CT-X420
YU(ST)
CT-X410
CT-X4150
CT-X4100
CT-X325
CT-X320
CT-X310
YU(ST)
YL(ST)
YL(ST)
YVJ(ST)
YZ(ST),YVJ(ST)
YZ(ST)
SERVICE MANUAL
STEREO CAR CASSETTE RECEIVER
This Service Manual is the “Revision Publishing” and replaces “Simple Manual”
CT-X420 YU(ST)/X410 YU(ST)(S/M Code No.09-003-339-2T1),
CT-X310 YZ(ST)/X325 YVJ(ST)/X320 YZ(ST),YVJ(ST)/X4100 YL(ST)/X4150 YL(ST)
(S/M Code No.09-003-339-1T2)
.
BASIC TAPE MECHANISM : CDS-363AG1-A
S/M Code No. 09-003-339-2R1
REVISION
DATA
SPECIFICATIONS
TYPE MODEL NAME SUFFIX
A CT-X420 YU
B CT-X410 YU
C CT-X310 YZ
D CT-X325 YV
E CT-X320 YZ
F CT-X320 YV
G CT-X4100 YL
H CT-X4150 YL
RADIO SECTION
(FM)
Frequency Range: 87.5 MHz–108 MHz
(100-kHz steps)
87.5 MHz–108 MHz [Except YV]
65 MHz–74 MHz [YV]
(50-kHz steps)
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 80 dB
Frequency Response: 30 Hz-15,000 Hz
S/N Ratio: 63 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 70 dB
Capture Ratio: 3 dB
(AM(MW)) [YU]
Frequency Range: 530 kHz–1,710 kHz
(10-kHz steps)
531 kHz–1,602 kHz
(9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
(MW) [YZ, YV]
Frequency Range: 531 kHz–1,620 kHz
(9-kHz steps)
530 kHz–1,710 kHz
(10-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
TAPE SECTION
Tape Speed: 4.8 cm/sec. (17/8 ips)
S/N Ratio: 50 dB
Frequency Response: 40 Hz–14,000 Hz
Stereo Separation: 40 dB
FF/REW Time: 190 sec. (C-60)
AUDIO SECTION
Max. Power Output: 40 W x 4 channels
CD/MD IN input
Input sensitivity (load impedance)
CD/MD IN: 300 mV (10 kΩ)
GENERAL
Power-Supply Voltage: 14.4 V (11 to 16 V allowable),
DC, negative ground
Load Impedance: 4Ω
Tone Control: Bass ± 10 dB at 100 Hz
Treble ± 10 dB at 10 kHz
Preamp Output Voltage (load impedance):
2.2 V (10 kΩ)
Installation size: 182(W) x 53(H) x 155(D) mm
(71/4(W) x 21/8(H) x 61/8(D) inches)
• Design and specifications are subject to change without notice.
(LW) [YZ, YV]
Frequency Range: 144 kHz–288 kHz
(1-kHz/9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
ACCESSORIES LIST
REF. NO PART NO. KANRI DESCRIPTION
1 8A-KTG-903-010 IB,YL(3L) 4100,4150<G,H>
1 8A-KTG-902-010 IB,YU(3L) 410<B>
1 8A-KTG-901-010 IB,YU(3L) 420<A>
1 8A-KTG-906-010 IB,YV(ER) 320<D,F>
1 8A-KTG-905-010 IB,YZ(9L) 320<C,E>
2 8A-KTG-904-010 IB,INST,SP (3L,P)-A<H>
2 8A-KTG-907-010 IB,INST,SP (ER)-A<D>
2 8A-KT5-902-010 IB,INST,YU,YL (3L,P)<A,B,G,H>
2 8A-KT3-902-010 IB,INST,YZ (9L)-A<C,D,E,F>
3 86-KT1-237-010 HLDR,REAR MTG
4 8Z-KT1-231-010 HLDR,HALF -T
5 8Z-KT1-625-010 CONN ASSY,16P SOC016<A,B,G,H>
6 8Z-KT1-030-010 CASE,DFP -T
7 8Z-KT1-232-010 KEY,REMOVE -T
8 87-B10-141-010 NUT,5 TYPE-2
NO.
REF. NO PART NO. KANRI DESCRIPTION
NO.
