Page 1
CA-DW539
U(ST)
SERVICE MANUAL
COMPACT DISC CARRY
COMPONENT SYSTEM
BASIC TAPE MECHANISM : ZZM-2 PR3NC1
BASIC CD MECHANISM : KSM213CDM
S/M Code No. 09-025-354-3N2
DATA
Page 2
SPECIFICATIONS
Design and specifications are subject to change without notice.
•
-2-
Page 3
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
This set employs laser. Therefore, be sure to follow carefully the instructions
below when servicing.
WARNING!
WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE
EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER
BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF
MORE THAN 30cm FROM THE SURFACE OF THE OBJECTIVE LENS
ON THE OPTICAL
Caution: Invisible laser radiation when open
and interlocks defeated avoid exposure to
beam.
Advarsel:Usynling laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
VAROITUS!
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa mainitulla tavalla
saattaa altistaa käyt-täjän turvallisuusluokan 1 ylittävälle näkymättömälle
lasersäteilylle.
VARNING!
Om apparaten används på annat sätt än vad som specificeras i denna
bruksanvising, kan användaren utsättas för osynling laserstrålning, som
överskrider gränsen för laserklass 1.
CAUTION
Use of controls or adjustments or performance of procedures other than
those specified herein may result in hazardousradiation exposure.
ATTENTION
L'utilisation de commandes, réglages ou procédures autres que ceux
spécifiés peut entraîner une dangereuse exposition aux radiations.
ADVARSEL!
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer ude af funktion.
Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1 LASER product.
The CLASS 1 LASER PRODUCT label is located on the rear exterior.
CLASS 1
KLASSE 1
LUOKAN 1
KLASS 1
LASER PRODUCT
LASER PRODUKT
LASER LAITE
LASER APPARAT
Precaution to replace Optical block
(KSS-213C)
Body or clothes electrostatic potential could ruin laser diode
in the optical block. Be sure ground body and workbench,
and use care the clothes do not touch the diode.
1) After the connection, remove solder shown in the
right figure.
-3-
Page 4
ACCESSORIES PARTS LIST -1/1
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
O AS1001 8B-CT5-913-010 IB,U(ESF)FM CA-DW539 a
O AS1002 8A-CLB-961-210 RC UNIT,RC-AAT11 a
O AS1003 87-A80-109-010 AC CORD,HK7281 BLK U a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-4-
Page 5
ELECTRICAL PARTS LIST - 1/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
CD 0 C 0401 87-010-403-080 ELEC CAP 3.3u/50V (M) SME TP= a
CD 0 C 0402 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0403 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
CD 0 C 0404 87-010-248-080 ELEC CAP 220U/10V (M) SME a
CD 0 C 0405 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0406 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
CD 0 C 0407 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
CD 0 C 0408 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a
CD 0 C 0409 87-010-248-080 ELEC CAP 220U/10V (M) SME a
CD 0 C 0410 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
CD X C 0411 SC-CBK-G81-54S CHIP CAP 0.15UF/50V (K) B a
CD 0 C 0412 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
CD 0 C 0413 87-016-369-080 CHIP CAP 0.033U/25V (K) B TP= a
CD 0 C 0414 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
CD 0 C 0416 87-010-545-080 ELEC CAP 0.22UF/50V (M) SEM T a
CD 0 C 0417 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
CD 0 C 0418 87-010-213-080 CHIP CAP 0.015u/25V (K) B TP= a
CD 0 C 0419 87-A11-608-080 CHIP CAP S 0.33UF/25V KB a
CD 0 C 0420 87-016-369-080 CHIP CAP 0.033U/25V (K) B TP= a
CD X C 0421 SC-CBK-G81-54S CHIP CAP 0.15UF/50V (K) B a
CA-DW539
U2
CD 0 C 0422 87-010-183-080 CHIP CAP S 2700P/50V (K) B TP a
CD 0 C 0423 87-010-992-080 CHIP CAP S 0.047UF/25V (K) B a
CD 0 C 0424 87-010-220-080 CHIP CAP S 0.018uF/25V (K)B a
CD 0 C 0425 87-012-140-080 CHIP.CAP,S 470P/50V (J) CH TP a
CD 0 C 0426 87-A11-608-080 CHIP CAP S 0.33UF/25V KB a
CD 0 C 0428 87-010-426-080 CHIP CAP S 0.012U/25V (K) B T a
CD 0 C 0429 87-010-186-080 CHIP CAP S 4700P/50V (K) B TP a
CD 0 C 0430 87-012-156-080 CHIP CAP,S 220P/50V (J) CH TA a
CD 0 C 0431 87-010-545-080 ELEC CAP 0.22UF/50V (M) SEM T a
CD 0 C 0432 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
CD 0 C 0433 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
CD 0 C 0434 87-010-184-080 CHIP CAP S 3300PF/50V (K) TP= a
CD 0 C 0435 87-018-134-080 AXIAL CAP 0.01U/50V (K) a
CD 0 C 0436 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
CD 0 C 0437 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
CD 0 C 0438 87-016-669-080 CHIP.CAP,S 0.1U/25V (K) B a
CD 0 C 0439 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
CD 0 C 0440 87-010-145-080 CHIP CAP S 1P/50V (C) CH a
CD 0 C 0441 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0442 87-010-311-080 CHIP CAP.S 12P/50V(J)CH a
CA-DW539
U2
CD 0 C 0445 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
CD 0 C 0446 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
CD 0 C 0447 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
CD 0 C 0448 87-010-315-080 CHIP.CAP,S 27P/50V (J) CH a
CD 0 C 0451 87-012-156-080 CHIP CAP,S 220P/50V (J) CH TA a
CD 0 C 0455 87-010-247-080 100UF/50V ELECTRICAL T=5mm a
CD 0 C 0457 87-010-312-080 CHIP CAP 15P/50V (J) CH TP=8m a
CD 0 C 0458 87-010-312-080 CHIP CAP 15P/50V (J) CH TP=8m a
CD 0 C 0459 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
CD 0 C 0460 87-015-819-080 CHIP.CAP 0.01U/50V (K) B TP=8 a
CD 0 C 0461 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0462 87-010-248-080 ELEC CAP 220U/10V (M) SME a
CD 0 C 0463 87-018-134-080 AXIAL CAP 0.01U/50V (K) a
CD 0 C 0465 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
CD 0 C 0466 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
CD 0 C 0467 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
CD 0 C 0469 87-012-154-080 CHIP.CAP,S 150P/50V (J) CH TP a
CD 0 C 0470 87-010-544-080 ELEC CAP 0.1uF/50V (M) SME TP a
CD 0 C 0471 87-015-785-080 CHIP.CAP 0.1UF/25V(Z) F TP=8m a
CD 0 C 0472 87-015-785-080 CHIP.CAP 0.1UF/25V(Z) F TP=8m a
CA-DW539
U2
CD 0 C 0473 87-015-785-080 CHIP.CAP 0.1UF/25V(Z) F TP=8m a
CD 0 C 0474 87-015-785-080 CHIP.CAP 0.1UF/25V(Z) F TP=8m a
CD 0 C 0475 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0476 87-010-236-080 ELEC CAP 1000uF/10V a
CD 0 C 0477 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0478 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
CD 0 C 0479 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0480 87-010-221-080 ELEC CAP 470u/10V (M) SME a
CD 0 C 0481 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
CD 0 C 0482 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
CD 0 C 0483 87-012-156-080 CHIP CAP,S 220P/50V (J) CH TA a
CD 0 C 0484 87-012-156-080 CHIP CAP,S 220P/50V (J) CH TA a
CD 0 C 0489 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
CD 0 C 0490 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
CD 0 C 0493 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CD 0 C 0494 87-018-134-080 AXIAL CAP 0.01U/50V (K) a
CD 0 C 0499 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
CD 0 C 4001 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
CD 0 C 4002 87-010-322-080 CHIP.CAP,S 100P/50V (J) CH TP a
CD 0 C 4003 87-010-322-080 CHIP.CAP,S 100P/50V (J) CH TP a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-5-
Page 6
ELECTRICAL PARTS LIST - 2/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
CD 0 C 4004 87-010-322-080 CHIP.CAP,S 100P/50V (J) CH TP a
CD 0 C 4005 87-010-322-080 CHIP.CAP,S 100P/50V (J) CH TP a
CD 0 C 4006 87-010-322-080 CHIP.CAP,S 100P/50V (J) CH TP a
CD 0 C 4007 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
CD 0 C 4010 87-018-209-080 AXIAL CAP 0.1UF/50V (Z) F TP= a
CD 0 C 4011 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
CD 0 C 4012 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
CD 0 C 4013 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
CD X C 4120 88-700-980-810 MYLAR CAP 0.056uF/50V (J) a
CD 0 CN 0401 87-A60-424-010 CONNECTOR FFC 16P (1.0mm) a
CD 0 CNA0402 8Z-CT6-631-010 CONNECTOR ASS’Y 6P a
CD S D 0401 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
CD S D 0402 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
CD S D 0403 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
CD 0 FFC0401 88-CT6-606-010 FF-CABLE,16P 1.0 a
CD S IC 0401 87-A20-446-010 CHIP IC LA9241ML a
CD S IC 0402 87-A21-319-010 CHIP IC LC78622NE a
CD S IC 0404 87-A21-093-010 IC LA6541D a
CD 0 L 0401 87-003-102-080 FIXED IND 10UH (K) TP=26mm a
CD 0 L 0402 87-003-102-080 FIXED IND 10UH (K) TP=26mm a
CA-DW539
U2
CD 0 L 0404 87-003-152-080 FIXED IND 100UH a
CD 0 L 0405 87-003-102-080 FIXED IND 10UH (K) TP=26mm a
CD 0 L 0406 87-008-372-080 BEADS CORE (BLO1RN1-A63.T6) T a
CD S Q 0401 87-A30-216-080 TR 2SA933AS(R) a
CD S Q 0402 89-113-187-080 TRANSISTOR 2SA1318T AA a
CD S Q 0403 87-A30-287-040 CHIP TRANSISTOR DTC114TKA T14 a
CD S Q 0404 87-A30-287-040 CHIP TRANSISTOR DTC114TKA T14 a
CD S Q 0407 87-A30-062-040 CHIP TR KRC104S a
CD S Q 0408 87-A30-062-040 CHIP TR KRC104S a
CD X R 0401 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
CD X R 0402 88-118-100-080 CHIP RES 1/10W 10ohm (J) TP= a
CD 0 R 0403 88-118-123-080 CHIP RES 1/10W (J) 12K ohm T a
CD 0 R 0405 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
CD 0 R 0406 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
CD 0 R 0408 88-118-683-080 CHIP RES 1/10W (J) 68Kohm T8 a
CD X R 0409 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
CD 0 R 0410 88-118-273-080 CHIP RES 27K 0805 a
CD X R 0411 88-118-561-080 CHIP RES 1/10W (J) 560ohm TP= a
CD 0 R 0412 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
CD X R 0413 88-118-393-080 CHIPRES 1/10W (J) 39Kohm TP=8 a
CA-DW539
U2
CD 0 R 0414 88-118-332-080 CHIP RES 1/10W (J) 3.3K 0805 a
CD 0 R 0415 88-118-273-080 CHIP RES 27K 0805 a
CD 0 R 0417 88-118-123-080 CHIP RES 1/10W (J) 12K ohm T a
CD 0 R 0418 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
CD X R 0419 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
CD X R 0420 88-118-333-080 CHIP RES 1/10W (J) 33K ohm T a
CD X R 0421 88-118-184-080 CHIP.RES,S 1/10W (J)180Kohm T a
CD 0 R 0423 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
CD X R 0424 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
CD X R 0425 88-118-563-080 CHIP RES 1/10W (J) 56Kohm TP= a
CD 0 R 0426 88-118-123-080 CHIP RES 1/10W (J) 12K ohm T a
CD 0 R 0427 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD X R 0428 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
CD X R 0429 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
