Aiwa CT-FR930M, CT-FRV735M, CT-FR730M, CT-FR730MYZ, CT-FR707 Service Manual

SERVICE MANUAL

DATA

BASIC TAPE MECHANISM : CDS-801AW1

STEREO CAR

CASSETTE RECEIVER

CT-FR930M
CT-FR730M
CT-FRV735M
CT-FR707
CT-FR710
CT-FRV715
CT-FX930M
CT-FX730M

S/M Code No. 09-003-342-9R1

YZ

YZ

YZ

YZ

YZ

YZ

YU YH

YU YH

REVISION

This Service Manual is the "Revision Publishing" and replaces "Simple Manual"

(S/M Code No. 09-003-342-9T1).

2

REF. NO PART NO. KANRI DESCRIPTION

NO.

REF. NO PART NO. KANRI DESCRIPTION

NO.

1 8A-KT1-901-010 IB,YZ(9L) FR930M<A>
1 8A-KT3-901-010 IB,YZ(9L) FR730M,FRV735M<B,C>
1 8A-KT3-901-010 IB,YZ(9L) FR730M,FRV735M<D,E,F>
1 8A-KT5-901-010 IB,YU(3L) 930M<G>
1 8A-KT5-907-010 IB,YH(E CK CH A) 930M<H>

1 8A-KT7-901-010 IB,YU(3L) 730M<I>
2 8A-KT3-902-010 IB,INST,YZ (9L)-A<A,B,C,D,E,F>
2 8A-KT5-902-010 IB,INST,YU,YL (3L,P)<G,I>
2 8A-KT5-908-010 IB,INST,YH,Y (E CK CH A)-A<H>
3 R8-AZR-190-040 AZR-1 RCKCGNF

4 8Z-KT1-625-010 CONN ASSY,16P SOC016<G,H,I,J>
5 86-KT1-237-010 HLDR,REAR MTG
6 87-B10-141-010 NUT,5 TYPE-2
7 87-B10-143-010 UT1+5-15 W/O SLOT
8 87-B10-144-010 W,5.2-10-0.5

9 88-KT1-247-010 S-SCREW,HEXAGON
10 8Z-KT1-231-010 HLDR,HALF -T
11 8Z-KT1-232-010 KEY,REMOVE -T
12 8Z-KT1-251-010 S-SCREW,5*6 TH+ TAPPING ST
13 8Z-KT1-030-010 CASE,DFP -T

14 88-KT1-250-010 S-SCREW,THIN HEAD+2.6-4 BLK
15 87-B10-145-010 W-SPR,5.3-8.5-1.5
16 88-KC4-255-010 S-SCREW,HEX-SOC+3-3.5 BLK
17 88-KC4-257-010 KEY,HEXAGON WRENCH
18 88-KC4-057-010 BELT, HRC

19 88-KC4-053-010 HLDR,BELT HRC

SPECIFICATIONS

RADIO SECTION
(FM)

Frequency Range [YZ]: 87.5 MHz–108 MHz

(50-kHz steps)

Frequency Range [YH,YU]: 87.5 MHz-108 MHz

(50-kHz steps)

87.5 MHz–108 MHz

(100-kHz steps)
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 80 dB
Frequency Response: 30 Hz-15,000 Hz
S/N Ratio: 63 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 70 dB
Capture Ratio: 3 dB

(MW) [YZ]

Frequency Range: 531 kHz–1,602 kHz

(9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)

(AM(MW)) [YH, YU]

Frequency Range: 530 kHz–1,710 kHz

(10-kHz steps)

531 kHz–1,620 kHz

(9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)

(LW) [YZ]

Frequency Range: 144 kHz–288 kHz

(1-kHz/9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)

TAPE SECTION

Tape Speed: 4.8 cm/sec. (17/8 ips)
S/N Ratio (normal): 50 dB
S/N Ratio (metal): DOLBY-NR OFF 54 dB
[CT-FR930M,FX930M] DOLBY-NR ON 64 dB
Frequency Response: 40 Hz–14,000 Hz (normal)

40 Hz–16,000 Hz (metal)
Stereo Separation: 40 dB
FF/REW Time: 95 sec. (C-60)

AUDIO SECTION

Max. Power Output: 45 W x 4 channels

AUX IN INPUT

Input Sensitivity (Load impedance)
AUX IN: 300 mV (10 kΩ)

GENERAL

Power-Supply Voltage: 14.4 V (11 to 16 V allowable),

DC, negative ground
Load Impedance: 4 Ω
Tone Control: Bass ±10 dB at 100 Hz

Treble ±10 dB at 10 kHz
Preamp Output Voltage (load impedance):

2.2 V (10 kΩ) [YZ]

4.0 V (10 kΩ) [YU,YH]

Installation size: 182(W) x 53(H) x 155(D) mm

(71/4(W) x 21/8(H) x 61/8(D) inches)

Steering-wheel-mounted remote control unit

Dimensions: approx. 67(W) x 26(H) x 27(D) mm

(23/4(W) x 11/16(H) x 11/8 (D) inches)

(excluding holder, battery)

approx. 38 g (1.33 oz.)

