Page 1
BZG-2
English
SERVICE MANUAL
CD MECHANISM
BASIC CD MECHANISM : KSM-213 RSCM
TYPE
MVSD5GNC
MVSD5GNC1
MVSD5GNC2
MVSD5GNM
MVSD5GNM1
BASIC CD MECHANISM
KSM-213 RSCM
S/M Code No. 09-023-353-2NC
DATA
Page 2
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING -1/1
This set employs laser. Therefore, be sure to follow carefully the
instructions below when servicing.
WARNING!
WHEN SERVICING, DO NOT APPROACH THE LASER EXIT
WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO
CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE
FROM A DISTANCE OF MORE THAN 30cm FROM THE
SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL
PICK-UP BLOCK.
Caution: Invisible laser radiation when
open and interlocks defeated avoid exposure to beam.
Advarsel:Usynling laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
VAROITUS!
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa mainitulla tavalla saattaa altistaa käyt-täjän turvallisuusluokan 1 ylittävälle näkymättömälle lasersäteilylle.
VARNING!
Om apparaten används på annat sätt än vad som specificeras i
denna bruksanvising, kan användaren utsättas för osynling
laserstrålning, som överskrider gränsen för laserklass 1.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
ATTENTION
L'utilisation de commandes, réglages ou procédures autres que
ceux spécifiés peut entraîner une dangereuse exposition aux
radiations.
ADVARSEL!
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer ude
af funktion. Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1 LASER
product.
The CLASS 1 LASER PRODUCT label is located on the rear
exterior.
CLASS 1
KLASSE 1
LUOKAN 1
KLASS 1
LASER PRODUCT
LASER PRODUKT
LASER LAITE
LASER APPARAT
-2-
Page 3
PRECAUTION TO REPLACE OPTICAL BLOCK -1/1 (KSS-213R)
Body or clothes electrostatic potential could ruin
laser diode in the optical block. Be sure ground
body and workbench, and use care the clothes
do not touch the diode.
1) After the connection, remove solder shown in
the right figure.
Solder
PICK-UP Assy PWB
-3-
Page 4
How to Adjust the Rotating Phase of the Gear, Main Cam
1) Pull out the FFC from the CD MAIN C.B, and then remove the TRAY, ASSY.
2) Set the GEAR, MAIN CAM so that the marking on it is positioned at the protrusion of
the CHAS, MECHA as shown in the drawing below.
3) Reassemble the TRAY,ASSY and insert the FFC back to the CD MAIN C.B.
NOTE : If the phase alignment of the GEAR, MAIN CAM is not correctly performed, it will not
work properly.
CHAS, MECHA
GEAR, MAIN CAM
FFC
TRAY, ASSY
PROTRUSION
MARKING
-4-
Page 5
ELECTRICAL PA RTS LIST -1/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0101 87-010-263-040 CAP,E 100-10 M 11L SME a b . d .
3CD O C 0101 87-A12-062-040 CAP,E 100-10 SMG . . c . e
3CD O C 0102 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0103 87-010-555-040 CAP,E 100-10 M 5L SRE a b c d e
3CD O C 0104 87-010-401-040 CAP,E 1-50 M 11L SME a b . d .
3CD O C 0104 87-A12-087-040 CAP,E 1-50 SMG . . c . e
3CD O C 0105 87-012-286-080 C-CAP,U 0.01-25 K B GRM a b c d e
3CD O C 0106 87-012-186-080 C-CAP,U 39P-50 J CH GRM a b c d e
3CD O C 0107 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0108 87-010-263-040 CAP,E 100-10 M 11L SME a b . d .
3CD O C 0108 87-A12-062-040 CAP,E 100-10 SMG . . c . e
3CD O C 0109 87-010-263-040 CAP,E 100-10 M 11L SME a b . d .
3CD O C 0109 87-A12-062-040 CAP,E 100-10 SMG . . c . e
3CD O C 0110 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0111 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0112 87-010-263-040 CAP,E 100-10 M 11L SME a b . d .
3CD O C 0112 87-A12-062-040 CAP,E 100-10 SMG . . c . e
3CD O C 0113 87-012-164-080 C-CAP,U 2P-50 C CH GRM a b c d e
3CD O C 0114 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0115 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0116 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0201 87-A11-058-080 C-CAP,U 0.22-10 K B a b c d e
3CD O C 0202 87-012-270-080 C-CAP,U 470P-50 K B GRM a b c d e
3CD O C 0203 87-012-270-080 C-CAP,U 470P-50 K B GRM a b c d e
3CD O C 0204 87-010-405-040 CAP,E 10-50 M 11L SME a b . d .
3CD O C 0204 87-A12-091-040 CAP,E 10-50 SMG . . c . e
3CD O C 0205 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0206 87-012-282-080 C-CAP,U 4700P-50 K B GRM a b c d e
3CD O C 0207 87-012-286-080 C-CAP,U 0.01-25 K B GRM a b c d e
3CD O C 0208 87-010-400-080 CAP,E 0.47-50 M 11L SME a b . d .
3CD O C 0208 87-A12-086-040 CAP,E 0.47-50 SMG . . c . e
3CD O C 0209 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0210 87-010-992-080 C-CAP,S 0.047-25 K B MK212 a b c d e
3CD O C 0211 87-012-284-080 C-CAP,U 6800P-50 K B GRM a b c d e
3CD O C 0212 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0213 87-A10-260-080 C-CAP,U 0.1-16 K B a b c d e
3CD O C 0214 87-012-174-080 C-CAP,U 12P-50 J CH GRM a b c d e
3CD O C 0215 87-012-174-080 C-CAP,U 12P-50 J CH GRM a b c d e
3CD O C 0216 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0218 87-010-405-040 CAP,E 10-50 M 11L SME a b . d .
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0218 87-A12-091-040 CAP,E 10-50 SMG . . c . e
3CD O C 0219 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0224 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0225 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0250 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0302 87-010-560-040 CAP,E 10-50 M 5L MA a b c d e
3CD O C 0305 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0308 87-010-221-080 CAP,E 470-10 M SME a b . d .
3CD O C 0308 87-016-459-080 CAP,E 470-10 M SMG . . c . e
3CD O C 0309 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0310 87-010-263-040 CAP,E 100-10 M 11L SME a b . d .
3CD O C 0310 87-A12-062-040 CAP,E 100-10 SMG . . c . e
3CD O C 0311 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0313 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0314 87-012-282-080 C-CAP,U 4700P-50 K B GRM a b c d e
3CD O C 0315 87-012-197-080 C-CAP,U 150P-50 J CH GRM a b c d e
3CD O C 0316 87-012-188-080 C-CAP,U 47P-50 J CH GRM a b c d e
3CD O C 0320 87-015-682-040 CAP,E 22-16 M 7L SRA a b c d e
3CD O C 0401 87-010-405-040 CAP,E 10-50 M 11L SME a b . d .
3CD O C 0401 87-A12-091-040 CAP,E 10-50 SMG . . c . e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0601 87-A12-068-010 CAP,E 470-16 SMG a b c d e
3CD O C 0602 87-A12-390-080 C-CAP,S 1-25 Z F GRM40 a b c d e
3CD O C 0603 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0605 87-010-384-040 CAP,E 100-25 M 11L SME a b . d .
3CD O C 0605 87-A12-072-040 CAP,E 100-25 SMG . . c . e
3CD O C 0606 87-A12-390-080 C-CAP,S 1-25 Z F GRM40 a b c d e
3CD O C 0607 87-012-286-080 C-CAP,U 0.01-25 K B GRM a b c d e
3CD O C 0608 87-010-263-040 CAP,E 100-10 M 11L SME a b . d .
