Aiwa CT-FR930M Service Manual
CT-FR930M
YZ
CT-FR730M
CT-FRV735M
CT-FR707
CT-FR710
CT-FRV715
CT-FX930M
CT-FX730M
YZ
YZ
YZ
YZ
YZ
YU YH
YU YH
SERVICE MANUAL
STEREO CAR
CASSETTE RECEIVER
This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
(S/M Code No. 09-003-342-9T1).
BASIC TAPE MECHANISM : CDS-801AW1
S/M Code No. 09-003-342-9R1
REVISION
DATA
SPECIFICATIONS
RADIO SECTION
(FM)
Frequency Range [YZ]: 87.5 MHz–108 MHz
(50-kHz steps)
Frequency Range [YH,YU]: 87.5 MHz-108 MHz
(50-kHz steps)
87.5 MHz–108 MHz
(100-kHz steps)
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 80 dB
Frequency Response: 30 Hz-15,000 Hz
S/N Ratio: 63 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 70 dB
Capture Ratio: 3 dB
(MW) [YZ]
Frequency Range: 531 kHz–1,602 kHz
(9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
(AM(MW)) [YH, YU]
Frequency Range: 530 kHz–1,710 kHz
(10-kHz steps)
531 kHz–1,620 kHz
(9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
TAPE SECTION
Tape Speed: 4.8 cm/sec. (17/8 ips)
S/N Ratio (normal): 50 dB
S/N Ratio (metal): DOLBY-NR OFF 54 dB
[CT-FR930M,FX930M] DOLBY-NR ON 64 dB
Frequency Response: 40 Hz–14,000 Hz (normal)
40 Hz–16,000 Hz (metal)
Stereo Separation: 40 dB
FF/REW Time: 95 sec. (C-60)
AUDIO SECTION
Max. Power Output: 45 W x 4 channels
AUX IN INPUT
Input Sensitivity (Load impedance)
AUX IN: 300 mV (10 kΩ)
GENERAL
Power-Supply Voltage: 14.4 V (11 to 16 V allowable),
DC, negative ground
Load Impedance: 4 Ω
Tone Control: Bass ±10 dB at 100 Hz
Treble ±10 dB at 10 kHz
Preamp Output Voltage (load impedance):
2.2 V (10 kΩ) [YZ]
4.0 V (10 kΩ) [YU,YH]
Installation size: 182(W) x 53(H) x 155(D) mm
(71/4(W) x 21/8(H) x 61/8(D) inches)
(LW) [YZ]
Frequency Range: 144 kHz–288 kHz
Steering-wheel-mounted remote control unit
Dimensions: approx. 67(W) x 26(H) x 27(D) mm
(1-kHz/9-kHz steps)
Usable Sensitivity: 30 µV (30 dB)
•
Design and specifications are subject to change without notice.
•
Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation.
•
“DOLBY”, and the double-D symbol are trademarks of Dolby
Laboratories Licensing Corporation.
ACCESSORIES LIST
REF. NO PART NO. KANRI DESCRIPTION
NO.
