Aiwa CT-X321, CT-X335 Service Manual

CT-X321

YV (ST)

CT-X335

YV (ST)

SERVICE MANUAL

STEREO CAR

CASSETTE RECEIVER

BASIC TAPE MECHANISM : CDS-363AG1-A

S/M Code No. 09-012-354-5N2

DATA

SPECIFICATIONS

RADIO SECTION

(FM)

Frequency Range: 65 MHz–74 MHz (50-kHz steps) *

87.5 MHz–108 MHz (50-kHz steps) *
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 80 dB
Frequency Response: 30 Hz-15,000 Hz
S/N Ratio: 63 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 70 dB
Capture Ratio: 3 dB

TAPE SECTION

Tape Speed: 4.8 cm/sec. (17/8 ips)
S/N Ratio: 50 dB
Frequency Response: 40 Hz–14,000 Hz
Stereo Separation: 40 dB

AUDIO SECTION

Max. Power Output: 40 W x 4 channels

AUX IN input

Input sensitivity (load impedance)
AUX IN: 300 mV (10 kΩ)

(MW)

Frequency Range: 531 kHz–1,602 kHz (9-kHz steps) * or

530 kHz–1,710 kHz (10-kHz steps) *

Usable Sensitivity: 30 µV (30 dB)

(LW)

Frequency Range: 144 kHz–288 kHz

(1-kHz/9-kHz steps)

Usable Sensitivity: 30 µV (30 dB)

9 k 10 k
* Set the frequency increment for your area using the switch on the
bottom of the unit. (The switch is factory-set to the 9 k position)

GENERAL

Power-Supply Voltage: 14.4 V (11 to 16 V allowable),

DC, negative ground
Load Impedance: 4Ω
Tone Control: Bass ± 10 dB at 100 Hz

Treble ± 10 dB at 10 kHz
Preamp Output Voltage (load impedance):

2.2 V (10 kΩ)

Installation size: 182(W) x 53(H) x 155(D) mm

(71/4(W) x 21/8(H) x 61/8(D) inches)

• Design and specifications are subject to change without notice.

-2-

ACCESSORIES LIST

REF. NO PART NO. KANRI DESCRIPTION

1 8B-KTG-905-010 IB,YV(ER) 321,335
2 8B-KT9-904-010 IB,INST,YZ,YV (9L,R)-C
3 8Z-KC1-235-010 HLDR,REAR MTG
4 8Z-KC1-231-110 HLDR,HALF -C
6 8Z-KC1-030-010 CASE,DFP -C

7 8Z-KC1-232-010 KEY,REMOVE -C
8 87-B10-216-010 U+2.6-4.0 ZINC BLK (BH M2.6)
9 87-B10-141-010 NUT,5 TYPE-2
10 8Z-KC1-244-010 S-SCREW,5*6 TH+ TAPPING ST
11 8Z-KC1-250-010 S-SCREW,HEXAGON

12 8A-KTG-951-010 SPKR,13CM ASSY
13 87-B10-143-010 UT1+5-15 W/O SLOT
14 87-B10-144-010 W,5.2-10-0.5
15 87-B10-145-010 W-SPR,5.3-8.5-1.5

NO.

-3-

ELECTRICAL MAIN PARTS LIST - 1/2

REF. NO PART NO. KANRI DESCRIPTION

IC

8Z-KT1-622-010 C-IC,LC75374E
8Z-KTG-622-010 IC,TA8259H
87-A21-191-010 IC,KIA6225S
87-A21-441-010 C-IC,TC9297FB
87-A21-929-030 C-IC,TC9323F-027

TRANSISTOR

87-A30-476-010 TR,KTA1046Y
87-A30-468-040 C-TR,KRC102S-RTK
87-A30-470-040 C-TR,KTC3875SY-RTK
87-A30-471-040 C-TR,KTA1504SY-RTK
8Z-KTH-626-080 TR,KTC3203Y

87-A30-487-080 TR,KRC111M-AT
87-A30-473-080 TR,KRC102M-AT
87-A30-467-040 C-TR,KRA111S-RTK
87-A30-469-040 C-TR,KRC111S-RTK
87-A30-295-080 TR,KRA226M