3CD O C 0608 87-A12-062-040 CAP,E 100-10 SMG . . c . e
3CD O C 0609 87-A12-390-080 C-CAP,S 1-25 Z F GRM40 a b c d e
3CD O C 0612 87-012-286-080 C-CAP,U 0.01-25 K B GRM a b c d e
3CD O C 0613 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0703 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0704 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0705 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0706 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0707 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0708 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0709 87-010-263-040 CAP,E 100-10 M 11L SME a b . d .
3CD O C 0709 87-A12-062-040 CAP,E 100-10 SMG . . c . e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-5-
Page 6
ELECTRICAL PA RTS LIST -2/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0710 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0710 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0711 87-012-191-080 C-CAP,U 68P-50 J CH GRM a b c d e
3CD O C 0712 87-012-191-080 C-CAP,U 68P-50 J CH GRM a b c d e
3CD O C 0713 87-012-191-080 C-CAP,U 68P-50 J CH GRM a b c d e
3CD O C 0714 87-012-191-080 C-CAP,U 68P-50 J CH GRM a b c d e
3CD O C 0715 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0716 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0717 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0718 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0719 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0720 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0721 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0722 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0723 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0751 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0752 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0753 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0754 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0754 87-A12-071-040 CAP,E 47-25 SMG . . c . e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0755 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0756 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0758 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0759 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0760 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0761 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0762 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0801 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0801 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0802 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0803 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0804 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0805 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0806 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0806 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0807 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0808 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0810 87-A10-706-080 C-CAP,U 0.33-16 Z F a b c d e
3CD O C 0811 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0812 87-010-264-040 CAP,E 100-10 M 5L SRE a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0813 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0814 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0814 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0815 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0816 87-010-264-040 CAP,E 100-10 M 5L SRE a b c d e
3CD O C 0817 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0818 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0819 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0820 87-012-172-080 C-CAP,U 10P-50 D CH GRM a b c d e
3CD O C 0821 87-012-172-080 C-CAP,U 10P-50 D CH GRM a b c d e
3CD O C 0822 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0822 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0823 87-010-378-040 CAP,E 10-16 M 11L SME a b c d .
3CD O C 0823 87-A12-075-040 CAP,E 10-35 SMG . . . . e
3CD O C 0824 87-010-805-080 C-CAP,S 1-16 Z F GRM a b c d e
3CD O C 0825 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0826 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0826 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0827 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0830 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0831 87-010-405-040 CAP,E 10-50 M 11L SME a b c d .
3CD O C 0831 87-A12-091-040 CAP,E 10-50 SMG . . . . e
3CD O C 0832 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0832 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0833 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0834 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0835 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0836 87-010-260-040 CAP,E 47-25 M 11L SME a b . d .
3CD O C 0836 87-A12-071-040 CAP,E 47-25 SMG . . c . e
3CD O C 0837 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0838 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0843 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0844 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0845 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0846 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0847 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0848 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0849 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0850 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0851 87-012-180-080 C-CAP,U 22P-50 J CH GRM a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-6-
Page 7
ELECTRICAL PA RTS LIST -3/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O C 0852 87-012-180-080 C-CAP,U 22P-50 J CH GRM a b c d e
3CD O C 0855 87-012-170-080 C-CAP,U 8P-50 D CH GRM a b c d e
3CD O C 0857 87-012-286-080 C-CAP,U 0.01-25 K B GRM a b c d e
3CD O C 0862 87-012-195-080 C-CAP,U 100P-50 J CH GRM a b c d e
3CD O C 0890 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0892 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0893 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0901 87-012-270-080 C-CAP,U 470P-50 K B GRM a b c d e
3CD O C 0902 87-012-199-080 C-CAP,U 220P-50 J CH GRM a b c d e
3CD O C 0903 87-012-270-080 C-CAP,U 470P-50 K B GRM a b c d e
3CD O C 0904 87-016-459-040 CAP,E 470-10 M SMG a b c d e
3CD O C 0905 87-012-180-080 C-CAP,U 22P-50 J CH GRM a b c d e
3CD O C 0909 87-010-831-080 C-CAP,U 0.1-16 Z F GRM a b c d e
3CD O C 0913 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD X C 0914 88-118-000-080 C-JUMPER,S a b c d e
3CD O C 0915 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0982 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O C 0983 87-012-274-080 C-CAP,U 1000P-50 K B GRM a b c d e
3CD O CN 0101 87-A60-429-010 CONN,16P H TOC-A a b c d e
3CD O CN 0402 84-ZG1-648-010 CONN ASSY,6P a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O CN 0404 87-099-212-010 CONN,5P V BLK 6216 a b c d e
3CD O CN 0601 87-A60-079-010 CONN,08P H 9604S-08F a b c d e
3CD O CN 0801 87-099-201-010 CONN,8P H BLK 6216 a b c d e
3CD S D 0301 87-A40-445-080 ZENER,MTZJ3.9A a b c d e
3CD S D 0303 87-020-465-080 DIODE,1SS133 a b c d e
3CD S D 0402 87-A40-917-080 ZENER,MTZJ3.6B a b c d e
3CD S D 0602 87-A40-344-080 ZENER,MTZJ6.2C a b c d e
3CD S D 0603 87-020-465-080 DIODE,1SS133 a b c d e
3CD S D 0604 87-020-465-080 DIODE,1SS133 a b c d e
3CD S D 0606 87-A40-437-080 ZENER,MTZJ4.3B a b c d e
3CD S D 0608 87-020-465-080 DIODE,1SS133 a b c d e
3CD S D 0701 87-A40-344-080 ZENER,MTZJ6.2C a b c d e
3CD S D 0801 87-A40-917-080 ZENER,MTZJ3.6B a b . d e
3CD S D 0801 87-A40-003-080 ZENER,MTZJ4.3A . . c . .
3CD S D 0803 87-020-465-080 DIODE,1SS133 a b c d e
3CD S D 0804 87-020-465-080 DIODE,1SS133 a b c d e
3CD S D 0805 87-020-465-080 DIODE,1SS133 a b c d e
3CD S D 0901 87-A40-313-080 C-DIODE,MC2840 a b c d e
3CD X FB 0601 88-100-000-010 PLATING-JW, 0.58 SN95 a b c d e
3CD O FB 0602 87-008-474-080 F-BEAD, BL02RN1-R62T2 EMI a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O FB 0603 87-008-474-080 F-BEAD, BL02RN1-R62T2 EMI a b c d e
3CD O FB 0604 87-A50-322-080 C-COIL,S BK2125 LM252 a b c d e
3CD O FB 0605 87-A50-322-080 C-COIL,S BK2125 LM252 a b c d e
3CD O FB 0606 87-A50-322-080 C-COIL,S BK2125 LM252 a b c d e
3CD O FB 0607 87-A50-322-080 C-COIL,S BK2125 LM252 a b c d e
3CD O FB 0608 87-A50-322-080 C-COIL,S BK2125 LM252 a b c d e
3CD X FB 0801 88-100-000-010 PLATING-JW, 0.58 SN95 a b c d e
3CD X FB 0802 88-100-000-010 PLATING-JW, 0.58 SN95 a b c d e
3CD X FB 0803 88-100-000-010 PLATING-JW, 0.58 SN95 a b c d e
3CD X FB 0902 88-121-750-080 RES,75-1/8W J a b c d e
3CD O FB 0903 87-008-372-080 FLTR,EMI BL01 RN1 a b c d e
3CD S IC 0101 87-A21-922-040 C-IC,CXA2550N a b c d e
3CD S IC 0102 87-017-917-040 C-IC,BU4066BCF a b c d e
3CD S IC 0201 87-A21-921-030 C-IC,CXD3068Q a b c d e
3CD S IC 0301 87-A21-161-040 C-IC,BA6392FP a b c d e
3CD S IC 0401 87-070-289-040 C-IC,BU2092F a b c d e
3CD S IC 0701 87-A21-893-040 C-IC,NJM14558V-TE2 a b c d e
3CD S IC 0702 87-A21-893-040 C-IC,NJM14558V-TE2 a b c d e
3CD S IC 0801 87-A22-338-030 C-IC,ES3880FM a b . d e
3CD S IC 0801 87-A21-923-030 C-IC,ES3880 . . c . .