CD X R 0430 88-128-682-080 CHIP RESISTOR 6.8K 1/8W 1206( a
CD X R 0431 88-118-274-080 CHIP RES,S 1/10W (J) 270Kohm a
CD X R 0432 88-118-274-080 CHIP RES,S 1/10W (J) 270Kohm a
CD 0 R 0433 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
CD 0 R 0434 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
CD 0 R 0435 88-118-223-080 CHIP RES 1/10W (J) 22Kohm TP a
CA-DW539
U2
CD X R 0436 88-118-183-080 CHIP RES 18K 0805 1/10W a
CD 0 R 0437 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD 0 R 0438 88-118-331-080 CHIP RES,S 1/10W (J) 330ohm T a
CD 0 R 0439 88-118-153-080 CHIP RES 1/10W (J) 15Kohm TP a
CD 0 R 0440 88-118-331-080 CHIP RES,S 1/10W (J) 330ohm T a
CD X R 0441 88-118-681-080 CHIP RES 1/10W (J) 680ohm TP a
CD 0 R 0442 88-118-273-080 CHIP RES 27K 0805 a
CD X R 0443 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
CD X R 0444 88-118-333-080 CHIP RES 1/10W (J) 33K ohm T a
CD 0 R 0445 88-118-153-080 CHIP RES 1/10W (J) 15Kohm TP a
CD 0 R 0446 88-118-273-080 CHIP RES 27K 0805 a
CD 0 R 0447 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD X R 0451 88-128-392-080 CHIP RES 1/8W 3.9K TP=8mm a
CD X R 0455 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
CD 0 R 0456 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
CD 0 R 0457 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD 0 R 0458 88-118-332-080 CHIP RES 1/10W (J) 3.3K 0805 a
CD 0 R 0460 88-118-683-080 CHIP RES 1/10W (J) 68Kohm T8 a
CD X R 0465 88-121-680-080 CARBON RES 1/6W (J) 68ohm TP= a
CD X R 0466 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-6-
Page 7
ELECTRICAL PARTS LIST - 3/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
CD X R 0467 88-118-333-080 CHIP RES 1/10W (J) 33K ohm T a
CD R 0469 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
CD X R 0475 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
CD X R 0476 88-118-229-080 CHIP RES 2.2ohm 1/10W TP=8mm a
CD 0 R 0477 88-121-103-080 CARBON RES 1/6W (J) 10Kohm TP a
CD X R 0478 88-128-104-080 CHIP RESISTOR 1/8W 100K 1206 a
CD 0 R 0479 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD 0 R 0480 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
CD 0 R 0481 88-118-273-080 CHIP RES 27K 0805 a
CD 0 R 0482 88-118-273-080 CHIP RES 27K 0805 a
CD X R 0483 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
CD X R 0484 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
CD 0 R 0485 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD 0 R 0486 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD 0 R 0487 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
CD 0 R 0488 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
CD X R 0489 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
CD X R 0495 88-118-821-080 CHIP RES 1/10W (J) 820ohm TP= a
CD X R 0496 88-128-821-010 CHIP RESISTOR 820ohm 1/8W 120 a
CD X R 0497 88-128-562-080 CHIP RESISTOR 5.6K 1/8W 1206 a
CA-DW539
U2
CD 0 R 0498 88-118-562-080 CHIP RES 1/10W(J) 5.6Kohm TP= a
CD 0 R 0530 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
CD 0 R 0531 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
CD 0 R 0532 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
CD 0 R 4001 88-121-101-080 CARBON RES 1/6W (J) 100ohm TP a
CD 0 R 4002 88-121-101-080 CARBON RES 1/6W (J) 100ohm TP a
CD X R 4003 88-121-272-080 CARBON RES 1/6W (J) 2.7Kohm T a
CD 0 R 4004 88-121-101-080 CARBON RES 1/6W (J) 100ohm TP a
CD 0 R 4005 88-121-101-080 CARBON RES 1/6W (J) 100ohm TP a
CD 0 R 4006 88-121-101-080 CARBON RES 1/6W (J) 100ohm TP a
CD 0 R 4007 88-118-125-080 CHIP RES,S 1/10W (J) 1.2Mohm a
CD 0 SFR0430 87-024-437-080 POTENTIAL METER 100KHZ a
CD 0 X 0401 8Z-CD5-633-010 CER RESONATOR 16.93MHZ (CSA16 a
FRONT 0 C 0601 87-010-313-080 CHIP.CAP,S 18P/50V (J) CH a
FRONT 0 C 0602 87-010-315-080 CHIP.CAP,S 27P/50V (J) CH a
FRONT 0 C 0603 87-010-317-080 CHIP.CAP,S 39P/50V (J) CH a
FRONT 0 C 0604 87-010-314-080 CHIP CAP 22P/50V (J) CH TP=8m a
FRONT 0 C 0605 87-012-184-080 CHIP CAP 33P/50V (J) CH TP=8m a
FRONT 0 C 0606 87-012-350-080 CHIP CAP (1206) 1UF/25V (F) Z a
FRONT 0 C 0607 87-012-566-080 CHIP CAP 0.01U/25V (Z) F a
CA-DW539
U2
FRONT 0 C 0608 87-010-197-080 CHIP.CAP,S 0.01U/25V (K) B TP a
FRONT 0 C 0609 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
FRONT 0 C 0610 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
FRONT 0 C 0611 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
FRONT 0 C 0612 87-010-221-080 ELEC CAP 470u/10V (M) SME a
FRONT 0 C 0613 87-010-402-080 ELEC CAP 2.2u/50V (M) SME TP= a
FRONT 0 C 0614 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
FRONT 0 C 0615 87-010-400-080 ELEC CAP 0.47U/50V (M) SME a
FRONT 0 C 0616 87-010-400-080 ELEC CAP 0.47U/50V (M) SME a
FRONT 0 C 0617 87-A11-552-080 CHIP CAP S 1200P/50V (K) B TP a
FRONT 0 C 0618 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
FRONT 0 C 0834 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
FRONT 0 C 0836 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
FRONT 0 C 0837 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
FRONT 0 C 0838 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
FRONT 0 C 0839 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
FRONT 0 C 0840 87-010-221-080 ELEC CAP 470u/10V (M) SME a
FRONT 0 C 0841 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
FRONT 0 C 0844 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
FRONT 0 C 6004 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a
CA-DW539
U2
FRONT 0 C 6011 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a
FRONT 0 CN 0205 8Z-CT9-641-010 CONNECTOR ASS’Y 2P 8Z-CT6-641 a
FRONT 0 CON0601 87-A60-109-010 CONNECTOR BASE 2P V (S2M-2W) a
FRONT S D 0601 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0602 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0611 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0612 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0615 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0616 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0623 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0625 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0628 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0820 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0821 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S D 0822 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
FRONT S IC 0601 8B-CT5-625-010 IC LC867132V5T98 (CPU) a
FRONT S IC 0602 87-A21-831-010 IC SPS-442-1-F1 a
FRONT 0 L 0601 87-003-149-080 FIXED IND 47 uH (K) T26 a
FRONT 0 L 0603 8B-CTA-971-010 FIXED IND 15UH a
FRONT 0 L 0605 87-008-372-080 BEADS CORE (BLO1RN1-A63.T6) T a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-7-
Page 8
ELECTRICAL PARTS LIST - 4/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
FRONT 0 L 0606 8B-CTA-971-010 FIXED IND 15UH a
FRONT 0 LCD0601 8B-CT5-601-010 LCD AIW4239-32P2N a
FRONT 0 LED0607 87-A41-050-040 LED BT-H203D-31 RED a
FRONT 0 LED0609 87-A41-050-040 LED BT-H203D-31 RED a
FRONT 0 LED0610 87-A41-050-040 LED BT-H203D-31 RED a
FRONT S Q 0601 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
FRONT S Q 0602 87-A30-216-080 TR 2SA933AS(R) a
FRONT S Q 0603 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
FRONT S Q 0605 87-026-464-080 D TRANSISTOR DTC114TSA TP a
FRONT S Q 0612 87-026-464-080 D TRANSISTOR DTC114TSA TP a
FRONT S Q 0616 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
FRONT S Q 0820 87-026-610-080 TR KTC3198-GR hFE=200~400 AI a
FRONT S Q 0822 87-026-610-080 TR KTC3198-GR hFE=200~400 AI a
FRONT S Q 0823 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
FRONT S Q 0824 87-026-462-080 TR 2SC1740SRS a
FRONT X R 0601 88-118-821-080 CHIP RES 1/10W (J) 820ohm TP= a
FRONT 0 R 0602 88-121-103-080 CARBON RES 1/6W (J) 10Kohm TP a
FRONT 0 R 0603 88-121-474-080 CARBON RES 1/6W (J) 470Kohm T a
FRONT X R 0604 88-121-334-080 CARBON RES 1/6W(J) 330kohm TP a
FRONT 0 R 0605 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
CA-DW539
U2
FRONT 0 R 0606 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
FRONT 0 R 0607 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
FRONT 0 R 0611 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0612 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0613 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0614 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0615 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0616 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0617 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0618 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT 0 R 0620 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT 0 R 0621 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0622 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT X R 0624 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
FRONT 0 R 0625 88-118-332-080 CHIP RES 1/10W (J) 3.3K 0805 a
FRONT 0 R 0627 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT X R 0628 88-118-821-080 CHIP RES 1/10W (J) 820ohm TP= a
FRONT 0 R 0629 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT 0 R 0630 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT X R 0631 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
CA-DW539
U2
FRONT X R 0633 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
FRONT X R 0634 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
FRONT 0 R 0635 88-118-182-080 CHIP RES 1/10W (J) 1.8Kohm TP a
FRONT 0 R 0640 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT X R 0641 88-118-821-080 CHIP RES 1/10W (J) 820ohm TP= a
FRONT 0 R 0642 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT 0 R 0643 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT 0 R 0651 88-118-224-080 CHIP RES 1/10W (J) 220K ohm a
FRONT 0 R 0652 88-121-103-080 CARBON RES 1/6W (J) 10Kohm TP a
FRONT X R 0653 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
FRONT 0 R 0658 88-121-103-080 CARBON RES 1/6W (J) 10Kohm TP a
FRONT X R 0660 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
FRONT 0 R 0664 88-118-223-080 CHIP RES 1/10W (J) 22Kohm TP a
FRONT 0 R 0670 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0673 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0675 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0676 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT X R 0677 88-121-272-080 CARBON RES 1/6W (J) 2.7Kohm T a
FRONT 0 R 0678 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 0679 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
CA-DW539
U2
FRONT 0 R 0680 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
FRONT X R 0880 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
FRONT X R 0884 88-118-333-080 CHIP RES 1/10W (J) 33K ohm T a