(including holder, battery)

A
B
C
D
E
F
G
H

I

J

CT-FR930M
CT-FR730M
CT-FRV735M
CT-FR707
CT-FR710
CT-FRV715
CT-FX930M
CT-FX930M
CT-FX730M
CT-FX730M

YZ
YZ
YZ
YZ
YZ
YZ
YU
YH
YU
YH

TYPE SUFFIXMODEL NAME

•

Design and specifications are subject to change without notice.

•

Dolby noise reduction manufactured under license from Dolby Labo­ratories Licensing Corporation.

•

“DOLBY”, and the double-D symbol are trademarks of Dolby

Laboratories Licensing Corporation.

ACCESSORIES LIST

3

REF. NO PART NO. KANRI DESCRIPTION

NO.

REF. NO PART NO. KANRI DESCRIPTION

NO.

ELECTRICAL MAIN PARTS LIST

IC

87-A20-233-010 C-IC,HA12192F<A,G,H>
87-002-394-010 IC,LB1641
87-A21-538-010 IC,KIA2025P<EXCEPT A,G,H>
8Z-KT1-622-010 C-IC,LC75374E
87-A21-562-010 IC,LA4743B

87-A21-531-030 C-IC,UPD178006A-XXX<I,J>
87-A21-594-030 C-IC,UPD178016AGC-559-3B9<G,H>
87-A21-530-030 C-IC,UPD178018A-XXX<A,B,C,D,E,F>
87-002-689-080 IC,NJM2072M<A,G,H>
87-A21-532-030 C-IC,LC75817W-8720<A,G,H>

88-KT1-608-010 C-IC,LC75854W<EXCEPT A,G,H>
87-A90-951-010 RCR UNIT,SBX1971-52
88-KT1-607-080 C-IC,SAA6579T<A,B,C,D,E,F>
87-001-611-080 IC,NJM3403M<G,H,I,J>

TRANSISTOR

87-A30-468-040 C-TR,KRC102S-RTK
87-A30-470-040 C-TR,KTC3875SY-RTK
87-A30-471-040 C-TR,KTA1504SY-RTK
87-A30-469-040 C-TR,KRC111S-RTK
87-A30-295-010 TR,KRA226M

87-A30-472-040 C-TR,KRA226S-RTK
87-026-576-080 C-TR,DTC343TK
87-A30-467-040 C-TR,KRA111S-RTK
8Z-KTH-627-080 TR,KTA1273Y
87-A30-476-010 TR,KTA1046Y

87-A30-063-080 C-TR,KRA104S
8Z-KTH-626-080 TR,KTC3203Y
87-A30-483-040 C-TR,KRC114S
89-423-953-010 TR,2SD2395F

DIODE

87-020-465-080 DIODE,1SS133 (110MA)
87-A40-350-080 ZENER,MTZJ 4.7C
87-A40-504-040 C-DIODE,KDS184
87-017-932-080 ZENER,MTZJ6.2B
87-A40-829-040 DIODE,KDS196-RTK

87-A40-830-040 DIODE,KDS226-RTK
87-001-783-080 DIODE,1N4002
87-A40-250-080 C-DIODE,DAN217
87-A40-819-040 C-ZENER,STZ6.8T
87-020-590-080 C-ZENER,02CZ10Y

87-027-262-010 LEDE,TLR-124(RED)
87-020-585-080 CHIP-ZENER,02CZ6.2Y
87-020-583-080 CHIP-ZENER,02CZ5.1Y
87-A40-337-080 ZENER,MTZJ 6.8B
87-070-022-010 DIODE,IN5402 (RECT)

87-070-334-080 ZENER,MTZJ10A
87-A40-869-080 C-ZENER,02CZ11X<EXCEPT A,G,H>
87-017-931-080 ZENER,MTZJ5.6B
87-A40-523-080 ZENER,MTZJ9.1B
87-A40-814-080 LED,SEL2E10C BLUE<C,F>

