SCHEMATIC
TRACTOR - - MODEL NUMBER QGT2046A
A
AMMETER
(OPTIONAL)
RED
B
G
L
IGNITION
SWITCH
BLACK
RED
BLACK
BATTERY
RED
FUSE
WHITE
RED
M
STARTER
BLACK
SOLENOID
S
M
A1
CLUTCH / BRAKE
(PEDAL UP)
WHITE
A2
SEAT SWITCH
(NOT OCCUPIED)
BLACK
GROUNDING
CONNECTOR
SPARK
PLUG
(2 PLUGS ON
TWIN CYL. ENGINES)
BLACK
GAP
BLUE
BLACK
BLACK
HOUR
METER
(OPTIONAL)
FUEL
LINE
BLACK
WHITE
ATT'MENT CLUTCH
(CLUTCH OFF)
BLACK
IGNITION
UNIT
IGNITION SWITCH
CIRCUITPOSITION
OFF
M+G+A1
B+A1RUN/LIGHT
B+A1RUN
B + S + A1START
“MAKE”
NONE
A2+L
NONE
NONE
28 VOLTS AC MIN. @ 3600 RPM
(CHARGING SYSTEM DISCONNECTED)
DIODE
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
FUEL SHUT-OFF SOLENOID
(IF SO EQUIPPED)
ORANGE
CHARGING SYSTEM OUTPUT
3 AMP DC @ 3600 RPM
RED
LIGHTING SYSTEM OUTPUT
5 AMP AC @ 3600 RPM
NOTE
YOUR TRACTOR IS
EQUIPPED WITH A SPECIAL
BROWN
ALTERNATOR SYSTEM.
THE LIGHTS ARE NOT
CONNECTED TO THE
BATTERY, BUT HAVE THEIR
OWN ELECTRICAL SOURCE.
BECAUSE OF THIS, THE
BRIGHTNESS OF THE LIGHTS
WILL CHANGE WITH ENGINE
SPEED. AT IDLE THE LIGHTS
WILL DIM. AS THE ENGINE IS
SPEEDED UP, THE LIGHTS
NON-REMOVABLE
CONNECTIONS
WILL BECOME THEIR BRIGHTEST.
REMOVABLE
CONNECTIONS
WIRING INSULATED CLIPS
NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR
SERVICING OF UNIT, THEY SHOULD BE REPLACED TO
PROPERLY SECURE YOUR WIRING.
ALTERNATOR
BLACK
HEADLIGHTS
31
REPAIR PARTS
ELECTRICAL
24
TRACTOR - - MODEL NUMBER QGT2046A
2221
42
41
70
33
30
27
43
27
25
27
27
26
40
16
16
12
8
10
11
D
.C
. A
M
P
E
R
E
S
45
52
29
28
27
55
2
1
12
32
REPAIR PARTS
ELECTRICAL
TRACTOR - - MODEL NUMBER QGT2046A
KEY PART
NO. NO. DESCRIPTION
1 163465 Battery, 12 Volt, 28 Amp
2 74760412 Bolt, Hex Head 1/4-20 UNC x 3/4
8 7603J Tray, Battery
10 145211 Bolt, Battery Front 1/4-20 x 7.5 Zinc
11 150109 Holddown Battery Dash Mount
12 145769 Nut, Push Nylon 1/4" Battery Front
16 153664 Switch Interlock Push-In
21 166181 Harness, Light
22 4152J Bulb, Light
24 4799J Cable, Battery, 6 Gauge, 11", Red
25 146148 Cable, Battery
26 166180 Fuse, 15 Amp
27 73510400 Nut, Hex, Keps 1/4-20 UNC
28 145491 Cable, Ground, 6 Gauge, 12", Black
29 121305X Switch, Plunger
30 163968 Switch, Ignition, Push-In
33 140401 Key, Ignition
40 170217 Harness, Ignition
41 71110408 Bolt, Hex, Fin. 1/4-20 x 1/2
42 131563 Co ver, Term ina l, Re d
43 145673 Solenoid
45 121433X Ammeter, Rectangular, 15 AMP
52 141940 Protection Wire Loop (Hour Meter)
55 17490508 Screw, Thdrol 5/16-18 x 1/2 TYT
70 170243 Harness, Engine
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
33
REPAIR PARTS
CHASSIS
TRACTOR - - MODEL NUMBER QGT2046A
26
31
208
25
20
58
212
53
23
12
51
28
52
55
29
57
24
17
30
25
26
3
11
44
209
15
3
18
24
5
5
9
207
209
33
206
26
3
6
16
3
35
74
10
2
3
108
3
38
35
3
34
3
38
8
3
207
37
26
145
37
54
1
13
208
34
REPAIR PARTS
CHASSIS
TRACTOR - - MODEL NUMBER QGT2046A
KEY PART
NO. NO. DESCRIPTION
1 169831 Chassis Wldmt.