87-A30-016-010 TR,KTD2058Y

DIODE

87-020-465-080 DIODE,1SS133 (110MA)
87-A40-798-010 DIODE,1N5402 (3A/200V)
87-001-783-080 DIODE,1N4002
87-017-932-080 ZENER,MTJ6.2B
87-A40-509-080 ZENER,MTZJ6.8C

87-A40-504-040 C-DIODE,KDS184
87-A40-624-080 ZENER,MTZJ10A
87-070-136-080 ZENER,MTZJ5.1B
87-A40-817-040 C-ZENER,STZ6.8N

MAIN C.B

ANT101 87-A92-038-010 ANT,MSP-403
C101 87-018-119-080 CAP, CER 100P-50V
C102 87-A11-145-080 CAP,TC U 0.01-50 Z F
C103 87-A11-128-080 CAP,TC U 4700P-50 K B
C104 87-010-263-040 CAP,E 100-10

C105 87-010-787-080 CAP, U 0.022-25
C106 87-010-263-040 CAP,E 100-10
C107 87-010-263-040 CAP,E 100-10
C108 87-010-757-080 C.CAP,U 0.047-25F
C109 87-A11-145-080 CAP,TC U 0.01-50 Z F

C110 87-010-759-080 C-CAP,U, 0.1-25F
C111 87-012-286-080 CAP, U 0.01-25
C112 87-012-286-080 CAP, U 0.01-25
C113 87-010-759-080 C-CAP,U, 0.1-25F
C114 87-010-787-080 CAP, U 0.022-25

C115 87-012-286-080 CAP, U 0.01-25
C116 87-010-495-040 CAP,E 2.2-50 GAS
C121 87-010-785-080 C-CAP,U0.015-25BK
C122 87-010-785-080 C-CAP,U0.015-25BK
C123 87-016-526-080 C-CAP,S 0.47-16 BK

C124 87-016-526-080 C-CAP,S 0.47-16 BK
C151 87-012-286-080 CAP, U 0.01-25
C152 87-012-180-080 C-CAP,U 22P-50 CH
C201 87-012-274-080 CHIP CAP,U 1000P-50B
C202 87-012-274-080 CHIP CAP,U 1000P-50B

C203 87-010-378-040 CAP,E 10-16
C204 87-010-378-040 CAP,E 10-16
C205 87-010-263-040 CAP,E 100-10
C206 87-010-263-040 CAP,E 100-10
C207 87-010-787-080 CAP, U 0.022-25

C208 87-010-787-080 CAP, U 0.022-25
C209 87-010-494-040 CAP,E 1-50 GAS
C210 87-010-494-040 CAP,E 1-50 GAS
C211 87-010-263-040 CAP,E 100-10
C212 87-010-380-040 CAP,E 47-16 SME

NO.

REF. NO PART NO. KANRI DESCRIPTION

C301 87-010-401-040 CAP,E 1-50 SME
C302 87-010-401-040 CAP,E 1-50 SME
C303 87-012-274-080 CHIP CAP,U 1000P-50B
C304 87-012-274-080 CHIP CAP,U 1000P-50B
C401 87-010-494-040 CAP,E 1-50 GAS

C402 87-010-494-040 CAP,E 1-50 GAS
C403 87-010-805-080 CAP, S 1-16
C404 87-010-805-080 CAP, S 1-16
C405 87-012-280-080 CAP, U 3300P-50
C406 87-012-280-080 CAP, U 3300P-50

C407 87-010-787-080 CAP, U 0.022-25
C408 87-010-787-080 CAP, U 0.022-25
C409 87-010-498-040 CAP,E 10-16 GAS
C410 87-010-498-040 CAP,E 10-16 GAS
C411 87-A11-177-080 C-CAP,S 0.15-16 K B

C412 87-A11-177-080 C-CAP,S 0.15-16 K B
C413 87-A11-177-080 C-CAP,S 0.15-16 K B
C414 87-A11-177-080 C-CAP,S 0.15-16 K B
C415 87-010-498-040 CAP,E 10-16 GAS
C416 87-010-498-040 CAP,E 10-16 GAS