1 8A-KT1-901-010 IB,YZ(9L) FR930M<A>
1 8A-KT3-901-010 IB,YZ(9L) FR730M,FRV735M<B,C>
1 8A-KT3-901-010 IB,YZ(9L) FR730M,FRV735M<D,E,F>
1 8A-KT5-901-010 IB,YU(3L) 930M<G>
1 8A-KT5-907-010 IB,YH(E CK CH A) 930M<H>
1 8A-KT7-901-010 IB,YU(3L) 730M<I>
2 8A-KT3-902-010 IB,INST,YZ (9L)-A<A,B,C,D,E,F>
2 8A-KT5-902-010 IB,INST,YU,YL (3L,P)<G,I>
2 8A-KT5-908-010 IB,INST,YH,Y (E CK CH A)-A<H>
3 R8-AZR-190-040 AZR-1 RCKCGNF
4 8Z-KT1-625-010 CONN ASSY,16P SOC016<G,H,I,J>
5 86-KT1-237-010 HLDR,REAR MTG
6 87-B10-141-010 NUT,5 TYPE-2
7 87-B10-143-010 UT1+5-15 W/O SLOT
8 87-B10-144-010 W,5.2-10-0.5
9 88-KT1-247-010 S-SCREW,HEXAGON
10 8Z-KT1-231-010 HLDR,HALF -T
11 8Z-KT1-232-010 KEY,REMOVE -T
12 8Z-KT1-251-010 S-SCREW,5*6 TH+ TAPPING ST
13 8Z-KT1-030-010 CASE,DFP -T
REF. NO PART NO. KANRI DESCRIPTION
14 88-KT1-250-010 S-SCREW,THIN HEAD+2.6-4 BLK
15 87-B10-145-010 W-SPR,5.3-8.5-1.5
16 88-KC4-255-010 S-SCREW,HEX-SOC+3-3.5 BLK
17 88-KC4-257-010 KEY,HEXAGON WRENCH
18 88-KC4-057-010 BELT, HRC
19 88-KC4-053-010 HLDR,BELT HRC
(23/4(W) x 11/16(H) x 11/8 (D) inches)
(excluding holder, battery)
approx. 38 g (1.33 oz.)
(including holder, battery)
NO.
TYPE SUFFIXMODEL NAME
CT-FR930M
A
CT-FR730M
B
CT-FRV735M
C
CT-FR707
D
CT-FR710
E
CT-FRV715
F
CT-FX930M
G
CT-FX930M
H
CT-FX730M
I
CT-FX730M
J
YZ
YZ
YZ
YZ
YZ
YZ
YU
YH
YU
YH
2
ELECTRICAL MAIN PARTS LIST
REF. NO PART NO. KANRI DESCRIPTION
IC
87-A20-233-010 C-IC,HA12192F<A,G,H>
87-002-394-010 IC,LB1641
87-A21-538-010 IC,KIA2025P<EXCEPT A,G,H>
8Z-KT1-622-010 C-IC,LC75374E
87-A21-562-010 IC,LA4743B
87-A21-531-030 C-IC,UPD178006A-XXX<I,J>
87-A21-594-030 C-IC,UPD178016AGC-559-3B9<G,H>
87-A21-530-030 C-IC,UPD178018A-XXX<A,B,C,D,E,F>
87-002-689-080 IC,NJM2072M<A,G,H>
87-A21-532-030 C-IC,LC75817W-8720<A,G,H>
88-KT1-608-010 C-IC,LC75854W<EXCEPT A,G,H>
87-A90-951-010 RCR UNIT,SBX1971-52
88-KT1-607-080 C-IC,SAA6579T<A,B,C,D,E,F>
87-001-611-080 IC,NJM3403M<G,H,I,J>
TRANSISTOR
87-A30-468-040 C-TR,KRC102S-RTK
87-A30-470-040 C-TR,KTC3875SY-RTK
87-A30-471-040 C-TR,KTA1504SY-RTK
87-A30-469-040 C-TR,KRC111S-RTK
87-A30-295-010 TR,KRA226M
87-A30-472-040 C-TR,KRA226S-RTK
87-026-576-080 C-TR,DTC343TK
87-A30-467-040 C-TR,KRA111S-RTK
8Z-KTH-627-080 TR,KTA1273Y
87-A30-476-010 TR,KTA1046Y
87-A30-063-080 C-TR,KRA104S
8Z-KTH-626-080 TR,KTC3203Y