2 169061 Drawbar Stretch 94
3 17060612 Screw 3/8-16 x 3/4
4 19131216 Washer 13/32 x 3/4 x 16 Ga.
5 155272 Bumper Hood/Dash
6 155923 Saddle Flat Lt
8 155138 Clip Retainer Slide-On
9 168348X012 Dash Private Label
10 72140608 Bolt RdHd Sqnk. 3/8-16 Unc x 1
11 156682 Panel Asm. Dash Lh
12 145660 Clip Tinnerman Grile P/L
13 172109 Panel Dash Rh
15 74180512 Screw Mach Trhd 5/16-18 Unc x 3/4
16 73510500 Nut Keps 5/16-18 Unc
17 159639X602 Hood Pnt STL P/L w/trim
18 126938X Bumper Hood
20 156437 Plate Mtg Battery/Fule Tank
23 124028X Bushing Snap Nyl Blk Fuel Line
24 74780616 Bolt Fin Hex 3/8-16 Unc x 1 Gr. 5
25 19131312 Washer 13/32 x 13/16 x 12 Ga.
26 73800600 Nut Lock Hex w/Insert 3/8-16 UNC
28 157373 Grill Private Lable Blk
29 140273X599 Lens Grille Private label
30 167270X602 Fender Asm YTGT
31 137113 Bracket Fender
33 145244X602 Footrest Pnt. Lh
34 145243X602 Footrest Pnt. Rh
35 72110606 Bolt RdHd Sht. Sqnk. 3/8-16 x 3/4
37 17490508 Screw Thdrol 5/16-18 x 1/2 Tyt
38 169834 Bracket Asm Pivot Mower Rear
44 140675 Strap Asm Fender
51 73800400 Nut Lock Hex W/Ins. 1/4-20
52 19091416 Washer 9/32 x 7/8 x 16 Ga.
53 144697 Bracket Grille LH
54 161464 Screw Hex Wshd 8-18 x 7/8
55 144696 Bracket, Grille RH
57 74780412 Bolt Fin Hex 1/4-20 x .75
58 162266 Air Duct Private Label
74 73680600 Nut Crownlock 3/8-16 Unc
108 74760612 Bolt Fin Hex 3/8-16 Unc x 3/4
145 156524 Rod Pivot Chassis/Hood
206 170165 Bolt Shoulder 5/16-18
207 17670508 Screw Thdrol 5/16-18 x 1/2
208 17670608 Screw Thdrol 3/8-16 x 1/2
209 17000612 Screw Hex wsh Thdrol 3/8-16 x 3/4
- - 5479J Plug Btn Blk
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
35
REPAIR PARTS
DRIVE
TRACTOR - - MODEL NUMBER QGT2046A
89
51
84
13
117
85
197
11
16
145
77
85
80
96
51
81
26
90
10
8
30
54
31
21
110
57
59
6
161
164
77
14
163
5
111
26
159
82
2
51
19
74
158
165
24
162
83
156
5
61
76
6
168
166
62
61
29
35
42
56
41
42
40
38
42
39
36
34
28
22
58
198
169
171
4
3
61
79
110
110
25
1
135
51
37
26
63
64
65
27
66
27
49
47
50
51
51
26
36
72
35
70
116
55
202
150
48
151
51
53
36
REPAIR PARTS
DRIVE
TRACTOR - - MODEL NUMBER QGT2046A
KEY PART
NO. NO. DESCRIPTION
1 - - - - - - - Transaxle, Peerless Model 820-
016D (Order Parts From Transaxle
Manufacturer)
2 146682 Spring, Brake Return
3 121327X Pulley, Transaxle (Driven)
4 12000004 Ring, Retainer
5 123787X Strap, Torque
6 17060512 Screw, 5/16-18 x 3/4
8 166020 Rod Shift Fender Adjust Yt
10 76020416 Pin, Cotter 1/8 x 1
11 105701X Washer, Shift Plate
13 74550412 Bolt 1/4-28 UNF Gr. 8 w/Patch
14 10040400 Washer Lock Hvy Helical
19 73800600 Nut, Lock Hex w/Ins. 3/8-16 UNC
21 106933X Knob
22 145340 Rod, Brake
24 73350600 Nut, Hex Jam 3/8-16
25 126909X Spring, Rod, Brake
26 19131016 Washer 13/32 x 5/8 x 16 Ga.