C417 87-010-072-040 CAP,E 2.2-50 5L
C418 87-010-495-040 CAP,E 2.2-50 GAS
C419 87-010-072-040 CAP,E 2.2-50 5L
C420 87-010-495-040 CAP,E 2.2-50 GAS
C423 87-010-759-080 C-CAP,U, 0.1-25F

C424 87-010-553-040 CAP,E 47-16 GAS
C426 87-010-379-040 CAP,E 22-16 M SME
C427 87-012-358-080 C-CAP,S 0.47-10 F Z
C428 87-012-358-080 C-CAP,S 0.47-10 F Z
C429 87-010-831-080 C-CAP,U,0.1-16F

C430 87-012-286-080 CAP, U 0.01-25
C431 87-010-759-080 C-CAP,U, 0.1-25F
C432 87-010-759-080 C-CAP,U, 0.1-25F
C433 87-010-553-040 CAP,E 47-16 GAS
C501 87-016-526-080 C-CAP,S 0.47-16 BK

C502 87-016-526-080 C-CAP,S 0.47-16 BK
C503 87-016-526-080 C-CAP,S 0.47-16 BK
C504 87-016-526-080 C-CAP,S 0.47-16 BK
C505 87-012-273-080 C-CAP,U 820P-50 B
C506 87-012-273-080 C-CAP,U 820P-50 B

C507 87-012-273-080 C-CAP,U 820P-50 B
C508 87-012-273-080 C-CAP,U 820P-50 B
C509 87-010-378-040 CAP,E 10-16
C510 87-010-759-080 C-CAP,U, 0.1-25F
C511 8A-KC7-623-000 CAP,E 2200U-16 BT(125C)

C512 87-012-274-080 CHIP CAP,U 1000P-50B
C513 87-010-494-040 CAP,E 1-50 GAS
C514 87-010-378-040 CAP,E 10-16
C601 87-016-526-080 C-CAP,S 0.47-16 BK
C602 87-012-180-080 C-CAP,U 22P-50 CH

C603 87-012-182-080 C-CAP,U 27P-50 CH
C606 87-010-787-080 CAP, U 0.022-25
C607 87-A10-189-040 CAP,E 220-10
C609 87-018-134-080 CAPACITOR,TC-U 0.01-16
C610 87-018-209-080 CAP, CER 0.1-50V

C611 87-018-209-080 CAP, CER 0.1-50V
C701 87-012-278-080 C-CAP,U 2200P-50 B
C702 87-010-759-080 C-CAP,U, 0.1-25F
C703 87-018-205-080 CAP, CERA-SOL 0.022
C704 87-010-263-040 CAP,E 100-10

C705 87-010-759-080 C-CAP,U, 0.1-25F
C706 87-010-935-040 CAP,E 220-16 M VR
C801 87-010-378-040 CAP,E 10-16
C802 87-010-075-040 CAP,E 10-16 5L
C803 87-012-271-080 CAP, U 560P-50

C804 87-012-271-080 CAP, U 560P-50
CN201 87-099-408-010 CONN,8P EH V WHT
CN202 87-A60-620-010 CONN,3P V 2MM JMT
CN601 88-KTA-603-010 CONN,15P CAM-B68
CNA201 8Z-KTG-652-010 CONN ASSY,8P MOTOR

NO.

-4-

ELECTRICAL MAIN PARTS LIST - 2/2

REF. NO PART NO. KANRI DESCRIPTION

CNA202 8Z-KTG-651-010 CONN ASSY,3P HEAD
CNA701 8A-KT1-645-010 CONN ASSY,8P ISO-BLACK-B
CNA702 8A-KT1-646-010 CONN ASSY,8P ISO-WHITE-B
D612 87-027-262-010 LEDE,TLR-124(RED)

!!

!F701 8Z-KC1-621-010 FUSE,15A 32V

!!

