FD Series
FD4025 FD5025
FD6025 FD4625
FD6935 FD5725
Installation Manual
INTRODUCTION
Thank you for choosing ARC Audio’s Foose Design
hi-performance mobile audio products. We hope you
enjoy your experience with all our products and we
welcome any questions or comments you may have.
DIRECT REPLACEMENT
ARC Audio speakers are designed to fit most
applications in the original stock location without
modification. Some vehicles may require minor
removal of material and relocation of mounting holes
to achieve a proper fit.
A WORD ON DISTORTION
Most speaker damage occurs as a result of amplifier
distortion also known as “Clipping”. Clipping occurs
when an amp is driven beyond its maximum rated
output. This kind of distortion can be hard to hear
unless you know what to listen for. Any time you hear
a harsh ear piercing sound at high volume your amp
is probably clipping.
1
Specifications
FD6025 FD5025
Diameter 6 ½” Diameter 5 ¼”
Musical Power 175 watts Musical Power 140 watts
Nor. Power 90 watts Nor. Power 75 watts
Sensitivity 86db Sensitivity 86db
Frequency
response
60hz20Khz
Frequency
response
80hz20Khz
IMP. 4 Ohm IMP. 4 Ohm
FD4025 FD4625
Diameter 4” Diameter 4” X 6”
Musical Power 100 watts Musical Power 100 watts
Nor. Power 55 watts Nor. Power 55 watts
Sensitivity 86db Sensitivity 86db
Frequency
response
IMP. 4 Ohm IMP. 4 Ohm
110hz20Khz
Frequency
response
90hz20Khz
CAUTION:
Please check the suitability of the installation location before you
begin. Do not cut any of the car’s structure. Pay attention to the
mechanism of the window and door.
If you do not have experience with automotive electrical and
mechanical systems contact a professional installer. Paying a
qualified installer is almost always cheaper then paying a
dealership to repair your car.
THE INSTALL
ARC Audio’s Foose Design coaxial speakers are designed to fit
most vehicles without modification. Some locations will require
cutting to obtain a proper fit.
FD6935 FD5725
Diameter 6” X 9” Diameter 5” X 7”
Musical Power 185 watts Musical Power 140 watts
Nor. Power 100 watts Nor. Power 75 watts
Sensitivity 86db Sensitivity 86db
Frequency
response
IMP. 4 Ohm IMP. 4 Ohm
50hz20Khz
Frequency
response
2
65hz20Khz
1. Remove the interior panel to expose the stock
speaker. It may take some time to find and remove all
the clip and screws to remove this panel.
2. Remove the stock speaker and disconnect it from the
wiring.
3. Check the fit with the new speaker. Make sure that all
the door and window hardware will clear the larger
magnet.
4. You may have to trim some material from around or
behind to speaker.
5. Connect the stock speaker wires to the new speaker.
Tip: Use a 9V battery and quickly touch it to the
terminals of the stock speaker. If the cone moves out
the + of the battery is on the + of the speaker. If you
noted the color of wire connected to this terminal then
you now the + speaker wire.
6. Install the speaker in the location. You may have to
drill new holes to secure the speaker.
7. Reinstall the panel. Congratulations you finished and
ready to enjoy your new system.
If you have any Question about this product please
call ARC Audio Technical Service:
209-543-8706
4
ARC AUDIO WARRANTY AND
SERVICE GUIDELINES
ARC AUDIO warrants all new speakers and subwoofers against defects in material and workmanship for a
period of NINTEY (90) DAYS from the original date of purchase on all over the counter purchases not
installed by an AUTHORIZED ARC AUDIO RETAILER. On all FD (Foose De signs) models, the limited
warranty is EXTENDED NINE (9) MONTHS additional from the original purchase dat e if the product is
originally installed by an AUTHORIZED ARC AUDIO RETAILER and is accompanied b y a valid cop y of
the original receipt showing a charge for the installation. This warranty is not transferable and applies only to
the original ret ail purchaser of the product from an authorized ARC AUDIO retailer. U pon inspection by
ARC AUDIO should services be necessary under this warranty for any reason due to manufacture defects
ARC AUDIO will, at its sole discretion, repair or replace the defective product with new or similar
conditioned product at no charge.
THIS WARRANTY DOES NOT COVER INSTALLATION OR DAMAGE RESULTING FROM
ACCIDNT, MISUSE, ABUSE, IMPROPER WIRING, OPERATION OUTSIDE OF UNIT OUTSIDE
OF MANUFACTURES SPECIFICATIONS, OR AGAINST INSTRUCTIONS IN OWNERS
MANUAL. IN ADDITION ANY PRODUCT THAT HAS BEN OPENED, TEMPERED WITH OR
MODIFIED, OR IF ANY SERIAL NUMBERS HAVE BEEN REMOVED WILL NOT BE COVERED
BY ANY PART OF THE MANUFACTURES WARRANTY.
All warranty returns should be sent to ARC AUDIO freight prepaid and must be acco mpanied by proof of
purchase (a copy of the original sales receipt). Direct returns from consumers or non-autho rized retailers will
be refused unless specifically authorized by ARC AUDIO with a valid return authorization number.
All warranty returns must be packed in original packaging and be accompanied by a copy of the
original sales receipt. Product damaged in shipment due to improper packaging w ill not be covered
underthis warranty and the customer or retailer will be char ged full cost to repair the specific piece of
product back to a like new or similar condition.
In no event will ARC AUDIO be liable for incidental, consequential, or other damages resulting from the use
of this product, this includes but is not limited to, damage of hearing, property or person, damage based u pon
inconvenience or on loss of use of the product, and to the extent permitted by law, damages for personal
injury. This warranty gives you specific legal rights, and you may have other right s, which vary from sta te to
state. This warranty applies to products sold and used in the United States of America. In all other countries
please contact your distributor
For warranty and non-warranty repairs, send to:
ARC Audio
4719 Green Leaf Cr. #4
Modesto CA, 95356
___________________________________________
Loading...