27 76020412 Pin, Cotter 1/8 x 3/4
28 145204 Rod, Brake, Park
29 71673 Cap, Brake Parking Black
30 123780X Bracket, Transaxle, L.H.
31 123791X Keeper, Belt, Transaxle, L.H.
34 155071 Shaft, Foot Pedal
35 120183X Bearing Nylon
36 19211616 Washer 21/32 x 1 x 16 Ga.
37 1572H Pin,Roll 3/16 x 1
38 131494 Idler, Flat
39 72110622 Bolt Rdhd 3/8-16 Unc x 2-3/4 Gr. 5
40 4470J Spacer
41 165838 Keeper, Idler
42 19131312 Washer 13/32 x 13/16 x 12 Ga.
47 127783 Pulley, Idler
48 154407 Bellcrank Clutch Grnd Drv Stl
49 123205X Retainer, Belt
50 74760624 Bolt, Hex 3/8-16 x 1-1/2
51 73680600 Nut, Crownlock 3/8-16
53 105710X Link, Clutch
54 126471X Clip, Insulator
55 105709X Spring, Return, Clutch
56 74760620 Bolt, Hex 3/8-16 x 1-1/4
57 163817 V-Belt, Drive
58 123792X Keeper, Belt, Transaxle, R.H.
59 169595 Keeper Belt Centerspan
61 17060612 Screw 3/8-16 x 3/4
62 8883R Cover, Foot Pedal
KEY PART
NO. NO. DESCRIPTION
63 140186 Pulley, Engine
64 71170764 Bolt, Hex 7/16-20 x 4-1/4
65 10040700 Washer, Lock Hvy Hlcl Spr 7/16
66 154778 Keeper Belt Engine F-proof
70 162848 Keeper Belt Engine
72 19132012 Washer 13/32 x 1-1/4 x 12 Ga.
74 108097X Spacer, Split
76 12000053 E-Ring
77 9396E Key Square 1/4 x 2
79 2228M Key, Woodruff #9
80 123794X Shift Arm
81 165601 Shaft Asm Cross Tapered P820.23"
82 123782X Spr ing, T orsio n
83 19171216 Washer 17/32 x 3/4 x 16 Gauge
84 166230 Link Transaxle P820/23" Zinc
85 150360 Nut Lock Center 1/4-28 Fnthd
89 139992X428 Console, 6 Speed
90 124346X Nut, Washer Head, Self-Thread
1/4
96 4497H Retainer Spring 1” Zinc/cad.
110 74760612 Bolt Hex 3/8-16 x 3/4
111 123776X Bracket, Transaxle, R.H.
116 72110610 Bolt Rdhd Sq Neck 3/8-16 x 1/25
117 19091216 Washer 9/32 x 3/4 x 16 Gauge
135 123800X Washer 1-1/32 x 1-5/8 x 16 Gauge
145 74490540 Bolt Hex Flghd 5/16-18 x Gr. 5
150 165850 Bushing Bellcrank
151 19133210 Washer 13/32 x 2 x 10 Ga.
