ALTO 2500, 4000 Service Manual

Service

MODEL: MISTRAL2500/4000

www.altoproaudio.com
Version 2.0

CONTENTS

1. Introduction..………………………………………………………….………………..2

2. Specification.…………………………………………………………….……….…….3

3. Schematic Diagram…………….…………………….……….….…………………....4

4. Wiring Diagram..……………….…………….………...…….………………….…….11

5. PCB Layout……..……………….…………….………...…….………………….…....13

6. Test Procedure…………..……………………….………………………….…….......18

7. Exploded Views &Mechanical Parts List…………………………….…………....19

8. BOM.…………………………………………………………………….……………….24

1

1. Introduction

ALTO MISTRAL amplifiers are series of innovative design power amplifiers. This series work under high
stability with great power supply in just 2-rack spaces. Airflow is from back to front panel to keep in a nice air
circulation inside the Rack. The automatic fan, which affects the temperature of machine includes various
kinds of speed, therefore, this low-noise fan makes a good result in cooling the heat from machines. MISTRAL
amplifiers include 2 independent channels with separate protection system and power supply. The
independent protection system avoids opening circuit, short, and wrong loading or over-heating. The special­designed protective system applies automatically restarting functions upon the default status and then goes
back to normal. All electronic inputs equip standard power connectors. And all inputs are electronic balanced,
with hi-quality transformer, MISTRAL amplifiers provide an outstanding performance in any conditions.

. Innovative design and high stability power amplifiers.
. Fan-cooled AB class high power amplifier in 19”rack, 2Usize
. Rugged amplifiers in a strong, compact chassis.
. 2 independent channels with separate protection system and power supply
. Smart-designed protection system for auto re-operation after fault.
. Auto-adjusting speed fan.
. 4LEDs for operation/protection, limit, power on and clip
. High-current toroidal transformer designed for high power at 2Ohms with low noise.
. Independent DC and thermal overload protection on each channel.
. IEC standard power connectors.
. Binding post and NEUTRIK® SPEAKON outputs power connectors.
. Balanced XLR inputs/ parallel outputs.

2

2. Specification

MISTRAL2500 MISTRAL4000

Output Power

20Hz~20KHz @0.1% THD, SCD MODE

8 ohms per channel (EIAJ) 450W 625W

4 ohms per channel (EIAJ) 700W 1000W

BRIDGE MONO MODE

8 ohms , 1KHz, 0.1%THD 140W 2000W

Distortion (SMPTE-IM)

Frequency Response 20Hz-20kHz +/- 0.1dB, -3 dB points: 10Hz-60kHz

Damping Factor, 1 kHz and below >300 at 8 ohms

Signal to Noise, 20 Hz-20 kHz 102 dB

VOLTAGE GAIN 40x (32dB)

Input Sensitivity @ 4 ohms 1Vrms

Input Clipping 10 Vrms (+22 dB)

Input Impedance 10 k ohms unbalanced, 20 k ohms balanced 56(36dB)

Controls

Indicators (1 per channel)

Connectors, each channel

<0.05%

FRONT: AC SWITCH, CH1 & CH2 GAIN KNOBS
REAR: LIMITER, BRIDGE SELECTOR.

Power-On: Blue LED
Operation/Protection : Dual Color (Green/Red LED)
Limit : Red LED
Clip : Red LED

Input: Active balanced XLR
Parallel Output : XLR
Output: NEUTRIK Speakon and Binding posts

Cooling Continuously variable-speed fan, rear-to-front air flow

Load Protection On/off muting, DC-fault load grounding relay. Internal fault fuses.

Power Requirements 200-240(100-120)Vac, 50-60Hz

Dimensions

15.9" (40 cm) deep (rack mounting to rear support ears)
19" (48.3 cm) rack mounting, 3.5" (8.9 cm) tall (2 rack spaces)

3

7654321

3. Schematic Diagram

4

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R1_58
68K 1/2W

CH1 BILED2

CH1 CLI P-

+15V

D1_1

ZD15V1.3W

GND1

7

C1_12

N/C

GND1

D1_4

-15V

R1_11

15K SPEAKERS BUS

C1_9
0R

3
2
1

C1_8

220uF/25V

C1_11

560pF/50 cer

R1_17

NTC 50R

C1_45

220uF/25V

R1_64

15K

1

4

3

R1_15
3K3 10W

R1_14
820R

D1_7

ZD5V6 1/2W

D1_5

1N4936

D1_6

1N4936

R1_16

TRIMMER 100R

R1_18
820R

D1_8

ZD5V6 1/2W

R1_19
3K3 10W

V1+

84

V1-

VAC FAN1-CH1

D1_27

(1.5A 200V)

W2 -0 4

2

-V_FAN_CH1

VAC FAN2-CH1

D1_9

1N4148

MJE15032

D1_11
0R

R1_21

TRIMMER 1K

R1_20

TRIMMER 1K

D1_12
0R

Q1_2

MJE15033

D1_10
1N4148

U1_1C

NJM4580L

C1_42

470uF/35V

Q1_1

R1_62

5R6 1W

R1_22

5R6 1W

R1_1

1K8

V1+

84

V1-

R1_25
22R 1W

TP1_3

TP1_6

R1_32
22R 1W

U1_2C

NJM4580L

U1_4

LM317T

12

R1_28

0.22 5W

Q1_5 Q1_6

4x2SA1943

12x1000uF/100V

C1_15

C1_17

D1_13

C1_13

3.3nF/50 cer

GND1

C1_14

3.3nF/50 cer

1000uF/100V

C1_16

1N4148

C1_40

22nF/100V poly

D1_14

1N4148

C1_18

4x2SC5200

Q1_9 Q1_10 Q1_11 Q1_12

R1_33

R1_34

0.22 5W

C1_44

100nF/50 cer

R1_35

0.22 5W

C1_43

10uF/63

0.22 5W

R1_3

NTC 100R

R1_2
150R

R1_29

0.22 5W

C1_19

C1_20

R1_36

0.22 5W

D1_28
1N4004

R1_30

0.22 5W

Q1_7 Q1_8

C1_21

C1_23

R1_23

1K 5W

R1_24

1K 5W

C1_22

C1_24

FAN OUT CH1

+12V

JP1_14

2P2.5

2
1

FAN

C1_25

C1_26

GND1

D1_15
1N5402

GND1

D1_16
1N5402

R1_31

0.22 5W

OUTPUT STAGE_A

+83V_A

1 2

1 2

-83V_A

GND1

K1_1

R1_39
5R6 2W

L1_1

2uH 10A

R1_40
12R 5W

GND1

5mm RED LED

Q1_15

MPSA92

D1_19
W2 -0 4

(1.5A 200V)

R1_44
6K8 1W

R1_41
12R 5W

C1_31
68nF/250V poly

CH1 BILED1

D1_17

R1_42

330K

Q1_16

MPSA92

R1_43

100K

RELAY VBS SERI ES

D1_23
1N4004

ON/PROTECTION

R1_46

100K

R1_47 47K

D1_20

1N4004

R1_48

330K

C1_32
10uF/63

R1_45
1K5

RELAY POWER1

CH1 OUTPU T

GND1

D1_18

ZD7V5 1/2W

CH1 BILED2

C1_33
47uF/63V

C1_ 34

220uF/16V NP

D1_22

1N4004

GND1

R1_63

1K 3W

CN-P CB6. 3

CH1 OUTPUT

SPEAKON PCB

JP1_2

CN-P CB6. 3

+83V_A

R1_49
10K 5W

R1_50
PTC 65R

100R/10K

Q1_17

MPSA42

TURN ON DELAY

D1_21

ZD36V 1W

JP1_1

MISTRAL2500 Schematic Diagram 1 of 2

CH2 AMPLIFIER
MIS25-CH2.S CH

Titel

ALTO MISTRAL2500-CH1 DRIVE

PCB# MIS4000.PCB

Size

Date:
File:

A2

MISTRAL2500

29-Apr-2004
MIS25-CH1.Sch

Sheet
Drawn By:

1
2

TO

1
2

RevisionModel No:

KEVIN LIN.

D

1+

1-

C

B

A

VER031212

21 of

CH1 INPUT

J1_1

J1_2

R1_53

8K2

(CH1 LIMITER MODE)

1
3
2

2
3
1

GND1

V1+

C1_35

56pF/50 cer

2

3

GND1

NJM4560L

(1.5A 200V)

S1_1A

3

1

GND1

2 1

SW 2C_2P

CH1 I N-

CH1 I N+

FCT TAUD6 00

(OPTION)

D1_25

1N4004

2

5

4

T1_1

GND1 GND1

CH1 INSERT CONNECTOR

R1_54

10K

1

U1_2A

D1_24

W2 -0 4

2

J1_4
3P2.5

GND1

1

3

J1_5
3P2.5

1 2
3 4
5 6
7 8
9 10

JP1_3

HEADER 5X2

-V_FAN_CH1

VAC FAN1-CH1

6

5

GND1

U1_2B

NJM4560L

R1_52

47R

C1_37

220uF/16V

CH1 CLI P+

R1_9
100R

GND1

CH1 CLI P-

C1_1

RB1_1A

6
9
7

8

22uF/50V

22uF/50V

4x10K

RB1_1C

4x10K

C1_2

C1_4

100pF/50 cer

CH1 INSERT IN

CH1 I NSE RT OUT

D1_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND1 GND1

HEADER 5X2

7

R1_55

330R

(FTR VT90N1 VACTEC+)

CH1 PHOTO COUPLER

D1_2

W2 -0 4

(1.5A 200V)

2

3

RB1_1D
4x10K

GND1

GND1

47uF/35V

V1-

S1_1B

SWITCH 2C_2P

5

1 2
3 4
5 6
7 8
9 10

JP1_15

-83V_A

+83V_A

CH1 BILED1

CH1 CLI P+

R1_57

100R

U1_5

VTL5C2

41

2 3

GND1

C1_3

100pF/50 cer

RB1_1B

4x10K

1

U1_1A
NJM4560L

C1_6

3
2
1

R1_5

3P-2.5

CH1 GAIN

CH1 BR IDGE S WITCH

FAN OUT CH1

VAC FAN2-CH1

56pF/50 cer

C1_5

47uF/35V

C1_36

GND1

GND1

R1_7 4K7

R1_6
4K7

R1_56

82K 1/2W

R1_51

100K

GND1

R1_8

10K

1 2
3 4
5 6
7 8
9 10

JP1_16

HEADER 5X2

CH1 P ILOTLIM

56pF/50 cer

6

5

U1_1B

NJM4560L

R1_10

V1+

C1_7

R1_13
68R

C1_38

1.5nF/250 cer

ZD15V1.3W

V1-

C1_10

27pF/50 cer

330R

GND1

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP1_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1+

JP1_6
CN-P CB6. 3

2
1

COM1

JP1_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1-

JP1_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE_A

RELAY POWER1

JP1_9
JEF-505

1
2

JP1_11
JEF-505

1
2

FUSE1-1

FUSE1-2

6.3x32 FUSE HOLDER

16AT

16AT

JP1_10
JEF-505

1
2

JP1_12
JEF-505

1
2

+83V_A

-83V_A

JP1_13

HEADER 3

7654321

5

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R2_58
68K 1/2W

CH2 BILED2

CH2 CLI P-

+15V

D2_1

ZD15V1.3W

GND2

7

C2_12

N/C

GND2

D2_4

-15V

R2_11

15K SPEAKERS BUS

C2_9

0R

3
2
1

C2_8

220uF/25V

C2_11

560pF/50 cer

R2_17

NTC 50R

C2_45

220uF/25V

1

4

3

R2_15
3K3 10W

R2_14
820R

D2_7

ZD5V6 1/2W

D2_5

1N4936

D2_6

1N4936

R2_16

TRIMMER 100R

R2_18
820R

D2_8

ZD5V6 1/2W

R2_19
3K3 10W

V2+

84

V2-

VAC FAN1

D2_27

W2 -0 4

(1.5A 200V)

2

-V_FAN_CH2

VAC FAN2

D2_9

1N4148

MJE15032

D2_11

0R

R2_21

TRIMMER 1K

R2_20

TRIMMER 1K

D2_12

0R

Q2_2

MJE15033

D2_10
1N4148

U2_1C

NJM4580L

C2_42

470uF/35V

Q2_1

R2_62

5R6 1W

R2_22

5R6 1W

R2_1

1K8

V2+

84

V2-

R2_25
22R 1W

TP2_3

TP2_6

R2_32
22R 1W

U2_2C

NJM4580L

U2_4

LM317T

12

R2_28

0.22 5W

Q2_5

4x2SA1943

12x1000uF/100V

C2_15

C2_17

D2_13

C2_13

3.3nF/50 cer

GND2

C2_14

3.3nF/50 cer

1000uF/100V

C2_16

1N4148

C2_40

22nF/100V poly

D2_14

1N4148

C2_18

4x2SC5200

Q2_9 Q2_10 Q2_11 Q2_12

R2_33

R2_34

0.22 5W

C2_44

100nF/50 cer

R2_35

0.22 5W

C2_43

10uF/63

0.22 5W

R2_3

NTC 100R

R2_2
150R

R2_29

0.22 5W

Q2_6

C2_19

C2_20

R2_36

0.22 5W

D2_28
1N4004

R2_30

0.22 5W

Q2_7

C2_21

C2_23

R2_23

1K 5W

R2_24

1K 5W

C2_22

C2_24

FAN OUT CH2

+12V

JP2_14

2P2.5

2
1

FAN

R2_31

0.22 5W

Q2_8

GND2

C2_25

OUTPUT STAGE_B

C2_26

D2_15
1N5402

GND2

D2_16
1N5402

+83V_B

K2_1

RELAY VBS SERI ES

CH2 OUTPU T

R2_39
5R6 2W

1 2

L2_1

1 2

-83V_B

2uH 10A

MPSA92

D2_19
W2 -0 4

(1.5A 200V)

