Ashley P414776 User Manual
Outdoor Round Fire Pit Table User Guide
ITEM#:P414-776
SAVE THESE INSTRUCTIONS
Product has been CSA tested and certified.
THIS PROODUCT WAS MANUFACTURED BY QUANZHOU SANSHUI COMPOSITE MATERIALS INDUSTRY AND TRADE CO.,LTD. FOR ASHLEY FURNITURE INDUSTRIES, INC.
P414-776
Page 1 of 46
IMPORTANT, FAILURE TO CAREFULLY READ, UNDERSTAND AND FOLLOW EVERY PART
OF THIS DOCUMENT MAY RESULT IN PROPERTY DAMAGE, SERIOUS BODILY INJURY
OR DEATH
ASSEMBLY INSTRUCTIONS
Installer: Leave these instructions with consumer.
Consumer: Keep these instructions for future reference.
SAFETY INFORM ATION
!
CSA MODEL S5-012
FOR USE WITH 20LB (9KG) PROPANE CYLINDER
WITH TYPE 1 CONNECTION OR FOR USE WITH
NATURAL GAS AFTER CONVERSION KIT IS
INSTALLED (MUST BE PROFESSIONALLY
INSTALLED) ALSO THE LP REGULATOR MUST BE
SUPPLIED BY THE MANUFACTURER.
WARNING
!
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
An LP-cylinder not connected for use shall not be stored
in the vicinity of this or any other appliance.
WARNING
!
USE FACTORY APPROVED REPLACEMENT PARTS
AND ACCESSORIES ONLY. USE OF UNAPPROVED
PART OR ACCESSORIES CAN VOID THE WARRANTY
ON THIS PRODUCT AND RESULT IN AHAZARDOUS\
CONDITION. PLEASE CONTACT US FOR
INFORMATION REGARDING REPLACEMNT HOSES,
THERMOCOUPLES, ELECTRODES, IGNITION
MODULES,LAVAROCKS,LOGS, FIRE ICE, ETC.
DANGER
DANGER indicates an imminently hazardous situation
which. If not avoided. Will result in death or serious injury.
DANGER
!
Failure to comply with the precautions and instructions
provided with this fire pit can result in death, serious
bodily injury and property loss or damage from
hazards of fire, explosion, burn, asphyxiation, and/or
carbon monoxide poisoning. Only persons who can
understand and follow the instructions should use or
service this fire pit.
! DANGER
FOR YOUR SAFETY - if you smell gas;
1. Shut off gas to the
appliance.
2. Extinguish any open flame.
3. If odor continues. Keep away from the appliance
and immediately call you gas supplier or fire
department.
P414-776
Page 2 of 46
SAFETY INFOR MATION
your
!
DANGER
!
EXPLOSION-FIRE HAZARD
Keep solid combustibles, such as building materials,
paper of cardboard, a safe distance away from the
fire pit as recommended by the instructions.
Provide adequate clearances around air openings
into the combustion chamber.
Never use the fire pit in spaces which do or may
contain volatile or airborne combustibles, or products
such as gasoline, solvents, paint thinner, dust particles
or unknown chemicals.
During operation, this product can be a source of
ignition. Keep fire pit area clear and free from
combustible materials, gasoline, paint thinner, cleaning
solvents and other flammable vapors and liquids. DO
not use fire pit in areas with high dust content.
Minimum fire pit clearances from combustible
materials: two (2) feet from the sides &two (2)
feet from the rear, 6 feet from ceiling.
DANGER
!
EXPLOSION - FIRE HAZARD
Never store propane near high heat, open flames,
pilot lights, direct sunlight, other ignition sources or
where temperatures exceed 120 degrees F (49°C).
Propane vapors are heavier than air and can
accumulate in low places. If you smell gas, leave the
area immediately.
Never install or remove propane cylinder while fire pit is
lighted, near flame, pilot lights, other ignition sources
or while fire pit is hot to touch.
The fire pit is red hot during use and can ignite
flammables too close to the burner. Keep flammables
at least 2 feet from sides & 2 feet from rear, 6 feet
from ceiling. Keep gasoline and other flammable liquids
and vapors well away from fire pit.
Store the propane cylinder outdoors in a well ventilated
space out of reach of children. Never store the propane
cylinder in an enclosed area (house, garage, etc.). If fire
pit is to be stored indoors, disconnect the propane
cylinder for outdoor storage.
WARNING
!
We cannot foresee every use which may be made of
our fire pit.
Check with your local fire safety authority if you have
questions about fire pit use.
Other standards govern the use of fuel gases and heat
producing products for specific uses. Your local
authorities can advise you about these.