156 166002 Washer Srrted 5/16ID x 1.125
158 165589 Bracket Shift Mount
159 165494 Hub Tapered Flange Shift Lt
161 72140406 Bolt Rdhd Sqnk 1/4-20 x 3/4 Gr 5
162 73680400 Nut Crownlock 1/4-20 Unc
163 74780416 Bolt Hex Fin 1/4-20 Unc x 1 Gr 5
164 19091010 Washer 5/8 x .281 x 10 Ga
165 165623 Bracket Pivot Lever
166 166880 Screw 5/16-18 x 5/8
168 165492 Bolt Shoulder 5/16-18 x .561
169 165581 Plate Fastening Lt
171 17490608 Screw Thdrol 3/8-16 x 1/2 Ty-Tt
197 169613 Nyliner Snap-In 5/8" Id
198 169593 Washer Nyl 7/8 Id x .105
202 72110612 Bolt Carr Sh 3/8-16 x 1-1/2 Gr.5
NOTE: All component dimensions given in U.S. inches\
1 inch = 25.4 mm
37
REPAIR PARTS
STEERING ASSEMBLY
37
TRACTOR - - MODEL NUMBER QGT2046A
38
63
11
39
1
41
42
37
36
62
23
56
11
44
51
8
27
22
66
40
29
68
29
15
15
54
17
18
19
46
8
6
9
2
7
9
80
79
25
82
29
15
5
3
40
47
65
85
11
10
68
13
46
8
85
32
26
28
30
6
9
67
67
67
47
7
9
5
4
43
43
6
8
38
REPAIR PARTS
STEERING ASSEMBLY
TRACTOR - - MODEL NUMBER QGT2046A
KEY PART
NO. NO. DESCRIPTION
1 140044 Wheel Steering Auto Black
2 154427 Axle Asm Front
3 169840 Spindle Asm Lh
4 169839 Spindle Asm Rh
5 6266H Bearing Race Thrust Harden
6 121748X Washer 25/32 X 1 5/8 X 16ga
7 19272016 Washer 27/32 X 1 1/4 X 16 Ga
8 12000029 Ring Klip #t5304-75
9 3366R Bearing Col Strg Blk
10 169832 Link Drag
11 10040600 Lockwasher
13 136518 Spacer Bearing Axle Front
15 145212 Nut Hex Flange Lock
17 156546 Shaft Asm Strg 5/8 X 15 19 Lt
18 57079 Washer Thrust 515x 750x 033
19 160395 Support Shaft
22 165857 Screw Hex WshHd Torx
23 165851 Shaft Asm Pittman
25 154406 Bracket Steering
26 126847X Bushing Rod Tie Blk Lt
27 136874 Gear Sector
28 19131416 Washer 13/32 X 7/8 X 16ga
29 17060612 Screw 3/8-16x3/4
30 76020412 Pin
32 130465 Rod Tie Wire Form 19 75 Mech
36 155099 Bushing Strg 5/8 Id Dash
37 152927 Screw TT #10-32 x 5 x 3/8 Flange
38 140045 Insert Cap Strg
39 19133812 Washer 13/32 X 2-3/8 X12 Ga
40 7810H Locknut Center
41 100711L Adaptor Wheel Strg 640/ 635id
42 145054X428 Boot Dash Steering
43 121749X Washer 25/32 X 1 1/4 X 16 Ga
44 153720 Extension Steering Non-Adjust
46 121232X Cap Spindle Fr Top Blk
47 6855M Fitting Grease
51 73800500 Nut Lock Hex W/Ins.
54 74780520 Bolt Fin Hex 5/16-18 Unc P
56 19131210 Washer 13/32 x 3/4 x 10 Ga.
62 167902 Kit Steering Assembly Service
63 74780616 Bolt Fin Hex 3/8-16unc x Gr. 5
65 160367 Spacer Axle
66 154404 Bearing Arm Pittman
67 72140618 Bolt Rdhd Sq 3/8-16 Unc x 2-1/4
68 169827 Brace Axle
79 19132012 Washer 13/32 x 1-1/4 x 12 Ga.
