Aussie 6T01U00SS1 User Manual

Table Top Grill
6T01U00SS1

LP Gas Grill Users Manual

For Outdoor Household Use Only. Not for Commercial Use.

DANGER

!

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from
the appliance and immediately call
your gas supplier or your fire

department.

Failure to follow these instructions could

result in fire or explosion which could
cause property damage, personal in­jury or death.

Need Help? Need to Register Your Grill? Looking for Aussie Parts & Accessories?

Visit us online at www.AussieGrills.com Or call Aussie Customer Service at 1-800-251-7558

• This instruction manual contains im­portant information necessary for
the proper assembly and safe use of
this appliance. Failure to follow these
instructions could result in death or
serious injury from explosion or fire.

• Read and follow all warnings and in­structions carefully before assembling
or using this appliance.

• Follow all warnings and instructions
when using this appliance.

• Keep this manual for future reference.

SAVE THESE INSTRUCTIONS.

WARNING

!

2

DANGER

!

CARBON MONOXIDE HAZARD

This appliance can produce carbon monoxide, an odorless toxic gas. Us­ing it in an enclosed space can kill you. Never use this appliance in an
enclosed space, such as a camper, tent, car, boat or home. This appli­ance is not intended for and should never be used as a heater.

WARNING

!

To reduce the risk of serious injury or death from fire or explosion:

• Never leave grill unattended

• Never use alcohol, prescription or non-prescription drugs while assembling or safely operat­ing this appliance.

• Keep children and pets away at all times.

• Do not connect to the LP Gas supply until assembly is complete.

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or
any other appliance.

• An LP cylinder not connected for use shall not be stored in the vicinity of this or any other
appliance.

• Always have a type BC or ABC fire extinguisher readily available.

CAUTION

!

To reduce the risk of a laceration hazard, wear protective gloves when handling parts that have

sharp edges.

NOTICE

Meco Corporation strives to be a quality supplier of consumer products. If we omitted

any parts needed for assembly, or you need troubleshooting information, please

contact us using our toll free number or visit our web site.

It is important to register your grill and retain your receipt.

1-800-251-7558
8 am - 5 pm E.S.T. Monday - Friday
1-423-639-1171 (Telephone)
1-423-639-2570 (Fax)

Register your grill @

www.aussiegrills.com

Tools Required for Assembly:

Consumer Service Department
MECO CORPORATION
1500 Industrial R o a d
Greeneville, TN 37745 USA

Phillips Screwdriver

Packing List

Grill Body
Regulator Housing Assembly
Warming Rack (inside)
Cooking Grid (inside)
Flavor Activator (inside)
Owner’s Manual and

Warranty Card (not pictured)

Detailed Parts List and Illustrations
may be found on pages 18 and 19.

When ordering parts, it is VERY important
to have the complete Model Number

to receive the correct replacement parts for
your grill. The grill model number and serial
number are printed on the label located on
the inside surface of the rear leg.

3

Contents

Packing List ..................................................................3

Preparation for Assembly .......................................... 4

Grill Assembly Instructions

Regulator-Valve Housing Assembly ..............................4

Drip Tray Access ...........................................................5

Table Top Use ............................................................... 5

Using Gas

LP Gas Cylinder ............................................................ 6

LP Regulator .................................................................6

Connecting LP Gas Cylinder .........................................7

Disconnecting LP Gas Cylinder ..................................... 7

Before Using Your LP Gas Grill

Installation Codes .........................................................8

Selecting a Location ..................................................... 8

Performing a Leak Test ................................................. 8

How to Perform a Leak Test ..........................................9

Lighting the Grill

Lighting Grill Using the Pulse-Spark Ignitor ................ 10

Manually Lighting the Grill ......................................... 11

Check the Flame ........................................................ 11

Cooking on the Gas Grill

Grill Cooking (Direct Method) .....................................12

Warming Rack ............................................................ 13

End of Cooking Session .............................................. 13

Storage and Transportation ........................................ 13

Care and Maintenance

Cleaning the Grill ....................................................... 14

How to Clean the Burners .......................................... 14

Emergencies ............................................................ 16

Troubleshooting....................................................... 17

Replacement Parts

Parts Illustration .........................................................18

Parts List... .................................................................. 19

Limited Warranty.......................................................20

Register your grill @ www.aussiegrills.com
and retain your receipt.

If you need a replacement part under warranty, a
proof of purchase will be necessary.

4

Preparation for Assembly

Remove grill and all packaging materials from the carton and place on a clean level surface. Some parts are packed
inside the grill body. Remove, unpack and inspect these parts as well.

NOTE: Before using your grill, read the instructions and your manual.

For easier set-up and assembly, follow instructions of each step in the order they are written as you look at the dia­grams. If accessories mentioned in certain assembly steps do not come with your model, skip that step and proceed to
the next step that applies to your model.