GND2

R2_40
12R 5W

C2_31
68nF/250V poly

GND2

CH2 BILED1

D2_17

5mm RED LED

Q2_15

MPSA92

R2_44
6K8 1W

R2_41
12R 5W

R2_42

330K

Q2_16

R2_43

100K

D2_23
1N4004

ON/PROTECTION

R2_46

100K

D2_20

1N4004

C2_32
10uF/63

R2_45
1K5

RELAY POWER2

R2_47 47K

R2_48

330K

GND2

D2_18

ZD7V5 1/2W

CH2 BILED2

C2_33
47uF/63V

C2_ 34

220uF/16V NP

D2_22

1N4004

GND2

+83V_B

Q2_17

MPSA42

TURN ON DELAY

D2_21

ZD36V 1W

R2_63

1K 3W

MISTRAL2500 Schematic Diagram 2 of 2

Titel

ALTO MISTRAL2500-CH2 DRIVE

PCB# MIS4000.PCB

Size

Date:
File:

A2

MISTRAL2500

29-Apr-2004
MIS25-CH2.Sch

Sheet
Drawn By:

JP2_1

CN-P CB6. 3

1

2+

2

CH2 OUTPUT

TO

SPEAKON PCB

1

2-

2

JP2_2

CN-P CB6. 3

R2_49
10K 5W

R2_50
PTC 65R

100R/10K

RevisionModel No:

VER031212

21 of

KEVIN LIN.

D

C

B

A

CH2 LIMITER MODE

CH2 INPUT

1
3
2

J2_1

2
3
1

J2_2

V2+

R2_53

8K2

GND2

(CH1 LIMITER MODE)

CH2 I N-

CH2 I N+

FCT TAUD6 00

(OPTION)

GND2

2 1

D2_25

1N4004

GND2

R2_54

10K

R2_52

47R

1

2

GND2

1

6
9
7

8

3

1 2
3 4
5 6
7 8
9 10

JP2_3

HEADER 5X2

CH2 BR IDGE

-V_FAN_CH2

VAC FAN1

6

5

22uF/50V

22uF/50V

C2_35

56pF/50 cer

2

3

U2_2A

NJM4560L

D2_24
W2 -0 4

(1.5A 200V)

S2_1A

3

1

SW 2C_2P

J2_4
3P2.5

GND2

2

5

4

T2_1

J2_5
3P2.5

GND2 GND2

CH2 INSERT CONNECTOR

7

U2_2B

NJM4560L

R2_55

330R

C2_37

220uF/16V

(FTR VT90N1 VACTEC+)

CH2 PHOTO COUPLER

CH2 CLI P+

R2_9
100R

GND2

1 2
3 4
5 6
7 8
9 10

JP2_15

W2 -0 4

(1.5A 200V)

2

3

RB2_1D
4x10K

GND2

V2-

S2_1B

SWITCH 2C_2P

5

CH2 CLI P-

C2_1

RB2_1A

4x10K

RB2_1C

4x10K

C2_2

C2_4

100pF/50 cer

CH2 INSERT IN

CH2 I NSE RT OUT

D2_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND2 GND2

HEADER 5X2

-83V_B

+83V_B

R2_57

100R

U2_5

VTL5C2

41

D2_2

C2_3

100pF/50 cer

RB2_1B

4x10K

C2_6

47uF/35V

CH2 GAIN

CH2 BILED1

CH2 CLI P+

56pF/50 cer

2 3

GND2

C2_5

47uF/35V

1

U2_1A
NJM4560L

3
2
1

R2_5

3P-2.5

CH2 LIMITER MODE

FAN OUT CH2

VAC FAN2

C2_36

GND2

GND2

R2_7 4K7

R2_6
4K7

R2_56

82K 1/2W

R2_51

100K

GND2

R2_8

10K

1 2
3 4
5 6
7 8
9 10

JP2_16

HEADER 5X2

CH2 P ILOTLIM

56pF/50 cer

6

5

U2_1B

NJM4560L

R2_10

V2+

C2_7

R2_13
68R

C2_38

1.5nF/250 cer

ZD15V1.3W

V2-

C2_10

27pF/50 cer

330R

GND2

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP2_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2+

JP2_6
CN-P CB6. 3

2
1

COM2

JP2_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2-

JP2_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE_B

RELAY POWER2

JP2_9
JEF-505

1
2

JP2_11
JEF-505

1
2

FUSE2-1

16AT

FUSE2-2

6.3x32 FUSE HOLDER

16AT

JP2_10
JEF-505

1
2

JP2_12
JEF-505

1
2

+83V_B

-83V_B

JP2_13

HEADER 3

7654321

6

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R1_58
68K 1/2W

CH1 BILED2

CH1 CLI P-

+15V

D1_1

ZD15V1.3W

GND1

7

C1_12

N/C

GND1

D1_4

-15V

C1_10

27pF/50 cer

R1_11

15K SPEAKERS BUS

C1_9
0R

3
2
1

C1_8

220uF/25V

C1_11

560pF/50 cer

R1_17

NTC 50R

C1_45

220uF/25V

R1_64

15K

1

4

3

R1_15
4K8 10W

R1_14
820R

D1_7

ZD5V6 1/2W

D1_5

1N4936

D1_6

1N4936

R1_16

TRIMMER 100R

R1_18
820R

D1_8

ZD5V6 1/2W

R1_19
4K8 10W

V1+

84

V1-

VAC FAN1-CH1

D1_27

(1.5A 200V)

W2 -0 4

2

-V_FAN_CH1

VAC FAN2-CH1

D1_9

1N4148

MJE15032

D1_11

0R

5R6 1W

R1_21

TRIMMER 2K2

5R6 1W

R1_20

TRIMMER 2K2

D1_12

0R

Q1_2

MJE15033

D1_10
1N4148

U1_1C

NJM4580L

C1_42

470uF/35V

Q1_1

R1_62

R1_22

R1_1

1K8

V1+

84

V1-

R1_25
22R 1W

TP1_3

TP1_6

R1_32
22R 1W

U1_2C

NJM4580L

U1_4

LM317T

12

R1_26

0.22 5W

Q2_3

Q2_4

0.22 5W

0.22 5W

Q1_5 Q1_6 Q1_7 Q1_8

R1_28

R1_27

6x2SA1943

16x470uF/160V

C1_15

C1_17

D1_13

C1_13

3.3nF/50 cer

GND1

C1_14

3.3nF/50 cer

470uF/160V

C1_16

1N4148

C1_40

22nF/100V poly

D1_14

1N4148

C1_18

6x2SC5200

Q1_9 Q1_10 Q1_11 Q1_12

R1_33

R1_34

0.22 5W

C1_44

100nF/50 cer

R1_35

0.22 5W

C1_43

10uF/63

0.22 5W

R1_3

NTC 100R

R1_2
150R

R1_29

0.22 5W

C1_19

C1_20

R1_36

0.22 5W

D1_28
1N4004

R1_30

0.22 5W

C1_21

C1_23

R1_23

1K5 5W

R1_24

1K5 5W

C1_22

C1_24

Q1_13

R2_37

0.22 5W

FAN OUT CH1

+12V

JP1_14

2P2.5

2
1

FAN

R1_31

0.22 5W

GND1

C1_25

OUTPUT STAGE_A

C1_26

Q1_14

R2_38

0.22 5W

D1_15
1N5402

C1_27 C1_29

C1_28 C1_30

GND1

D1_16
1N5402

+83V_A

1 2

1 2

-83V_A

GND1

K1_1

R1_39
5R6 2W

L1_1

2uH 10A

R1_40
12R 5W

GND1

5mm RED LED

Q1_15

MPSA92

D1_19
W2 -0 4

(1.5A 200V)

R1_44
6K8 1W

R1_41
12R 5W

C1_31
68nF/250V poly

CH1 BILED1

D1_17

R1_42

330K

Q1_16

MPSA92

R1_43

100K

RELAY VBS SERI ES

D1_23
1N4004

ON/PROTECTION

R1_46

100K

R1_47 47K

D1_20

1N4004

R1_48

330K

C1_32
10uF/63

R1_45
1K5

RELAY POWER1

CH1 OUTPU T

GND1

D1_18

ZD7V5 1/2W

CH1 BILED2

C1_33
47uF/63V

C1_ 34

220uF/16V NP

D1_22

1N4004

GND1

R1_63

1K 3W

CN-P CB6. 3

CH1 OUTPUT

SPEAKON PCB

JP1_2

CN-P CB6. 3

+83V_A

R1_49
10K 5W

R1_50
PTC 65R

100R/10K

Q1_17

MPSA42

TURN ON DELAY

D1_21

ZD36V 1W

JP1_1

MISTRAL4000 Schematic Diagram 1 of 2

CH2 AMPLIFIER
MIS40-CH2.S CH

Titel

ALTO MISTRAL4000-CH1 DRIVE

PCB# MIS4000.PCB

Size

A2

MISTRAL4000

29-Apr-2004

Date:
File:

MIS40-CH1.Sch

Sheet
Drawn By:

1
2

TO

1
2

RevisionModel No:

KEVIN LIN.

D

1+

1-

C

B

A

VER031212

21 of

CH1 INPUT

J1_1

J1_2

R1_53

8K2

(CH1 LIMITER MODE)

1
3
2

2
3
1

GND1

V1+

C1_35

56pF/50 cer

2

3

GND1

NJM4560L

(1.5A 200V)

S1_1A

3

1

GND1

2 1

SW 2C_2P

CH1 I N-

CH1 I N+

FCT TAUD6 00

(OPTION)

D1_25

1N4004

2

5

4

T1_1

GND1 GND1

CH1 INSERT CONNECTOR

R1_54

10K

1

U1_2A

D1_24

W2 -0 4

2

J1_4
3P2.5

GND1

1

3

J1_5
3P2.5

1 2
3 4
5 6
7 8
9 10

JP1_3

HEADER 5X2

-V_FAN_CH1

VAC FAN1-CH1

6

5

GND1

U1_2B

NJM4560L

R1_52

47R

C1_37

220uF/16V

CH1 CLI P+

R1_9
100R

GND1

CH1 CLI P-

C1_1

RB1_1A

6
9
7

8

22uF/50V

22uF/50V

4x10K

RB1_1C

4x10K

C1_2

C1_4

100pF/50 cer

CH1 INSERT IN

CH1 I NSE RT OUT

D1_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND1 GND1

HEADER 5X2

7

R1_55

330R

(FTR VT90N1 VACTEC+)

CH1 PHOTO COUPLER

D1_2

W2 -0 4

(1.5A 200V)

2

3

RB1_1D
4x10K

GND1

GND1

47uF/35V

V1-

S1_1B

SWITCH 2C_2P

5

1 2
3 4
5 6
7 8
9 10

JP1_15

-83V_A

+83V_A

CH1 BILED1

CH1 CLI P+

R1_57

100R

U1_5

VTL5C2

41

2 3

GND1

C1_3

100pF/50 cer

RB1_1B

4x10K

1

U1_1A
NJM4560L

C1_6

3
2
1

R1_5

3P-2.5

CH1 GAIN

CH1 BR IDGE S WITCH

FAN OUT CH1

VAC FAN2-CH1

56pF/50 cer

C1_5

47uF/35V

C1_36

GND1

GND1

R1_7 4K7

R1_6
4K7

R1_56

82K 1/2W

R1_51

100K

GND1

R1_8

10K

1 2
3 4
5 6
7 8
9 10

JP1_16

HEADER 5X2

CH1 P ILOTLIM

56pF/50 cer

6

5

U1_1B

NJM4560L

R1_10

V1+

C1_7

R1_13
68R

C1_38

1.5nF/250 cer

ZD15V1.3W

V1-

330R

GND1

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP1_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1+

JP1_6
CN-P CB6. 3

2
1

COM1

JP1_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE1-

JP1_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE_A

RELAY POWER1

JP1_9
JEF-505

1
2

JP1_11
JEF-505

1
2

FUSE1-1

FUSE1-2

6.3x32 FUSE HOLDER

10AT

10AT

JP1_10
JEF-505

1
2

JP1_12
JEF-505

1
2

+83V_A

-83V_A

JP1_13

HEADER 3

7654321

7

8

D

C

XLR FEMALE90

XLR MALE90

(PARALLEL OUTPUT)