9 8Z-KT1-251-010 S-SCREW,5*6 TH+ TAPPING ST
10 88-KT1-247-010 S-SCREW,HEXAGON
11 88-KT1-250-010 S-SCREW,THIN HEAD+2.6-4 BLK
12 8A-KTG-951-010 SPKR,13CM ASSY<D>
13 8Z-KTG-951-010 SPKR,16CM ASSY<H>
14 87-B10-143-010 UT1+5-15 W/O SLOT
15 87-B10-144-010 W,5.2-10-0.5
16 87-B10-145-010 W-SPR,5.3-8.5-1.5
2
ELECTRICAL MAIN PARTS LIST
REF. NO PART NO. KANRI DESCRIPTION
IC
8Z-KT1-622-010 C-IC,LC75374E
8Z-KTG-622-010 IC,TA8259H
87-A21-539-030 C-IC,TC9323F
87-A21-191-010 IC,KIA6225S
87-A21-441-010 C-IC,TC9297FB
TRANSISTOR
89-423-953-010 TR,2SD2395FY
87-A30-468-040 C-TR,KRC102S-RTK
87-026-576-080 C-TR,DTC343TK
87-A30-470-040 C-TR,KTC3875SY-RTK
87-A30-471-040 C-TR,KTA1504SY-RTK
8Z-KTH-626-080 TR,KTC3203Y
8Z-KTH-627-080 TR,KTA1273Y
87-A30-476-010 TR,KTA1046Y
87-A30-487-080 TR,KRC111M-AT
87-A30-295-010 TR,KRA226M
87-A30-473-080 TR,KRC102M-AT
87-A30-475-080 TR,KRA104M-AT
8Z-KTH-623-080 TR,KTA1267Y<C,D,E,F>
87-A30-467-040 C-TR,KRA111S-RTK
87-A30-469-040 C-TR,KRC111S-RTK
87-A30-472-040 C-TR,KRA226S-RTK
DIODE
87-020-465-080 DIODE,1SS133 (110MA)
87-A40-798-010 DIODE,1N5402GW(3A/200V)
87-001-783-080 DIODE,1N4002
87-017-932-080 ZENER,MTZJ6.2B
87-070-334-080 ZENER,MTZJ10B
87-A40-337-080 ZENER,MTZJ 6.8B
87-A40-523-080 ZENER,MTZJ9.1B
87-A40-830-040 DIODE,KDS226-RTK
87-020-585-080 CHIP-ZENER,02CZ6.2Y
87-A40-819-040 C-ZENER,STZ6.8T
MAIN C.B
ANT101 8Z-KT1-614-010 ANT,AW-002
C101 87-018-119-080 CAP, CER 100P-50V
C102 87-018-134-080 CAPACITOR,TC-U 0.01-16
C103 87-010-380-010 CAP,E 47-16 SME
C104 87-010-380-010 CAP,E 47-16 SME
C105 87-018-134-080 CAPACITOR,TC-U 0.01-16
C106 87-018-134-080 CAPACITOR,TC-U 0.01-16
C109 87-018-134-080 CAPACITOR,TC-U 0.01-16
C110 87-018-134-080 CAPACITOR,TC-U 0.01-16
C111 87-010-402-080 CAP, ELECT 2.2-50V
C112 87-018-205-080 CAP, CERA-SOL 0.022
C119 87-010-194-080 CAP, CHIP 0.047
C120 87-010-194-080 CAP, CHIP 0.047
C121 87-018-134-080 CAPACITOR,TC-U 0.01-16
C122 87-018-134-080 CAPACITOR,TC-U 0.01-16
C123 87-010-380-010 CAP,E 47-16 SME
C124 87-018-209-080 CAP, CER 0.1-50V
C201 87-018-209-080 CAP, CER 0.1-50V
C203 87-018-132-010 CAP CER CYL SS 2200P
C204 87-018-205-080 CAP, CERA-SOL 0.022
C205 87-010-263-010 CAP, ELECT 100-10V
C208 87-010-112-010 CAP,ELECT 100-16V
C211 87-010-378-010 CAP, ELECT 10-16SME
C213 87-010-380-010 CAP,E 47-16 SME
C214 87-018-134-080 CAPACITOR,TC-U 0.01-16<C,D,E,F>
C215 87-018-209-080 CAP, CER 0.1-50V
C301 87-018-131-080 CAP, CER 1000P-50V
C302 87-018-131-080 CAP, CER 1000P-50V
C303 87-010-378-010 CAP, ELECT 10-16SME
NO.