If no local codes exist, follow National Fuel Gas Code,
ANSI Z223. 1. In Canada, installation must conform to
local codes. If no local codes exist, follow the current
National standards of CANADA CAN/CGA-B 149.2.
DANGER
CARBON MONOXIDE HAZARD
This fire pit is a combustion appliance. All combustion
appliances produce carbon monoxide (CO) during the
combustion process. This product is designed to produce
extremely minute, non-hazardous amounts of CO if used
and maintained in accordance with all warnings and
instructions. DO not block air flow into or out of the fire pit.
Carbon monoxide (CO) poisoning produces flu-like
symptoms, watery eyes, headaches, dizziness, fatigue
and possibly death. You can't see it and you can't
smell it. It’s an invisible killer. If these symptoms are
present during operation of this product get fresh air
immediately!
For outdoor use only.
Never use inside house, or other unventilated or
enclosed areas.
This fire pit consumes air (oxygen). Do not use in
unventilated or enclosed areas to avoid endangering
life.
WARNING
!
WARNING indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
WARNING
!
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
An LP-cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
WARNING: For Outdoor Use Only
!
DANGER
!
Improper installation, adjustment alteration, service or
maintenance can cause property damage, injury or
death. Read the installation, operating and
maintenance instructions thoroughly before installing
or servicing this equipment.
CARBON MONOXIDE HAZARD
This appliance can produce
carbon monoxide which has
no odor. Using it in an enclosed
space can kill you. Never use this
appliance in an enclosed space
such as a camper, tent, car or home.
WARNING
!
P414-776
Page 3 of 46
TABLE OF CONTENTS
1. Important Safety Information ................................................ 5
2. Information about Propane .................................................... 7
3. Specifications .............................................................................. 7
4. Parts List ..................................................................................... 8
5. Hardware List .............................................................................. 9
6. Installation ..................................................................................10
7. Natural Gas Conversion..............................................................13
8.
Lighting Instructions ...................................................................
9.
Mainte nance ...............................................................................
10 .Troubleshoo ting Guide ...............................................................
14
15
15
P414-776
Page 4 of 46
IMPORTANT SAFETY INFORMATION
The installation must conform with local codes or, in the absence of all applicable local codes, including,
without limitation, with the National Fu el Gas Code, ANSI Z223.1/NFP A 54; International Fuel Gas Code;
Natural Gas and Propane Installation Code, CSA B149.1; or Propane Storage and Handling Code, B149.2, as
applicable.
The appliance and its appliance main gas valve must be disconnected from the gas supply piping system
during any pressure testing of that system at test pressures in excess of 1/2 psi (3.5kPa).
The appliance must be isolated from the gas supply piping system by closing its equipment shutoff valve
during any pressure testing of the gas supply system at test pressure equal to or less than 1/2 psi (3.5kPa).
The appliance area must be kept clear and free from combustible materials, gasoline and other flammable
vapors and liquids.
Do not use this appliance if any part has been damaged or under water. Immediately call a qualified service
technician to inspect. Immediately call a qualified service technician to inspect the appliance and to replace
any part of the control system and any gas control which has been damaged or under water.
Do not sit or stand on appliance even when not in use and do not touch appliance
while in use or for at least 45 minutes after use as the appliance is very hot during
use and can cause serious burns.
The appliance will remain hot for up to 45 minutes after use. Do not touch or move
appliance for at least 45 minutes after it has been completely shut off.
Children and adults should be alerted to the hazards of high surface temperatures
and kept at a safe distance to avoid burns or clothing ignition.
All children should be kept away from the appliance and should not be allowed near the
product unless carefully supervised by an adult.
Clothing, any other object or flammable material should not be hung from the
appliance, placed on, near or underneath the appliance.
Any screen or guard removed for servicing an appliance must be replaced prior
to operating the appliance.
Keep children away from this appliance. This appliance contains small parts that
can be swallowed by children resulting in serious bodily injury or death.
Installation and repair should be done by a qualified service person. The appliance should
be inspected before use and at least annually by a professional service person. More frequent cleaning
may be required as necessary. It is imperative that the control compartments, burners and circulating
air passageways of the appliance be kept clean.
Do NOT burn solid fuels in this gas fireplace.
Do NOT ignite the burner before pouring all of the burner media (lava rock or fire glass) into the burner pan.
The media must be evenly distributed over the burner.
During initial firing of fire pit, please stay away from the fire pit for 20 minutes as fire media (lava rock or fire
glass) may pop and hit someone on the face or eyes
Do NOT ignite or use the fire pit if the burner media (lava rock or fire glass) are wet. Ensure the burner media
are completely dry before igniting as intense heat could cause the media to crack and pop. Always place the
cover on the appliance when not in use in order to avoid water contacting the media.
