Alliance Laundry Systems HA025L, HT025L, SA025L, SA025N, ST025L Operation & Maintenance Manual

...

Tumble Dryers

25 Pound Capacity 30 Pound Capacity 35 Pound Capacity 55 Pound Capacity

Starting Serial No. 0602004144

Refer to Page 3 for Model Identification

Operation/Maintenance

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

www.comlaundry.com

Part No. 70380401R9EN

January 2012

Installation must conform with local codes or in the absence of local codes with:

FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury or death.

W033

WARNING

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

• WHAT TO DO IF YOU SMELL GAS: – Do not try to light any appliance. – Do not touch any electrical switch; do

not use any phone in your building.

– Clear the room, building or area of all

occupants.

– Immediately call your gas supplier from

a neighbor’s phone. Follow the gas supplier’s instructions.

– If you cannot reach your gas supplier,

call the fire department.

• Installation and service must be performed by a qualified installer, service agency or the gas supplier.

W052

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

W053

• Évitez de ranger ou d’utiliser de l’essence ou tout autre liquide inflammable ou produisant des vapeurs inflammables à proximité de cet appareil ou de tout autre appareil.

• PRÉCAUTIONS À PRENDRE SI VOUS SENTEZ UNE ODEUR DE GAZ : – Ne tentez d’allumer aucune veilleuse. – Évitez tout contact avec les

interrupteurs électriques; ne vous servez d’aucun téléphone de votre édifice.

– Évacuez toute personne du local, de

l’édifice ou de la zone concerné(e).

– Téléphonez immédiatement à votre

fournisseur du gaz en vous servant du téléphone d’un voisin. Suivez les instructions du fournisseur du gaz.

– Si vous n’arrivez pas à vous mettre en

contact avec votre fournisseur du gaz, appelez les pompiers.

• L’installation et l’entretien de cet appareil doivent être exécutés par un installateur qualifié, un centre de service agréé ou votre fournisseur du gaz.

W052FR

•

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser d’essence ou autres gaz et liquides inflammables au voisinage de cet appareil ou de tout autre.

W053FR

POUR VOTRE SÉCURITÉ, veillez à bien respecter les indications de ce manuel afin de minimiser les risques d’incendie ou d’explosion ou d’écarter les dangers de dommages matériels, corporel ou de mort.

W033FR

MISE EN GARDE

In the U.S.A.

, installation must conform to the latest edition of the American National Standard Z223.1/

NFPA 54 “National Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric Code.”

In Canada

, installation must comply with Standards CAN/CSA-B149.1 or Natural Gas and Propane Code

CSA C22.1, latest edition, Canadian Electric Code, Part I.

In Australia

, installation must comply with the Australian Gas Association Installation Code for Gas

Burning Appliances and Equipment.

IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the user smells gas. These instructions must be posted in a prominent location. Step-by-step instructions of the above safety information must be posted in a prominent location near the tumble dryer for customer use.

70380401 (EN)

Table of

Contents

Introduction......................................................................................... 3

Model Identification ............................................................................. 3

Customer Service.................................................................................. 4

Wiring Diagram .................................................................................... 4

Serial Plate Location............................................................................. 4

Safety Information.............................................................................. 5

Explanation of Safety Messages........................................................... 5

Important Safety Instructions ............................................................... 6

Operating Instructions ....................................................................... 8

Emergency Stop Button on CE Models................................................ 8

Operating Instructions .......................................................................... 8

Control Instructions .............................................................................. 9

Dual Digital Timer Control.............................................................. 9

Electronic OPL Control ................................................................... 11

Single Drop Control......................................................................... 12

MDC Coin Control .......................................................................... 14

MDC Card Control .......................................................................... 15

NetMaster Coin Control................................................................... 16

NetMaster Card Control................................................................... 17

Quantum Control ............................................................................. 18

LED OPL Control ............................................................................ 19

UniLinc OPL Control ...................................................................... 20

Ignition Control Operation for

Non-CE Models.................................................................................. 21

Ignition Control Operation for CE Models........................................... 22

Maintenance ........................................................................................ 24

Daily ..................................................................................................... 24

Monthly................................................................................................. 26

Quarterly ............................................................................................... 26

Bi-Annually .......................................................................................... 26

Annually ............................................................................................... 26

Before You Call for Service ............................................................... 30

Customer Service.................................................................................. 30

© Copyright 2012, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.