J801 87-A61-225-110 JACK,PIN 2P XR-401
L101 87-003-143-080 COIL 4.7 UH
L102 8Z-KT1-619-010 COIL,68MH K7-D
L103 87-003-097-080 COIL,1UH
L301 87-003-143-080 COIL 4.7 UH

L601 87-003-149-080 COIL,47UH
L602 87-003-149-080 COIL,47UH
L701 8B-KCF-615-010 FLTR,AMORPHOUS -CHOKE
S601 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A
TU101 8B-KCG-620-010 TU UNIT, FAE347-P21

X601 87-A70-325-010 VIB,XTAL 4.5MHZ HC-49/S

FRONT C.B

C1001 87-012-358-080 C-CAP,S 0.47-10 F Z
C1002 87-012-286-080 CAP, U 0.01-25
CN1001 88-KTA-602-010 CONN,15P CAM-B67
D1007 87-A91-355-040 C-LED,BR1112H-TR-RED
D1008 87-A91-355-040 C-LED,BR1112H-TR-RED

D1009 87-A91-355-040 C-LED,BR1112H-TR-RED
D1010 87-A92-042-090 LED,KM2520MBC30 BLU
D1011 87-A92-042-090 LED,KM2520MBC30 BLU
D1012 87-A92-042-090 LED,KM2520MBC30 BLU
LCD1001 8B-KTG-610-010 LCD,BKT-16-17

NO.

REF. NO PART NO. KANRI DESCRIPTION

PL1001 8B-KTG-605-010 LAMP,9V-60MA W/CAP-B
PL1002 8B-KTG-605-010 LAMP,9V-60MA W/CAP-B
S1001 87-036-339-080 C-SW,TACT SKQM
S1002 87-A91-987-080 SW,TACT SKQCAB
S1003 87-036-339-080 C-SW,TACT SKQM

S1004 87-036-339-080 C-SW,TACT SKQM
S1005 87-A91-987-080 SW,TACT SKQCAB
S1006 87-A91-987-080 SW,TACT SKQCAB
S1007 87-036-339-080 C-SW,TACT SKQM
S1008 87-A91-987-080 SW,TACT SKQCAB

S1009 87-036-339-080 C-SW,TACT SKQM
S1010 87-A91-987-080 SW,TACT SKQCAB
S1011 87-A91-987-080 SW,TACT SKQCAB
S1012 87-036-339-080 C-SW,TACT SKQM
S1013 87-A91-987-080 SW,TACT SKQCAB

S1015 87-A91-987-080 SW,TACT SKQCAB
S1016 87-036-339-080 C-SW,TACT SKQM
S1017 87-A91-986-010 SW,RTRY EC12E24504-15MM

AUX C.B

J1001 85-HRL-623-010 JACK,3.5 ST BLK
W1001 8A-KC7-611-010 F-CABLE,3P (AUX)

HEAD C.B

NO.

• Regarding connectors, they are not stocked as they are not the initial order items.
The connectors are available after they are supplied from connector manufacturers upon the order is received.

CHIP RESISTOR PART CODE

Chip Resistor Part Coding

88

A

Resistor Code

Chip resistor

Wattage Type Tolerance
1/16W 1005 5% CJ

1/16W
1/10W

1/8W

1608
2125

3216

5%
5%

5%

Symbol

Figure

Value of resistor

CJ
CJ

CJ

-5-

Form

L

W

Dimensions (mm)

LW t

1.0 0.5 0.35 104

t

1.6 0.8 0.45
2 1.25 0.45

1.6

0.55

3.2

Resistor Code

: A
: A

108
118

128

TRANSISTOR ILLUSTRATION

E C B

KTC3203

E C B

KRA226M
KRC102M
KRC111M

B C E

KTA1046
KTD2058

C

B

E

KRA111S
KRC102S
KRC111S
KTA1504S
KTC3875S

-6-

BLOCK DIAGRAM - 1/1

D605(AREA1)
D607(LW)
D609(9K/10K)

-7-

8 7
6 5
4 3
2 1

TEL MUTE

2 1
4 3
6 5
8 7

F701

F702

,

SCHEMATIC DIAGRAM - 1/2 (MAIN SECTION)

TU101 FAE347-P21

D605 1SS133

-8-

W701

F702

FUSE 0.5A

TEL MUTE

WIRING - 1/2 (MAIN C.B)