MAIN C.B

C101 87-010-322-080 C-CAP,S 100P-50 CH
C102 87-010-197-080 CAP, CHIP 0.01 DM
C103 87-010-322-080 C-CAP,S 100P-50 CH
C104 87-010-186-080 CAP,CHIP 4700P
C105 87-010-490-040 CAP, ELECT 0.1-50

C106 87-010-198-080 CAP, CHIP 0.022
C107 87-010-553-040 CAP,E 47-16 GAS
C108 87-010-196-080 CHIP CAPACITOR,0.1-25
C109 87-010-553-040 CAP,E 47-16 GAS
C110 87-010-194-080 CAP, CHIP 0.047

C111 87-010-213-080 C-CAP,S 0.015-50 B<EXCEPT G,I>
C111 87-010-198-080 C-CAP,S 0.022-25 KB<G,I>

C112 87-010-213-080 C-CAP,S 0.015-50 B<EXCEPT G,I>
C112 87-010-198-080 C-CAP,S 0.022-25 KB<G,I>
C113 87-010-194-080 CAP, CHIP 0.047
C114 87-010-194-080 CAP, CHIP 0.047
C115 87-010-197-080 CAP, CHIP 0.01 DM

C116 87-010-495-080 CAP,E2.2-50
C117 87-010-197-080 CAP, CHIP 0.01 DM
C118 87-010-197-080 CAP, CHIP 0.01 DM
C119 87-010-553-040 CAP,E 47-16 GAS
C120 87-010-196-080 CHIP CAPACITOR,0.1-25

C301 87-010-494-040 CAP,E 1-50 GAS
C302 87-010-494-040 CAP,E 1-50 GAS
C401 87-010-494-040 CAP,E 1-50 GAS<EXCEPT D,E,F>
C402 87-010-494-040 CAP,E 1-50 GAS<EXCEPT D,E,F>
C501 87-010-494-040 CAP,E 1-50 GAS

C502 87-010-494-040 CAP,E 1-50 GAS
C503 87-010-494-040 CAP,E 1-50 GAS
C504 87-010-494-040 CAP,E 1-50 GAS
C505 87-010-184-080 CHIP CAPACITOR 3300P(K)
C506 87-010-184-080 CHIP CAPACITOR 3300P(K)

C507 87-010-198-080 CAP, CHIP 0.022
C508 87-010-198-080 CAP, CHIP 0.022
C509 87-010-498-040 CAP,E 10-16 GAS
C510 87-010-498-040 CAP,E 10-16 GAS
C511 87-A11-177-080 C-CAP,S 0.15-16 K B

C512 87-A11-177-080 C-CAP,S 0.15-16 K B
C513 87-A11-177-080 C-CAP,S 0.15-16 K B
C514 87-A11-177-080 C-CAP,S 0.15-16 K B
C515 87-010-498-040 CAP,E 10-16 GAS
C516 87-010-498-040 CAP,E 10-16 GAS

C517 87-010-555-040 CAP,E 100-10 SRE
C518 87-010-498-040 CAP,E 10-16 GAS
C519 87-010-196-080 CHIP CAPACITOR,0.1-25
C520 87-010-494-040 CAP,E 1-16 GAS
C521 87-010-805-080 CAP, S 1-16

C522 87-010-805-080 CAP, S 1-16
C523 87-010-805-080 CAP, S 1-16
C524 87-010-494-040 CAP,E 1-50 GAS
C525 87-016-526-080 C-CAP,S 0.47-16 BK
C526 87-016-526-080 C-CAP,S 0.47-16 BK

C527 87-016-526-080 C-CAP,S 0.47-16 BK
C528 87-010-196-080 CHIP CAPACITOR,0.1-25
C529 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C530 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C531 87-010-178-080 CHIP CAP 1000P

C601 87-A11-177-080 C-CAP,S 0.15-16 K B
C602 87-A11-177-080 C-CAP,S 0.15-16 K B
C603 87-A11-177-080 C-CAP,S 0.15-16 K B
C604 87-A11-177-080 C-CAP,S 0.15-16 K B
C605 87-010-180-080 C-CER 1500P

C606 87-010-180-080 C-CER 1500P
C607 87-010-180-080 C-CER 1500P
C608 87-010-180-080 C-CER 1500P
C609 87-010-068-040 CAP E 0.22-50 5L
C610 87-010-552-040 CAP,E 22-16 GAS

