Page 1
MODEL: AMX 180FX-USB
Page 2
CONTENT
1. INTRODUCTION..1
2. TECHNICAL SPECIFICATION..2
3. BLOCK DIAGRAM....................3
4. SCHEMATIC DIAGRAM.4
5. WIRING DIAGRAM.12
6. PCB LAYOUT..13
7. TEST PROCEDURE.....................18
8. EXPLODED VIEW & MECHANICAL PARTS LIST..25
9. BOM..27
Page 3
1. INTRODUCTION
- 5 MIC input channels with gold plated XLR and balanced LINE inputs
- 4 stereo input channels with balanced TRS jacks
- Ultra-low noise discrete MIC pre-amps with +48V Phantom Power
- Extremely high headroom offering more dynamic range
- Insert on each of mono input channels
- Switchable Low-cut filter on each mono channel
- +48dBu/-10dBV on each channel
- Warm, natural 3-babd EQ on each channel
- Peak LED on each channel
- Mute/ALT 3-4, SOLO function on each channel
- 4 AUX returns for additional functionality
- Control room and headphone outputs
- 2-Track inputs assignable to main mix, control room/headphone outputs
- Highly accurate 12-segment bar graph meters
- 24 bit digital effect processor
- 256 effects (16 presets*16 variations)
- Effect on/off by means of MUTE switch or a footswitch connected to the DFX
FOOTSWITCH
- 16 Bit 32~48KHz ADC/DAC USB input and output with selectable track
- No software drivers are need with windows XP or Mac OSX
- Performance and excellent noise figures
- Manufactured under ISO9001 certified management system
- 1 -
Page 4
2. TECHNICAL SPECIFICATION
-2 -
Mono input channels
Stereo input channels
Impedance Microphone input
Equalization Hi shelving
Main Mix Section Noise (Bus noise )
USB SECTION
Power supply
(AC/AC Adaptor)
Physical
Microphone input Electronically balanced ,discrete input configuration
Frequency response
Distortion (THD&N)
Gain range
SNR (Signal Noise Rated)
Line input
Frequency response
Distortion (THD&N)
Sensitivity range
Line input
Frequency response
Distortion (THD&N) 0.005% at +4dBu, 1KHz
Channel insert return
All other inputs
Tape out
All other output
Mid bell
Low shelving
Max output
AUX Return gain range
AUX Sends max out
ADC / DAC 16 Bit 32~48KHz
Fully Compliant with USB 1.1 specification
S/PDIF input and output interface
No software drivers or need with windows XP or Mac OS X
Main voltage
Power Consumption
Net weight
10Hz to 55KHz, 3dB
0.005% at +4dBu, 1KHz
0dB to 44dB(MIC)
115dB
Electronically balanced
10Hz to 55KHz, 3dB
0.005% at +4dBu, 1KHz
+15dBu to -30dBu
Balanced
10Hz to 55KHz, 3dB
1.4K ohm
2.5K ohm
10Kohm or greater
1K ohm
120 ohm
15dB @ 12KHz
12dB @ 2.5KHz
15dB @ 80Hz
Fader 0 dB, channels muted:-100.0dBr (ref.:+4dBu)
Fader 0 dB,all input channels assigned and set to
UNITY gain:-90dBr(ref.:+4dBu)
+22dBu balanced XLR,
+22dBu unbalanced,1/4" jacks
OFF to +15dB
+22dBu
USA/ Canada 100-120V~,60Hz
Europe 210-230V~,50Hz/60Hz
U.K/Australia 240V~,50Hz
35watts
390mm 330mm 43mm Dimension (W D H)
15.35" 12.99" 1.69"
3.8Kg
Page 5
3. BLOCK DIAGRAM
D
12
1110987654321
LEFT
RIGHT
TAPE OUT
2TK
MAIN OUT
TRS
C
LEFT
RIGHT
MAIN MIX LEFT
213
TRS
MAIN MIX RIGHT
213
ALT-3(L)
TRS
ALT 3-4 OUT
TAPE IN
ALT-4(R)
2TK
TRS
B
PHONES
SOLO ACTIVE
LEFT METER
RIGHT METER
TRS
PHONES OUTPUT
AMX180FX-USB
A
LEFT
RIGHT
TRS
TRS
CONTROL ROOM OUTPUT
AUX SEND1
AUX SEND
TRS
MAIN MIX LEFT
MAIN MIX RIGHT
AUX1
LEVEL
2
2
1
3
1
3
USB RECORD
Vin L
Vin L
ADC
USB
PROTOCOL
USB PORT
TO PC
USB MODULE
CONTROLLER
Vout L
DAC
MONO CHANNEL 1
Vout L
MONO CHANNEL 2
LOGIC
EFX SEND
SOLO(PFL)
AFL-R
AFL-L
AUX-2
AUX-1
ALT-4(R)
ALT-3(L)
RIGHT-BUS
LEFT-BUS
AUX-1
LEFT-BUS
ALT-3
MAIN/ALT
AUX SEND2
TRS
2TK LEVEL
& PHONES
2TK
AUX2
LEVEL
(LEFT)
MAIN MIX LEVEL
AUX-2
RIGHT-BUS
ALT-4
LEFT-BUS
AFL-L
AFL-R
(RIGHT)
MAIN MIX LEVEL
SOLO(PFL)
AUX-2
ON
SOLO
( )
LEVEL
ALT3-4
ALT 3-4 TO MIX
RIGHT-BUS
ALT-3(L)
ALT-4(R)
AUX-1
LEFT-BUS
ALT-3
RIGHT-BUS
MAIN/ALT
MUTE/ALT3-4 LED
2TK TO MIX
LEFT-BUS
RIGHT-BUS
LEFT-BUS
ALT-4
AFL-L
ALT 3-4
SOLO CTRL
MAIN MIX
RIGHT-BUS
AFL-R
SOLO(PFL)
ON
SOLO
( )
CONTROL ROOM SOURCE
AFL L
AFL R
AUX-2
AUX-1
LEFT-BUS
RIGHT-BUS
PFL
AFL
( )
( )
SOLO MODE
PFL LED
(LEVEL SET)
SOLO(PFL)
LEFT-BUS
RIGHT-BUS
AUX-1
AUX-1
CONTROL ROOM
LOGIC
EFX SEND
SOLO(PFL)
AFL R
AFL L
AUX-2
AUX-1
ALT-4(R)
ALT-3(L)
RIGHT-BUS
LEFT-BUS
MUTE/ALT3-4 LED
RIGHT-BUS
LEFT-BUS
PAN
2
2
1
1
3
3
USB PLAYBACK
STEREO CHANNELS 11
STEREO CHANNELS 12
LEVEL
12K80
2.5K
MID HI
LO
GAIN
MONO INPUT CHANNELS (1-4)
+/-15db
3-BAND EQ
T
RSRN
2
LO CUT
1
3
+
-
213
+48V
POWER
PHANTOM
MIC IN
TN
3c5e1a4d2b
75Hz
HI PASS
INSERT
LINE IN
MIC GAIN:0~40dB
LINE IN TRIM:+15dB~-25dB
AUX1
AUX2
PRE
POST
1 2
1 2
POST
PEAK
BALANCE
POST
PRE
LEVEL
12K80
2.5K
MID HILO
2
1
3
-
RSRN
TN
3c5e1a4d2b
STEREO INPUT CHANNELS (5-12)
12K80
2.5K
+/-15db
3-BAND EQ
T
EQ
2
1
3
-
+
+
(LEVEL +4dBu/-10dBv)
T
RSRN
TN
3c5e1a4d2b
LEFT(MONO)
RIGHT
1 2
AUX1
AUX2
1
3
1
3
PRE
PRE
POST
1 2
PEAK
AUX1 RETURN
-
+
T
RSRN
3c5e1a4d2b
LEFT(MONO)
RSRN
3c5e1a4d2b
-
TN
STEREO AUX RETURN 1
EFX TO AUX-1
2
RETURN
AUX2 / DSP
+
T
TN
-
RSRN
TN
3c5e1a4d2b
RIGHT
2
AUX2 / DSP
-
+
T
+
T
RSRN
TN
3c5e1a4d2b
LEFT
DSP BOARD
MUTE
PRESETS
VARIATIONS
RIGHT
DSP FOOTSWITCH
STEREO AUX RETURN 2
1 2 3 4 5 6 7 8 9 10 11 12
D
C
B
A
- 3 -
Page 6
4. SCHEMATIC DIAGRAM
- 4 -
D
12
3906
TR19
R250
120R 1/4W
+VCC
ALT-3
ALT-4
AFL-L
LEFT-BUS
RIGHT-BUS
1
3
4
6
SW14A
SW14B
SW15A
2
5
PS-42E85L
PS-42E85L
1110987654321
5K1
5K1
R162
R161
SW14:MUTE/ALT3-4
SW15:SOLO,PFL
BAL
VR34
B5K
AMX180FXMN1-USB(1/4)
R213
4K7
4K7
R105
C33
47u/25V
R225
22K
1
U6A
22P
C153
3
2
5K1
R153
R431
5K1
22P
C145
C81
18n(M)
VR29A
B50K
C69
18n(M)
EQ HI
12KHZ
SW2A
SW2:MUTE/ALT3-4
SW3:SOLO,PFL
CH1
C13
R221
22P
C141
R428
7K68
C77
VR1
C65
22P
C154
4580M
R433
5K1
R432
10KD
VR35B
R97
7K5
C18
1M
R181
47u/25V
1
U5A
4580M
3
2
C17
47u/25V
R34
910R
C93
12n(M)
B50K
VR30A
1K3
1K1
R17
R5
910R
R33
47u/25V
10K
1
R467
22P
C314
3
2
R465
10K
PRE-CH5
ALT-3
ALT-4
LEFT-BUS
RIGHT-BUS
1
3
4
6
SW2B
SW3A
2
5
PS-42E85L
PS-42E85L
5K1
5K1
R138
R137
VR6
PAN
R201
4K7
47u/25V
15K
1
U1A
4580M
R430
5K1
3
2
680R
R133
VR7A
C9
47u/25V
7
22P
1M
C137
R177
5
6
C5
47u/25V
C89
12n(M)
18n(M)
B50K
1K1
R1
R13
18n(M)
EQ HI
AFL-R
1
3
4
6
SW15B
2
5
PS-42E85L
PS-42E85L
27K
27K
R241
R242
R214
4K7
R106
4K7
C34
47u/25V
22K
7
R226
U6B
4580M
R434
5
6
5K1
R154
5K1
LEVEL
R98
7K5
22P
C149
C82
18n(M)
B50K
VR29B
C73
18n(M)
EQ HI
6K8
R62
C105
12n(M)
VR31A
B50K
R61
6K8
LO
MID
2.5K
C316
U36A
4580M
PRE-CH5
AFL-L
AFL-R
1
3
4
6
SW3B
2
5
PS-42E85L
PS-42E85L
27K
27K
R233
R234
SOLO(PFL)
7
9
7
9
SW14C
8
PS-42E85L
SW13A
SW15C
8
PS-42E85L
10K
R107
5K1
LEVEL
VR35A
10KD
C26
1M
R185
47u/25V
7
U5B
4580M
5
6
C25
47u/25V
R41
910R
C97
12n(M)
B50K
VR30B
1K3
1K1
R9
R21
R42
910R
12KHZ
C121
33n(M)
C122
33n(M)
80HZ
MID
R89
10K
10K
7
R468
22P
C315
5
6
R466
10K
PRE-CH6
PRE-CH6
AUX-2
SOLO(PFL)
VR5
W50K
AUX-POST
R139
B5K
R202
4K7
7
9
7
SW2C
SW3C
8
8
PS-42E85L
PS-42E85L
17K4
R85
LEVEL
10KD
1K3
+VCC
U1B
4580M
6K8
R50
R25
910R
C101
12n(M)
B50K
VR2
VR3
B50K
6K8
910R
R49
R26
MID
2.5K
C1
47u/25V
RTN-CH1
RTN-CH1
123
J1
POST
1
3
9
SW1A
2
PS-22E85L
LD3
RED
R189
1K5
6K8
R57
4K7
R197
C161
2.2u/50V
C113
10K
R81
33n(M)
LD2
YEL
C114
33n(M)
LO
80HZ
AUX-1
AUX-2
VR32
W50K
AUX-PRE
VR33
W50K
AUX-POST
5K1
5K1
R164
R163
J5
POST
(PRE)
1
3
2
PS-22E85L
AUX1 PRE/POST
+VCC
LD15
RED
R193
1K5
PEAK
3904
TR4
C155
6K8
R77
C165
2.2u/50V
C109
12n(M)
2.5K
C317
47u/25V
U36B
4580M
AUX-1
6K8
(PRE)
AUX1 PRE/POST
PEAK
3904
TR2
3904
TR3
R209
4K7
R121
47K
6K8
R70
VR31B
R69
R140
10K
R93
C129
33n(M)
B50K
6K8
C130
33n(M)
LO
80HZ
VR4
W50K
AUX-PRE
SW5:MUTE/ALT3-4
6K8
SW6:SOLO,PFL
CH2
R222
22P
C142
R429
7K68
PGND1
3904
TR1
C138
47K
R117
-VCC
LOGIC
R125
2K2
LOGIC
10
12
(SOLO)
11
C78
18n(M)
(LOGIC=2.0V or 0.5V)
VR8
B50K
D2
BAS316
C66
18n(M)
SW3D
PS-42E85L
R249
510R
CR-A
ALT-3
LEFT-BUS
RIGHT-BUS
1
3
4
6
SW17A
SW17B
2
5
PS-42E85L
PS-42E85L
5K1
5K1
R166
R165
SW17:MUTE/ALT3-4
SW18:SOLO,PFL
BAL
R215
4K7
4K7
R108
C35
47u/25V
R227
22K
PGND1
1
U8A
22P
3
2
5K1
R155
R438
5K1
-VCC
R129
2K2
LOGIC
YEL
LD14
10
12
(SOLO)
11
22P
C146
C83
18n(M)
VR36A
B50K
C70
18n(M)
EQ HI
ALT-3
LEFT-BUS
RIGHT-BUS
1
3
4
SW5A
SW5B
2
5
PS-42E85L
PS-42E85L
5K1
5K1
R142
R141
R203
4K7
C14
47u/25V
15K
1
U2A
4580M
R436
5K1
3
2
680R
R134
C10
47u/25V
7
22P
1M
R178
6
C6
47u/25V
C90
12n(M)
1K1
R2
EQ HI
C156
4580M
R441
5K1
R99
7K5
LOGIC
(LOGIC=2.0V or 0.5V)
D3
BAS316
SW15D
PS-42E85L
C20
1M
R182
47u/25V
1
U7A
3
2
C19
47u/25V
R36
910R
C94
12n(M)
B50K
VR37A
1K3
1K1
R18
R6
910R
R35
12KHZ
ALT-4
AFL-L
6
1
3
4
SW6A
SW6B
2
PS-42E85L
PS-42E85L
27K
27K
R235
R236
VR13
B5K
PAN
R204
4K7
7
9
SW5C
8
PS-42E85L
10KD
LEVEL
VR14A
U2B
4580M
5
R27
910R
C102
B50K
VR9
1K3
R14
910R
R28
MID
2.5K
C2
47u/25V
RTN-CH2