80 74950612 Bolt Hex Nylon 3/8-16 x 3/4
82 169835 Bracket Susp Chassis Front
85 133835 Fastner Christmas Tree
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
39
REPAIR PARTS
ENGINE
TRACTOR - - MODEL NUMBER QGT2046A
2
26
15
38
14
81
17
34
33
1
25
32
31
7
16
3
13
17
62
72
8
10
6
5
39
37
40
33
41
29
OPTIONAL EQUIPMENT
Spark Arrester
45
23
4
40
REPAIR PARTS
ENGINE
TRACTOR - - MODEL NUMBER QGT2046A
KEY PART
NO. NO. DESCRIPTION
1 148875 Control, Throttle
2 17720410 Screw, Hex Head, Thread Cutting 1/4-20 x 5/8
3 - - - - - - - Engine, B&S Model Number 407777
(Order Parts From Engine Manufacturer)
4 149723 Muffler
5 159955 Tube, Manifold, LH
6 160589 Tube, Manifold, RH
7 126470X Clip Insulated
8 150176 Bolt 5/16-18 UNC x 3/4 w/Sems
10 162797 Shield, Browning
13 165391 Muffler Gasket
14 13280336 Nipple, Pipe 3/8 NPT x 4-1/2
15 13200300 Elbow, Standard 90° 3/8-18 NPT
16 11050600 Washer, Lock, External Tooth 3/8
17 17490624 Screw Thdrol 3/8-16 x 1-1/2
23 169837 Shield, Browning / Debris Guard
25 145996 Choke Control
26 73920600 Nut, Keps 3/8-24 UNF
29 137180 Kit, Spark Arrestor
31 151346 Tank Fuel 3 50 Rear
32 140527 Cap Asm Fuel W/sym Vented
33 123487X Clamp, Hose
34 106082X Pad, Spacer
37 8543R Line, Fuel
38 - - - - - - - Plug, Oil Drain (Order From Engine Manufacturer)
39 109227X Pad, Idler
40 3645J Bushing
41 139277 Stem, Fuel Tank
45 17000612 Screw Hex wsh Thdrol 3/8-16 x 3/4
62 10040500 Washer Lock 5/16
72 71070512 Screw Hex Hd Cap 5/16-18 x 3/4
81 73510400 Nut Keps Hex 1/4-20 Unc
NOTE: All component dimensions given in U.S. inches.
1 inch = 25.4 mm
41
REPAIR PARTS
MOWER DECK
TRACTOR - - MODEL NUMBER QGT2046A
152
151
158
153
116
157
154
117
153
119
67
156
45
155
39
32
46
33
31
126
58
42
44
129
38
41
85
127
130
69
35
72
52
136
132
42
41
59
135
131
61
62
34
30
50
60
44
31
33
49
36
37
43
30
32
40
21
46
45
106
105
103
47
102
104
105
21
22
118
134
48
19
82
133
18
1
21
29
28
117
15
11
16
14
10
13
9
8
12
51
18
18
3
6
5
23
20
24
104
101
25
26
27
102
103
106
42
REPAIR PARTS
MOWER DECK
TRACTOR - - MODEL NUMBER QGT2046A
KEY PART
NO. NO. DESCRIPTION
1 164210 Deck Asm., Mower 46"
3 138457 Bracket Asm., Sway Bar
5 4939M Retainer Spring
6 130832 Arm, Suspension, Rear (Sway Bar)
8 850857 Bolt, Patched 3/8-24 x 1-1/4 Gr. 8
9 10030600 Washer, Lock Hvy., Unplated 3/8
10 140296 Washer, Hard Blade, Mower Vented
11 170698 Blade Hi-Perf 46"
12 129895 Bearing, Ball, Mandrel #6204
13 137553 Shaft Asm. w/Lower Bearing
(Includes Key No. 12)
14 137152 Housing, Mandrel
15 110485X Bearing, Ball, Mandrel
16 140329 Stripper, Mower Round
18 72140505 Bolt, Carriage 5/16-18 x 5/8
19 132827 Bolt, Hex Head, Shoulder 5/16-18
20 145055 Baffle, Vortex Mower 46"
21 73680500 Nut, Crownlock 5/16-18 UNC
22 134753 Stiffiner, Bracket
23 131267 Bracket, Deflector
24 105304X Cap, Sleeve
25 149287 Spring, Torsion, Deflector
26 110452X Nut, Push
27 166883 Shield, Deflector Mower
28 19111016 Washer 11/32 x 5/8 x 16 Ga.