B

A

R2_58
68K 1/2W

CH2 BILED2

CH2 CLI P-

+15V

D2_1

ZD15V1.3W

GND2

7

C2_12

N/C

GND2

D2_4

-15V

C2_10

27pF/50 cer

R2_11

15K SPEAKERS BUS

C2_9
0R

3
2
1

C2_8

220uF/25V

C2_11

560pF/50 cer

R2_17

NTC 50R

C2_45

220uF/25V

1

4

3

R2_15
4K8 10W

R2_14
820R

D2_7

ZD5V6 1/2W

D2_5

1N4936

D2_6

1N4936

R2_16

TRIMMER 100R

R2_18
820R

D2_8

ZD5V6 1/2W

R2_19
4K8 10W

V2+

84

V2-

VAC FAN1

D2_27

W2 -0 4

(1.5A 200V)

2

-V_FAN_CH2

VAC FAN2

D2_9

1N4148

MJE15032

D2_11

0R

5R6 1W

R2_21

TRIMMER 2K2

5R6 1W

R2_20

TRIMMER 2K2

D2_12

0R

Q2_2

MJE15033

D2_10
1N4148

U2_1C

NJM4580L

C2_42

470uF/35V

Q2_1

R2_62

R2_22

R2_1

1K8

V2+

84

V2-

R2_25
22R 1W

TP2_3

TP2_6

R2_32
22R 1W

U2_2C

NJM4580L

U2_4

LM317T

12

R2_26

0.22 5W

Q2_3

Q2_4

0.22 5W

0.22 5W

Q2_5 Q2_6 Q2_7 Q2_8

R2_28

R2_27

6x2SA1943

12x470uF/160V

C2_15

C2_17

D2_13

C2_13

3.3nF/50 cer

GND2

C2_14

3.3nF/50 cer

470uF/160V

C2_16

1N4148

C2_40

22nF/100V poly

D2_14

1N4148

C2_18

6x2SC5200

Q2_9 Q2_10 Q2_11 Q2_12

R2_33

R2_34

0.22 5W

C2_44

100nF/50 cer

R2_35

0.22 5W

C2_43

10uF/63

0.22 5W

R2_3

NTC 100R

R2_2
150R

R2_29

0.22 5W

C2_19

C2_20

R2_36

0.22 5W

D2_28
1N4004

R2_30

0.22 5W

C2_21

C2_23

R2_23

1K5 5W

R2_24

1K5 5W

C2_22

C2_24

Q2_13

R2_37

0.22 5W

FAN OUT CH2

+12V

JP2_14

2P2.5

2
1

FAN

R2_31

0.22 5W

GND2

C2_25

OUTPUT STAGE_B

C2_26

Q2_14

R2_38

0.22 5W

D2_15
1N5402

C2_27 C2_29

C2_28 C2_30

GND2

D2_16
1N5402

+83V_B

K2_1

RELAY VBS SERI ES

CH2 OUTPU T

R2_39
5R6 2W

1 2

L2_1

1 2

-83V_B

2uH 10A

MPSA92

D2_19
W2 -0 4

(1.5A 200V)

GND2

R2_40
12R 5W

C2_31
68nF/250V poly

GND2

CH2 BILED1

D2_17

5mm RED LED

Q2_15

MPSA92

R2_44
6K8 1W

R2_41
12R 5W

R2_42

330K

Q2_16

R2_43

100K

D2_23
1N4004

ON/PROTECTION

R2_46

100K

D2_20

1N4004

C2_32
10uF/63

R2_45
1K5

RELAY POWER2

R2_47 47K

R2_48

330K

GND2

D2_18

ZD7V5 1/2W

CH2 BILED2

C2_33
47uF/63V

C2_ 34

220uF/16V NP

D2_22

1N4004

GND2

+83V_B

Q2_17

MPSA42

TURN ON DELAY

D2_21

ZD36V 1W

R2_63

1K 3W

MISTRAL4000 Schematic Diagram 2 of 2

Titel

ALTO MISTRAL4000-CH2 DRIVE

PCB# MIS4000.PCB

Size

Date:
File:

A2

MISTRAL4000

29-Apr-2004
MIS40-CH2.Sch

Sheet
Drawn By:

JP2_1

CN-P CB6. 3

1

2+

2

CH2 OUTPUT

TO

SPEAKON PCB

1

2-

2

JP2_2

CN-P CB6. 3

R2_49
10K 5W

R2_50
PTC 65R

100R/10K

RevisionModel No:

VER031212

21 of

KEVIN LIN.

D

C

B

A

CH2 LIMITER MODE

CH2 INPUT

1
3
2

J2_1

2
3
1

J2_2

V2+

R2_53

8K2

GND2

(CH1 LIMITER MODE)

CH2 I N-

CH2 I N+

FCT TAUD6 00

(OPTION)

GND2

2 1

D2_25

1N4004

GND2

R2_54

10K

R2_52

47R

1

2

GND2

1

6
9
7

8

3

1 2
3 4
5 6
7 8
9 10

JP2_3

HEADER 5X2

CH2 BR IDGE

-V_FAN_CH2

VAC FAN1

6

5

22uF/50V

22uF/50V

C2_35

56pF/50 cer

2

3

U2_2A

NJM4560L

D2_24
W2 -0 4

(1.5A 200V)

S2_1A

3

1

SW 2C_2P

J2_4
3P2.5

GND2

2

5

4

T2_1

J2_5
3P2.5

GND2 GND2

CH2 INSERT CONNECTOR

7

U2_2B

NJM4560L

R2_55

330R

C2_37

220uF/16V

(FTR VT90N1 VACTEC+)

CH2 PHOTO COUPLER

CH2 CLI P+

R2_9
100R

GND2

1 2
3 4
5 6
7 8
9 10

JP2_15

W2 -0 4

(1.5A 200V)

2

3

RB2_1D
4x10K

GND2

V2-

S2_1B

SWITCH 2C_2P

5

CH2 CLI P-

C2_1

RB2_1A

4x10K

RB2_1C

4x10K

C2_2

C2_4

100pF/50 cer

CH2 INSERT IN

CH2 I NSE RT OUT

D2_26

2 1

1N4004

BRIDGED

6

4

NORMAL

GND2 GND2

HEADER 5X2

-83V_B

+83V_B

R2_57

100R

U2_5

VTL5C2

41

D2_2

C2_3

100pF/50 cer

RB2_1B

4x10K

C2_6

47uF/35V

CH2 GAIN

CH2 BILED1

CH2 CLI P+

56pF/50 cer

2 3

GND2

C2_5

47uF/35V

1

U2_1A
NJM4560L

3
2
1

R2_5

3P-2.5

CH2 LIMITER MODE

FAN OUT CH2

VAC FAN2

C2_36

GND2

GND2

R2_7 4K7

R2_6
4K7

R2_56

82K 1/2W

R2_51

100K

GND2

R2_8

10K

1 2
3 4
5 6
7 8
9 10

JP2_16

HEADER 5X2

CH2 P ILOTLIM

56pF/50 cer

6

5

U2_1B

NJM4560L

R2_10

V2+

C2_7

R2_13
68R

C2_38

1.5nF/250 cer

ZD15V1.3W

V2-

330R

GND2

TO USE ONLY CH2 PUT JUMPER ON PIN 6&8

JP2_5

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2+

JP2_6
CN-P CB6. 3

2
1

COM2

JP2_7

CN-P CB6. 3

2
1

RECTIFIER BRIDGE2-

JP2_8

CN-P CB6. 3

2
1

AC INPUT

1 2 3 4 5 6 78

OUTPUT STAGE_B

RELAY POWER2

JP2_9
JEF-505

1
2

JP2_11
JEF-505

1
2

FUSE2-1

10AT

FUSE2-2

6.3x32 FUSE HOLDER

10AT

JP2_10
JEF-505

1
2

JP2_12
JEF-505

1
2

+83V_B

-83V_B

JP2_13

HEADER 3

D

8

C

B

A

VER030504

11of

KEVIN LIN

RevisionModel No:

4

Drawn By:

Sheet

K2_2

3 4

5 6

7 8

RELAY-2-24

1 2

C2_46

470uF/35V

12

MISTRAL4000

R2_67

R2_69

12R 5W

12R 5W

R2_68

R2_70

12R 5W

12R 5W

(AC_2)

COM1

BRIDGE1+

321

BD1

35A/200V

BRIDGE1-

BD2

BRIDGE2+

35A/200V

COM2

COM

AC_1

BRIDGE2-

R2_72

12R 5W

R2_71

12R 5W

TRANS-IN

D2_31

1N4004

R2_74

2K7 5W

R2_73

2K7 5W

SWITCH

1

2

P7

CN-PCB6.3

NEUTRAL

2

P8

ALTO MISTRAL4000 POWER BOARD

PCB# MIS40PWR.PCB

9-Apr -2004

MIS40PWR.Sch

A4

Titel

Size

File:

Date:

1

CN-PCB6.3

63V

P1

115V or 120V

1

2

P2

CN-PCB6.3

63V0V63V

1

2

CN-PCB6.3

TRANS-IN

0V

0V

63V

13.5V

0V

1. COMPONENTS WITH ARE SAFETY CRITICAL PARTS.

PT-MIS4000-E

T130℃

115V or 120V

1

2

1

P3

2

P4

CN-PCB6.3

P5

CN-PCB6.3

T130℃

0V

1

2

1

2

P6

CN-PCB6.3

CN-PCB6.3

CIRCUIT BRE AKER

USA:15A-125V

NEUTRAL

EUROPE:8A-230V

POWER SWITCH

1 2 3 4

LINE

GND

NEUT

IEC AC INLET

D

C

B

A

D

9

C

B

A

VER030710

11of

C.C.LIN

RevisionModel No:

4

Drawn By:

Sheet

2

MISTRAL4000

2

D1_30

1 2

321

D2_30

1 2

3mm YELLOW LED

3mm YELLOW LED

D1_3

LIMITER

LIMITER

1 2

D2_3

1 2

D1_29

CLIP

3mm RE D LED

D2_29

CLIP

3mm RE D LED

POWER ON

3mm BL UE LE D

1 2

POWER ON

3mm BL UE LE D

1 2

RED

D1_1

RED

D2_1

GREEN

1

1

2

2

GREEN

1

1

JP1_22

1 2

3 4

5 6

7 8

9 10

3mm R/G BLCOL LED

ON/PROTECTION

JP2_22

1 2

3mm R/G BLCOL LED

ON/PROTECTION

3 4

HEADER 5X2

5 6

7 8

9 10

HEADER 5X2

ALTO : MIST RAL4000 FP

9-Apr -2004

MIS40FP.Sch

A4

Titel

Size

File:

Date:

VR1_1

B50K

123

CN1_1

D

3P2.5

CN2_1

C

VR2_1

B50K

123

3P2.5

B

A

1 2 34

D

10

C

B

A

VER031206

11of

C.C.LIN

RevisionModel No:

4

Drawn By:

Sheet

MISTRAL4000

ALTO : MIST RAL4000 INPUT

9-Apr -2004

MIS40IN.Sch

A4

Titel

Size

File:

Date:

321

CN4

123

CN2

CON3

CN3

12345

CON5

123

CON3

123

CN1

CON3

PJ1

PHONEJACK2

1 2 34

D

C

B

A

MISTRAL4000 Chassis Wiring Drawing (100V-130V)

4. Wiring Diagram

11

7654321

8

D

D

OUT1GND1OUT2GND2

GRAY

HA01258

HA02471

RED

PURPLE

BLACK

HA02449

WHITE

WHITE

GRAY

BLUE

BLACK

HA01198

HA01244

HA01239

HA01237

JP1_1

(CH1_OUT)

JP1_2

(GND1)

JP1_13

JP1_14

JP1_7

R1_5

R2_5

JP2_1

(CH2_OUT)

JP2_2

(GND2)

JP2_13

JP2_14

JP2_7

C

HA01333

P8

P6

AC

AC

P5

P4

C

P3

AC

P1

P2

P7

AC

RED

GREEN

WHITE

HA02488

HA01321

HA01243

YELLOW

PURPLE

B

JP1_5

PT-MIS4000-E

HA02469

HA02470

HA02451

HA02450

A

CN1_1 CN2_1

JP1_22 JP2_22

(BRIDGE+)

JP1_6

(COM1)

JP1_8

(AC_1)

JP1_16 JP2_16

JP2_5

(BRIDGE+)

JP2_6

(COM2)

JP2_8

(AC_2)

B

A

VER030613
DRAWING BY KEVIN LIN.

1 2 3 4 5 6 78

MISTRAL4000 Chassis Wiring Drawing (220V-240V)

12

7654321

8

D

D

OUT1GND1OUT2GND2

GRAY

HA01258

HA02471

RED

PURPLE

BLACK

HA02449

WHITE

WHITE

GRAY

BLUE

BLACK

HA01198

HA01244

HA01239

HA01237

JP1_1

(CH1_OUT)

JP1_2

(GND1)

JP1_13

JP1_14

JP1_7

R1_5

R2_5

JP2_1

(CH2_OUT)

JP2_2

(GND2)

JP2_13

JP2_14

JP2_7

C

HA01333

P8

P6

AC

AC

P5

P4

C

P3

AC

P1

P2

P7

AC

RED

GREEN

WHITE

HA02488

HA01321

HA01243

YELLOW

PURPLE

B

JP1_5

PT-MIS4000-E

HA02469

HA02470

HA02451

HA02450

A

CN1_1 CN2_1

JP1_22 JP2_22

(BRIDGE+)

JP1_6

(COM1)

JP1_8

(AC_1)

JP1_16 JP2_16

JP2_5

(BRIDGE+)

JP2_6

(COM2)

JP2_8

(AC_2)

B

A

VER030613
DRAWING BY KEVIN LIN.