87-A30-483-040 C-TR,KRC114S
89-423-953-010 TR,2SD2395F
DIODE
87-020-465-080 DIODE,1SS133 (110MA)
87-A40-350-080 ZENER,MTZJ 4.7C
87-A40-504-040 C-DIODE,KDS184
87-017-932-080 ZENER,MTZJ6.2B
87-A40-829-040 DIODE,KDS196-RTK
87-A40-830-040 DIODE,KDS226-RTK
87-001-783-080 DIODE,1N4002
87-A40-250-080 C-DIODE,DAN217
87-A40-819-040 C-ZENER,STZ6.8T
87-020-590-080 C-ZENER,02CZ10Y
87-027-262-010 LEDE,TLR-124(RED)
87-020-585-080 CHIP-ZENER,02CZ6.2Y
87-020-583-080 CHIP-ZENER,02CZ5.1Y
87-A40-337-080 ZENER,MTZJ 6.8B
87-070-022-010 DIODE,IN5402 (RECT)
87-070-334-080 ZENER,MTZJ10A
87-A40-869-080 C-ZENER,02CZ11X<EXCEPT A,G,H>
87-017-931-080 ZENER,MTZJ5.6B
87-A40-523-080 ZENER,MTZJ9.1B
87-A40-814-080 LED,SEL2E10C BLUE<C,F>
MAIN C.B
C101 87-010-322-080 C-CAP,S 100P-50 CH
C102 87-010-197-080 CAP, CHIP 0.01 DM
C103 87-010-322-080 C-CAP,S 100P-50 CH
C104 87-010-186-080 CAP,CHIP 4700P
C105 87-010-490-040 CAP, ELECT 0.1-50
C106 87-010-198-080 CAP, CHIP 0.022
C107 87-010-553-040 CAP,E 47-16 GAS
C108 87-010-196-080 CHIP CAPACITOR,0.1-25
C109 87-010-553-040 CAP,E 47-16 GAS
C110 87-010-194-080 CAP, CHIP 0.047
C111 87-010-213-080 C-CAP,S 0.015-50 B<EXCEPT G,I>
C111 87-010-198-080 C-CAP,S 0.022-25 KB<G,I>
NO.
REF. NO PART NO. KANRI DESCRIPTION
C112 87-010-213-080 C-CAP,S 0.015-50 B<EXCEPT G,I>
C112 87-010-198-080 C-CAP,S 0.022-25 KB<G,I>
C113 87-010-194-080 CAP, CHIP 0.047
C114 87-010-194-080 CAP, CHIP 0.047
C115 87-010-197-080 CAP, CHIP 0.01 DM
C116 87-010-495-080 CAP,E2.2-50
C117 87-010-197-080 CAP, CHIP 0.01 DM
C118 87-010-197-080 CAP, CHIP 0.01 DM
C119 87-010-553-040 CAP,E 47-16 GAS
C120 87-010-196-080 CHIP CAPACITOR,0.1-25
C301 87-010-494-040 CAP,E 1-50 GAS
C302 87-010-494-040 CAP,E 1-50 GAS
C401 87-010-494-040 CAP,E 1-50 GAS<EXCEPT D,E,F>
C402 87-010-494-040 CAP,E 1-50 GAS<EXCEPT D,E,F>
C501 87-010-494-040 CAP,E 1-50 GAS
C502 87-010-494-040 CAP,E 1-50 GAS
C503 87-010-494-040 CAP,E 1-50 GAS
C504 87-010-494-040 CAP,E 1-50 GAS
C505 87-010-184-080 CHIP CAPACITOR 3300P(K)
C506 87-010-184-080 CHIP CAPACITOR 3300P(K)
C507 87-010-198-080 CAP, CHIP 0.022
C508 87-010-198-080 CAP, CHIP 0.022
C509 87-010-498-040 CAP,E 10-16 GAS
C510 87-010-498-040 CAP,E 10-16 GAS
C511 87-A11-177-080 C-CAP,S 0.15-16 K B
C512 87-A11-177-080 C-CAP,S 0.15-16 K B