1

3

5

7

9

TU101

JR107

IC601

IC401

1

510

15

20

24

64

60

55

50

45

41

25

30

35

40

80

1

1

12

15 20

22

23

25

30

33

34

40

44

1

5

75

70

65

TO MAIN C.B

CN202

TO HEAD C.B

CNA202

CNA702

CNA701

D605

101112131415161718192021222324

1234567892526272829303132

A

B

C

D

E

F

H

I

J

G

K

L

M

N

O

P

Q

R

S

T

U

-9-

SCHEMATIC DIAGRAM - 2/2 (FRONT SECTION)

BLU

390

KM2520MBC30 BLU

390

KM2520MBC30 BLU

390

KM2520MBC30 BLU

-10-

WIRING - 2/2 (FRONT C.B)

J

I

H

G

F

E

D

C

B

A

2223242526272829303132
2223242526272829303132

161718192021
161718192021

123456789101112131415
123456789101112131415

A

B

C

D

E

F

G

-11-

H

I

J

IC BLOCK DIAGRAM - 1/2

IC, TC9297FB

IC, LC75374E

-12-

IC BLOCK DIAGRAM - 2/2

IC, KIA6225S

IC, TA8259H

-13-

IC DESCRIPTION - 1/1 (TC9323F-027) - 1/2

Pin No. Pin Name I/O Description

1 ~ 4

5

N.C

_______

APS

–

O

Not connected.

MS signal output

10

11

12

13

14

15

16

17

18

6

7

8

9

N.C

S-MUTE

______________

P-MUTE

LOUD

LOCAL

MONO

20dB MUTE

AGC CUT/IF REQ

–

Not connected.

O

Standby muting output

O

Muting output to power amp

O

Loudness output

O

Local/DX switching output. LOCAL: "H", DX: "L"

O

MONO/STEREO switching output. MONO: "H", STEREO: "L"

O

-20dB muting output. This function is enabled when the -20dB muting jumper is selected.

Outputs "H" during searching of frequency. This is an IF count control signal or used to shut off

O

the AGC circuit.

RADIO

TAPE

CD

O

O

O

RADIO output

TAPE output

CD output

Band switching outputs

BAND 1

O

BAND1 BAND2

FM H L

MW L L

BAND 2

O

LW L H

FM (L) H H

19 ~ 21

22

23

24 ~ 33

34 ~ 37

38 ~ 45

46

47

48

49

50

51

52

53

54

55

56

N.C

RE1

RE2

N.C

K0 ~ K3

T0 ~ T7

TAPE

CD

PANEL

POWER

PHONE MUTE

LEVEL METER

DIR

FF/REW

E-VOL DATA

E-VOL CK

E-VOL CE

–

Not connected

I

Rotary encoder input 1

I

Rotary encoder input 2

–

Not connected

I

Key matrix inputs

O

Diode matrix outputs

I

TAPE input

I

CD input. "H" CD input enables the CD key.

Detects detachable panel (0.2-0.5 s chattering time is provided). Panel provided: "H", Panel not

I

provided: "L"

O

Power output

I

The telephone signal automatically applies muting.

The signal level is converted to a digital signal. This meter signal moves the LCD level bar

O

according to the level.

I

TAPE running direction indicator input

I

TAPE FF/REW indicator input

O

Pins to control the LC75374E electronic VR.

-14-

IC DESCRIPTION - 1/1 (TC9323F-027) - 2/2

Pin No. Pin Name I/O Description

57

58

59

60

61

62

63

64

65

66

67

68

69

70, 71

72

73

74

V-REF

LED FLASH

DATA

CLK

CE

BEEP

T-MUTE

REMO-IN

INTR 2

TEST

HOLD

SD-IN

IF-IN

DO1, DO2

GND

FMIN

AMIN

O

I/O

O

O

O

O

O

–

I

Reference voltage pin

This function is enabled when the ACC input is "L" and PANEL input is "L". "H" causes

flashing for 0.1 s and "L" causes 0.9 s flashing. This output is disabled when the LED FLASH

jumper is "H".

For communications with LCD driver and key input IC TC9297F.

Buzzer output

Tuner muting output

I

Interrupt of remote control signal

I

Not used.

I

Test mode control input

I

Monitors that the power is turned on with ignition switched on.