FRONT 0 R 0885 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
FRONT X R 0886 88-118-474-080 CHIP RES 1/10W (J) 470Kohm 06 a
FRONT X R 0887 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
FRONT 0 R 0888 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
FRONT 0 R 0889 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
FRONT X R 0890 88-130-221-080 CARBON RES 1/4W 220ohm TP=26m a
FRONT X R 0891 88-118-334-080 CHIP RES 1/10W(J) 330Kohm TP= a
FRONT 0 R 6003 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 6004 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 R 6011 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
FRONT 0 SW 0602 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0603 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0604 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0605 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0606 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0607 87-A92-171-080 TACT SW H=5.0mm 260g a
FRONT 0 SW 0608 87-A91-704-080 TACT SWITCH H=5.0mm a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-8-
Page 9
ELECTRICAL PARTS LIST - 5/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
FRONT 0 SW 0612 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0613 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0614 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0615 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0616 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0617 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0618 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 SW 0619 87-A91-704-080 TACT SWITCH H=5.0mm a
FRONT 0 VR 0801 87-A90-239-010 ROTARY VOLUME 10KA a
FRONT 0 X 0601 87-030-273-010 X’TAL CD 32.768KHZ CL:12.5P(D a
FRONT 0 X 0602 87-030-376-080 CER.RESONATOR 5.76MHZ 87-A70- a
JACK 0 C 0830 87-010-197-080 CHIP.CAP,S 0.01U/25V (K) B TP a
JACK 0 C 0831 87-012-566-080 CHIP CAP 0.01U/25V (Z) F a
JACK 0 C 0832 87-010-181-080 CHIP CAP 1800P/50V (K) B TP=8 a
JACK 0 C 0833 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
JACK 0 C 0835 87-010-544-080 ELEC CAP 0.1u/50V (M) SME a
JACK 0 C 0842 87-012-140-080 CHIP.CAP,S 470P/50V (J) CH TP a
JACK 0 J 0251 87-009-216-010 3.5 JACK W/SW ST a
JACK 0 J 0801 87-009-216-010 3.5 JACK W/SW ST a
JACK 0 L 0801 87-008-372-080 BEADS CORE (BLO1RN1-A63.T6) T a
CA-DW539
U2
JACK S Q 0821 89-322-405-080 TR 2SC2240GR TP a
JACK X R 0279 88-118-181-080 CHIP RES 1/10W (J) 180ohm TP= a
JACK X R 0280 88-118-181-080 CHIP RES 1/10W (J) 180ohm TP= a
JACK X R 0878 88-118-681-080 CHIP RES 1/10W (J) 680ohm TP a
JACK 0 R 0879 88-118-224-080 CHIP RES 1/10W (J) 220K ohm a
JACK X R 0881 88-118-474-080 CHIP RES 1/10W (J) 470Kohm 06 a
JACK 0 R 0882 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
JACK X R 0883 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
MAIN 0 C 0001 87-010-314-080 CHIP CAP 22P/50V (J) CH TP=8m a
MAIN 0 C 0002 87-012-184-080 CHIP CAP 33P/50V (J) CH TP=8m a
MAIN 0 C 0003 87-010-314-080 CHIP CAP 22P/50V (J) CH TP=8m a
MAIN 0 C 0005 87-016-669-080 CHIP.CAP,S 0.1U/25V (K) B a
MAIN 0 C 0006 87-010-313-080 CHIP.CAP,S 18P/50V (J) CH a
MAIN 0 C 0007 87-012-140-080 CHIP.CAP,S 470P/50V (J) CH TP a
MAIN 0 C 0008 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0010 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0011 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0012 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0013 87-010-149-080 CHIP CAP 5P/50V 0805 CH (C) a
MAIN 0 C 0014 87-010-303-080 CHIP CAP 330P/50V (K) B a
CA-DW539
U2
MAIN 0 C 0015 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0016 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
MAIN 0 C 0017 87-010-992-080 CHIP CAP S 0.047UF/25V (K) B a
MAIN 0 C 0018 87-010-757-080 CHIP CAP 0.047UF/25V (K) B 12 a
MAIN 0 C 0019 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
MAIN 0 C 0020 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0021 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0022 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0023 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0025 87-A12-162-080 CHIP CAP 0.22U/25V (K) B a
MAIN 0 C 0027 87-010-805-080 CHIP.CAP,S 1UF/16V (Z) F TP=8 a
MAIN 0 C 0028 87-016-669-080 CHIP.CAP,S 0.1U/25V (K) B a
MAIN 0 C 0029 87-016-669-080 CHIP.CAP,S 0.1U/25V (K) B a
MAIN 0 C 0030 87-A11-228-080 CHIP CAP 0.027UF/25V (K) B TP a
MAIN 0 C 0031 87-A11-228-080 CHIP CAP 0.027UF/25V (K) B TP a
MAIN 0 C 0033 87-015-610-080 CHIP CAP 0.47UF/25V (Z)F a
MAIN 0 C 0034 87-015-610-080 CHIP CAP 0.47UF/25V (Z)F a
MAIN 0 C 0035 87-015-819-080 CHIP.CAP 0.01U/50V (K) B TP=8 a
MAIN 0 C 0036 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
MAIN 0 C 0037 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CA-DW539
U2
MAIN 0 C 0038 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
MAIN 0 C 0039 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0040 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0042 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0043 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0044 87-010-312-080 CHIP CAP 15P/50V (J) CH TP=8m a
MAIN 0 C 0045 87-010-312-080 CHIP CAP 15P/50V (J) CH TP=8m a
MAIN 0 C 0046 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0047 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0048 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0049 87-012-140-080 CHIP.CAP,S 470P/50V (J) CH TP a
MAIN 0 C 0050 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0071 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0072 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
MAIN 0 C 0073 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0075 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0091 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0092 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0093 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0099 87-018-134-080 AXIAL CAP 0.01U/50V (K) a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-9-
Page 10
ELECTRICAL PARTS LIST - 6/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
MAIN 0 C 0215 87-A10-201-080 CHIP CAP 0.33/50V (Z) F a
MAIN 0 C 0216 87-A10-201-080 CHIP CAP 0.33/50V (Z) F a
MAIN 0 C 0231 87-015-632-080 CHIP CAP 0.015UF/50V (Z) F a
MAIN 0 C 0232 87-015-632-080 CHIP CAP 0.015UF/50V (Z) F a
MAIN 0 C 0233 87-A10-201-080 CHIP CAP 0.33/50V (Z) F a
MAIN 0 C 0234 87-A10-201-080 CHIP CAP 0.33/50V (Z) F a
MAIN 0 C 0235 87-A12-319-080 CHIP CAP 0.1U/25V (K) B (1206 a
MAIN 0 C 0236 87-A12-319-080 CHIP CAP 0.1U/25V (K) B (1206 a
MAIN 0 C 0237 87-010-380-080 ELEC CAP 47UF/16V (M) TP=5mm a
MAIN 0 C 0238 87-010-248-080 ELEC CAP 220U/10V (M) SME a
MAIN 0 C 0239 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0240 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0241 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0242 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0243 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0244 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0245 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0246 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0247 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0248 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
CA-DW539
U2
MAIN 0 C 0251 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
MAIN 0 C 0261 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0262 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0263 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0264 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0266 87-010-545-080 ELEC CAP 0.22UF/50V (M) SEM T a
MAIN 0 C 0267 87-010-545-080 ELEC CAP 0.22UF/50V (M) SEM T a
MAIN 0 C 0271 87-010-237-080 EL CAP 1000UF/16V a
MAIN 0 C 0272 87-010-237-080 EL CAP 1000UF/16V a
MAIN 0 C 0277 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0278 87-010-112-080 ELEC CAP 100UF/16V (M) SME TP a
MAIN 0 C 0279 87-010-112-080 ELEC CAP 100UF/16V (M) SME TP a
MAIN 0 C 0280 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0281 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0285 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0287 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0288 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a
MAIN 0 C 0292 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0293 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0298 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
CA-DW539
U2
MAIN 0 C 0299 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0301 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
MAIN 0 C 0302 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
MAIN 0 C 0303 87-010-177-080 CHIP CAP 820P/50V TP=8mm a
MAIN 0 C 0304 87-010-177-080 CHIP CAP 820P/50V TP=8mm a
MAIN 0 C 0305 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
MAIN 0 C 0306 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
MAIN 0 C 0307 87-010-382-080 ELEC.CAP 22 UF/25V (M) SME TP a
MAIN 0 C 0308 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
MAIN 0 C 0309 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0310 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0311 87-010-248-080 ELEC CAP 220U/10V (M) SME a
MAIN 0 C 0312 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
MAIN 0 C 0313 87-015-828-080 CHIP CAP 0.033UF/25V (Z)F TP= a
MAIN 0 C 0314 87-015-828-080 CHIP CAP 0.033UF/25V (Z)F TP= a
MAIN 0 C 0315 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0316 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0317 87-010-382-080 ELEC.CAP 22 UF/25V (M) SME TP a
MAIN 0 C 0318 87-010-382-080 ELEC.CAP 22 UF/25V (M) SME TP a
MAIN 0 C 0319 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
CA-DW539
U2
MAIN 0 C 0320 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
MAIN 0 C 0321 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
MAIN 0 C 0322 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
MAIN 0 C 0323 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0324 87-010-197-080 CHIP CAP S 0.01U/25V (K) B TP a
MAIN 0 C 0325 87-010-180-080 CHIP CAP 1500P/50V (K) B TP=8 a
MAIN 0 C 0326 87-010-180-080 CHIP CAP 1500P/50V (K) B TP=8 a
MAIN 0 C 0327 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0328 87-010-178-080 CHIP CAP 1000P/50V (K) B TP=8 a
MAIN 0 C 0329 87-010-182-080 CHIP CAP 2200P/50V (K) B TP=8 a
MAIN 0 C 0330 87-010-213-080 CHIP CAP 0.015u/25V (K) B TP= a
MAIN 0 C 0331 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
MAIN 0 C 0332 88-700-620-810 MALAY CAP 0.0012UF/50V (J) a
MAIN 0 C 0334 87-012-155-080 CHIP CAP 180P/50V (J) CH TP=8 a