70380401 (EN)

Introduction

Model Identification

Information in this manual is applicable to these models.

Gas Steam Electric

ST025L ST025N SU025L SU025N UA025L UA025N UT025L UT025N

SA030N ST030D ST030L ST030N SU030L SU030N UA030L UA030N

SA035N ST035L ST035N SU035L SU035N UA035L UA035N UT035L UT035N

SA055L SA055N ST055D ST055L ST055N SU055L SU055N

25 Pound

30 Pound

35 Pound

55 Pound

HA025L HA025N HT025L HT025N HU025L HU025N SA025L SA025N

HA030L HA030N HT030D HT030L HT030N HU030L HU030N SA030L

AT035L AT035N HA035L HA035N HT035L HT035N HU035L HU035N SA035L

HA055L HA055N HT055D HT055L HT055N HU055L HU055N

Includes models with control suffixes:

UU025L UU025N YT025L YT025N YU025L YU025N

UT030L UT030N UU030L UU030N YT030L YT030N YU030L YU030N

UU035L UU035N YT035L YT035N YU035L YU035N

UA055L UA055N UT055L UT055N UU055L UU055N

HT025S HU025S ST025S SU025S UT025S UU025S YT025S YU025S

HT030S HU030S ST030S SU030S UT030S UU030S YT030S YU030S

AT035S HT035S HU035S ST035S SU035S UT035S UU035S YT035S YU035S

Not

Applicable

HT025E HU025E ST025E SU025E

HT030E HU030E ST030E SU030E

AT035E HT035E HU035E ST035E SU035E

HT055E HU055E ST055E SU055E

UT025E UU025E YT025E YU025E

UT030E UU030E YT030E YU030E

UT035E UU035E YT035E YU035E

UT055E UU055E

BC – basic electronic, coin NC – NetMaster coin UO – UniLinc OPL BL – basic electronic, central pay NR – NetMaster card WC – network ready coin BX – basic electronic, prep for coin NX – NetMaster, prep for coin WX – network ready, prep for coin BY – basic electronic, prep for card NY – NetMaster, prep for card WY – network ready, prep for card EO – LED OPL OM – OPL micro ZC – NetMaster network coin LC – network adaptable coin QT – dual digital timer ZR – NetMaster network card LX – network adaptable, prep for coin SD – single drop ZX – NetMaster network, prep for coin LY – network adaptable, prep for card SX – single drop, prep for coin ZY – NetMaster network, prep for card

70380401 (EN)

Introduction

Customer Service

If literature or replacement parts are required, contact the source from which the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950 for the name and address of the nearest authorized parts distributor.

For technical assistance, call (920) 748-3121.

Serial Plate Location

When calling or writing for information about your product, be sure to mention model and serial numbers. Model and serial numbers are found on serial plate on rear of machine, and inside door hinge. Refer to Figure 1.

Wiring Diagram

The wiring diagram is located in the junction or contactor box. The wiring diagram part number in the lower portion of the electrical data on the serial plate.

1 Serial Plate

TMB2098N

Figure 1

70380401 (EN)

Safety Information

Indicates an imminently hazardous situation that, if not avoided, will cause severe personal injury or death.

DANGER

Indicates a hazardous situation that, if not avoided, could cause severe personal injury or death.

WARNING

Indicates a hazardous situation that, if not avoided, may cause minor or moderate personal injury or property damage.

CAUTION

Failure to install, maintain, and/or operate this machine according to manufacturer’s instructions may result in conditions which can produce serious injury, death and/or property damage.