I

SD signal input

I

IF signal input

DO outputs

GND

I

FM/AM local oscillator signal input

75

76

77

78

79

80

VDD

_____________

RESET

XOUT

XIN

VXT

GND

–

VDD terminal

I

Reset input

O

I

For the connection of a crystal oscillator

–

–

GND

-15-

LCD DISPLAY

LCD

Pin No.

SEGMENT

No.

COM1 COM1 – – FM 1 2 1a 1b VOL 2a 2b BAS – TRE

COM2 – COM2 – MW LW 3 1f 1g 1c 2f 2g 2c : –

COM3 – – COM3 AM PM ST 1e 1d 1h 2e 2d 2h B2 B3

LCD

Pin No.

SEGMENT

No.

COM1 3a 3b 4a 4b BAL FAD MUTE 5a 5b LO MY-IN AUX H-BA

COM2 3f 3g 3c 4f 4g 4e 5 ST 5f 5g 5c CH

COM3 3e 3d 3h 4e 4d B4 B5 B6 5e 5d B7 B8 B9 B10

1234567891011121314

– – – S1S2S3S4S5S6S7S8S9S10S11

15 6 171819202122232425262728

S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25

-16-

MECHANICAL EXPLODED VIEW - 1/1

PWB

A

CDS-363AG1-A

H

10

9

13

11

G

4

12

15

14

LCD

30

14

SH,LCD

31

29

32

33

34

A

C

C

45

C

43

C

C

14

16

3

2

1

6

25

28

27

5

8

23

7

22

19

18

21

26

C

24

CHAS,
SIDE L-T

C

44

B

C

PANEL
HT-SINK

B

48

49

47

D

F

C

B

B

36

38

37

39

17

40

B

20

42

41

52

PWB

E
A

C

50

C

SH,PWB

H

51

35

53

-17-

MECHANICAL MAIN PARTS LIST 1/1

REF. NO PART NO. KANRI DESCRIPTION

NO.

1 8B-KT9-007-010 KNOB,RTRY BK9
2 8B-KT9-008-010 POINTER,RTRY
3 8A-KC7-220-010 SPR-C,ROTARY -AC
4 8B-KT9-005-010 LENS,ARC
5 8B-KT9-012-010 BTN,FAN

6 8B-KT9-006-010 CABI,RING
7 8B-KTG-009-010 WINDOW,X321<321YV>
7 8B-KTG-010-010 WINDOW,X335<335YV>
8 8B-KTF-001-010 CABI,FRONT BKF
9 8B-KT9-009-010 BTN,ARC

10 8B-KT9-202-010 LENS,L
11 8B-KT9-011-010 BTN,SEESAW
12 8B-KTG-002-010 BTN,UP/DN G
13 8B-KTF-004-010 BTN,EJECT BKF
14 8B-KTF-204-010 SPR-C,EJ/FF/REW

15 8B-KTF-010-010 BTN,REW BKF
16 8B-KTF-009-010 BTN,FF BKF
17 8B-KT9-018-010 BTN,P.SET 5
18 8B-KT9-016-010 BTN,P.SET 3
19 8B-KT9-014-010 BTN,P.SET 1

20 8B-KT9-013-010 BTN,TWIN
21 8B-KTG-004-010 BTN,P.SET 6G
22 8B-KTG-003-010 BTN,P.SET 4G
23 8B-KT9-015-010 BTN,P.SET 2
24 8B-KT9-204-010 HLDR,P.BTN 246

25 8B-KT9-203-010 HLDR,P.BTN 135
26 8B-KT9-020-010 BTN,DETACH
27 8Z-KC2-223-010 SPR-C,DETACH -C2
28 8B-KT9-201-010 LENS,R
29 8B-KT9-206-010 COVER, LCD R

30 8B-KT9-205-010 COVER, LCD L
31 8B-KT9-207-010 LENS,LCD BK9
32 8B-KT9-208-010 REFLECTOR,LCD BK9
33 8B-KTG-203-010 CAP,LAMP BLUE
34 8B-KTF-002-010 CABI,REAR BKF

REF. NO PART NO. KANRI DESCRIPTION

NO.

