Antunes, AJ 9300584, 9300582, 9300586, 9300576, 9300570 User Manual
...
MANUFACTURING
A
S
D
L
I
S
T
E
O
I
N
N
I
T
A
T
NUMBERS:
9300570
9300572
9300576
9300580
9300582
9300584
9300586
EGG STATION
A
T
T
I
I
O
N
N
A
S
L
CM
D
I
S
E
T
P/N 1010871 Rev. D 08/05
Model ES-600 & ES-1200
Owner’s Manual
EGG STATION (ES-600 & ES-1200)
TABLE OF CONTENTS
Owner Information .....................................................2
General ......................................................................2
Warranty Information .................................................2
Service/Technical Assistance ....................................3
Important Safety Information ....................................3
Electrical Ratings .......................................................5
Specifications .............................................................5
Model Designation .....................................................5
Electrical Cord & Plug Configurations .......................5
Dimensions ................................................................6
Shipping Weight ........................................................6
Net Weight .................................................................6
Installation ...................................................................7
Unpacking ..................................................................7
Equipment Setup .......................................................7
OWNER INFORMATION
General
This product cooks/steams a maximum of six or twelve
eggs (refrigerated) in approximately 150 seconds and
reheats sliced meat for sandwiches. Eggs, within the
Egg Rings, are cooked with a combination of heat and
steam. With the cover closed, water is poured into a
trough on the cover and drips onto a hot Platen producing steam, cooking the eggs. The unit is equipped with
audio/visual signals for operation.
This manual provides the safety, installation and operating procedures for the Egg Station. We recommend
that all information contained in this manual be read
prior to installing and operating the unit.
Your Egg Station is manufactured from the finest materials available, assembled to Roundup’s strict quality
standards, and tested at the factory to ensure dependable trouble-free operation.
Warranty Information
Egg Cooking Procedure ............................................8
Operation .....................................................................8
Preparing Unit ............................................................8
Bacon Timer* .............................................................9
Maintenance ................................................................9
Daily Cleaning ...........................................................9
Checking Cycle Times (Monthly) ............................ 10
Checking Grill Platen Temperature ......................... 10
Troubleshooting .......................................................11
Control Board LEDs ............................................... 12
Green LED Blink Codes ......................................... 12
Wiring Diagram ......................................................... 13
Replacement Parts ...................................................14
LIMITED WARRANTY ...............................Back Cover
The warranty does not extend to:
• Damages caused in shipment or damage as
result of improper use.
• Installation of electrical service.
• Installation, calibration, or adjustment.
• Normal maintenance outlined in this manual.
• Consumable parts such as Egg Rings, gaskets, rubber feet, labels, O-rings, light bulbs,
etc.
• Malfunction resulting from improper service
or maintenance.
• Damage caused by improper installation,
abuse, or careless handling.
• Damage from moisture getting into electrical
components.
Please read the full text of the Limited Warranty
printed on the back cover of this manual.
If the unit arrives damaged, contact the carrier
immediately and file a damage claim with them.
Save all packing materials when filing a claim.
Freight damage claims are the responsibility of the
purchaser and not covered under warranty.
• Damage from tampering with, removal of, or
changing any preset control or safety device.
• Damage caused by parts or components not
provided by A.J. Antunes & Co.
IMPORTANT! Keep these instructions for future reference. If the unit changes owner-
ship, be sure this manual accompanies the equipment.
2
P/N 1010871 Rev. D 08/05
EGG STATION (ES-600 & ES-1200)
OWNER INFORMATION (continued)
Service/Technical Assistance
If you experience any problems with the installation
or operation of your unit, contact your local Roundup
Authorized Service Agency. They can be found in the
service agency directory packaged with the equipment.
Fill in the information below and have it handy when
calling your authorized service agency for assistance.
The serial number is on the specification plate located
on the rear of the unit.
Purchased From:
Date of Purchase:
Model No.:
Serial No.:
Mfg. No.:
Refer to the service agency directory and fill in the
information below:
Authorized Service Agency
Name:
Phone No.:
Address:
Use only genuine Roundup replacement parts in this
unit. Use of replacement parts other than those supplied by the manufacturer will void the warranty. Your
Authorized Service Agency has been factory trained
and has a complete supply of parts for this unit.
You may also contact the factory at 1-877-392-7854 or
1-630-784-1000 if you have trouble locating your local
authorized service agency.
IMPORTANT
A.J. Antunes & Co. reserves the right to change specifications and product design
without notice. Such revisions do not entitle the buyer to corresponding changes,
improvements, additions or replacements for previously purchased equipment.
IMPORTANT SAFETY INFORMATION
Throughout this manual, you will find the following safety words and symbols that signify important safety issues with
regards to operating or maintaining the Miracle Steamer.
WARNING
GENERAL WARNING. Indicates information important to the proper operation of
the equipment. Failure to observe may
result in damage to the equipment and/or
severe bodily injury or death.
CAUTION
GENERAL CAUTION. Indicates information important to the proper operation of
the equipment. Failure to observe may
result in damage to the equipment.
ELECTRICAL WARNING. Indicates information relating to possible shock hazard.
Failure to observe may result in damage
to the equipment and/or severe bodily
injury or death.