MAIN 0 C 0341 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
MAIN 0 C 0342 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
MAIN 0 C 0343 87-012-157-080 EHIP.CAP,S 330P/50V (J) CH TP a
MAIN 0 C 0344 87-010-303-080 CHIP CAP 330P/50V (K) B a
MAIN 0 C 0363 87-010-182-080 CHIP CAP 2200P/50V (K) B TP=8 a
MAIN 0 C 0364 87-010-182-080 CHIP CAP 2200P/50V (K) B TP=8 a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-10-
Page 11
ELECTRICAL PARTS LIST - 7/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
MAIN 0 C 0491 87-015-819-080 CHIP.CAP 0.01U/50V (K) B TP=8 a
MAIN 0 C 0492 87-010-221-080 ELEC CAP 470u/10V (M) SME a
MAIN 0 C 0501 87-010-390-010 EL CAP 3300UF/25V a
MAIN 0 C 0506 87-010-404-080 ELEC CAP 4.7u/50V (M) SME TP= a
MAIN 0 C 0507 87-010-401-080 ELEC CAP 1UF/50V (M) SME TP=5 a
MAIN 0 C 0508 87-010-221-080 ELEC CAP 470u/10V (M) SME a
MAIN 0 C 0511 87-010-374-080 ELEC CAP 47U/10V (M) SME TP=5 a
MAIN 0 C 0512 87-010-385-080 ELEC CAP 220U/25V (M) SME =6 a
MAIN 0 C 0513 87-012-566-080 CHIP CAP 0.01U/25V (Z) F a
MAIN 0 C 0515 87-012-566-080 CHIP CAP 0.01U/25V (Z) F a
MAIN 0 C 0521 87-012-566-080 CHIP CAP 0.01U/25V (Z) F a
MAIN 0 C 0522 87-010-263-080 ELEC CAP 100UF/10V (M) SME TP a
MAIN 0 C 0544 87-010-405-080 ELEC CAP 10UF/50V (M) SME TP= a
MAIN 0 C 0598 87-010-383-080 ELEC CAP 33UF/25V (M) SME TP= a
MAIN 0 C 0599 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
MAIN 0 C 0761 87-010-380-080 ELEC CAP 47UF/16V (M) TP=5mm a
MAIN 0 C 0762 87-010-198-080 CHIP CAP S 0.022U/25V (K) B T a
MAIN 0 C 0765 87-010-196-080 CHIP.CAP,S 0.1U/25V (Z) F TP= a
MAIN 0 CF 0001 87-A91-094-010 FILER CER CDA10.7MG80-A a
MAIN 0 CF 0002 82-785-747-010 FILTER CFSFE10.7MS2G-A a
CA-DW539
U2
MAIN 0 CF 0003 82-785-747-010 FILTER CFSFE10.7MS2G-A a
MAIN X CN 0001 8Z-CT4-623-010 TERMINAL PIN 1 a
MAIN X CN 0004 8Z-CT4-623-010 TERMINAL PIN 1 a
MAIN X CN 0005 8Z-CT4-623-010 TERMINAL PIN 1 a
MAIN X CN 0006 8Z-CT4-623-010 TERMINAL PIN 1 a
MAIN X CN 0007 8Z-CT4-623-010 TERMINAL PIN 1 a
MAIN 0 CN 0301 8B-CT5-616-010 CONNECTOR ASS’Y WIRE 4P 330mm a
MAIN 0 CN 0302 8B-CT5-617-010 CONNECTOR ASS’Y WIRE 5P 215mm a
MAIN 0 CN 0501 87-049-919-010 CONNECTOR BASE 3P 2.5mm a
MAIN 0 CN 0751 8B-CT5-618-010 CONNECTOR ASS’Y 8P WIRE 315x2 a
MAIN 0 CON0201 87-A61-893-010 SPK TEVMINAL 4P 94VO a
MAIN S D 0001 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0002 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN 0 D 0003 87-A40-616-070 VARI-CAP SVC384 (S/T) a
MAIN 0 D 0004 87-A40-128-080 C-VARI-CAP,HVU202A a
MAIN 0 D 0005 87-A40-128-080 C-VARI-CAP,HVU202A a
MAIN S D 0006 87-017-072-080 ZENER HZS3B1 a
MAIN S D 0200 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0201 87-027-702-080 ZENER HZ6C2L a
MAIN S D 0491 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
CA-DW539
U2
MAIN S D 0494 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0503 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0504 87-A40-648-080 ZENER DIODE MTZJ8.2A a
MAIN S D 0505 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0506 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0508 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0511 87-027-702-080 ZENER HZ6C2L a
MAIN S D 0532 87-027-399-080 ZENER HZ7A3L a
MAIN S D 0761 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0762 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S D 0763 87-070-345-080 SILICON DIODE 1N4148M DO-34 T a
MAIN S IC 0001 87-A21-550-010 IC TA2149N a
MAIN S IC 0002 87-A21-185-040 C-IC LC72121M a
MAIN S IC 0202 87-A21-090-010 IC LA4600 a
MAIN S IC 0203 87-A21-911-040 CHIP IC M61515FP a
MAIN S IC 0301 87-020-828-010 IC BA3416BL a
MAIN S IC 0302 87-001-440-010 IC BA15218N a
MAIN 0 L 0002 87-A50-560-010 FM BPF 2.2x6.5T a
MAIN 0 L 0003 SL-B08-010-45G AM ANT COIL 58T:20T 0.07x4 21 a
MAIN 0 L 0004 87-A50-420-010 AM OSC (87-A50-420-01) a
CA-DW539
U2
MAIN 0 L 0005 87-A50-566-010 COIL FM RF a
MAIN 0 L 0006 87-A50-567-010 FM OSC a
MAIN 0 L 0007 87-A91-308-010 AM IFT W/C.F a
MAIN 0 L 0008 87-003-102-080 FIXED IND 10UH (K) TP=26mm a
MAIN 0 L 0201 87-003-152-080 FIXED IND 100UH a
MAIN 0 L 0330 88-CT6-620-010 REC OSC a
MAIN 0 PN 0301 87-A60-110-010 CONNECTOR BASE 4P a
MAIN 0 PN 0302 87-A60-111-010 CONNECTOR BASE 5P V S2M-5W a
MAIN 0 PN 0751 87-099-832-010 CONN ASS’Y 8P V S2M-8W a
MAIN S Q 0001 89-327-143-080 CHIP TR 2SC2714O a
MAIN S Q 0002 87-026-462-080 TR 2SC1740SRS a
MAIN S Q 0003 89-111-624-080 CHIP TR 2SA1162Y a
MAIN S Q 0004 87-A30-283-040 TR DTC114YKA a
MAIN S Q 0071 89-327-125-080 CHIP TR 2SC2712GR TPE2 89-327 a
MAIN S Q 0243 89-320-011-080 TRANSISTOR 2SC2001K T a
MAIN S Q 0244 89-320-011-080 TRANSISTOR 2SC2001K T a
MAIN S Q 0306 89-320-011-080 TRANSISTOR 2SC2001K T a
MAIN S Q 0308 87-026-462-080 TR 2SC1740SRS a
MAIN S Q 0311 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
MAIN S Q 0491 89-112-965-080 TRANSISTOR 2SA1296GR TPE2 a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-11-
Page 12
ELECTRICAL PARTS LIST - 8/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
MAIN S Q 0492 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
MAIN S Q 0501 89-112-965-080 TRANSISTOR 2SA1296GR TPE2 a
MAIN S Q 0502 87-A30-216-080 TR 2SA933AS(R) a
MAIN S Q 0503 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
MAIN S Q 0504 87-A30-226-010 TR 2SB1655E a
MAIN S Q 0505 87-026-462-080 TR 2SC1740SRS a
MAIN S Q 0510 89-318-154-080 TRANSISTER 2SC1815Y TPE2 a
MAIN S Q 0521 89-318-154-080 TRANSISTER 2SC1815Y TPE2 a
MAIN S Q 0761 87-A30-216-080 TR 2SA933AS(R) a
MAIN S Q 0762 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
MAIN S Q 0764 87-A30-623-080 D TRANSISTOR DTC124XSA TP(87- a
MAIN S Q 0770 89-112-965-080 TRANSISTOR 2SA1296GR TPE2 a
MAIN 0 R 0001 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0002 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0003 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
MAIN 0 R 0004 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN X R 0005 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
MAIN 0 R 0006 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN X R 0007 88-118-151-080 CHIP RES 1/10W (J) 150ohm TP= a
MAIN X R 0008 88-118-470-080 CHIP RES 1/10 W (J) 47ohm TP= a
CA-DW539
U2
MAIN 0 R 0009 88-118-331-080 CHIP RES,S 1/10W (J) 330ohm T a
MAIN X R 0010 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
MAIN 0 R 0011 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0012 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0013 88-118-331-080 CHIP RES,S 1/10W (J) 330ohm T a
MAIN 0 R 0014 88-118-332-080 CHIP RES 1/10W (J) 3.3K 0805 a
MAIN 0 R 0015 88-121-472-080 CARBON RES 1/6W (J) 4.7Kohm T a
MAIN 0 R 0016 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0017 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN X R 0018 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
MAIN X R 0019 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
MAIN X R 0020 88-128-471-080 CHIP RESISTOR 1/8W 470ohm TP= a
MAIN 0 R 0021 88-128-101-080 CHIP RES 1/8W 100ohm TP=8mm a
MAIN 0 R 0022 88-118-562-080 CHIP RES 1/10W(J) 5.6Kohm TP= a
MAIN 0 R 0023 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN X R 0024 88-118-681-080 CHIP RES 1/10W (J) 680ohm TP a
MAIN X R 0025 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
MAIN 0 R 0027 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0028 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0029 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
CA-DW539
U2
MAIN 0 R 0030 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0031 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0032 88-121-330-080 CARBON RES 1/6w (J) 33ohm TP= a
MAIN X R 0033 88-118-100-080 CHIP RES 1/10W 10ohm (J) TP= a
MAIN 0 R 0034 88-118-153-080 CHIP RES 1/10W (J) 15Kohm TP a
MAIN X R 0035 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
MAIN 0 R 0036 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0037 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
MAIN 0 R 0039 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
MAIN 0 R 0072 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0073 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
MAIN X R 0074 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
MAIN 0 R 0075 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN X R 0200 88-130-101-080 CARBON RES 1/4W (J) 100ohm TP a
MAIN 0 R 0215 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0216 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0217 88-121-101-080 CARBON RES 1/6W (J) 100ohm TP a
MAIN 0 R 0228 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0229 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0231 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
CA-DW539
U2
MAIN 0 R 0232 88-118-272-080 CHIP RES 1/10W (J) 2.7Kohm T a
MAIN 0 R 0233 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0234 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
MAIN X R 0235 88-118-392-080 CHIP RES 1/10W (J) 3.9Kohm T8 a
MAIN 0 R 0236 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0237 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0241 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0242 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0243 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0244 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0245 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0246 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN X R 0251 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
MAIN X R 0252 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
MAIN X R 0253 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
MAIN X R 0254 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
MAIN 0 R 0255 88-118-332-080 CHIP RES 1/10W (J) 3.3K 0805 a
MAIN 0 R 0269 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN X R 0271 88-118-183-080 CHIP RES 18K 0805 1/10W a
MAIN X R 0272 88-118-183-080 CHIP RES 18K 0805 1/10W a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-12-
Page 13
ELECTRICAL PARTS LIST - 9/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
MAIN 0 R 0273 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0274 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0291 88-118-123-080 CHIP RES 1/10W (J) 12K ohm T a
MAIN 0 R 0293 88-118-123-080 CHIP RES 1/10W (J) 12K ohm T a
MAIN X R 0301 88-118-560-080 CHIP RES 1/10W (J) 56ohm a
MAIN X R 0302 88-118-560-080 CHIP RES 1/10W (J) 56ohm a
MAIN X R 0303 88-128-392-080 CHIP RES 1/8W 3.9K TP=8mm a
MAIN X R 0304 88-118-392-080 CHIP RES 1/10W (J) 3.9Kohm T8 a
MAIN X R 0305 88-128-104-080 CHIP RESISTOR 1/8W 100K 1206 a
MAIN X R 0306 88-128-104-080 CHIP RESISTOR 1/8W 100K 1206 a