If you have any questions or need help, go to www.aussiegrills.com or contact Customer Service at 1-800-251-

7558. Be sure to have the grill model number and serial number printed on the label located on the inside surface of the
rear leg. If you need replacement parts, look in the Parts List Section to find the exact parts you need. If you need a
replacement part under warranty, a proof of purchase will be necessary. You will be asked to forward your
proof of purchase via e-mail to [e-mail] or to fax your proof of purchase to 423-639-1055 and reference
your model and serial number. It is important to register your grill and retain your receipt.

Grill Assembly Instructions

Regulator-Valve Housing Assembly

Insert the end of the regulator valve nozzle into the open end of the burner tube (venturi). Align the holes in Regulator
Housing with the threaded holes in the grill firebowl and insert two 5/32 x .31” Bolts through the holes in the housing
into the threaded holes in the firebox. Tighten the bolts securely.

View shown without
Housing for clarity

Burner Venturi Hole fits
centrally around Regulator
Valve nozzle.

WARNING

!

To reduce the risk of serious injury or death from fire or explosion:

• Be sure the grill has cooled completely before removing the drip tray.

• Be sure to empty and re-install the drip tray after each use.

CAUTION

!

To reduce the risk of a laceration hazard, wear protective gloves when handling parts that have sharp edges.

Drip Tray Access

The Drip Tray is accessed for cleaning by
rotating the spring tab and sliding the tray out
from under the grill.

5

Note:
Shown without Igniter
Housing for clarity

Spring Tab

Drip Tray

Table Top Use

Unfold the legs, as shown and place grill on a
level surface.

When legs are unfolded completely they will
snap into the open position. Dimples in the legs
help them remain in position. To close, simply ap­ply enough pressure to overcome the friction fit.

6

Using Gas

LP Gas Cylinder

DANGER

!

If you see, smell, or hear the hiss of LP gas escaping from the cylinder:

1. Do not attempt to light appliance.

2. Extinguish any open flame.

3. Disconnect from fuel supply.
Carbon Monoxide Hazard

• This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you.

• Never use this appliance indoors, on recreational vehicles, or boats.

WARNING

!

To reduce the risk of serious injury or death from fire or explosion:

• Use only propane gas with this LP gas grill.

• Do not attempt to convert this LP unit to natural gas.

• Always use a gas appliance outdoors in an open area with good ventilation to avoid breathing toxic fumes from
combustion or leaking gas. As with all conventional fuels, the burning process consumes oxygen and produces toxic
gases, including carbon monoxide. In addition, the combustion products of such fuels, including liquefied petroleum
(LP), contain chemicals known to the state of California and other authorities to cause cancer, birth defects, and
other reproductive harm.

• Read and follow all warnings on LP Gas Cylinder.

• Do not operate the LP gas grill without the LP Gas Cylinder oriented as instructed in “Connecting LP Gas Cylinder”
on page 7.

• Never connect or disconnect LP Gas Cylinder or fittings while grill is in use or is hot.

• Do not use an LP Gas Cylinder if it has a damaged valve or shows signs of dents, gouges, bulges, fire damage,
corrosion, leakage, excessive rust, or other forms of visual external damage; it may be hazardous and should
be checked immediately by a liquid propane supplier.

• Do not store a spare LP Gas Cylinder under or near the LP gas grill.

• When grill is not in use, turn off all grill Control Knobs and disconnect LP Gas Cylinder.

• Never fold or transport grill while LP cylinder is attached.

• Never refill a 1 lb. cylinder.

The LP Gas Cylinder, for use with this LP gas grill, must meet the following requirements:

1. 1 lb. capacity

2. Constructed and marked in accordance with Specifications for LP Gas Cylinders of the U.S. Department of Trans­portation (DOT) or the National Standard of Canada, CAN\CSA-B339, Cylinders, Spheres and Tubes for Trans­portation of Dangerous Goods; and Commission, as applicable (See collar for marking)

3. Marked “PROPANE.”

4. Provided with a cylinder connection device that is compatible with the grill’s connection.

LP Regulator

WARNING

!

To reduce the risk of serious injury or death from fire or explosion:

• Clean and inspect the gas regulator before each use of the outdoor cooking gas appliance. Replace the gas
regulator prior to being used if there is evidence of excessive abrasion or wear.

• Use only the gas regulator assembly that has been supplied with this gas grill. Do not use a regulator from
another manufacturer. A replacement gas regulator must be specified by this grill’s manufacturer before using.

• Always check for gas leaks (see page 9) when you connect and disconnect the regulator to the LP Gas Cylinder,
especially after a period of storage (for example, over winter).

Any use or alteration of this unit inconsistant with these instructions could be hazardous and will void your warranty.