Alinco DJ-560E, DJ-560T Service Manual

D J - 5 6 0 T / E

*3r '

Service Manual

In d ex

• SPECIFICATIONS

• PARTS LIST

• CABINET PARTS LOCATION

• ADJUSTMENT ••••

• BLOCK DIAGRAM

.........................

..............................

..........

.........................

......*.................

• SCHEMATIC DIAGRAM OF CPU .UNIT-

• CPU PC BOARD

.............

••••••

• SCHEMATIC DIAGRAM OF IF UNIT

• IF PC BOARD

.........

..........

• SCHEMATIC DIAGRAM OF VCO UNIT --

• VCO PC BOARD-

.......

........

• SCHEMATIC DIAGRAM OF RF UNIT •

• RF PC BOARD

.....•................

a i

.......

....

..........

......

• 1

• • 2

••7

-9 ,

• 1 2

•13 ’

■1.5

•17

•19

•23

•25

•27

2 9

■. Vs>%

> ; v

”

....... ■

ALINCO ELECTRONICS INC-

• = >.s

' V

1 1 "< ' •• ; -':v ’ • ‘ ¡: 1 :

■ ' ■ V : ■ '. ; ■

, v.. .

: ^ \ ' ß

■ ■ : ;T

i|. /'• • ‘ • .

■ SP E C I F IC ATI O N S

■ General

Frequency Coverage...................................See MODEL CHART

Memory Channel Signal Type

Mic. Input Impedance..................................2kQ

Speaker Impedance

Power Supply Requirement......................... D.C. 7.2V

Dimensions.................................................. 169(H) x 57(W) x 32(D)mm (6.65 x 2.24 x 1.23 inch)

Weight.......................................................... Approx. 440g (0.97 lbs.)

■ Transmitter

Output Power............................................... See BATTERY PACK INFORMATION

Modulation System...................................... Variable reactance Frequency modulation

Max. Freq. Deviation................................... ± 5kHz

Spurious Emission....................................... Less than 60dB below carrier

Tone Frequency........................................... 67.0 to 250.3Hz — 38

Operation Mode........................................... Simplex,

........................................

..................................................

.................................... 8Q

42 Channels (VHF/UHF 20 Channels Each & Independent Call Channels) F3

DJ-560T — Subaudible Encoding Tone DJ-560E — 1,750Hz Tone Burst

*CTCSS Decoder is included as standard

Duplex: 5kHz Steps (Minimum) between 0 and 9.995MHz

from receive frequency

*DTMF Encoder is included as standard

■ Receiver

Receiving System

Sensitivity.........................

Intermediate Frequencies

...........

Double-conversion superheterodyne 12dB SINAD less than -15dB^ VHF 1st IF 55.05MHz

2nd IF 455kHz

UHF 1st IF 58.125MHz

2nd IF 485kHz

MODEL CHART

Type DJ-560T DJ-560E

Frequency Coverage

(MHz)

Channel Spacing (kHz) Tone Burst Subaudible DTMF

VHF: 144.000 - 147.995(TX)

130.000 - 173.995(RX)

UHF: 440.000 - 449.995(TX)

400.000 - 519.995(RX)

5, 10, 12.5, 20, and 25 5, 10, 12.5, 20, and 25

Not Available 1,750Hz

Included (Encode & Decode) Included (Encode & Decode)

Included (16 Buttons)

VHF: 144.000 - 145.995(TX)(RX)

UHF:430.000 -439.995(TX)(RX)

Included (16 Buttons)

BATTERY PACK INFORMATION

Battery Pack EBP-10N

(Standard)

EBP-12N

(Optional)

Voltage & Current

7.2V 700mAh

12V 700mAh

Output Power

(TX) (Hi)

2W About 3hrs. E DC-17

5W About 3hrs. E DC-18

Operating Time Selected Charger

(A.C. 220/240V) E DC-21 (A.C. 120V)

(A.C. 220/240V) EDC-22

(A.C. 120V)

Note: The conditions for the above operation time are High output power and the ratio of

TX 1 : RX 1 : Waiting for RX 8. The operating time will be longer at Low output power.

-1 -

■ P ART S LIS T (DJ-560T/ E)

Ref.

Part Code

No.

XA0139

IC1 IC2 XA0108 IC3 XA0019 IC4

XA0019

IC5

XA0105

IC6

XA0106

Ql XT0038 Transistor, 2SA1037KT1146R

XT0077 Transistor, 2SC3326KT1146R

XU0022

XU0012 Degital Transistor,

XU0012

XT0038

Q10

XU0022

Q11

XU0012

Q12

XT0037

Q13

XT0037

Q14

XT0038

XD0040

D2 D3 XD0120 D4

XD0091

XD0040

XD0120

XD0040 D8 XD0040 D9 XD0040 D11

XD0040

RK3001 Chip R, MCR03 OQ

RK3050

RK3038

RK3056

RK3046

RK3050

R10

RK3038

R10 RK3060

R12 RK3050 R13

RK3038 R15 RK3050 R16

RK3038 R17

RK3001

R17

RK3050 Chip R.MCR03 10KQ

RK3073

R18

RK3074

R19

RK3046

R20

RK3058

R21

RK3074

R22

RK3062

R23

RK3062

R27

RK3074

R28

RK3038

R29

RK3038

R30

RK3038

R31

RK3038

R32

RK3058

R33

RK3074

R34

RK3044

R35

RK3044

R36

RK3044

R37

RK3074

R40

RK3054

R41

Part Name and Number

CPU Unit ^ x

IC, HD4074608H \ IC,FX365LGAR )

IC, n PD40948G-T1 IC, uPD4094BG-T1 IC, MC145436DWR IC, S-8054HN-CB-T1

Degital Transistor,

Transistor, 2SA1037KT1146R Degital Transistor,

Degital Transistor,

Transistor, 2SC2412KT1146R Transistor, 2SC2412KT1146R Transistor, 2SA1037KT1146R

Diode, DAN202KT96 Diode, DAN202KT96 Shot Key, MA704WKTX Diode, IMN10T108 Diode, DAN202KT96 Shot Key, MA704WKTX Diode, DAN202KT96 Diode, DAN202KT96 (E only) Diode, DAN202KT96 (T/TW only) Diode, DAN202KT96

Chip R, MCR03 10KQ Chip R, MCR03 1KQ Chip R, MCR03 33KQ Chip R,MCR03 4.7KQ Chip R,MCR03 4.7KQ Chip R, MCR03 4.7KQ Chip R, MCR03 10KQ Chip R, MCR03 10KQ Chip R, MCR03 10KQ Chip R, MCR03 1KQ

Chip R, MCR03 68KQ

Chip R, MCR03 10KQ

Chip R, MCR03 1KQ Chip R, MCR03 10KQ Chip R, MCR03 1KQ Chip R, MCR03 OQ

Chip R, MCR03 820KQ Chip R, MCR03 1M Q Chip R, MCR03 4.7KQ Chip R, MCR03 47KQ

Chip R, MCR03 1MQ Chip R, MCR03 100KQ Chip R, MCR03 100KQ

Chip R, MCR03 1MQ Chip R, MCR03 1KQ Chip R, MCR03 1KQ Chip R, MCR03 1K Q Chip R, MCR03 1KQ Chip R, MCR03 47KQ Chip R, MCR03 1MQ Chip R, MCR03 3.3KQ Chip R, MCR03 3.3KQ Chip R, MCR03 3.3KQ Chip R, MCR03 1MÛ Chip R, MCR03 22KQ

DTA114EKT96

DTC114EKT96

DTA114EKT96

DTC114EKT96

(T/TW only)

(E only)

(T/TEA W only)

(TAE A W only)

Ref.

Part Code

No.