MAIN 0 R 0307 88-118-562-080 CHIP RES 1/10W(J) 5.6Kohm TP= a
MAIN 0 R 0308 88-118-562-080 CHIP RES 1/10W(J) 5.6Kohm TP= a
MAIN 0 R 0309 88-121-471-080 CARBON RES 1/6W (J) 470ohm TP a
MAIN 0 R 0310 88-121-103-080 CARBON RES 1/6W (J) 10Kohm TP a
MAIN 0 R 0311 88-118-104-080 CHIP RES 1/10W (J) 100Kohm TP a
MAIN 0 R 0312 88-121-101-080 CARBON RES 1/6W (J) 100ohm TP a
MAIN 0 R 0313 88-118-182-080 CHIP RES 1/10W (J) 1.8Kohm TP a
MAIN 0 R 0314 88-118-182-080 CHIP RES 1/10W (J) 1.8Kohm TP a
MAIN 0 R 0319 88-118-224-080 CHIP RES 1/10W (J) 220K ohm a
MAIN X R 0320 88-121-224-080 CARBON RES 1/6w (J) 220kohm T a
CA-DW539
U2
MAIN 0 R 0321 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0322 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN X R 0323 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
MAIN X R 0324 88-118-122-080 CHIP RES 1/10W (J) 1.2Kohm TP a
MAIN 0 R 0325 88-118-471-080 CHIP RES 1/10W (J) 470ohm TP= a
MAIN 0 R 0326 88-118-471-080 CHIP RES 1/10W (J) 470ohm TP= a
MAIN 0 R 0327 88-118-153-080 CHIP RES 1/10W (J) 15Kohm TP a
MAIN 0 R 0328 88-118-153-080 CHIP RES 1/10W (J) 15Kohm TP a
MAIN 0 R 0329 88-118-332-080 CHIP RES 1/10W (J) 3.3K 0805 a
MAIN X R 0330 88-118-822-080 CHIP RES 1/10W (J) 8.2Kohm TP a
MAIN 0 R 0331 88-130-331-080 CARBON RES 1/4W (J) 330ohm TP a
MAIN X R 0332 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
MAIN 0 R 0333 88-118-273-080 CHIP RES 27K 0805 a
MAIN X R 0334 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
MAIN 0 R 0336 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0338 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0347 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0348 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0351 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0352 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
CA-DW539
U2
MAIN 0 R 0355 88-121-472-080 CARBON RES 1/6W (J) 4.7Kohm T a
MAIN 0 R 0356 88-118-472-080 CHIP RES 1/10W (J) 4.7Kohm TP a
MAIN 0 R 0361 88-118-153-080 CHIP RES 1/10W (J) 15Kohm TP a
MAIN 0 R 0362 88-118-153-080 CHIP RES 1/10W (J) 15Kohm TP a
MAIN 0 R 0470 87-140-229-080 CARBON RES 1/2W (J) 2.2ohm TP a
MAIN 0 R 0490 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0491 88-118-473-080 CHIP RES 1/10W (J) 47Kohm TP a
MAIN 0 R 0492 88-118-331-080 CHIP RES,S 1/10W (J) 330ohm T a
MAIN X R 0503 88-118-101-080 CHIP RES 1/10W (J) 100ohm TP= a
MAIN X R 0504 88-118-474-080 CHIP RES 1/10W (J) 470Kohm 06 a
MAIN 0 R 0505 88-118-471-080 CHIP RES 1/10W (J) 470ohm TP= a
MAIN 0 R 0506 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
MAIN X R 0507 88-118-152-080 CHIP RES 1/10W (J) 1.5Kohm T a
MAIN 0 R 0509 88-121-471-080 CARBON RES 1/6W (J) 470ohm TP a
MAIN X R 0513 88-130-101-080 CARBON RES 1/4W (J) 100ohm TP a
MAIN 0 R 0516 88-118-223-080 CHIP RES 1/10W (J) 22Kohm TP a
MAIN 0 R 0521 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN X R 0522 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
MAIN 0 R 0524 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN X R 0527 88-118-822-080 CHIP RES 1/10W (J) 8.2Kohm TP a
CA-DW539
U2
MAIN 0 R 0528 88-118-102-080 CHIP RES 1/10W (J) 1Kohm TP=8 a
MAIN 0 R 0672 88-118-394-080 CHIP RES,S 1/10W(J) 390Kohm T a
MAIN 0 R 0761 87-029-019-010 FUSE RES 1/2W (J) 2.2ohm a
MAIN X R 0762 88-118-333-080 CHIP RES 1/10W (J) 33K ohm T a
MAIN X R 0763 88-118-563-080 CHIP RES 1/10W (J) 56Kohm TP= a
MAIN 0 R 0764 88-118-273-080 CHIP RES 27K 0805 a
MAIN X R 0765 88-118-564-080 CHIP RES 1/10W (J) 560Kohm TP a
MAIN X R 0766 88-118-222-080 CHIP RES 1/10W (J) 2.2Kohm TP a
MAIN X R 0770 88-118-474-080 CHIP RES 1/10W (J) 470Kohm 06 a
MAIN 0 R 0771 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
MAIN 0 R 0772 88-118-103-080 CHIP RES 1/10W (J) 10Kohm TP= a
MAIN 0 R 0892 88-118-471-080 CHIP RES 1/10W (J) 470ohm TP= a
MAIN 0 SFR0761 87-024-239-010 POTENTIALMETER 22K a
MAIN X SH 0001 88-ZA1-605-010 SHIELD CASE (STEEL) a
MAIN 0 SW 0301 88-CT6-619-010 BACK SLIDE SW 6P2T SHORTING a
MAIN 0 TC 0001 87-011-254-080 CER TRIMMER (PINK) 20P 6.15x5 a
MAIN 0 X 0001 87-A70-061-010 X’TAL 4.5MHZ a
POWER 0 C 0901 87-A10-577-080 CER CAP 0.022UF/50V (Z) F a
POWER 0 C 0902 87-A10-577-080 CER CAP 0.022UF/50V (Z) F a
POWER 0 C 0903 87-A10-577-080 CER CAP 0.022UF/50V (Z) F a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-13-
Page 14
ELECTRICAL PARTS LIST - 10/10
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
POWER 0 C 0904 87-A10-577-080 CER CAP 0.022UF/50V (Z) F a
POWER S D 0901 87-A40-465-090 DIODE FR202 a
POWER S D 0902 87-A40-465-090 DIODE FR202 a
POWER S D 0903 87-A40-465-090 DIODE FR202 a
POWER S D 0904 87-A40-465-090 DIODE FR202 a
POWER S D 0905 87-A40-465-090 DIODE FR202 a
POWER ! 0 J 0901 87-A60-177-010 AC JACK W/SW BLK U a
POWER ! S PR 0901 87-A90-473-080 PROTECTOR 3.5A 491 60V (TP=52 a
POWER ! 0 PT 0901 8B-CT5-620-010 TRANSFORMER AC120V U DC=12.5V a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-14-
Page 15
• Regarding connectors, they are not stocked as they are not the initial order items.
The connectors are available after they are supplied from connector manufacturers upon the order is received.
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
88
Resistor Code
Chip resistor
Wattage Type Tolerance
1/16W 1005 5% CJ
1/16W
1/10W
1/8W
1608
2125
3216
TRANSISTOR ILLUSTRATION
A
5%
5%
5%
Symbol
CJ
CJ
CJ
Figure
Value of resistor
Form
L
Dimensions (mm)
t
W
0.55
Resistor Code
108
118
128
LW t
1.0 0.5 0.35 104
1.6 0.8 0.45
2 1.25 0.45
3.2
1.6
: A
: A
ECB
2SA1296
2SA1318
C
B
E
2SA1162
2SC2712
2SC2714
DTC114TKA
DTC114YKA
KRC104S
ECB
2SC2001
2SA933
2SC1815
KTC3198
2SC2240
BCE
2SB1655
ECB
DTC114TSA
B
C
E
2SC1740
DTC124XSA
-15-
Page 16
SCHEMATIC DIAGRAM - 1/4 (MAIN-1/2, DECK/AMP/POWER SECTION)
1B
2B
3B
4B
5B
6B
7B
8B
9B
TO CD C.B 1B-12B
10B
11B
12B
1A
2A
3A
4A
5A
6A
7A
8A
9A
10A
TO MAIN C.B-2/3 (TUNER SECTION) 1A-110A
0.01
3C
6C
8C
7C
5C
4C
9C
TO FRONT C.B 3C-9C
22C
19C
21C
23C
TO FRONT C.B 1C,2C,10C-28C
24C
20C
10C
11C
12C
13C
14C
15C
16C
17C
18C
TO JACK C.B 1D-5D
1C
2C
25C
26C
27C
28C
1D
2D3D4D
5D
MAIN C.B-1/3 (DECK/AMP SECTION)
10/50
100/16
POWER
1000/16
R293
IC203
M61515FP
1/50
1/50
1/50
C293
4.7/50
4.7/50
C231
0.22/50
R273
DECK2
DECK1
EH
0.033
0.033
L330
BIAS FREQUENCY ADJ.
0.0012
4.7/50
R291
1/50
1/50
1/50
DTC124XSA
DTC124XSA
1N4148M
330
0.015
2SC1740SRS
2200P
2.2K
100/10
2SA933AS(R)
1N4148M
HZ7A3L
DTC124XSA
4.7/50
TAPE SPEED ADJ.
1N4148M
47/16
220/10
470/10
2SA1296GR
1N4148M
1N4148M
0.1
C599
2SC1740SRS
1/50
1N4148M
MTZJ8.2A
C598
33/25
0.22/50
1N4148M
2SA933AS(R)
1N4148M
DTC124XSA
R274
4.7/50
4.7/50
10/50
100/16
0.01
C515
3300/25
2SC1815Y
220/25
47/10
1000/16
POWER
33
11
22
C902
D902
C901
D901
D903
C.B
J901
AC120V
60Hz
M1
DECK
MOTOR
-16-
Page 17
SCHEMATIC DIAGRAM - 2/4 (MAIN -2/2, TUNER SECTION)
MAIN C.B-2/3 (TUNER SECTION)
L003,TC001
AM TRACKING ADJ.
L004
AM VT ADJ.
OSC COIL AM
FM TRACKING ADJ.
L005
L006
FM VT ADJ.
TP1
HVU202A
5P
1N4148M
1N4148M
FM BPF
FM RF
FM OSC
0.8 0.7 3.6 1.2 1.2
4.4 4.10
0.047
0.027
0
0
3.43.50.70.70.702.94.74.54.74.54.7
0.027
0.65
1.4
0
0
2.2
1.0
06.6001.32.71.0
03.53.42.0004.300001.0
SIGNAL
L007
AM IF ADJ.
AM IFT W/C.F
CFSFE10.7MS2G-A
2.8
CFSFE10.7MS2G-A
2.1
4.0
-17-
0.47
0.47
4.7 7.8
5.4
Q002-Q004
5.4 5.4
4.7
0.01
DTC114YKA
0
3.8
4A
1A
3B
2A
5A
6A
7A
8A
10A
9A
TO MAIN C.B-1/3 (DECK/AMP SECTION) 1A-10A
Page 18
SCHEMATIC DIAGRAM - 3/4 (CD SECTION)
CD C.B
5.6K
KRC104S
820
10K 10K 10K
DTC114TKA
1000P
KRC104S
1000P
1000P
47/10
100/10
C4120
0.056
470P
1/50
10K
220/10
10/50
10/50
68K
18K
1N4148M
100/50
12P
330
C499
10/50
L406
BEADS CORE
16.93MHz
10UH
220/10
100/10
10UH
10/50
10/50
3.3/50
1000P
5.6K
100K
100K
820
10K
0.22/50
39K
100/10
100K
0.018
220/10
2SA933AS(R)
1N4148M
DTC114TKA
1K
2700P
47/10
2.7K
27K
M3
M2
SW1
PIN3
FFC401
100/10
0.012
4.7/50
10K
47/10
0.22/50
10K
0
3.5
3.4
3.5
000
000
3.0
3.5
2.5
2.5
5.0
1000/10
3.4
2.6
2.5
8.0
8.0
0
5.0
5.0
2.5
3.8
0
5.0
3.5
2.5
2.0
5.1
7.1
7.8
0.1/50
1/50
15K
470/10
1N4148M
MAIN C.B-3/3
470/10
100/10
1N4148M
DTC124XSA
1N4148M
1B
6B
5B
2B
4B
3B
7B
TO MAIN C.B-1/3 (DECK/AMP SECTION) 1B-12B
11B
10B
8B
9B
12B
MOTOR
C.B
-18-
Page 19
SCHEMATIC DIAGRAM - 4/4 (FRONT/JACK SECTION)
FRONT C.B
AIW4239-32P2N
DISPLAY
BT-H203D-31 RED
SPS-442-1-F1
REMOTE SENSOR
CD DOOR SWITCH
1C
2C
3C
4C
5C
6C
7C
8C
9C
10C
11C
12C
13C
14C
15C
16C
17C
18C
CON601
1N4148M
1N4148M
L606
O-RWC/CE
LC867132V-5T98
1N4148M
1N4148M
1N4148M
DTC124XSA
LED609
BT-H203D-31 RED
LED610
BT-H203D-31 RED
19C
TO MAIN C.B-1/3 (DECK/AMP SECTION) 1-28C
20C
21C
22C
23C
24C
25C
26C
27C
28C
L605
BEADS CORE
PB SIGNAL :
JACK
C.B(1/2)
MIC
1N4148M
DTC124XSA
2SC2240GR
2SA933AS(R)
1N4148M
1N4148M
DTC124XSA
1N4148M
1N4148M
1N4148M
1N4148M
DTC124XSA
R679
33P
REPEAT/
FM MODE/
OSC/SLEEP
DTC114TSA
DTC114TSA
0.022 0.022
DUB SPEED
JACK C.B (2/2)
-19-
1D2D3D4D5D
TO MAIN C.B-1/3 (DECK/AMP SECTION) 1D-5D
Page 20
WIRING - 1/2 (MAIN C.B / CD C.B / FRONT C.B / JACK C.B)
101112131415161718192021222324
1234567892526272829303132
A
B
C
C4120
48
49
64
1
33
32
17
16
L406
GRN
GRN
L005
L002
L006
IC001
12
1
2413
VOL
VOL
CON601
D
E
F
G
H
33
32
48
49
17
16
64
1
I
J
64
13
24
112
L606
65
80
1
41
40
25
24
K
L
M1
DECK MOTOR
Q521
M
N
C292
O
P
Q
4
3
Q308
2
5
6
1
R
S
T
U
-20-
Page 21
WIRING - 2/2 (POWER C.B / MOTOR C.B)
1 3
J901
AC
120V 60Hz
PIN3
M3
SW1
_
+
M2
M3
(SPINDLE MOTOR)
SW1
(INSIDE LIMIT SW)
M2
(SLED MOTOR)
TO CD C.B CNA402
_
+
6
1
MOTOR C.B
POWER C.B
PR901
123456789101112131415
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
-21-
U
Page 22
ELECTRICAL ADJUSTMENT-1/1
< TUNER SECTION >
1. AM IF Adjustment
L007 ....................................................................... 530kHz
L003
BAR ANT
FRONT C.B MAIN C.B CD C.B
L007
3
1
IC001
C39
4
L006
2
L004
4
2
L330
L005
5
TC001
3
SFR430
6
SFR761
J251
8
7
7
2. AM VT Adjustment
Settings: • Test point: C39 +
• Adjustment location: L004
Method: Set to AM 1710kHz adjust L004 so that the test
point becomes 5.5V±0.05V
3. AM Tracking Adjustment
L003 ....................................................................... 600kHz
TC001................................................................... 1400kHz
4. FM VT Adjustment
Settings: • Test point: C39 +
• Adjustment location: L006
Method: Set to FM 108MHz adjust L006 so that the test
point becomes 6.0V±0.05V
5. FM Tracking Adjustment
L005 ........................................................................98MHz
< TAPE SECTION >
6. Bias frequency Adjustment
9
L330 ............................................................. 56kHz ±2kHz
7. Tape speed Adjustment
Settings: • Test tape: MT111
• Test point: PHONES JACK (J251)
• Adjustment location: SFR761
Method: Play back the test tape and adjust so that the
output frequency is 3000Hz ±30Hz.