RTN-CH2
C
CH2
CH3
CH4
CH5/6
CH7/8
CH9/10
CH11/12
RED
RED
LD19
LD22
10
12
10
12
SW20D
PS-42E85L
SW23D
PS-42E85L
11
11
ALT-4
AFL-L
AFL-R
1
3
4
6
SW18A
SW18B
2
5
PS-42E85L
PS-42E85L
27K
27K
R243
R244
VR41
B5K
R216
4K7
7
R109
4K7
SW17C
8
PS-42E85L
C36
47u/25V
22K
7
R228
22P
R439
U8B
4580M
R442
5K1
5
6
5K1
R156
5K1
RED
RED
LD13
LD16
10
12
10
12
SW14D
SW17D
9
PS-42E85L
PS-42E85L
11
11
AUX-2
SOLO(PFL)
AUX-POST
J6
POST
1
3
7
9
SW16A
2
PS-22E85L
SW18C
8
PS-42E85L
10K
R110
+VCC
R194
LEVEL
10KD
VR42B
R100
7K5
22P
C150
C84
18n(M)
B50K
VR36B
4580M
C74
18n(M)
6K8
R64
C106
12n(M)
VR38A
B50K
R63
6K8
MID
2.5K
PRE-CH7
PRE-CH7
AFL-R
6
AUX-2
SOLO(PFL)
5
J2
7
9
SW4A
SW6C
8
PS-42E85L
17K4
R86
R190
1K5
+VCC
6K8
R58
C162
2.2u/50V
6K8
C115
R52
33n(M)
12n(M)
VR10
B50K
6K8
R51
C116
33n(M)
LO
80HZ
LEVEL
VR42A
10KD
6K8
R78
C28
1M
47u/25V
R186
6
C27
47u/25V
C98
12n(M)
1K1
R10
EQ HI
12KHZ
C123
33n(M)
C124
33n(M)
LO
80HZ
VR12
W50K
AUX-POST
6K8
R143
POST
(PRE)
1
3
2
PS-22E85L
LD6
RED
PEAK
TR6
4K7
R198
R118
-VCC
10K
R82
LD5
YEL
(SOLO)
C166
7
R90
3904
2.2u/50V
U7B
4580M
5
R43
910R
C110
B50K
VR37B
1K3
R22
R44
910R
MID
2.5K
10K
YEL
LD17
PRE-CH8
PRE-CH8
AUX-1
VR11
W50K
AUX-PRE
6K8
R144
AUX1 PRE/POST
C143
PGND1
3904
TR5
47K
LOGIC
R126
2K2
(LOGIC=2.0V or 0.5V)
LOGIC
D4
BAS316
10
12
SW6D
PS-42E85L
11
RED
RED
LD7
LD10
10
12
10
12
SW8D
PS-42E85L
SW11D
PS-42E85L
11
11
AUX-1
VR39
W50K
AUX-PRE
VR40
W50K
5K1
5K1
R168
R167
(PRE)
AUX1 PRE/POST
22P
C157
R440
LD18
RED
1K5
PEAK
3904
TR8
3904
TR7
R210
4K7
R122
47K
6K8
R72
12n(M)
VR38B
R71
-VCC
(SOLO)
SW8:MUTE/ALT3-4
22P
R435
7K68
10K
R94
C131
33n(M)
B50K
6K8
C132
33n(M)
LO
80HZ
LOGIC
R130
2K2
(LOGIC=2.0V or 0.5V)
LOGIC
D5
BAS316
10
12
SW18D
PS-42E85L
11
ALT-3
LEFT-BUS
RIGHT-BUS
1
3
4
SW8A
SW8B
2
5
PS-42E85L
PS-42E85L
5K1
5K1
R146
R145
SW9:SOLO,PFL
R205
4K7
C15
47u/25V
R223
15K
1
U3A
4580M
R437
5K1
3
2
680R
R135
C11
47u/25V
22P
1M
C139
R179
6
C7
47u/25V
C91
C79
12n(M)
18n(M)
VR15
B50K
1K1
R3
C67
18n(M)
EQ HI
CH1
RED
RED
LD1
LD4
12
R229
22K
5K1
PGND1
C85
VR43A
C71
ALT-4
6
VR20
PAN
7
5
R15
(MUTE/ALT3-4)
-VCC
AMX180FXMN1-USB
AMX180FXMN1-USB.S01
10
12
10
SW2D
PS-42E85L
SW5D
PS-42E85L
11
11
ALT-3
ALT-4
LEFT-BUS
RIGHT-BUS
1
3
4
6
1
SW20A
SW20B
SW21A
2
5
PS-42E85L
5K1
R169
SW20:MUTE/ALT3-4
SW21:SOLO,PFL
R217
4K7
4K7
R111
C37
47u/25V
1
U10A
4580M
R447
5K1
3
2
5K1
R157
1M
R183
22P
C147
2
C21
47u/25V
18n(M)
C95
12n(M)
B50K
1K1
R7
18n(M)
EQ HI
12KHZ
AFL-L
1
3
4
SW9A
SW9B
2
5
PS-42E85L
PS-42E85L
27K
27K
R237
R238
2
PS-42E85L
PS-42E85L
27K
5K1
R245
R170
BAL
VR48
B5K
R112
4K7
22K
R230
22P
C158
R445
5K1
LEVEL
10KD
VR49B
R101
7K5
C22
47u/25V
1
U9A
4580M
3
R38
910R
B50K
VR44A
1K3
R19
910R
R37
MID
2.5K
PRE-CH9
PRE-CH9
AFL-R
6
AUX-2
SOLO(PFL)
B5K
J3
R206
4K7
7
9
SW8C
8
PS-42E85L
10KD
LEVEL
VR21A
U3B
4580M
R29
910R
C103
B50K
VR16
1K3
910R
R30
MID
2.5K
C3
47u/25V
RTN-CH3
RTN-CH3
1
7
9
SW7A
PS-22E85L
SW9C
8
PS-42E85L
17K4
R87
R191
1K5
+VCC
6K8
R59
C163
2.2u/50V
6K8
C117
R54
33n(M)
12n(M)
VR17
B50K
6K8
R53
C118
33n(M)
LO
80HZ
B
AMX180FXMN1-USB
AMX180FXMN1-USB.S02
AFL-L
AFL-R
3
4
6
SW21B
5
PS-42E85L
27K
R246
R218
4K7
7
9
7
SW20C
SW21C
8
8
PS-42E85L
C38
7
5
6
5K1
R158
R102
C151
C86
18n(M)
B50K
VR43B
C75
18n(M)
6K8
R66
C107
12n(M)
VR45A
B50K
R65
6K8
VR19
W50K
AUX-POST
R147
POST
(PRE)
3
2
LD9
RED
4K7
R199
10K
R83
YEL
LD8
PS-42E85L
47u/25V
10K
R113
U10B
4580M
R448
5K1
LEVEL
VR49A
10KD
7K5
22P
C30
1M
R187
7
U9B
5
6
C29
47u/25V
R45
C99
12n(M)
VR44B
1K3
1K1
R11
R23
R46
EQ HI
12KHZ
C125
R91
10K
33n(M)
C126
33n(M)
LO
80HZ
AUX-1
VR18
W50K
AUX-PRE
6K8
6K8
R148
AUX1 PRE/POST
PEAK
PGND1
3904
TR10
3904
TR9
47K
R119
-VCC
LOGIC
R127
2K2
(LOGIC=2.0V or 0.5V)
LOGIC
D6
BAS316
10
12
(SOLO)
SW9D
PS-42E85L
11
AMX180FXMN1-USB
AMX180FXMN1-USB.S03
ALT-3
ALT-4
LEFT-BUS
1
3
SW23A
SW23B
AUX-1
AUX-2
SOLO(PFL)
VR46
W50K
AUX-PRE
VR47
W50K
AUX-POST
5K1
5K1
R172
R171
J7
POST
(PRE)
1
3
9
SW19A
2
PS-22E85L
AUX1 PRE/POST
22P
C159
+VCC
R195
1K5
6K8
R79
47u/25V
C167
2.2u/50V
4580M
910R
R74
C111
B50K
12n(M)
VR45B
B50K
6K8
R73
910R
MID
2.5K
-VCC
YEL
LD20
(SOLO)
PRE-CH10
PRE-CH10
ALT-3
LEFT-BUS
1
3
SW11A
2
PS-42E85L
5K1
R149
SW11:MUTE/ALT3-4
SW12:SOLO,PFL
R207
4K7
C16
47u/25V
R224
15K
1
22P
C144
3
2
680R
R136
R443
7K68
22P
C140
C80
18n(M)
VR22
B50K
C68
18n(M)
EQ HI
R446
LD21
RED
PEAK
3904
TR12
3904
TR11
R211
4K7
R123
47K
6K8
10K
R95
C133
33n(M)
C134
33n(M)
LO
80HZ
LOGIC
R131
2K2
(LOGIC=2.0V or 0.5V)
LOGIC
D7
BAS316
10
12
SW21D
PS-42E85L
11
ALT-4
RIGHT-BUS
4
6
1
SW11B
SW12A
5
2
PS-42E85L
PS-42E85L
5K1
27K
R239
R150
VR27
B5K
U4A
4580M
R444
5K1
LEVEL
10KD
VR28A
C12
47u/25V
7
1M
R180
U4B
4580M
5
6
C8
47u/25V
C92
R31
910R
12n(M)
B50K
VR23
1K1
1K3
R4
R16
910R
R32
C4
47u/25V
2
PS-42E85L
5K1
R173
SW23:MUTE/ALT3-4
SW23:SOLO,PFL
BAL
R219
4K7
4K7
R114
C39
47u/25V
R231
22K
1
U12A
4580M
R450
5K1
3
2
5K1
R159
5K1
PGND1
1M
R184
1
22P
C148
3
2
C23
47u/25V
C87
18n(M)
C96
12n(M)
VR50A
B50K
1K1
R8
C72
18n(M)
EQ HI
12KHZ
AFL-L
AFL-R
3
4
6
SOLO(PFL)
SW12B
5
PS-42E85L
27K
R240
PAN
R208
4K7
7
9
7
9
SW11C
SW12C
8
8
PS-42E85L
PS-42E85L
17K4
R88
R192
1K5
+VCC
6K8
R60
C164
2.2u/50V
6K8
C119
R56
C104
12n(M)
VR24
B50K
6K8
R55
C120
LO
MID
RTN-CH4
RTN-CH4
80HZ
2.5K
AFL-L
RIGHT-BUS
4
6
1
3
4
SW24A
SW24B
5
2
PS-42E85L
5K1
R174
22P
C160
VR56B
R103
7K5
C24
47u/25V
U11A
R40
910R
B50K
VR51A
1K3
R20
910R
R39
AUX-2
AUX-POST
J4
POST
1
SW10A
2
PS-22E85L
33n(M)
33n(M)
5
PS-42E85L
PS-42E85L
27K
27K
R247
R248
VR55
B5K
R220
4K7
R115
4K7
C40
47u/25V
22K
7
R232
U12B
5
6
5K1
R160
R449
5K1
LEVEL
10KD
R104
7K5
22P
C152
C88
18n(M)
B50K
VR50B
4580M
C76
18n(M)
6K8
R68
C108
12n(M)
VR52A
B50K
R67
6K8
MID
2.5K
PRE-CH11
PRE-CH11
AUX-1
AUX-PRE
VR26
W50K
6K8
6K8
R152
R151
(PRE)
3
AUX1 PRE/POST
LD12
RED
PEAK
3904
TR16
3904
TR15
4K7
R200
47K
R120
-VCC
10K
R84
LOGIC
R128
2K2
LOGIC
D8
YEL
LD11
10
12
(SOLO)
11
A
AFL-R
6
AUX-1
AUX-2
SOLO(PFL)
VR53
W50K
AUX-PRE
VR54
W50K
AUX-POST
5K1
5K1
R176
R175
J8
POST
(PRE)
1
7
9
SW23C
SW24C
8
PS-42E85L
R116
3
7
9
SW22A
2
PS-22E85L
8
PS-42E85L
AUX1 PRE/POST
10K
4580M
R451
5K1
+VCC
R196
LEVEL
VR56A
10KD
6K8
R80
C32
1M
47u/25V
R188
6
C31
47u/25V
C100
12n(M)
1K1
R12
EQ HI
12KHZ
C127
33n(M)
C128
33n(M)
LO
80HZ
VR25
W50K
PGND1
(LOGIC=2.0V or 0.5V)
BAS316
SW12D
PS-42E85L
C168
7
2.2u/50V
U11B
4580M
5
R47
910R
C112
B50K
12n(M)
VR51B
1K3
R24
R48
910R
MID
2.5K
R92
10K
YEL
LD23
(SOLO)
PRE-CH12
C318
100n
PRE-CH12
84
C61
100n
84
C60
100n
84
C59
100n
84
C56
100n
84
C55
100n
84
C51
100n
84
C50
100n
84
C49
100n
84
C45
100n
84
C44
100n
84
C43
100n
84
C41
100n
84
+VCC
R464
0R
LD24
RED
1K5
PEAK
PGND1
3904
TR18
3904
TR17
R212
4K7
R124
47K
6K8
R76
VR52B
R75
-VCC
10K
R96
C135
33n(M)
B50K
6K8
C136
33n(M)
LO
80HZ
LOGIC
R132
2K2
(LOGIC=2.0V or 0.5V)
LOGIC
D9
BAS316
10
12
SW24D
PS-42E85L
11
C319
100n
U36C
4580M
C64
100n
U12C
4580M
C63
100n
U11C
4580M
C62
100n
U10C
4580M
C58
100n
U9C
4580M
C57
100n
U8C
4580M
C54
100n
U7C
4580M
C53
100n
U6C
4580M
C52
100n
U5C
4580M
C48
100n
U4C
4580M
C47
100n
U3C
4580M
C46
100n
U2C
4580M
C42
100n
U1C
4580M
-VCC
1 2 3 4 5 6 7 8 9 10 11 12
D
C
B
A
Page 7
D
- 5 -
8
LEFT-BUS
LEFT-BUS
7654321
19K6
R263
AMX180FXMN1-USB(2/4)
C253
R317
22P
AUX RETURN 1
C213
36K
VR58A
R291
47u/25V
1
2
22P
C254
U20A
4580M
3
W50K
22K
R307
8K2
AUX-RTN1-L
RIGHT-BUS
19K6
RIGHT-BUS
R266
19K6
R265
19K6
R264
36K
R318
VR58B
R294
C214
47u/25V
7
5
6
22P
C255
U20B
4580M
W50K
22K
R308
8K2
AUX-RTN1-R
AUX-1
27K4
R321
SW25A
PS-22E85L
20K
EFX TO AUX1
R319
R315
C215
36K
VR57A
R298
47u/25V
1
U21A
4580M
3
2
W50K
22K
R309
8K2
SW25B
36K
R320
C256
22P
W50K
VR57B
R300
8K2
AUX RETURN 2
AUX-RTN2-L
AUX-RTN2-R
C
AUX-1
27K4
R322
LEFT-BUS
PS-22E85L
20K
R316
C216
47u/25V
7
U21B
4580M
5
6
22K
R310
2TK TO MIX
SW28A
PS-22E85L
W50K
VR65A
SW28B
PS-22E85L
2TK IN
8K2
R261
R303
C211
22P
C185
2K
R311
2TK TO CR-L
C205
47u/25V
10K
47u/25V
7
U22B
4580M
22P
5
6
1K5
R312
C251
100P
2TK-IN-L
C186
2TK TO CR-R
B
C310
100n
84
C235
100n
84
C234
100n
84
RIGHT-BUS
C229
100n
84
C228
100n
W50K
VR65B
8K2
R262
R304
C212
2K
R313
C206
47u/25V
10K
47u/25V
1
U22A
4580M
3
2
1K5
R314
100P
C252
2TK-IN-R
84
C227
100n
84
C223
100n
84
C222
100n
84
C217
100n
84
C311
100n
U28C
4580M
C238
100n
U22C
4580M
C237
100n
U21C
4580M
C232
100n
U20C
4580M
C231
100n
U19C
4580M
C230
100n
U18C
4580M
C226
100n
U17C
4580M
C225
100n
U16C
4580M
C219
100n
U13C
4580M
A
AUX-RTN1-L
MAINL
MAINL
LEFT
R255
MAIN MIX
C312
22P
R454
36K
R257
5K1
10K
R251
22P
C169
10K
C187
47u/25V
7
U28B
5
6
R452
R259
C175
47u/25V
7
5
6
AUX-RTN1-R
4580M
5K1
680R
VR62A
10KD
U13B
4580M
AUX-RTN2-L
MAINR
MAINR
RIGHT
R256
MAIN MIX
C313
22P
R455
36K
R258
5K1
22P
C170
10K