REF. NO PART NO. KANRI DESCRIPTION
C304 87-010-378-010 CAP, ELECT 10-16SME
C305 87-010-263-010 CAP, ELECT 100-10V
C306 87-010-263-010 CAP, ELECT 100-10V
C307 87-012-365-080 C-CAP,S 0.027-25VBK
C308 87-012-365-080 C-CAP,S 0.027-25VBK
C309 87-010-401-010 CAP, ELECT 1-50V
C310 87-010-401-010 CAP, ELECT 1-50V
C311 87-010-263-010 CAP, ELECT 100-10V
C312 87-010-401-010 CAP, ELECT 1-50V
C313 87-010-401-010 CAP, ELECT 1-50V
C314 87-010-380-010 CAP,E 47-16 SME
C315 87-A11-128-080 CAP, CER 4700P
C316 87-A11-128-080 CAP, CER 4700P
C401 87-010-380-010 CAP,E 47-16 SME
C402 87-010-196-080 CHIP CAPACITOR,0.1-25
C403 87-010-401-010 CAP, ELECT 1-50V
C404 87-010-401-010 CAP, ELECT 1-50V
C405 87-010-401-010 CAP, ELECT 1-50V
C406 87-010-401-010 CAP, ELECT 1-50V
C407 87-010-184-080 CHIP CAPACITOR 3300P(K)
C408 87-010-184-080 CHIP CAPACITOR 3300P(K)
C409 87-010-198-080 CAP, CHIP 0.022
C410 87-010-198-080 CAP, CHIP 0.022
C411 87-010-378-010 CAP, ELECT 10-16SME
C412 87-010-378-010 CAP, ELECT 10-16SME
C413 87-A11-177-080 C-CAP,S 0.15-16 K B
C414 87-A11-177-080 C-CAP,S 0.15-16 K B
C415 87-A11-177-080 C-CAP,S 0.15-16 K B
C416 87-A11-177-080 C-CAP,S 0.15-16 K B
C417 87-010-378-010 CAP, ELECT 10-16SME
C418 87-010-378-010 CAP, ELECT 10-16SME
C419 87-010-401-010 CAP, ELECT 1-50V
C420 87-010-401-010 CAP, ELECT 1-50V
C421 87-010-401-010 CAP, ELECT 1-50V
C422 87-010-401-010 CAP, ELECT 1-50V
C424 87-010-378-010 CAP, ELECT 10-16SME
C425 87-010-196-080 CHIP CAPACITOR,0.1-25
C426 87-010-196-080 CHIP CAPACITOR,0.1-25
C451 87-010-401-010 CAP, ELECT 1-50V
C452 87-010-401-010 CAP, ELECT 1-50V
C501 87-010-378-010 CAP, ELECT 10-16SME<A>
C502 87-010-378-010 CAP, ELECT 10-16SME<A>
C503 87-010-378-010 CAP, ELECT 10-16SME
C504 87-010-378-010 CAP, ELECT 10-16SME
C505 87-010-175-080 CAP 560P<A>
C506 87-010-175-080 CAP 560P<A>
C507 87-010-175-080 CAP 560P
C508 87-010-175-080 CAP 560P
C601 87-016-083-080 C-CAP,S 0.15-16 RK
C602 87-016-083-080 C-CAP,S 0.15-16 RK
C603 87-016-083-080 C-CAP,S 0.15-16 RK
C604 87-016-083-080 C-CAP,S 0.15-16 RK
C605 87-018-209-080 CAP, CER 0.1-50V
C607 87-A11-179-010 CAP,E 10-16-105 D5*L11 KMF
C608 8Z-KT1-633-090 CAP,E 3300U-16 PW
C609 87-010-180-080 C-CER 1500P
C610 87-010-180-080 C-CER 1500P
C611 87-010-180-080 C-CER 1500P
C612 87-010-180-080 C-CER 1500P
C701 87-010-380-010 CAP,E 47-16 SME
C702 87-010-248-010 CAP, ELECT 100-10V
C703 87-010-198-080 CAP, CHIP 0.022
C705 87-010-314-080 C-CAP,S 22P-50V
C706 87-010-197-080 CAP, CHIP 0.01 DM
C707 87-010-315-080 C-CAP,S 27P-50 CH
C708 87-010-314-080 C-CAP,S 22P-50V
C709 87-016-526-080 C-CAP,S 0.47-16 BK
C710 87-010-401-010 CAP, ELECT 1-50V
C711 87-010-404-010 CONDENSER 4.7-50
C712 87-012-349-080 C-CAP,S 1000P-50 CH
NO.