P414-776
Page 5 of 46
IMPORTANT SAFETY INFORMATION
It is UNSAFE to use this product for any purpose except as described in this document including, without
limitation, cooking.
CAUTION: The propane gas pressure regulator provided with this appliance must be used. This
regulator is set for an outlet pressure of 11 inches water column.
This outdoor gas appliance is not intended to be installed in or on recreational vehicles and/or boats.
Before each use of this gas appliance, open the LP (Liquid Propane) Tank Drawer and inspect the LP
Hose. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be replaced prior to
the gas appliance being put into operation. Use only the replacement hose assembly specified in this
manual. Inspect the burner before each use of the appliance. The burner must be replaced prior to the
appliance being put into operation if it is evident that the burner is damaged. Use only the burner listed in
these instructions.
Keep the fuel supply hose away from any heated surfaces.
If you have any questions regarding the use of this unit, or find that your fire pit unit needs service, please
contact Ashley Furniture Industries at the below number.
1 (800) 477-2222 Customer Service.
P414-776
Page 6 of 46
IMPORTANT SAFETY INFORMATION ABOUT
PROPANE (LP) GAS
A self-contained LP-gas cylinder for use with this appliance must have a capacity of 20
lbs. and must be equipped with a Type 1 connector and an OP D (overfill protection
device). See Figure 1.
The LP-gas supply cylinder to be used must be constructed and marked in accordance
with the specification for LP- gas cylinders of the U.S. Department of Transportation
(DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinder, Sphere and
Tubes for the Transportation of Dangerous Goods.
The cylinder supply system must be arranged for vapor withdrawal.
The cylinder used must include a collar to protect the cylinder valve.
This appliance shall be used only outdoors in a well-ventilated space and shall
not be used in a building, garage or any other enclosed space.
When this appliance is not is use, the gas must be turned off at the supply
cylinder.
Storage of this appliance indoors is permissible only if the cylinder is
disconnected and removed from the appliance.
Cylinders must be stored outdoors in a well-ventilated area out of the reach
of children. Disconnected cylinders must have threaded valve plugs tightly installed
and must not be stored in a building, garage or any other enclosed areas.
CSA (Canadian Standards Association) certified to ANSI Z21.97•CSA 2.41-2016
“Outdoor Decorative Gas Appliances”.
P414-776
Figure 1
SPECIFICATIONS
INPUT Btu/hr
Propane Regulator
Pressure
Natural Gas Minimum
Inlet Pressure
Clearances to
combustible surfaces
50,000
11 inches water column
7 inches water column
Sides: 48in./121.9cm Top: 72 in. / 182.9 cm
Page 7 of 46
PARTS IDENTIFICATION LIST
F
H
G
E
A
K
B
C
D
Item
A
B
C
D
E
F
G
H
I
J
K
I
Description
Lid
Table top
Back Frame
Right Frame
Fire Glass (Weight:11kg)
PVC Rain Cover
Left Frame
Door Frame
Reinforcement Bar
Slide Rails & Tank Holder
Battery (AAA)
J
Qty
1PC
1PC
1PC
1PC
1BOX
1PC
1PC
1PC
2PCS
1PC
1PC
P414-776
Page 8 of 46
H A R D W AR E L I S T
L
Item
Description Qty
L
M
N
O
P
Q
1/4"*20 Bolt
1/4"*30 Bolt
1/4"*40 Bolt
1/4" Lock Washer
∅6.5*∅16 Flat Washer
4mm Allen Wrench
M
N
O
P
Q
8 PCS
6 PCS
4 PCS
18 PCS
18 PCS
1 PC
Before beginning assembly of this product be sure all parts are present. Compare parts with
package contents list and hardware contents list. If any part appears to be missing or damaged do
not begin assembly of this product and call customer service immediately.
Estimated assembly time: 30 minutes
Tools required for assembly (included): Wrench(Q)
P414-776
Page 9 of 46
INSTALLATION
1.
Attach Back Frame (C) to Left Frame (G)
and Right Frame (D) using 4pcs of 1/4"*30
Bolt (M), 4pcs of 1/4" Lock Washer (O) and
M
4pcs of ∅6.5*∅16 Flat Washer (P) by 4mm
Allen Wrench (Q).
2. Turn over the unit, then attach the three
frames to Table Top (B) using 4pcs of
1/4"*20 Bolt (L), 4pcs of 1/4" Lock Washer
(O) and 4pcs of ∅6.5*∅16 Flat Washer (P)
by 4mm Allen Wrench (Q).