C513 87-A11-177-080 C-CAP,S 0.15-16 K B
C514 87-A11-177-080 C-CAP,S 0.15-16 K B
C515 87-010-498-040 CAP,E 10-16 GAS
C516 87-010-498-040 CAP,E 10-16 GAS
C517 87-010-555-040 CAP,E 100-10 SRE
C518 87-010-498-040 CAP,E 10-16 GAS
C519 87-010-196-080 CHIP CAPACITOR,0.1-25
C520 87-010-494-040 CAP,E 1-16 GAS
C521 87-010-805-080 CAP, S 1-16
C522 87-010-805-080 CAP, S 1-16
C523 87-010-805-080 CAP, S 1-16
C524 87-010-494-040 CAP,E 1-50 GAS
C525 87-016-526-080 C-CAP,S 0.47-16 BK
C526 87-016-526-080 C-CAP,S 0.47-16 BK
C527 87-016-526-080 C-CAP,S 0.47-16 BK
C528 87-010-196-080 CHIP CAPACITOR,0.1-25
C529 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C530 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C531 87-010-178-080 CHIP CAP 1000P
C601 87-A11-177-080 C-CAP,S 0.15-16 K B
C602 87-A11-177-080 C-CAP,S 0.15-16 K B
C603 87-A11-177-080 C-CAP,S 0.15-16 K B
C604 87-A11-177-080 C-CAP,S 0.15-16 K B
C605 87-010-180-080 C-CER 1500P
C606 87-010-180-080 C-CER 1500P
C607 87-010-180-080 C-CER 1500P
C608 87-010-180-080 C-CER 1500P
C609 87-010-068-040 CAP E 0.22-50 5L
C610 87-010-552-040 CAP,E 22-16 GAS
C611 87-010-198-080 CAP, CHIP 0.022
C612 8Z-KT1-633-000 CAP,E 3300U-16 105 PW
C613 87-010-553-040 CAP,E 47-16 GAS
C614 87-010-196-080 CHIP CAPACITOR,0.1-25
C615 87-010-196-080 CHIP CAPACITOR,0.1-25
C616 87-010-196-080 CHIP CAPACITOR,0.1-25
C617 87-010-196-080 CHIP CAPACITOR,0.1-25
C618 87-010-322-080 C-CAP,S 100P-50 CH
C619 87-010-322-080 C-CAP,S 100P-50 CH
C620 87-010-322-080 C-CAP,S 100P-50 CH
C621 87-010-322-080 C-CAP,S 100P-50 CH
C622 87-010-322-080 C-CAP,S 100P-50 CH
C623 87-010-322-080 C-CAP,S 100P-50 CH
C624 87-010-322-080 C-CAP,S 100P-50 CH
C625 87-010-322-080 C-CAP,S 100P-50 CH
NO.
3
REF. NO PART NO. KANRI DESCRIPTION
C626 87-010-196-080 CHIP CAPACITOR,0.1-25
C701 87-010-490-040 CAP, ELECT 0.1-50
C702 87-010-196-080 CHIP CAPACITOR,0.1-25
C703 87-010-314-080 C-CAP,S 22P-50 CH
C704 87-010-315-080 C-CAP,S 27P-50 CH
C705 87-010-196-080 CHIP CAPACITOR,0.1-25
C707 87-016-039-090 CAP,DL 0.022F-5.5 Z 70 FM
C708 87-010-322-080 C-CAP,S 100P-50 CH
C709 87-010-322-080 C-CAP,S 100P-50 CH
C710 87-010-178-080 CHIP CAP 1000P
C711 87-010-197-080 CAP, CHIP 0.01 DM
C712 87-010-197-080 CAP, CHIP 0.01 DM
C713 87-010-197-080 CAP, CHIP 0.01 DM