35 8B-KTF-003-010 CABI,BASE BKF
36 8Z-KC2-203-210 LEVER,DFP HOOK -C2
37 8Z-KC2-221-110 SPR-C,DETACH HOOK-C2
38 8Z-KT1-244-010 SPR-T,DOOR Z
39 8B-KT9-023-010 DOOR,CASSETTE

40 8Z-KC2-222-010 SPR-T,DETACH LOCK-C2
41 8Z-KC2-204-210 LEVER,DFP LOCK -C2
42 8B-KT9-211-010 CHAS,FRONT BK9
43 8A-KC7-231-010 HLDR,ISO-WIRE 2 -AC
44 8B-KTF-201-010 HLDR,DECK BKF

45 8Z-KC1-211-010 COVER, TOP -C
47 8Z-KC3-201-010 COVER, CD BLIND -C
48 8A-KCG-211-010 HLDR,P-IC -AC16
49 8A-KT5-204-010 HLDR,TR
50 8B-KC1-214-010 CHAS,SIDE R-BC

51 8Z-KC1-212-010 COVER, BOTTOM -C
52 8Z-KC1-231-110 HLDR,HALF -C
53 8A-KCF-020-110 CABI,TRIM -AC15
A 8Z-KC1-253-010 S-SCREW,PT 2*8 BH+ BLK
B 8Z-KC1-251-010 S-SCREW,TH2.6-4.0-0.8

C 87-251-073-410 SCREW,U+2.6-6
D 87-251-097-410 U+3-12
E 87-432-903-010 WASHER,WTE 2.6
F 87-B10-259-010 UT2+3.0-10.0 W/O SLOT (BH TAP)
G 87-B10-334-010 VTT+1.7-5 W/O

H 87-B10-216-010 U+2.6-4.0 ZINC BLK (BH M2.6)

-18-

COLOR NAME TABLE

COLOR NAME TABLE

Basic color symbol Color Basic color symbol Color Basic color symbol Color

B Black C Cream D Orange
G Green H Gray L Blue

LT Transparent Blue N Gold P Pink

R Red S Silver ST Titan Silver
T Brown V Violet W White

WT Transparent White Y Yellow YT Transparent Yellow

LM Metallic Blue LL Light Blue GT Transparent Green
LD Dark Blue DT Transparent Orange GM Metallic Green

YM Metallic Yellow DM Metallic Orange PT Transparent Pink

LA Aqua Blue GL Light Green

-19-

MECHANISM EXPLODED VIEW - 1/1 <CDS-363AG1-A>

8

A

7

5

4

2

6

3

1

9

12

15

B

B

10

18

19

20

A

43

I

C

D

11

17

13

14

E

E

E

16

F

F

A

22

25

25

21

30

31

23

29

24

G

H

33

A

26

27

C

28

32

34

63

67

64

62

61

68

66

65

60

40

39

38

N

41

42

69

48

I

A

C

M

M

47

55

56

46

M

C

MAIN
CHASSIS
ASSY

M

C

54

57
57

58

59

J

J

37

K

L

45

I

53

52

50

35

36

44

HEAD C.B

M

49

51

-20-

MECHANISM MAIN PARTS LIST - 1/1<CDS-363AG1-A>

REF. NO PART NO. KANRI DESCRIPTION

NO.

1 S1-013-810-100 HOLDER CASS(X)
2 SX-003-610-190 EJECT CAM LOCK ASSY
3 S1-003-220-070 TAPE HOOKER
4 S1-013-810-020 HANGER CASS(X)
5 S1-003-640-070 EJECT CAM LOCK SPG

6 S1-003-640-230 CENTER PLATE SPG(B)
7 S1-003-610-180 PLATE CENTER
8 S1-036-350-070 RETURN LINK
9 S1-003-670-570 MOTOR
10 S1-036-330-420 MOTOR PULLEY(MBC)

11 S1-003-630-320 ROLLER FF(A)
12 S1-003-610-150 PLATE SPG SUPPORT
13 S1-003-640-100 ADJUSTER ARM SPG(A)
14 S1-003-640-110 ADJUSTER ARM SPG(B)
15 S1-036-370-040 HEAD