R252
10K
C188
47u/25V
1
U28A
3
2
R453
R260
C176
47u/25V
1
3
2
AUX-RTN2-R
22P
C177
4580M
5K1
680R
VR63A
10KD
U13A
4580M
C171
2TK-IN-L
ALT3-L
LEFT-BUS
SW27A
PS-22E85L
ALT 3/4 OUT
36K
R269
7
5
6
VR59B
(ALT-3)
ALT 3-4
C189
47u/25V
1
22P
R253
27K
2
(ALT3/4 TO MIX)
27K
R305
R287
10K
C243
47u/25V
U16B
4580M
36K
R270
C178
22P
W50K
R277
6K2
22P
C172
U16A
4580M
3
R254
2TK-IN-R
ALT4-R
RIGHT-BUS
SW27B
PS-22E85L
27K
R306
R288
10K
C244
47u/25V
7
U17B
4580M
5
6
W50K
VR59A
+VCC
36K
R271
22P
C179
R458
3K6
C209
47u/25V
AUX1 SEND
6K2
R278
C190
47u/25V
1
U17A
4580M
3
2
27K
R267
22P
C173
-VCC
AUX-SEND1
AUX-SEND1
R289
10K
C199
7
47u/25V
C180
22P
U18B
4580M
5
6
R459
W50K
VR60
26K1
1
C210
R279
8K2
C195
47u/25V
C174
U18A
4580M
3
2
AUX-SEND2
AUX-SEND2
R290
10K
36K
R272
C200
7
47u/25V
U19B
4580M
5
6
3K6
47u/25V
W50K
VR61
8K2
AUX2 SEND
R268
R280
C191
26K1
47u/25V
1
22P
U19A
4580M
3
2
LEFT-BUS
D
RIGHT-BUS
C
ALT-3
ALT-4
B
AUX-1
AUX-2
1 2 3 4 5 6 7 8
A
Page 8
D
- 6 -
C
B
A
8
7654321
C309
C306
100n
84
U26C
100n
4580M
AMX180FXMN1-USB(3/4)
C308
C305
100n
CTRL-R-L
CTRL-R-L
17K4
R426
1
22P
C287
62K
R412
LEFT
U23A
4580M
3
2
5K1
R385
VR64B
10KD
CTRL ROOM
0R
R366
C292
47u/25V
22P
C285
20K
R376
SW-FET
SW-FET
SW29A
PS-22E85L
R358
7
U23B
4580M
5
6
R407
J112
TR20
SW30A
PS-22E85L
MAIN MIX
47K
56K
R420
PFL-IN-L
L-METER
PFL-IN-L
12K
R410
5K1
R383
SW31A
PS-22E85L
ALT-3
TR21
33K
SW-FET
2TK
22P
C288
R413
RIGHT
CTRL ROOM
R367
C293
47u/25V
22P
C286
R377
J112
SW-FET
SW-FET
SW-FET
SW29B
CTRL ROOM SOURCE
20K
R406
C289
47u/25V
22P
C282
10K
R362
2
SOLO(PFL)
SOLO(PFL)
R372
MAINL
20K
R368
1
U25A
4580M
3
20K
20K
R373
ALT3 TO CR-L
C283
2TK TO CR-L
PFL-IN-L
PFL-IN-L
5
SW26B
PS-42E85L
4
6
20K
R369
C290
47u/25V
7
U25B
4580M
22P
R378
68K
5
6
AFL-L
AFL-L
C284
PFL-IN-R
PFL-IN-R
8
SW26C
PS-42E85L
7
C291
47u/25V
22P
68K
R379
6
AFL-R
AFL-R
CTRL-R-R
CTRL-R-R
17K4
R427
1
U24A
4580M
3
2
5K1
R386
62K
VR64A
10KD
0R
R359
56K
7
U24B
4580M
20K
5
6
12K
R409
TR22
J112
SW30B
PS-22E85L
R408
9
PS-22E85L
MAIN MIX
20K
MAINR
20K
R370
ALT-4
20K
R374
ALT4 TO CR-R
LD27
7
SW26A
U26B
4580M
5
PS-42E85L
84
U25C
C304
100n
84
U24C
C302
100n
84
U23C
+VCC
47K
R421
PFL-IN-R
PFL-IN-R
33K
R411
5K1
R384
SW31B
2TK
PS-22E85L
20K
R375
2TK TO CR-R
SW-FET
SW-FET
5K1
R382
SOLO
PFL
ACTIVE
5K1
R381
RED
YEL
LD26
1
3
U26A
2
4580M
10K
R363
R380
220K
+VCC
+VCC
R356
100K
100n
4580M
C307
100n
4580M
C303
100n
4580M
-VCC
R-METER
+VCC
TR24
J112
TR23
SW-FET
SW-FET
C299
R371
1
3
LOGIC
LOGIC
J112
R357
100K
2.2u/50V
20K
10
12
SW26D
PS-42E85L
11
D11
D12
BAS316
BAS316
C296
100n
2
10K
R364
15K
R361
15K
R360
-VCC
LD30
RED
YEL
LD31
GR
LD32
GR
(+4) (+7) (+10) (+18)
LD33
GR
LD34
GR
LD35
LEFT METER
GR
LD36
GR
LD37
GR
LD38
GR
LD39
GR
LD40
GR
(-30) (-20) (-10) (-7) (-4) (-2) (0) (+2)
LD41
3906
TR13
R387
120R 1/4W
+VCC
123456789101112131415
CN3
CTRL-R-L
CTRL-R-R
2TK-IN-L
2TK-IN-R
PH LED
ALT4-R
ALT3-L
2TK-IN-L
2TK-IN-R
FOOTSW
CTRL-R-L
CTRL-R-R
12345678910111213
CN2
PRE-CH9
PRE-CH10
PRE-CH11
PRE-CH12
AUX-SEND1
AUX-RTN2-L
AUX-RTN2-R
AUX-RTN1-L
AUX-RTN1-R
12345678910111213
CN1
GND
+VCC
RTN-CH1
RTN-CH2
RTN-CH3
RTN-CH4
PRE-CH5
PGND
2K
R422
GR
LD29
PWR ON
+VCC
U35B
6
LM339
1
7
U35C
LM339
8
14
9
U34B
6
LM339
1
7
U34C
8
LM339
14
9
U33B
6
LM339
1
7
U33C
8
LM339
14
9
U32B
6
LM339
1
7
U32C
8
LM339
14
9
U31B
6
LM339
1
7
U31C
8
LM339
14
9
U30B
6
LM339
1
7
U30C
8
LM339
14
9
PGND
CR-A
R388
510R
D1B
D1A
16
CON16
1
2
CN17
CON2
GND
+5VD
PGND
DGND
ALT3 TO CR-L
ALT4 TO CR-R
14
CON14
GND
MAINL
MAINR
AUX-SEND2
14
CON14
-VCC
PRE-CH6
PRE-CH7
PRE-CH8
PH LED
R423
8K2
R419
4
5
R418
5K6
10
11
R417
2K
4
5
R416
1K3
10
11
R415
620R
4
5
R414
510R
10
11
R403
470R
4
5
R405
330R
10
11
R402
470R
4
5
R404
330R
10
11
R401
470R
4
5
R391
120R
10
11
56R
R390
R389
510R
R365
10K
DA204K
DA204K
EFXRTN-R
EFXRTN-L
12345
CN5
CH1
4K7
LD28
RED
PHANTOM
U35A
LM339
2
U35D
LM339
13
U34A
LM339
2
U34D
LM339
13
U33A
LM339
2
U33D
LM339
13
U32A
LM339
2
U32D
LM339
13
U31A
LM339
2
U31D
LM339
13
U30A
LM339
2
U30D
LM339
13
PGND
CON5
CH2
LEFT-BUS
RIGHT-BUS
CH1
CH2
LEFT-BUS
RIGHT-BUS
C294
C295
47u/25V
47u/25V
+VCC
47R
R424
100n
C300
312
U35E
LM339
312
U34E
LM339
312
U33E
LM339
312
U32E
312
312
84
D17
1
RLS4148
3
2
D14
7
RLS4148
5
6
L-METER
LM339
U31E
LM339
U30E
LM339
U27C
4580M
R394
RLS4148
U27A
4580M
R393
RLS4148
U27B
4580M
PGND
-VCC
LD42
RED
LD43
YEL
LD44
GR
LD45
GR
LD46
GR
LD47
GR
LD48
GR
LD49
GR
LD50
GR
LD51
GR
D16
LD52
GR
LD53
GR
D13
3906
TR14
R392
120R 1/4W
-VCC
47R
R425
PGND
100n
C301
R398
10K
PGNDPGND
0R0
0R0
PGND
C298
47u/25V
R396
100K
R397
10K
PGND
C297
47u/25V
R395
100K
R399
36K
R400
36K
R-METER
1 2 3 4 5 6 7 8
D
C
B
A
Page 9
D
- 7 -
C
B
A
(MUTE)
SW401A
FOOTSW
1
2
3
4
PS-22E85NL
DGND
R352
220R
DGND
COM
JP1
PGND
U49_1
R353
220R
AMX180FXMN1-USB(4/4)
C263_1
EN2
124
8
SDB161PVB15FS
AR2
680R*4
321
+5VD
AR1
680R*4
123
7 8
5 6
3 4
1 2
COM
124
EN1
SDB161PVB15FS
123
7 8
5 6
3 4
1 2
PRESETVARIATION
C263
4
DGND
4.7uF
AUX-SEND2
8
4
C261_1
C261
4.7uF
3
RL1B
RY-5W-K
(MUTE)
5
7
LD401_2
LD401
C262
4.7uF
RED
PEAK(FLICKER)
MUTE(GLOW)
+VCC
C262_1
RL1C
RY-5W-K
(MUTE)
4
6
8
12345678910
CN11
HEADER 8X2
+5VD
1112
1314
1516
EFXRTN-L
C275
100N
DGND
EFXRTN-R
D20
RLS4148
R331_2
R335_2
C260_2
CN11_16
12
+5VD
RL1A
RY-5W-K
TR26
3904
R274
10K
DGND DGND
3906
TR27
R273
+VCC
GND
-VCC
C261_1
123456789
+5VD
C262_1
TR400_C
CN11_16
CN4
D
PGND
DGND
U49_1
C263_1
LD401_2
10111213141516
C
R281
3904
C260_2
R335_2
R331_2
CON16
+5VD
TR400_C
B
R275
TR25
47K
470R
C181
330uF/16V
R276
20K
10K
DGND DGND
1 2 3 4
DGND DGND
A
Page 10
B
- 8 -
X29
TN
TRS
1
JY-6351G-02-250
R183
120R
R210
10K
47u/25V
4580M
3
4d
2b
RN
C179
U18A
2
3c5e1a
ALT3 TO CR-L
ALT-4 (RIGHT)
R182
120R
R35
5K1
C9
22P
U18B
X32
TN
TRS
7
5
5K1
JY-6351G-02-250
ALT4 TO CR-R
R189
120R
R211
10K
C207
47u/25V
4580M
100n
84
C205
100n
84
+VCC
4d
2b
RN
C180
6
R4
CH1
CH2
CH1
CH2
12345
CON5
+VCC
-VCC
D-D+VINL
C
LEFT-BUS
RIGHT-BUS
LEFT-BUS
RIGHT-BUS
VINL
VINR
AGND
AGND
VOUTL
VOUTR
VINR
VOUTL
VOUTR
123456789
C7
22P
3c5e1a
ALT-3 (LEFT)
R181
120R
R34
5K1
R3
5K1
D
C189
100n
8
7654321
84
C184
100n
84
+VCC
C190
100n
U21C
4580M
C188
100n
U20C
4580M
-VCC
USB_GND
R99
0R
D-
D+
123
4
CN4
USB B TYPE
CN8
+5VD
USB_GND
101112
CN6
USB MIXER
AMX180FXPU1-USB(1/2)
VINL
VINR
VOUTL
VOUTR
A
AMX180FXPU1-USB
AMX180FXPU1-USB.S01
C208
100n
U24C
4580M
C206
100n
U23C
4580M
-VCC
USB MIXER
ALT3-L
VINL
2
SW12A
SW-2WAY
USB RECORD
1
3
1
U20A
R214
10K
CH1
4580M
C101
22P
3
2
10K
R101
MAINL
VINR
5
SW12B
SW-2WAY
4
6
7
10K
R215
C105
22P
5
6
10K
R103
CH2
MAINR
R221
U20B
4580M
VOUTL
2
SW13A
SW-2WAY
USB PLAYBACK
1
3
R104
10K0
C164
22P
3
2
56K
GND
U21A
4580M
1
C197
47uF/25V
CH11
R222
8K06
R227
LEFT-BUS
VOUTR
5
SW13B
SW-2WAY
4
6
R212
10K0
R184
3c5e1a
120R
MAIN R (UNBAL)
X30
4d
2b
TRS
RN
TN
R186
120R
C165
22P
5
6
56K
GND
U21B
4580M
7
8K06
R228
C199
47uF/25V
CH12
RIGHT-BUS
JY-6351G-02-250
R185
3c5e1a
120R
MAIN L (UNBAL)
X33
4d
2b
RN
JY-6351G-02-250
TRS
TN
R190
120R
ALT4-R
RIGHT
213
(BALANCED)
MAIN OUT
X37
R195
120R
JY-5030-030G
213
123
LEFT
X38
JY-5030-030G
R201
5K1
R196
R197
120R
120R
101112
SW9A
PS-42E85L
R200
5K1
R199
120R
5K1
R203
P
SW9D
PS-42E85L
R198
R202
5K1
R194
R193
120R
R192
120R
MAIN-R-3
C217
47u/25V
R260
R255
C178
1000uF/16V
+5VD
TR2
7805
+VCC
TR1
7815A
PGNDDGND
PH PWR-LED
47K
R229
TR5
PGND
R205
0R
PGND
C176
C177
220u/25V
220u/25V
-VCC
D28
D27
5817
5817
D6
RLS4148
RLS4148
D5
TR3
7915A
C174
C173
2200u/25V
2200u/25V
R206
TR4
3904
PH PWR
20K
R209
C172
4R7
47u/100V
(47V 0.5W)
TIP122
PH PWR-LED
SW11
CN2.5-2P-180
R208
47K
R230
100K
+VCCPH LED
PGND
ZD1
1N5261
C171
100u/100V
MAINL
MAINR
68R0
15K0
R252
33P
C210
2
R237
10K0
RIGHT
22K
1
U23A
4580M
C212
33P
3
C209
R245
33P
11k
MAIN-R-2
MAIN-L-3
MAIN-L-2
C219
47u/25V
R259
22K
R248
18K
R247
18K
R256
68R0
7
U23B
4580M
R251
18K
5
6
R238
10K0
11K
R243
MAIN OUT
789
R257
68R0
15K0
R253
33P
C211
33P
C215
2
LEFT
R241
10K0
(BALANCED)
120R
456
P
SW9C
PS-42E85L
C218
47u/25V
R261
22K
1
U24A
4580M
C214
33P
3
C213
R246
33P
11K
120R
P
SW9B
PS-42E85L
C220
47u/25V
R262
22K
R250
18K
R249
18K
R258
68R0
7
U24B
4580M
R254
18K
5
6
C216
33P
R242
10K0
11K
R244
PHANTOM PWR
R204
0R
D1
1N4002
D2
D3
1N4002
C175
100u/100V
PHANTOM
R207
C170
100u/100V
1N4002
390K
D4
1N4002
INSERT1
3c5e1a
X28
INSERT2
JY-6351G-02-250
4d
2b
TRS
RN
TN
R180
120R
3c5e1a
X31
INSERT3
JY-6351G-02-250
4d
2b
TRS
RN
TN
R187
120R
3c5e1a
X34
INSERT4
JY-6351G-02-250
4d
2b
TRS
RN
TN
R188
120R
3c5e1a
X35
JY-6351G-02-250
4d
2b
TRS
RN
TN
R191
120R
3c5e1a
X36
4d
JY-6351G-02-250
2b
FOOTSW
C169
100u/100V
SW10
CN2.5-2P-90
PGND
CN5
AC IN
D
C
RTN-CH1
INS-CH1
RTN-CH2
INS-CH2
RTN-CH3
INS-CH3