1 2 3 4 5 6 78

5. PCB Layout

MIS40FP2

Bottom layer

Top overlay

MIS40PWR

Bottom layer

Top overlay

13

Top overlay

MIS40SP

Top layer

Bottom layer

14

MIS40MN-CH1

Top overlay

Top layer

15

Bottom layer

MIS40MN-CH2

Top overlay

16

Top layer

Bottom layer

17

6. Test Procedure

18

1) Test Equipment:

1.Frequency transformer 2.Digital voltage meter 3.AP ( Audio precision ) 4.Oscilloscope

5.Two 8Ω(400W) load

2) Test procedures and specification

1.Set LIMITER and BRIDGE switches at OFF, turn VR of CH1 and CH2 to maximum, then turn on the power switch and the

blue power LED lights up, and OPERATING/PROTECTION LED shows red then become green after 2-5 seconds or so.

2. Applied no signal, adjust R1-16(CH1) and R2-16(CH2) so that the voltage of R1-17/2-17 is 138±2mV. Connect a 4Ω load

at output, input a 5KHz signal into CH1 or CH2, adjust the signal so that the output is 5VP-P (about 2VRMS), verify the curve

on oscilloscope and there shall be no crossover distortion. Adjust the output signal level so that the distortion on oscilloscope

is about 1.5-2%, adjust R1-20, R1-21(CH1) and R2-20, R2-21(CH2) so that the crossover distortion reaches its peak (note:

the power supply shall be remained in 230V).

3. Input a 1KHz,－4dB signal, the output shall be 48V+/-0.5V and the distortion shall be less than 1%. Using the

multifunctional meter to measure two pins of JP1_14(JP2_14), the voltage shall be increasing up (about 10V at first). Using a

tweezers to short D1_18 (2_18), the overheat protection will start (no signal output).

4.To short the output terminal, the LIMITER on front panel is lit, the power consumption is less than 485W while in short

protection.

5.S/N: larger than 90dB(A weighted is more than 102dB)

6. Compressor function test: LIMITER switch is set at ON, input a 1KHz / +12dB signal, the LIMITER LED is lit in yellow and

there is no clipped signal.

7.Adjust the VR on front panel so that the output is 2V(4Ω). The measured frequency response is more than 30Hz to 20

kHz+/-1dB (CH1/CH2).

8.Press the BRIDGE switch down, input a 1KHz signal into CH1(the level control of CH2 is turn to minimum), connect a 8Ω

load to output terminal, measure the bridged output voltage is more than about 85V and the distortion is less than 1%. (This

measurement shall be done in a minute).

9.Turn off the input signal, the power consumption shall be less than 85W.

10. Done

7. Exploded Views & Mechanical Parts List

19

Mechanical Parts List (For MISTRAL2500)

20

No. Item Number Description Specification Quantify

MA04096 ZC-panel 3.1*88.8*25.5*483 1

1

MA04164 ZC-panel 1.5*83.2*22.4*422 1

2

MB02820 ZC-rear chassis 1.5t*85.5*370*430 1

3

MC00517 ZC-cover 1.5t*360*433.4 1

4

MI01744 ZB-handle 20*25.5*80 2

5

NI02650 Plastical knob

6

NI02651 Knob fixing tube

7

HI00031 Power supply SW R415KKETOF 1

8

MI01746 ZD-front panel 14*81*89 1

9

MI01750 ZB-panel fixing bracket 26.5*88.8*400mm 1

10

MI01752 ZB-panel fixing bracket 26.5*88.8*400mm 1

11

MI01759 ZD-partition board (left) 0.8t*53.5*78 1

12

MI01756 ZD-partition board (right) 0.8t*53.5*78 1

13

MI01763 ZB-cushion slice 2.0t*80*80 1

14

HC00005 AC socket AC-008 1

15

MG00247 Copper post M3*10*0.5PH total 16 4

16

MG00061 Black plated screw M3*10 14

17

MG00295 Black plated screw M4*6 12

18

MG00025 Black plated screw M3*6 33

19

φ18*18mm
10*φ22.5 black A600.2

2
2

MG00042 Black plated screw M3*10 6

20

MF00037 Spring washer

21

ME00015 Color nut 3mm 6

22

MF00038 Spring washer

23

ME00016 Color nut 4mm 3

24

MF00048 Outer-tooth washer

25

MF00018 Color washer

26

MG00268 Nickel screw M5*12 4

27

MG00041 Black plated screw M3*6 16

28

MG00075 Black plated screw M4*16 4

29

NI00437 Rubber ring

30

φ3*φ5*1t

φ4*φ7*1t

φ4*φ8*0.5t

φ4*φ10*1t

φ20*φ120*2tB

22

7

1
2

1

31 MG00215 Zinc screw Outer hexagon M8*80 1

21

32 ME00026 Zinc nut M8 1
33 MF00026 Color washer
34 MF00041 Spring washer
35 TD00175 Loop transformer PT-MIS2500-E 1
36 HE00007 Fan -AD0812US-A70GL DC12V/0.3A 80*80*25mm 300mm 1
37 NI00312 Power switch Square 5*5*9 hole 2.8*2.8 black 2
38 HK03957 K-PCB P-MIS40MN(MISTRAL2500 1
39 HK03958 K-PCB P-MIS40PWR 1
40 HK03959 K-PCB P-MIS40FP2 1
41 HK04015 K-PCB P-MIS40SP 1
42 ME00006 Nut
43 MF00004 Color washer
44 MH00766 ZB-steel plate
45 NC00059 ZD-fixing board 1*46*46(Sax-2000) 1

φ8*φ18*1.5t
φ8*φ13.5*2t

φ9
φ9*φ14*0.5t
φ11*φ90*2

2
1

4
2
1

46 HK03959 K-PCB P-MIS40FP2 1
47 MF00030 Nickel washer
48 MF00037 Spring washer
49 MG00171 Nickel screw M3*14 10
50 MD00444 Fan grill 80*80mm(K-G08A05- 4HA) 1
51 MI01755 Heat sink 9*83*40*309 MISTRAL4000 2
52 MI01954 ZD-fixing bracket (right0 1.5t*136*16mm 4
53 HK00787 K-PCB P-MIS2500-INPUT(MIC socket) 2
54 HK00793 K-PCB P-MIS2500-INPUT(terminal stage) 2

φ3*φ8*0.8t
φ3*φ5*1t

10
10

Mechanical Parts List (For MISTRAL4000)

22

No. Item Number Description Specification Quantify

MA04096 ZC-panel 3.1*88.8*25.5*483 1

1

MA04111 ZC-panel 1.5*83.2*22.4*422 1

2

MB02820 ZC-rear chassis 1.5t*85.5*370*430 1

3

MC00517 ZC-cover 1.5t*360*433.4 1

4

MI01744 ZB-handle 20*25.5*80 2

5

NI02650 Plastical knob

6

NI02651 Knob fixing tube

7

HI00031 Power supply SW R415KKETOF 1

8

MI01746 ZD-front panel 14*81*89 1

9

MI01750 ZB-panel fixing bracket 26.5*88.8*400mm 1

10

MI01752 ZB-panel fixing bracket 26.5*88.8*400mm 1

11

MI01759 ZD-partition board (left) 0.8t*53.5*78 1

12

MI01756 ZD-partition board (right) 0.8t*53.5*78 1

13

MI01763 ZB-cushion slice 2.0t*80*80 1

14

HC00005 AC socket AC-008 1

15

MG00247 Copper post M3*10*0.5PH total 16 4

16

MG00061 Black plated screw M3*10 14

17

MG00295 Black plated screw M4*6 12

18

MG00025 Black plated screw M3*6 33

19

φ18*18mm
10*φ22.5 black A600.2

2
2

MG00042 Black plated screw M3*10 6

20

MF00037 Spring washer

21

ME00015 Color nut 3mm 6

22

MF00038 Spring washer

23

ME00016 Color nut 4mm 3

24

MF00048 Outer-tooth washer

25

MF00018 Color washer

26

MG00268 Nickel screw M5*12 4

27

MG00041 Black plated screw M3*6 16

28

MG00075 Black plated screw M4*16 4

29

NI00437 Rubber ring

30

φ3*φ5*1t

φ4*φ7*1t

φ4*φ8*0.5t

φ4*φ10*1t

φ20*φ120*2tB

22

7

1
2

1

31 MG00215 Zinc screw Outer hexagon M8*80 1

23

32 ME00026 Zinc nut M8 1
33 MF00026 Color washer
34 MF00041 Spring washer
35 TD00217 Loop transformer PT-MIS4000-E 1
36 HE00007 Fan -AD0812US-A70GL DC12V/0.3A 80*80*25mm 300mm 1
37 NI00312 Power switch Square 5*5*9 hole 2.8*2.8 black 2
38 HK00673 K-PCB P-MIS40MN(MISTRAL4000) 1
39 HK01708 K-PCB P-MIS40PWR(MISTRAL4000) 1
40 HK03958 K-PCB P-MIS40PWR 1
41 HK04015 K-PCB P-MIS40SP 1
42 ME00006 Nut
43 MF00004 Color washer
44 MH00766 ZB-steel plate
45 NC00059 ZD-fixing board 1*46*46(Sax-2000) 1

φ8*φ18*1.5t
φ8*φ13.5*2t

φ9
φ9*φ14*0.5t
φ11*φ90*2

2
1

4
2
1

46 NI02666 Fixing plate 26.5*7*3.5 1
47 MF00030 Nickel washer
48 MF00037 Spring washer
49 MG00171 Nickel screw M3*14 10
50 MD00444 Fan grill 80*80mm(K-G08A05- 4HA) 1
51 MI01755 Heat sink 9*83*40*309 MISTRAL4000 2
52 MI01958 K-PCB P-MIS40PWR 4
53 HK00787 K-PCB P-MIS2500-INPUT(MIC socket) 2
54 HK00793 K-PCB P-MIS2500-INPUT(terminal stage) 2

φ3*φ8*0.8t
φ3*φ5*1t

10
10

8. BOM

24

MISTRAL2500 Parts List

No. Part No. Description Specification Remark

1 MA04096 panel MISTRAL4000
2 MA04097 panel MISTRAL4000
3 MA04098 panel
4 MI01309 panel 3.1*88.8*25.5*483
5 MA00150 panel MISTRAL2500 ALT O new_V1.0
6 MA04436 panel CPA 1000
7 MA05424 panel MISTRAL1500_V1.0
8 MJ00088 iron board 1.5*2135*1220 30.67kg
9 MB02820 rear board MISTRAL4000
10 MB02821 rear board MISTRAL4000_V1.1
11 MB02822 rear board
12 MJ00088 iron board 1.5*2135*1220 30.67kg
13 ME00002 screw pillar M4*20*0.7PH
14 ME00051 iron pillar M3*12

MISTRAL4000 3.1*88.8*25.5*483

MISTRAL4000 430*400*85.5*2.0t_V1.1

15 ME00001 screw pillar M4*10*0.7PH
16 MI01516 partition MISTRAL4000 57*177*195
17 MJ00058 iron board 1*2135*1220 20.45kg
18 MC00517 top cover MISTRAL4000
19 MC00622 top cover MISTRAL2500_V1.0
20 MC00621 top cover MISTRAL2500_V1.0
21 MJ00088 iron board 1.5*2135*1220 30.67kg
22 MI01744 handle MISTRAL4000 20*25.5*80
23 MI01745 handle MISTRAL4000 20*25.5*80
24 MI01750 fixed bracket MISTRAL4000 left L type
25 MI01751 fixed bracket

MISTRAL4000 left L type 26.5*88.8*400mm

26 MJ01154 iron board 2.0t*1850*950mm 27.6kg
27 MI01752 fixed bracket MISTRAL4000 right L type
28 MI01753 fixed bracket 26.5*88.8*400mm
29 MJ01154 iron board 2.0t*1850*950mm 27.6kg
30 MI01746 front board MISTRAL4000 14*81*89
31 MJ00061 Zn-plated board 1*2135*1220 20.45kg
32 MI01759 partition