RK3034 Chip R, MCR03 470 Q

R42

RK3026

R43

RK3050

R44

RK3046 Chip R,MCR03 4.7KQ

R45

RK3046 Chip R, MCR03 4.7KQ

R46

RK3042

R47

RK3038 Chip R, MCR03 1KQ

R48

RK3038 Chip R, MCR03 1KQ

R49 R50 RK3066

RK3064

R52

CS0236 Chip Tantal, TMC-M0J685MTR

CU3035 Chip C, CM105W5R102K50VAT

CS0057 Chip Tantal, TMC0J225TR

CS0053 Chip Tantal, TMC0J476TR

C4 C7 CU3052 Chip C, CM105W5R103K25VAT

C8 CU3052 Chip C, CM105W5R103K25VAT

C9 CS0049 Chip Tantal, TMC1C105TR CIO CU3035 Chip C, CM105W5R102K50VAT C11 CU8003 Chip C, C2012JF1E104Z C12 CS0049 Chip Tantal, TMC1C105TR C13 CU8003 Chip C, C2012JF1E104Z C14 CU8003 C15 CU3058 Chip C, GR39CH221J50PT C16 CU3058 Chip C, GR39CH221J50PT

CS0049

C17 C18 CU8003 C19 CU3023 Chip C, CM105CH101K

CU3023

C20

CU3035

C21

CS0050

C22

CU3035 Chip C, CM105W5R102K50VAT

C23 C24 CU3031 Chip C, CM105W5R471K50VAT

CU3035 Chip C, CM105W5R102K50VAT

C25

CU3035 Chip C, CM105W5R102K50VAT

C26

CU3052 Chip C,CM105W5R103K25VAT

C27

CU8003

C28

CU8003

C29

CU3052

C30

CU3031

C31

CU3052

C32 C33 CU3035

CU3035

C34

CU3035

C39

CU3035

C40

CU3035

C41

CU3035

C42

CS0063 Chip Tantal, TMC1V104TR

C43

CU8003

C44

CU3052

C45

CU3043 Chip C, CM105W5R472K50VAT

C46

QC0043 Chip L, NL322522T-2R2M

XB0006 CSB1000J221

XB0005 Ceramic Resonator, 800kHz

X4 XB0001 FAR, C4CA03580000K01R

TS0049 EP0005

LP1

EP0005

LP2

EL0011 LCD UE0103 B-B Housing, 52022-2810

CN1

UP0177 CPU UNIT ST0023 LCD Flame DH0005 LCD Reflection Board FG0053 Rover Connector EY0003 ED0005 Lithium Battery YZ0058

TZ0024 TS0048 CPU Shield

TS0045 IF Earth Hardware

Part Name and Number

Chip R, MCR03 100Q Chip R, MCR03 10KQ

Chip R, MCR03 2.2KQ

Chip R, MCR03 220KQ Chip R, MCR03 150KQ

(T/TW only)

(TAW only)

Chip C, C2012JF1E104Z

Chip Tantal, TMC1 Cl 05TR Chip C, C2012JF1E104Z

Chip C, CM105CH101K Chip C, CM105W5R102K50VAT Chip Tantal, TMC1A475TR

Chip C,C2012JF1E104Z Chip C, C2012JF1E104Z Chip C, CM105W5R103K25VAT Chip C, CM105W5R471K50VAT Chip C, CM105W5R103K25VAT Chip C, CM105W5R102K50VAT Chip C, CM105W5R102K50VAT

Chip C, CM105W5R102K50VAT Chip C, CM105W5R102K50VAT Chip C, CM105W5R102K50VAT Chip C, CM105W5R102K50VAT

Chip C, C2012JF1E104Z Chip C, CM105W5R103K25VAT

(E only)

CPU Front Shield Lamp, 23-BR-5V60 Lamp, 23-BR-5V60

Mic Unit

Solderd Plating Cable

0. 4 0 1mn

Lithium Insulator

IF Unit

XA0070

IC1

XA0070 IC, MC3361DT

IC2

IC, MC3361DT

Ref.

Part Code

No.

IC3

XA0068 IC, M5218FP-T01-1

IC4

XA0111

IC5

XA0019

IC6

XA0104 IC, M5236ML-T73A-36

XD0118 Shot Key, MA716-TW

XD0040

XD0118 Shot Key, MA716-TW

XD0040 Diode, DAN202KT96

XD0118 Shot Key, MA716-TW

XD0040 Diode, DAN202KT96

D10

XD0118 Shot Key, MA716-TW

Dll

XD0041 Diode, DAP202KT96

D12

XD0104

D13

XD0041 Diode, DAP202KT96

D14

XD0040

D15

XD0110

D16

XD0041 Diode, DAP202KT96

D18

XD0118

XT0081

XT0037

XU0026

Q5 XU0017 Digital Transistor,

XT0036

XT0081

Q10

XT0037

Q11

XT0037

Q12

XT0037

Q13

XT0036

Q14

XT0036 Transistor, 2SC2413KT146R

Q15

XU0017 Digital Transistor,

Q18

XT0088

Q19

XT0037

Q20

XU0002

Q21 XT0088 Q22

XT0088

Q23

XU0027

Q24

XU0026

Q26

XU0027

Q27

XU0017

Q28

XT0037 Transistor, 2SC2412KT146R

Q29

XT0088 Transistor, 2SA1213YTE12L

Q30

XT0057 Transistor, 2SB1184F5T200Q

Q31

XU0002 Digital Transistor,

Q32

XU0002 Digital Transistor,

Q33

XU0002 Digital Transistor,

Q34

XU0012

Q35

XU0012 Digital Transistor,

X1 XQ0041 X2

XQ0039 UM-1 54.595MHz

CFÎ

XC0005 Ceramic Filter, CFUM455E

CF2 ■

XC0004 Ceramic Filter,CFWM485F

VR1

RV0014

VR2

RH0059 VR, MVR32HXBN223

VR4

RV0015 VR, RK0972210(10KB X 2)

VR5

RH0059

VR7

RH0060 VR, MVR32HXBN473

VR8

RH0060 VR, MVR32HXBN473

VR9

RH0060 VR, MVR32HXBN473

UR0005 Rotary Encoder, EC09P20-04L20

QC0037

QA0044

QC0037

QA0044

QC0039

Part Name and Number

IC, NJM2073M-T1 IC, M PD40948G-T1

Diode, DAN202KT96

Zenner, 02C26-2YTE85L

Diode, DAN202KT96 Diode, IN5551

Shot Key, MA716-TW Transistor, 2SC2714YTE85L

Transistor, 2SC2412KT146R Transistor, 2SC2412KT146R Digital Transistor, FMG2XT98

DTA114EKT146

Transistor, 2SC2413KT146R Transistor, 2SC2413KT146R Transistor, 2SC2714YTE85L Transistor, 2SC2412KT146R Transistor, 2SC2412KT146R Transistor, 2SC2412KT146R Transistor, 2SC2413KT146R

DTA114EKT146 Transistor, 2SA1213YTE12L Transistor, 2SC2412KT146R Digital Transistor,

DTC114YKT146 Transistor, 2SA1213YTE12L Transistor, 2SA1213YTE12L Digital Transistor, FMA7XT98 Digital Transistor, FMG2XT98 Digital Transistor, FMA7XT98 Digital Transistor,

DTA114EKT146

DTC114YKT146

DTC114YKT146 Digital Transistor,

DTC114EKT146

UM-1 57.64MHz

VR, RK09722115R1211 (10KBX2)

VR, MVR32HXBN223

Chip L,NL322522TR68M 455kHz IF Coil-T Chip L, NL322522TR68M

45 5kHz IF C o i l - T

Chip L, NL322522T1 ROM

33 AJ -O 33 Ai iX3 ^D 33 33 *Xj Ai -AJ A) 33 JJ A) Ai Ai Ai Ai Ai Ai -AJ Ai 33 Ai Ai Ai Ai _AJ -AJ t t c o c i o r o r o H ^ ^ ^ m o i m m o j o j o i Q C K r o w w w w w w a i u i a i ^ j i . ^ ^ ^ ^ N O J ü j a j o a w c o u o j ü j f o f o c n > a o M - ‘ [ û ^ - ^ o c D o o ^ O ) a i > W M - ‘ O C D œ - ^ cn i u i^ cj jr o -‘ C Dœ -Ni a)ai -‘ OC DC)o-Îj®aiGol:o -* ' i ''':'' ;"

3333333333 33 33 33 33 3 33 33 33 33 X I3 33 33 33 3 33 3X 33 3 33 )3 ]3 )3 33 )3 33 ]J )

OCüCD'slOJCJI^COM —‘ OCDC D'vJOJCn^WNJ —k i—->

P 2.