RTN-CH4
INS-CH4
B
A
1 2 3 4 5 6 7 8
Page 11
D
- 9 -
C
B
A
12
1110987654321
AMX180FXPU1-USB(2/2)
PRE-CH9
20K0
R149
C108
47u/25V
7
U16B
4580M
C56
22P
R272
2K20
5
6
2K20
R114
5K1
R159
R264
510R
(LEVEL +4dBu/-10dBv)
R110
2K20
R278
2K20
SW7A
PS-22E85L
C69
22P
R106
10K
R84
10K
C129
100P
100P
C127
TRS
RN
TN
3c5e1a4d2b
X7
JY-6351G-02-250
LEFT(MONO)
LINE IN 9
C97
47u/25V
1
22P
C55
U11A
4580M
R66
5K11
3
2
22P
C54
R65
5K11
R81
R80
10K
1
U12A
4580M
5K11
3
2
D13
4148
D16
4148
R44
3K60
C34
47u/50V
R16
47R
213
4
10K
7
22P
C53
R63
22P
C52
VR9
Z10K
+VCC -VCC
+VCC -VCC
C10
47P
R25
R24
6.81K 1%
C8
470P
PH PWR
R15
47R
X23
SMC-6.02
U12B
4580M
5K11
R64
5
6
R52
27R
C42
1000u/10V
D15
4148
D14
4148
R45
3K60
C35
47u/50V
6.81K 1%
MIC 5
PRE-CH5
R82
10K0
R147
10K0
C106
47u/25V
7
U13B
4580M
22P
C51
R271
2K20
5
6
2K20
R96
5K1
R156
R263
510R
SW5A
PS-22E85L
R90
10K
R79
10K
100P
C121
TRS
RN
TN
3c5e1a4d2b
X4
LEFT(MONO)
LINE IN 5
(LEVEL +4dBu/-10dBv)
2K20
R93
2K20
R273
22P
C66
C124
100P
JY-6351G-02-250
PRE-CH10
20K0
R151
C109
47u/25V
1
4580M
U16A
C72
22P
R281
2K20
3
2
R112
R113
R267
R107
10K
RN
3c5e1a4d2b
R100
20K
R83
C107
R277
2K20
R97
R265
R89
10K
RN
3c5e1a4d2b
2K20
2K20
5K1
R160
R279
510R
C131
100P
TRS
TN
RIGHT
LINE IN 10
PRE-CH6
2K20
SW7B
PS-22E85L
10K
C71
22P
R108
100P
C132
X8
JY-6351G-02-250
10K0
R148
10K0
47u/25V
1
U13A
4580M
C68
22P
3
2
2K20
R157
5K1
510R
SW5B
PS-22E85L
R91
10K
100P
C122
TRS
TN
X5
RIGHT
LINE IN 6
(LEVEL +4dBu/-10dBv) (LEVEL +4dBu/-10dBv)
2K20
R94
2K20
R274
22P
C64
100P
C123
JY-6351G-02-250
PRE-CH11
20K
R239
C203
47u/25V
2
SW14A
PS-22E85L
1
3
CH11
R150
C110
47u/25V
7
U17B
4580M
C73
22P
R282
2K20
5
6
R115
2K20
5K1
R161
R268
510R
SW8A
PS-22E85L
R109
10K
R105
10K
100P
C128
TRS
RN
TN
3c5e1a4d2b
LEFT(MONO)
LINE IN 11
PRE-CH7
C103
47u/25V
7
U15B
22P
C67
R276
2K20
5
6
R98
2K20
5K1
R158
R266
510R
SW6A
PS-22E85L
R92
10K
R88
10K
100P
C125
TRS
RN
TN
3c5e1a4d2b
LEFT(MONO)
LINE IN 7
(LEVEL +4dBu/-10dBv)
R111
2K20
R280
2K20
22P
C70
C130
100P
X9
JY-6351G-02-250
20K0
R146
4580M
(LEVEL +4dBu/-10dBv)
2K20
R95
2K20
R275
C65
22P
C126
100P
X6
JY-6351G-02-250
PRE-CH12
20K
R240
C204
47u/25V
5
SW14B
PS-22E85L
4
6
CH12
R155
C115
47u/25V
1
C81
22P
4580M
R286
2K20
R284
2K20
U17A
3
2
R124
R125
R270
R122
10K
C135
RN
TN
3c5e1a4d2b
C114
C79
R121
R269
R118
10K
C133
RN
TN
3c5e1a4d2b
2K20
2K20
5K1
R163
100P
TRS
2
100P
TRS
R285
SW8B
PS-22E85L
10K
22P
R123
C80
100P
C136
X12
JY-6351G-02-250
RIGHT
PRE-CH8
20K0
R154
1
4580M
U15A
3
R120
2K20
5K1
R162
R283
SW6B
PS-22E85L
C78
22P
R119
10K
100P
C134
X11
JY-6351G-02-250
RIGHT
510R
LINE IN 12
47u/25V
22P
2K20
510R
LINE IN 8
C24
100n
C25
100n
84
U18C
4580M
C167
C166
100n
84
(LEVEL +4dBu/-10dBv)
C162
100n
84
2K20
C160
100n
84
C158
100n
84
C156
100n
84
C154
100n
84
C152
100n
84
C149
100n
84
C147
100n
84
C145
100n
84
C143
100n
84
(LEVEL +4dBu/-10dBv)
C141
100n
84
C139
2K20
100n
84
C137
100n
84
+VCC
100n
+VCC
C151
100n
C113
47u/25V
84
84
PHONES
120R
1
2
2
10K
R126
-VCC
C168
100n
C116
47u/25V
U10C
BA15218N
U9C
BA15218N
X21
JY-6351G-02-250
R174
R173
120R
U10A
BA15218N
3
1
U9A
BA15218N
3
CTRL-R-R
R175
120R
120R
7
U10B
BA15218N
5
6
7
U9B
BA15218N
5
6
R127
10K
22P
C120
CTRL-R-L
U15C
4580M
C163
100n
U13C
4580M
C161
100n
U12C
4580M
C159
100n
U11C
4580M
C157
100n
U17C
4580M
C155
100n
U16C
4580M
C153
100n
U8C
4580M
C150
100n
U7C
4580M
C148
100n
U6C
4580M
C146
100n
U5C
4580M
C144
100n
U4C
4580M
C142
100n
U3C
4580M
C140
100n
U2C
4580M
C138
100n
U1C
4580M
-VCC
X27
SCP6873NS3232
TAPE IN TAPE OUT
CN3
CN2
CN1
MAINL
MAINL
12
1K
R176
1 4
L(WHITE)
123456789101112131415
CTRL-R-L
CTRL-R-R
2TK-IN-L
2TK-IN-R
PGND
DGND
PH LED
ALT3-L
ALT4-R
FOOTSW
2TK-IN-L
2TK-IN-R
CTRL-R-L
CTRL-R-R
123456789101112131415
PRE-CH9
PRE-CH10
PRE-CH11
PRE-CH12
GND
AUX-RTN2-L
AUX-RTN2-R
AUX-SEND1
AUX-SEND2
AUX-RTN1-L
AUX-RTN1-R
12345678910111213
GND
+VCC
RTN-CH1
RTN-CH2
RTN-CH3
RTN-CH4
PRE-CH5
PRE-CH6
PRE-CH7
PRE-CH8
MAINR
2TK-IN-L
MAINR
1K
R177
6
2 5
3
R(RED)
16
CON16
GND
+5VD
ALT3 TO CR-L
ALT4 TO CR-R
16
CON16
MAINL
MAINR
EFXRTN-L
EFXRTN-R
14
CON14
-VCC
3c5e1a4d2b
2TK-IN-R
R172
22P
C119
AUX SEND1
INS-CH1
123
SW1A
LO CUT
C94
1
U2A
4580M
3
2
R59
R76
10K
1
U1A
4580M
5K11
3
2
D7
4148
D11
4148
R41
3K60
R32
11K0
C31
47u/50V
C21
22u/35V
R13
47R
213
4
C2
470P
MIC 1
PS-22E85L
20K
R140
47u/25V
R62
5K11
22P
C48
5K11
R56
VR5
Z10K
+VCC -VCC
R21
6.81K 1%
C3
470P
6K8
R136
C84
0.22u/50V
22P
C50
C83
R132
0.22u/50V
R77
10K
22P
C47
22P
C46
R51
27R
+VCC -VCC
C6
47P
C33
47u/50V
R22
6.81K 1%
PH PWR
R12
47R
3c5e1a4d2b
X22
SMC-6.02
LINE IN1
R142
20K
C96
47u/25V
7
U2B
4580M
5
6
1K3
R58
D9
4148
D8
4148
62K
R128
C82
0.22u/50V
7
U1B
5K11
4580M
5
6
C41
1000u/10V
R43
11K0
R31
C23
22u/35V
C5
R2
R1
X1
U3A
3K60
R33
11K0
C32
470P
C22
22u/35V
51K
51K
C1
470P
JY-6351G-02-250
INS-CH2
123
SW2A
LO CUT
C95
47u/25V
1
U4A
4580M
3
2
22P
C49
R60
R78
10K
1
4580M
R57
3
2
D10
4148
D12
4148
R42
3K60
47u/50V
R11
47R
213
4
MIC 2
PS-22E85L
20K
R141
R61
5K11
5K11
5K11
VR6
Z10K
+VCC -VCC
R23
6.81K 1%
C4
470P
R14
47R
6K8
R137
C89
0.22u/50V
C87
22P
C63
0.22u/50V
R133
R86
10K
22P
C60
22P
C58
R54
27R
+VCC -VCC
C16
47P
C36
47u/50V
R28
6.81K 1%
PH PWR
3c5e1a4d2b
X25
SMC-6.02
LINE IN2
R145
20K
C100
47u/25V
7
U4B
4580M
5
6
1K3
D18
D17
62K
R130
C86
0.22u/50V
7
U3B
4580M
R68
5K11
5
6
C43
1000u/10V
4148
U5A
4148
R46
3K60
C37
R38
R36
11K0
C27
22u/35V
X2
11K0
47u/50V
C13
470P
C26
22u/35V
51K
R7
51K
R6
C11
470P
JY-6351G-02-250
INS-CH3
123
SW3A
LO CUT
C98
47u/25V
1
U6A
4580M
3
2
R70
R87
10K
1
R69
4580M
3
2
D19
4148
D22
4148
R47
3K60
R17
47R
213
4
MIC 3
PS-22E85L
20K
R143
R71
5K11
22P
C61
5K11
5K11
VR7
Z10K
+VCC -VCC
R26
6.81K 1%
C12
470P
R18
47R
6K8
R138
C90
0.22u/50V
C88
0.22u/50V
22P
C62
R134
R85
10K
22P
C59
22P
C57
R53
27R
+VCC -VCC
C15
47P
C38
47u/50V
R27
6.81K 1%
PH PWR
3c5e1a4d2b
X24
SMC-6.02
LINE IN3
R144
20K
C99
47u/25V
7
U6B
4580M
5
6
1K3
D21
D20
62K
R129
C85
0.22u/50V
7
R67
5K11
U5B
4580M
5
6
C44
1000u/10V
4148
U7A
4148
R48
3K60
R40
11K0
R37
11K0
C28
22u/35V
R8
R5
X3
C39
47u/50V
C14
470P
C29
51K
51K
C17
470P
JY-6351G-02-250
INS-CH4
123
SW4A
LO CUT
C111
47u/25V
1
U8A
4580M
3
2
R74
R117
10K
1
4580M
R73
3
2
D23
4148
D26
4148
R49
3K60
22u/35V
R19
47R
4
MIC 4
PS-22E85L
20K
R152
R75
5K11
22P
C76
5K11
5K11
VR8
Z10K
+VCC -VCC
R30
6.81K 1%
C18
470P
R20
47R
213
6K8
R139
C93
0.22u/50V
C92
0.22u/50V
22P
C77
R135
R116
10K
22P
C75
22P
C74
R55
27R
+VCC -VCC
C20
47P
C40
47u/50V
R29
6.81K 1%
PH PWR
3c5e1a4d2b
X26
SMC-6.02
LINE IN4
R153
20K
C112
47u/25V
7
U8B
4580M
5
6
1K3
D25
4148
D24
4148
62K
R131
C91
0.22u/50V
7
R72
5K11
U7B
4580M
5
6
C45
1000u/10V
R50
3K60
R39
11K0
C30
C19
22u/35V
470P
51K
R10
51K
R9
X10
JY-6351G-02-250
STEREO AUX
3c5e1a4d2b
R165
AUX-RTN1-L
C191
C183
47u/25V
LEFT 1
RETURN1
(MONO / MASTER)
X17
3c5e1a4d2b
TRS
RN
TN
120R
R164
120R
AUX-SEND1
AUX-RTN1-R
C185
100P
47u/25V
3c5e1a4d2b
X13
JY-6351G-02-250
RIGHT 1
AUX SEND2
X18
3c5e1a4d2b
JY-6351G-02-250
R166
120R
C192
100P
X14
JY-6351G-02-250
JY-6351G-02-250
TRS
RN
TN
R169
120R
AUX-SEND2
R178 R179
EFXRTN-L
LEFT
CTRL ROOM OUT
X20
3c5e1a4d2b
R171
120R
R168
120R
CTRL-R-L
AUX-RTN2-L
C193
C186
100P
47u/25V
3c5e1a4d2b
X15
JY-6351G-02-250
LEFT 2
RETURN2
STEREO AUX
RIGHT
X19
JY-6351G-02-250
3c5e1a4d2b
JY-6351G-02-250
R170
120R
R167
120R
CTRL-R-R
AUX-RTN2-R
C194
C187
100P
47u/25V
EFXRTN-R
3c5e1a4d2b
X16
JY-6351G-02-250
RIGHT 2
1 2 3 4 5 6 7 8 9 10 11 12
D
C
B
A
Page 12
D
- 10 -
8
C
B
A
DSP-PRE
DGND
7654321
U49D
U49F
74HC14
74HC14
8 9
12 13
DGND
12
13
K
R
15
CLK
S
11
9
R415
47K
+5VD
4TG2TH6
RS
DS
CTR
OUT
U43A
NE555
3
U49C
74HC14
5 6
U49B
74HC14
3 4
DGND
C350
10uF
7
5
DGND
DGND
DGND
C333
100N
U48B
14
74HC109
J
Q10Q
D15
BAS316
C353
+5VD
R414
10K
D7
BAS316
R413
10K
+5VD
2
J
Q6Q
U48A
74HC109
R412
10K
10K
R411
R410
10K
TR17
3904
R1
0R
3904
TR16
1uF
12
U49A
4
3
K
R
CLK
S
7
R409
10K
DGND
74HC14
C352
1uF
DGND
DGND
1
5
DGNDDGND
C351
10uF
+5VD
C341
100N
147
U49G
74HC14
C340
D16
DA202K
D10A
U46A
4580M
10K
U46B
4580M
NetCN6_16
NetU49_1
R419
7K5
+VCC
NetC343_1
PGND
DGND
NetLD54_2
NetC332_2
10111213141516
RB400D
R431
820K
R426
220R
5
6
R425
2M2
R417
1M
C334
NetR408_2
NetR400_2
U47B
LM393
7
R418
1K
100N
3
2
U47A
R416
PEAK(FLICKER)
MUTE(GLOW)
LM393
4K7
1
CN1-2.0-16P
R400
10K
C348
33P
5
R399
C345
C329
6
10K
R398
10K
U44B
1.5nF 2.5%
4580M
7
10K
R397
3
2
22P
R422
3K3
U44A
4580M
1
R420
100R
R408
10K
C349
33P
C332
5
R406
C347
C331
6
10K
R405
10K
U45B
1.5nF 2.5%
4580M
7
10K
R402
3
2
22P
R423
3K3
U45A
4580M
1
R421
100R
(MUTE)
22P
R404
10K
C346
1.5nF 2.5%
ZD2
2.4V
22P
C330
ZD1
2.4V
(MUTE)
1
R407
10K
2
7
R424
2K2
5
6
R401
10K
GND
+VCC
-VCC