MISTRAL4000(LEFT) 0.8t*53.5*78_V1.1

33 MJ00067 iron board 0.8*2440*1220 18.69kg
34 MI01756 partition

MISTRAL4000(RIGHT) 0.8t*53.5*78_V1.1

35 MJ00067 iron board 0.8*2440*1220 18.69kg

MISTRAL2500 Parts List

25

No. Part No. Description Specification Remark

36 NI02650 knob
37 NI02651 knob fix sheath
38 HC00005 AC socket AC-008
39 HI00031 power switch R415KKETOF
40 SA00013 bridge rectifier 35A/200V
41 HA01243 wire 300mm UL1015 14AWG brown
42 HA01333
43 HA01247 wire 180mm UL1015 14AWG blue
44 HA02469 wire 3P-3P 480mm 28AWG blue
45 HA02470 wire 3P-3P 600mm 28AWG blue
46 HA02452 wire 10Pfema*3 415mm UL2651
47 HA02448 wire 530mm UL1015 14AWG red
48 HA02449 wire 700mm UL1015 14AWG black
49 HA01244 wire 380mm UL1015 14AWG red
50 HA01198 wire 180mm UL1015 14AWG black
51 MG00247 copper pillar M3*10*0.5PHsingle length16
52 MG00061 screw M3*10

single terminal wiring CF:W76

φ18*18mm
10*φ22.5

150mm UL1015 18AWG green/yellow

53 MG00295 screw M4*6
54 MG00025 screw M3*6
55 MG00042 screw M3*10
56 MF00037 washer
57 ME00015 nut 3m/m
58 MF00038 washer
59 ME00016 nut 4m/m
60 MF00048 washer
61 MF00018 washer
62 MG00268 screw M5*12
63 MG00041 screw M3*6
64 MG00075 screw M4*16
65 ME00006 nut R.S
66 MF00004 washer
67 NI00437 rubber coil
68 MG00556 screw M8*82.5*1.25PH_V1.0
69 ME00026 nut 8m/m

φ3*φ5*1t

φ4*φ7*1t

φ4*φ8*0.5t
φ4*φ10*1t

9φ
φ9*φ14*0.5t
φ20*φ120*2tB

70 MF00026 washer

φ8*φ18*1.5t

MISTRAL2500 Parts List

26

No. Part No. Description Specification Remark

71 MF00041 washer
72 MH00766 iron piece
73 MH00768 iron piece

φ8*φ13.5*2t
φ11*φ90*2_V1.1
φ11*φ90*2_V1.1

74 MJ01154 iron board 2.0t*1850*950mm 27.6kg
75 TD00175 loop transformer PT-MIS2500_115/230V
76 NI00252 sleeve
77 NI00248 sleeve
78 HE00050 fan

φ4*20mm
φ4*1000mm

DV12V/0.37A 80*80*25 360mm JST2P

79 NI00312 power switch button square 5*5*9 hole 2.8*2.8 black
80 HA00871 power cord(European 3P)

LT-322+1.5*3C(H05VV-F) 6FT+LT-501

81 NI00218 cable tie-black ALT-102SB
82 HJ00006 desiccant 30g
83 NA00135 PE bag 0.05t*610*500mm
84 NB02476 box MISTRAL2500 ALT O_V1.1
85 NB01944 barrier PSA-3000_V1.1
86 NB02086 box MACRO
87 NE02227 label PSA-31500 220-240V
88 NI00037 adhesive label 0.05*1M
89 NI00034 membrane 0.045*1M
90 NF00061 assurance card ALTO
91 NE11516 label MISTRAL2500
92 NH00012 bond paper 0.04*1M
93 NI00014 membrane 0.035*1M
94 NE11347 label ALT O PI
95 NH00334 cone paper 0.040*1m
96 NC00059 fixed board 1*46*46(Sax-2000)
97 NC00175 insulator 1.0t*51mm*100M
98 HK04155 PC board

P-MIS40MN CH2(MISTRAL2500)

99 HB01243 PCB MIS40MN-CH2_VER040326
100 RA00211 fixed resistor 1/4W
101 RA00239 fixed resistor 1/4W
102 RA00266 fixed resistor 1/4W
103 RA00174 fixed resistor 1/4W

820Ω M type

8.2KΩ M type
47KΩ M type
47Ω M type

R2_14,R2_18

R2_47

R2_52
104 RA00299 fixed resistor 1/4W
105 RA00200 fixed resistor 1/4W

330KΩ M type
330Ω M type

R2_42,R2_48

R2_10,R2_55

MISTRAL2500 Parts List

27

No. Part No. Description Specification Remark

106 RA00616 fixed resistor 1/4W
107 RA00217 fixed resistor 1/4W
108 RA00158 fixed resistor 1/4W
109 RA00246 fixed resistor 1/4W
110 RA00219 fixed resistor 1/4W
111 RA00282 fixed resistor 1/4W
112 RA00184 fixed resistor 1/4W
113 RA00242 fixed resistor 1/4W
114 RA00908 fixed resistor 1/2W
115 RA00909 fixed resistor 1/2W
116 RB00010 resistor
117 RA00027 metal-oxide-film resistor 1W
118 RA00007 metal-oxide-film resistor 1W
119 RA00020 metal-oxide-film resistor 1W
120 RA00051 metal-oxide-film resistor 2W
121 RA00953 metal-oxide-film resistor 5W
122 RA00062 metal-oxide-film resistor 3W
123 RA00880 cement resistor 5W
124 RA00870 cement resistor 5W

470Ω M type

1.5KΩ M type

0.0Ω M type
15KΩ M type

1.8KΩ M type
100KΩ M type
100Ω M type
10KΩ M type
68KΩ P type
82KΩ P type
10KΩ 8P C Type

5.6Ω P type
22Ω P type

6.8KΩ P type

5.6Ω P type
10KΩ P type

1.0KΩ RSS P type

0.22Ω SQM type
12Ω SQM type

R2_9

R2_45

R2_2

R2_11

R2_1

R2_43,R2_46,R2_51

R2_57

R2_54,R2_8

R2_58

R2_56

RB2_1

R2_22,R2_62

R2_25,R2_32

R2_44

R2_39

R2_49

R2_63

R2_28,R2_29,R2_30,R2_31,R2_33,R2_34,

R2_36,R2-35

R2_41,R2_40
125 RA00869 cement resistor 5W
126 RA00981 cement resistor 10W

1KΩ SQM type

3.3KΩ SQM type

R2_23,R2_24

R2_15,R2_19
127 CA00010 ceramic capacitor 27PF NPO C2_10
128 CA00018 ceramic capacitor 56PF NPO C2_35,C2_36,C2_7
129 CA00024 ceramic capacitor 100PF SL C2_3,C2_4
130 CA00043 ceramic capacitor 0.0033uF C2_13,C2_14
131 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C2_11
132 CA00047 ceramic capacitor 0.033uF C2_12
133 CA00053 ceramic capacitor 0.1uF SL C2_44
134 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C2_40
135 CF00013 metal-film capacitor MEF 0.068uF/250V C2_31
136 CB00143 electrolytic capacitor
137 CB00177 electrolytic capacitor
138 CB00169 electrolytic capacitor
139 CB00039 electrolytic capacitor
140 CB00149 electrolytic capacitor

10uF/63V φ5*11mm
22uF/50V φ5*11mm
47uF/16V NP φ6.3*1 1mm
47uF/25V φ5*11mm
47uF/63V φ6*11mm

C2_32,C2_43

C2_1,C2_2,R2-43

C2_9

C2_5,C2_6

C2_33

MISTRAL2500 Parts List

28

No. Part No. Description Specification Remark

141 CB00055 electrolytic capacitor
142 CB00171 electrolytic capacitor
143 CB00057 electrolytic capacitor
144 CB00067 electrolytic capacitor
145 CB00170 electrolytic capacitor

220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm
220uF/25V φ8*11mm
470uF/35V φ10*20mm
1000uF/100V φ18*35.5mm

C2_37

C2_34

C2_8,C2_45

C2_42

C2_15,C2_16,C2_17,C2_18,C2_19,C2_20,

C2_21,C2_22,C2_23,C2_24,C2_25,C2_26

146 SA00167 bridge rectifier 2A W2-04 D2_2,D2_19,D2_24,D2_27
147 SA00093 rectifier diode 1N4148 0.5A D2_11,D2_12
148 SA00098 rectifier diode 1A/400V IN4004

D2_10,D2_13,D2_14,D2_20,D2_22,D2_23,

D2_25,D2_26,D2_28,D2_9

149 SA00187 rectifier diode IN5404 D2_15,D2_16
150 SA00002 high speed diode 1A/600V 1N4937 D2_5,D2_6
151 SA00107 zener diode 1W 15V 1N4744 D2_1,D2_4
152 SA00197 L.E.D 1W 36V 1N4753 D2_21
153 SA00117 zener diode 1/2W 5.6V 6B1 D2_7,D2_8
154 SA00188 diode 1/2W 7.5V D2_18
155 SA00026 L.E.D 5m/m circle red B1115 D2_17
156 SB00042 transistor MJE15032 Q2_1
157 SB00044 transistor MJE15033 Q2_2
158 SB00130 transistor MPSA42/(PHILIPS) Q2_17
159 SB00129 transistor MPSA92(TO92)/(PHI) Q2_15,Q2_16
160 SB00023 power transistor 2SA1943-O Q2_5,Q2_6,Q2_7,Q2_8
161 SB00021 power transistor 2SC5200 Q2_9,Q2_10,Q2_11,Q2_12
162 SD00032 integrated circuit LM317T U2_4
163 SD00173 integrated circuit NJM4580L(JRC) U2_1,U2_2
164 CN00060 fixed inductance
165 RH00021 Thermal resistor
166 RH00017 Thermal resistor
167 RH00025 resistor
168 RC00319 resistor
169 RC00348 resistor

2uH 10A(CSAF-302824)(φ1.5mm*12 1/2T)

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)

B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

L2_1

R2_3

R2_17

R2_50

R2_16

R2_20,R2_21
170 HI00211 raley 8P 24VDC/16A 881H-1CC-C K2_1
171 HI00039 push-button switch SP70300-0202-11F1-N S2_1
172 HK02231 coupling

P-photosensitive resistanceφ5LLED

U2_5
173 RH00020 photosensitive resistance VT90N1
174 SA00201 L.E.D

φ5 red(LI3330/A)

175 NI02779 sleeve

φ9*30mm

MISTRAL2500 Parts List

29

No. Part No. Description Specification Remark

176 NI00274 sleeve
177 HC00324 terminal 6.5m/m (PC250)

φ9*1000mm

JP2_1,JP2_2,JP2_5,JP2_6,JP2_7,JP2_8

178 HC00056 FUSE holder 8*10.6*1.5 JEF-505 JP2_9,JP2_10,JP2_11,JP2_12
179 HC00112 XLR MIC jack 99M-107SP-1-2 90° PUSH J2_1
180 HC00111 XLR MIC jack 99M-108SP1 J2_2
181 HC00504 row-wire header(male) 10P 2.54mm 180° JP2_15,JP2_16,JP2_3
182 HC00172 row-wire header(male) 3P 3.96mm 180° JP2_13
183 HC00077 row-wire header(male) 3P 2.5mm 180° R2_5
184 HC00076 row-wire header(male) 2P 2.5mm 180° JP2_14
185 HA01933 jumper wire 2.5mm J2_4,J2_5
186 HC00034 connector NO.2700 2.54mm/6mm OPEN
187 HD00029 ceramic tube fuse

15A φ6*32mm UL
188 MJ01200 spacer MISTRAL4000 14.5*30.5*2t
189 MJ01201 spacer MISTRAL4000 14.5*30.5*2t
190 MJ01154 iron board 2.0t*1850*950mm 27.6kg
191 MF00030 washer
192 MF00037 washer

φ3*φ8*0.8t

φ3*φ5*1t

193 NC00005 silicone insulator TO-220 square type
194 MG00171 screw M3*14
195 ND00182 silicone sleeve
196 ND00171 silicone sleeve

φ1*30mm

φ1*1000mm

197 NC00181 insulator MISTRAL4000 1.6t*136*16mm
198 NC00041 red foil white board 1.6t*0.65M*70M
199 MI01954 fixed bracket

MISTRAL4000 1.5t*136*16mm right

200 MJ00069 iron board 1.5*2135*1220 30.67kg
201 HA02759 wire 5P-5P 120mm UL1007 24AWG
202 CA00088 ceramic capacitor 100PF/1000V Q2-1,Q2-2
203 MI02325 heat-sink 9*83*70*309 right_V1.0
204 MI02359 heat sink

9*83*70*4400 +5/-0 18.8320KG_V1.0

205 HK03958 PC board P-MIS40PWR
206 HB00946 PCB MIS40PWR_VER030710
207 HC00324 terminal 6.5m/m (PC250) P1,P2,P3,P4,P5,P6,P7,P8
208 CG00044 metal oxide varistor NP35L-Y2 K2-2
209 HK03959 PC board P-MIS40FP2
210 HB00947 PCB MIS40FP2_VER030710

MISTRAL2500 Parts List

30

No. Part No. Description Specification Remark

211 SA00191 L.E.D

φ3 (LEG2062)

D1_1,D2_1
212 SA00053 L.E.D high intensity 3m/m round(red)long foot 26mm D1+3,D2_3
213 SA00054 L.E.D high intensity 3m/m round(yellow)long foot 26 D1_30,D2_30
214 HC00066 row-wire header(male) 3P 2.5mm 90° CN1_1,CN2_1
215 RC00209 PPBC239
216 SA00194 L.E.D

A10KΩ RV110-40E1-225A-A14
φ3

VR1_1,VR2_1

D1_29,D2_29
217 NI01765 LED spacer support LEDS-10 10mm
218 HA02450 wire
219 HA02451 wire