3 3? 2 22 2 22 :XI:l3:O2 2 2 2 33:D3,:D:xl33:3033^3)3, 3,::o:3D3333:II:D33:n:D:n:D':D:D:l0303J:D3J33^ 3J333]:D^^333333333^^333)33333]33333)3J333)333]

^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^ ^

CjUUWWWUUOJWtJWWUWWUWWaJWUOJCOUCOWUWWWOJWWUWWCOUWWCOCOWWWWWOJUWUUWWUCOOJÙJUWWUUWWUCJWOJWUW OOOpOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOOO.OOOOOOOOO

^ -v j C T O ) a ) ^^ ^ . ^Q ^ M a ia i c ri c ri ü ia ) ai o j^ c r )a i ^ cr i w ^ .- N i^ o ) u io i ^a i a ia ic r ) aí M a i u i! X ia i a )C T ) a iC T )í í .c D - v iM a ia i ai ^ a ir o K ) ai a iW í >. 0 ) ^. a ic o ^ -~ s i ^a 5 u i co ^ M S J C 0 f O M a ) O ) a ) M K 3 - * M O ^ O O O - ‘ O U O ) -v |O M a )a ) K )O N ) M O 0 0 ^a ) 0 0O a i- v |( D O 00 a )! O N 3 N )0 Ú K ) N )M - ‘ N 3 O ^ O 0) O M N )C D O ^ a )- N |N ) O 0 0 N 3 O N )N )O a )M

o o o o

o o hO hO

o o

—» o —‘ ‘ ro en ro ro

-< O -< -<

o —* o o

^ ^ tvj ro rvj

>95 9

' ë’ ë‘ -6'

3 33 33 33

9 9 9 9 9 9 9 9 9 9

■o' ë -o’ ë’ ë ë' ë' ë' ë' ë'

o —i o o o o <

sa 8 e sgi

o 03 —‘ —*• —‘ —»

—‘ I—' O O O O

ro - en e n en en

-< zd ^ o o o

- * 2 a i X I I

m O 33 ‘ ^

-* o - * cn o -si

O t— O OOCT 3 íi N N t: t: ro ro

— o t O —*■ i

cn r o -

-< -< ■

cn —k : < m <

o o

^ -P*. ro ro

» —i o » 3 o

O CO —J

DDO DDDD

9 9 9 9

ë'ë'

ë’ "ë" -ë' ë'

§*

* o o o o

en cn en cn

!3i3i3i3ï

) < 33 33 33 k ^, —k —k co

> o I

: —*i o o co

' W M M N3

-t* -t* <

-~j rvi :

) hxl ^ ^ ^

9 9 9 9 ë'ë'ë'ë'

33 33 33 33 33 33 33 o o o o

33 33 33 33 0 0( 00

CO CO CO CO

-P* —‘ OO —J

-O O O O

t : ?: t ;

o o o o

9 9 9

ë'ë'ë'

o o O ( 33 33 33 :

O O CD ( CO CO CO (

— ro

co o —j

O ^

ODO

9 9 9 9 9 9 9

ë’ -ë'

ë' ë' -ë' -ë’ -ë' -ë' ë’

o pO —I o o o o <

o o o o o o o

2 M 2 K) m 2 2

—‘ O —k O O —k —k

O O

o —‘ O —‘ ‘ o o

cn ro cn ro ro cn cn

en cn

< -< Í -< HC S «

ai -* ai -* —* a i a i

33 m 33 m rjl 33 33

o —*

o o o o o o o

ro ^

CO -pi. CO 4^ -P* co co

101 ^ r^i ivj ^ ^

ë'ë'

3) 3)

ro cn O 05 ?; ^

D D

9 9 9 9 9 9

1 9 9

ë ' ë '

ë ' ë ' ë ' ë ’ ë ’ ë ’

1 33 33 33 33 33 33 33 33 33

S 33ñ33

33 i l i CO CO CO CO CO

; — —ro— ! ° » D D

---- IO) —‘ O C D 0 0 ' v | a 5 a i W M - * O C D 0 0 - s | O C D 0 0 ^ C D U l i k C 0 K ) - ‘ O

999999999 99 99999 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9

ë' ë' -ë’

33 33 33 S z z

o o o 33 33 33 O O O

CO CO CO

—k o •

O O —-J - - _

O D D

O D D D

k _* _k —k —k —L —* —.. —k —k __k —L __k ___ __

ë ‘ë '

33 33 S

O 33B33

CO CO co co CO CO CO CO CO CO CO co co COCOCOCO CO CO CO CO CO

•U.

— -P*.

-o ro D DDD D

O rr

ë '

3=§2:

33 g3Tg COcoCOCOco en -fc* o O ro o

D D D

ë ’ë - ë ’ë*

33 333333 33 33 33 33 33 33 33 33 33 33 33 33 33

S O

ro ro

£3 D D D D D D

9 9 9 9 9 9 9 9 9 9

9 9 9

H •

ë ’ ë ' ë ’

33 333333 33 33

ë'

S O 33

ë ’ ë ' ë ' ë ‘ ë ' ë ; ë ‘ ë ' ë ’ ë '

33k33

CO CO CO

~v|

4*.

D D

D D DDO O

ë ë ë 'ë'ë ’

■S

33S33O33

g g — o O

3) 33 3) 33 33 33 33 33 33 33 sr

3Tg3T

,2: O 33

CO CO

o o ro

k —k —k —k —k —k —k —k

ë ' ë ' ë ’

S O

— CO ro ro

D D

33'

33k33

33 CO CO CO CO ro ro

O O

ë ’

ë ’ë'ë ’ë * ë ' ë ’ë ' ë - ë ' ë ’

o o OO

. _

*-o

D D D

O 2T

9 9 9 9 9

ë ’

ë ' ë ' ë ’ ë ' ë ‘

33 33 33

S O 33

—

S g

33 CO CO ro ro

D o

__k __k __k __k co cd CD CD CD CD CD CD CD CD OO OO

p j

s o 33

D DDD

S —

-p*. o ro O O

D D O

33 3) 33 33

33 33 S

g g

_ _ .

g—g

D D D D

>9 9 9 9 *

ë ë ë - ë ’

33333 33 s

33 CO CO CO CO

ro N3

D 10 D D

-P‘ +:* -f *- 4^ + iU ¿ U3 C O CA J C OC O C O CO C O CO r Or o ro rO r Or or O rO r Or O —‘ —» —‘ —1 —- —k —k —‘ —‘ —»C 0 0 0- ^ 0 )U 1 4 ^ C O |S 3 —» 5 t O N J - ‘ O C D O O - > J O ) ü l ^ U r s 3 - ‘ O C D C D - > J O )ü l JS k C ü K ) -‘ O C D O O - > j a ) ü l ^ W N 3 - > 0 C O W C O N3 K ) K ) K ) M M h O K ) M - ‘ - ‘ - - O O O O O O O O O o S o D - Í j O ) ü l S c ! o M - - o S - > J

O O O O p p p p p p p p p p p p p p p p O O p p p p p O p p O p p p p p 0 0 0 0 0 0 0 0 2 2 2 3 3 ^ 3 ^ 3 3 3 3 3 3 3 3 X 3 3 3 0 3 3 3 3 3 I 3 ) 3 ] 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 ] 3 3 3 ] 3 3 3 ] 3 3 3 ] 3 3 3 ] 3 3 3 3 3 3

8 § S g g g g g 5 g 5 g § 5 S g g 5 5 g g g g g g g g g g g S g g g g § S § g g g g g g g s S 5 3 S S S S S S S S S S ä S S S S S 5 S 5 S S S S S 5 S 5 S S S 5 S S g g S SS S g S 8S S g S S H g gg S S gg 2 22 g g g S gg g SS g S S gS g S g g g SS g eS S S S SS S g S SS S S S 5g S S g e ,í 5í 5 í5 S g SS S S S gS S g

CD <D CD CD —‘ —» CD Cn Cn ^ CO CD CTI CH CD CD O CD CD CD ~v| CD CO

99999

ë ë ëë ë

—» —* o en ^

O O Ol > CT) O) —I —I

S 33E33

*¡

s; 3 33

ë '

ë ' 33 33 33 S

33S33

CO CO CO

ë '

ë ‘

3)3333 33

S O 33E33

D?:D D

ë ’

CO CO O

ë ‘

S O 33

cn 05

9 9 9 ë’ ë' ë'

ë '

z z z z z z

o o o o o o

33 33 33 33 JO 33

—» KD —1 —» -

*7Q

9 9 9 9 9 9

ë‘ ë’ ë' ë' -o' ë’

SgS O 33

CO CO CO

— D O

§ 1 co CO CO

en en

ë'

33 S

O 33

33 33

CO CO O CD

O O

o zr

ë '

33 33 O

D D

X X

co co

o o CD O

o o

-'s! ~v|

□ -i

ë ’

3 3 .