C611 87-010-198-080 CAP, CHIP 0.022
C612 8Z-KT1-633-000 CAP,E 3300U-16 105 PW
C613 87-010-553-040 CAP,E 47-16 GAS
C614 87-010-196-080 CHIP CAPACITOR,0.1-25
C615 87-010-196-080 CHIP CAPACITOR,0.1-25

C616 87-010-196-080 CHIP CAPACITOR,0.1-25
C617 87-010-196-080 CHIP CAPACITOR,0.1-25
C618 87-010-322-080 C-CAP,S 100P-50 CH
C619 87-010-322-080 C-CAP,S 100P-50 CH
C620 87-010-322-080 C-CAP,S 100P-50 CH

C621 87-010-322-080 C-CAP,S 100P-50 CH
C622 87-010-322-080 C-CAP,S 100P-50 CH
C623 87-010-322-080 C-CAP,S 100P-50 CH
C624 87-010-322-080 C-CAP,S 100P-50 CH
C625 87-010-322-080 C-CAP,S 100P-50 CH

4

REF. NO PART NO. KANRI DESCRIPTION

NO.

REF. NO PART NO. KANRI DESCRIPTION

NO.

C626 87-010-196-080 CHIP CAPACITOR,0.1-25
C701 87-010-490-040 CAP, ELECT 0.1-50
C702 87-010-196-080 CHIP CAPACITOR,0.1-25
C703 87-010-314-080 C-CAP,S 22P-50 CH
C704 87-010-315-080 C-CAP,S 27P-50 CH

C705 87-010-196-080 CHIP CAPACITOR,0.1-25
C707 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM
C708 87-010-322-080 C-CAP,S 100P-50 CH
C709 87-010-322-080 C-CAP,S 100P-50 CH
C710 87-010-178-080 CHIP CAP 1000P

C711 87-010-197-080 CAP, CHIP 0.01 DM
C712 87-010-197-080 CAP, CHIP 0.01 DM
C713 87-010-197-080 CAP, CHIP 0.01 DM
C714 87-010-197-080 CAP, CHIP 0.01 DM
C801 87-010-182-080 C-CAP,S 2200P-50 B

C802 87-010-182-080 C-CAP,S 2200P-50 B
C803 87-010-196-080 CHIP CAPACITOR,0.1-25
C804 87-010-552-040 CAP,E 22-16 GAS
C805 87-010-555-040 CAP,E 100-10 GAS
C806 87-010-935-040 CAP,E 220-16 M VR

C807 87-010-197-080 CAP, CHIP 0.01 DM
C808 87-010-197-080 CAP, CHIP 0.01 DM
C809 87-010-553-040 CAP,E 47-16 GAS
C810 87-010-198-080 CAP, CHIP 0.022
C901 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>

C902 87-010-553-040 CAP,E 47-16 GAS<A,G,H>
C903 87-A10-189-040 CAP,E 220-10<A,G,H>
C904 87-010-495-040 CAP,E 2.2-50 GAS<A,G,H>
C905 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
C906 87-010-194-080 CAP, CHIP 0.047<A,G,H>

C1107 87-010-197-080 CAP, CHIP 0.01 DM<A,B,C,D,E,F>
C1201 87-010-805-080 CAP, S 1-16<G,H,I>
C1202 87-010-805-080 CAP, S 1-16<G,H,I,J>
C1203 87-010-805-080 CAP, S 1-16<G,H,I,J>
C1204 87-010-805-080 CAP, S 1-16<G,H,I,J>

C1205 87-010-805-080 CAP, S 1-16
C1206 87-010-805-080 CAP, S 1-16
C1207 87-010-805-080 CAP, S 1-16
C1208 87-010-805-080 CAP, S 1-16
C1209 87-010-805-080 CAP, S 1-16

C1210 87-010-805-080 CAP, S 1-16
C1211 87-010-805-080 CAP, S 1-16
C1212 87-010-805-080 CAP, S 1-16
C1213 87-012-140-080 CAP 470P<G,H,I,J>
C1214 87-012-140-080 CAP 470P<G,H,I,J>

C1215 87-012-140-080 CAP 470P
C1216 87-012-140-080 CAP 470P
C1217 87-010-112-040 CAP,E 100-16 SME<G,H,I,J>
C1218 87-010-555-040 CAP,E 100-10 GAS<G,H,I,J>
C1219 87-010-322-080 C-CAP,S 100P-50 CH

C1301 87-010-198-080 CAP, CHIP 0.022<A,B,C,D,E,F>
CN801 8Z-KT1-624-010 CONN,16P SOC017<G,H,I,J>
CN1101 8Z-KTH-613-010 CONN,3P HEADER-ANGLE<A,B,C,D,E,F>
CN1102 8Z-KTH-613-010 CONN,3P HEADER-ANGLE<A,B,C,D,E,F>
CNA201 8A-KT7-651-010 CONN ASSY,5P MAIN-EQ