3
REF. NO PART NO. KANRI DESCRIPTION
C713 87-016-526-080 C-CAP,S 0.47-16 BK
C714 87-016-526-080 C-CAP,S 0.47-16 BK
C715 87-016-669-080 C-CAP,S 0.1-25 K B
C716 87-016-669-080 C-CAP,S 0.1-25 K B
C717 87-010-248-010 CAP, ELECT 100-10V
C801 87-018-134-080 CAPACITOR,TC-U 0.01-16
C802 87-018-209-080 CAP, CER 0.1-50V
C803 87-018-209-080 CAP, CER 0.1-50V
C804 87-012-349-080 C-CAP,S 1000P-50 CH
C805 87-012-349-080 C-CAP,S 1000P-50 CH
CN201 8Z-KT1-624-010 CONN,16P SOC017<A,B,G,H>
CN301 87-009-031-010 CONNECTOR, 3P
CN302 87-099-408-010 CONN,8P EH V WHT
CN801 88-KTA-603-010 CONN,15P CAM-B68
CNA201 8A-KT1-631-010 CONN ASSY,8P ISO-BLACK-A<C,D,E,F>
CNA202 8A-KT1-632-010 CONN ASSY,8P ISO-WHITE-A<C,D,E,F>
CNA301 8Z-KTG-651-010 CONN ASSY,3P HEAD
CNA302 8Z-KTG-652-010 CONN ASSY,8P MOTOR
D806 87-027-262-010 LEDE,TLR-124(RED)
F201 8Z-KC1-621-010 FUSE,15A 32V
J501 87-A61-225-010 JACK,PIN 2P XR-401<EXCEPT A>
J501 87-A61-224-010 JACK,PIN 4P XR-401<A>
L101 87-003-143-080 COIL 4.7 UH
L102 8Z-KT1-619-010 COIL,68MH K7-D
L201 8Z-KT1-615-010 FLTR,AMORPHOUS -CHOKE
L451 87-003-143-080 COIL 4.7 UH
L701 87-003-149-080 COIL,47UH
L702 87-003-097-080 COIL,1UH
L801 87-003-149-080 COIL,47UH
S751 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A
TUN101 8A-KC8-620-010 TU UNIT, FAE347-A11<C,E>
TUN101 8A-KC8-621-010 TU UNIT, FAE347-A12<A,B,G,H>
TUN101 8A-KTG-607-010 TU UNIT, FAE347-P10<D,F>
X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49
NO.
REF. NO PART NO. KANRI DESCRIPTION
FRONT C.B
C901 87-012-358-080 C-CAP,S 0.47-10 F Z
C902 87-010-197-080 CAP, CHIP 0.01 DM
CN901 88-KTA-602-010 CONN,15P CAM-B67
D907 87-017-827-070 C-LED,SEC 1201C RED
D908 87-017-827-070 C-LED,SEC 1201C RED
D909 87-017-827-070 C-LED,SEC 1201C RED
D910 87-A40-813-040 C-LED,SEC1E01C BLUE
D911 87-A40-813-040 C-LED,SEC1E01C BLUE
D912 87-A40-813-040 C-LED,SEC1E01C BLUE
LCD901 8A-KTG-612-010 LCD,AKT-16-17 AUX<EXCEPT F>
LCD901 8A-KTG-610-010 LCD,AKT-16-17<F>
PL901 8A-KT7-655-010 LAMP,9V-50MA
PL902 8A-KT7-655-010 LAMP,9V-50MA
S901 87-036-251-080 SW,T CT 6X3.5 160
S902 87-036-251-080 SW,T CT 6X3.5 160
S903 87-036-251-080 SW,T CT 6X3.5 160
S904 87-036-251-080 SW,T CT 6X3.5 160
S905 87-A90-001-080 C-SW,TACT SKQMAL
S906 87-036-251-080 SW,T CT 6X3.5 160
S907 87-036-251-080 SW,T CT 6X3.5 160
S908 87-036-251-080 SW,T CT 6X3.5 160
S909 87-036-251-080 SW,T CT 6X3.5 160
S910 87-036-251-080 SW,T CT 6X3.5 160
S911 87-A90-001-080 C-SW,TACT SKQMAL
S912 87-A90-001-080 C-SW,TACT SKQMAL
S913 87-036-251-080 SW,T CT 6X3.5 160
S915 87-A90-001-080 C-SW,TACT SKQMAL
S916 87-A90-001-080 C-SW,TACT SKQMAL
VR101 87-A91-597-010 SW,RTRY SIM-026MT
W901 8A-KT9-611-010 F-CABLE,3P 50MM
AUX C.B
J901 87-A61-229-010 JACK,3.5 BLK ST W/SW
NO.