H- H -

(/) C/> z: o

o o

ro ro

CO CO

o o

C 3 C T

o o o o o o o o o o o c ^ o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o Q p p p p o p p p p o p p o

—» —» —» —k —k —k —k —k _k _k _k _k _k _k —k _L —k —k —k —k —k —k —k —k —k —k —k —k —k —k —k —k —kCDCDCDCDCDCDCDCD cd cd oo oo oo oo co oo -vi —j-o —>j— >j—J-0050505050505050505 o en en en cn cncnc ncncncncn^^i

ucoo)CA)MivjN )Njf1o WN3 MNj - * _ k - . _ - k - . - . - k - * - > - o o o o o o o o o o c o - > i a 5 c n ^ c o r s 3 - ‘ O CD Oo >i o)c n- ‘ 0 OO '«i O5 cn ikt jji o-‘ O C DO û '> i ®c n ^t jJ M -‘ O(D Oo> i'siO) cnik CON 3-‘ O O)cn >f O -* OC O O O >| (T )ü l^ M -‘ OCOOO^ItJ)UlikCOCOrs3-‘0 00 '> |0) CJ lik CO M -* 0

P P Q O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O P O O O P O P P P P c c c c c c ç c c c c c c c c r n c c c c c M c m c w c c c c c c c c c m c c M C M c m c m c M a î c c c c c c c c w c c c ç c w c ç M c c c c c c

COCJCOCOCOCOCOCOCOCOCOCOCOCOCOOCOCOCOCOCOOCOOCOOCOCOCOCOCOCOCOCOCjOOCOCOOCOOCOOCOOCOOOCOCOCOCOCOCOCOCOOCOCOCOCOCOOCOCOOCO co co co co co

o p o o o p o o o o o o o o o c o o o o o o o o c o o t s o o o o o o o o o o c o o o o o o o c o o c o o o o o o o o o o o o o o o o o p p p p o o p o o o o

üi u o) N 3M fo i s3 co c o co m c nw a )c n -‘ c n cj i W ü iC A )ü i w - *w o c nw c n co a i C ûw c o co - * w w c n w ü io i -* c ji - ‘ ü iü i ai c jic o cù - ‘ U ia )o iü ic nc ji -‘ - ‘ O c n u i c n a i O ) K > w w ^ u N

+^ c n —‘ c o c o c o c o c n c n c n —k C O cn c n c D cn c D ro c n r o cn o oc n cn c n c o ro c n ro c n co —» —‘ cn cn cn en —‘ ~>i —i w c D c n c û U i 0 O O C D C n c n c D C D O C D ( D > l c D C o c D O 3 a 5 O 0 - ^ w w a iu i —‘ en o

999

9 9 9 9 9:

6-6«'

ë'ë ë'ë'ë' '

O O O

O O O O O <

2 2 2 2 2 2 2 2 2 2 2 ^

o o o o o cn cn cn cn cn

^ « o

O O Q O « en en X 33 33 N)

ro —* ~j ro o -k co t o X

t: X

9 9 9 9 ë'ë‘ ë’ë'

p o p p

—k —k o O O O —■‘ an cn cn ro

o o —^o m ro 4^

^3 ^

9991

ë’ë-ë-;

o o o '

8 8 8 1

O O O cn cn cn « « -< cn cn cn 33 33 <

399

6-ß-

o —*■

—k —k o

ct> ro cn

O -< æ < cn

CD O O <

^ co r

rvj ^ ;

9 9 9 ë’ -ë’ -ë’

o o o

§ §2

o o o cn cn cn

?n ^ ^ 33 33 33

99!

ë‘ -ë’ !

—i o '

I ß f

tu —‘ - t—' O 05 (

cn o «

-j ^ : 3¿ en ^ ( O 33 ->l

O —» CD > C_ O i ^ ro : ->l ^

9 9 9 9

¡99

ër-ë-

ë-ë’^-ë’

0 —1 0 0 0 0

o o o o co ro co ro

^ ^ ^ 7K.

ëë-

o o

i o o i cn en : -< ^ i cn en

o "J ro

9 99 H

ë’ -ë’ ë‘ 8

o o o

* ' ‘

en en en < 33 33 33 ^

^ ‘ ‘ ~-l

~v| O O OD —‘ ro isa

9 9 9 9

ë‘ ë’ ë‘ ë’

O O -H O —I O

—k —k Q) —k (

O O I—1 o t

cn cn - « «

en en __ 33 33 O 33

—k .p*. o -t*. O S L S ho —‘ ho —‘

9 9 m 9 m 9

ë-ë-8 ë-8 r

, ? o f o § § MTJ •

< —k 05 —■k

ro o ro

!- < <- <

05 —k I—1 h-' O O

----- _

O 3 3 0 m - - - im - o m o o < 3 )

' ■ ^ O —k Œ3 —‘ 03 —* —‘ —» —k —»

: t: ro

o D o ro h- M o û ) o

ho - ro

- Ë - m o m

9 9 9

ëë ’ë-

2 2 2 2 % 2 2

o o o en cn cn o o o X X I —k 4^ o en -o en o o o

------

9 9 9

9 9 9 9 9 9 9 9

ë’ ë" ë’ ë’ ë’ ë‘ ë‘ ë‘

ë-ë‘ë‘

O —I —I O O O O O O O O —I O O O O

. 8 8 8 8 S 8

Q) —k —k

m ’ - en en

O' >

3> o o

-Ci. -pk ro —j ro —

o o

o — o

—- o —- ro en ro

-< o -< — ni —* m ro m —k ro —»

o — o

-t*. ^ -1^.

n n ro N

9 9 9 9

ë’ ë’ ë‘ ë‘

o —i o o

O I—1 o o en * en cn

cn 5 cn en < O < 33

^ —k _k ro

o > o ro

. o

co 4^. -Ê* co n o n t ;

9 9 9 9!

ë‘ ë’ ë’

—i o o o o <

i cn cn cn — 33 33 ZO o —* —- co

—k o o co

^ rso ro> ho

o o o o o o o o o o o o o o o c z c r o o o

c o c o c o c o c o c o c o c o c o c o o o o o o o o o o o r o c n c n c n c n c n c n c n — -t*

03N3CD(DMN)(DN)tûCO

999999999

9 9 9

ë-ë-ë-ë*ë’ë-ë-ë*ë-

ë-ë’ë-

o o o o o o o o o

p o p

O —‘ — o — — —

i §

—k o O —‘ o o o

o —

ro cn cn ro en cn cn

cn ro

-< « sg -< Æ o sg

s e e

— CD OO O —‘ —»

-* en cn -* cn i cn

□ 2 3 □ 5 ^ ^ O O O O o O ~v|

o o

^ CO CO ^ CO 7C N)

CO -E*.

ro ^ ^ rsj ^

^ ro

z £ ? %

Ref.

Part Code

No.

CU3035

C135

CU3035

C136 C137 CS0235

CS0235

C138 C139 CU3035 C140 CU3035 C141 CU3035

CU3035

C142 C143 CU3035

C144 CU3035

CU3023

C146

UE0039

CN6

UA0028 UE0106

UE0104 TS0044 TS0050

UU0011

SW1

UU0011

SW2

UU0011

SW3

UE0123

CN7

RK3031

CU3031

C35

CU3035

C36

CU3035

C37

CU3035

C38

XT0090

Q3 Q4 XT0030 Q5 XT0082

XD0077

QA0063

QK0081

L3 L4

QC0010 L5 QC0010 L6 QC0010 L7 QC0003

UT0019

TS0039

RK3046

R4 R6

RK3050

RK3062 RK3038

R8 R10 RK3062 R11 RK3026

RK3036

R12

RK3046

R13 R14 RK3022 R15 RK3026 R16 RK3050

RK3054

R17

R18 RK3030 R19 RK3052

CS0058

Cl C2 CU8003 C4 CU3035

CU3052

CU3035

CU3052

CU3035

C10

CU3052

C11

CU3035 CS0063

C12 C13 CU3003 C14 CU3052

C15 C17 C18

Ref.

No.