29 131491 Rod, Hinge
30 157722 Screw, Thdroll Washer Head
31 129963 Washer, Spacer Mower Vented
32 153531 Pulley, Mandrel
33 137266 Nut, Flg. Top Lock Cntr. 9/16
34 144945 Anchor, Spring Deck 46"
35 17490628 Screw, Thdroll 3/8-16 x 1-3/4 Tytt
37 131494 Pulley, Idler, Flat
38 156085 Keeper, Belt, Idler
39 144917 Pulley, Idler, Driven
40 137273 Spring, Secondary 44/46/50 Vent
41 17060620 Screw 3/8-16 x 1-1/4
42 165723 Spacer, Retainer
43 144949 Arm, Idler Secondary
44 133943 Washer, Hardened
45 145059 Cover, Mandrel Deck
46 137729 Screw, Thdroll. 1/4-20 x 5/8
47 144959 V-Belt, Mower, Secondary
48 139573 V-Belt, Mower, Primary
49 73680600 Nut, Crownlock 3/8-16 UNC
50 72110612 Bolt, Carriage 3/8-16 x 1-1/2 Gr. 5
51 153390 Washer Felt
52 165888 Pulley Idler Flat
KEY PART
NO. NO. DESCRIPTION
58 165906 Rod Brake 46"
59 157034 Guide Bolt 46" Mower Dr
60 156722 Arm Asm Brake 46"
61 161315 Bolt Shld 5/16-18
62 131870 Spring Return
67 106932X Knob Rd 3/8-16 Plstc Thds Blk
69 73350600 Nut Hex Jam 3/8-16 Unc
72 19131316 Washer 13/32 x 1 x 16 Ga.
82 4497H Retainer Spring
85 10040600 Washer Lock 3/8
101 145579 Cover Mulcher 46" Black
102 71161010 Screw Truss Hd Phil 10-24 x 5/8
103 10071000 Washer Lock #10
104 19061216 Washer #10
105 130758 Latch Asm Bagger
106 2029J Nut Weld .327/.304 #10-24
116 4898H Bolt, Shoulder
117 165746 Gauge Wheel
118 73930600 Nut, Centerlock 3/8-16 UNC
119 19121414 Washer 3/8 x 7/8 x 14 Ga.
126 156472 Arm, Idler, Primary Deck 46"
127 146763 Pulley, Idler, V-Groove Dim. 4.25
129 19133808 Washer 13/32 x 2-3/8 x 8 Ga
130 165891 Bolt Carriage Idler
131 169022 Spring Return Idler
132 165890 Arm Spring Brake Mower
133 165904 Bracket Anchor Cable 46"
134 17490512 Screw Thdrol5/16-18 x 3/4
135 165898 Re tain er Sp ring Yel low
136 19091216 Washer 9/32 x 3/4 x 16 Ga
151 169670 Bracket Clutch Cable
152 170328 Clutch Cable 38"/46"
153 169674 Washer Flat 3/8" Type B
154 169675 Spring Retainer
155 169671 Spring Retension Q
156 169672 SPacer Clutch Cable
157 169669 Rod Clutch Cable 3/8"
158 17720410 Screw Hex Thd Cut 1/4-20 x 5/8
- - 143651 Mandrel Asm 44"/46"/50" Service
- - 152443 Blade Mulch 46"
- - 172497 Deck Complete (Std. Deck-Order
separately mulch plateand gauge
wheel components Key Nos. 101106 and 116-118)
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
43
REPAIR PARTS
MOWER LIFT
TRACTOR - - MODEL NUMBER QGT2046A
10
7
8
9
1
13
11
19
13
46
12
47
13
20
15
14
2
6
20
18
17
16
20
13
31
32
31
32
19
42
43
39
44
44
20
15
REPAIR PARTS
MOWER LIFT
TRACTOR - - MODEL NUMBER QGT2046A
KEY PART
NO. NO. DESCRIPTION
1 121006X Rod Assembly, Lever
2 159188 Shaft Assembly, Lift
6 74780624 Bolt, Hex Head, Fin. 3/8-16 x 1-1/2
7 109413X Grip Handle
8 124526X Button Plunger Black
9 122364X Plunger Lever Lift
10 2876H Spring
11 145537 Link, Lift, LH
12 145536 Link, Lift, RH
13 4939M Retainer Spring
14 159189 Lever Assembly, Lift, RH
15 173288 Link, Front
16 73350800 Nut, Hex, Jam 1/2-13 UNC
17 130171 Trunnion
18 73800800 Nut Lock W/Wsh 1/2-13 Unc
19 139868 Arm, Suspension, Rear
20 163552 Retainer Spring
31 169865 Bearing
32 73540600 Nut, Crownlock 3/8-24
39 142992 Stop Over Center
42 73680600 Nut, Crownlock 3/8-16 UNC
43 19131612 Washer 13/32 x 1 x 12 Ga.