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
88
A
Resistor Code
Chip resistor
Wattage Type Tolerance
1/16W 1005 5% CJ
1/16W
1/10W
1/8W
1608
2125
3216
5%
5%
5%
Symbol
CJ
CJ
CJ
Figure
Value of resistor
Form
L
TYPE MODEL NAME SUFFIX
A CT-X420 YU
B CT-X410 YU
C CT-X310 YZ
D CT-X325 YV
E CT-X320 YZ
F CT-X320 YV
G CT-X4100 YL
H CT-X4150 YL
Dimensions (mm)
LW t
1.0 0.5 0.35 104
t
1.6 0.8 0.45
W
2 1.25 0.45
3.2
1.6
0.55
Resistor Code
108
118
128
: A
: A
4
TRANSISTOR ILLUSTRATION
E C B
KTC3203
E C B
KRA104M
KRA226M
KRC102M
KRC111M
KTA1267
KTA1273
B C E
2SD2395
KTA1046
IC BLOCK DIAGRAM-1
IC, TC9297FB
C
B
E
DTC343TK
KRA111S
KRA226S
KRC102S
KRC111S
KTA1504
KTC3875
IC, LC75374E
65
SCHEMATIC DIAGRAM-1
M1
MTZJ9.1B
YZ/YV ONLY
87
WIRING-1
1
A
B
C
D
234567
[YU,YL]
DIFFERENCE TABLE
8
9
10
[YV,YZ]
11 12 13
14
[This table listes the different
components marked with
asterisks (*) in the MAIN CB]
Ref No. A B C D E F G H
C214 C D E F
C501 A
C502 A
C505 A
C506 A
CN201 A B G H
CNA201 C D E F
CNA202 C D E F
D751 D F
D754 A B G H
D757 C D E F
J501-2 A
Q212 C D E F
R111 D F
R217 C D E F
R218 C D E F
TYPE MODEL NAME SUFFIX
A CT-X420 YU
B CT-X410 YU
C CT-X310 YZ
D CT-X325 YV
E CT-X320 YZ
F CT-X320 YV
G CT-X4100 YL
H CT-X4150 YL
E
F
G
80
1
5
H
I
10
15
20
24
25
30
35
41
40
75
70
65
64
60
55
50
45
J
109
SCHEMATIC DIAGRAM-2
LAMPE+B
5.4
2.1/0 5.45.42.70
VDD
5.4/0.9
5.4/0.9
5.4/0.9
5.4/0.9
0/0.9
0/0.9
0/0.9
0/0.9
1211
WIRING-2
1
A
B
234567
23456 654321
1
AA
C
B
B
C
C
D
D
D
E
E
E
F
F
35
G
F
G
G
H
H
I
I
40
45
30
25
20
55
60
10
5
J
J
H
K
K
L
L
I
M
M
N
N
2
3
1
J
13
IC BLOCK DIAGRAM-2
IC, KIA6225S
IC, TA8259H
14
IC DESCRIPTION
IC, TC9323F
Pin No. Pin Name I/O Description
1 ~ 4
5
N.C
_______
APS
–
O
Not connected.
MS signal output
10
11
12
13
14
15
16
17
18
6
7
8
9
N.C
S-MUTE
______________
P-MUTE
LOUD
LOCAL
MONO
20dB MUTE
–
Not connected.
O
Standby muting output
O
Muting output to power amp
O
Loudness output
O
Local/DX switching output. LOCAL: "H", DX: "L"
O
MONO/STEREO switching output. MONO: "H", STEREO: "L"
-20dB muting output. This function is enabled when the -20dB muting jumper is
O
selected.
Outputs "H" during searching of frequency. This is an IF count control signal or used
AGC CUT/IF REQ
O
to shut off the AGC circuit.
RADIO
TAPE
CD
O
O
O
RADIO output
TAPE output
CD output
Band switching outputs
BAND 1
O
BAND1 BAND2
FM H L
MW L L
BAND 2
O
LW L H
FM (L) H H
19 ~ 21
22
23
24 ~ 33
34 ~ 37
38 ~ 45
46
47
48
49
50
51
52
53
54
55
56
N.C
RE1
RE2
N.C
K0 ~ K3
T0 ~ T7
TAPE
CD
PANEL
POWER
PHONE MUTE
LEVEL METER
DIR
FF/REW
E-VOL DATA
E-VOL CK
E-VOL CE
–
Not connected
I
Rotary encoder input 1
I
Rotary encoder input 2
–
Not connected
I
Key matrix inputs
O
Diode matrix outputs
I
TAPE input
I
CD input. "H" CD input enables the CD key.