Part Name and Number

Chip C, CM105W5R102K Chip C, CM105W5R102K Chip Tantal, TMCM1V334MTR Chip Tantal, TMCM1V334MTR Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105CH101K

Housing, T2L-P02P A1 FFC 20Pin 24frm B-B Connector, 50020-8114 B-B Wafer. 53020-2810 VOL Earth Board

IF Spring

Q3 Q4 XT0035 Q5

D2 D3 XD0098 D4 XD0098 D5 XD0098 D6 XD0098 D7

S w i t c h U n it

Tact Switch. SKHMPU Real Tact Switch, SKHMPU Real

L3 QC0039 L4 L5

Tact Switch, SKHMPU Real

L6 QC0067

Pin Header. TZL-P05P-L1 UT0019

Chip J, MCR03 0Q (T only) Chip J.MCR03 0Q (T only)

R7 Chip C, CM105W5R471K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105W5R102K

R9 R10 R11 R12

\ / m 1 Init

Transistor. 2SC2411KT146Q Transistor, 2SC3356T1BR25 Transistor,2SC3120TE85L

Varicap, 1SV161TPH2 Varicap, 1SV161TPH2

R13 RK3022 R14 RK3042 R15 RK3042 R16 R17 R18 RK3046 R19 R20 RK3050 R21 RK3022 R22 RK3051

VC0 Coil Aire Core Coil, 0.4-1.5 X4T

R23 RK3046 R24

Chip LMLF3216E100M Chip L, MLF3216E100M Chip L, MLF3216E100M Chip L,MLF3216A1ROM

PC Board Terminal

VCO Case, 560

Chip R, MCR03 4.7KQ Chip R, MCR03 10KQ Chip R.MCR03 100KQ Chip R, MCR03 1KQ Chip R, MCR03 100KQ Chip R, MCR03 100Q Chip R, MCR03 680 Q

Chip R, MCR03 4. 7KQ Chip R.MCR03 470 Chip R, MCR03 100Q Chip R, MCR03 10KQ Chip R, MCR03 22KQ Chip R, MCR03 220 Q Chip R, MCR03 15KQ

C1 C11 CU3027 C13

C14 CU3008 C15

C16 C17 CU3016 Chip C, CM105CH270K C18 CU3005 C19 CU3002 Chip C, CM105CH010C (E only) C20 C21 C22 C23 C24 CU3002 C25 CS0049 C26 CU3035 C27

C28 CU3035 Chip C, CM105W5R102K C29 CU3002 C31 CU3035 C32

Chip Tantal, TMC0J685TR Chip C, C2012Y1E104Z

Chip C, CM105W5R102K Chip C, CM105W5R103K

Chip C, CM105W5R102K Chip C, CM105W5R103K Chip C, CM105W5R102K Chip C, CM105W5R103K Chip C, CM105W5R102K Chip Tantal, TMC1V104TR Chip C, CM105CH020C Chip C, CM105W5R103K

IC1 IC2 IC3

IC4 Q3

Q4 Q5 Q6

Part Code Part Name and Number

CU3023 CU3035 CU3035

Chip C, CM105CH101K Chip C, CM105W5R102K Chip C, CM105W5R102K

n r n iinit

XT0035

Transistor, 2SC3429T85R Transistor, 2SC3429T85R

XT0030

XD0098

Transistor, 2SC3356T1BR25

Varicap, 1SV153TPH2 Varicap, 1SV153TPH2 Varicap, 1SV153TPH2 Varicap, 1SV153TPH2 Varicap, 1SV153TPH2

XD0040

QK0087

Diode, DAN202KT96

Aire Core Coil,

0. 45-2.0X4. 5T

Chip L, NL322522T1 ROM QC0039 QK0082

Chip L, NL322522T1 ROM

Aire Core Coil,

0. 5-2.0 X3.5T Chip L, NL322522TR10M PC Board Terminal, CK-1-2

TS0032A

RK3042 RK3042 RK3032

RK3048 RK3028 RK3050

VCO Case, 460SX

Chip R, MCR03 2.2KQ Chip R, MCR03 2.2KQ

Chip R, MCR03 330Q Chip R, MCR03 6.8KQ Chip R, MCR03 150Q Chip R, MCR03 10KQ Chip R, MCR03 47Q Chip R, MCR03 2.2KQ Chip R, MCR03 2.2KQ

RK3050 RK3032

Chip R, MCR03 10KQ VR3 RH0038 Chip R, MCR03 330Q VR4 Chip R, MCR03 4.7KQ

RK3028

Chip R, MCR03 150Q TC4 CT0012 Chip R,MCR03 10KQ TC5 CT0012 Chip R, MCR03 47 Q TC6 Chip R, MCR03 12KQ TC7 Chip R, MCR03 4.7KQ

RK3022 Chip R, MCR03 47Q

CS0057

Chip Tantal, TMC0J225TR L5 Chip C, CM105SL221K L6

CU3057

Chip C, CM105CH130J L7

Chip C, CM105CH070C L9

CU3035

Chip C, CM105W5R102K

CU3035 Chip C, CM105W5R102K

Chip C, CM105CH040C

CU3010

CU3011 CU3035 CU3035

Chip C, CM105CH090C Chip C, CM105CH100K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105CH010C Chip Tantal, TMC1C105TR Chip C, CM105W5R102K

CU3035 Chip C, CM105W5R102K

Chip C, CM105CH010C Chip C, CM105W5R102K

CU3035

Chip C, CM105W5R102K

R F U n i t

XA0069

XA0044 XA0103 XA0103

XE0015 XT0036 XT0036 XU0017

IC, M57797MA IC, M57796MA IC, MB1501PF-BND-TF IC, MB1501PF-BND-TF

FET, 2SK302YTE85 Transistor, 2SC2413KT 146P Transistor. 2SC2413KT146P Digital Transistor,

DTC114YKT146

Ref.

Part Code

No.

XU0002

Part Name and Number

Digital Transistor,

DTC114YKT146

XT0030

Q10

XT0048 XT0030

Q11 Q12 XT0030 Q13 XU0002

Transistor, 2SC3356-T1BR25 Transistor, 2SC3356-T1BR25 Transistor, 2SC3357-T1 RE Transistor,2SC3356-T1BR25 Transistor, 2SC3356-T1BR25 Digital Transistor,

DTC114YKT146

Q14

XU0002

Digital Transistor,

DTC114YKT146

Q15

XT0030

Q16

XT0030

Q17

XE0015

Q18 XT0048

XT0030

Q19 Q20 XT0082 Q21 XU0017

Transistor, 2SC3356-T1BR25

Transistor, 2SC3356-T1BR25 FET, 2SK302YTE85 Transistor, 2SC3357-T1RE Transistor, 2SC3356-T1BR25 Transistor, 2SC3120TE85L Digital Transistor,

DTC114YKT146

Q22 XU0002

Digital Transistor,

DTC114YKT146

D2 XD0066 D3 XD0040 D4 XD0040 D5

XD0061

XD0066 D9 XD0066 D10

XD0066 D14

XD0066 D15

XD0066 D16 XD0066

Diode, RLS135-TE-11

Diode, DAN202KT96 Diode, DAN202KT96 Diode, DAN204KT96 Diode, RLS135-TE-11 Diode, RLS135-TE-11 Diode, RLS135-TE-11 Diode, RLS135-TE-11 Diode, RLS135-TE-11

Diode, RLS135-TE-11

D17 XD0077 Varicap, 1SV161TPH2 D18 XD0077 Varicap, 1SV161TPH2 D19 XD0077 Varicap, 1SV161TPH2

VR1 VR2

RH0037 RH0036

VR, CVR-42A-471AW1D VR, CVR-42A-102AW1D VR.CVR-42A-473AW1D

RH0038

VR, CVR-42A-473AW1D

T r inroer Condenser, CTZ-10AW Trinner Condenser, CTZ-10AW

CT0012

QA0064

L3 L4 QA0064

QA0064 QC0003 QC0016

QK0012 L10 QK0012 L11 QK0012 L12 QK0012 L13 QC0013

L14 QC0012 L15 QC0012 L16 QK0012

QK0047

L17

QK0047 Air Core Coil, 0. 5-2. 2X3. 5T

L18 L19 QK0047 L20

QK0048 L21 QK0074 L22 QA0065 L23 QC0003

QA0065

L24 L25 QA0065 L26 QA0064

QA0064

L27

L28 QA0064 L29 QK0012 L30

QC0013

QC0047

L31

QK0079

L32 L33

QC0013 QC0015

L34

QC0003

L35

L36 QK0012

J1 RK3001 J2 RK3001

T r irrnier Condenser, CTZ -10AW T r immer Condenser, CTZ-10 AW

Filter Matching Coil Filter Matching Coil Filter Matching Coil Chip L, MLF3216A1 ROM