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD S IC 0802 87-A21-924-030 C-IC,ES3889 a b c d e
3CD S IC 0803 8C-ZA6-610-010 C-IC,HT27C020BLA a b . . .
3CD S IC 0803 87-A21-927-010 C-IC,SST39SF020A . . c . .
3CD S IC 0803 87-A22-340-040 C-IC,HT27C020(V0A) . . . d e
3CD S IC 0804 87-A21-925-030 C-IC,SM81C256K16D-35 a b c d e
3CD O J 0901 87-009-502-010 JACK,PIN 1P YEL W/O SW a b c d e
3CD X JR 0804 88-128-000-080 C-JUMPER,3216 a b c d e
3CD X JR 0806 88-108-000-080 C-JUMPER,U a b c d e
3CD X JW 0101 88-128-000-080 C-JUMPER,3216 a b c d e
3CD X JW 0102 88-128-000-080 C-JUMPER,3216 a b c d e
3CD X JW 0201 88-128-000-080 C-JUMPER,3216 a b c d e
3CD X JW 0202 88-128-000-080 C-JUMPER,3216 a b c d e
3CD X JW 0801 88-100-000-010 PLATING-JW, 0.58 SN95 a b c d e
3CD O L 0901 87-005-424-080 COIL,2.2UH K FLR50 a b c d e
3CD O M 0201 87-045-305-010 MOT,RF-500TB a b c d e
3CD S Q 0101 87-026-609-080 TR,KTA1266GR a b c d e
3CD S Q 0102 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0103 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0301 87-A30-520-080 TR,2SC5342Y a b c d e
3CD S Q 0302 87-A30-520-080 TR,2SC5342Y a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-7-
Page 8
ELECTRICAL PA RTS LIST -4/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD S Q 0303 87-A30-520-080 TR,2SC5342Y a b c d e
3CD S Q 0304 87-A30-520-080 TR,2SC5342Y a b c d e
3CD S Q 0305 87-A30-520-080 TR,2SC5342Y a b c d e
3CD S Q 0306 87-A30-520-080 TR,2SC5342Y a b c d e
3CD S Q 0307 87-A30-520-080 TR,2SC5342Y a b c d e
3CD S Q 0308 87-A30-520-080 TR,2SC5342Y a b c d e
3CD S Q 0309 89-332-665-080 TR,2SC3266GR a b c d e
3CD S Q 0310 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0311 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0312 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0313 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0402 89-111-625-080 C-TR,2SA1162GR a b c d e
3CD S Q 0403 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0404 87-A30-087-080 C-FET,2SK2158 a b c d e
3CD S Q 0405 89-111-625-080 C-TR,2SA1162GR a b c d e
3CD S Q 0601 89-112-965-080 TR,2SA1296GR a b c d e
3CD S Q 0602 89-112-965-080 TR,2SA1296GR a b c d e
3CD S Q 0603 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0604 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0605 89-332-665-080 TR,2SC3266GR a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD S Q 0606 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0801 89-332-665-080 TR,2SC3266GR a b c d e
3CD S Q 0802 89-327-125-080 C-TR,2SC2712GR a b c d e
3CD S Q 0803 87-A30-087-080 C-FET,2SK2158 a b c d e
3CD S Q 0804 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0805 87-A30-087-080 C-FET,2SK2158 a b c d e
3CD S Q 0806 87-A30-076-080 C-TR,2SC3052F a b c d e
3CD S Q 0901 89-111-625-080 C-TR,2SA1162GR a b c d e
3CD O R 0101 88-108-153-080 C-RES,U 15K-1/16W J a b c d e
3CD O R 0102 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0103 88-108-105-080 C-RES,U 1M-1/16W J a b c d e
3CD O R 0104 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD X R 0105 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0106 88-108-332-080 C-RES,U 3.3K-1/16W J a b c d e
3CD O R 0107 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0108 88-108-473-080 C-RES,U 47K-1/16W J a b c d e
3CD O R 0109 88-108-473-080 C-RES,U 47K-1/16W J a b c d e
3CD O R 0110 88-108-332-080 C-RES,U 3.3K-1/16W J a b c d e
3CD O R 0111 88-108-332-080 C-RES,U 3.3K-1/16W J a b c d e
3CD X R 0114 88-108-100-080 C-RES,U 10-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD X R 0115 88-108-333-080 C-RES,U 33K-1/16W J a b c d e
3CD X R 0116 88-108-333-080 C-RES,U 33K-1/16W J a b c d e
3CD X R 0117 88-108-333-080 C-RES,U 33K-1/16W J a b c d e
3CD X R 0118 88-108-333-080 C-RES,U 33K-1/16W J a b c d e
3CD X R 0119 88-108-333-080 C-RES,U 33K-1/16W J a b c d e
3CD X R 0120 88-108-333-080 C-RES,U 33K-1/16W J a b c d e
3CD X R 0121 88-108-181-080 C-RES,U 180-1/16W J a b c d e
3CD O R 0124 88-108-823-080 C-RES,U 82K-1/16W J a b c d e
3CD O R 0125 88-108-563-080 C-RES,U 56K-1/16W J a b c d e
3CD O R 0126 88-108-563-080 C-RES,U 56K-1/16W J a b c d e
3CD X R 0127 88-108-000-080 C-JUMPER,U a b c d e
3CD O R 0128 88-108-823-080 C-RES,U 82K-1/16W J a b c d e
3CD O R 0129 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0130 88-108-000-080 C-JUMPER,U a b c d e
3CD X R 0134 88-108-000-080 C-JUMPER,U a b c d e
3CD O R 0137 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0138 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD O R 0205 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0206 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0207 88-108-224-080 C-RES,U 220K-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD X R 0208 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0209 88-108-332-080 C-RES,U 3.3K-1/16W J a b c d e
3CD X R 0210 88-108-182-080 C-RES,U 1.8K-1/16W J a b c d e
3CD X R 0211 88-108-333-080 C-RES,U 33K-1/16W J a b c d e
3CD O R 0212 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD X R 0213 88-108-104-080 C-RES,U 100K-1/16W J a b c d e
3CD X R 0214 88-108-000-080 C-JUMPER,U a b c d e
3CD O R 0215 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0216 88-108-332-080 C-RES,U 3.3K-1/16W J a b c d e
3CD O R 0217 88-108-332-080 C-RES,U 3.3K-1/16W J a b c d e
3CD X R 0218 88-108-824-080 C-RES,U 820K-1/16W J a b c d e
3CD X R 0219 88-108-474-080 C-RES,U 470K-1/16W J a b c d e
3CD X R 0220 88-108-105-080 C-RES,U 1M-1/16W J a b c d e
3CD X R 0224 88-108-470-080 C-RES,U 47-1/16W J a b c d e
3CD X R 0225 88-108-470-080 C-RES,U 47-1/16W J a b c d e
3CD X R 0226 88-108-470-080 C-RES,U 47-1/16W J a b c d e
3CD X R 0229 88-108-000-080 C-JUMPER,U a b c d e
3CD X R 0230 88-108-000-080 C-JUMPER,U a b c d e
3CD X R 0231 88-108-000-080 C-JUMPER,U a b c d e
3CD X R 0232 88-108-000-080 C-JUMPER,U a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-8-
Page 9
ELECTRICAL PA RTS LIST -5/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD X R 0233 88-108-000-080 C-JUMPER,U a b c d e
3CD X R 0234 88-108-000-080 C-JUMPER,U a b c d e
3CD O R 0235 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0244 88-108-392-080 C-RES,U 3.9K-1/16W J a b c d e
3CD X R 0245 88-108-105-080 C-RES,U 1M-1/16W J a b c d e
3CD X R 0246 88-108-474-080 C-RES,U 470K-1/16W J a b c d e
3CD X R 0301 88-128-181-080 C-RES, 180-1/8W J a b c d e
3CD X R 0304 88-128-689-080 C-RES, 6.8-1/8W J a b c d e
3CD O R 0305 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0306 88-128-000-080 C-JUMPER,3216 a b c d e
3CD O R 0308 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD X R 0309 88-108-154-080 C-RES,U 150K-1/16W J a b c d e
3CD O R 0310 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0311 88-108-182-080 C-RES,U 1.8K-1/16W J a b c d e
3CD O R 0312 88-108-562-080 C-RES,U 5.6K-1/16W J a b c d e
3CD X R 0314 88-128-689-080 C-RES, 6.8-1/8W J a b c d e
3CD O R 0315 88-108-272-080 C-RES,U 2.7K-1/16W J a b c d e
3CD X R 0316 88-108-682-080 C-RES,U 6.8K-1/16W J a b c d e
3CD O R 0317 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0318 88-108-101-080 C-RES,U 100-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0319 88-108-272-080 C-RES,U 2.7K-1/16W J a b c d e
3CD X R 0320 88-108-682-080 C-RES,U 6.8K-1/16W J a b c d e
3CD O R 0321 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0324 88-108-272-080 C-RES,U 2.7K-1/16W J a b c d e
3CD O R 0325 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0326 88-128-399-080 C-RES, 3.9-1/8W J a b c d e
3CD X R 0327 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0328 88-108-562-080 C-RES,U 5.6K-1/16W J a b c d e
3CD O R 0329 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0330 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0331 88-108-272-080 C-RES,U 2.7K-1/16W J a b c d e
3CD X R 0332 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0333 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0334 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0335 88-108-473-080 C-RES,U 47K-1/16W J a b c d e
3CD X R 0336 88-128-569-080 C-RES, 5.6-1/8W J a b c d e
3CD X R 0337 88-128-339-080 C-RES, 3.3-1/8W J a b c d e
3CD X R 0340 88-108-222-080 C-RES,U 2.2K-1/16W J a b c d e
3CD X R 0341 88-128-271-080 C-RES, 270-1/8W J a b c d e
3CD O R 0401 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD X R 0403 88-108-471-080 C-RES,U 470-1/16W J a b c d e
3CD O R 0404 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD X R 0405 88-108-471-080 C-RES,U 470-1/16W J a b c d e
3CD X R 0406 88-108-471-080 C-RES,U 470-1/16W J a b c d e
3CD X R 0407 88-108-471-080 C-RES,U 470-1/16W J a b c d e
3CD O R 0408 88-108-822-080 C-RES,U 8.2K-1/16W J a b c d e
3CD O R 0409 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD O R 0410 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD O R 0411 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0412 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0413 88-108-473-080 C-RES,U 47K-1/16W J a b c d e
3CD O R 0414 88-108-562-080 C-RES,U 5.6K-1/16W J a b c d e
3CD X R 0415 88-108-682-080 C-RES,U 6.8K-1/16W J a b c d e
3CD O R 0416 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0417 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0418 88-108-272-080 C-RES,U 2.7K-1/16W J a b c d e
3CD X R 0419 88-108-122-080 C-RES,U 1.2K-1/16W J a b c d e
3CD X R 0420 88-108-682-080 C-RES,U 6.8K-1/16W J a b c d e
3CD X R 0422 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD X R 0423 88-108-222-080 C-RES,U 2.2K-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD X R 0424 88-108-682-080 C-RES,U 6.8K-1/16W J a b c d e
3CD O R 0601 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0602 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD X R 0603 88-108-152-080 C-RES,U 1.5K-1/16W J a b c d e
3CD X R 0604 88-108-152-080 C-RES,U 1.5K-1/16W J a b c d e
3CD X R 0607 88-108-151-080 C-RES,U 150-1/16W J a b c d e
3CD O R 0608 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD O R 0609 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0610 88-128-681-080 C-RES, 680-1/8W J a b c d e
3CD O R 0611 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0612 88-108-151-080 C-RES,U 150-1/16W J a b c d e
3CD O R 0613 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0614 88-128-000-080 C-JUMPER,3216 a b c d e