8. Azimuth Adjustment
Settings: • Test tape: TTA-320
• Test point: PHONES JACK (J251)
• Adjustment location:Azimuth adjustment
screw
Method: Play back the 8kHz signal of the test tape and
adjust screw so that the output becomes
maximum.
JACK C.B
RPH/PH
8
< CD SECTION >
9. Focus Bias Adjustment
Settings: • Test CD: TCD-782 (A-BEX)
• Test point: IC401 PIN20, PIN58
• Adjustment location: SFR430
Method: Play back the #15 of the test CD and adjust
SFR430 so that the voltage between pin20 and
pin 58 of IC401 becomes 0V ±0.1mV.
-22-
Page 23
LCD DISPLAY -1/1 (AIW4239-32P2N)
GRID ASSIGNMENT
ANODE CONNECTION
-23-
Page 24
IC BLOCK DIAGRAM -1/2
IC, TA2149N
IC, BA3416BL
DECK R
DECK L
DECK R
DECK L
R OUT
L OUT
IC, LC72121M
TAPE SELECT
-24-
Page 25
IC BLOCK DIAGRAM -2/2
IC, LA6541D
IC, M61515FP
IN1-R
IN2-R
IN3-R
IN4-R
RECOUT-R
SEND-R
RETURN-R
TONE-H-R
TONE-L-R
OUT-R
GND
1
2
3
4
5
6
7
8
9
10
11
VOL VOL
Treble
boost
Mono.SW
MUTE
ATT ATT
Bass
boost
Bass
boost
Treble
boost
24
23
22
21
20
19
18
17
16
15
14
IN1-L
IN2-L
IN3-L
IN4-L
RECOUT-L
SEND-L
RETURN-L
TONE-H-L
TONE-L-L
OUT-L
VSS
CONT
Control logic
-25-
1312
VDD
Page 26
IC DESCRIPTION-1/3 (LA9241ML)-1/2
Pin No. Pin Name I/O Description
Pin to which external pickup photo diode is connected. RF signal is created by adding with the
1
2
FIN2
FIN1
I
FIN1 pin signal. FE signal is created by subtracting from the FIN1 pin signal.
I
Pin to which external pickup photo diode is connected.
10
11
12
13
14
15
16
17
3
4
5
6
7
8
9
E
F
TB
TE-
TE
TESI
SCI
TH
TA
TD-
TD
JP
TO
FD
FD-
Pin to which external pickup photo diode is connected. TE signal is created by subtracting from
I
the F pin signal.
I
Pin to which external pickup photo diode is connected.
I
DC component of the TE signal is input.
I
Pin to which external resistor setting the TE signal gain is connected between the TE pin.
O
TE signal output pin.
TES “Track Error Sense” comparator input pin. TE signal is passed through a band-pass filter
I
then input.
I
Shock detection signal input pin.
I
Tracking gain time constant setting pin.
O
TA amplifier output pin.
Pin to which external tracking phase compensation constants are connected between the TD and
I
VR pins.
I
Tracking phase compensation setting pin.
I
Tracking jump signal (kick pulse) amplitude setting pin.
O
Tracking control signal output pin.
O
Focusing control signal output pin.
Pin to which external focusing phase compensation constants are connected between the FD and
I
FA pins.
18
19
20
21
22
23
24
25
26
27
28
29
30, 31
32, 33
34
FA
FA-
FE
FE-
AGND
SP
SPI
SPG
SP-
SPD
SLEQ
SLD
SL-, SL+
JP-, JP+
TGL
—
Pin to which external focusing phase compensation constants are connected between the FD- and
I
FA- pins.
Pin to which external focusing phase compensation constants are connected between the FA and
I
FE pins.
O
FE signal output pin.
I
Pin to which external FE signal gain setting resistor is connected between the FE pin.
Analog signal GND.
O
Signal ended output of the CV+and CV- pin input signal.
I
Spndle amp input.
I
Pin to which external spindle gain setting resistor in 12 cm mode is connected. (Not connected)
Pin to which external spindle phase compensation constants are connected together with SPD
I
pin.
O
Spindle control signal output pin.
I
Pin to which external sled phase compensation constants are connected.
O
Sled control signal output pin.
I
Sled advance signal input pin from microprocessor.
I
Tracking jump signal input pin from DSP.
I
Tracking gain control signal input from DSP. Low gain when TGL = H.
35
TOFF
I
Tracking off control signal input pin from DSP. Off when TOFF = H.
-26-
Page 27
IC DESCRIPTION-1/3 (LA9241ML)-2/2
Pin No. Pin Name I/O Description
36
TES
O
Pin from which TES signal is output to DSP.
37
38
39, 40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
HFL
SLOF
CV-, CV+
RFSM
RFS-
SLC
SLI
DGND
FSC
TBC
NC
DEF
CLK
CL
DAT
CE
DRF
O
O
O
—
O
—
O
O
“High Frequency Level” is used to judge whether the main beam position is on top of bit or on
top of mirror.
I
Sled servo off control input pin.
I
CLV error signal input pin from DSP.
RF output pin.
I
RF gain setting and EFM signal 3T compensation constant setting pin together with RFSM pin.
“Slice Level Control” is the output pin which controls the RF signal data slice level by DSP.
I
Input pin which control the data slice level by the DSP.
Digital system GND.
Output pin to which external focus search smoothing capacitor is connected.
I
“Tracking Balance Control” EF balance variable range setting pin.
No connection.
Disc defect detector output pin.
I
Reference clock input pin. 4.23 MHz of the DSP is input.
I
Microprocessor command clock input pin.
I
Microprocessor command data input pin.
I
Microprocessor command chip enable input pin.
“Detect RF” RF level detector output.
55
56
57
58
59
60
61
62
63
64
FSS
VCC2
REFI
VR
LF2
PH1
BH1
LDD
LDS
VCC1
—
—
—
I
“Focus Search Select” focus search mode (± search/+ search) select pin. (Not connected)
Servo system and digital system Vcc pin.
Pin to which external bypass capacitor for reference voltage is connected. (Pull down)
O
Reference voltage output pin.
I
Disc defect detector time constant setting pin. (Pull down)
I
Pin to which external capacitor for RF signal peak holding is connected. (Pull up)
I
Pin to which external capacitor for RF signal bottom holding is connected. (Pull down)
O
APC circuit output pin.
I
APC circuit input pin.
RF system Vcc pin.
-27-
Page 28
IC DESCRIPTION-2/3 (LC78622NE)-1/2
Pin No. Pin Name I/O Description
1
2
3
DEFI
TAI
PDO
I
Defect sense signal (DEF) input pin. (Connect to 0V when not used).
I
O
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
Phase comparator output pin to control external VCO.
4
5
6
7
8
9
10
11
12, 13
14
15
16
17
18
19, 20
21
VVSS
ISET
VVDD
FR
VSS
EFMO
EFMIN
TEST2
CLV+, CLV-
___
V/P
HFL
TES
TOFF
TGL
JP+, JP-
PCK
—
—
—
For PLL.
I
I
Digital system GND. Be sure to connect to 0V.
O
For slice level control.
I
I
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
O
Disc motor control output. Three level output is possible using command.
Rough servo or phase control automatic selection monitoring output pin. Rough servo at H.
O
Phase servo at L.
I
Track detect signal input pin. Schmidt input.
I
Tracking error signal input pin. Schmidt input.
O
Tracking OFF output pin.
O
Tracking gain selection output pin. Gain boost at L.
O
Track jump control signal output pin. Three level output is possible using command.
O
EFM data playback clock monitoring pin 4.3218 MHz when phase is locked in. (Not connected)
GND pin for built-in VCO. Be sure to connect to 0V.
Pin to which external resistor adjusting the PD0 output current. (Pull down)
Power supply pin for built-in VCO.
Pin for VCO frequency range adjustment. (Pull down)
EFM signal output pin.
EFM signal input pin.
22
23
24
25
26
27
28
29
30
31
32, 33
34
35
36
37
38
39
40
41
FSEQ
VDD
SL+
SL-
PUSW
PU IN
RW
EMPH
C2F
DOUT
TEST3, TEST4
N.C.
MUTEL
LVDD
LCHO
LVSS
RVSS
RCHO
RVDD
O
—
I/O
I/O
I/O
I/O
I/O
O
O
O
I
—
O
—
O
—
—
O
—
Sync signal detection output pin. H when the sync signal which is detected from EFM signal and
thesync signal which is internally generated agree. (Not connected)
Digital system power supply pin.
The pin is controlled by the serial data command
from microprocessor. When the pin is not used, set
General purpose input/output pin 1 to 5. the pin to the input terminal and connect to 0V, or
alternately set the pin to output terminal and leave
the pin open. (26: Not connected)
De-emphasis monitor output pin. De-emphasis disc is being played back at H. (Not connected)
C2 flag output pin. (Not connected)
DIGITAL OUT output pin. (EIAJ format) (Not connected)
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
Not used. Set the pin to open.
L-channel mute output pin. (Not connected)
L-channel 1-bit DAC.
R-channel 1-bit DAC.
L-channel power supply pin.
L-channel output pin.
L-channel GND. Be sure to connect to 0V.
R-channel GND. Be sure to connect to 0V.
R-channel output pin.
R-channel power supply pin.
42
MUTER
O
R-channel mute output pin. (Not connected)
-28-
Page 29
IC DESCRIPTION-2/3 (LC78622NE)-2/2
Pin No. Pin Name I/O Description
43
44
45
XVDD
XOUT
XIN
—
Crystal oscillator power supply pin.