Detects detachable panel (0.2-0.5 s chattering time is provided). Panel provided: "H",
I
Panel not provided: "L"
O
Power output
I
The telephone signal automatically applies muting.
The signal level is converted to a digital signal. This meter signal moves the LCD level
–
bar according to the level.
I
TAPE running direction indicator input
I
TAPE FF/REW indicator input
O
Pins to control the LC75374E electronic VR.
15
Pin No. Pin Name I/O Description
57
V-REF
I
Reference voltage pin
This function is enabled when the ACC input is "L" and PANEL input is "L". "H"
58
LED FLASH
O
causes flashing for 0.1 s and "L" causes 0.9 s flashing. This output is disabled when the
LED FLASH jumper is "H".
59
60
61
DATA
CLK
CE
I/O
O
O
For communications with LCD driver and key input IC TC9297F.
62
63
64
65
66
67
68
69
70, 71
72
73
74
75
76
77
78
79
80
BEEP
T-MUTE
REMO-IN
INTR 2
TEST
HOLD
SD-IN
IF-IN
DO1, DO2
GND
FMIN
AMIN
VDD
_____________
RESET
XOUT
XIN
VXT
GND
O
Buzzer output
O
Tuner muting output
I
Interrupt of remote control signal
I
Not used.
I
Test mode control input
I
Monitors that the power is turned on with ignition switched on.
I
SD signal input
I
IF signal input
O
DO outputs
–
GND
I
FM/AM local oscillator signal input
–
VDD terminal
I
Reset input
O
I
For the connection of a crystal oscillator
–
–
GND
16
LCD DISPLAY
Parts No. 8A-KTG-610-010 [Except for CT-X320YV] Parts No. 8A-KTG-610-010 [CT-X320YV]
1817
MECHANICAL EXPLODED VIEW 1/1
7
9
8
6
4
2
1
FRONT C.B
3
5
30
10
11
12
A
1314
5
18
19
15
20
36
22
21
16
23
37
17
24
25
C
C
CHAS,SIDE L-T
CSD-363AG1-A
C
40
41
C
B
B
42
HT-SINK
B
C
44
(C.D.E.F only)
C
44(A,B,G,H only)
C
C
E
43
F
C
29
LCD901
26
27
31
28
AUX C.B
35
B
A
B
334
33
32
CHAS,FRONT S
B
38
39
C
D
C
B
MAIN C.B
SH,PWB
45
CHAS,SIDE R-T
C
46
2019
MECHANICAL MAIN PARTS LIST 1/1
TYPE MODEL NAME SUFFIX
A CT-X420 YU
B CT-X410 YU
C CT-X310 YZ
D CT-X325 YV
E CT-X320 YZ
F CT-X320 YV
G CT-X4100 YL
H CT-X4150 YL
REF. NO PART NO. KANRI DESCRIPTION
1 8A-KTF-020-010 KNOB,RTRY NON RUBBER
2 8A-KT5-021-010 RING,RTRY A
3 8A-KTG-017-010 WINDOW,LCD X310<C>
3 8A-KTG-010-010 WINDOW,LCD X320<E,F>
3 8A-KTG-016-010 WINDOW,LCD X325<D>
3 8A-KTG-005-010 WINDOW,LCD X410<B>
3 8A-KTG-006-010 WINDOW,LCD X4100<G>
3 8A-KTG-007-010 WINDOW,LCD X4150<H>
3 8A-KTG-002-010 WINDOW,LCD X420<A>
4 8A-KT4-011-010 WINDOW,L 4<C>
4 8A-KTF-004-010 WINDOW,L F<EXCEPT C>
5 8A-KT4-010-010 WINDOW,R 4<C>
5 8A-KTF-005-010 WINDOW,R F<EXCEPT C>
6 8A-KTG-001-010 CABI,FRONT G
7 8A-KTF-013-010 BTN,FNC F
8 8A-KT5-012-010 BTN,PWR<EXCEPT C>
8 8A-KT4-005-010 BTN,PWR 4<C>
9 8A-KT5-210-010 HLDR,BTN MU
10 8A-KTF-010-010 BTN,EJECT F
11 8Z-KTA-226-010 SPR-C,EJECT
12 8A-KTG-003-010 BTN,UP/DN G
13 8A-KTF-205-010 LENS,ENCO F
14 8A-KTF-012-010 BTN,REW F
15 8A-KTF-011-010 BTN,FF F
16 87-KTE-205-010 SPR-C,EJ/FF/REW
17 8A-KTG-004-010 BTN,P.SET G
18 8A-KTF-015-010 BTN,DETACH
19 8Z-KTA-223-010 SPR-C,RELEASE -T10
20 8A-KT5-013-010 BTN,DISP<EXCEPT C>
20 8A-KT4-007-010 BTN,SEL 4<C>
21 8A-KT5-014-010 BTN,A/M<EXCEPT C>
21 8A-KT4-009-010 BTN,PS 4<C>
22 8A-KT5-016-010 BTN,INFO<EXCEPT C>
22 8A-KTG-015-010 BTN,INFO G<C>
23 8A-KT5-015-010 BTN,LO
NO.