W051R1

WARNING

Explanation of Safety Messages

Precautionary statements (“DANGER,” “WARNING,” and “CAUTION”), followed by specific instructions, are found in this manual and on machine decals. These precautions are intended for the personal safety of the operator, user, servicer, and those maintaining the machine.

Additional precautionary statements (“IMPORTANT” and “NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used to inform the reader of specific procedures where minor machine damage will occur if the procedure is not followed.

IMPORTANT: Warranty is void unless tumble dryer is installed according to instructions in the Installation Manual. Compliance with minimum specifications and requirements detailed herein, and with applicable local gas fitting regulations, municipal building codes, water supply regulations, electrical wiring regulations, and any other relevant statutory regulations. Because of varied requirements, applicable local codes should be thoroughly understood and all pre-installation work arranged for accordingly.

NOTE: The WARNING and IMPORTANT instructions appearing in this manual are not meant to cover all possible conditions and situations that may occur. It must be understood that common sense, caution and carefulness are factors which CANNOT be built into this tumble dryer. These factors MUST BE supplied by the person(s) installing, maintaining or operating the tumble dryer.

Always contact your dealer, distributor, service agent or the manufacturer on any problems or conditions you do not understand.

NOTE: The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is important but not hazard related.

70380401 (EN)

Safety Information

Hazardous Voltage. Can cause shock, burn or cause death. Allow machine power to remain off for two minutes prior to working in and around AC inverter drive.

W359

WARNING

Important Safety Instructions

Save These Instructions

1. Read all instructions before using the tumble dryer.

2. Refer to the GROUNDING INSTRUCTIONS for the proper grounding of the tumble dryer.

3. Do not dry articles that have been previously cleaned in, washed in, soaked in, or spotted with gasoline, dry cleaning solvents, other flammable or explosive substances as they give off vapors that could ignite or explode.

4. Do not allow children on or in the tumble dryer. This appliance is not intended for use by young children or infirm persons without supervision. Young children should be supervised to ensure that they do not play with the appliance.

5. Before the tumble dryer is removed from service or discarded, remove the door to the drying compartment and the door to the lint compartment.

6. Do not reach into the tumble dryer if the cylinder is revolving.

7. Do not install or store the tumble dryer where it will be exposed to water and/or weather.

8. Do not tamper with the controls.

9. Do not repair or replace any part of the tumble dryer, or attempt any servicing unless specifically recommended in the user-maintenance instructions or in published user-repair instructions that you understand and have the skills to carry out.

10. Do not use fabric softeners or products to eliminate static unless recommended by the manufacturer of the fabric softener or product.

11. To reduce the risk of fire, DO NOT DRY plastics or articles containing foam rubber or similarly textured rubberlike materials.

12. Always clean the lint filter daily.

13. Keep area around the exhaust opening and adjacent surrounding area free from the accumulation of lint, dust and dirt.

14. The interior of the tumble dryer and the exhaust duct should be cleaned periodically by qualified service personnel.

15. If not installed, operated and maintained in accordance with the manufacturer’s instructions or if there is damage to or mishandling of this product’s components, use of this product could expose you to substances in the fuel or from fuel combustion which can cause death or serious illness and which are known to the State of California to cause cancer, birth defects or other reproductive harm.

16. Tumble dryer will not operate with the loading door open. DO NOT bypass the door safety switch to permit the tumble dryer to operate with the door open. The tumble dryer will stop tumbling when the door is opened. Do not use the tumble dryer if it does not stop tumbling when the door is opened or starts tumbling without pressing or turning the START mechanism. Remove the tumble dryer from use and call for service.

17. Tumble dryer will not operate with lint panel open. DO NOT bypass lint panel safety switch to permit the tumble dryer to operate with the lint panel open.

18. Do not put articles soiled with vegetable or cooking oil in the tumble dryer, as these oils may not be removed during washing. Due to the remaining oil, the fabric may catch on fire by itself.

19. To reduce the risk of fire, DO NOT put clothes which have traces of any flammable substances such as machine oil, flammable chemicals, thinner, etc. or anything containing wax or chemicals such as in mops and cleaning cloths, or anything dry-cleaned at home with dry-cleaning solvent in the tumble dryer.