3CD O R 0617 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0620 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD O R 0701 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0702 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0703 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD O R 0704 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD O R 0705 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-9-
Page 10
ELECTRICAL PA RTS LIST -6/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0706 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0707 88-128-181-080 C-RES, 180-1/8W J a b c d e
3CD O R 0708 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0709 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0710 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD O R 0711 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD O R 0713 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD O R 0714 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD X R 0715 88-108-273-080 C-RES,U 27K-1/16W J a b c d e
3CD X R 0716 88-108-273-080 C-RES,U 27K-1/16W J a b c d e
3CD X R 0717 88-108-273-080 C-RES,U 27K-1/16W J a b c d e
3CD X R 0718 88-108-273-080 C-RES,U 27K-1/16W J a b c d e
3CD X R 0719 88-108-824-080 C-RES,U 820K-1/16W J a b c d e
3CD X R 0720 88-108-824-080 C-RES,U 820K-1/16W J a b c d e
3CD X R 0721 88-108-824-080 C-RES,U 820K-1/16W J a b c d e
3CD X R 0722 88-108-824-080 C-RES,U 820K-1/16W J a b c d e
3CD O R 0751 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0752 88-108-223-080 C-RES,U 22K-1/16W J a b c d .
3CD O R 0752 88-108-473-080 C-RES,U 47K-1/16W J . . . . e
3CD O R 0753 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0754 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0755 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD O R 0756 88-108-223-080 C-RES,U 22K-1/16W J a b c d e
3CD O R 0757 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0758 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0759 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0801 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD X R 0802 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0804 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0808 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0809 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0810 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD X R 0811 88-108-271-080 C-RES,U 270-1/16W J a b c d e
3CD X R 0812 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD X R 0813 88-108-104-080 C-RES,U 100K-1/16W J a b c d e
3CD O R 0814 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0815 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0816 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0817 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0818 88-128-120-080 C-RES, 12-1/8W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0819 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0820 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD X R 0821 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD X R 0822 88-128-101-080 C-RES, 100-1/8W J a b c d e
3CD X R 0823 88-128-120-080 C-RES, 12-1/8W J a b c d e
3CD O R 0824 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD O R 0825 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0826 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0827 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0828 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0829 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0830 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD O R 0831 88-108-103-080 C-RES,U 10K-1/16W J a b c d e
3CD X R 0832 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD X R 0833 88-108-470-080 C-RES,U 47-1/16W J a b c d e
3CD O R 0834 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0835 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0836 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0837 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0841 88-108-101-080 C-RES,U 100-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0842 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0843 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0844 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0845 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0846 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0847 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0848 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0849 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0855 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0856 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0857 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0858 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0859 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0860 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0861 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0862 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0863 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0864 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0865 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0866 88-108-101-080 C-RES,U 100-1/16W J a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-10-
Page 11
ELECTRICAL PA RTS LIST -7/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0867 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0868 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0869 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0870 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0871 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0872 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0873 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0874 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0875 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0876 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0877 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0878 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0879 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0880 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0881 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0882 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0883 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0884 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0885 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0886 88-108-101-080 C-RES,U 100-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0887 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0888 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0889 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0890 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0891 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0892 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0893 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0894 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0895 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0896 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0897 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0898 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0899 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0900 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD X R 0901 88-108-750-080 C-RES,U 75-1/16W J a b c d e
3CD X R 0902 88-108-221-080 C-RES,U 220-1/16W J a b c d e
3CD X R 0903 88-108-000-080 C-JUMPER,U a b c d e
3CD O R 0905 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0906 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0907 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD X R 0908 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0909 88-108-102-080 C-RES,U 1K-1/16W J a b c d e
3CD X R 0910 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD X R 0911 88-108-472-080 C-RES,U 4.7K-1/16W J a b c d e
3CD O R 0912 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0913 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0914 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0915 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0916 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0917 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0918 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0919 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0920 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0921 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0922 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0923 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0924 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0925 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0926 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0927 88-108-101-080 C-RES,U 100-1/16W J a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O R 0928 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0929 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0930 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0931 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0932 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0933 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0934 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0935 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0936 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0937 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0938 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0939 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0940 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0941 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0942 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0943 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O R 0944 88-108-101-080 C-RES,U 100-1/16W J a b c d e
3CD O S 0301 87-036-109-010 SW,MICRO SPPB61 a b c d e
3CD O S 0302 87-036-109-010 SW,MICRO SPPB61 a b c d e
3CD O S 0801 87-A90-162-010 SW,SL 1-1-3 SSSU a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-11-
Page 12
ELECTRICAL PA RTS LIST -8/9
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
3CD O W 0001 8B-ZG2-601-010 FF-CABLE,16P 1.0 115MM a . . . .