REF. NO PART NO. KANRI DESCRIPTION
24 8A-KT5-211-010 HLDR,BTN DISP
25 8A-KTF-206-010 LENS,R F
26 8A-KTG-201-010 HLDR,LCD G
27 8A-KTG-203-010 LENS,LCD G
28 8A-KTG-202-010 CASE,LCD G
29 8Z-KT1-239-0100 CAP,LAMP BLU B<EXCEPT C>
29 8Z-KTG-209-010 CAP,LAMP ORN<C>
30 8A-KTF-002-010 CABI,REAR F
31 8A-KTF-003-010 CABI,TRIM F
32 8Z-KT1-231-010 HLDR,HALF -T
33 8Z-KTA-203-010 LEVER,DFP LOCK -T10
34 8Z-KTA-221-010 SPR-C,DETACH LOCK-T10
35 8A-KTF-014-010 CABI,BASE F
36 8Z-KT1-244-010 SPR-T,DOOR Z
37 8Z-KT1-023-110 DOOR,CASS
38 8Z-KTA-204-110 LEVER,DEF HOOK -T10
39 8Z-KTA-222-010 SPR-T,DETACH LOCK-T10
40 8A-KT5-204-010 HLDR,TR
41 8A-KTF-202-010 HLDR,DECK F
42 8Z-KT1-211-010 COVER, TOP -T
43 8Z-KT4-201-010 COVER, CD BLIND -T
44 8Z-KT5-201-010 COVER, ISO BLIND -T<A,B,G,H>
44 8A-KT5-219-010 HLDR,ISO-WIRE 5<C,D,E,F>
45 8A-KTF-201-010 HLDR,IC F
46 8Z-KT1-212-010 COVER, BOTTOM -T
A 8Z-KT1-253-010 S-SCREW,PT 2*8 BH+ BLK
B 88-KT1-250-010 S-SCREW,THIN HEAD+2.6-4 BLK
C 87-251-073-410 SCREW,U+2.6-6
D 87-432-903-010 WASHER,WTE 2.6
E 87-251-097-410 U+3-12
F 87-B10-259-010 UT2+3.0-10.0 W/O SLOT (BH TAP)
NO.
Basic color symbol Color Basic color symbol Color Basic color symbol Color
LT Transparent Blue N Gold P Pink
WT Transparent White Y Yellow YT Transparent Yellow
LM Metallic Blue LL Light Blue GT Transparent Green
LD Dark Blue DT Transparent Orange
COLOR NAME TABLE
B Black C Cream D Orange
G Green H Gray L Blue
R Red S Silver ST Titan Silver
T Brown V Violet W White
21
MECHANISM EXPLODED VIEW 1/1
8
A
7
5
4
2
6
3
1
9
12
B
B
10
18
19
20
A
73
I
15
C
D
11
17
13
14
E
E
E
16
F
F
A
22
25
25
21
30
31
23
29
24
G
H
33
A
26
27
C
28
32
34
63
67
64
62
61
68
66
65
60
40
39
38
N
41
42
69
70
I
A
5
M
M
55
56
71
72
C
M
43
M
54
C
57
57
58
59
J
53
J
37
K
L
45
I
48
47
52
46
50
35
36
44
73
M
49
51
22
MECHANISM MAIN PARTS LIST 1/1
REF. NO PART NO. KANRI DESCRIPTION
1 S1-013-810-100 HOLDER CASS(X)
2 SX-003-610-190 EJECT CAM LOCK ASSY
3 S1-003-220-070 TAPE HOOKER
4 S1-013-810-020 HANGER CASS(X)
5 S1-003-640-070 EJECT CAM LOCK SPG
6 S1-003-640-230 CENTER PLATE SPG(B)
7 S1-003-610-180 PLATE CENTER
8 S1-036-350-070 RETURN LINK
9 S1-003-670-570 MOTOR
10 S1-036-330-420 MOTOR PULLEY(MBC)
11 S1-003-630-320 ROLLER FF(A)
12 S1-003-610-150 PLATE SPG SUPPORT
13 S1-003-640-100 ADJUSTER ARM SPG(A)
14 S1-003-640-110 ADJUSTER ARM SPG(B)
15 S1-036-370-040 HEAD
