Aussie WALK-A-BOUT 4280 User Manual
Model 4280
Walk-A-Bout™ Gas
LP Gas Grill Users Manual
1 lb propane cylinder not included
For Outdoor Household Use Only. Not for Commercial Use.
DANGER
!
If you smell gas:
1. Shut off gas to the appliance.
2. Extinquish any open flame.
3. Open lid.
4. If odor continues, keep away from
the appliance and immediately call
your gas supplier or your fire
department.
Failure to follow these instructions could
result in fire or explosion which could
cause property damage, personal injury or death.
WARNING
!
• This instruction manual contains important information necessary for
the proper assembly and safe use of
this appliance. Failure to follow these
instructions could result in death or
serious injury from explosion or fire.
• Read and follow all warnings and instructions carefully before assembling
or using this appliance.
• Follow all warnings and instructions
when using this appliance.
• Keep this manual for future reference.
SAVE THESE INSTRUCTIONS.
Need Help? Need to Register Your Grill? Looking for Aussie Parts & Accessories?
Visit us online at www.AussieGrills.com Or call Aussie Customer Service at 1-800-251-7558
2
DANGER
!
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide, an odorless toxic gas. Using it in an enclosed space can kill you. Never use this appliance in an
enclosed space, such as a camper, tent, car, or home. This appliance is
not intended for and should never be used as a heater.
WARNING
!
To reduce the risk of serious injury or death from fire or explosion:
• Never use alcohol, prescription or non-prescription drugs while assembling or safely operating this appliance.
• Do not connect LP Gas Cylinder until assembly is complete.
• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or
any other appliance.
• An LP cylinder not connected for use shall not be stored in the vicinity of this or any other
appliance.
Meco Corporation strives to be a quality supplier of consumer products. If we omitted any parts
needed for assembly, or you need troubleshooting information, please contact us using our toll
free number or visit our website.
It is important to register your grill and retain your receipt.
1-800-251-7558
8 am - 5 pm E.S.T. Monday - Friday
1-423-639-1171 (Telephone)
1-423-639-2570 (Fax)
Assembled in the United States from component parts from China and the United States.
www.aussiegrills.com
Consumer Service Department
MECO CORPORATION
1500 Industrial R o a d
Greeneville, TN 37745 USA
Contents
Preparation for Assembly .......................................... 3
Packing List
Model 4280 ..................................................................3
Assembly Instructions
Set Up Instructions........................................................ 4
Using Gas
LP Gas Cylinder ............................................................ 5
LP Regulator .................................................................5
Connecting/ Disconnecting LP Gas Cylinder .................6
How to Perform a Leak Test ..........................................6
Before Using Your LP Gas Grill
Installation Codes .........................................................7
Selecting a Location ..................................................... 7
Lighting the Grill ...........................................................7
Lighting Grill Using the Pulse-Spark Ignitor .................. 8
Manually Lighting the Grill ...........................................8
Check the Flame .......................................................... 9
End of Cooking Session ................................................ 9
Care and Maintenance
Cleaning the Grill ....................................................... 10
Storage and Transportation ........................................ 10
How to Clean the Burners .......................................... 11
Cooking on the Gas Grill
Grill Cooking (Direct Method) .....................................12
Roasting (Indirect Method) ..........................................13
Emergencies ............................................................ 13
Troubleshooting....................................................... 14
Replacement Parts
Parts List and Illustrations ...........................................15
Limited Warranty....................................................... 16
Register your grill and retain your receipt.
If you need a replacement part under warranty, a
proof of purchase will be necessary.
3
CAUTION
!
To reduce the risk of a laceration hazard, wear protective gloves when handling parts that have sharp edges.
Preparation for Assembly
This Grill is pre-assembled. Unlock Hood Latch. (See Illustration) Remove Cooking Grid, Grease Cup, Wire Grease Cup
Holder and Owner’s Manual from the grill. Make sure there are no loose parts before discarding packing materials.
Packing List
Owner’s Manual and
Warranty Card (not pictured)
Grill Body
Grease Cup
Wire Grease Cup Holder
Cooking Grid
Detailed Parts List and Illustrations
may be found on page 15.
For easier set-up, follow instructions of each step in the order they are written as you look at the diagrams.
If you have any questions or need help, contact Customer Service at 1-800-251-7558 or go to www.aussiegrills.
com. Be sure to have the grill model number and serial number printed on the black label, located on the underside of
the control panel. If you need replacement parts, look in the Parts List Section to find the exact parts you need. If you
need a replacement part under warranty, a proof of purchase will be necessary. You will be asked to forward
your proof of purchase via e-mail or to fax your proof of purchase to 423-639-1055 and reference your model and serial number. It is important to register your grill and retain your receipt.