3CD O W 0002 8B-ZG2-602-010 FF-CABLE,5P 1.25 185MM a b c d e
3CD O X 0201 87-030-270-080 VIB,XTAL 16.9344MHZ HC-49/U03 a b c d e
3CD O X 0801 87-A70-125-080 VIB,XTAL 27MHZ 50PPM a b c d e
T-T O C 0401 87-A11-148-080 CAP,TC U 0.1-50 Z F a b c d e
T-T O CN 0401 86-NFZ-675-010 CONN,5P H 6216-11H a b c d e
T-T O M 0001 87-A91-982-010 MOT,M25E-4 2054 a b c d e
T-T O PS 0401 87-A90-156-010 SNSR,SG-240 a b c d e
T-T X R 0408 88-121-561-080 RES,560-1/8W J a b c d e
T-T X R 0409 88-121-273-080 RES,27K-1/8W J a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-12-
Page 13
ELECTRICAL PARTS LIST -9/9
• Regarding connectors, they are not stocked as they are not the initial order items.
The connectors are available after they are supplied from connector manufacturers upon the order is received.
-13-
Page 14
TRANSISTOR ILLUSTRATION -1/1
E
CB
KTA1266GR
2SC5342Y
2SA1296
2SC3266
B
E
2SC3052F
2SA1162
2SC2712
C
G
S
2SK2158
D
-14-
Page 15
BLOCK DIAGRAM -1/1
-15-
Page 16
SCHEMATIC DIAGRAM -1/2
-16-
Page 17
SCHEMATIC DIAGRAM -2/2
Q801
REG.
FB604 FB608
COIL, S BK2125
DRAM
17
IC701 AMP
16
15
C2PO
4.9V
6.9V
Q601 604
7.9V
-17-
Page 18
WIRING -1/2 (3CD C.B) -1/2
3CD C.B (COMPONENT SIDE)
181920212223242526272829303132
17 16151413121110987654321
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
-18-
R
S
T
U
Page 19
WIRING -1/2 (3CD C.B) -2/2
151413121110987654321
A
16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
3CD C.B (CONDUCTOR SIDE)
B
TO KSM-213RSCM
C
D
E
F
G
H
PICK UP ASSY
(W001)
1
2
S301
(TRAY SW)
15
16
(CD MOUNT SW)
1
2
TO MOTOR C.B
S302
5
6
PIN 3
1
6
S801
AUTO NTSC PAL
I
J
K
L
M
N
O
P
Q
TO MAIN UNIT
J901
VIDEO
OUT
8
7
2
1
5
4
M201
2
1
M
1
2
7
8
R
S
M201
(TRAY MOTOR)
TO MAIN UNIT
TO T-T C.B
(W002)
CN401
T
U
-19-
Page 20
WIRING -2/2 (T-T C.B)
123456789101112131415
A
TO 3CD C.B
CN404
M001
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
-20-
T
U
Page 21
WAVE FORM -1/2
1
39
IC201 (FC)
VOLT/DIV: 500mV
TIME/DIV: 500mS
8
IC401 (DISHF)
3
9
IC401 (DISHR)
4
1
IC401 (D+)
7
IC401 (D-)
8
2
VOLT/DIV: 5V
TIME/DIV: 500mS
IC201 (TE)
2
IC401
0.8Vp-p
8
9
CN404
1
2
41
VOLT/DIV: 500mV
TIME/DIV: 1S
OPEN
9
M201
-
+
3.9Vp-p
5Vp-p
4Vp-p
3Vp-p
VOLT/DIV: 2V
TIME/DIV:500mS
2.5Vp-p
1.8Vp-p
8 VOLT/DIV: 5V
IC401 (DISHF)
3
9
IC401 (DISHR)
4
IC401 (DISHAF)
5
IC401 (DISHR)
6
14
15
8
9
14
15
TIME/DIV: 500mS
3.8Vp-p
4.9Vp-p
2Vp-p
2Vp-p
-21-
CLOSE
10
M201
-
+
VOLT/DIV: 2V
TIME/DIV: 500mS
7.2Vp-p
Page 22
WAVE FORM -2/2
OPEN
6
IC401 (OPEN)
3
IC401 (CLOSE)
11
12
13
7
12
IC401 (OPEN)
13
IC401 (CLOSE)
VOLT/DIV: 5V
TIME/DIV: 500mS
2
CN404 D+ D- ( :0 Level)
14
1
2
VOLT/DIV: 1V
TIME/DIV: 500mS
2.2Vp-p
6
7
12
13
CLOSE
IC401 (OPEN)
3
IC401 (CLOSE)
11
IC401 (OPEN)
12
IC401 (CLOSE)
13
6
5Vp-p
0Vp-p
1.5Vp-p
1.5Vp-p
2
CN404 D+ D- ( :0 Level)
14
1
2.0Vp-p
2
VOLT/DIV: 1V
2.4Vp-p
TIME/DIV: 500mS
6
7
12
13
VOLT/DIV: 5V
TIME/DIV: 500mS
5Vp-p
CN404
2.3Vp-p
1
3.15Vp-p
2
7
12
13
5Vp-p
1.5Vp-p
1.5Vp-p
-22-
Page 23
IC BLOCK DIAGRAMS -1/2
IC,CXA2550
AGC
VTH
LD
1k
APC LD
1
2
APC PD.AMP
VEE
VEE
10k
55k
56k
10k
10k
AMP
56k
Vcc
20
19
VCC
LD ON
PD
PD1
PD2
VEE
F
E
E1
VC
10
3
4
5
6
7
7
VC
VC
VC
VC
VC
10k
VC
10k
VC
12p
8k
8k
VEE
12p
8
VC
9
VC
49
2k
25k
260k
260k
26k
2k
13k
13k
15k
VREF 1.25V
6p
6p
Vcc
30k
30k
10k
32k
24p
670mV
VC
2k
2k
32k
VC
30k
30k
VC
87k
96k
95k
13.4k
VEE
154k
50 A
15k
VC
6k
54k
24p
174k
FOCUS
ERROR
AMP
TRACKING
ERROR
AMPVEE
Vcc
18
17
16
15
14
13
12
11
7
AGC CONT
RFTC
RF1
RFO
RFM
FE
FE BIAS
TE
IC,BU4066BCF
E OUT
B/D IN
B/D OUT
CONTROL
(B/D)
CONTROL
(F)
VSS
VDD
1
OUT/IN IN/OUT
SWA
2
3
SWD
OUT/IN IN/OUT
4
IN/OUT OUT/IN
5
SWB
6
SWC
IN/OUT OUT/IN
7
14
13
12
11
10
9
8
CONTROL
(E)
CONTROL
(A/C)
A/C OUT
A/C IN
F OUT
F IN
-23-
Page 24
IC BLOCK DIAGRAMS -2/2
IC,BA6392FP
IC,BU2092
VSS
DATA
CLK
LCK
CD-ON
OPEN
CLOS
DISHF
DISHR
CONTROL CIRCUIT
VDD
OE
DISHR
DISHF
CLOSE
OPEN
LED
MOTE
IC,SST39SF
-24-
Page 25
IC DESCRIPTION -1/4 (CXD3068Q) -1/2
Pin No. Pin Name I/O Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
DVDD0
XRST
MUTE
DATA
XLAT
CLOK
SENS
SCLK
ATSK
WFCK
XUGF
XPCK
GFS
C2PO
SCOR
C4M
WDCK
DVSS0
COUT
MIRR
DFCT
FOK
PWMI
LOCK
MDP
SSTP
FSTO
DVDD1
SFDR
SRDR
TFDR
TRDR
FFDR
FRDR
DVSS1
TEST
TES1
VC
FC
—
O
I/O
O
O
O
O
O
O
O
O
—
I/O
I/O
I/O
I/O
I/O
O
O
—
O
O
O
O
O
O
—
Digital power supply.