10P-10P 350mm UL2651 28AWG PH1.27mm

10P-10P 250mm UL2651 28AWG PH1.27mm

JP2_22

JP1_22
220 HK04015 PC board P-MIS40SP
221 HB00962 PCB MIS40SP_VER030522
222 HC00442 speaker holder NL4MP (NEUTRIK)
223 HC00522 terminal 4P black/red/red/black A414B-BL
224 MJ00942 fixed board CS12/600
225 MJ00061 Zn-plated board 1*2135*1220 20.45kg
226 HA01239
227 HA01237

signle terminal wiring CF:W209
signle terminal wiring CF:W207

180mm UL1015 14AWG white

200mm UL1015 14AWG grey
228 HA02471 wire 360mm UL1015 14AWG white
229 HA01258 quick terminal wiring 380mm UL1015 14AWG grey
230 HI00143 manual reposition switch A0701HM-8A
231 HA01241 wire 480mm UL1015 14AWG brown
232 HA01248 wire 150mm UL1015 14AWG brown
233 NA00116 PE bag 0.04t*170*100mm
234 NI01867 self-adhere foot cushion 20.5*14*7.6mm(SF-006)
235 NI00389 plastic washer

φ12*φ16*0.5
236 NI00375 film 45*60.5*0.5mm
237 MJ01227 cushion MISTRAL2500
238 MJ01228 cushion MISTRAL2500 2.0t*422*15
239 MJ01154 iron board 2.0t*1850*950mm 27.6kg
240 HK00793 PC board P-MIS2500-INPUT
241 HB01105 PCB MIS40IN-1_VER031206
242 HC00297 terminal block DT-55-A14W-03(3PH) CN1
243 HC00077 row-wire header(male) 3P 2.5mm 180° CN3
244 HC00079 row-wire header(male) 5P 2.5mm 180° CN4
245 HK00787 PC board P-MIS2500-INPUT(MIC jack)

MISTRAL2500 Parts List

31

No. Part No. Description Specification Remark

246 HB01104 PCB MIS40IN-2_VER031206
247 HC00077 row-wire header(male) 3P 2.5mm 180° CN1
248 HC00110 MIC jack JY-6314-02-340 JP1
249 HA01394 row-wire connector wiring 3P-3P 120
250 MD00444 protecting cover 80*80mm(K-G08A05-4HA)
251 NF01672 instruction MISTRAL2500 ALT O_V1.3
252 NH00149 paper 889*640mm
253 HK04156 PC board
254 HB01242 PCB MIS40MN-CH1_VER040326

P-MIS40MN CH1(MISTRAL2500)

255 RA00211 fixed resistor 1/4W
256 RA00239 fixed resistor 1/4W
257 RA00266 fixed resistor 1/4W
258 RA00174 fixed resistor 1/4W
259 RA00299 fixed resistor 1/4W
260 RA00200 fixed resistor 1/4W
261 RA00616 fixed resistor 1/4W
262 RA00217 fixed resistor 1/4W
263 RA00158 fixed resistor 1/4W
264 RA00246 fixed resistor 1/4W
265 RA00219 fixed resistor 1/4W
266 RA00282 fixed resistor 1/4W
267 RA00184 fixed resistor 1/4W
268 RA00242 fixed resistor 1/4W
269 RA00908 fixed resistor 1/2W
270 RA00909 fixed resistor 1/2W
271 RB00010 resistor

820Ω M type

8.2KΩ M type

47KΩ M type

47Ω M type

330KΩ M type

330Ω M type

470Ω M type

1.5KΩ M type

0.0Ω M type

15KΩ M type

1.8KΩ M type

100KΩ M type

100Ω M type

10KΩ M type

68KΩ P type

82KΩ P type

10KΩ 8P C Type

R1_14,R1_18
R1_53
R1_47
R1_52
R1_42,R1_48
R1_10,R1_55
R1_9
R1_45
R1_2
R1_11,R1_64
R1_1
R1_43,R1_46,R1_51
R1_57
R1_54,R1_8
R1_58
R1_56

RB1_1
272 RA00027 metal-oxide-film resistor 1W
273 RA00007 metal-oxide-film resistor 1W
274 RA00020 metal-oxide-film resistor 1W
275 RA00051 metal-oxide-film resistor 2W
276 RA00953 metal-oxide-film resistor 5W
277 RA00062 metal-oxide-film resistor 3W
278 RA00880 cement resistor 5W
279 RA00870 cement resistor 5W
280 RA00869 cement resistor 5W

5.6Ω P type
22Ω P type

6.8KΩ P type

5.6Ω P type
10KΩ P type

1.0KΩ RSS P type

0.22Ω SQM type
12Ω SQM type
1KΩ SQM type

R1_22,R1_62

R1_25,R1_32

R1_44

R1_39

R1_49

R1_63

R1_28,R1_29,R1_30,R1_31,R1_33,R1_34,

R1_36,R1-35

R1_40,R1_41

R1_23,R1_24

MISTRAL2500 Parts List

32

No. Part No. Description Specification Remark

281 RA00981 cement resistor 10W

3.3KΩ SQM type

R1_15,R1_19
282 CA00010 ceramic capacitor 27PF NPO C1_10
283 CA00018 ceramic capacitor 56PF NPO C1_36,C1_35,C1_7
284 CA00024 ceramic capacitor 100PF SL C1_3,C1_4
285 CA00043 ceramic capacitor 0.0033uF C1_13,C1_14
286 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C1_11
287 CA00047 ceramic capacitor 0.033uF C1_12
288 CA00053 ceramic capacitor 0.1uF SL C1_44
289 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C1_40
290 CF00013 metal-film capacitor MEF 0.068uF/250V C1_31
291 CB00185 electrolytic capacitor
292 CB00177 electrolytic capacitor
293 CB00169 electrolytic capacitor
294 CB00039 electrolytic capacitor
295 CB00149 electrolytic capacitor
296 CB00055 electrolytic capacitor
297 CB00171 electrolytic capacitor

10uF/63V φ5*11mm
22uF/50V φ5*11mm
47uF/16V NP φ6.3*1 1mm
47uF/25V φ5*11mm
47uF/63V φ6*11mm
220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm

C1_32,C1_43

C1_2,C1_1,R1-43

C1_9

C1_5,C1_6

C1_33

C1_37

C1_34
298 CB00057 electrolytic capacitor
299 CB00067 electrolytic capacitor
300 CB00170 electrolytic capacitor

220uF/25V φ8*11mm
470uF/35V φ10*20mm
1000uF/100V φ18*35.5mm

C1_8,C1_45

C1_42

C1_15,C1_16,C1_17,C1_18,C1_19,C1_20,

C1_21,C1_22,C1_23,C1_24,C1_25,C1_26

301 SA00167 bridge rectifier 2A W2-04 D1_19,D1_2,D1_24,D1_27
302 SA00093 rectifier diode 1N4148 0.5A D1_11,D1_12
303 SA00098 rectifier diode 1A/400V IN4004

D1_10,D1_13,D1_14,D1_20,D1_22,D1_23,

D1_25,D1_26,D1_28,D1_9

304 SA00187 rectifier diode IN5404 D1_15,D1_16
305 SA00002 high speed diode 1A/600V 1N4937 D1_5,D1_6
306 SA00107 zener diode 1W 15V 1N4744 D1_1,D1_4
307 SA00197 L.E.D 1W 36V 1N4753 D1_21
308 SA00117 zener diode 1/2W 5.6V 6B1 D1_7,D1_8
309 SA00188 diode 1/2W 7.5V D1_18
310 SA00026 L.E.D 5m/m circle red B1115 D1_17
311 SB00042 transistor MJE15032 Q1_1
312 SB00044 transistor MJE15033 Q1_2
313 SB00130 transistor MPSA42/(PHILIPS) Q1_17
314 SB00129 transistor MPSA92(TO92)/(PHI) Q1_15,Q1_16
315 SB00023 power transistor 2SA1943-O Q1_6,Q1_7,Q1_8,Q1_5

MISTRAL2500 Parts List

33

No. Part No. Description Specification Remark

316 SB00021 power transistor 2SC5200 Q1_10,Q1_11,Q1_12,Q1_9
317 SD00032 integrated circuit LM317T U1_4
318 SD00173 integrated circuit NJM4580L(JRC) U1_1,U1_2
319 CN00060 fixed inductance

2uH 10A(CSAF-302824)(φ1.5mm*12 1/2T)

L1_1
320 RH00021 Thermal resistor
321 RH00017 Thermal resistor
322 RH00025 resistor
323 RC00319 resistor
324 RC00348 resistor

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)

B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

R1_3

R1_17

R1_50

R1_16

R1_20,R1_21
325 HI00211 raley 8P 24VDC/16A 881H-1CC-C K1_1
326 HI00039 push-button switch SP70300-0202-11F1-N S1_1
327 HK02231 coupling

P-photosensitive resistanceφ5LLED

U1_5
328 RH00020 photosensitive resistance VT90N1
329 SA00201 L.E.D
330 NI02779 sleeve
331 NI00274 sleeve
332 HC00324 terminal 6.5m/m (PC250)

φ5 red(LI3330/A)
φ9*30mm
φ9*1000mm

JP1_1,JP1_2,JP1_5,JP1_6,JP1_7,
333 HC00056 FUSE holder 8*10.6*1.5 JEF-505 JP1_10,JP1_11,JP1_12,JP1_9

334 HC00112 XLR MIC jack 99M-107SP-1-2 90° PUSH J1_1
335 HC00111 XLR MIC jack 99M-108SP1 J1_2
336 HC00504 row-wire header(male) 10P 2.54mm 180° JP1_15,JP1_16,JP1_3
337 HC00172 row-wire header(male) 3P 3.96mm 180° JP1_13
338 HC00077 row-wire header(male) 3P 2.5mm 180° R1_5
339 HC00076 row-wire header(male) 2P 2.5mm 180° JP1_14
340 HA01933 jumper wire 2.5mm J1_4,J1_5
341 HC00034 connector NO.2700 2.54mm/6mm OPEN
342 HD00029 ceramic tube fuse

15A φ6*32mm UL
343 MI01755 heat-chassis 9*83*40*309 MISTRAL4000
344 MJ01200 spacer MISTRAL4000 14.5*30.5*2t
345 MJ01201 spacer MISTRAL4000 14.5*30.5*2t
346 MJ01154 iron board 2.0t*1850*950mm 27.6kg
347 MF00030 washer
348 MF00037 washer
349 NI00279 sleeve
350 NI00278 sleeve

φ3*φ8*0.8t

φ3*φ5*1t

φ15*20mm

φ15*1000mm

U1_4

MISTRAL2500 Parts List

34

No. Part No. Description Specification Remark

351 NC00005 silicone insulator TO-220 square type
352 MG00171 screw M3*14
353 ND00182 silicone sleeve
354 ND00171 silicone sleeve

φ1*30mm

φ1*1000mm

355 NC00181 insulator MISTRAL4000 1.6t*136*16mm
356 NC00041 red foil white board 1.6t*0.65M*70M
357 MI01954 fixed bracket

MISTRAL4000 1.5t*136*16mm right

358 MJ00069 iron board 1.5*2135*1220 30.67kg
359 HA02759 wire 5P-5P 120mm UL1007 24AWG
360 CA00088 ceramic capacitor 100PF/1000V Q1-1,Q1-2
361 MI02324 heat-sink 9*83*70*309 left_V1.0
362 MI02359 heat sink

9*83*70*4400 +5/-0 18.8320KG_V1.0

363 NA00279 clip-chain bag 0.04t*100*150mm_V1.0
364 AD00012 twin adhesive 90*120mm_V1.0

MISTRAL4000 Parts List

35

No. Part No. Description Specification Remark

1 MA04096 panel MISTRAL4000
2 MA04097 panel MISTRAL4000
3 MA04098 panel
4 MI01309 panel 3.1*88.8*25.5*483
5 MA00196 panel MISTRAL4000 ALT O new_V1.0
6 MA04436 panel CPA 1000
7 MA05424 panel MISTRAL1500_V1.0
8 MJ00088 iron board 1.5*2135*1220 30.67kg
9 MB02820 rear board MISTRAL4000
10 MB02821 rear board MISTRAL4000_V1.1
11 MB02822 rear board
12 MJ00088 iron board 1.5*2135*1220 30.67kg
13 ME00002 screw pillar M4*20*0.7PH
14 ME00051 iron pillar M3*12

MISTRAL4000 3.1*88.8*25.5*483

MISTRAL4000 430*400*85.5*2.0t_V1.1

15 ME00001 screw pillar M4*10*0.7PH
16 MI01516 partition MISTRAL4000 57*177*195
17 MJ00058 iron board 1*2135*1220 20.45kg
18 MC00517 top cover MISTRAL4000
19 MC00622 top cover MISTRAL2500_V1.0
20 MC00621 top cover MISTRAL2500_V1.0
21 MJ00088 iron board 1.5*2135*1220 30.67kg
22 MI01744 handle MISTRAL4000 20*25.5*80
23 MI01745 handle MISTRAL4000 20*25.5*80
24 MI01750 fixed bracket MISTRAL4000 left L type
25 MI01751 fixed bracket 26.5*88.8*400mm
26 MJ01154 iron board 2.0t*1850*950mm 27.6kg
27 MI01752 fixed bracket MISTRAL4000 right L type
28 MI01753 fixed bracket 26.5*88.8*400mm
29 MJ01154 iron board 2.0t*1850*950mm 27.6kg
30 MI01746 front board MISTRAL4000 14*81*89
31 MJ00061 Zn-plated board 1*2135*1220 20.45kg
32 MI01759 partition

