AEG EIW60002X User Manual

Instruction manual

REFRESHMENT CENTER

Built-in appliance

welcome to the world of Electrolux electrolux 3

Welcome to the world of Electrolux

Thank you for choosing a first class product from Electrolux, which hopefully
will provide you with lots of pleasure in the future.

The Electrolux ambition is to offer a wide variety of quality products that
make your life more comfortable.

You find some examples on the cover in this manual.
Please take a few minutes to study this manual so that you can take

advantage of the benefits of your new machine.
We promise that it will provide a superior User Experience delivering Ease-of-

Mind.
Good luck!

4 electrolux contents

Contents

Electrical safety ........................5

Electrical safety .................... 5

Installation........................... 6

Use .................................... 6

Cleaning..............................6

Environment......................... 6

Appliance description.................. 7

Units .................................. 7

Identification plate (Fig. 2)...........8

Technical Characteristics .............8

Installation .............................. 9

Installation steps: .................. 9

Package content ....................9

1 Unit positioning ................. 9

2 Water mains and siphon

connection ..................... 11

3 Install filter cartridge ........ 12

4 Startup ......................... 13

Using the Refreshment Center . 14

Front touch panel................. 14

Dispensing.......................... 14

Alarms.................................. 15

Maintenance........................... 18

CO2 bottle replacement ......... 18

Sanification + filtration cartridge18

Environment care..................... 21

Electric diagram ...................... 22

Hydraulic diagram .................... 23

Guarantee/Customer Service....... 24

The following symbols are utilized with this manual:

Safety information

Environment

Disposal directives

electrical safety electrolux 5

Electrical safety

This appliance conforms to the following safety electrical European
Directives:

This manual has been written for your own safety and of others.

Please read manual carefully before installation and/or use. Please

keep this instruction manual in a safe and dry place. This appliance

conforms to the following safety electrical European Directives:

73/23/CEE, 89/336/CEE, 92/31/CEE, 98/37/CEE.

Please keep this instruction manual in a safe and dry place.

This manual has been written
for you own safety and of
others. Please read manual
carefully before installation
and/or use.

Electrical safety

The unit needs to be
connected to a power supply
line that conforms fully to
local safety regulations
regarding electrical safety. If
in doubt please have your
electrical system checked by
a specialized electrician.

Please do not try to repair
the unit as you might cause
additional damage. Contact
your nearest Technical
assistance center.

Remove power supply cord
before proceeding with repair
operations.

If the power supply cord
appears to be damaged,
please ask for a replacement
cord.

6 electrolux appliance description

Installation

Please handle appliance with
care to prevent damaging of
the refrigeration circuit.

Avoid prolonged exposure of
the appliance to direct
sunlight.

To guarantee maximum
stability and safety, it’s
necessary to install the built­in appliance only in AEG, REX
and Electrolux sized cabinets.

Please follow instruction
carefully before, during and
after installation.

If the appliance is
transported in vertical
position, please place in
horizontal (normal) position
and wait 1 hour for the oil to
return to the compressor
before turning unit on.

Do not bend water supply and
discharge tube excessively
during installation.

Do not allow children to use
the appliance if not under
the supervision of adults.

Cleaning

Do not use metallic tools to
clean the appliance as it may
cause damage.

Environment

Please follow local disposal
regulations.

Use

Do not use the Refreshment
Unit for something else other
than dispense cold,
carbonated, ambient water
and ice. An incorrect use of
the appliance may harm
people or cause damage to
the appliance itself.

Appliance description

The Refreshment Unit is a domestic
appliance designed to dispense
purified cold, carbonated and
ambient temperature water and ice­cubes.
The appliance has 2 outlet from
which the following products can be

2 31 4 5 6

7 8 9

Units

The unit is mainly composed of:

1 St. Steel front display
2 Filter head
3 Water dispense nozzle

appliance description electrolux 7

dispensed:

- Ambient temperature water

- Cold water

- Carbonated water

- Ice-Cubes.

4 Glass touch command panel
5 Ice dispense outlet

6 Drip tray
7 CO2 bottle
8 H2O pressure regulator with

gauge

9 Filter cartridge

13121110

10 Power supply socket
11 Main on/off switch
12 H2O inlet
13 H2O drainage

8 electrolux identification plate

Identification plate (Fig. 2)

Should you need to contact a
technical Assistance Center,
make sure you have the serial
number handy for
identification. The serial
number is on the

MODEL PNC

TYPE

Refreshment Center

230 V ~ 50 Hz

MAX 190 W

MADE IN ITALY

xxx xxx xxxXXXXXXXX

SERIAL No.:

xxxxxxxx

identification plate in the side
of the appliance. Extract from
cabinet to identify plate.

Fig. 2

Technical Characteristics

Power Supply 230-240 V

Frequency 50 Hz

Power consumption 190 W

Cold water dispense capacity 2lt @ 1 l/min.

Carbonated water dispense capacity 2lt @ 1 l/min

Dispense temperature < 13°C

Water mains pressure (water inlet) > 2.0 bar

CO2 pressure 2.5-4 bar

Filtration 0.5 micron

Filter capacity 3000 litres

Ambient temperature conditions range 18°C-32°C

Unit dimensions L x P x H (mm) 594x530xH378

Weight 38 Kg

Refrigerant gas R134a – 60gr

installation electrolux 9

Installation

Warning

In order for the unit to work
correctly, the Technical
Characteristics specification
chart on page 6 needs to be
observed.

Installation steps:

1. Refreshment unit assembly inside
kitchen

2. Water mains connection

3. Water filter connection

4. Electric power supply

Package content

Open package and immediately check
for any transport damages. During
installation please handle with care.