NetC342_1
NetC344_1
NetTR16_C
123456789
3
R403
+5VD
CN1
100N
168
U48C
74HC109
81
84
84
C338
100N
84
C336
100N
84
DGND
U43B
NE555
U47C
LM393
U46C
4580M
C339
100N
U45C
4580M
C337
100N
U44C
4580M
-VCC
+VCC
1 2 3 4 5 6 7 8
D
C
B
A
Page 13
D
- 11 -
C
C9
22P
B
C31
100n
84
U3C
C33
100n
4580M
A
AMX-USB
4
R6 10M
DGND
X1
12MHz
DGND DGND
C8
22P
C30
100n
84
U2C
C32
100n
4580M
DGND
+VCC
C13 1uF
C12 1uF
C11 1uF
C10 1uF
20
23
27
28
25
22
26
VDDI
DGND
SSPDN
D+1D-2VBUS3DGND4HID05HID16HID27SEL08SEL19VCCCI10AGNDC11VINL12VINR13VCOM
U1
321
R4 22R
R3 22R
1 2
R5
1K5
R9
10R
+5V
USB_GND
C7
100uF
21
24
DIN
DOUT
R2
19
XTI
XTO
VCCXI
AGNDX
VOUTR15VOUTL16VCCP1I17AGNDP18VCCP2I
PCM2902
14
10uF
DGND
0R
10uF
C6
C5
10uF
C2
R24
18K
C15
1.8nF
AGND
R16
3K9
3
2
AGND
C28
220P
R22
27K
U3A
R23
4580M
1
USB_GND
C4 10uF
C3 10uF
L1
BLM21
R18
100R
R19
100R
R20
100R
C17
330P
C22
10uF
-VCC
AGND
10uF
C1
R25
18K
C18
1.8nF
AGND
R17
3K9
5
6
C29
220P
27K
U3B
4580M
7
R21
100R
C19
330P
AGND
C23
10uF
AGND
1
C26
1n
U2A
4580M
R7
C35
100n
USB_GND
DGND
R26
R1
1K82
3.6V~3.8V
OUT
3K16
C34
100n
G
IN
OUT
IN
G
1K5
USB_GND
+VCC
3
2
R14
3K9
C24
R12
12K
C20
10uF
R10
4K7
C14
AGND
-VCC
AGND
R8
1K5
4.7nF
330P
AGND AGND
7
C27
1n
U2B
4580M
5
6
R15
3K9
C25
4.7nF
R13
12K
C21
10uF
R11
4K7
C16
330P
AGND AGND
1 2 3 4
+5V
VINL
VINR
VOUTL
D-
TR1
A1117
CN1
D+
101112
CON12
VOUTR
123456789
D
C
B
A
Page 14
D
Voltage Converter
5. WIRING DIAGRAM
- 12 -
8
AC IN
TG00041
7654321
AC/120V
18VAC~
C
B
A
CN3
CN3
SW10
CN8 CN2
CN17
CN2
AMX-180FX USB
PCB AMX180FXPU1-USB
PCB AMX180FXMN1-USB
D
CN1
SW11
C
CN1
CN5
1 2 3 4 5 6 7 8
B
A
Page 15
6. PCB LAYOUT
-13 -
Page 16
- 14 -
Page 17
Page 18
- 16 -
Page 19
- 17 -
Page 20
7. TEST PROCEDURE
- 18 -
1. Instruments:
1). AP (Audio precision)
2). Dual oscillograph
3). voltmeter
4).USB connector line
2. Instruments Setting:
1). AP output: 0dBu 1KHz SINE wave, Load out 40Ω Bal-Gnd or Load out 20Ω Unbal-Gnd.
2). AP input: Load 100KΩ BNC-Float or Load 100KΩ XLR-Bal BW: 22Hz~22KHz. Fltr:
A-Weighting (1207).
3. Visual Check: check the surface of the AMX-180FX, and be sure it is OK; check the
potentiometer knob, and be sure it has no frication.
4. Functional Test:
1). After the surface check is OK, input the proper AC power voltage, open the maim
power switch, the POWER led will light up. Then open the PHANTOM switch, the
PHANTOM led will light up. The second and third pin on each MIC output socket {MIC1,
MIC2, MIC3, MIC4, MIC (MONO)} has 48V PHANTOM voltage which is tested by
voltmeter, and close this switch (notice: we should close this switch for the following
test , or the instrument will be damaged).
2). Put the MAIN MIX LEVEL, PHONES/CONTROL ROOM, EQ, AUX, PAN, and BAL
knob in 0; put the TRIM, AUX RTN1 and AUX RTN2 in min, the entire keys is OFF.
(when test the LEVEL of CH1~CH2, we should turn the LEVEL to max)
3). AP input 0dBu, connect the balanced input to MIC {MIC1, MIC2, MIC3, MIC4, MIC
(MONO)} respectively; when the balanced output is in MAIN MIX OUTPUT, the output
is +5dBu (±2dB) THD+N<0.005%.
Page 21
4). Connect the unbalanced input to AUX RETURN2 respectively, the unbalanced output
- 19 -
(LEFT & RIGHT) of the MAIN MIX OUTPUT is 4dBu (±2dB) THD+N<0.005%.
5). Connect the unbalanced input to AUX RETURN1 respectively, the balanced output
(LEFT & RIGHT) of the MAIN MIX OUTPUT is 4dBu (±1dB) THD+N<0.003%.
6). Connect the unbalanced input to AUX RETURN2 LEFT (MONO), press the EFX TO
AUX1switch, turn the AUX RTN2 to 0, and the output of AUX SEND1 is 0dB (±1dB)
THD+N<0.005%.
7). Connect the RCA terminal to L & R on TAPE IN respectively:
a. Once press the 2TK TO MIX, MAIN TO CONTROL ROOM key, we can test the
unbalanced output (LEFT & RIGHT) of MAIN MIX OUTPUT and output of CONTROL
ROOM, the output of PHONE (use the STEREO jack to test) is 0dBu (±2dB)
THD+N<0.006%, the output of TAPE OUT is -3dBu (±1dB) THD+N<0.007%.
b. release the 2TK TO MIX, MAIN TO CONTROL ROOM key (OFF), when turn the 2TK
IN to 0, the CONTROL ROOM has no output; when press the 2TK TO CONTORL
ROOM, the output is -4dBu (±2dB) THD+N<0.002%.
8). Input +15dBu 1KHz SINE wave (Load out 600Ω BNC-Unbal) from LINE1, press the
MAIN MIX TO CONTROL ROOM, turn the MAIN MIX LEVEL to min, the LED LEVEL
will be decreased simultaneously; turn the MAIN MIX LEVEL potentiometer to max, the
LED LEVEL will light up in return. The output level (LEFT & RIGHT) of MAIN MIX
OUTPUT will match with the LED: whenever the LED point at which level, it will appear
the corresponding output level value, and the max non-distortion is +15dBu (±1dB,
THD+N<0.005%).
b.Turn the TRIM knob on CHANNEL1 in clockwise, the PEAK led will light up (red). Use
the same way to test the knob on CHANNEL2~CHANNEL4, and to see if the PEAK led
is in normal.
5. Frequency Response Test:
According to the following procedure to test when the LINE1, LINE2, LINE3, LINE4,
LINE5, and LINE6 is in input condition, and to test the output frequency response curve of
MAIN MIX OUTPUT (LEFT & RIGHT). Set the entire knob and the functional testing to
initialize: 4.2)).
1). Open the AMX-180FXRESP1.at1, we can test when press and release the LOW CUT
switch, the curve is:
Page 22
- 20 -
2). When put the EQ HI & LOW knob to max and min (EQ MID is mid), the frequency
response curve is:
3). Set the EQ MID knob to max and min (EQ HI & LOW is in mid) respectively, the
frequency response curve is:
Page 23
- 21 -
Note: normal instrument frequency response test:
1). Input from each channel respectively; rotate the EQ LOW knob of the corresponding
channel to max (±15) in clockwise, and the output is +15dBu (±2dB); rotate the EQ
LOW knob on this channel to min (-15) in counterclockwise, and the output is -15dBu
(±2dB);
2). Change the input frequency to 2.5KHz, rotate the EQ MID knob on corresponding
channel to max (+12) in clockwise, and the output is +12dBu (±2dB), the output is
-12dBu (±2dB) on the other hand;
3). Change the input frequency to 12KHz, rotate the EQ HIGH knob on the corresponding
channel to max (+15) in clockwise, the output is +15dBu (±3dB);
6. The effect for testing DSP:
Input signal from MIC1 to MIC4, input signal from AUX SENDS1, at the moment turn the
AUX2, AUX2 SEND, AUX RTN2 (DFX) to max, and turn the AUX1 to min, rotate the
PRESETS and ARATIONS knob, it will appear the signal which has been processed by
DSP, if the INPUT signal is larger, the PEAK led will light up (red), once press the DFX
MUTE key, it will appear the BYPASS signal.
7. The test for USB function:
1). Set the MAIN MIX LEVEL, PHONES/CONTROL ROOM, EQ, PAN, BAL knob to 0, the
TRIM, AUX1, AUX2, AUX RTN1, AUX RTN2, 2TK IN, ALT3-4, SENDS to min, rotate
the PAN on CH1 to LEFT, and the PAN knob on CH2 to RIGHT, and set the entire key
in OFF.
2). AP input 0dBu, connect the balanced input to MIC1, MIC2, CH1, CH2 and rotate the
LEVEL on these to max, set the unbalanced output in MAIN MIX OUTPUT, and the
output is +10dBu (±2dB) THD+N<0.005%.
Page 24
3). Switch the USB RECORD to CH1/2 and the USB PLAYBACK to MAIN MIX, connect
- 22 -
the USB line to PC, and open the recorder to tape for 60 seconds.
4). Take off the input signal, and press the playing key, the output is 0dBu (±2dB)
THD+N<2%.
5). AP input 0dBu, connect the balanced input to MIC1, MIC2, CH1, CH2 and rotate the
LEVEL on these to max, set the unbalanced output in MAIN MIX OUTPUT, and the
output is +10dBu (±2dB) THD+N<0.005%.
6). Switch the USB RECORD to MAIN MIX, the USB PLAYBACK to CH11/12, and connect
the USB line to PC, open the recorder to tape for 60 seconds.
Page 25
7). Take off the input signal, press the LINE/USB on CH11/12, push the CH LEVEL to 0,
- 23 -
and then press the playing key, and the output is +4dBu (±2dB) THD+N<1%.
8). Open the C:\Apw in\S2\A-A FFT. at2 and set:
9). Do not input the signal, set the unbalanced output in MAIN MIX OUTPUT, switch the
USB RECORD to MAIN MIX, the USB PLAYBACK to MAIN MIX, connect the USB line
to PC, and open the recorder to tape for 60 seconds.
10). After recording, press the playing key, the AP will start to scan; the waveform has no
special prominence, and then connects the high quality amplifier and speaker to listen
if there has high frequency sounding.
Page 26
- 24 -
8. Selecting Check: connect the AMX-180FX USB to high quality amplifier and speaker,
and listen if there has abnormal noise.
9. Factory Preset: rotate the entire volume control knob to min, and the other control knob
in mid, and close the entire switch in OFF.