Chip L, MLF3216A2R2M

Air Core Coil, 0. 4-2. 0 X 2. 5T Air Core Coil, 0. 4-2. O X 2. 5T Air Core Coil, 0. 4-2. 0X2. 5T Air Core Coil, 0. 4-2. 0X2. 5T Choke Coil, LAL021R0M Choke Coil, LAL02NA4R7M Choke Coil, LAL02NA4R7M Air Core Coil, 0. 4-2. 0X2. 5T Air Core Coil, 0. 5-2. 2X3. 5T

Air Core Coil, 0. 5-2. 2X3. 5T Air Core Coil, 0. 5-2. 2X4. 5T Air Core Coil, 0. 4-1. 6X9. 5T Front End, BPF Chip L, MLF3216A1R0M Front End, BPF Front End, BPF Filter Matching Coil Filter Matching Coil Filter Matching Coil

Air Core Coil, 0. 4-2. 0 X 2. 5T Choke Coil, LAL021R0M

Chip L, NLF322522T4R7M Air Core Coil, 0.4-2. 6X6T Choke Coil, LAL021ROM Choke Coil, LAL02R22M Chip L, MLF3216A1 ROM Air Core Coil, 0. 4-2. 0X2. 5T

Chip R, MCR03 0Q Chip R, MCR03 0Q

- 4 -

O CD CN '—

QC O QC O

CN OC

X LO L O » : LO LO l O O <

I o o o o o o o o o

o o

.a .a

a .a .a a

¡ 5 o 5 o

LO LO LO CNI *— CNI LO CD

•-conoco ocooo

O O C D C D C D C D C D C D C D c o c o c o c o c o c o c o c o c o = > = > = > = > = > = > = > = > = >

o o o o o o o o o

» o

C D N C O ' - ^ f L f l t D N N LO LO LO CD CD CD CD CD CD

DCZ

o o o o o o o o o

a a

co0CO0COOCO0CO0CO CO QC

QCyQC

'S.

QC OC

.a .a .a .a .a .a .a .a .a .a

555555555555JZ055555

CNI OO O CNI CNI CNI CD CD ''3' CD CD CNI CO CO CD CNI CNI CNI I CNI CO CNI CNI

o o o o o o o o o o o o coc oco coco coc ococ oco coco

QC QC QC QC QC QC QC QC QC QC QC QC

OJ o O Ç O Ç

O O o o o o

'— LO CD LO

OC O O ^ O ^

; £ 5 5 < 5 <

I LO LO LO I— LO I— > O O O ' O '—

.a .a .a 5 5 5

aaa a a a a

0 0§0

—

QCyQC

QC QC

S .

0 0CO0

QC QC QC

OQCO

QC QC OC OC

CO0CO

o cm CN o ç i

O O O O O O O I 0 QC ^ ÜC O 5

1 lo > i Ln i P :

o ^ o o ^ o <

LO LO '— LO LO LO I— I O O _ O O O

I I ^ Ü S

.a .a i .a .a .a 5 5 5 5 5 5

00 LO CO CD LO CO

o co en -- en o

CD CD O CD CD CD co co c d co co co

=> => LU = > => =>

CJ) CJ) CJ CJ> CJ> C->

OO CD O «— CO CD CD I"-- I"- h- !■"-

o o o o o o

O a

CO0CO

QCOQC

QC OCQCOC OC QC QC

■ rH

• rH

'— *— '— CNJ

» o o o

a a a Cl

0 0

• H

o o o o o o

QC QC QC QC QC QC

0 0

c r

QC QC QC QC OC

■ H

.a .a

^ ^ ^ ^

i ^ sé: : CN CN CN ü

» o o o o

; 5 5 5 O

■ LO LO LO 3=

. » BE » O

-----

a a a a a a a a

■ rH

- LO LO LO LO ' O O O O

0 0 0 0 0 0 0 0 0 0 0 0 0 0 ; <J cj <J cJ o o o o o cJ cJ cj cj <J <

a a q.

• rH • H

5 5 5

■^r lo lo

r— r— r—

o o o

q a aq . aq .a a aa . aQ .a q.

■rH -H ■ rH ■ rH -rH • rH -r—I ■ r—I ■ r—I ■ r—I • rH 1 rT • r—I ■ H ■

5 6 o â à â 5 o ü 6 â â à â i

L O L O L O L O C D L O L O C D L O L O C O L O L O C D C D

c oc o co o--c oc o ^c o or -n (io o^

O O O O O O C D O O O O O O O O c o c o c o o o o o c o c o o o c o c o c o o o o o o o c o

n a n D D D D D n n D n D D D

o o o o o o o o o o o o o o o

CDf— OO CD O 1— CNI CO LO CD I— OO CD CD

CM 1—1

CM CM CM

COOco0co

OCOO

QCOQC

zs .

• H

■ H

5 5 5 5 5

LO LO LO LO LO CD LO LO LO LO

o o o o o o o o o o cococo coco cocococo co

ic : ^ ^ ^ ^ ^ QC QC QC QC QC QC QC QC QC QC

O CM CM CM CM

OJ CM

CO CO

O O

QC QC QC

QC OCOCOC

.a . a .a

55555 5 5 5 5

CN (

O CD <

5 : t

a a a

OJ CM CM

CO0CO0co

: » o »

) LO LO LO ) O O O

zs.

• rH

O ^ CNI CNI o :

O O O CD O C 0 '— QC QC O <

1 i l o L n i :

O O ^ 36 O c

LO LO LO LO LO L o o o o o <

a a

c r

'—

LO 1— ■■— LO r

0>a

1 —1

§00§

OCOO

O QC QC

zs.

QC QC OC

.a .a

^ SÉ SÉ O CNI O CD

o o o

CNJ -—

h~ r—

O QC

QC CNJ O

i LO I I

: 36 O O

I LO LO LO

» o o o

3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3 3

0 0

o o

o o o

a a a

.a .a 5 5 5 5 5

CO LO LO CD OO '— OO CD »—; LO CD CNI CO CO LO CNI LO '— CO ' — '— CO LO »— CO 05 CN CN CNJ LO '— LO CNI O CO CO *— O ' — ■■— ■<— -— C O '— I f i C N C N J C O L O C O M C M C N C N O C O O O O r - L O L O L O *— COC O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O

c o c o c o co c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o o

o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o l u

o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o

O ' — C N I C O - ^ L O C D h ' O O C D O O O O O O O O O '— t— t— *— t— CM CM CN CN CN CN

05 05 05 05 Oj 05 05 05 05 05 * * ' ’ * ' • 1 ’ ' 1 ’ ’ ’ * * * ' ’ 1 * * I i

o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o o

ï c

CD O O

O O CD CD »—

O O) N

O »— t— '— o

i— oo Cxi

*— QC QC — X X X . O O O < LO LO LO l o o o <

‘ o o o o“ o" o o" o

.a .a a -a .a .a .a .a .a .a .a - a 5 5 5 5 5 5 5 5 5 5 5 5

Ü ^ CN o

o o o o o '— LO LO '— O ' — '— QC O

0 0 0 ^ 0 LO LO LO LO LO o o o o o

3333333333333333333 I3I

0 0 0 0 0 0 0

.a .a .a .a .a 5 5 5 5 5

CM CO CO LO LO ^í" LO CM CM CM CM CM LO CO CD LO LO CO LO t— CM I CM CD CD CO CD LO CD CO ^ >. O ' — «— C O O OC O LO L O L O L O C D CM CM O -— CO C M CO L O L O L O L O OO CD L O C O O'— '— O O OO O O OO O OO O OO O OO O OO O OO C N IO OO O OO O c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o c o o c o o c o o c o o o c o c o c o c o

D DD D zirjz jr jD D DD n r jn DZ jn rjw n c oz iw rjw w r jr jr j z )

0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0

O CM

o o

CO '— O QC

LO LO LO LO LO LO

o o o o o o

.a .a 5 5

^ CN en <N

’— CD O CD (O i— i— *— '— OC QC QC X LO LO LO

o o o o o o o o o o o o o o o o o o o o

O ' — C N CO ^t LO C DO O CD '— C N C O^ tL O CD I- '- OO C DO '— C NCO-'S 'lD

: ^

i co co > o o

QC QC QC QC

o o

.a .a

5 5

O I - O O O O L O O O O O O O O O — C O O C O O O C S I - - Û C n C N | N ^ r - ^ C N O . CD '— CD CD O QC O O O ^í" OC QC QC CNI ■>— QC

X X X X X L O X X X X L O L p L O X X L O D » -

0 0 0 0 0 3 6 0 0 0 0 ^ 3 6 ^ 0 0 ^ c D

LO LO LO LO LO LO LO LO LO LO LO LO LO LO LO LO »— h— O O O C D O O O O O O O O O O O O . .