CNA251 8A-KT5-661-010 CONN ASSY,12P MAIN-CONTROL
CNA801 8A-KT1-631-010 CONN ASSY,8P ISO-BLACK-

<A,B,C,D,E,F>

CNA802 8A-KT1-632-010 CONN ASSY,8P ISO-WHITE-A

<A,B,C,D,E,F>
CNA1401 8A-KT5-654-010 CONN ASSY,6P MAIN-TAKE UP
CNA1402 8A-KT5-652-010 CONN ASSY,10P MAIN-TAKE UP

F801 8Z-KC1-621-010 FUSE,15A 32V
J101 8Z-KT1-614-010 ANT,AW-002
J401 8A-KC7-620-010 JACK,DIN 13 P SKDS1302<EXCEPT D,E,F>
J1201 88-KTA-604-010 JACK,PIN 4P V-TYPE<B,C>
J1201 87-A61-224-010 JACK,PIN 4P XR-401<EXCEPT B,C>

L101 87-003-143-080 COIL 4.7 UH
L102 8Z-KT1-619-010 COIL,68MH K7-D
L301 87-003-143-080 COIL 4.7 UH

L701 87-003-149-080 COIL,47UH
L801 8Z-KT1-615-010 FLTR,AMORPHOUS -CHOKE 370UH
L1201 87-003-143-080 COIL 4.7 UH
MIC901 8Z-KT1-643-090 MIC,EMC KUC2123-040245DB<A,G,H>
PL801 8A-KT7-655-010 LAMP,9V-50MA

SW701 87-A91-070-010 SW,TACT SKHHLV
SW702 87-036-109-010 PUSH SWITCH
SW703 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A
TU101 8A-KC8-620-010 TU UNIT, FAE347-A11<A,B,C,D,E,F>
TU101 8A-KC8-621-010 TU UNIT, FAE347-A12<G,H,I,J>

W301 8A-KT5-611-010 F-CABLE,3P 40MM
X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49

CONTROL C.B

C251 87-010-553-040 CAP,E 47-16 GAS
C252 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C253 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C254 87-010-196-080 CHIP CAPACITOR,0.1-25
C255 87-012-141-080 CHIP-CAPACITOR,0.22-16F

C256 87-010-497-040 CAP,E 4.7-35 GAS
C257 87-010-197-080 CAP, CHIP 0.01 DM
C258 87-010-553-040 CAP,E 47-16 GAS
CON251 87-099-203-010 CONN,10P 6216 H
CON252 87-A61-262-010 CONN,12P V B12B-ZR

EQ/DOLBY C.B<A,G,H>

C201 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C202 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C203 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C204 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C205 87-010-426-080 CAP, CHIP 0.012 KB<A,G,H>

C206 87-010-426-080 CAP, CHIP 0.012 KB<A,G,H>
C207 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C208 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C209 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C210 87-010-494-040 CAP,E 1-50 M 5L SRE<A,G,H>

C211 87-010-494-040 CAP,E 1-50 M 5L SRE<A,G,H>
C212 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C213 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C214 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C215 87-010-197-080 CAP, CHIP 0.01 DM<A,G,H>

C216 87-010-197-080 CAP, CHIP 0.01 DM<A,G,H>
C218 87-010-555-040 CAP,E 100-10 GAS<A,G,H>
C219 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C220 87-A11-548-080 C-CAP,S 560P-50 KB<A,G,H>
C221 87-A11-548-080 C-CAP,S 560P-50 KB<A,G,H>

C222 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C223 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C224 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
C225 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
C226 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>

CON201 87-009-349-010 CONN,6P PH H<A,G,H>
CON202 87-A61-260-010 CONN,9P V B9B-ZR<A,G,H>
SVR201 87-024-433-080 SFR,10K RH063EC<A,G,H>
SVR202 87-024-433-080 SFR,10K RH063EC<A,G,H>

EQ C.B<EXCEPT A,G,H>

C271 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C272 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C273 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C274 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C275 87-010-552-040 CAP,E 22-16 GAS<EXCEPT A,G,H>

C276 87-010-552-040 CAP,E 22-16 GAS<EXCEPT A,G,H>
C277 87-010-426-080 C-CAP,S 0.012-25 B<EXCEPT A,G,H>
C278 87-010-426-080 C-CAP,S 0.012-25 B<EXCEPT A,G,H>
C279 87-010-494-040 CAP,E 1-50 GAS<EXCEPT A,G,H>
C280 87-010-494-040 CAP,E 1-50 GAS<EXCEPT A,G,H>