O
Pin to which external 16.9344 MHz crystal oscillator is connected.
I
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
XVSS
SBSY
EFLG
PW
SFSY
SBCK
FSX
WRQ
RWC
SQOUT
COIN
___________
CQCK
RES
TST11
16M
4.2M
TEST5
—
Crystal oscillator GND pin. Be sure to connect to 0V.
O
Subcode block sync signal output pin. (Not connected)
O
C1, C2, single and dual correction monitoring pin. (Not connected)
O
Subcode P, Q, R, S, T, U and W output pin. (Not connected)
Subcode frame sync signal output pin. Falls down when subcode enters standby.
O
(Not connected)
I
Subcode read clock input pin. Schmidt input. (Be sure to connected to 0V when not in use.)
Pin outputting the 7.35 kHz sync signal which is generated by dividing frequency of crystal
O
oscillator. (Not connected)
O
Subcode Q output standby output pin.
I
Read/write control input pin. Schmidt input.
O
Subcode Q output pin.
I
Command input pin from microprocessor.
I
Command input read clock or subcode read input clock from SQOUT pin
I
LC78622 reset input pin. Set this pin to L once when the main power is turned on.
O
Test signal output pin. Use this pin as open (normally L output). (Not connected)
O
16.9344 MHz output pin. (Not connected)
O
4.2336 MHz output pin.
I
Test signal input pin with built-in pull-down resistor. Be sure to connect to 0V.
63
______
CS
Chip select signal input pin with built-in pull-down resistor. Be sure to connect to 0V while it is
I
not controlling.
64
TEST1
Test signal input pin without built-in pull-down resistor. Be sure to connect to 0V.
I
Note: The same potential must be applied to the respective power supply terminals. (VDD, VVDD, LVDD, RVDD, XVDD)
-29-
Page 30
IC DESCRIPTION-3/3 (LC867132V-5T98)-1/2
Pin No. Pin Name I/O Description
1
2
3
O-RMC/CE
O-DATA
O-CLK
O
CD read/write control output and TU CE.
O
Data output to M62495FP.
O
Output CLK to tuner PLL.
10
11
12
13
14
15
16
17
18
19
20
21
22
4
5
6
7
8
9
TU-DI
O-CLKSFT
I-HOLD
I-RST
XT1 (IN)
XT2 (OUT)
VSS1
CF1 (IN)
CF2 (OUT)
VDD1
I-ST IND
I-KEYO
I-CD SW
I-KEY1
I-MOTOR
I-REC
I-FM/AM
I-TU DO
O-BASS LED
—
—
—
Data output to LC72121M.
O
Clock shift output of the microcomputer.
I
Hold status detection.
I
Microcomputer reset.
I
Connected to 32.768KHZ crystal oscillator.
O
GND.
I
Connected to 6MHZ Ceramic Filter.
O
Power supply for microcomputer (+5V).
I
FM STEREO status input.
I
KEY AD input.
I
CD DOOR SW status detection input.
I
KEY AD input.
I
DECK MECHA MOTOR status input.
I
REC status input.
I
FM, AM status input. (Not connected)
I
Data input from tuner PLL.
O
BASS LED ON/OFF control output. (Not connected)
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37-40
41
42
43-54
O-QS LED
O-DUBB LED
O-INT
I-DRF
I-WRQ
I-REMO
S0/PA0
S1/PA1
S2/PA2
S3/PA3
S4/PA4
S5/PA5
S6/PA6
S7/PA7
S8-S11
VDD3
VSS3
S12-S23
—
—
O
Q-Sound LED ON/OFF control output.
O
LED control output used for high-speed dubbing.
O
INT DIODE MATRIX detection output.
I
CD RF level detection input.
I
CD sub-code Q standby input.
I
Remote control input.
O
LCD segment output.
O
LCD segment output.
O
LCD segment output.
O
LCD segment output.
O
LCD segment output.
O
LCD segment output.
O
LCD segment output.
O
LCD segment output.
O
LCD segment output.
Power supply for microcomputer (+5V).
GND.
O
LCD segment output. (51-54: Not connected)
55
O-CD LED
O
LED ON/OFF control output for CD functions.
-30-
Page 31
IC DESCRIPTION-3/3 (LC867132V-5T98)-2/2
Pin No. Pin Name I/O Description
56
57
58
O-TU LED
O-TA LED
O-ROCK LED
O
LED ON/OFF control output for TU functions.
O
LED ON/OFF control output for TAPE functions. (Not connected)
O
LED ON/OFF control output for ROCK. (Not connected)
59
60
61-63
64-66
67
68
69
70
71
72
73
74
75
76
77
78
79
O-POP LED
O-JAZZ LED
—
COM0-COM2
—
VSS2
VDD2
O-CD ON
O-TU ON
O-P.CONT
___________________
O-H.DUBB
O-MUTE
O-MO/ST
O-BEAT CONT
BEAT
O-COIN
I-SQOUT
—
—
—
—
O
LED ON/OFF control output for POP. (Not connected)
O
LED ON/OFF control output for JAZZ. (Not connected)
Not connected.
O
LCD common output.
Not connected.
GND.
Power supply for microcomputer (+5V).
O
CD PWR control output.
O
TU PWR control output.
O
Power supply control output.
O
Dubbing speed control output.
O
Main mute output.
O
FM mono/stereo output. (Not connected)
O
BEAT switch over output. (Not connected)
O
Beat control output for Q306.
O
CD command output.
I
CD sub-code Q input.
80
O-CQCK
O
CLK for CD commands/sub-codes.
-31-
Page 32
MECHANICAL EXPLODED VIEW -1/1
28
27
32
31
30
29
62
57
26
24
25
56
72
34
33
A
16
A
37
C
23
8
13
64
21
D
22
38
D
15
35
39
70
M
E
H
61
50
45
I
46
H
65
40
K
48
J
41
44
43
42
G
A
F
N
G
G
51
52
A
53
66
67
69
B
B
54
58
11
20
H
60
E
L
E
17
18
H
H
H
H
76
14
19
55
7
6
10
9
2
5
74
1
47
3
36
5
73
4
49
12
75
71
63
M
68
C
59
A
-32-
Page 33
MECHANICAL PARTS LIST -1/2
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
O MC1001 8B-CT5-031-010 WINDOW,CASS L RF a
O MC1002 8B-CT5-209-010 BOX,CASS L RF a
O MC1003 8B-CT5-032-010 WINDOW,CASS R RF a
O MC1004 8B-CT5-210-010 BOX,CASS R RF a
O MC1005 8B-CTA-206-010 SPR-T,CASS a
O MC1006 8B-CT5-028-010 WINDOW,DISP U RF a
O MC1007 8B-CT5-001-110 CABI,FR U a
O MC1008 8B-CT5-040-010 BTN,FUNC RF a
O MC1009 8B-CT5-015-010 BTN,CD a
O MC1010 8B-CT5-044-010 BTN,T-BASS RF a
O MC1011 8B-CT5-039-010 BTN,VOL RF a
0 MC1012 87-NF8-220-010 DMPR,150 a
O MC1013 8Z-CT9-641-010 CONN ASSY,2P PH(CD DOOR) a
O MC1014 8A-CT6-627-010 COVER,1P SMF a
X MC1014a 8A-CDB-628-010 WIRE ASSY,FM-ANT a
X MC1015 8B-CT5-603-010 PWB,MAIN a
X MC1016 8B-CT5-604-010 PWB,FRONT a
O MC1017 8A-CT9-215-010 SPR-P,REC A a
0 MC1018 8B-CT5-208-010 SPR-P,REC a
O MC1019 88-CD6-661-010 HLDR,BAR ANT. a
CA-DW539
U2
0 MC1020 86-CT9-205-110 HLDR,REC a
X MC1021 M8-8ZK-390-070 KSM213CDM a
O MC1022 88-CH6-220-010 CUSHION,CD A a
O MC1023 8B-CT5-203-010 HLDR,LED QSUD a
O MC1024 8B-CT5-201-010 HLDR,LCD a
O MC1025 8B-CT5-202-010 HLDR,LED FUNC a
O MC1026 8B-CT5-038-010 KNOB,RTRY MIC RF a
X MC1027 SF-440-387-20H RUBBER RING (RUBBER) a
O MC1028 8B-CH4-223-010 BASE,CHUCK N a
0 MC1029 8C-CHE-220-010 MAGNET,CD F/M a
O MC1030 86-CT9-222-010 PLATE,MAGNET a
O MC1031 86-CD4-225-110 HLDR,CHUCK A a
O MC1032 8B-CT5-035-010 LID,CD RF a
O MC1033 8B-CT5-046-010 CHAS,CD RF a
0 MC1034 87-036-389-010 SW,PUSH 1-1-1 R8120125 a
O MC1035 8B-CTA-205-010 SPR-T,CD a
O MC1036 8B-CT5-030-010 PANEL,CASS R RF a
0 MC1037 87-063-164-010 OIL-DMPR, a
O MC1038 88-CH6-019-110 PANEL,CD a
O MC1039 8A-CK4-659-010 FF-CABLE,16P 1.0 170MM a
CA-DW539
U2
O MC1040 8B-CT5-036-010 HANDL,ARM RF a
O MC1041 8B-CT5-037-010 HANDL,GRIP RF a
O MC1042 8B-CT5-034-010 LID,BATT RF a
O MC1043 87-A92-048-010 ANT,ROD 5SEC a
O MC1044 8B-CT5-033-010 CABI,REAR RF a
O MC1045 87-A92-285-010 COVER,AC SOCKET COVER PSU27-MC a
! O MC1046 8B-CT5-620-010 PT,U EI-57 a
O MC1047 8B-CT5-029-010 PANEL,CASS L RF a
O MC1048 86-CT9-213-010 SPR-C,BATT(-) a
O MC1049 8B-CT5-207-010 BASE,BTN CD a
! O MC1050 87-A60-177-010 JACK,AC U BLK W/SW a
0 MC1051 8B-CTA-205-010 SPR-T,CD a
O MC1052 8B-CTA-029-010 HLDR,CORD SPKR a
O MC1053 8B-CT5-050-010 CABI,REAR SPKR L RF a
O MC1053 8B-CT5-051-010 CABI,REAR SPKR R RF a
O MC1053a 8B-CTA-209-010 HLDR,SPKR a
O MC1054 8A-CT6-630-010 SPKR,120 2.7OHM RED a
O MC1055 87-B00-010-010 BADGE,AIWA 30.5-5.2 S 2.5L a
O MC1056 8B-CT5-014-010 LENS,Q-SURROUND a
O MC1057 8B-CT5-047-010 LENS,FUNC RF a
CA-DW539
U2
O MC1058 8B-CT5-041-010 BTN,EQ RF a
O MC1059 8Z-CT6-646-010 CORD ASSY,SPEAKER a
X MC1060 M8-ZZM-29G-170 ZZM-2PR3NC1 a
X MC1061 8B-CT5-211-010 CHAS,TU RF a