3 3 3 3 3 3 3 3 3 3 3 3 3 ° ^

.a .a .a .a .a .a .a .a .a .a a .a .a .a .a .a 5 5 5

^ ^ :

O '

O O O '—

O LO CM '— O

CD LO <

O C M Q C ' — _ _

x x x x x lo x lo 2 l o : z

0 0 0 0 0 3 S 0 ^ f = 3 6 ( =

LOLOLO LOLOL OLOLO » LO O O O O O O O O l —I O I—I

0 0 0 0 0 0 0

.a .a

5 5

: CM :

.a .a .a 5 5 5

SÉ CM SÉ CM SÉ '— CM CM CO CM

0 - 30-3

QC O QC O

o o

0 0 0

'— 2 LO OC U O Li) 2 X

^ (= o

LO » LO

O rH O

O I— O H-

a a a a

5 5 5 5

.a .a .a 5 5 5

: -M -M 2 3 :

: s s u. u. ( > I— I— O O C

CNJ GO CNJ

2 ¡f ® 2

LO L

O h~ ^ "

«— ^ cm O ;

> C O O C

LO L

O O QC O T

^ » LO LO L

i—I i—I o o c

(0 (0 ’— »

.a .a .a .a. 5 5 5 5 c

.a .a .a .a .a 5 5 6 5 5

CO LO CO ’— CO *- ID CN CO CO OO r - CM i— CO LO

o o o o o o o o

O CO O CO CO CO CO CO LU 3 LU D Z) 3 = 3 0

o o o o o o o o

; cm o

_____

5 o o Ö 0 0 0 0 0

cD __Lor-- 0'— o

: c c o i r - C M '— Q C '—

-L OX f- X X X L O X , 5 o ' v o 0 0 5 0

- LO LO I— LO LO LO LO LO

" 0 0 ^ 0 0 0 0 0

I I I i l l 1 1

o o o o o o‘ c j

5 5

. a . a . a . a . a 5 5 5 5 5

LO h - CO CD — LO T— CO o ^ --------- o o o o o o o

co co co co co co co

0 0 -' -' ^ '

o o o o o o o

CO '—

QC QC QC QC QC QC QC QC QC QC QC QC

■g

=lef.

a O

CO CO QC QC

OC OC

.a .a

0 0 CO

CO QC OC

No.

Ü 2 2

co co co

a a

OC OC

.a .a

5 5 5 5

QC QC

a Oa

COCOCO CO

QC QC QC OC QC

2 2 2

OC OC OC OC QC QC QC QC OC OC OC OC OC OC

a a

• rH

CO CO LO LO CO

co co co co co

OC QC QC QC QC QC QC OC OC QC OC OC OC OC OC OC OCOCQC QC QC

CNI

QC cE QC QC

a O0

0 CM

—

co co CO CO co

QC QC QC QC QC OC QC QC

ZSl

2 2 2

a a

• rH

• H

JZ0JZ

5 5 5

00 00

CD CO co co

LO CDOOCD

cE cE

- LO CD r"- oo

a Cl a Cl

—

2 2 2

a a

■ Ha• Ha■ rH

CNJ

CNI

co CO co co co co co co co co co

QC oc QC QC oc

OC cE

a ClCl a a a a a a

0 0

O O 0 0

CO CO CO CO

5 5 5

0O0 CD

■«3-

CO CO co OC QC QC QC OC QC QC QC QC QC

2 2 2

a a

■ rH

■ rHa■ rH

CD CD CD

CM CM

CD r-~

OO QC QC oc

'— cni co '— r

CM CM CM CO CO

QC QC QC QC QC

r^-

r—

CO CO

co CO

2 2 2 zs. 2

OC OC OC OCacOC

■ rH .a

- rHarH

■ H

CM 00

CNI

co co

0 LO CD

OC OC OC OC

a a a Cl

FÍ

0 0

•*3 -

CO co

CO CO CO CO CO CO CO

2 2 2 2

QC QC OC OC OC

• rH

■ rH .a .a

5 5 5 5 5

CM CD CD CD CM

■'3-CD

co CO CO

OC QC OC OC

O CM LO

Cd OC QC OC Cd

QC QC

'- C M ,í'--- '-'-C M C M C M (N C N CM C M (N C SIC M C n CO CO CO CO CO CO CO C O ^t'^ '^ 'í'í 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0

a a ci a a a Cl a a a a a a Cl a a a Cl a

CnI

• H

JZ0JZ

0 0

■^r

co co CO

CD CD

LO LO

O r-~

CO CO

co co

OC QC cE QC QC QC QC OC OC QC QC QC OC QC QC OC

QC OC

2 2 2 2 2

2 2

OC OC OC OC OC

OC OC

■ rH

5 5

CD 0

co co COCOO

QC OC OC OC OC OC OC QC OC OC QC OC OC OC

OC Cd OC OC QC QC QC oc

■ rH

* rH .a

JZ0JZ

CD CD CD

CM CM O

.a .a .a

CO co CO co CO co co COCOCO CO CO CO

LO CD

r-~

00 CO CO

CO CO

2 2 2 2 2 2 2 2 2 2 2 2 2

IS.

OCQCOC OC

5 5 5 5 5

i-~- OO

.aaa

• H

CD CD

0 ■^r ■^r

CM LO

CD 0

QC QC OCCdOC OC QC QC

^ N OO 05 O r- CM C O ^tLO CD h ~O O C D O'— C O V L fiC D M D O J O '— LOCDCD

a a

5 5

CO CO

■^r

COcoCO

■ rH

• rH

CO CO co CO co CO OC

OC QC OC OC QC QC QC

LO CD

r— OOCD0 CM

— CO CO CO CO CO

QC QC OC OC OC OC OC

0 O

0 CM

QC OC OC QC QC

QC OC OCQCQC OC

■ Ha■ H

JZ0JZ

CNI

r-~ CD

OC OC cc

Cl Cl Cl 0 1 a

2 2

CO CO COcoCO

a a a

5 5 5 5 5 5

OC OCOCOC

2 2 2 2 2 2

• rH

.a .a

0 CD CD CD

-'3-

h- r— LOLOCM CM

CO co co CO CO CO CO

QC OC QC OC

CO LO

OC OC OC OC QC

a ci a

CO 0 0 CO

CO co CO CO CO CO CO

OC OC OC

2 2 2

QC OC OC OC OC OC OC

a a

r— OC QC

■rH

5 5

■^r

OO 00

CO CO

CO co

OC OC OC

00 CD

I""-

■ Ha• H

5 5

0 CM 00

■ rHa• rH

JZ0JZ

CD r-~

0 ' —

co co CO

QC QC QC

SÉÜÉ

ZS.

OC OC

.a .a .a .a

OO0CD OO LO

CN CO

O O

co co

QC QC QC

CO CD

00 00

OO OC00QC

QC OC

a a a a

t— ^

r—

co co co

i §

2 2

QC OC

.9 .a

JZOJZ

5655566566

CM O

■^r

CN LO

CO CO

CO OC OC QC

r—

CD O

OO CD

OC OCCDOCCDOC

a a a0Cl

it:

O 0

co co

OC0QC QC QC

0 2O2O2O202

QC OC

.a .a

CD CD 00

OCOO

QC OC

CO ''fr OO

a 0

ic :

0 000

*”

CO CO

OC OC

QC QC OC QC QC

a a

• rH .a

0 0

LO CN

CO co

OC OC

OC QC

0 0

CDOC05

QC OC Cd cE

00 CD — CM CO

■*3- -O LO LO o o o o o

0 0

' ’

0 2

• »—1

CD CD

Ref.