65

88

A

Resistor Code

Chip Resistor Part Coding

Figure

Value of resistor

Chip resistor

Wattage Type Tolerance

1/16W

1/10W

1/8W

1608

2125

3216

5%

5%

5%

CJ

CJ

CJ

Form

LW t

1.6 0.8 0.45

2 1.25 0.45

3.2

1.6

108

118

128

: A
: A

CHIP RESISTOR PART CODE

0.55

Resistor Code

Dimensions (mm)

Symbol

1/16W 1005 5% CJ

1.0 0.5 0.35 104

L

t

W

TRANSISTOR ILLUSTRATION

KTC3203

KRA226M
KTA1273

2SD2395
KTA1046

DTC343TK
KRA104S
KRA111S
KRA226S
KRC102S
KRC111S
KRC114S
KTA1504
KTC3875

E C B E C B

B C E

E

B

C

A
B
C
D
E
F
G
H

I

J

CT-FR930M
CT-FR730M
CT-FRV735M
CT-FR707
CT-FR710
CT-FRV715
CT-FX930M
CT-FX930M
CT-FX730M
CT-FX730M

YZ
YZ
YZ
YZ
YZ
YZ
YU
YH
YU
YH

TYPE SUFFIXMODEL NAME

C281 87-010-555-040 CAP,E 100-10 GAS<EXCEPT A,G,H>
C282 87-010-497-040 CAP,E 4.7-35 GAS<EXCEPT A,G,H>
C283 87-010-498-040 CAP,E 10-16 GAS<EXCEPT A,G,H>
C284 87-010-494-040 CAP,E 1-50 GAS<EXCEPT A,G,H>
C285 87-010-494-040 CAP,E 1-50 GAS<EXCEPT A,G,H>

C286 87-010-553-040 CAP,E 47-16 GAS<EXCEPT A,G,H>
CON271 87-009-349-010 CONN,6P PH H<EXCEPT A,G,H>
CON272 87-A61-259-010 CONN,5P V B5B-ZR<EXCEPT A,G,H>

HEAD C.B

TAKE UP C.B

SW1017 87-036-220-080 C-SW,T
CN1403 8Z-KT1-613-010 CONN,16P CAM-C74
CON1401 87-009-411-010 CONN,6P ZH V
CON1402 87-A61-261-010 CONN,10P V B10B-ZR

FRONT C.B

C1001 87-010-805-080 CAP, S 1-16
C1002 87-010-194-080 CAP, CHIP 0.047<EXCEPT A,G,H>
C1002 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C1003 87-010-194-080 CAP, CHIP 0.047
C1004 87-010-194-080 CAP, CHIP 0.047<A,G,H>

C1004 87-010-176-010 CAP, S 680P-50<EXCEPT A,G,H>
C1005 87-010-194-080 CAP, CHIP 0.047<A,G,H>
C1005 87-010-805-080 CAP, S 1-16<EXCEPT A,G,H>
C1006 87-012-156-010 C-CAP,S 220P-50 CH<A,G,H>
C1006 87-010-194-080 CAP, CHIP 0.047<EXCEPT A,G,H>

C1007 87-010-805-080 CAP, S 1-16<A,G,H>
CON1001 8Z-KT1-612-010 CONN,16P CAM-C73
LCD1001 8A-KC7-610-010 LCD,AKC-7(DOT)<A,G,H>
LCD1001 8A-KC8-611-010 LCD,AKC-2/8(NO COLOR)<C,F>
LCD1001 8A-KT7-610-010 LCD,AKT-3/4/7(3COLOR)<B,D,E,I,J>

LED1001 87-017-827-070 C-LED,SEC 1201C RED
LED1002 87-017-827-070 C-LED,SEC 1201C RED
LED1003 87-017-827-070 C-LED,SEC 1201C RED
LED1004 87-A40-813-040 C-LED,SEC1E01C BLUE
LED1005 87-A40-813-040 C-LED,SEC1E01C BLUE

LED1006 87-A40-813-040 C-LED,SEC1E01C BLUE
LED1007 87-A40-814-080 C-LED,SEL2E10C BLUE<C,F>
PL1002 8Z-KT1-651-010 LAMP,9V-85MA<A,G,H>
PL1002 8A-KT7-655-010 LAMP,9V-50MA<B,D,E,I,J>
PL1003 8Z-KT1-651-010 LAMP,9V-85MA<A,G,H>