16 S1-013-820-053 ADJUSTER ARM BLUE
17 S1-013-810-060 ADJUSTER SHIM(X)
18 S1-003-820-180 GUIDE TAPE
19 S1-036-320-060 LINK ADJUSTER(B)
20 SX-036-310-020 HEAD PLATE ASSY

21 S1-003-640-060 PLATE SPG HEAD
22 SX-036-310-040 FR CONVRT ARM ASSY(A)
23 S1-003-640-170 SW SELECT ARM SPG
24 S1-003-610-510 LEVER FF(AT)
25 S1-003-640-010 LEVER SPG FF/REW

26 S1-003-610-530 LEVER REW(AT)
27 S1-003-610-290 ARM LOCK(A)
28 S1-003-640-020 LEVER SPG LOCK
29 S1-003-610-230 LEVER CHANG(B)
30 S1-036-330-110 ROLLER PROGRAM

31 S1-003-640-080 ARM SPG PROGRAM
32 SX-036-360-020 LEVER BRACKET ASSY
33 S1-036-350-030 SELECTOR LINK(B)
34 SX-036-360-030 TU GEAR ARM ASSY
35 SX-036-360-050 PINCH ARM ASSY(F)

36 S1-036-340-030 PINCH ARM SPG(F)
37 S1-036-370-010 SW,MUTE
38 S1-036-370-050 SW POWER
39 S1-036-340-050 LEVER SPG EJECT
40 S1-003-610-070 LEVER EJECT

41 S1-036-340-060 CAM SPG EJECT
42 S1-036-310-030 CAM EJECT
43 S1-036-330-070 ROLLER HP(A)
44 S1-036-370-020 SW,SLIDE
45 S1-005-820-215 IDLE PULLEY(A)

REF. NO PART NO. KANRI DESCRIPTION

NO.

46 S1-003-620-090 ARM SENSOR
47 S1-003-620-010 GEAR IDLE
48 S1-003-620-040 GEAR REDUCTION(A)
49 S1-036-360-100 FLYWHEEL ASSY(F) CPL
50 S1-036-360-110 FLYWHEEL ASSY(R) CPL

51 S1-003-650-040 BELT MAIN
52 S1-003-610-260 ARM FR(B)
53 S1-036-320-030 GEAR PULLEY
54 S1-036-350-010 BELT SUB
55 SX-036-360-040 PINCH ARM ASSY(R)

56 S1-036-340-040 PINCH ARM SPG(R)
57 SX-036-320-050 REEL SPINDLE ASSY
58 SX-036-360-060 DETECTOR CAM ASSY(V)
59 S1-013-840-010 BACK TENSION SPG
60 SX-036-360-010 REEL BASE ASSY

61 S1-003-620-140 GEAR DETECTR
62 S1-003-640-150 DASH SPG
63 S1-003-620-100 GEAR SELECTOR
64 S1-003-630-180 COLLER(SELECTOR GEAR)
65 S1-003-640-030 GEAR LOCK ARM SPG

66 S1-003-820-140 GEAR LOCK ARM
67 S1-003-840-140 RATCHET SPG
68 S1-003-620-070 RATCHET
69 S1-003-620-030 GEAR REDUCTION(B)
A S2-171-200-501 E-RING 2

B S2-103-200-25C SCREW,M2-2.5
C S1-003-650-240 PSW(REEL)B 1.5-3.2-0.25
D S2-101-200-40C SCREW,M2-4
E S1-013-850-020 SCREW,M2-5
F S2-103-200-70C SCREW,M2-7

G S2-171-250-601 E-RING 2.5
H S2-133-200-40C SCREW,S-TYPE M2-4
I S2-181-200-30D PSW-S 1.2-3.0-0.25
J S2-181-600-32E LMW-S 1.6-3.2-0.35
K S2-133-170-40C SCREW,S-TYPE M1.7-4

L 87-B10-255-010 SCREW,FLAT M2-3
M S2-138-200-30C SCREW,B-TYPE M2-3
N S2-133-170-60C SCREW,S-TYPE M1.7-6

-21-

2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:[phone]

H251701

Printed in Singapore