C714 87-010-197-080 CAP, CHIP 0.01 DM
C801 87-010-182-080 C-CAP,S 2200P-50 B
C802 87-010-182-080 C-CAP,S 2200P-50 B
C803 87-010-196-080 CHIP CAPACITOR,0.1-25
C804 87-010-552-040 CAP,E 22-16 GAS
C805 87-010-555-040 CAP,E 100-10 GAS
C806 87-010-935-040 CAP,E 220-16 M VR
C807 87-010-197-080 CAP, CHIP 0.01 DM
C808 87-010-197-080 CAP, CHIP 0.01 DM
C809 87-010-553-040 CAP,E 47-16 GAS
C810 87-010-198-080 CAP, CHIP 0.022
C901 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
C902 87-010-553-040 CAP,E 47-16 GAS<A,G,H>
C903 87-A10-189-040 CAP,E 220-10<A,G,H>
C904 87-010-495-040 CAP,E 2.2-50 GAS<A,G,H>
C905 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
C906 87-010-194-080 CAP, CHIP 0.047<A,G,H>
C1107 87-010-197-080 CAP, CHIP 0.01 DM<A,B,C,D,E,F>
C1201 87-010-805-080 CAP, S 1-16<G,H,I>
C1202 87-010-805-080 CAP, S 1-16<G,H,I,J>
C1203 87-010-805-080 CAP, S 1-16<G,H,I,J>
C1204 87-010-805-080 CAP, S 1-16<G,H,I,J>
C1205 87-010-805-080 CAP, S 1-16
C1206 87-010-805-080 CAP, S 1-16
C1207 87-010-805-080 CAP, S 1-16
C1208 87-010-805-080 CAP, S 1-16
C1209 87-010-805-080 CAP, S 1-16
C1210 87-010-805-080 CAP, S 1-16
C1211 87-010-805-080 CAP, S 1-16
C1212 87-010-805-080 CAP, S 1-16
C1213 87-012-140-080 CAP 470P<G,H,I,J>
C1214 87-012-140-080 CAP 470P<G,H,I,J>
C1215 87-012-140-080 CAP 470P
C1216 87-012-140-080 CAP 470P
C1217 87-010-112-040 CAP,E 100-16 SME<G,H,I,J>
C1218 87-010-555-040 CAP,E 100-10 GAS<G,H,I,J>
C1219 87-010-322-080 C-CAP,S 100P-50 CH
C1301 87-010-198-080 CAP, CHIP 0.022<A,B,C,D,E,F>
CN801 8Z-KT1-624-010 CONN,16P SOC017<G,H,I,J>
CN1101 8Z-KTH-613-010 CONN,3P HEADER-ANGLE<A,B,C,D,E,F>
CN1102 8Z-KTH-613-010 CONN,3P HEADER-ANGLE<A,B,C,D,E,F>
CNA201 8A-KT7-651-010 CONN ASSY,5P MAIN-EQ
CNA251 8A-KT5-661-010 CONN ASSY,12P MAIN-CONTROL
CNA801 8A-KT1-631-010 CONN ASSY,8P ISO-BLACK-
CNA802 8A-KT1-632-010 CONN ASSY,8P ISO-WHITE-A
CNA1401 8A-KT5-654-010 CONN ASSY,6P MAIN-TAKE UP
CNA1402 8A-KT5-652-010 CONN ASSY,10P MAIN-TAKE UP
F801 8Z-KC1-621-010 FUSE,15A 32V
J101 8Z-KT1-614-010 ANT,AW-002
J401 8A-KC7-620-010 JACK,DIN 13 P SKDS1302<EXCEPT D,E,F>
J1201 88-KTA-604-010 JACK,PIN 4P V-TYPE<B,C>
J1201 87-A61-224-010 JACK,PIN 4P XR-401<EXCEPT B,C>
L101 87-003-143-080 COIL 4.7 UH
L102 8Z-KT1-619-010 COIL,68MH K7-D
L301 87-003-143-080 COIL 4.7 UH
NO.
