AYP PPR17H42STC User Manual

SCHEMATIC

TRACTOR - - MODEL NUMBER PPR17H42STC

RED

BATTERY

BLACK

A

AMMETER

(OPTIONAL)

RED

B

G

L

IGNITION

SWITCH

BLACK

RED

FUSE

WHITE

RED

M

STARTER

BLACK

SOLENOID

S

M

A1

CLUTCH / BRAKE

(PEDAL UP)

WHITE

A2

SEAT SWITCH

(NOT OCCUPIED)

WHITE

BLACK

BLACK

HOUR

ATT'MENT CLUTCH

BLACK

(CLUTCH OFF)

BLACK

BLACK

GROUNDING

CONNECTOR

METER

BLUE

(OPTIONAL)

FUEL
LINE

BLACK

CHARGING SYSTEM OUTPUT
3 AMP DC @ 3600 RPM

IGNITION

UNIT

28 VOLTS AC MIN. @ 3600 RPM
(CHARGING SYSTEM DISCONNECTED)

SPARK

PLUG

GAP

(2 PLUGS ON

TWIN CYL. ENGINES)

IGNITION SWITCH

CIRCUITPOSITION

OFF

M+G+A1

B+A1RUN/LIGHT
B+A1RUN

B + S + A1START

“MAKE”

NONE

A2+L
NONE
NONE

FUEL SHUT-OFF SOLENOID

(IF SO EQUIPPED)

ORANGE

RED

LIGHTING SYSTEM OUTPUT
5 AMP AC @ 3600 RPM

DIODE

14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)

NOTE

YOUR TRACTOR IS
EQUIPPED WITH A SPECIAL

BROWN

ALTERNATOR SYSTEM.
THE LIGHTS ARE NOT
CONNECTED TO THE
BATTERY, BUT HAVE THEIR
OWN ELECTRICAL SOURCE.
BECAUSE OF THIS, THE
BRIGHTNESS OF THE LIGHTS
WILL CHANGE WITH ENGINE
SPEED. AT IDLE THE LIGHTS
WILL DIM. AS THE ENGINE IS
SPEEDED UP, THE LIGHTS

NON-REMOVABLE

CONNECTIONS

WILL BECOME THEIR BRIGHTEST.

REMOVABLE

CONNECTIONS

WIRING INSULATED CLIPS

NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR

SERVICING OF UNIT, THEY SHOULD BE REPLACED TO
PROPERLY SECURE YOUR WIRING.

ALTERNATOR

BLACK

HEADLIGHTS

27

REPAIR PARTS

TRACTOR - - MODEL NUMBER PPR17H42STC

ELECTRICAL

42

24

43

27

41

27

26

2221

70

40

25

27

D.C. AMPERES

45

16

16

52

29

27

33

30

8

27

2

1

28

28

REPAIR PARTS

TRACTOR - - MODEL NUMBER PPR17H42STC

ELECTRICAL

KEY PART
NO. NO. DESCRIPTION

1 144925 Battery 12 Volt 25 Amp
2 74760412 Bolt Hex Hd 1/4-20unc X 3/4
8 156417 Case Battery Mech Hinge
16 153664 Switch Interlock Push-In
21 166181 Harness Socket Light
22 4152J Bulb, Light # 1156
24 4799J Cable Battery
25 146147 Cable Battery 6 Ga Red w/16 wire
26 166180 Fuse 15 Amp
27 73510400 Nut Keps Hex 1/4-20 Unc
28 4207J Cable Ground 6ga 12 black
29 121305X Switch Plunger Nc Gray
30 163968 Switch Ign
33 140401 Key Ign
40 170217 Harness Ign
41 71110408 Bolt Fin Hex 1/4-20uncx 1/2
42 131563 Cover Terminal Red
43 145673 Solenoid
45 121433X Ammeter Rectangular
52 141940 Protection Loop
70 170243 Harness Engine

NOTE: All component dimensions given in U.S. inches

1 inch = 25.4 mm

29

REPAIR PARTS

TRACTOR - - MODEL NUMBER PPR17H42STC

CHASSIS AND ENCLOSURES

17

208

26

30

11

31

25

24

18

12

28

24

25

26

3

208

9

207

5

5

208

53

51

54

52

55

207

57

20

58

23

29

206

26

3

35

3

3

2

33

3

142

3

10

142

3

3

38

64

207

1

13

37

3

3

3

35

3

34

145

37

208

26

30

REPAIR PARTS

TRACTOR - - MODEL NUMBER PPR17H42STC

CHASSIS AND ENCLOSURES

KEY PART
NO. NO. DESCRIPTION

1 169830 Chassis
2 169061 Drawbar
3 17060612 Screw 3/8-16x3/4
5 155272 Bumper Hood/Dash
9 168337X012 Dash P/L
10 72140608 Bolt Carriage 3/8-16 x 1
11 155927 Panel Dash Lh
12 145660 Clip Tinnerman
13 172108 Panel Dash Rh
17 159639X428 Hood LT/PL
18 126938X Bumper Hood
20 156437 Plate Mtg Battery Fuel Tank Fr
23 124028X Bushing
24 74780616 Bolt Fin Hex 3/8-16 x 1 Gr 5
25 19131312 Washer 13/32 X 13/16 X 12 Ga
26 73800600 Nut Lock Hex W/Ins 3/8-16 Unc
28 157428 Grille LT/PL
29 146654X599 Lens LT/PL
30 169468X428 Fender Footrest LTST Pnt
31 136619 Bracket Fender
33 145244X428 Footrest Pnt Lh
34 145243X428 Footrest Pnt Rh
35 72110606 Bolt Rdhd Sht Sqnk 3/8-16 x 3/4
37 17490508 Screw Thdrol 6/16-18 x 1/2 TYT
38 169834 Bracket, Asm. Pivot, Mower Rear
51 73800400 Nut Lock Hex W/Ins 1/4-20
52 19091416 Washer 9/32 x 7/8 x 16 Ga.
53 144697 Bracjet Grukke Lh
54 161464 Screw Hex Wshd 8-18 x 7/8
55 144696 Bracket Grille Rh
57 74780412 Bolt Hex 1/4-20 x 3/4
58 150127 Duct Air
64 154798 Dash Lower STLT
142 165867 Plate Reinforcement STLT
145 156524 Rod Pivot Chassis/Hood
206 170165 Bolt Shoulder 5/16-18
207 17670508 Screw Thdrol 5/16-18 x 1/2
208 17670608 Screw Thdrol 3/8-16 x 1/2

- - 5479J Plug Btn Blk

NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

31

REPAIR PARTS

TRACTOR - - MODEL NUMBER PPR17H42STC

DRIVE

89

69

197

81

32

30

16

52

169

10

57

21

198

164

8

161

14

163

82

159

52

165

158

162

83

156

62

32

59

168

166

61

36

35

41
42
40

38

42

56

51

51

34

42

39

37

66

64

63

65

27

49

47

51

51

50

26

36

72

35

70

116

202

150

48

151
51

77

15

96

26

95

1

16

77

26

74

30

25

75

26

19

24

29

32

61

78

76

71

22

28

73

200

16

16

26

84

53

27

55

199

61