Page 27
8. EXPLODED VIEW & PARTS LIST
- 25 -
Page 28
No. Part No. Description Specification Pcs
A
φ
φ
A
p
φ
p
φ
p
φ
p
φ
p
φ
p
φ
p
φ
r
φ
p
p
φ9*φ
φ8φ
y
A
(
)
p
r
φ
A
(
)
r
p
A
A
(
)
- 26 -
PARTS LIST
1 NI01945 ZC-handle
MX-180; 180FX-V1.0 1
2 HK06386 K-PC board P-AMX180FXMN1-USB-DIP 1
3 NI01863 key-RS
4 NI02377 knob-RS-C-ABS
5.5*W10*7.5 black 34
5.5*7.5mm(3.3*3.3mm) black 8
5 MG00041 screw-RS M3*6 33
6 MA05705 ZC-panel
MX-180FX USB ALTO-V1.3 1
7 NI02309 knob-RS 24*11.5*11-V1.1 8
8 NI02352 knob-RS 24*11.5*11 2
9 NI02353 knob-RS 24*11.5*11 1
10 NI02082
11 NI02633
12 NI02081
13 NI02083
14 NI02714
15 NI02817
16 NI02386
lastic knob-RS-C
lastic knob-RS-C
lastic knob-RS-C
lastic knob-RS-C
lastic knob-RS-C
lastic knob-RS-C
lastic knob-RS-C
17 MF00061 washe
10.5*18mm dual 8
10.5*18mm dual 10
10.5*18mm dual 10
10.5*18mm dual 24
10.5*18mm dual 5
10.5*18mm dual 2
14*13mm dual 2
9.6*φ13*0.5t 30
18 ME00060 MIC nut-HC00125 JY-6351G-02-250 30
19 MG00061 screw-RS M3*10 18
20 HI00171
21 HI00026
ower switch-RS R612KKATOF 1 1
ower switch-RS RA12KKATOF 2P 1
22 HC00601 DC socket-RS SCD554CCS003000 1
23 NI00378plastic washer-RS-C
24 NC00037 ZD-cushion-XM1602-07 1t
13 used to PU socket 1
12.5mm XM1602-V1.0 1
25 ME00143 nickle nut-HC00601 10 5/6"*32w 1
26 HK06383 K-PC board P-AMX-180FXPU1-USB-DIP 1
27 NI01862 ke
28 MI03095 ZD-heat sink-AXM180FX.USB-0
-RS-C 5.5*5.5*14.5-V1.1 10
MX180FX.USB 1t*125*160-V1.11
29 MG00162 nickle screw-RS M3*8 3
30 NC00005 sheet mica-RS SB-9500DSP 18*13*0.1t-V1.0 4
31 NI02249 insulator-RS TW-1
32 MF00037 s
ring washe
3.2*φ5.5*1t 7
TO-220
4
33 ME00015 color nut-RS 3mm 3
34 MG00243 copper pillar -RS M3*5*0.5PH 3
35 HK6381 K-PC board
MX-USB-DIP 1
36 HK06352 K-PC board P-DSP-PRE-DIP 1
37 HK01409 K-PC board P-313123-DIP
AMX-140FX
1
38 NI02620 ZD-insulator board-L8-04 1*86.5*53 L-8 1
39 MG00326 screw-RS M3*4 2
40 NC00080 ZD-washe
41 MJ00808
ower fixed clip-RS WL3-32T 1
42 MJ01318 ZC-fixed board
43 MB04414 ZB-chassis
44 NI00498 self-adhere cushion-RS 12.7*7*6mm
1*φ3.17*φ8.2* black 1
MX-180FX USB-V1.2 1
MX-180FX.USB-V1.0 1
SF-005
4
45 MG00036 screw-RS M3*4 3
Page 29
No. Part No. Description Specification Remark
9. BOM
- 27 -
1 NI00498 self-adhere foot cushion 12.7*7*6mm(SF-005)
2 NI00252 sleeve φ4*20mm
3 NI00248 sleeve φ4*1000mm
4 MA05705 panel AMX-180FX USB ALTO_V1.4
5 MA05598 panel-RS AMX-180FX.USB
6 AE00343 solvent No.003
7 AE00177 paint-RS 4866
8 MA05597 panel-RS AMX-180FX.USB 0.8t*42*327.5*385_V1.2
9 MJ00068 iron board 0.8*2135*1220 16.35kg
10 MJ01318 fixed board AMX-180FX USB_V1.2
11 MJ01298 fixed board-RS AMX-140FX.USB
12 AE00177 paint-RS 4866
13 MJ01297 fixed board-RS AMX-140FX.USB 0.8t*33*103.5_V1.0
14 MJ00068 iron board 0.8*2135*1220 16.35kg
15 MG00061 screw-RS M3*10
16 ND00234 dustproof cloth 0.35t*294*80mm
17 TG00204 transformer-RS 230V/50Hz-AC18V/1500mA-EI57
18 NI00378 plastic washer 9*13 used to PU socket
19 NI00218 cable tie ALT-102SB
20 NI02714 knob φ10*13.5mm
21 NI02377 knob-RS φ5.5*7.5(3.3*3.3mm)_V1.2
22 NI02633 knob φ10.5*18
23 NI02386 konb φ14*13mm
24 NI01863 key-RS φ5.5*W10*7.5
25 NI01862 key 5.5*5.5*14.5_V1.1
26 NI02817 knob φ10.5*18mm
27 NI02309 knob 24*11.5*11_V1.1
28 NI02352 knob 24*11.5*11
29 NI02353 knob 24*11.5*11
30 NI02081 knob φ10.5*18mm
31 NI02083 knob φ10.5*18mm
32 NI02082 knob φ10.5*18mm
33 NI01945 handle AMX-180;180FX_V1.0
34 NI02878 handle 330*33*26mm AMX-180 black
35 NF00061 assurance card ALTO
36 NE05004 label ALTO
37 NH00334 cone paper 0.040*1m
38 NB03165 cushion AMX-180 right_V1.0
39 NB03166 cushion AMX-180 left_V1.0
40 NF02622 user manual-RS AMX-180FX USB ALTO_V1.0
41 NE15393 lable AMX-180FX USB_V1.0
42 NI00014 membrane 0.035*1M
43 NH00012 bond paper 0.04*1M
44 NB03033 carton AMX-180 ALTO_V1.0
45 NA00279 clip-chain bag 0.04t*100*150mm_V1.0
46 NA00135 PE bag 0.05t*610*500mm
47 MJ00808 fixed clip WL3-32T
48 MG00041 screw M3*6
49 ME00015 color nut 3m/m
50 MG00326 screw 3*4
51 MF00061 MIC jack φ9.6*φ13*0.5t
52 ME00143 nut 5/6"x32w
53 ME00060 MIC jack JY-6351G-02-250
54 MG00243 copper pillar M3*5*0.5PH
55 HI00171 power switch-RS R612KKAT0F1
56 HJ00006 dessicant 30g
Page 30
No. Part No. Description Specification Remark
- 28 -
57 HI00026 power switch-RS RA12KKATOF 2P
58 HA01388 wire-RS 2P 100mm UL1007 24AWG
59 HA03524 wire-RS 2P 340mm UL1007 24AWG
60 HK06386 PC board P-AMX180FXMN1-USB-DIP
61 RC00284 slide potentiometer D10KΩ RF6011YP600F-10KD(SAS1) VR7,VR14,VR21,VR28,VR62,VR63
62 SA00054 L.E.D 3m/m round(yellow)long foot 26 LD2,LD5,LD8,LD11,LD14,LD17,LD20,LD23,LD27,LD31,LD43
LD29,LD32,LD33,LD34,LD35,LD36,LD37,LD38,LD39,LD40,L
63 SA00052 L.E.D φ3 round(green)long foot 26
D41,LD44,LD45,LD46,LD47,LD48,LD49,LD50,LD51,LD52,LD
53
64 SA00053 L.E.D φ3 round(red)long foot 26mm
LD1,LD3,LD4,LD6,LD7,LD9,LD10,LD12,LD13,LD15,LD16,LD
18,LD19,LD21,LD22,LD24,LD26,LD28,LD30,LD42,LD401
65 RC00285 slide potentiometer-dual unit D10KΩ RF60112P600G-10KD*2(SAS1) VR35,VR42,VR49,VR56,VR64
66 NI01782 LED spacer support LEDS-11 11mm
67 HI00161 relay RY-5W-K,5V RL1
68 HI00195 rotary switch SDB161PVB15.5F-1-4-16-16PC EN1,EN2
69 HI00238 push-button switch-RS 2 6P PS-92 26A(NON-LOCK) SW401
70 HI00236 push-button switch-RS 2 6P PS-92 26A(SELF-LOCK)
71 HI00237 push-button switch-RS 2 12P PS-13422 R(SELF-LOCK)
SW1,SW4,SW7,SW10,SW13,SW16,SW19,SW22,SW25,SW
27,SW28,SW29,SW30,SW31
SW2,SW3,SW5,SW6,SW8,SW9,SW11,SW12,SW14,SW15,S
W17,SW18,SW20,SW21,SW23,SW24,SW26
72 HC00473 connector-RS-ACT 2.45mm 180° 2*8P B25-2*8BG1(B)H=5mm CN11
73 HA03075 wire
74 HA03132 wire-RS
14P(male)-14P(female) 40mm UL1007 28AWG
5P(male)-5P(female) 350mm UL1007 28AWG
CN1
CN5
75 HA03173 wire-RS 16P-16P 300mm UL1007 28AWG CN3
76 HA03177 wire-RS 16P-14P/2P 40/50mm UL1007 28AWG CN2
77 HK06388 PC board P-AMX180FXMN1-USB-SMD
78 RD00541 SMD precise resistance 1/10W 0Ω±1% 0603 R366,R367,R464,R393,R394
79 RD00224 SMD precise resistor 1/10W 100KΩ ±1% 0603 R356,R357,R395,R396
80 CI00059 SMD ceramic capacitor 0603 100PF/50V NPO ±5% C251,C252
C41,C42,C43,C44,C45,C46,C47,C48,C49,C50,C51,C52,C53,C5
4,C55,C56,C57,C58,C59,C60,C61,C62,C63,C64,C217,C219,C22
81 CI00075 SMD ceramic capacitor 0603 0.1uF/50V Y5V +80,-20%
2,C223,C225,C226,C227,C228,C229,C230,C231,C232,C234,C2
35,C237,C238,C275,C296,C300,C301,C302,C303,C304,C305,C
306,C307,C308,C309,C310,C311,C318,C319
R81,R82,R83,R84,R89,R90,R91,R92,R93,R94,R95,R96,R10
82 RD00214 SMD precise resistor 1/10W 10.0KΩ ±1% 0603
7,R110,R113,R116,R251,R252,R255,R256,R273,R274,R287
,R288,R289,R290,R303,R304,R362,R363,R364,R365,R397,
R398,R465,R466,R467,R468
83 RD00069 SMD fixed resistor 1/10W 120Ω ±5% 0603 R391
84 RD00102 SMD fixed resistor 1/10W 12KΩ ±5% 0603 R407,R409
85 RD00218 SMD precise resistor 1/10W 15.0KΩ ±1% 0603 R221,R222,R223,R224,R360,R361
86 RD00293 SMD precise resistor 1/10W 17.4KΩ ±1% 0603 R85,R86,R87,R88,R426,R427
87 RD00447 SMD precise resistor 1/10W 19.6KΩ±1% 0603 R264,R265,R266,R263
88 RD00350 SMD fixed resistor 1/10W 1.1KΩ ±5% 0603 R1,R2,R3,R4,R5,R6,R7,R8,R9,R10,R11,R12
89 RD00351 SMD fixed resistor 1/10W 1.3KΩ ±5% 0603
R13,R14,R15,R16,R17,R18,R19,R20,R21,R22,R23,R24,R416
90 RD00085 SMD fixed resistor 1/10W 1.5KΩ ±5% 0603 R189,R190,R191,R192,R193,R194,R195,R196,R312,R314
91 RD00292 SMD precise resistor 1/10W 1.00MΩ ±1% 0603
92 RD00219 SMD precise resistor 1/10W 20.0KΩ ±1% 0603
R177,R178,R179,R180,R181,R182,R183,R184,R185,R186,R
187,R188
R276,R315,R316,R368,R369,R370,R371,R372,R374,R376,R
377,R406,R408,R373,R375
93 RD00119 SMD fixed resistor 1/10W 220KΩ ±5% 0603 R380
94 RD00542 SMD precise resistance 1/10W 220Ω±1% 0603 R352,R353
95 RD00105 SMD fixed resistor 1/10W 22KΩ ±5% 0603
R225,R226,R227,R228,R229,R230,R231,R232,R307,R308,R
309,R310
Page 31
No. Part No. Description Specification Remark
- 29 -
C137,C138,C139,C140,C141,C142,C143,C144,C145,C146,C147
,C148,C149,C150,C151,C152,C153,C154,C155,C156,C157,C15
96 CI00051 SMD ceramic capacitor 0603
22PF/50V C0G±5%(C1608C0G1H220JT)/TDK
8,C159,C160,C169,C170,C171,C172,C173,C174,C177,C178,C1
79,C180,C185,C186,C253,C254,C255,C256,C282,C283,C284,C
285,C286,C287,C288,C312,C313,C314,C315
97 RD00356 SMD precise resistor 1/10W 26.1KΩ ±1% 0603 R267,R268
98 RD00106 SMD fixed resistor 1/10W 27KΩ ±5% 0603
R233,R234,R235,R236,R237,R238,R239,R240,R241,R242,R
243,R244,R245,R253,R254,R246,R247,R248,R305,R306
99 RD00221 SMD precise resistor 1/10W 27.4KΩ ±1% 0603 R321,R322
100 RD00203 SMD precise resistor 1/10W 2.00KΩ ±1% 0603 R417,R422,R311,R313
101 RD00392 SMD precise resistor 1/10W 2.20KΩ ±1% 0603 R125,R126,R127,R128,R129,R130,R131,R132
102 RD00393 SMD precise resistor 1/10W 330Ω ±1% 0603 R404,R405
103 RD00108 SMD fixed resistor 1/10W 33KΩ ±5% 0603 R410,R411
104 RD00407 SMD precise resistor 1/10W 36.0KΩ ±1% 0603
105 SF00056 transistor MMBT3904(SOT23)/(PHI)
R269,R270,R271,R272,R317,R318,R319,R320,R399,R400,R
454,R455
TR1,TR2,TR3,TR4,TR5,TR6,TR7,TR8,TR9,TR10,TR11,TR12
,TR15,TR16,TR17,TR18,TR25,TR26
106 SF00053 transistor MMBT3906(SOT23)/(PHI) TR13,TR19,TR14,TR27
107 RD00406 SMD precise resistor 1/10W 3.60KΩ ±1% 0603 R458,R459
108 SG00558 integrated circuit-RS 4580M(SOP8)/(YW)
U1,U2,U3,U4,U5,U6,U7,U8,U9,U10,U11,U12,U13,U16,U17,U
18,U19,U20,U21,U22,U23,U24,U25,U26,U27,U28,U36
109 RD00078 SMD fixed resistor 1/10W 470Ω ±5% 0603 R281,R401,R402,R403
110 RD00339 SMD precise resistor 1/10W 47.0KΩ ±1% 0603
R117,R118,R119,R120,R121,R122,R123,R124,R275,R420,R421
111 RD00065 SMD fixed resistor 1/10W 47Ω ±5% 0603 R424,R425