I
System reset. Reset when low.
I
Mute input (low: off, high: on)
I
Serial data input from CPU.
I
Latch input from CPU. Serial data is latched at the falling edge.
I
Serial data transfer clock input from CPU.
SENS output to CPU.
I
SENS serial data readout clock input.
Anti-shock input/output.
WFCK output. (Not connected)
XUGF output. MNT0 or RFCK is output by switching with the command. (Not connected)
XPCK output. MNT1 is output by switching with the command. (Not connected)
GFS output. MNT2 or XROF is output by switching with the command.
G2PO output. MNT3 or GTOP is output by switching with the command.
Outputs a high signal when either subcode sync S0 or S1 is detected.
4.2336MHz output. 1/4 frequency division output for V16M in CAV-W mode or variable pitch
mode. (Not connected)
Word clock output. f = 2Fs. GRSCOR is output by the command switching. (Not connected)
Digital GND.
Track count signal I/O. (Not connected)
Mirror signal I/O. (Not connected)
Detect signal I/O. (Not connected)
Focus OK signal I/O.
I
Spindle motor external control input.
GFS is sampled at 460Hz; when GFS is high, this pin outputs a high signal.If GFS is low eight
consecutive samples, this pin outputs low. Input when LKIN = 1. (Not connected)
Spindle motor servo control output.
I
Disc innermost track detection signal input.
2/3 frequency division output for XTAI pin. (Not connected)
Digital power supply.
Sled drive output.
Sled drive output.
Tracking drive output.
Tracking drive output.
Focus drive output.
Focus drive output.
Digital GND.
I
Test. Normally, GND.
I
Test. Normally, GND.
I
Center voltage input.
I
Focus error signal input.
40
SE
I
Sled error signal input.
-25-
Page 26
IC DESCRIPTION -1/4 (CXD3068Q) -2/2
Pin No. Pin Name I/O Description
41
TE
I
Tracking error signal input.
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
CE
RFDC
ADIO
AVSS0
IGEN
AVDD0
ASYO
ASYI
RFAC
AVSS1
CLTV
FILO
FILI
PCO
AVDD1
BIAS
VCTL
V16M
VPCO
DVDD2
ASYE
MD2
DOUT
LRCK
PCMD
BCK
EMPH
XTSL
DVSS2
XTAL1
XTAL0
SOUT
SOCK
XOLT
SQSO
SQCK
SCSY
SBSO
O
—
—
O
—
O
O
—
I/O
O
—
O
O
O
O
O
—
O
O
O
O
O
O
I
Center servo analog input.
I
RF signal input.
Test. No connected.
Analog GND.
I
Constant current input for operational amplifier.
Analog power supply.
EFM full-swing output. (low = Vss, high = VDD)
I
Asymmetry comparator voltage input.
I
EFM signal input.
Analog GND.
I
Multiplier VCO1 control voltage input.
Master PLL filter output (slave = digital PLL).
I
Master PLL filter input.
Master PLL charge pump output.
Analog power supply.
I
Asymmetry circuit constant current input.
I
Wide-band EFM PLL VCO2 control voltage input.
Wide-band EFM PLL VCO2 oscillation output. Serves as wide-band EFM PLL clock input by
switching with the command. (Not connected)
Wide-band EFM PLL charge pump output.
Digital power supply.
I
Asymmetry circuit on/off (low = off, high = on).
I
Digital Out on/off control (low = off, high = on).
Digital Out output.
D/A interface. LR clock output. f = Fs
D/A interface. Serial data output (two’s complement, MSB first).
D/A interface. Bit clock output.
Outputs a high signal when the playback disc has emphasis, and a lowsignal when there is no
emphasis. (Not connected)
I
Crystal selection input. Low when the crystal is 16.9344MHz; high when it is 33.8688MHz.
Digital GND.
I
Crystal oscillation circuit input. When the master clock is input externally, input it from this pin.
Crystal oscillation circuit output.
Serial data output in servo block. (Not connected)
Serial data readout clock output in servo block. (Not connected)
Serial data latch output in servo block. (Not connected)
Sub-Q 80-bit, PCM peak or level data outputs. CD TEXT data output.
I
SQSO readout clock input.
I
GRSCOR resynchronization input. (Not connected)
Sub-Q P to W serial output.
80
EXCK
I
SBSO readout clock input.
-26-
Page 27
IC DESCRIPTION -2/4 (ES3880) -1/2
Pin No. Pin Name I/O Description
1
2
3
VDD3
________
RAS
__________
DWE
—
Voltage supply for 3.3 V.
O
DRAM row address strobe. (active low)
O
DRAM write enable. (active low)
4-12
13-28
29
30
31
32-39
40
41
42
43
44
45-49
50
51
52
53
54
MA0-MA8
DBUS0-DBUS15
_____________
RESET
GND
VDD3
YUV0-YUV7
VSYNC
HSYNC
CPUCLK
PCLK2X
PCLK
AUX0-AUX4
GND
VDD3
AUX6
AUX5
AUX7
O
I/O
—
—
O
I/O
I/O
I/O
I/O
I/O
—
—
I/O
I/O
I/O
DRAM multiplexed row and column address bus.
DRAM data bus.
I
System reset. (active low)
Ground.
Voltage supply for 3.3 V.
Y is luminance, UV are chrominance data bus for screen video interface.
YUV [7: 0] for 8-bit YUV mode.
Vertical sync for screen video interface, programmable for rising or falling edge.
Horizontal sync for screen video interface, programmable for rising or falling edge.
RISC and system clock input.
I
CPUCLK is used only if SEL_PLL [1: 0] = 00.
Pixel clock; two times the actual pixel clock for screen video interface.
Pixel clock qualifier in for screen video interface.
Auxiliary control pins. (AUX0 and AUX1 are open collectors)
Ground.
Voltage supply for 3.3 V.
Auxiliary control pins.
Auxiliary control pins.
Auxiliary control pins.
55-62
63
64
65-67
68-79
80
81
82-87
88
89
90
LD0-LD7
__________
LWR
________
LOE
__________ _________
LCS3-LCS0
LA0-LA11
GND
VDD5
LA12-LA17
ACLK
AOUT/SELPLL1
ATCLK
I/O
O
O
O
O
—
—
O
I/O
O
I/O
RISC interface data bus.