0 MC1062 8B-CT5-601-010 LCD AIW4239-32P2N a
X MC1063 8B-CT5-608-010 PWB,WIER a
X MC1064 8B-CTA-211-010 HT-SINK,5W/CH a
X MC1065 8B-CTA-213-010 PLATE,PT a
X MC1066 8B-CTA-212-010 PLATE,ANT a
X MC1067 8B-CT5-048-010 CABI,FR SPKR RF a
X MC1068 8B-CT5-049-010 GRILLE,SPKR RF a
X MC1069 8B-CTA-214-010 CUSH,FOOT 12-8-2 a
X MC1070 8B-CT5-605-010 PWB,CD a
X MC1071 8B-CT5-606-010 PWB,POWER a
X MC1072 8B-CT5-607-010 PWB,JACK a
O MC1073 8B-CT5-042-010 KEY,CASS L RF a
O MC1074 8B-CT5-212-010 HLDR,KEY CASS L RF a
O MC1075 8B-CT5-043-010 KEY,CASS R RF a
O MC1076 8B-CT5-213-010 HLDR,KEY CASS R RF a
0 MC1A 87-067-581-010 BVT2+3-15 W/O SLOT a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-33-
Page 34
MECHANICAL PARTS LIST -2/2
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
0 MC1B 87-761-096-410 VFT2+3-10 W/O SLOT a
0 MC1C 87-067-758-010 BVT2+3-12 W/O SLOT a
0 MC1D 8A-CK4-223-010 S-SCREW,CD a
0 MC1E 87-751-096-410 VT2+3-10 W/O SLOT a
0 MC1F 87-741-096-410 UT2+3-10 W/O SLOT a
0 MC1G 87-751-104-410 VT2+3-30 W/O SLOT a
0 MC1H 87-B10-269-010 UT2+3-12 W/O CR a
0 MC1I 87-352-075-210 VF2+2.6-10 a
0 MC1J 87-721-095-410 QT2+3-8 W/O SLOT a
0 MC1K 87-067-660-010 BVT2+3-8 W/O SLOT BLK a
0 MC1L 8A-CDA-222-010 S-SCREW,CASS+2.6-4 a
0 MC1M 87-751-095-410 VT2+3-8 W/O SL0T a
O MC1N 87-254-097-410 U+3-12 CR a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-34-
Page 35
COLOR NAME TABLE -1/1
Basic color symbol Color Basic color symbol Color Basic color symbol Color
B Black C Cream D Orange
G Green H Gray L Blue
LT Transparent Blue N Gold P Pink
R Red S Silver ST Titan Silver
T Brown V Violet W White
WT Transparent White Y Yellow YT Transparent Yellow
LM Metallic Blue LL Light Blue GT Transparent Green
LD Dark Blue DT Transparent Orange GM Metallic Green
YM Metallic Yellow DM Metallic Orange PT Transparent Pink
LA Aqua Blue GL Light Green HT Transparent Gray
HM Metallic Gray NH Champagne Gold M Wood Pattern
-35-
Page 36
TAPE MECHANISM EXPLODED VIEW-1/1 (ZZM-2 PR3NC1)
54
60
61
A
2
18
21
20
13
b
24
22
60
23
54
6
5
28
59
27
25
26
55
29
22
21
20
a
30
4
3
6
5
1
59
46
45
44
53
17
16
13
19
14
18
24
27
26
25
28
B
29
42
55
47
14
19
17
16
38
33
37
62
A
23
31
10
9
57
58
12
11
8
7
43
34
b
1
51
2
a
12
4
3
1
11
10
9
8
7
57
56
40
53
39
48
50
49
51
52
15
47
46
44
45
43
41
36
40
33
37
32
34
1
35
38
58
39
-36-
Page 37
TAPE MECHANISM PARTS LIST -1/1 (ZZM-2 PR3NC1)
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
ZZM-2
PR3NC1
O ST1001 8Z-ZM1-254-410 SPR-C,REEL R a
O ST1002 8Z-ZM1-225-110 GEAR,REEL R a
O ST1003 8Z-ZM1-289-010 SPR-C,AUTO SENSOR C a
O ST1004 8Z-ZM1-217-110 LEVER,AUTO SENSOR a
O ST1005 8Z-ZM1-212-210 LEVER,T-UP a
O ST1006 8Z-ZM1-245-310 SPR-T,AUTO a
O ST1007 8Z-ZM1-236-010 CLR,SLIP FF/REW a
O ST1008 8Z-ZM1-288-010 SPR-C,FF/REW C a
O ST1009 8Z-ZM2-213-010 GEAR,SLIP FR A ZZM-2 a
O ST1010 8Z-ZM1-269-010 FELT,FF/REW 2 a
O ST1011 8Z-ZM1-238-110 GEAR,SLIP FF/REW B 2 a
O ST1012 8Z-ZM1-237-110 LEVER,FF/REW 2 a
O ST1013 8Z-ZM1-209-810 LEVER,PAUSE a
O ST1014 8Z-ZM1-218-410 LEVER,E-LOCK H a
O ST1015 8Z-ZM2-210-010 LEVER,BRIDGE a
O ST1016 8Z-ZM1-244-210 SPR-T,T-UP a
O ST1017 8Z-ZM1-286-010 SPR-T,PINCH C a
O ST1018 8Z-ZM1-291-010 ROLLER ASSY,PINCH Y a
X ST1018a 8Z-ZM1-292-010 CLR,ROLLER Y a
X ST1018b 8Z-ZM1-293-010 ROLLER,PINCH Y a
ZZM-2
PR3NC1
O ST1019 8Z-ZM1-221-310 LEVER,PINCH a
O ST1020 8Z-ZM1-205-510 LEVER,PLAY a
O ST1021 8Z-ZM1-248-310 SPR-T,BRG a
O ST1022 87-A90-403-210 HEAD,RPH MS15R a
O ST1023 84-ZM2-227-310 SPR-C,AZIMUTH a
O ST1024 8Z-ZM1-216-210 LEVER,AUTO a
O ST1025 8Z-ZM1-246-110 SPR-T,AUTO 2 a
O ST1026 8Z-ZM2-214-110 GEAR,IDL REW ZZM-2 a
O ST1027 8Z-ZM2-212-110 LEVER,STOP ZZM-2 a
O ST1028 8Z-ZM1-207-010 LEVER,FF a
O ST1029 8Z-ZM1-206-010 LEVER,REW a
O ST1030 8Z-ZM1-211-210 LEVER,REC 2 a
O ST1031 87-A91-819-010 HEAD,EH 2NSS-2200 a
O ST1032 8Z-ZM2-218-010 LEVER,REC LOCK ZZM-2 a
O ST1033 87-A91-492-010 SW,LEAF MSW18560 a
O ST1034 8Z-ZM1-226-010 GEAR,REEL L a
O ST1035 8Z-ZM1-241-310 SPR-T,PLAY a
O ST1036 8Z-ZM1-220-110 LEVER,REC SENSOR a
O ST1037 8Z-ZM1-287-010 SPR-T,FR C a
O ST1038 8Z-ZM1-242-410 SPR-T,FF/REW a
ZZM-2
PR3NC1
O ST1039 8Z-ZM3-244-110 GEAR,CAM TD20 a
O ST1040 8Z-ZM1-232-010 GEAR,IDL FF/REW a
O ST1041 8Z-ZM1-290-010 FLY-WHL ASSY,ZZM-1 a
X ST1041a 8Z-ZM3-228-210 FLY-WHL,M3 a
X ST1041b 8Z-ZM1-267-110 SHAFT,CAPSTAN 2 a
O ST1042 8Z-ZM2-217-010 SPR-T,PLAY 2 a
O ST1043 8Z-ZM1-228-010 GEAR,SLIP T-UP B a
O ST1044 8Z-ZM1-265-010 FELT,T-UP a
O ST1045 8Z-ZM1-227-010 GEAR,SLIP T-UP A a
O ST1046 8Z-ZM1-251-310 SPR-C,T-UP SLIP a
O ST1047 8Z-ZM1-243-410 SPR-T,STOP/PAUSE a
O ST1048 87-A91-532-010 MOT,MS15U2LW1A a
O ST1049 8Z-ZM1-235-010 PULLEY,MOT a
O ST1050 8Z-ZM2-216-010 BELT,MAIN M a
O ST1051 8Z-ZM1-294-010 SPR-P,CAS 3 a
O ST1052 8Z-ZM2-201-810 CHAS ASSY,ZZM-2 a
X ST1052a 8Z-ZM2-202-810 CHAS ASSY,OUT-SERT ZZM-2 a
X ST1052b 8Z-ZM2-203-310 CHAS,ZZM-2 a
X ST1052c 8Z-ZM1-268-010 BRG,METAL a
O ST1053 8Z-ZM1-255-410 SPR-T,E-LOCK a
ZZM-2
PR3NC1
O ST1054 8Z-ZM2-219-110 LEVER,E-OPEN ZZM-2 a
O ST1055 8Z-ZM1-214-410 LEVER,LOCK a
O ST1056 8Z-ZM2-230-010 FLY-WHL ASSY,ZZM-2 a
X ST1056a 8Z-ZM2-211-310 FLY-WHL,ZZM-2 a
X ST1056b 8Z-ZM1-267-110 SHAFT,CAPSTAN 2 a
O ST1057 8Z-ZM1-257-210 SPR-C,F/R a
O ST1058 8Z-ZM1-275-010 W-L,1.47-4-0.25 a
O ST1059 87-B10-301-010 W-L,1.63-3.2-0.5 SLIT a
X ST1060 87-450-411-010 TERMINAL,LB 1 a
X ST1061 89-930-090-110 WIRE,UB0-9-3 a
X ST1062 89-931-080-110 WIRE,UB1-8-3 a
O ST1A 84-ZM2-252-010 S-SCREW,AZI-2-6.4 C a
O ST1B 8Z-ZM2-220-110 V+2.6 ZZM-2 a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-37-
Page 38
TAPE MECHANISM OTHER PARTS LIST -1/1 (ZZM-2 PR3NC1)
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
ZZM-2
PR3NC1
X 82-ZM3-987-010 BAG,PV 0.04-300-210 a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-38-
Page 39
CD MECHANISM EXPLODED VIEW -1/1 (KSM213CDM)
6
2
COVER
5
1
A
4
3
-39-
Page 40
CD MECHANISM PARTS LIST -1/1 (KSM213CDM)
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
KSM-213
CDM
O SC1001 9X-262-620-210 MOTOR CHASSIS ASSY(MB) a
O SC1002 92-626-907-010 GEAR(A)(S) a
O SC1003 9X-262-576-910 MOTOR GEAR ASSY a
O SC1004 92-626-908-010 SLED SHAFT a
O SC1005 92-627-003-020 GEAR(B)(RP) a
O SC1006 87-A90-468-010 PICK UP KSS-213C a
O SC1A 97-621-255-150 SCREW,+P2-3 a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-40-
Page 41
OTHER PARTS LIST -1/1
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
CA-DW539
U2
X 87-B50-054-010 WARR-CARD,USA CUST/PORTABLE a
X 87-B40-090-010 BAG,PV 0.04-400-500 PL a
X 93-704-336-010 SH,FOAMED-MAT 0.31-750-250 a
X 88-CD5-608-010 SHLD-PLATE,PT BTM a
X 87-033-220-010 PIN DIA1 COATING a
X 87-051-183-010 BAG,PV 0.03-120-280 a
X 87-B40-095-010 BAG,PV 0.04-500-550 PL a
X 8B-CT5-854-010 CTN,PRINTED USC a
X 8B-CT5-852-010 CUSHION,BOTTOM C a
X 8B-CT5-853-010 CUSHION,TOP C a
X 94-875-574-010 SH,FOAMED-MAT 0.31-650-450 a
X 87-B40-085-010 BAG,PV 0.04-200-350 PL a
X 8Z-HC4-209-010 TAG,SENSOR AM a
X SF-440-367-40X LABEL SPKR 2.7 OHM (PAPER) a
X SF-440-111-10J ROUND LABEL(PAPER) a
X SF-440-370-20S SPONGE (25) a
X 87-064-080-010 BINDER,WIRE a
X 8B-CT5-976-010 LBL,POP U2L a
X 8B-CT5-977-010 LBL,POP U2R a
X 84-711-909-010 LBL DATE CODE a
CA-DW539
U2
X 87-B40-282-010 LBL,BAR-CODE AU 35X8 a
X 8B-CT5-045-010 LBL,SPEC U2 RF a
X SF-440-109-00S SPONGE 15*7*5 a
X 8Z-CT9-646-010 WIRE ASSY,2P UL2468 a
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-41-
Page 42
2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111
H251941
Printed in Singapore
Loading...