4
Set-Up Instructions
CAUTION
!
PI NC H H AZ A R D
To reduce the risk of bodily
injury from pinch hazard, keep
hands and fingers away from
hinges and leg pivot points.
Read and follow these instructions to set up your grill.
Step 3
Swing Legs away from grill body until
they are straight out as shown.
Step 1
Lay grill on its side. Place on grass or a
soft surface to prevent paint damage.
Step 4
Grasp the inner leg near the grill body
and pull it toward the back of the grill.
Step 2
Swing Pivot Latch away from the Leg
Crossrod to allow the legs to pivot.
Pivot Latch
Crossrod
Step 5
Slide the Leg Hook Wire on to the Bowl
Bracket until it stops at the back of the
Bracket. Be sure to allow the Safety Latch
to drop down behind the Leg Hook to
prevent the Hook from sliding off of the
Bracket.
Bowl
Bracket
Safety Latch
Leg
Step 6
Stand facing the top of the hood and
grasp the grill by the Control Panel
Handle and the hood flange at the rear.
Lift and rotate the grill until it is standing
upright on the ground.
Step 7
Install the Wire Grease Cup Holder by
first removing the Cooking Grid. Next,
holding the Wire by the small loop at the
top, thread the end down through the
small hole in the center of the bottom of
the grill bowl until the wire is hanging by
the small loop.
Wire
Grease Cup
Holder
Leg Hook
Step 8
Install the Grease Cup in the Wire
Holder by reaching under the grill
a n d s l i d i n g t h e c u p i n t o t h e w i r e .
Replace the Cooking Grid.
Grease Cup
Using Gas
LP Gas Cylinder
DANGER
!
If you see, smell, or hear the hiss of LP gas escaping from the cylinder:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
Carbon Monoxide Hazard
• This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you.
• Never use this appliance indoors, on recreational vehicles, or boats.
WARNING
!
To reduce the risk of serious injury or death from fire or explosion:
• Use only propane gas with this LP gas grill.
• Do not attempt to convert an LP unit to natural gas.
• Always use a gas appliance outdoors in an open area with good ventilation to avoid breathing toxic fumes from
leaking gas. As with all conventional fuels, the burning process consumes oxygen and produces toxic gases, including carbon monoxide. In addition, the combustion products of such fuels, including liquefied petroleum (LP), contain
chemicals known to the state of California and other authorities to cause cancer, birth defects, and other reproductive harm.
• Read and follow all warnings on LP Gas Cylinder.
• Do not operate the LP gas grill without the LP Gas Cylinder oriented as shown in Assembly Instructions for Connecting the LP Gas Cylinder.
• Never connect or disconnect LP Gas Cylinder or fittings while grill is in use or is hot.
• Do not use an LP Gas Cylinder if it has a damaged valve or shows signs of dents, gouges, bulges, fire damage,
corrosion, leakage, excessive rust, or other forms of visual external damage; it may be hazardous and should
be checked by a liquid propane supplier.
• Do not store a spare LP Gas Cylinder under or near the LP gas grill.
• When grill is not in use, turn off all grill Control Knobs and disconnect LP Gas Cylinder.
• Never fold or transport grill while LP cylinder is attached.
• Never refill a 1 lb. cylinder.
5
The LP Gas Cylinder, for use with this LP gas grill, must meet the following requirements:
1. 1 lb. capacity
2. Must be constructed and marked in accordance with Specifications for LP Gas Cylinders of the U.S. Department
of Transportation (DOT) or the National Standard of Canada, CAN\CSA-B339, Cylinders, Spheres and Tubes for
Transportation of Dangerous Goods; and Commission, as applicable (See collar for marking)
3. Must be marked “PROPANE.”
4. Must be provided with a cylinder connection device that is compatible with the grill’s connection.
LP Regulator
WARNING
!
To reduce the risk of serious injury or death from fire or explosion:
• Clean and inspect the gas regulator before each use of the outdoor cooking gas appliance. Replace the gas
regulator prior to being used if there is evidence of excessive abrasion or wear.
• Use only the gas regulator assembly that has been supplied with this gas grill. Do not use a regulator from
another manufacturer. Replacement gas regulator assembly must be specified by this grill’s manufacturer before
using.
• Always check for gas leaks when you connect and disconnect the regulator to the LP Gas Cylinder, especially
after a period of storage (for example, over winter).
Any use or alteration of this unit not intended could be unsafe and will void your warranty.
Loading...