R105,R106,R108,R109,R111,R112,R114,R115,R197,R198,R
112 RD00093 SMD fixed resistor 1/10W 4.7KΩ ±5% 0603
199,R200,R201,R202,R203,R204,R205,R206,R207,R208,R2
09,R210,R211,R212,R213,R214,R215,R216,R217,R218,R21
9,R220,R423
113 RD00347 SMD fixed resistor 1/10W 510Ω ±5% 0603 R249,R388,R389,R414
114 RD00346 SMD fixed resistor 1/10W 56Ω ±5% 0603 R390
R137,R138,R141,R142,R145,R146,R149,R150,R153,R154,R155
,R156,R157,R158,R159,R160,R161,R162,R163,R164,R165,R16
115 RD00094 SMD fixed resistor 1/10W 5.1KΩ ±5% 0603
6,R167,R168,R169,R170,R171,R172,R173,R174,R175,R176,R3
81,R382,R383,R384,R385,R386,R430,R431,R432,R433,R434,R
436,R437,R438,R439,R440,R441,R442,R444,
116 RD00095 SMD fixed resistor 1/10W 5.6KΩ ±5% 0603 R418
117 RD00348 SMD fixed resistor 1/10W 620Ω ±5% 0603 R415
118 RD00113 SMD fixed resistor 1/10W 62KΩ ±5% 0603 R412,R413,R378,R379
119 RD00080 SMD fixed resistor 1/10W 680Ω ±5% 0603 R133,R134,R135,R136,R259,R260
120 RE00011 SMD resistor networks 1/16W 680Ω*4 ±5% 8P 0603 AR1,AR2
121 RD00096 SMD fixed resistor 1/10W 6.2KΩ ±5% 0603 R277,R278
R49,R50,R51,R52,R53,R54,R55,R56,R57,R58,R59,R60,R61
122 RD00097 SMD fixed resistor 1/10W 6.8KΩ ±5% 0603
,R62,R63,R64,R65,R66,R67,R68,R69,R70,R71,R72,R73,R7
4,R75,R76,R77,R78,R79,R80,R139,R140,R143,R144,R147,
R148,R151,R152
123 RD00098 SMD fixed resistor 1/10W 7.5KΩ ±5% 0603 R97,R98,R99,R100,R101,R102,R103,R104
124 RD00468 SMD precise resistor 1/10W 7.68KΩ ±1% 0603 R428,R429,R435,R443
125 RD00099 SMD fixed resistor 1/10W 8.2KΩ ±5% 0603 R261,R262,R279,R280,R291,R294,R298,R300,R419
126 RD00349 SMD fixed resistor 1/10W 910Ω ±5% 0603
R25,R26,R27,R28,R29,R30,R31,R32,R33,R34,R35,R36,R37
,R38,R39,R40,R41,R42,R43,R44,R45,R46,R47,R48
127 SE00028 SMD rectifier diode-RS-ACT BAS316,115 D2,D3,D4,D5,D6,D7,D8,D9,D11,D12
128 SE00008 SMD rectifier diode DA204K/T-146 D1
129 SF00039 transistor MMBFJ112(SOT23)/(FAIRCHILD) TR22,TR23,TR24,TR20,TR21
130 SG00032 SMD integrated circuit LM339DR(SO14)/(TI/ST) U30,U31,U32,U33,U34,U35
131 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D13,D14,D16,D17,D20
132 AE00449 solder material without lead 9308/Sn Ag Cu
133 AC00179 tin without lead-RS M705E Sn 3Ag-0.5Cu
134 HK06387 PC board P-AMX180FXMN1-USB-AI
Page 32
No. Part No. Description Specification Remark
- 30 -
135 RA01260 fixed resistor 1/4W 120Ω R250,R387,R392
C113,C114,C115,C116,C117,C118,C119,C120,C121,C122,C
136 CF00137 metal-film capacitor MSC 0.033uF/63V 5% CASE01
123,C124,C125,C126,C127,C128,C129,C130,C131,C132,C1
33,C134,C135,C136
137 CF00136 metal-film capacitor MSC 0.018uF/63V 5% CASE01
C65,C66,C67,C68,C69,C70,C71,C72,C73,C74,C75,C76,C77
,C78,C79,C80,C81,C82,C83,C84,C85,C86,C87,C88
C89,C90,C91,C92,C93,C94,C95,C96,C97,C98,C99,C100,C1
138 CF00138 metal-film capacitor MSC 0.012uF/63V ±5% CASE01
01,C102,C103,C104,C105,C106,C107,C108,C109,C110,C11
1,C112
139 CB00190 electrolytic capacitor 4.7uF/25V φ4*7mm C261,C262,C263
C1,C2,C3,C4,C5,C6,C7,C8,C9,C10,C11,C12,C13,C14,C15,C16,
C17,C18,C19,C20,C21,C22,C23,C24,C25,C26,C27,C28,C29,C3
140 CB00194 electrolytic capacitor 47uF/25V φ5*11mm
0,C31,C32,C33,C34,C35,C36,C37,C38,C39,C40,C175,C176,C18
7,C188,C189,C190,C191,C195,C199,C200,C205,C206,C209,C2
10,C211,C212,C213,C214,C215,C216,C243
141 CB00248 electrolytic capacitor 2.2uF/50V ψ4*5mm C161,C162,C163,C164,C165,C166,C167,C168,C299
142 CB00268 electrolytic capacitor 330uF/16V φ8*11mm 5mm C181
143 HB01833 PCB-RS AMX180FXMN1-USB_VER060222
144 RD00112 SMD fixed resistor 1/10W 56KΩ ±5% 0603 R358,R359
145 HK06352 PC board P-DSP-PRE-DIP CN4
146 HC00697 connector 2.0 90° 16P(gold-pated)2.5/9.5mm 2mm CN1
147 HK06353 PC board P-DSP-PRE-SMD
148 HB01916 PCB-RS DSP-PRE_VER051020
149 CI00051 SMD ceramic capacitor 0603
150 CI00053 SMD ceramic capacitor 0603
22PF/50V C0G±5%(C1608C0G1H220JT)/TDK
33PF/50V C0G±5%(C1608C0G1H330JT)/TDK
C329,C330,C331,C332
C348,C349
151 CI00129 SMD ceramic capacitor 0603 0.0015uF/50V X7R ±10% C345,C346,C347
152 CI00075 SMD ceramic capacitor 0603 0.1uF/50V Y5V +80,-20% C333,C334,C336,C337,C338,C339,C340,C341
153 CL00002
154 CL00006
SMD tantalum capacitor-RS-ACT
SMD tantalum capacitor-RS-ACT
1.0uF/16V case A C352,C353
10uF/16V case B2 C350,C351
155 RD00068 SMD fixed resistor 1/10W 100Ω ±5% 0603 R420,R421
156 RD00073 SMD fixed resistor 1/10W 220Ω ±5% 0603 R426
157 RD00059 SMD fixed resistor 1/10W 0.0Ω ±5% 0603 R1
158 RD00083 SMD fixed resistor 1/10W 1.0KΩ ±5% 0603 R418
159 RD00088 SMD fixed resistor 1/10W 2.2KΩ ±5% 0603 R424
160 RD00091 SMD fixed resistor 1/10W 3.3KΩ ±5% 0603 R422,R423
161 RD00093 SMD fixed resistor 1/10W 4.7KΩ ±5% 0603 R416
162 RD00098 SMD fixed resistor 1/10W 7.5KΩ ±5% 0603 R419
163 RD00101 SMD fixed resistor 1/10W 10KΩ ±5% 0603
R397,R398,R399,R400,R401,R402,R403,R404,R405,R406,R
407,R408,R410,R411,R412,R413,R414
164 RD00111 SMD fixed resistor 1/10W 47KΩ ±5% 0603 R415
165 RD00124 SMD fixed resistor 1/10W 820KΩ ±5% 0603 R431
166 RD00125 SMD fixed resistor 1/10W 1.0MΩ ±5% 0603 R417
167 RD00126 SMD fixed resistor 1/10W 2.2MΩ ±5% 0603 R425
168 SG00122 SMD integrated circuit-RS-ACT NJM4580M-TE3(SOP8)/(JRC) U44,U45,U46
169 SG00306 SMD integrated circuit LM393DR(TI)/(MEXICO) U47
170 SG00068 SMD integrated circuit 74HC14DT(SO14)/(PHI) U49
171 SG00469 SMD integrated circuit-RS SN74HC109DR(SO16)/(TI) U48
172 SE00028 SMD rectifier diode-RS-ACT BAS316,115 D7,D15
173 SE00009 SMD rectifier diode DAN202K/T-146 D16
174 SE00007 SMD rectifier diode RB400D(D3A) D10
175 SF00056 transistor MMBT3904(SOT23)/(PHI) TR17
176 AE00449 solder material without lead 9308/Sn Ag Cu
177 SE00085 SMD zener diode-RS 1/2W 2.4V ZMM55-C2V4 ZD1,ZD2
178 SG00243 SMD integrated circuit NE555DR(SO8)/(TI) U43
179 AC00179 tin without lead-RS M705E Sn 3Ag-0.5Cu
180 AC00179 tin without lead-RS M705E Sn 3Ag-0.5Cu
Page 33
No. Part No. Description Specification Remark
- 31 -
181 RC00672 potentiometer-RS B50KΩ XV09213YNPV30F-1B50K C.C
182 RC00703 potentiometer-RS W50KΩ XV09213YNPV30F-4BP50K CC
183 RC00669 potentiometer-RS B50KΩ XV012313YGPV30F-3B50K C.C
VR1,VR2,VR3,VR8,VR9,VR10,VR15,VR16,VR17,VR22,VR2
3,VR24
VR4,VR5,VR11,VR12,VR18,VR19,VR25,VR26,VR32,VR33,V
R39,VR40,VR46,VR47,VR53,VR54,VR60,VR61
VR29,VR30,VR31,VR36,VR37,VR38,VR43,VR44,VR45,VR5
0,VR51,VR52
184 RC00670 potentiometer-RS W50KΩ XV012313YGPV30F-4B50K C.C VR57,VR58,VR59,VR65
185 RC00700 potentiometer-RS B5KΩ XV09213YNPV30F-1BP5K CC VR6,VR13,VR20,VR27,VR34,VR41,VR48,VR55
186 HK06383 PC board P-AMX-180FXPU1-USB-DIP
187 SD00074 integrated circuit L7805CV(TO220)/(ST) TR2
188 RC00356 potentiometer Z10KΩ RD09F1130042-10KZ(SAS1);30F VR5,VR6,VR7,VR8,VR9
189 SD00079 integrated circuit L7915CV(TO220)/(ST) TR3
190 SD00077 integrated circuit-RS L7815CV(TO220)/(ST/MOROCCO) TR1
191 SD00007 integrated circuit BA15218N(M5218L)(SIP8)/(ROHM) U9,U10
192 SB00043 transistor-RS-ACT TIP122(TO220)/(ST) TR4
193 NI02249 plastic washer TW-1(TO-220)
194 NC00005 mica SB-9500DSP 18*13*0.1t_V1.0
195 MG00041 screw M3*6
196 MF00037 washer φ3.2*φ5.5*1t
197 HI00236 push-button switch-RS 2 6P PS-92 26A(SELF-LOCK) SW1,SW2,SW3,SW4,SW5,SW6,SW7,SW8,SW14
198 HI00237 push-button switch-RS 2 12P PS-13422 R(SELF-LOCK) SW9
199 HC00754 USB socket CU02SAH0000 90° CN4
200 HI00125 slide switch SL20202-25Y-6mm SW12,SW13
201 HC00403 RCA jack SCP6873NS3232T2 4P X27
202 HC00392 balance MIC jack-RS JY-5030-030G 180° X37,X38
203 HC00076 connector(male) 2P 2.5mm 180° SW11
204 HC00126 balance MIC jack-RS JY-5042-030G female plug 180° X22,X23,X24,X25,X26
205 HC00125 MIC jack-RS JY-6351G-02-250
X1,X2,X3,X4,X5,X6,X7,X8,X9,X10,X11,X12,X13,X14,X15,X16,X1
7,X18,X19,X20,X21,X28,X29,X30,X31,X32,X33,X34,X35,X36
206 HC00505 connector(male) 16P 2.0mm 180° CN2,CN3
207 HC00256 connector(male) 5P 2.0mm 180° CN8
208 HC00321 connector(male) 14P 2.0mm 180° CN1
209 HC00065 connector(male) 2P 2.5mm 90° SW10
210 CB00082 electrolytic capacitor 2200uF/25V φ16*21mm C173,C174
211 CB00279 electrolytic capacitor 100uF/100V φ10*20mm C169,C170,C171,C175
212 HK06385 PC board P-AMX-180FXPU1-USB-SMD
213 RD00059 SMD fixed resistor 1/10W 0.0Ω ±5% 0603 R204,R205
214 RD00224 SMD precise resistor 1/10W 100KΩ ±1% 0603 R230
215 CI00059 SMD ceramic capacitor 0603 100PF/50V NPO ±5%
C121,C122,C123,C124,C125,C126,C127,C128,C129,C130,C
131,C132,C133,C134,C135,C136,C191,C192,C193,C194
C24,C25,C137,C138,C139,C140,C141,C142,C143,C144,C14
216 CI00075 SMD ceramic capacitor 0603 0.1uF/50V Y5V +80,-20%
5,C146,C147,C148,C149,C150,C151,C152,C153,C154,C155
,C156,C157,C158,C159,C160,C161,C162,C163,C166,C167,
C168,C184,C188,C189,C190,C205,C206,C207,C208
R76,R77,R78,R79,R80,R81,R84,R85,R86,R87,R88,R89,R90,R9
217 RD00214 SMD precise resistor 1/10W 10.0KΩ ±1% 0603
218 RD00334 SMD precise resistor 1/10W 11.0KΩ ±1% 0603
1,R92,R105,R106,R107,R108,R109,R116,R117,R118,R119,R12
2,R123,R126,R127,R210,R211,R82,R83,R147,R148,R237,R238,
R241,R242,R101,R103,R104,R212,R214,R215
R243,R244,R245,R246,R31,R32,R33,R36,R37,R38,R39,R40
R164,R165,R166,R167,R168,R169,R170,R171,R172,R173,R
219 RD00069 SMD fixed resistor 1/10W 120Ω ±5% 0603
174,R175,R180,R181,R182,R183,R184,R185,R186,R187,R1
88,R189,R190,R191,R192,R193,R194,R195,R196,R197,R19
8,R199
220 RD00218 SMD precise resistor 1/10W 15.0KΩ ±1% 0603 R252,R253
221 RD00473 SMD precise resistor 1/10W 18.0KΩ ±1% 0603 R247,R248,R249,R250,R251,R254
222 RD00282 SMD precise resistor 1/10W 1.00KΩ ±1% 0603 R176,R177
223 RD00351 SMD fixed resistor 1/10W 1.3KΩ ±5% 0603 R132,R133,R134,R135
Page 34