P
O
Q
Q
L
O
P
3. Attach Slide Rails & Tank Holder (J)
to Left Frame (G) and Right Frame (D)
using 4pcs of 1/4"*40 Bolt (N), 4pcs of 1/4"
Lock Washer (O) and 4pcs of ∅6.5*∅16
Flat Washer (P) by 4mm Allen Wrench (Q).
P414-776
J
P
D
G
O
N
Page 10 of 46
Q
INSTALLATION
4. Attach Door Frame (H) to Slide Rails &
Tank Holder (J) using 2pcs of 1/4"*30 Bolt
(M), 2pcs of 1/4" Lock Washer (O) and 2pcs
of ∅6.5*∅16 Flat Washer (P) by 4mm Allen
Wrench (Q).
5. Attach 2pcs of Reinforcement bar (I) to
Door Frame (H) and Slide Rails & Tank
Holder (J) using 4pcs of 1/4"*20 Bolt (L),
4pcs of 1/4" Lock Washer (O) and 4pcs of
∅6.5*∅16 Flat Washer (P) by 4mm Allen
Wrench (Q).
Q
P
M
O
H
J
Q
P
L
O
H
Pour the fire glass into fire bowl.
6.
DANGER
To ensure proper function, the guard on
this burner must not be covered by glass
beads.
L
O
P
I
J
P414-776
Page 11 of 46
INSTALLATION
7. Cover the Lid (A) on the fire bowl.
8. Make sure the control knob is in the “OFF”
position. Unscrew the push button cap on
the ignition module located on the control
panel to access the Battery(K) compartment.
The ignition
Battery(K).
module requires one AAA size
A
9. Pull the door open and place the propane
gas tank (not included) into the tank holder.
Tighten the preassembled wing screw
clockwise to ensure the propane tank is
secure. Replace the door after the tank is
connected to the regulator.
K
P414-776
Page 12 of 46
INSTALLATI
10.
Turn the cylinder valve on the tank
clockwise to close the propane tank.
Attach the preassembled regulator to
the cylinder valve by turning the
regulator coupling nut clockwise.
Make sure it is fastened securely and
tighten connections by hand only.
Open the tank valve. Apply a solution
of soapy water to the tank-regulator
connection and to the valve-hose
connection to check for leaks. If soap
bubbles continue to form, the
connection has a leak. If a leak is
found, close the tank valve and
tighten all connections. NEVER USE
A FLAME TO CH ECK FOR LEAKS.
ON
BLACK COUPLING NUT
turn clockwise to connect
REGULATOR
PRESSURE
RELIEF VALVE
CYLINDER VALVE
BLEED-OFF
VALVE
turn clockwise
to reseal
This unit can be converted to operate on natual gas. If you wish to
convert this unit, please contact your Ashley Furniture representative
and order PA50-1 (sold separately).
NATURAL GAS CONVERSION
Natural gas conversion must be performed only by your natural gas provider or
service company. Attempting to perform the natural gas conversion yourself is
not safe and may result in property damage, serious bodily injury or death.
WARNING
USC
IMPORTANT
!
SAVE THESE INSTRUCTIONS
DANGER
!
If you smell gas:
1. Shut o gas to the appliance.
2. Extinguish any open fl ame.
3. If odor continues, keep away from the appliance and
immediately call your gas supplier or fi re department.
!
If the information in this manual
is not followed exactly, a fi re or
explosion may result causing
property damage personal injury
or loss of life.
Improper Installation, adjustment,
alteration, service or maintenance
can cause injury or property
damage.
Read the installation, operation
and maintenance instructions
thoroughly before installing or
servicing this equipment.
P414-776
Page 13 of
46
Prior to turning gas on and attempting to light the appliance, make sure the appliance is
outside, in a well ventilated area and free of any debris and is not in contact with or near any
people, animals, materials or structures. Failure to adhere to the above instruction may result
in prop erty damage, serious bodily injury or death.
LIGHTING INSTRUCTIONS
To Light
1. Read instructions before lighting.
2. Control knob must be in the “OFF” position.
3. Connect propane cylinder (See Manual), open cylinder valve.
4. Push and turn control knob counter clockwise to “LOW”.
5. Press the igniter button repeatedly to light burner.
6. Release control knob after 45 seconds.
7. If ignition does not occur in 45 seconds, push and turn burner control knob to “OFF”, wait 5
minutes, fan with newspaper or magazine, and repeat lighting procedure.
8. If igniter does not light burner, use a long match or long butane lighter.
9. After burner ignites, adjust flame to desired flame with the control knob.
To Extinguish
1. Turn and push the control knob clockwise to the OFF position.
2. Close cylinder valve, disconnect propane cylinder.
P414-776
Page 14 of 46
Loading...