PL1003 8A-KT7-655-010 LAMP,9V-50MA<B,D,E,I,J>
SW1001 87-A90-001-080 C-SW,TACT SKQMAL
SW1002 87-036-251-080 SW,T CT 6X3.5 160
SW1003 87-036-251-080 SW,T CT 6X3.5 160
SW1004 87-A90-001-080 C-SW,TACT SKQMAL

SW1005 87-036-251-080 SW,T CT 6X3.5 160
SW1006 87-036-251-080 SW,T CT 6X3.5 160
SW1007 87-036-251-080 SW,T CT 6X3.5 160
SW1008 87-036-251-080 SW,T CT 6X3.5 160
SW1009 87-A90-001-080 C-SW,TACT SKQMAL

SW1010 87-036-251-080 SW,T CT 6X3.5 160
SW1011 87-036-251-080 SW,T CT 6X3.5 160
SW1012 87-A90-001-080 C-SW,TACT SKQMAL
SW1013 87-036-251-080 SW,T CT 6X3.5 160
SW1014 87-A90-001-080 C-SW,TACT SKQMAL

SW1015 87-036-251-080 SW,T CT 6X3.5 160
SW1016 87-A91-597-010 SW,RTRY SIM-026MT

AUX C.B

J1401 85-HRL-623-010 JACK,3.5 ST BLK

RDS C.B<A,B,C,D,E,F>

C1101 87-012-149-080 C-CAP,S 30P-50 CH<A,B,C,D,E,F>
C1102 87-010-315-080 C-CAP,S 27P-50 CH<A,B,C,D,E,F>
C1103 87-010-175-080 CAP 560P<A,B,C,D,E,F>
C1104 87-010-196-080 CHIP CAPACITOR,0.1-25
<A,B,C,D,E,F>

C1105 87-012-157-080 C-CAP,S 330P-50 CH<A,B,C,D,E,F>
C1106 87-010-495-040 CAP,E 2.2-50 GAS<A,B,C,D,E,F>
SVR1101 87-024-437-080 SFR100K,RH063EC<A,B,C,D,E,F>
X1101 87-A70-091-010 VIB,XTAL 4.332MHZ CSA-309

<A,B,C,D,E,F>

LED C.B<C,F>

LED1008 87-A40-814-080 C-LED,SEL2E10C BLUE<C,F>

MECHA C.B

REF. NO PART NO. KANRI DESCRIPTION

NO.

REF. NO PART NO. KANRI DESCRIPTION

NO.

87

SCHEMATIC DIAGRAM-1 [CT-FR930M YZ]

00000

0

7.4
0

003.8

4.8

0
0

0
0

0

8.8

0
0

007.8
0

8.4

8.4

0.4

2.2

0
0

2.9

2.9

2.9

2.9

0
0

0000004.9

4.9

0
0

3.9

1.1

8.4

8.4

1.7
0

0 0.3 0.4 0.2 4.4 4.4 14 14 0.4 0.4

4.8

4.8

4.8

4.8

0

0

0

0

0

0

4.8

4.8

4.8

4.84.8

4.8

4.8

4.84.8

4.8 4.8

4.8

4.8

4.8

4.8

4.8

4.8

4.8

4.8

4.8

4.8

4.8

9.2

4.8

4.8

4.8

4.8

4.8

4.8

4.8

4.8

4.8

3.1

2.8

2.8

2.8

2.8

2.8

2.8

13

14.314.314.3

2.8

4.8

3.8

2.4

3.1

2.8

3.1

3.1

0

0

0

0

0

0

0

4.8

3.6

3.6

4.8

0

0

0

0

0

0

0

0

0.3

0.15

3.9

0

4.3

3.5/0

3.5/0

0/4.3

2.7/0

0/4.5

4.4/4.3

0

0

0

0

0

00000

0

0

4.3

3.1

0

0

0

0

0

0

0

0/3.8

0/3.8

0

3.9

3.4

0

0

0

3.6

0

1.5

1.5

3.6

4.8

5.0

0

0

0

000

0

000

0

0

0

3.8

1.6

3.8

3.7

3.6

4.4

0.15

0

00

0

2.4 2.4 2.5

2.1

4.9

2.4 2.5

2.5

4.9

2.5

2.4

2.5

4.7

5.8 4.7

4.7

4.7

4.7

4.7

4.7

4.7

4.7

4.7

9.2

9.4

4.7

4.7

4.7

4.7

4.7

5.9

5.9

0.28

0

0

0

4.9

2.5

2.5

4.7

MOTOR DRIVE

CNA802

CNA801

4.8 4.80

0.5

0.5 0.5 0.5 0

109

SCHEMATIC DIAGRAM-2 [CT-FR730M YZ, FRV735M YZ, FR707 YZ, FR710 YZ, FRV715 YZ]

