Page 1
R
INSTALLATION AND OPERATING INSTRUCTIONS
Condiment Dispenser Pump
DSTI-X & DCSTI-X
PRODUCT MANUAL
Operation Instructions
Adjustment Instructions
Cleaning Instructions
Replacement Parts List
Warranty/Service Information
24 Hour Toll Free
Service Hot Line:
1-800-733-2203
IMPORTANT FOR FUTURE REFERENCE
Please complete this information and retain this manual for the life of the equipment. For
WarrantyServiceand/or Parts,this information isrequired.
ModelNumber SerialNumber DatePurchased
P/N 88722-00 9/05
APW WYOTT Foodservice Equipment Company
P.O. Box 1829
Cheyenne, WY 82003
+1(307) 634-5801 Phone +1(800) 752-0863 TollFree
+1(307) 637-8071 Fax www.apwwyott.com
1
Page 2
NOTE: Clean the pump thoroughly in a sanitizing solution before using it for the first time.
Operation:
To operate the pump, press the lever knob down until it stops; then release it. A brisk, smooth
strokedelivers thecondiment uniformly.
Adjustment:
Adjust the pump to deliver the amount of condiment you require. Depending on the condiment,
thepump candispense upto about1 ½ounces with onestroke.
1. Turnthe pump knobcounterclockwise andremove it.
2. Turn the upper spring cage clockwise for a smaller portion of condiment and
3. Replacethe pumpknob tightly.
Cleaning:
Cleanthe pump accordingto theinstructions below.
youcan reassembleit inreverse order.
Instructions for Operating, Adjusting & Cleaning
the DSTI-X & DCSTI-X Condiment Dispenser Pump
counterclockwisefor alarger portion.
daily
Notethe waythe pumpcomes apartso
1. Removethe hairpinclip onthe bottomof the pump.
2. Removethe cup.
3. Removethe intakevalve.
4. Turnthe pump knobcounterclockwise andremove it.
5. Turnthe upper springcage counterclockwiseand remove it.
6. Removethe springand lowerspring cage.
7. Removethe piston.
8. Wash all pump parts thoroughly in a sanitizing solution, using the brush provided; rinse the
partsin hotwater and allowthem toair dry.
9. Reassemblethe pumpusing reverseProcedure.
PLEASE PLACE THESE INSTRUCTIONS WHERE THEY MAY BE REFERRED
TO BY THOSE PERSONS USING AND CLEANING THE PUMP
2
Page 3
PARTS LISTS & EXPLODED VIEWS
DSTI-X PUMP
2
3
1
DCSTI-X PUMP
7
4
9
3
4
6
3
7
5
2
7 3/16 REF.
1
5
8
6
9
Item P/N Description Quan
1
2
3
4
5
6
7
8
9
10
87043
813
89110
40677
43422
43431
43429
42432
89905-01
30247
Pump Knob
Upper Spring Cage
Spring
Lower Spring Cage
Lid & Spout
Piston Rod
Intake Valve
Cup
Hairpin Clip
Cleaning Brush (NOT SHOWN)
1
1
1
1
1
1
1
1
1
1
8
Item P/N Description Quan
1
2
3
4
5
6
7
8
9
10
43422
43431
40677
813
43429
43421
87043
89905-01
89110
30247
Spout Tube Weldment
Piston Rod Weldment
Lower Spring Cage
Upper Spring Cage
Intake Valve
Cup
Pump Knob
Hairpin Clip
Spring
Cleaning Brush (NOT SHOWN)
1
1
1
1
1
1
1
1
1
1
Page 4
APW WYOTT EQUIPMENT LIMITED WARRANTY
APW Wyott Foodservice Equipment Company warrants it'sequipment against defects in materials and workmanship, subject to the
following conditions:
This warranty applies to the original owneronlyandisnotassignable.
Should any product fail tofunction in its intended manner under normal use within the limits defined in this warranty,at the option of
APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency. APW Wyott will only be
responsible for charges incurred or service performed by its Authorized Service Agencies. The use of other than APW Wyott
Authorized Service Agencies will void this warranty andAPWWyottwill not beresponsible for such work orany charges associated
with same. The closestAPWWyottAuthorized ServiceAgent must be used.