20. Use the tumble dryer only for its intended purpose, drying fabrics.

21. ALWAYS disconnect and lockout the electrical power to the tumble dryer before servicing. Disconnect power by shutting off appropriate breaker or fuse.

22. Install this tumble dryer according to the INSTALLATION INSTRUCTIONS. All connections for electrical power, grounding, and gas supply must comply with local codes and be made by licensed personnel when required.

70380401 (EN)

Safety Information

WARNING

To reduce the risk of serious injury, install lockable door(s) to prevent public access to rear of tumble dryers.

W055R1

23. Remove laundry immediately after tumble dryer stops.

24. Always read and follow manufacturer’s instructions on packages of laundry and cleaning aids. Heed all warnings or precautions. To reduce the risk of poisoning or chemical burns, keep them out of reach of children at all times (preferably in a locked cabinet).

25. Do not tumble fiberglass curtains and draperies unless the label says it can be done. If they are dried, wipe out the cylinder with a damp cloth to remove particles of fiberglass.

26. Always follow the fabric care instructions supplied by the garment manufacturer.

27. Never operate the tumble dryer with any guards and/or panels removed.

28. DO NOT operate the tumble dryer if it is smoking, grinding, has missing or broken parts.

29. DO NOT bypass any safety devices.

30. Solvent vapors from dry-cleaning machines create acids when drawn through the heater of the drying unit. These acids are corrosive to the tumble dryer as well as to the laundry load being dried. Be sure make-up air is free of solvent vapors.

31. Failure to install, maintain, and/or operate this machine according to the manufacturer’s instructions may result in conditions which can produce bodily injury and/or property damage.

70380401 (EN)

Operating Instructions

To reduce the risk of fire:

• DO NOT DRY articles containing foam rubber or similarly textured rubberlike materials.

• DO NOT DRY plastics, anything containing wax or chemicals such as mops and cleaning cloths, or anything dry-cleaned at home with a dry-cleaning solvent.

• DO NOT TUMBLE fiberglass curtains and draperies unless the label says it can be done. If they are dried, wipe out the cylinder with a damp cloth to remove particles of fiberglass.

W076

To reduce the risk of serious injury, allow cylinder to stop before cleaning lint screen.

W412

WARNING

Emergency Stop Button on CE Models

All CE approved OPL tumble dryers are factory equipped with an emergency stop button located on the front panel. Refer to Figure 2.

Operating Instructions

Step 1: Clean Lint Screen/Compartment

Remove any accumulated lint from the lint screen and compartment. Close panel tightly against tumble dryer frame and lock panel securely, if applicable.

IMPORTANT: Clean lint screen and lint compartment daily. Failure to clean the lint screen daily will result in higher than normal temperatures that may damage laundry.

Step 2: Load Laundry

Open loading door and load cylinder with laundry. DO NOT OVERLOAD.

NOTE: Overloading causes slow drying and wrinkling.

Emergency Stop Button

Figure 2

To operate emergency stop button:

a. Press red emergency stop button to stop all

action.

b. To restart machine, pull red emergency stop

button out and press START pad or button.

TMB1664N

Close loading door. Tumble dryer will not operate with the door open.

Step 3: Determine Control Type and Temperature Setting

Refer to the various controls, pages 9 - 20, follow instructions for the appropriate control type.

The type of fabric being dried will determine the temperature setting. Consult the fabric care label or fabric manufacturer to determine proper temperature setting.

NOTE: Activation of the emergency stop button stops all machine control circuit functions, but DOES NOT remove all electrical power from machine.

IMPORTANT: Always follow the fabric care instructions supplied by the garment manufacturer.

Step 4: Remove Laundry

When the cycle is complete, open door and remove the

laundry.

70380401 (EN)

+ 22 hidden pages

Alliance Laundry Systems HA025L, HT025L, SA025L, SA025N, ST025L Operation & Maintenance Manual

Specifications and Main Features

Frequently Asked Questions

User Manual