No. Part No. Description Specification Remark
- 32 -
224 RD00219 SMD precise resistor 1/10W 20.0KΩ ±1% 0603
R100,R140,R141,R142,R143,R144,R145,R152,R153,R239,R
240,R146,R149,R151,R154
225 RD00105 SMD fixed resistor 1/10W 22KΩ ±5% 0603 R259,R260,R261,R262
C7,C9,C46,C47,C48,C49,C50,C51,C52,C53,C54,C55,C56,C
226 CI00051 SMD ceramic capacitor 0603
22PF/50V C0G±5%(C1608C0G1H220JT)/TDK
57,C58,C59,C60,C61,C62,C63,C64,C65,C66,C67,C68,C69,
C70,C71,C72,C73,C74,C75,C76,C77,C78,C79,C80,C81,C10
1,C105,C119,C120,C164,C165
227 RD00265 SMD fixed resistor 1/10W 27Ω ±5% 0603 R51,R52,R53,R54,R55
R93,R94,R95,R96,R97,R98,R110,R111,R112,R113,R114,R115,
228 RD00392 SMD precise resistor 1/10W 2.20KΩ ±1% 0603
229 CI00053 SMD ceramic capacitor 0603
33PF/50V C0G±5%(C1608C0G1H330JT)/TDK
R120,R121,R124,R125,R271,R272,R273,R274,R275,R276,R277
,R278,R279,R280,R281,R282,R283,R284,R285,R286
C209,C210,C211,C212,C213,C214,C215,C216
230 SF00056 transistor MMBT3904(SOT23)/(PHI) TR5
231 RD00345 SMD fixed resistor 1/10W 390KΩ ±5% 0603 R207
232 RD00406 SMD precise resistor 1/10W 3.60KΩ ±1% 0603 R41,R42,R43,R44,R45,R46,R47,R48,R49,R50
233 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34)
234 SG00558 integrated circuit-RS 4580M(SOP8)/(YW)
235 CI00063 SMD ceramic capacitor 0603
470PF/50V NPO ±5
D7,D8,D9,D10,D11,D12,D13,D14,D15,D16,D17,D18,D19,D2
0,D21,D22,D23,D24,D25,D26,D5,D6
U1,U2,U3,U4,U5,U6,U7,U8,U11,U12,U13,U15,U16,U17,U18,
U20,U21,U23,U24
C1,C2,C3,C4,C5,C8,C11,C12,C13,C14,C17,C18,C19
236 RD00111 SMD fixed resistor 1/10W 47KΩ ±5% 0603 R208,R229
237 CI00055 SMD ceramic capacitor 0603
47PF/50V C0G±5%(C1608C0G1H470JT)/TDK
C6,C10,C15,C16,C20
238 RD00298 SMD precise resistor 1/10W 47.0Ω ±1% 0603 R11,R12,R13,R14,R15,R16,R17,R18,R19,R20
239 RD00347 SMD fixed resistor 1/10W 510Ω ±5% 0603 R263,R264,R265,R266,R267,R268,R269,R270
240 RD00354 SMD fixed resistor 1/10W 51KΩ ±5% 0603 R1,R2,R5,R6,R7,R8,R9,R10
241 SE00048 SMD Schottky barrier diode 1A/20V PRLL5817(SOD87)/(PHI) D27,D28
242 RD00094 SMD fixed resistor 1/10W 5.1KΩ ±5% 0603
243 RD00210 SMD precise resistor 1/10W 5.11KΩ ±1% 0603
R3,R4,R34,R35,R156,R157,R158,R159,R160,R161,R162,R1
63,R200,R201,R202,R203
R56,R57,R58,R59,R60,R61,R62,R63,R64,R65,R66,R67,R68
,R69,R70,R71,R72,R73,R74,R75
244 RD00113 SMD fixed resistor 1/10W 62KΩ ±5% 0603 R128,R129,R130,R131
245 RD00394 SMD precise resistor 1/10W 68.0Ω ±1% 0603 R255,R256,R257,R258
246 RD00097 SMD fixed resistor 1/10W 6.8KΩ ±5% 0603 R136,R137,R138,R139
247 AE00449 solder material without lead 9308/Sn Ag Cu
248 AC00179 tin without lead-RS M705E Sn 3Ag-0.5Cu
249 HK06384 PC board P-AMX-180FXPU1-USB-AI
250 RA01262 precise resistor 1/4W 6.81KΩ R21,R22,R23,R24,R25,R26,R27,R28,R29,R30
251 RA01325 fixed resistor 1/8W 4.7Ω R206
252 RA01115 fixed resistor 1/4W 20KΩ R209
253 SA00094 rectifier diode 1N4002/100V D1,D2,D3,D4
254 SA00127 zener diode 1/2W 47V 1N5261 ZD1
C94,C95,C96,C97,C98,C99,C100,C103,C106,C107,C108,C1
255 CB00194 electrolytic capacitor 47uF/25V φ5*11mm
09,C110,C111,C112,C113,C114,C115,C116,C179,C180,C18
3,C185,C186,C187,C203,C204,C217,C218,C219,C220,C197
,C199
256 CB00251 electrolytic capacitor 220UF/25V φ8*11mm C176,C177
257 CB00255 electrolytic capacitor 1000uF/10V φ8*11mm 5mm C41,C42,C43,C44,C45
258 CB00238 electrolytic capacitor 0.22uF/50V φ5*11mm C82,C83,C84,C85,C86,C87,C88,C89,C90,C91,C92,C93
259 CB00254 electrolytic capacitor 47uF/100V φ10*12mm 5mm C172
260 CB00334 electrolytic capacitor-RS 47uF/50V φ6.3*11mm C31,C32,C33,C34,C35,C36,C37,C38,C39,C40
261 CB00253 electrolytic capacitor 1000uF/16V φ10*16mm 5mm C178
262 CB00242 electrolytic capacitor 22uF/35V φ5*11mm C21,C22,C23,C26,C27,C28,C29,C30
263 HB01834 PCB-RS AMX180FXPU1-USB_VER060915
264 CI00219 SMD ceramic capacitor 0603
150PF/50V C0G ±5%(C1608C0G1H151JT)/TDK
C117,C118
265 RD00112 SMD fixed resistor 1/10W 56KΩ ±5% 0603 R221,R222
266 RD00289 SMD precise resistor 1/10W 8.06KΩ ±1% 0603 R227,R228
267 RD00129 SMD fixed resistor 1/4W 0.0Ω ±5% 1206 R99
Page 35
No. Part No. Description Specification Remark
- 33 -
268 HC00920 DC jack-RS SCD554CCS103BB4G
269 AC00179 tin without lead-RS M705E Sn 3Ag-0.5Cu
270 MI03095 heat-sink AMX180FX.USB 1t*125*160_V1.2
271 MJ00999 AL plate-RS 1*2000*1000 5.44kg
272 ME00041 iron pillar hexagon6.35*M3*6
273 ME00166 iron pillar M3*3_V1.0
274 MG00024 screw M3*7 0.5PH
275 HA00392 wire-RS 260mm black L5R5
276 HA00384 wire 180mm black L5R5
277 HK08142 PC board P-AMX-USB-DIP(AMX-180FX USB) CN6
278 SC00003 crystal oscillator 12.000MHZ HC-49/US ±20PPM X1
279 HC00555 connector 2.54 90° 12P 6/14 CN1
280 HK06382 PC board P-AMX-USB-SMD
281 RD00309 SMD fixed resistor 1/10W 10MΩ ±5% 0603 R6
282 RD00063 SMD fixed resistor 1/10W 22Ω ±5% 0603 R3,R4
283 RD00059 SMD fixed resistor 1/10W 0.0Ω ±5% 0603 R2
284 RD00085 SMD fixed resistor 1/10W 1.5KΩ ±5% 0603 R5
285 RD00272 SMD precise resistor 1/10W 10.0Ω ±1% 0603 R9
286 RD00492 SMD precise resistor 1/10W 1.82KΩ ±1% 0603 R1
287 RD00363 SMD precise resistor 1/10W 3.16KΩ ±1% 0603 R26
288 SG00412 SMD integrated circuit-RS AZ1117H-ADJ(SOT223)/(BCD) TR1
289 SG00489 SMD integrated circuit-RS PCM2900E(SSOP28)/(TI) U1
290 CJ00005 SMD AL electrolytic capacitor 10uF/16V CASE4φ C1,C2,C3,C4,C5,C6,C20,C21,C22,C23
291 CI00051 SMD ceramic capacitor 0603
292 CI00030 SMD ceramic capacitor 0805 1uF/16V Y5V-0805(2012) C10,C11,C12,C13
293 HB01832 PCB-RS AMX-USB _VER061128
294 CJ00012 SMD AL electrolytic capacitor- 100uF/16V CASE6.3φ C7
295 AE00449 solder material without lead 9308/Sn Ag Cu
296 CI00075 SMD ceramic capacitor 0603 0.1uF/50V Y5V +80,-20% C34,C30,C31,C32,C33,C35
297 RD00068 SMD fixed resistor 1/10W 100Ω ±5% 0603 R18,R19,R20,R21
298 RD00106 SMD fixed resistor 1/10W 27KΩ ±5% 0603 R22,R23
299 RD00104 SMD fixed resistor 1/10W 18KΩ ±5% 0603 R24,R25
300 RD00102 SMD fixed resistor 1/10W 12KΩ ±5% 0603 R12,R13
301 RD00093 SMD fixed resistor 1/10W 4.7KΩ ±5% 0603 R10,R11
302 RD00092 SMD fixed resistor 1/10W 3.9KΩ ±5% 0603 R14,R15,R16,R17
303 CO00006 SMD chip inductance-RS-ACT BLM21A102SPT/(MURATA) L1
304 SG00558 integrated circuit-RS 4580M(SOP8)/(YW) U2,U3
305 CI00090 SMD ceramic capacitor 0603 0.0047uF/50V X7R ±10% C24,C25
306 CI00066 SMD ceramic capacitor 0603 0.0018uF/50V X7R ±10% C15,C18
307 CI00065 SMD ceramic capacitor 0603 0.001uF/50V X7R ±10% C26,C27
308 CI00062 SMD ceramic capacitor 0603
309 CI00061 SMD ceramic capacitor 0603 220PF/50V NPO ±5% C28,C29
310 AC00179 tin without lead-RS M705E Sn 3Ag-0.5Cu
311 HK06603 PC board P-313123_2-V2-DIP
312 SC00004 crystal oscillator 16.00MHZ XT1
313 HC00484 connector 2.54 180° 2*8P(gold-plated) 13.5/19mm CN2
314 SG00193 SMD integrated circuit AT27LV010A-90JC/L-8 IC4
315 SG00168 SMD integrated circuit-RS HT27LC010-90J(PLCC32)/(HOLTEK)
316 NE11475 label L-8
317 NH00221 paper 0.055*1M
318 NI00016 membrane 0.05*1M
319 AC00179 tin without lead-RS M705E Sn 3Ag-0.5Cu
320 HK06604 PC board P-313123_2-V2-SMD
321 HB01963 PCB-RS 313123_2-V2
322 CI00049 SMD ceramic capacitor 0603
323 CI00075 SMD ceramic capacitor 0603 0.1uF/50V Y5V +80,-20% C17,C15,C18,C6,C10,C22,C20,C13,C14,C1,C3,C4,C11
22PF/50V C0G±5%(C1608C0G1H220JT)/TDK
330PF/50V NPO ±5
15PF/50V C0G±5%(C1608C0G1H150JT)/TDK
C8,C9
C14,C16,C17,C19
C8,C9
Page 36
No. Part No. Description Specification Remark
- 34 -
324 RD00059 SMD fixed resistor 1/10W 0.0Ω ±5% 0603 R35,R36
325 RD00061 SMD fixed resistor 1/10W 10Ω ±5% 0603 R22
326 RD00068 SMD fixed resistor 1/10W 100Ω ±5% 0603 R12,R14,R7,R8,R34,R17,R13,R33
327 RD00073 SMD fixed resistor 1/10W 220Ω ±5% 0603 R3
328 RD00085 SMD fixed resistor 1/10W 1.5KΩ ±5% 0603 R16,R15,R21,R20,R4,R19,R10,R18,R9,R5
329 RD00088 SMD fixed resistor 1/10W 2.2KΩ ±5% 0603 R28,R27,R23,R24,R29,R30,R25,R26
330 RD00101 SMD fixed resistor 1/10W 10KΩ ±5% 0603 R32,R31,R1
331 RD00125 SMD fixed resistor 1/10W 1.0MΩ ±5% 0603 R2
332 CJ00013 SMD AL electrolytic capacitor- 100uF/6.3V CASE5φ C19,C12,C5,C2,C24,C16,C21,C25,C26,C28,C7
333 RE00006 SMD resistor networks 1/16W 100Ω*4 ±5% 8P 0603 AR1,AR2
334 SE00011 SMD rectifier diode RLS4148 0.5A (LL-34) D1
335 SG00068 SMD integrated circuit 74HC14DT(SO14)/(PHI) IC1
336 SG00410 SMD integrated circuit IC41LV16256-35KG(SOJ40)/(ICSI) IC6
337 SG00166 SMD integrated circuit TY-2 ALTO(GMCODE:105022) IC3
338 SG00147 SMD integrated circuit CHEF DSP(GMCODE:105022)
339 SG00037 SMD integrated circuit LD1117DT33C(TO252)/(ST) IC2
340 HC00611 IC socket (SMD) PLCC32 (AMP S/N:822516-7) IC4
341 SG00016 SMD integrated circuit UDA1345TS(SSOP28)/(PHI) IC5
342 AE00449 solder material without lead 9308/Sn Ag Cu
343 NC00037 cushion-RS-ACT 1t*φ8*φ12.5mm XM1602_V1.1
344 NC01665 black foil white board-RS-CT 1.0t*65mm(+0.1)*60M 5.4kg
345 NC00080 washer φ3.17*φ8.2*1
346 NC01112 black foil white board 1.0t*65mm(+0.1)*60M
347 MB04414 rear board-RS AMX-180FX.USB_V1.0
348 AE00177 paint-RS 4866
349 MB04413 rear board-RS AMX-180FX.USB 0.8t*43*330*385_V1.1
350 MJ00067 single light board 0.8t*2135*1220mm 18.69kg
351 MG00036 screw M3*4
352 MF00093 washer φ8.10*φ10.10*0.3t
353 HA01835 wire-RS 70mm brown L5R5
354 NB03036 inner case-RS AMX-180/180FX/180FX USB ALTO_V1.1
355 MG00304 copper pillar M3*14*0.5PH
356 MI02093 fixed bracket AMX-180 left_V1.0
357 MI02092 fixed bracket AMX-180 1.0t*25*76.5*410_V1.1
358 MJ00058 single light board 1*2135*1220 20.45kg
359 MI02095 fixed bracket AMX-180 right_V1.0
360 MI02094 fixed bracket AMX-180 1.0t*25*76.5*410_V1.1
361 MJ00058 single light board 1*2135*1220 20.45kg
Loading...