MISTRAL4000(left) 0.8t*53.5*78_V1.1

33 MJ00067 iron board 0.8*2440*1220 18.69kg
34 MI01756 partition

MISTRAL4000(right) 0.8t*53.5*78_V1.1

35 MJ00067 iron board 0.8*2440*1220 18.69kg

MISTRAL4000 Parts List

36

No. Part No. Description Specification Remark

36 NI02650 knob
37 NI02651 knob fix sheath
38 HC00005 AC socket AC-008
39 HI00031 power switch R415KKETOF
40 SA00200 bridge rectifier 40A/400V BP40-04
41 HA01243 wire 300mm UL1015 14AWG brown
42 HA01333
43 HA01247 wire 180mm UL1015 14AWG blue
44 HA02469 wire 3P-3P 480mm 28AWG blue
45 HA02470 wire 3P-3P 600mm 28AWG blue
46 HA02452 wire 10Pfema*3 415mm UL2651
47 HA02448 wire 530mm UL1015 14AWG red
48 HA02449 wire 700mm UL1015 14AWG black
49 HA01244 wire 380mm UL1015 14AWG red
50 HA01198 wire 180mm UL1015 14AWG black
51 MG00247 copper pillar M3*10*0.5PHsingle length16
52 MG00061 screw M3*10

single terminal wiring CF:W76 150mm UL1015 18AWG green/yellow

φ18*18mm

10*φ22.5

53 MG00295 screw M4*6
54 MG00025 screw M3*6
55 MG00042 screw M3*10
56 MF00037 washer
57 ME00015 nut 3m/m
58 MF00038 washer
59 ME00016 nut 4m/m
60 MF00048 washer
61 MF00018 washer
62 MG00268 screw M5*12
63 MG00041 screw M3*6
64 MG00075 screw M4*16
65 ME00006 nut R.S
66 MF00004 washer
67 NI00437 rubber coil
68 MG00556 screw M8*82.5*1.25PH_V1.0
69 ME00026 nut 8m/m

φ3*φ5*1t

φ4*φ7*1t

φ4*φ8*0.5t

φ4*φ10*1t

9φ

φ9*φ14*0.5t

φ20*φ120*2tB

70 MF00026 washer

φ8*φ18*1.5t

MISTRAL4000 Parts List

37

No. Part No. Description Specification Remark

71 MF00041 washer
72 MH00766 iron piece
73 MH00768 iron piece

φ8*φ13.5*2t

φ11*φ90*2_V1.1

φ11*φ90*2_V1.1

74 MJ01154 iron board 2.0t*1850*950mm 27.6kg
75 TD00217 loop transformer PT-MIS4000_115/230V
76 NI00252 sleeve
77 NI00248 sleeve
78 HE00050 fan

φ4*20mm

φ4*1000mm

DV12V/0.37A 80*80*25 360mm JST2P

79 NI00312 power switch button square 5*5*9 hole 2.8*2.8 black
80 HA00871 power cord(European 3P)

LT-322+1.5*3C(H05VV-F) 6FT+LT-501

81 NI00218 cable tie-black ALT-102SB
82 HJ00006 desiccant 30g
83 NA00135 PE bag 0.05t*610*500mm
84 NF01499 instruction MISTRAL4000 ALTO_V1.3
85 NH00149 paper 889*640mm
86 NB02466 color box MISTRAL4000 ALTO_V1.1
87 NB01944 barrier PSA-3000_V1.1
88 NB02086 box MACRO
89 NE02227 label PSA-31500 220-240V
90 NI00037 adhesive label 0.05*1M
91 NI00034 membrane 0.045*1M
92 NF00061 assurance card ALTO
93 NE11460 label MISTRAL4000
94 NH00012 bond paper 0.04*1M
95 NI00014 membrane 0.035*1M
96 NE11347 label ALT O PI
97 NH00334 cone paper 0.040*1m
98 NC00059 fixed board 1*46*46(Sax-2000)
99 NC00175 insulator 1.0t*51mm*100M
100 HK04177 PC board

P-MIS40MN CH1(MISTRAL4000)

101 HB01242 PCB MIS40MN-CH1_VER040326
102 RA00211 fixed resistor 1/4W
103 RA00239 fixed resistor 1/4W
104 RA00266 fixed resistor 1/4W

820Ω M type

8.2KΩ M type

47KΩ M type

R1_14,R1_18
R1_53
R1_47

105 RA00174 fixed resistor 1/4W

47Ω M type

R1_52

MISTRAL4000 Parts List

38

No. Part No. Description Specification Remark

106 RA00299 fixed resistor 1/4W
107 RA00200 fixed resistor 1/4W
108 RA00616 fixed resistor 1/4W
109 RA00217 fixed resistor 1/4W
110 RA00158 fixed resistor 1/4W
111 RA00246 fixed resistor 1/4W
112 RA00219 fixed resistor 1/4W
113 RA00282 fixed resistor 1/4W
114 RA00184 fixed resistor 1/4W
115 RA00242 fixed resistor 1/4W
116 RA00908 fixed resistor 1/2W
117 RA00909 fixed resistor 1/2W
118 RB00010 resistor
119 RA00027 metal-oxide-film resistor 1W
120 RA00007 metal-oxide-film resistor 1W
121 RA00020 metal-oxide-film resistor 1W
122 RA00051 metal-oxide-film resistor 2W

330KΩ M type

330Ω M type

470Ω M type

1.5KΩ M type

0.0Ω M type

15KΩ M type

1.8KΩ M type

100KΩ M type

100Ω M type

10KΩ M type

68KΩ P type

82KΩ P type

10KΩ 8P C Type

5.6Ω P type

22Ω P type

6.8KΩ P type

5.6Ω P type

R1_42,R1_48
R1_10,R1_55
R1_9
R1_45
R1_2
R1_11,R1_64
R1_1
R1_43,R1_46,R1_51
R1_57
R1_54,R1_8
R1_58
R1_56
RB1_1
R1_22,R1_62
R1_25,R1_32
R1_44

R1_39
123 RA00953 metal-oxide-film resistor 5W
124 RA00062 metal-oxide-film resistor 3W
125 RA00880 cement resistor 5W
126 RA00870 cement resistor 5W
127 RA01016 cement resistor 5W
128 RA01017 cement resistor 10W

10KΩ P type

1.0KΩ RSS P type

0.22Ω SQM type
12Ω SQM type

2.2KΩ SQM type

4.7KΩ SQM type

R1_49

R1_63

R1_27,R1_28,R1_29,R1_30,R1_31,R1_33,

R1_34,R1_36,R1_37,R1-26,R1-35,R1-38

R1_40,R1_41

R1_23,R1_24

R1_15,R1_19
129 CA00010 ceramic capacitor 27PF NPO C1_10
130 CA00018 ceramic capacitor 56PF NPO C1_36,C1_35,C1_7
131 CA00024 ceramic capacitor 100PF SL C1_3,C1_4
132 CA00043 ceramic capacitor 0.0033uF C1_13,C1_14
133 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C1_11
134 CA00047 ceramic capacitor 0.033uF C1_12
135 CA00053 ceramic capacitor 0.1uF SL C1_44
136 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C1_40
137 CF00013 metal-film capacitor MEF 0.068uF/250V C1_31
138 CB00185 electrolytic capacitor
139 CB00177 electrolytic capacitor

10uF/63V φ5*11mm
22uF/50V φ5*11mm

C1_32,C1_43

C1_2,C1_1,R1-43
140 CB00169 electrolytic capacitor

47uF/16V NP φ6.3*1 1mm

C1_9

MISTRAL4000 Parts List

39

No. Part No. Description Specification Remark

141 CB00039 electrolytic capacitor
142 CB00149 electrolytic capacitor
143 CB00055 electrolytic capacitor
144 CB00171 electrolytic capacitor
145 CB00057 electrolytic capacitor
146 CB00067 electrolytic capacitor
147 CB00180 electrolytic capacitor

47uF/25V φ5*11mm
47uF/63V φ6*11mm
220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm
220uF/25V φ8*11mm
470uF/35V φ10*20mm
470uF/160V φ18*45mm

C1_5,C1_6

C1_33

C1_37

C1_34

C1_8,C1_45

C1_42

C1_15,C1_16,C1_17,C1_18,C1_19,C1_20,C1_21,C1_22,C

1_23,C1_24,C1_25,C1_26,C1_27,C1_28,C1_29,C1_30

148 SA00167 bridge rectifier 2A W2-04 D1_19,D1_24,D1_27,D1_2
149 SA00093 rectifier diode 1N4148 0.5A D1_11,D1_12
150 SA00098 rectifier diode 1A/400V IN4004

D1_10,D1_13,D1_14,D1_20,D1_22,D1_23,

D1_25,D1_26,D1_28,D1_9

151 SA00187 rectifier diode IN5404 D1_15,D1_16
152 SA00002 high speed diode 1A/600V 1N4937 D1_5,D1_6
153 SA00107 zener diode 1W 15V 1N4744 D1_1,D1_4
154 SA00197 L.E.D 1W 36V 1N4753 D1_21
155 SA00117 zener diode 1/2W 5.6V 6B1 D1_7,D1_8
156 SA00188 diode 1/2W 7.5V D1_18
157 SA00026 L.E.D 5m/m circle red B1115 D1_17
158 SB00042 transistor MJE15032 Q1_1
159 SB00044 transistor MJE15033 Q1_2
160 SB00130 transistor MPSA42/(PHILIPS) Q1_17
161 SB00129 transistor MPSA92(TO92)/(PHI) Q1_15,Q1_16
162 SB00023 power transistor 2SA1943-O
163 SB00021 power transistor 2SC5200

Q1_6,Q1_7,Q1_8,Q1_5,Q1_4,Q1_3

Q1_10,Q1_11,Q1_12,Q1_9,Q1_13,Q1_14

164 SD00032 integrated circuit LM317T U1_4
165 SD00173 integrated circuit NJM4580L(JRC) U1_1,U1_2
166 CN00060 fixed inductance
167 RH00021 Thermal resistor
168 RH00017 Thermal resistor
169 RH00025 resistor
170 RC00319 resistor
171 RC00348 resistor

2uH 10A(CSAF-302824)(φ1.5mm*12 1/2T)

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)

B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

L1_1

R1_3

R1_17

R1_50

R1_16

R1_20,R1_21
172 HI00211 raley 8P 24VDC/16A 881H-1CC-C K1_1
173 HI00039 push-button switch SP70300-0202-11F1-N S1_1
174 HK02231 coupling

P-photosensitive resistanceφ5LLED

U1_5
175 RH00020 photosensitive resistance VT90N1

MISTRAL4000 Parts List

40

No. Part No. Description Specification Remark

176 SA00201 L.E.D
177 NI02779 sleeve
178 NI00274 sleeve
179 HC00324 terminal 6.5m/m (PC250)

φ5 red(LI3330/A)
φ9*30mm
φ9*1000mm

JP1_1,JP1_2,JP1_5,JP1_6,JP1_7,JP1_8

180 HC00056 FUSE holder 8*10.6*1.5 JEF-505 JP1_10,JP1_11,JP1_12,JP1_9
181 HC00112 XLR MIC jack 99M-107SP-1-2 90° PUSH J1_1
182 HC00111 XLR MIC jack 99M-108SP1 J1_2
183 HC00504 row-wire header(male) 10P 2.54mm 180° JP1_15,JP1_16,JP1_3
184 HC00172 row-wire header(male) 3P 3.96mm 180° JP1_13
185 HC00077 row-wire header(male) 3P 2.5mm 180° R1_5
186 HC00076 row-wire header(male) 2P 2.5mm 180° JP1_14
187 HA01933 jumper wire 2.5mm J1_4,J1_5
188 HC00034 connector NO.2700 2.54mm/6mm OPEN
189 HD00029 ceramic tube fuse

15A φ6*32mm UL
190 MI02324 heat-sink 9*83*70*309 left_V1.0
191 MI02359 heat sink

9*83*70*4400 +5/-0 18.8320KG_V1.0

192 MJ01200 spacer MISTRAL4000 14.5*30.5*2t
193 MJ01201 spacer MISTRAL4000 14.5*30.5*2t
194 MJ01154 iron board 2.0t*1850*950mm 27.6kg
195 MF00030 washer
196 MF00037 washer
197 NI00279 sleeve
198 NI00278 sleeve

φ3*φ8*0.8t

φ3*φ5*1t

φ15*20mm

φ15*1000mm

U1_4

199 NC00005 silicone insulator TO-220 square type
200 MG00171 screw M3*14
201 ND00182 silicone sleeve
202 ND00171 silicone sleeve

φ1*30mm

φ1*1000mm

203 NC00181 insulator MISTRAL4000 1.6t*136*16mm
204 NC00041 red foil white board 1.6t*0.65M*70M
205 MI01954 fixed bracket