RISC interface write enable. (active low) (Not connected)
RISC interface output enable. (active low)
RISC interface chip select. (active low)
RISC interface address bus.
Ground.
Digital supply voltage for 5 V.
RISC interface address bus.
Master clock for external audio DAC. (8.192 MHz, 11.2896 MHz, 12.288 MHz, 16.9344MHz,
and 18.432 MHz)
Dual-purpose pin. AOUT is the audio interface serial data output.
Pins SEL_PLL [1: 0] select phase-lock loop (PLL) clock frequency CPUCLK for the Visba:
00 = bypass PLL.
I
01 = 54 MHz PLL.
10 = 67.5 MHz PLL.
11 = 81 MHz PLL.
Audio transmit bit clock.
-27-
Page 28
IC DESCRIPTION -2/4 (ES3880) -2/2
Pin No. Pin Name I/O Description
Dual-purpose pin. ATFS is the audio interface transmit frame sync.
O
91
92
93
94
95
96
97
98
99
100
ATPS/SEL_PLL1
________
DOE
AIN
ARCLK
ARFS
TDMCLK
TDMDP
TDMFS
________
CAS
GND
—
Pins SEL_PLL [1: 0] select phase-lock loop (PLL) clock frequency CPUCLK for the Visba.
I
See the SEL_PLL0 pin above for the settings.
Dual purpose pin: DRAM output enable. (active low)
O
Audio interface serial data input.
I
Audio receive bit clock.
I
Audio interface receive frame sync.
I
TDM interface serial clock.
I
TDM interface serial data receive.
I
TDM interface frame sync.
I
DRAM column address strobe bank 0. (active low)
O
Ground.
-28-
Page 29
IC DESCRIPTION -3/4 (ES3889) -1/3
Pin No. Pin Name I/O Description
1, 2
3
4
GND
NC
GND
—
I
I
Ground.
No connect.
Ground.
10
11
12
13
14
15
16
17
18
19
20
21
22
5
6
7
8
9
VDD
OSC_C
AUX0
DSC_D0
AUX1
DSC_S
AUX2
DCLK/EXT_CLK
_______
RST
AUX7
MUTE
VDD
MCLK
AUX8
TWS/PLLOUT
AUX9
TSD
TBCK
I/O
I/O
I/O
I/O
O
I/O
O
I/O
O
I/O
O
I
Voltage supply, 5V.
I
Clock for programming to access internal registers.
Servo Forward or Control Pin.
Data for programming to access internal registers.
Servo Reverse or Control Pin.
I
Strobe for programming to access internal registers.
Servo LDON or Control Pin.
Dual-purpose pin DCLK is the MPEG decoder clock.
I
EXT_CLK is the external clock EXT_CLK is an input during bypass PLL mode.
I
Video reset. (active low)
Servo BRKM/Sense or Control Pin/VFD_DI.
Audio mute. (Not connected)
I
Voltage supply, 5V.
I
Audio master clock.
Servo Mute/Open or Control Pin/VFD_CLK.
I
Dual-purpose pin TWS is the transmit audio frame sync.
SPLL_OUT is the select PLL output.
Servo SQC0 or Control Pin.
I
Transmit audio data input.
I
Transmit audio bit clock.
Dual-purpose pin RWS is the receive audio frame sync.
23
24
25, 26
27, 28
29-31
32
33
34
35
36
PWS/SPLL1
RSTOUT
GND
NC
GND
VDD
RSD/SPLL0
AUX10
AUX11
AUX12
O
—
O
I/O
I/O
I/O
Pins SEL_PLL [1:0] select the PLL clock frequency for the DCLK output.
SEL_PLL1 SEL_PLL0 DCLK
I
I
I
I
I
0 0 Bypass PLL (input mode)
0 1 27MHz (output mode)
1 0 32.4MHz (output mode)
1 1 40.5MHz (output mode)
Reset output. (active-low)
Ground.
No connect.
Ground.
Voltage supply, 5V.
Dual-purpose pin. RSD is the receive audio data input.
SEL_PLL0 along with SEL_PLL1 select the PLL clock frequency for the DCLK output. See the
table for pin number 23.
Servo SQCK or Contrtol pin.
3880 IRQ or Interrupt Output or Control Pin.
CD C2PO or Interrupt Input or Control Pin.
-29-
Page 30
IC DESCRIPTION -3/4 (ES3889) -2/3
Pin No. Pin Name I/O Description
O
Dual-purpose pin. RBCK is the receive audio bit clock.
37
38
39
40
41
PBCK/SER_IN
AUX13
AUX14
AUX15
AGND
I/O
I/O
I/O
SER_IN is the serial input DSC mode.
I
I
0 – Parallel DSC mode.
1 – Serial DSC mode.
Serial Interrupt/CD-Mute or Control Pin.
Servo SCOR (SOS1) or Interrupt Input or Control Pin.
Interrupt Input or Control Pin.
Audio Analog Ground.
42
43
44
45, 46
47, 48
49
50
51
52
53
54
55
56, 57
58
59, 60
61
62, 63
VREFM
VREFP
AVDD
AOR+, AOR–
AOL–, AOL+
MIC2
MIC1
AGND
VREF
VCM
RSET
COMP
VGND
CDAC
VVDD
YDAC
VGND
ADC Common Mode Reference (CMR) buffer output. CMR is approximately 2.25V. Bypass to
I
analog ground with 47µF electrolytic in parallel with 0.1µF.
I
DAC and ADC maximum reference. Bypass to VCMR with 10µF in parallel with 0.1µF.
I
Analog VCC, 5V.
O
Right channel output.
O
Left channel output.
I
Microphone input1. (Not connected)
I
Microphone input2.
I
Audio Analog Ground.
Internal resistor divider generates Common Mode Reference (CMR) voltage. Bypass to analog
I
ground with 0.1µF.
I
DAC and ADC minimum reference. Bypass to VCMR with 10µF in parallel with 0.1µF.
I
Full scale DAC current adjustment.
I
Compensation Pin.
I
Video Analog Ground.
O
Modulated chrominance output. (Not connected)
I
Video VCC, 5V.
O
Y Iuminance data bus for screen video port. (Not connected)
I
Video Analog Ground.
64
65
66
67
68
69
70
71
72
73
74
75
76
77
VDAC
PLLCAP
VDD
AUX6
AUX5
AUX4
AUX3
XOUT
GND
VDD
XIN
GND
NC
GND
O
I/O
I/O
I/O
I/O
O
—
Composite video output.
I
Audio CAP.
I
Voltage supply, 5V.
Servo XLAT or Control Pin / VFD_DO.
Servo Data or Control Pin.
Servo CCW/Close or Control Pin. (Not connected)
Servo CW/Limit or Control Pin.
Crystal output.
I
Ground.
I
Voltage supply, 5V.
I
27MHz crystal input.
I
Ground.
No connect.
I
Ground.
-30-
Page 31
IC DESCRIPTION -3/4 (ES3889) -3/3
Pin No. Pin Name I/O Description
78
79
80
VDD
PCK
PCK2
I/O
I/O
I
Voltage supply, 5V.
13.5MHz pixel clock.
27MHz. (2 times pixel clock)
81
82
83
84
85
86-89
90
91
92
93
94
95
96
97
98
99
100
DSC_D1
HSYNC
DSC_D2
______________
VSYNC
DSC_D3
YUV[0-3]
VDD
GND
YUV4
DSC_D4
YUV5
DSC_D5
YUV6
DSC_D6
YUV7
DSC_D7
GND
I/O
O
I/O
O
I/O
I/O
I/O
I/O
I/O
Data for programming to access internal registers.
Horizontal sync. (active-low)
Data for programming to access internal registers.
Vertical sync. (active-low)
Data for programming to access internal registers.