HOT SURFACE WARNING. Indicates
information important to the handling of
equipment and parts. Failure to observe
caution could result in personal injury.
WARNING
WARNING
P/N 1010871 Rev. D 08/05
3
EGG STATION (ES-600 & ES-1200)
IMPORTANT SAFETY INFORMATION (continued)
In addition to the warnings and cautions in this manual,
use the following guidelines for safe operation of the
unit.
• Read all instructions before using equipment.
• For your safety, the equipment is furnished with
a properly grounded cord connector. Do not
attempt to defeat the grounded connector.
• Install or locate the equipment only for its intended use as described in this manual. Do not use
corrosive chemicals in this equipment.
• Do not operate this equipment if it has a damaged cord or plug, if it is not working properly, or
if it has been damaged or dropped.
• This equipment should be serviced by qualified
personnel only. Contact the nearest Roundup
authorized service facility for adjustment or repair.
• Do not block or cover any openings on the unit.
• Do not immerse cord or plug in water.
• Keep cord away from heated surfaces.
• Do not allow cord to hang over edge of table or
counter.
The following warnings and cautions appear
throughout this manual and should be carefully
observed.
• Turn the unit off, disconnect the power source
and allow unit to cool down before performing
any service or maintenance on the unit.
• WARNING ELECTRICAL SHOCK HAZARD.
FAILURE TO FOLLOW THESE INSTRUCTIONS
COULD RESULT IN SERIOUS INJURY OR
DEATH.
- Electrical ground is required on this appliance.
- Do not modify the power supply cord plug.
If it does not fit the outlet, have a proper
outlet installed by a qualified electrician.
- Do not use an extension cord with this
appliance.
- Check with a qualified electrician if you
are in doubt as to whether the appliance is
properly grounded.
• If the supply cord is damaged, it must be
replaced by the manufacturer or its service
agent.
• Do not clean this appliance with a water jet.
• Do not use a sanitizing solution or abrasive
materials. The use of these may cause damage to the stainless steel finish.
• Chlorides or phosphates in cleansing agents
(e.g. bleach, sanitizers, degreasers or detergents) could cause permanent damage to
stainless steel equipment. The damage is
usually in the form of discoloration, dulling
of metal surface finish, pits, voids, holes or
cracks. This damage is permanent and not
covered by warranty.
• The equipment should be grounded according to local electrical codes to prevent the
possibility of electrical shock. It requires a
grounded receptacle with separate electrical
lines, protected by fuses or circuit breaker of
the proper rating.
• All electrical connections must be in accordance with local electrical codes and any
other applicable codes.
4
P/N 1010871 Rev. D 08/05
EGG STATION (ES-600 & ES-1200)
L
IMPORTANT SAFETY INFORMATION (continued)
• The following tips are recommended for maintenance of your stainless steel equipment,
- Always use soft, damp cloth for cleaning,
rinse with clear water and wipe dry. When
required, always rub in direction of metal
polish lines.
- Routine cleaning should be done daily
using soap, ammonia detergent and water.
SPECIFICATIONS
Electrical Ratings
Model
Number
ES-600HI 9300570 230 2900 12.6 50/60
ES-600HC 9300572 230 2900 12.6 50/60
ES-600 9300576 230 2900 12.6 50/60
ES-1200HI 9300580 230 2900 12.6 50/60
ES-1200HC 9300582 230 2900 12.6 50/60
ES-1200HG 9300584 230 2900 12.6 50/60
ES-1200 9300586 230 290 12.6 50/60
Mfg.
Number
Volts Watts Amp Hertz
- Stains and spots should be sponged using
a vinegar solution as required.
- Finger marks and smears should be
rubbed off using soap and water.
- Hard water spots should be sponged using
a vinegar solution.
Model Designation
ES-600XX or
ES-1200XX
TYPE OF POWER CORD
H = Harmonized
TYPE OF PLUG
C = CEE 7/7
G = BS-1365 Fused/Permaplug
I = International Pin & Sleeve
WARNING
ELECTRICAL SHOCK HAZARD. FAILURE TO
FOLLOW THE INSTRUCTIONS IN THIS MANUAL
COULD RESULT IN SERIOUS INJURY OR DEATH.
• Electrical ground is required on this appliance.
• Do not modify the power supply cord plug. If
it does not fit the outlet, have a proper outlet
installed by a qualified electrician.
• Do not use an extension cord with this appliance.
• Check with a qualified electrician if you are in
doubt as to whether the appliance is properly
grounded.
CAUTION
All electrical connections must be in accordance
with local electrical codes and any other applicable codes.
Electrical Cord & Plug Configurations
Letter
Code*
(H)C CEE 7/7, 16
(H)G BS-1365 - Fused,
(H)I IEC-309, 16 Amp.,
* Used in Model Designation
Description Configuration
Amp., 250 VAC
(Assembly Only).
Permaplug
16 Amp, 250 VAC
(Assembly Only)
250 VAC., Pin &
Sleeve (Assembly
Only).
AS3112 15
Amp., Australia
(Harmonized Cord)
Image Not Avaliable
P/N 1010871 Rev. D 08/05
5
Loading...