MISTRAL4000 1.5t*136*16mm right

206 MJ00069 iron board 1.5*2135*1220 30.67kg
207 HA02759 wire 5P-5P 120mm UL1007 24AWG
208 CA00088 ceramic capacitor 100PF/1000V Q1-1,Q1-2
209 HK01708 PC board P-MIS40PWR(MIS4000)
210 HB00946 PCB MIS40PWR_VER030710

MISTRAL4000 Parts List

41

No. Part No. Description Specification Remark

211 HC00324 terminal 6.5m/m (PC250) P1,P2,P3,P4,P5,P6,P7,P8
212 CG00044 metal oxide varistor NP35L-Y2 K2-2
213 HK03959 PC board P-MIS40FP2
214 HB00947 PCB MIS40FP2_VER030710
215 SA00191 L.E.D

φ3 (LEG2062)

D1_1,D2_1
216 SA00053 L.E.D high intensity 3m/m round(red)long foot 26mm D1+3,D2_3
217 SA00054 L.E.D high intensity 3m/m round(yellow)long foot 26 D1_30,D2_30
218 HC00066 row-wire header(male) 3P 2.5mm 90° CN1_1,CN2_1
219 RC00209 PPBC239
220 SA00194 L.E.D

A10KΩ RV110-40E1-225A-A14
φ3

VR1_1,VR2_1

D1_29,D2_29
221 NI01765 LED spacer support LEDS-10 10mm
222 HA02450 wire
223 HA02451 wire

10P-10P 350mm UL2651 28AWG PH1.27mm

10P-10P 250mm UL2651 28AWG PH1.27mm

JP2_22

JP1_22
224 HK04015 PC board P-MIS40SP
225 HB00962 PCB MIS40SP_VER030522
226 HC00442 speaker holder NL4MP (NEUTRIK)
227 HC00522 terminal 4P black/red/red/black A414B-BL
228 MJ00942 fixed board CS12/600
229 MJ00061 Zn-plated board 1*2135*1220 20.45kg
230 HA01239
231 HA01237

signle terminal wiring CF:W209
signle terminal wiring CF:W207

180mm UL1015 14AWG white

200mm UL1015 14AWG grey
232 HA02471 wire 360mm UL1015 14AWG white
233 HA01258 quick terminal wiring 380mm UL1015 14AWG grey
234 HI00141 manual reposition switch A0701HM-10A
235 HA01241 wire 480mm UL1015 14AWG brown
236 HA01248 wire 150mm UL1015 14AWG brown
237 NA00116 PE bag 0.04t*170*100mm
238 NI01867 self-adhere foot cushion 20.5*14*7.6mm(SF-006)
239 NI00389 plastic washer

φ12*φ16*0.5
240 NI00375 film 45*60.5*0.5mm
241 MJ01227 cushion MISTRAL2500
242 MJ01228 cushion MISTRAL2500 2.0t*422*15
243 MJ01154 iron board 2.0t*1850*950mm 27.6kg
244 HK00793 PC board P-MIS2500-INPUT
245 HB01105 PCB MIS40IN-1_VER031206

MISTRAL4000 Parts List

42

No. Part No. Description Specification Remark

246 HC00297 terminal block DT-55-A14W-03(3PH) CN1
247 HC00077 row-wire header(male) 3P 2.5mm 180° CN3
248 HC00079 row-wire header(male) 5P 2.5mm 180° CN4
249 HK00787 PC board P-MIS2500-INPUT(MIC jack)
250 HB01104 PCB MIS40IN-2_VER031206
251 HC00077 row-wire header(male) 3P 2.5mm 180° CN1
252 HC00110 MIC jack JY-6314-02-340 JP1
253 HA01394 row-wire connector wiring 3P-3P 120
254 MD00444 protecting cover 80*80mm(K-G08A05-4HA)
255 HK04178 PC board
256 HB01243 PCB MIS40MN-CH2_VER040326

P-MIS40MN CH2(MISTRAL4000)

257 RA00211 fixed resistor 1/4W
258 RA00239 fixed resistor 1/4W
259 RA00266 fixed resistor 1/4W
260 RA00174 fixed resistor 1/4W
261 RA00299 fixed resistor 1/4W
262 RA00200 fixed resistor 1/4W
263 RA00616 fixed resistor 1/4W
264 RA00217 fixed resistor 1/4W
265 RA00158 fixed resistor 1/4W
266 RA00246 fixed resistor 1/4W
267 RA00219 fixed resistor 1/4W
268 RA00282 fixed resistor 1/4W
269 RA00184 fixed resistor 1/4W
270 RA00242 fixed resistor 1/4W
271 RA00908 fixed resistor 1/2W
272 RA00909 fixed resistor 1/2W
273 RB00010 resistor

820Ω M type

8.2KΩ M type

47KΩ M type

47Ω M type

330KΩ M type

330Ω M type

470Ω M type

1.5KΩ M type

0.0Ω M type

15KΩ M type

1.8KΩ M type

100KΩ M type

100Ω M type

10KΩ M type

68KΩ P type

82KΩ P type

10KΩ 8P C Type

R2_14,R2_18
R2_53
R2_47
R2_52
R2_42,R2_48
R2_10,R2_55
R2_9
R2_45
R2_2
R2_11
R2_1
R2_43,R2_46,R2_51
R2_57
R2_54,R2_8
R2_58
R2_56

RB2_1
274 RA00027 metal-oxide-film resistor 1W
275 RA00007 metal-oxide-film resistor 1W
276 RA00020 metal-oxide-film resistor 1W
277 RA00051 metal-oxide-film resistor 2W
278 RA00953 metal-oxide-film resistor 5W
279 RA00062 metal-oxide-film resistor 3W
280 RA00880 cement resistor 5W

5.6Ω P type
22Ω P type

6.8KΩ P type

5.6Ω P type
10KΩ P type

1.0KΩ RSS P type

0.22Ω SQM type

R2_22,R2_62

R2_25,R2_32

R2_44

R2_39

R2_49

R2_63

R2_27,R2_28,R2_29,R2_30,R2_31,R2_33,

R2_34,R2-37,R2_36,R2-26,R2-35,R2-38

MISTRAL4000 Parts List

43

No. Part No. Description Specification Remark

281 RA00870 cement resistor 5W
282 RA01016 cement resistor 5W
283 RA01017 cement resistor 10W

12Ω SQM type

2.2KΩ SQM type

4.7KΩ SQM type

R2_41,R2_40

R2_23,R2_24

R2_15,R2_19
284 CA00010 ceramic capacitor 27PF NPO C2_10
285 CA00018 ceramic capacitor 56PF NPO C2_35,C2_36,C2_7
286 CA00024 ceramic capacitor 100PF SL C2_3,C2_4
287 CA00043 ceramic capacitor 0.0033uF C2_13,C2_14
288 CA00070 ceramic capacitor 0.022uF/50V±20% Y5U C2_11
289 CA00047 ceramic capacitor 0.033uF C2_12
290 CA00053 ceramic capacitor 0.1uF SL C2_44
291 CF00022 metal-film capacitor MSC 0.022uF/100V 5% CASE01 C2_40
292 CF00013 metal-film capacitor MEF 0.068uF/250V C2_31
293 CB00185 electrolytic capacitor
294 CB00177 electrolytic capacitor
295 CB00169 electrolytic capacitor
296 CB00039 electrolytic capacitor
297 CB00149 electrolytic capacitor

10uF/63V φ5*11mm
22uF/50V φ5*11mm
47uF/16V NP φ6.3*1 1mm
47uF/25V φ5*11mm
47uF/63V φ6*11mm

C2_32,C2_43

C2_1,C2_2,R2-43

C2_9

C2_5,C2_6

C2_33
298 CB00055 electrolytic capacitor
299 CB00171 electrolytic capacitor
300 CB00057 electrolytic capacitor
301 CB00067 electrolytic capacitor
302 CB00180 electrolytic capacitor

220uF/16V φ8*11mm
220uF/16V NP φ10*12.5mm
220uF/25V φ8*11mm
470uF/35V φ10*20mm
470uF/160V φ18*45mm

C2_37

C2_34

C2_8,C2_45

C2_42

C2_15,C2_16,C2_17,C2_18,C2_19,C2_20,C2_21,C2_22,C

2_23,C2_24,C2_25,C2_26,C2_27,C2_28,C2_29,C2_30

303 SA00167 bridge rectifier 2A W2-04 D2_2,D2_19,D2_24,D2_27
304 SA00093 rectifier diode 1N4148 0.5A D2_11,D2_12
305 SA00098 rectifier diode 1A/400V IN4004

D2_10,D2_13,D2_14,D2_20,D2_22,D2_23,

D2_25,D2_26,D2_28,D2_9

306 SA00187 rectifier diode IN5404 D2_15,D2_16
307 SA00002 high speed diode 1A/600V 1N4937 D2_5,D2_6
308 SA00107 zener diode 1W 15V 1N4744 D2_1,D2_4
309 SA00197 L.E.D 1W 36V 1N4753 D2_21
310 SA00117 zener diode 1/2W 5.6V 6B1 D2_7,D2_8
311 SA00188 diode 1/2W 7.5V D2_18
312 SA00026 L.E.D 5m/m circle red B1115 D2_17
313 SB00042 transistor MJE15032 Q2_1
314 SB00044 transistor MJE15033 Q2_2
315 SB00130 transistor MPSA42/(PHILIPS) Q2_17

MISTRAL4000 Parts List

44

No. Part No. Description Specification Remark

316 SB00129 transistor MPSA92(TO92)/(PHI) Q2_15,Q2_16
317 SB00023 power transistor 2SA1943-O
318 SB00021 power transistor 2SC5200
319 SD00032 integrated circuit LM317T U2_4
320 SD00173 integrated circuit NJM4580L(JRC) U2_1,U2_2
321 CN00060 fixed inductance

2uH 10A(CSAF-302824)(φ1.5mm*12 1/2T)

Q2_5,Q2_6,Q2_7,Q2_8,Q2_4,Q2_3

Q2_9,Q2_10,Q2_11,Q2_12,Q2_13,Q2_14

L2_1
322 RH00021 Thermal resistor
323 RH00017 Thermal resistor
324 RH00025 resistor
325 RC00319 resistor
326 RC00348 resistor

500Ω(TDC5C150L)
50Ω(TDC05A050J)
100Ω(PAS7101ZF)

B100Ω PT1030-V1B101-C1-H10
B1KΩ PT1030-V1B102-C1-H10

R2_3

R2_17

R2_50

R2_16

R2_20,R2_21
327 HI00211 raley 8P 24VDC/16A 881H-1CC-C K2_1
328 HI00039 push-button switch SP70300-0202-11F1-N S2_1
329 HK02231 coupling

P-photosensitive resistanceφ5LLED

U2_5
330 RH00020 photosensitive resistance VT90N1
331 SA00201 L.E.D
332 NI02779 sleeve
333 NI00274 sleeve
334 HC00324 terminal 6.5m/m (PC250)

φ5 red(LI3330/A)
φ9*30mm
φ9*1000mm

JP2_1,JP2_2,JP2_5,JP2_6,JP2_7,JP2_8

335 HC00056 FUSE holder 8*10.6*1.5 JEF-505 JP2_9,JP2_10,JP2_11,JP2_12
336 HC00112 XLR MIC jack 99M-107SP-1-2 90° PUSH J2_1
337 HC00111 XLR MIC jack 99M-108SP1 J2_2
338 HC00504 row-wire header(male) 10P 2.54mm 180° JP2_15,JP2_16,JP2_3
339 HC00172 row-wire header(male) 3P 3.96mm 180° JP2_13
340 HC00077 row-wire header(male) 3P 2.5mm 180° R2_5
341 HC00076 row-wire header(male) 2P 2.5mm 180° JP2_14
342 HA01933 jumper wire 2.5mm J2_4,J2_5
343 HC00034 connector NO.2700 2.54mm/6mm OPEN
344 HD00029 ceramic tube fuse

15A φ6*32mm UL
345 MI02325 heat-sink 9*83*70*309 right_V1.0
346 MI02359 heat sink

9*83*70*4400 +5/-0 18.8320KG_V1.0

347 MJ01200 spacer MISTRAL4000 14.5*30.5*2t
348 MJ01201 spacer MISTRAL4000 14.5*30.5*2t
349 MJ01154 iron board 2.0t*1850*950mm 27.6kg
350 MF00030 washer

φ3*φ8*0.8t

MISTRAL4000 Parts List

45

No. Part No. Description Specification Remark

351 MF00037 washer
352 NC00005 silicone insulator TO-220 square type
353 MG00171 screw M3*14
354 ND00182 silicone sleeve
355 ND00171 silicone sleeve
356 NC00181 insulator MISTRAL4000 1.6t*136*16mm
357 NC00041 red foil white board 1.6t*0.65M*70M
358 MI01954 fixed bracket
359 MJ00069 iron board 1.5*2135*1220 30.67kg
360 HA02759 wire 5P-5P 120mm UL1007 24AWG
361 CA00088 ceramic capacitor 100PF/1000V Q2-1,Q2-2
362 MG00027 screw M3*12
363 NA00279 clip-chain bag 0.04t*100*150mm_V1.0
364 AD00012 twin adhesive 90*120mm_V1.0

φ3*φ5*1t

φ1*30mm

φ1*1000mm

MISTRAL4000 1.5t*136*16mm right