MOTOR DRIVE

CNA801

CNA802

1211

SCHEMATIC DIAGRAM-3 [CT-FX930M YU, YH]

Q109,Q110

TUNER

SWITCHING

CON201

PH

13

1

234567

A

B

C

D

E

F

G

H

I

J

WIRING-1 [EQ/DOLBY, EQ C.B]

<CT-FR930M(YZ)/FX930M(YU)/FX930M(YH)> <CT-FR930M(YZ)/FX930M(YU)/FX930M(YH)>

CT-FR730M(YZ)/FRV735M(YZ)/FR707(YZ)/

FR710(YZ)/FRV715(YZ)/FX730M(YU)

CT-FR730M(YZ)/FRV735M(YZ)/FR707(YZ)/

FR710(YZ)/FRV715(YZ)/FX730M(YU)

14

1

234567

A

B

C

D

E

F

G

H

I

J

WIRING-2 [CONTROL, MECHA C.B]

1615

SCHEMATIC DIAGRAM-4 [CT-FX730M YU, YH]

TUNER PACK

MOTOR DRIVE

CON272

1817

IC BLOCK DIAGRAM-1

VDD

VSS

VSS

IC, HA12192F

IC, LB1641 IC, NJM2072M

IC, SAA6579T

DIFFERENCE TABLE

[This table listes the different components marked with asterisks (*) in the MAIN CB]

Ref No. A B C D E F G H I J
R402 A B C G H I J
R403 A B C G H I J
R404 A B C G H I J
R405 A B C G H I J
R406 A B C G H I J
R407 A B C G H I J
R408 A B C G H I J
R409 A B C G H I J
R410 A B C G H I J
R411 A B C G H I J
R709 A B C G H I J
R710 A B C G H I J
R711 A B C G H I J
R712 A B C G H I J
R713 A B C G H I J
R714 A B C G H I J
R736 G H I J
R737 G H I J
R738 E F
R739 E F
R743 B C D E F I J
R901 A G H
R902 A G H
R903 A G H
R904 A G H
R905 A G H
R906 A G H
R907 A G H
R1103 A B C D E F
R1104 A B C D E F
R1201 G H I J
R1202 G H I J
R1203 G H I J
R1204 G H I J
R1205 G H I J
R1206 G H I J
R1207 G H I J
R1208 G H I J
R1209 G H I J
R1210 G H I J
R1211 G H I J
R1212 G H I J
R1217 G H I J
R1218 G H I J
R1219 G H I J
R1301 A B C D E F
R1302 A B C D E F
SVR1101 A B C D E F

Ref No. A B C D E F G H I J
C401 A B C G H I J
C402 A B C G H I J
C901 A G H
C902 A G H
C903 A G H
C904 A G H
C905 A G H
C906 A G H
C1107 A B C D E F
C1201 G H I J
C1202 G H I J
C1203 G H I J
C1204 G H I J
C1213 G H I J
C1214 G H I J
C1217 G H I J
C1218 G H I J
C1301 A B C D E F
CN801 A B C D E F
CN802 A B C D E F
CNA202 A G H
CON801 G H I J
D401 A B C G H I J
D402 A B C G H I J
D403 A B C G H I J
D404 A B C G H I J
D405 A B C G H I J
D406 A B C G H I J
D711 A G H
D713 A G H
D714 A B C D E F
D715 G H I J
D716 A G H
D720 A G H
D809 B C D E F I J
D810 B C D E F I J
D721 A B C D E F
IC901 A G H
IC1201 G H I J
J401 A B C G H I J
Q401 A B C G H I J
Q402 A B C G H I J
Q817 B C D E F I J
Q818 B C D E F I J
Q1101 A B C D E F
Q1201 G H I J
Q1202 G H I J
Q1301 A B C D E F
R401 A B C G H I J

A
B
C
D
E
F
G
H

I
J

CT-FR930M
CT-FR730M
CT-FRV735M
CT-FR707
CT-FR710
CT-FRV715
CT-FX930M
CT-FX930M
CT-FX730M
CT-FX730M

YZ
YZ
YZ
YZ
YZ
YZ
YU
YH
YU
YH

TYPE SUFFIXMODEL NAME