Ayp WET2242STB User Manual

REPAIR PARTS

TRACTOR - - MODEL NUMBER WET2242STB, PRODUCT NUMBER 954 57 08-71

SCHEMATIC

A

AMMETER

(OPTIONAL)

RED

B

G

L

IGNITION

SWITCH

BLACK

RED

BLACK

BATTERY

RED

FUSE

WHITE

RED

M

STARTER

BLACK

SOLENOID

S

M

A1

CLUTCH / BRAKE

(PEDAL UP)

WHITE

A2

SEAT SWITCH

(NOT OCCUPIED)

BLACK

GROUNDING

CONNECTOR

SPARK

PLUG

(2 PLUGS ON

TWIN CYL. ENGINES)

BLACK

GAP

BLUE

BLACK

BLACK

HOUR

METER

(OPTIONAL)

FUEL
LINE

BLACK

WHITE

ATT'MENT CLUTCH

(CLUTCH OFF)

BLACK

IGNITION

UNIT

IGNITION SWITCH

CIRCUITPOSITION

OFF

M+G+A1

B+A1RUN/LIGHT

B+A1RUN

B + S + A1START

“MAKE”

NONE

A2+L

NONE

NONE

28 VOLTS AC MIN. @ 3600 RPM
(CHARGING SYSTEM DISCONNECTED)

DIODE

14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)

FUEL SHUT-OFF SOLENOID

(IF SO EQUIPPED)

ORANGE

CHARGING SYSTEM OUTPUT
3 AMP DC @ 3600 RPM

RED

LIGHTING SYSTEM OUTPUT
5 AMP AC @ 3600 RPM

NOTE

YOUR TRACTOR IS
EQUIPPED WITH A SPECIAL

BROWN

ALTERNATOR SYSTEM.
THE LIGHTS ARE NOT
CONNECTED TO THE
BATTERY, BUT HAVE THEIR
OWN ELECTRICAL SOURCE.
BECAUSE OF THIS, THE
BRIGHTNESS OF THE LIGHTS
WILL CHANGE WITH ENGINE
SPEED. AT IDLE THE LIGHTS
WILL DIM. AS THE ENGINE IS
SPEEDED UP, THE LIGHTS

NON-REMOVABLE

CONNECTIONS

WILL BECOME THEIR BRIGHTEST.

REMOVABLE

CONNECTIONS

WIRING INSULATED CLIPS

NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR

SERVICING OF UNIT, THEY SHOULD BE REPLACED TO
PROPERLY SECURE YOUR WIRING.

ALTERNATOR

BLACK

HEADLIGHTS

27

REPAIR PARTS

TRACTOR - - MODEL NUMBER WET2242STB, PRODUCT NUMBER 954 57 08-71

ELECTRICAL

22

21

42

24

41

43

27

27

33

30

8

27

25

27

27

48

26

40

16

16

52

29

28

2

1

90

28

REPAIR PARTS

TRACTOR - - MODEL NUMBER WET2242STB, PRODUCT NUMBER 954 57 08-71

ELECTRICAL

KEY PART
NO. NO. DESCRIPTION

1 163465 Battery 12 Volt 28 Amp
2 74760412 Bolt Hex Hd 1/4-20unc X 3/4
8 176689 Box Battery
16 176138 Switch Interlock Push -In
21 175685 Harness Asm Light W/4152J
22 4152J Bulb Light #1156
24 4799J Cable Battery 6 Ga 11”red
25 146147 Cable Battery 6 Ga w/16 wire,red
26 175158 Fuse 20 AMP
27 73510400 Nut Keps Hex 1/4-20 unc
28 4207J Cable Ground 6 Ga 12” black
29 121305X Switch Plunger Nc Gray
30 175566 Switch Ign
33 140401 Key Ign
40 179720 Harness Ign
41 71110408 Bolt Blk Fin Hex 1/4-20 X 1/2
42 131563 Cover Terminal Red
43 178861 Solenoid
48 140844 Adapter Ammeter
52 141940 Protection Wire Loop
90 180449 Cover Terminal

NOTE: All component dimensions give in U.S. inches

1 inch = 25.4 mm.