This warranty covers products shipped into the 48 contiguous United States,Hawaii, metropolitan areas of Alaska and Canada. There
will be no labor coverage for equipment locatedonanyislandnotconnected by roadway to the mainland.
Warranty coverage on products used outside the 48 contiguous United States, Hawaii, and metropolitan areas of Alaska and Canada
may vary.ContacttheinternationalAPWWyott distributor, dealer, or service agency for details.
TimePeriod
One year for parts and one year for labor,effective from the date of purchase by the original owner. The Authorized Service Agency
may, at their option, require proof of purchase. Parts replaced under this warranty are warranted for the un-expired portion of the
original product warranty only.
Exceptions
Inallcases, parts covered by extended warranty willbeshipped FOB the factory after the first year.
Portable Carry In Products
Equipment weighing over 70 pounds or permanently installed will be serviced on-site as per the terms of this warranty. Equipment
weighing 70 pounds or under, and which is not permanently installed, i.e. with cord and plug, is considered portable and is subject to
the following warranty handling limitations. If portable equipment fails to operate in its intended manner on the first day of
connection, or use, atAPWWyott'soptionoritsAuthorized ServiceAgency, it will be serviced on site or replaced.
From day two through the conclusion of this warranty period, portable units must be taken to or sent prepaid to the APW Wyott
Authorized Service Agency for in-warranty repairs. Nomileageortravelcharges are allowed on portable units after the firstdayofuse.
If the customer wants on-site service, they may receive same by paying the travel and mileage charges. Exceptions to this rule: (1)
countertop warmers andcookers, which are covered underthe Enhanced Warranty Program, and (2) toastersor rollergrills which have
instore service.
Exclusions
The following conditions are not covered bywarranty:
If the equipment has been changed, altered, modified or repaired by other than an Authorized Service Agency during or after the
warranty period, thenthe manufacturer shallnot be liable forany damages to anyperson or to any property,whichmay result from the
use of the equipment thereafter.
This warranty does not cover services performed at overtime or premium labor rates. Should service be required at times which
normally involve overtime orpremiumlabor rates, the owner shall be charged forthedifferencebetween normal service rates and such
premium rates.APWWyott does not assume anyliabilityforextended delays in replacing or repairing anyitemsbeyonditscontrol.
Inallcases, the use of other thanAPWWyottAuthorized OEM ReplacementParts will void this warranty.
This equipment is intended for commercial useonly.Warranty is void if equipment is installed in other thancommercial application.
WaterQualityRequirements
Water supply intended for a unit that has in excess of 3.0 grains of hardness per gallon (GPG) must be treated or softened before
being used. Water containing over 3.0 GPG will decrease the efficiency and reduce the operation life of the unit.
Note: Product failure caused by liming or sediment buildup is not covered under warranty.
THE FOREGOING WARRANTY IS IN LIEU OFANYAND ALL OTHER WARRANTIES EXPRESSED OR IMPLIED
INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSES
AND CONSTITUTES THE ENTIRE LIABILITY OFAPW WYOTT. IN NO EVENT DOES THE LIMITED WARRANTY
EXTEND BEYOND THE TERMS STATEDHEREIN.
*Gas/Electric Cookline:
component parts, except switches andthermostats. (2 additional years on parts only. No labor on second or third year.)
*BroilerBriquettes,
*Heat Strips:
*GlassWindows, Doors, Seals, Rubber Seals, Light Bulbs:
*Equipment failure relating to improper installation, improper utility connection or supply and problems due to
ventilation.
*Equipment that has not been properly maintained, calibration of controls, adjustments, damage from improper cleaning
and water damage to controls.
*Equipment that has not been used in an appropriate manner, or has been subject to misuse or misapplication, neglect,
abuse, accident, alteration, negligence, damageduring transit, delivery or installation, fire,flood,riotoractofgod.
*Equipment that has the model number orserialnumberremoved or altered.
Models FD, FDL, FDD, FDDL. Two (2)Year Warrantyonelementonly. No labor second year.
Models GCB, GCRB, GF, GGM, GGT, CHP-H, EF, EG, EHP. Three (3) Year Warranty on all
RockGrates,CookingGrates,BurnerShields,Fireboxes:
90Day Material Only. No Labor.
90DayMaterialOnly.NoLabor.
9/05
4
Loading...