Part Code

No.

C136 CU3035

CU3035

C137

CU3035

C138

CU3005

C140

CU3052

C141

CU3015

C142 C143 CU3011

C144 CU3006

CU3035

C145 C146 CU3052

CS0057

C147

CU3035

C148

CS0057

C149

CU3052

C150

CSO209

C151 C152 CU3011

CU3056

C153 C154 CS0209 C155 CS0063 C156

CU3035

C157 CS0063

CU3035

C158 C159 CU3019 C160

CE0032

C165 CU3052

CU3007

C166 C167 CU3035

CU3015

C168

CU3035

C169 C170 CU3052 C171 CU3059 C173

CU3023 C174 CU3023 C175 CU3035 C176 CU3035 C177 CU3035 C178 CU3035 C179 CU3031 C180

CU3031 C181 CU3035

CU3035

C182

CU3006

C183

XI XQ0022

XF0007

XF1

XF0003

XF2

CN5 UE0105

UE0029A

US0015

CN2 UE0039

CN3 UE0039 CN4 UEO107

JK1 UJ0017

UJ0016

JK2

TS0041 TS0046 AZ0026 YZ0001

Part Name and Number

Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C,CM105CH040C Chip C, CM105W5R103K Chip C, CM105CH220K Chip C, CM105CH100K

Chip C, CM105CH050C

Chip C, CM105W5R102K Chip C, CM105W5R103K Chip Tantal, TMC0J225TR Chip C,CM105W5R102K

Chip Tantal, TMC0J225TR Chip C, CM105W5R103K Chip Tantal, TMCM0J106MTRB

Chip C, CM105CH100K

Chip C, CM105Y5V473Z Chip Tantal, TMCM0J106MTRB Chip Tantal, TMC1V104TR Chip C, CM105W5R102K Chip Tantal, TMC1V104TR Chip C, CM105W5R102K Chip C, CM105CH470K Chemical C, 16V

4.7 m FMS5D=3

Chip C, CM105W5R103K Chip C, CM105CH060C Chip C, CM105W5R102K Chip C, CM105CH220K Chip C, CM105W5R102K Chip C, CM105W5R103K Chip C, CM105Y5V104Z Chip C, CM105CH101K Chip C, CM105CH101K Chip C, CM105W5R102K Chip C, CM105W5R102K Chip C,CM105W5R102K Chip C, CM105W5R102K Chip C, CM105W5R471K Chip C, CM105W5R471K Chip C, CM105W5R102K

Chip C, CM105W5R102K

Chip C, CM105CH050C

UM-1 12.8MHz

X’tal Filter, 58. 125MHz UM-1 X’tal Filter,

55. 05MHz(55M15B1)

FPC Connector, 52030-2010 Antenna Connector,

Slide Switch, HSW0880-01-210

Housing, TZL-P02P-A1 Housing, TZL-P02P-A1 Housing, TZL-P07P-A1

MIC Jack, HSJ2079-01-010 Jack, HSJ1423-01-050

RF Shield PM Earth Board Insulate Spacer, 3. 2-6-0. 3 Silicon Grease

Ref.

No.

Part Code

Part Name and Number

■ CA B IN E T P ARTS L OC ATI ON

Ref.

No.

Part Code

Part Name and Number

Mechanical Parts

DV0003

TG0006

KM0060

ST0023

EL0011

FG0053

DH0005

ST0020

ES0005

UT0022

FG0049

TS0045

TS0043

TS0051

TS0044

NB0027

FG0052

TS0050

i<£OCs’ !

SP Metal Nut

Speaker Sheet Front C^se LCD Flame

LCD Panel Rubber Connector Reflection Board Speaker Stabilizer Speaker Terminal (+) Silicon Key IF Earth Board Terminal Earth Board IF Diecast Earth Board Vol Earth Board

Release Knob

DC Rubber IF Spring

Ref.

Part Code

No.

TS0046

XA0044

XA0069 UHF Power Module

UE0029A Antenna Connector

TS0047 Antenna Earth 560

TS0040 RF Shield A 25 AZ0026 26 TS0053 27

UT0021 28

DD0006 PTT Cover 29

NS0002 H/L Knob 30

NK0019 Volume Knob 31 NW0004 Squelch Knob

NK0018 Dial Knob

33 KU0071 34

FG0051 MIC Rubber

DP0042 Acryl Panel

36 YZ0068 37 YZ0056 Panel Tape A

Part Name and Number

PM Earth Board VHF Power Module

Insulate Spacer VCO Shield Terminal (-)

Upper Panel

Pane] Tap^

- 7 -

AF0013 AF0014

SA0007

3 4 AB0001 5 AP0003 Ô AA0034 7 AN0012

Screws

M2+4 M2. 6+3. 5 Support M2. 6+8 Self Tapping M2+16 M2+5 Dial Nut

■ ADJUST MEN T

■ VHF

(DJ 560T/E)

Item

VCO Voltage L2

Output Power *Hi Power

Deviation

Signal to

Noise Ratio DTMF

Deviation

Subaudible Tone Deviation (T, TW)

1,750kHz

Tone Deviation (E)

Transmitting Range

Detection Coil L4

Front End L22, L24, L25,

S meter VR5

Total Distortion

Total Signal to Noise Ratio

Squelch

Receiving Range

Transmitting Spurious

Adjustment

point(s)

(V-VCO Board)

VR2 (RF Board)

* Low Power

Verification only VR4

(RF Board) Verification only Enter the microphone input of -45dBm/1kHz, then verify that the deviation is 3.5kHz± 0.5kHz. Verification only Enter the microphone input of 3.5kHz/dev/1kHz, then verify that transmit S/N is 35dB or over.

Verification only

VR9 (IF Board)

Verification only

(IF Board)

L26, L27, L28 (RF Board)

(IF Board)

Verification only At 145.03MHz enter a signal of +66dB//lkHz/3.5kHzDev of signal generator, then verify, that the

Verification only At 145.03MHz, enter a signal of +66dB/i/1kHz/3.5kHzDev of signal generator, then verify that the

Verification only 1. Turn off the output power of signal generator and rotating the squelch knob of VHF, verify that

Verification only

Adjustment method

Receive at 145.00MHz, then adjust L2 on V-VCO board so that the voltage of TP2 on RF board is

1.9 V.

Transmit at 144.95MHz, then adjust VR2 on RF board so that the output power is 3.2W.

Transmit at 144.95MHz on the Low power, then verify that the output power is 0.1W to 1W.

Transmit at 144.95MHz and enter the microphone input of -26dBm, then adjust VR4 on RF board so that the deviation is 4.2kHz.

Turn off the modulation output power of the signal generator and at 144.95MHz press the key pad

1, then verify the deviation is 3.1 kHz ± 0.4kHz.

Turn off the modulation output power of the signal generator at 144.95MHz, transmit 88.5Hz tone, then adjust VR9 on IF board so that the deviation is 800kHz.

Turn off the modulation output power of the signal generator and at 144.95MHz, pressing the Tone

Burst Switch on Switch board, transmit then adjust VR9 on IF board so that the deviation is

3.5kHz. On Hi power, transmit at the following frequencies and verify the output power as follows;

0.1W or over at 135.00MHz

0.1W or over at 169.99MHz.

At 145.03MHz, enter +66dB/*/1kHz/3.5kHzDev of signal generator, then adjust L4 on IF board so that the detection output power is at its maximum.

At 145.03MHz, adjust L22, L24, L25, L26, L27, and L28 so that 12dB SINAD sensitivity is at its

maximum.

At 145.03MHz, enter a signal of + 10dB of signal generator, then adjust VR5 on IF board so that FULL in the S meter starts lighting.

distortion at OdBm output is 5% or under.

S/N is 35dB or over.

the noise disappears at the position between 8:30 and 12 o’clock of the knob.

2. Turn the squelch knob until the noise just disappears, then verify that squelch will open at

145.03MHz and -10dB.

3. Rotate the squelch knob fully clockwise, then changing the output power of signal generator, verify that the squelch will open at -8 — + 2dB.

Enter a signal of +66dB/i/1kHz/3.5kHzDev of signal generator, then verify that the unit can receive at 130.00MHz and 169.00MHz.

At 144.95MHz, verify that the transmit spurious is - 60dBc or under on Hi power and -50dBc or under on Low power.

- 9 -

+ 22 hidden pages