29

REPAIR PARTS

TRACTOR - - MODEL NUMBER WET2242STB, PRODUCT NUMBER 954 57 08-71

CHASSIS AND ENCLOSURES

212

17

208

30

25

26

31

209

209

9

11

207

24

18

12

28

24

25

26

5

5

209

208

53

51

52

55

219

54

58

57

20

29

206

26

3

35

3

3

2

33

3

142

3

10

142

3

14

38

64

219

1

13

37

3

3

3

35

14

34

145

37

208

26

chassis-pl.lt_stlt_48

30

REPAIR PARTS

TRACTOR - - MODEL NUMBER WET2242STB, PRODUCT NUMBER 954 57 08-71

CHASSIS AND ENCLOSURES

KEY PART
NO. NO. DESCRIPTION

1 174619 Chassis
2 176554 Drawbar
3 17060612 Screw 3/8-16x.75
5 155272 Bumper Hood/Dash
9 168336X010 Dash P/L
10 72140608 Bolt Carriage 3/8-16 x 1
11 174996 Panel Dash Lh
12 145660 Clip Tinnerman
13 172105X010 Panel Dash Rh
14 17490608 Screw Thdrol 3/8-16 x 1-1/4
17 159639X550 Hood LT/PL
18 184921 Bumper Hood
20 180679 Tray
24 74780616 Bolt Fin Hex 3/8-16 x 1 Gr 5
25 19131312 Washer 13/32 X 13/16 X 12 Ga
26 73800600 Nut Lock Hex W/Ins 3/8-16 Unc
28 179844 Grille LT/PL
29 170472X599 Lens LT/PL
30 169468X550 Fender Footrest LT Pnt
31 136619 Bracket Support Fender
33 179716X550 Footrest Pnt Lh
34 179717X550 Footrest Pnt Rh
35 72110606 Bolt Rdhd Sht Sqnk 3/8-16 x 3/4
37 17490508 Screw Thdrol 6/16-18 x 1/2 TYT
38 175710 Bracket Asm. Pivot Mower Rear
51 73800400 Nut Lock Hex W/Ins 1/4-20
52 19091416 Washer 9/32 x 7/8 x 16 Ga.
53 144697 Bracjet Grukke Lh
54 161464 Screw Hex Wshd 8-18 x 7/8
55 144696 Bracket Grille Rh
57 74780412 Bolt Hex 1/4-20 x 3/4
58 178000 Duct Air
64 154798 Dash Lower STLT
142 175702 Plate Reinforcement STLT
145 156524 Rod Pivot Chassis/Hood
206 170165 Bolt Shoulder 5/16-18
207 17670508 Screw Thdrol 5/16-18 x 1/2
208 17670608 Screw Thdrol 3/8-16 x 1/2
209 17000612 Screw Hex Wsh Thdr. 3/8-16 x 3/4
212 156229 Insert Lens Refl ect P/L LT
219 17670508 Screw

- - 5479J Plug Btn Blk .359

NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

31

REPAIR PARTS

TRACTOR - - MODEL NUMBER WET2242STB, PRODUCT NUMBER 954 57 08-71

DRIVE

57

89

51

84

13

16

77

145

14

112

85

197

11

52

96

69

26

80

85

30

32

81

10

8

170

21

1

63

212

59

26

66

65

64

50

27

49

47

120

36

27

159

14

163

51

52

74

82

19

158

162

83

165

5

18

6

24

78

76

161

198

32

164

113

30

25

26

2

77

169

18

4

3

6

79

6

75

156

62

168

166

35

29

61

36

56

41

38

39

37

34

28

22

35

70

116

55

202

150

48

151
51

53

32