 = 3.00 kW rapid burner
4 = 1.00 kW auxiliary burner
10
Specifications – BHG710.5SS
Product dimensions:
Depth: 510 mm
Width: 720 mm
Height: 50 mm
Aperture dimensions:
Depth: 480 mm
Width: 560 mm
Product specifications:
o 1 x 3.00 kW rapid burner
o 2 x 1.75 kW semi-rapid burners
o 1 x 1.00 kW auxiliary burner
o 1 x 3.50 kW triple crown (wok) burner
o Front control operation
o Heavy duty cast iron pan stands
o Automatic ignition
o Flame failure safety device on each burner
Standard accessories:
o LPG conversion jets
Gas hob surface layout
1 = 1.75 kW semi-rapid burner
2 = 1.75 kW semi-rapid burner
3 = 3.50 kW triple crown burner
4 = 3.00 kW rapid burner
5 = 1.00 kW auxiliary burner
11
Loading...