44 72240608 Bolt, Carriage 3/8-16 x 1.00
46 12000022 E-Ring
47 19292016 Washer
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
45
REPAIR PARTS
SEAT ASSEMBLY
TRACTOR - - MODEL NUMBER QGT2046A
1
18
28
28
14
16
15
24
11
25
7
10
27
5
7
5
6
22
2
21
13
17
KEY PART
NO. NO. DESCRIPTION
1 127428 Seat
2 140551 Pivot Bracket, Seat
5 145006 Clip, Push-in Hinged
6 73800600 Nut, Lock Hex w/Ins 3/8-16 UNC
7 124181X Spring, Seat
10 155925 Pan, Seat
11 166369 Knob, Seat, Black
12 121246X Bracket, Switch Mounting
13 121248X Bushing, Snap, Black, Nylon
14 72050412 Bolt, Carriage 1/4-20 x 1-1/2
15 134300 Spacer, Split .28 x .96
12
KEY PART
NO. NO. DESCRIPTION
16 121250X Spring
17 123976X Locknut, Flange 1/4 Grade 5
18 124238X Cap Spring Seat Blk 1.75 x 1.0
21 171852 Bolt, Shoulder 5/16-18 Unc -2A
22 73800500 Nut Lock Hex W/Ins 5/16-18 Unc
24 19171912 Washer 17/32 x 1-3/16 x 12 Gauge
25 127018X Bolt, Shoulder 5/16-18 x .62
27 17490608 Screw Thdrol 3/8-16 x 3/4
28 171877 Bolt 5/16-18 UNC x 3/4 w/Sems
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
46
REPAIR PARTS
DECALS
TRACTOR - - MODEL NUMBER QGT2046A
11
9
1
KEY PART
NO. NO. DESCRIPTION
1 172372 Decal Fender
2 172376 Decal Side Panel
3 172580 Decal Hood LH
4 172579 Decal Hood RH
5 173000 Decal HP Engine
6 168427 Decal Battery
7 157002 Decal Danger Fender English
8 4900J Decal Clutch/brake English
9 173256 Decal Chassis
10 139346 Decal V-Belt Sch
11 172375 Decal Steering
17
12
10
4
5
18
16
2
3
16
2
6
14
8
19
15
KEY PART
NO. NO. DESCRIPTION
12 156876 Decal Oper sDL Eng/Fr
13 106202X Reflector Taillight
14 145005 Decal, Btry Dngr/Psn
15 170563 Decal, Warning Mower
16 173260 Decal Panel
17 172584 Decal Fender Side
18 172913 Decal Replacement Hood
19 168548 Decal Deck Mulch/Vented
- - 157199X428 Pad, Footrest
- - 138311 Decal Handle Lft Height Adjust
- - 172749 Manual, Owner's (English)
9
13
13
7
17
WHEELS & TIRES
1
2
6
5,8
KEY PART
NO. NO. DESCRIPTION
1 59192 Cap Valve Tire
2 65139 Stem Valve
4,10
7
3,9
11
3 106222X Tire Front
4 59904 Tube Front (Service Item Only)
5 106732X427 Rim Asm 6" front
6 278H Fitting Grease (Front Wheel Only)
7 9040H Bearing Flange (Front Wheel nly)
8 124074X427 Rim Asm 12" rear
9 140183 Tire R 23 x 9.5-12 C Service
10 7154J Tube Rear (Service Item Only)
11 104757X Cap Axle Blk 1 50 X 1 00
- - 144334 Sealant, Tire (1 Doz. Tube)
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm
47
Loading...