<A,B,C,D,E,F>
<A,B,C,D,E,F>
REF. NO PART NO. KANRI DESCRIPTION
L701 87-003-149-080 COIL,47UH
L801 8Z-KT1-615-010 FLTR,AMORPHOUS -CHOKE 370UH
L1201 87-003-143-080 COIL 4.7 UH
MIC901 8Z-KT1-643-090 MIC,EMC KUC2123-040245DB<A,G,H>
PL801 8A-KT7-655-010 LAMP,9V-50MA
SW701 87-A91-070-010 SW,TACT SKHHLV
SW702 87-036-109-010 PUSH SWITCH
SW703 87-A91-152-010 SW,SL 1-1-2 SSSS212-11-A
TU101 8A-KC8-620-010 TU UNIT, FAE347-A11<A,B,C,D,E,F>
TU101 8A-KC8-621-010 TU UNIT, FAE347-A12<G,H,I,J>
W301 8A-KT5-611-010 F-CABLE,3P 40MM
X701 87-A70-175-010 VIB,XTAL 4.5MHZ AT-49
CONTROL C.B
C251 87-010-553-040 CAP,E 47-16 GAS
C252 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C253 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C254 87-010-196-080 CHIP CAPACITOR,0.1-25
C255 87-012-141-080 CHIP-CAPACITOR,0.22-16F
C256 87-010-497-040 CAP,E 4.7-35 GAS
C257 87-010-197-080 CAP, CHIP 0.01 DM
C258 87-010-553-040 CAP,E 47-16 GAS
CON251 87-099-203-010 CONN,10P 6216 H
CON252 87-A61-262-010 CONN,12P V B12B-ZR
EQ/DOLBY C.B<A,G,H>
C201 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C202 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C203 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C204 87-A11-550-080 CHIP CAP 820P-50 KB<A,G,H>
C205 87-010-426-080 CAP, CHIP 0.012 KB<A,G,H>
C206 87-010-426-080 CAP, CHIP 0.012 KB<A,G,H>
C207 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C208 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C209 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C210 87-010-494-040 CAP,E 1-50 M 5L SRE<A,G,H>
C211 87-010-494-040 CAP,E 1-50 M 5L SRE<A,G,H>
C212 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C213 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C214 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C215 87-010-197-080 CAP, CHIP 0.01 DM<A,G,H>
C216 87-010-197-080 CAP, CHIP 0.01 DM<A,G,H>
C218 87-010-555-040 CAP,E 100-10 GAS<A,G,H>
C219 87-010-196-080 CHIP CAPACITOR,0.1-25<A,G,H>
C220 87-A11-548-080 C-CAP,S 560P-50 KB<A,G,H>
C221 87-A11-548-080 C-CAP,S 560P-50 KB<A,G,H>
C222 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C223 87-010-494-040 CAP,E 1-50 GAS<A,G,H>
C224 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
C225 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
C226 87-010-497-040 CAP,E 4.7-35 GAS<A,G,H>
CON201 87-009-349-010 CONN,6P PH H<A,G,H>
CON202 87-A61-260-010 CONN,9P V B9B-ZR<A,G,H>
SVR201 87-024-433-080 SFR,10K RH063EC<A,G,H>
SVR202 87-024-433-080 SFR,10K RH063EC<A,G,H>
EQ C.B<EXCEPT A,G,H>
C271 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C272 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C273 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C274 87-A11-550-080 C-CAP,S 820P-50 K B<EXCEPT A,G,H>
C275 87-010-552-040 CAP,E 22-16 GAS<EXCEPT A,G,H>
C276 87-010-552-040 CAP,E 22-16 GAS<EXCEPT A,G,H>
C277 87-010-426-080 C-CAP,S 0.012-25 B<EXCEPT A,G,H>
C278 87-010-426-080 C-CAP,S 0.012-25 B<EXCEPT A,G,H>
C279 87-010-494-040 CAP,E 1-50 GAS<EXCEPT A,G,H>
C280 87-010-494-040 CAP,E 1-50 GAS<EXCEPT A,G,H>
NO.
4
Loading...