I
YUV data bus for screen video port.
I
Voltage supply, 5V.
I
Ground.
I
YUV data bus for screen video port.
Data for programming to access internal registers.
I
YUV data bus for screen video port.
Data for programming to access internal registers.
I
YUV data bus for screen video port.
Data for programming to access internal registers.
I
YUV data bus for screen video port.
Data for programming to access internal registers.
I
Ground.
-31-
Page 32
IC DESCRIPTION -4/4 (HT27C020) -1/1
Pin No. Pin Name I/O/C/P Description
1
VPP
P
Program voltage supply.
2,3
4
5-12
13-15
16
17-21
22
23
24
25
26,27
28,29
30
31
32
A16, A15
A12
A7-A0
DQ0-DQ2
VSS
DQ3-DQ7
CE
A10
OE
A11
A9,A8
A13,A14
A17
PGM
VCC
I
I
I
I/O
I
I/O
C
I
C
I
I
I
I
C
I
Address input.
Address input.
Address input.
Data input/output.
Negative power supply.
Data input/output.
Chip enable.
Address input.
Output enable
Address input.
Address input.
Address input.
Address input.
Program voltage supply.
Positive power supply.
-32-
Page 33
MECHANICAL EXPLODED VIEW -1/1
30
7
8
10
24
22
B
9
C
18
19
23
21
20
25
26
27
13
11
15
17
31
4
6
5
3
2
12
1
3
32
16
29
29
33
A
28
28
14
34
D
-33-
Page 34
CD MECHANISM P AR TS LIST -1/1
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
X MC1001 8B-ZG2-611-010 PWB,T-T 28M a . . . .
X MC1001 8B-ZG2-606-010 PWB,T-T . b c d e
O MC1002 87-A91-982-010 MOT,M25E-4 2054 a b c d e
O MC1003 84-ZG1-267-010 PULLEY,LOAD MO 8 a b c d e
O MC1004 8B-ZG2-256-010 BELT,SQ1-97.7-U a b c d e
O MC1005 8B-ZG2-241-110 GEAR,WORM a b c d e
O MC1006 8B-ZG2-236-010 PULLEY,WORM a b c d e
O MC1007 8B-ZG2-003-010 TRAY,2K GRA a b . . .
O MC1007 8B-ZG2-003-110 TRAY,2K GRA . . c d e
O MC1008 84-ZG1-269-010 GEAR,MAIN TT 4 a b c d e
O MC1009 84-ZG1-288-010 LEVER,TT NAT a b c d e
O MC1010 8B-ZG2-004-010 TURN TABLE,2K GRA a b c d e
O MC1011 83-ZG3-604-010 RING,MAG 2 a b c d e
O MC1012 87-045-305-010 MOT,RF-500TB a b c d e
O MC1013 8B-ZG2-226-010 GEAR,TRAY a b c d e
O MC1014 8B-ZG2-260-010 HLDR,MECHA RSCM a b c d e
O MC1015 M8-CZK-390-070 KSM-213RSCM a b c d e
O MC1016 8B-ZG2-201-210 CHAS,MECHA a b c d e
O MC1017 84-ZG1-291-210 HLDR,MAGNET 4 NAT a b c d e
O MC1018 84-ZG1-271-010 PULLEY,RELAY 8 a b c d e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
O MC1019 84-ZG1-209-010 BELT,SQ1.8-117.7 a b c d e
O MC1020 84-ZG1-206-110 GEAR RELAY a b . d .
O MC1020 84-ZG1-274-010 GEAR,RELAY 8 . . c . e
O MC1021 83-ZG3-213-010 LVR,SW a b c d e
O MC1022 8B-ZG2-221-010 GEAR,MAIN CAM a b c d e
O MC1023 8B-ZG2-231-010 GEAR,TRAY RELAY a b c d e
O MC1024 84-ZG1-211-010 SPR-E,CAM S a b c d e
O MC1025 8B-ZG2-216-110 LEVER,CAM a b c d e
O MC1026 81-ZG1-255-110 PLATE,MAGNET MK2 a b c d e
O MC1027 8B-ZG2-211-010 PLATE,MECHA CAM a . c . .
O MC1027 8B-ZG2-211-110 PLATE,MECHA CAM . b . d e
O MC1028 8A-ZG1-204-010 CUSHION,CD880BRN a b c d e
X MC1029 8A-ZG1-202-010 CUSHION,CD880 a b c d e
O MC1030 8B-ZG2-251-010 SPR-P,PULLEY 2K a b . d .
O MC1031 8A-ZG1-214-110 SH, 25-40-0.5 PC a b c d e
X MC1032 A8-CZA-692-070 CZA-6 CMVSD5NC a . . . .
X MC1032 A8-CZA-691-070 CZA-6 CMVSD5NC1 . b . . .
X MC1032 A8-CZA-690-030 CZA-6 CMVSD5NM . . c . .
X MC1032 A8-CZA-693-070 CZA-6 CMVSD5NC2 . . . d .
X MC1032 A8-CZA-694-070 CZA-6 CMVSD5NM1 . . . . e
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
X MC1032a 8C-ZA6-620-010 PWB,CZA-6 CMV 2M FINEMOST a . . . .
X MC1032a 8C-ZA6-601-010 PWB,CZA-6 CMV 2M . b c . e
X MC1032a 8C-ZA6-630-010 PWB,CZA-6 CMV 2M B/F . . . d .
X MC1033 8B-ZG2-262-010 SHLD-PLATE,VCD 2 a b . d .
X MC1033 8B-ZG2-270-110 SHLD-PLATE,VCD 2M . . c . e
O MC1034 8A-ZGD-609-010 FF-CABLE,16P 1.0 270MM . b c d e
O MC1A 8B-ZG2-261-010 S-SCREW,DAMPER RSCM a b c d e
O MC1B 87-B10-331-010 VF+3-6 BLK a b c d e
O MC1C 87-067-584-010 BVT2+3-6 W/0 SL0T a b . d .
O MC1D 87-067-579-010 BVT2+3-8 W/O SLOT a b c d e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-34-
Page 35
COLOR NAME TABLE -1/1
Basic color symbol Color Basic color symbol Color Basic color symbol Color
B Black C Cream D Orange
G Green H Gray L Blue
LT Transparent Blue N Gold P Pink
R Red S Silver ST Titan Silver
T Brown V Violet W White
WT Transparent White Y Yellow YT Transparent Yellow
LM Metallic Blue LL Light Blue GT Transparent Green
LD Dark Blue DT Transparent Orange GM Metallic Green
YM Metallic Yellow DM Metallic Orange PT Transparent Pink
LA Aqua Blue GL Light Green HT Transparent Gray
HM Metallic Gray NH Champagne Gold M Wood Pattern
-35-
Page 36
OTHERS P ARTS LIST -1/1
! = ! SAFTY PARTS
C = Components marked
UNIT-NAME ! C REF-NO PARTS-NO PARTS-NAME SUFFIX&MODEL
BZG-2 BZG-2 BZG-2 BZG-2 BZG-2
MVSD5GNC MVSD5GNC1 MVSD5GNM MVSD5GNC2 MVSD5GNM1
X 87-063-173-010 CLOTH, N9295B BLK 30-10-0.35 a b c d e
X 84-426-949-010 LBL,SERIAL NO . . c . e
All components used on this model at the production line are shown in this service manual.
However, please note that not all components will be available as spare parts for after-sales service.
Components marked S and O are designated as spare parts for service and will be stocked at the spare parts centers.
Components marked X and R are not designated as spare parts for after sales service, and will not be stocked at the spare parts centers.
-36-
Page 37
921338
2-11, IKENOHATA 1-CHOME, TAITO-KU, T OKYO 110-8710, JAPAN TEL:03 (3827) 3111
Loading...