16 S1-013-820-053 ADJUSTER ARM BLUE
17 S1-013-810-060 ADJUSTER SHIM(X)
18 S1-003-820-180 GUIDE TAPE
19 S1-036-320-060 LINK ADJUSTER(B)
20 SX-036-310-020 HEAD PLATE ASSY
21 S1-003-640-060 PLATE SPG HEAD
22 SX-036-310-040 FR CONVRT ARM ASSY(A)
23 S1-003-640-170 SW SELECT ARM SPG
24 S1-003-610-510 LEVER FF(AT)
25 S1-003-640-010 LEVER SPG FF/REW
26 S1-003-610-530 LEVER REW(AT)
27 S1-003-610-290 ARM LOCK(A)
28 S1-003-640-020 LEVER SPG LOCK
29 S1-003-610-230 LEVER CHANG(B)
30 S1-036-330-110 ROLLER PROGRAM
31 S1-003-640-080 ARM SPG PROGRAM
32 SX-036-360-020 LEVER BRACKET ASSY
33 S1-036-350-030 SELECTOR LINK(B)
34 SX-036-360-030 TU GEAR ARM ASSY
35 SX-036-360-050 PINCH ARM ASSY(F)
36 S1-036-340-030 PINCH ARM SPG(F)
37 S1-036-370-010 SW,MUTE
38 S1-036-370-050 SW POWER
39 S1-003-620-030 GEAR REDUCTION(B)
39 S1-036-340-050 LEVER SPG EJECT
40 S1-003-610-070 LEVER EJECT
42 S1-036-310-030 CAM EJECT
42 S1-036-340-060 CAM SPG EJECT
44 S1-036-370-020 SW,SLLLLLIDE
45 S1-005-820-215 IDLE PULLEY(A)
NO.
REF. NO PART NO. KANRI DESCRIPTION
49 S1-036-360-100 FLYWHEEL ASSY(F) CPL
50 S1-036-360-110 FLYWHEEL ASSY(R) CPL
51 S1-003-650-040 BELT MAIN
52 S1-003-610-260 ARM FR(B)
53 S1-036-320-030 GEAR PULLEY
54 S1-036-350-010 BELT SUB
55 SX-036-360-040 PINCH ARM ASSY(R)
56 S1-036-340-040 PINCH ARM(R)
57 SX-036-320-050 REEL SPINDLE ASSY
58 SX-036-360-060 DETECTOR CAM ASSY(V)
59 S1-013-840-010 BACK TENSION SPG
60 SX-036-360-010 REEL BASE ASSY
61 S1-003-620-140 GEAR DETECTR
62 S1-003-640-150 DASH SPG
63 S1-003-620-100 GEAR SELECTOR
64 S1-003-630-180 COLLER(SELECTOR GEAR)
65 S1-003-640-030 GEAR LOCK ARM SPG
66 S1-003-820-140 GEAR LOCK ARM
67 S1-003-840-140 RATCHET SPG
68 S1-003-620-070 RATCHET
70 S1-003-620-040 GEAR REDUCTION(A)
71 S1-003-620-010 GEAR IDLE
72 S1-003-620-090 ARM SENSOR
73 S1-036-330-070 ROLLER HP(A)
A S2-171-200-501 E-RING 2
B S2-103-200-25C SCREW,M2-2.5
C S1-003-650-240 PSW(REEL)B 1.5-3.2-0.25
D S2-101-200-40C SCREW,M2-4
E S1-013-850-020 SCREW,M2-5
F S2-103-200-70C SCREW,M2-7
G S2-171-250-601 E-RING 2.5
H S2-133-200-40C SCREW,S-TYPE M2-4
I S2-181-200-30D PSW-S 1.2-3.0-0.25
J S2-181-600-32E LMW-S 1.6-3.2-0.35
K S2-133-170-40C SCREW,S-TYPE M1.7-4
M S2-138-200-30C SCREW,B-TYPE M2-3
N S2-133-170-60C SCREW,S-TYPE M1.7-6
NO.
23
2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111
931196
Printed in Singapore
Loading...