Inside you should find the following
material:

A. Refreshment Unit
B. 2 Sliding Rails
C. Mounting base plate
D. 6 spacers 2x1mm, 2x2mm, 2x3mm

A

B

C

D

Power supply cord

H

O inlet flexible hose and

2

discharge tube

Filtration Cartridge

Sanitazing cartridge and liquid

1 Unit positioning

Please install unit as far away
as possible from heat sources

Please install unit higher than
the water main in the kitchen

Please don’t install the
Refreshment Center farther
than 4m from the water main
or please use another water
inlet and discharge tubes.

10 electrolux installation

- The dimension requirements for
the kitchen cabinet are:

1. Height(1):360mm

2. Depth(2):580mm

3. Width(3):564mm

5

0

4

5

0

3

2

1

Please be sure that the
frontal edge of the mounting
base plate and the frontal
edge of the piece of
furniture are coincident

- Mount the 2 sliding rails onto the
base plate.

Fig. 5

- Install the mounting base plate
inside the kitchen cabinet after
checking after checking
dimension requirements as shown
in Fig. 4. If necessary, please use
the spacers to fix the mounting
base plate to the cabinet.

Fig. 4

- Place the Refreshment Center on
the sliding rails.

Fig. 6

2 Water mains and siphon connection

Warning

Connect only to potable
water mains.
All water mains connections
should be carried out by a
certified plummer.

Warning

Water mains pressure can be
set through the H

O pressure

2

regulator placed near the

bottle. Pressure should

CO

2

be no higher than 3.0 bars
and no lower than 2.0 bars.

installation electrolux 11

Complete following operations (Fig.

8):

- Connect the flexible hose to the

O inlet (Fig.8) on the unit.

H

2

Connect water mains to flexible
hose.

- Connect discharge tube to
discharge barbed connection on
unit and to sink siphon (Fig.8).

Warning

Please do not install
Refreshment Center farther
than 4 meters or please get
longer inlet and discharge
tubes.

Fig. 8

Water discharge 3/4”

Water Inlet 3/4”

12 electrolux installation

3 Install filter cartridge

Lift locking spring placed under drip
tray (Fig. 9).

Pull unit from cabinet.
On the left side of the unit please find
the filter cartridge (Fig. 10).

Remove filter plastic cap and install
filter in filter head as shown on filter
instruction booklet (Fig. 11).

Open the on/off valve
placed near the filter cartridge.

Check for water leaks and make sure
the CO
CO

bottle is tightly fixed on the

2

pressure regulator.

2

Open the pressure regulator valve and
set pressure to 3 bars on gauge.
Pressure can be increased to 4 bars to
increase carbonation levels (Fig. 13).

Filter cartridge

Fig. 12

Fig. 9

Fig. 10

Fig. 11

Fig. 13

4 Startup

Warning

Before plugging unit to
power supply, please check
for correct power supply
voltage and frequency as
stated on Technical
Characteristic chart (see
page 9).

Connect unit to 230V through
supplied cord.

Electric supply circuit should conform
to local laws and regulations.

Warning

The supplier declines any
responsibility should any
safety rule not be respected
during installation.

Turn unit on through main on/off
switch on side of unit. The unit will
undergo an initialization process
which will take approx. 4 minutes.

installation electrolux 13

Fig. 15

After 4 minutes
turn unit on
through on/off b

utton on touch
control panel to activate all
functions.

At this point please wait approx.
3 hours before the unit reaches final
working temperatures in order to
dispense cold water, carbonated
water and ice-cubes. Ambient water
is readily immediately.

Fig. 14

This preliminary operation will be
carried out every time the unit is
turned off and on through the main
on/off switch inside the cabinet.
During this process the touch control
panel is inactive.

14 electrolux installation

Using the Refreshment Center

Front touch panel

1 2 3 4 5 6 7 8

1 Empty CO2 bottle led
2 On/Off switch
3 Water ambient temperature

button

5 Cold water button
6 Ice dispense button
7 Light button On/Off
8 Exhaust filter led

4 Carbonated water button

Dispensing

After turning appliance on through
on/off switch on touch screen, wait
for cooling time before dispensing.

Place a glass under dispense nozzle.
Press button corresponding to desired
selection. Release until desired
dispense water level or number of ice­cubes is reached. Please do not
dispense more than 1 liter of
carbonated water continuously since
you might experience CO
from nozzle. Should that occur,
please wait
1 minute and restart dispensing
carbonated water.

exhaust

2

Dispensing is signaled by the
corresponding led.

In order to dispense in bottles or
carafes, please extract dispense
nozzle by grabbing on sides of nozzle
and pulling forward.

Alarms

Led indications Message

Led blinks slowly

Filter is about to exhaust. 2900 liters have
been dispensed.
Please change filter as described in the
following chapters.

alarms electrolux 15

Led is lit

Led is lit

Filter is about to exhaust. 2980 liters have
been dispensed. Please change filter as
described in the following chapters.

All dispense buttons disabled.
3000 liters have been reached.
Please change filter as described in the
following chapters.

16 electrolux alarms

Carbonated
water led blinks
slowly

CO2 bottle led on

Leds

- ambient water

- ice
blink
simultaneously

Ice forming bin blocked.
Turn unit on/off through main on/off switch on side of
unit.

Leds

- ambient water

- cold water

- carbonated
water

blink
simultaneously
Leds

- carbonated
water

- ambient water

- cold water

- ice

blink
simultaneously

Volumetric turbine malfunctioning. Dispense functions
enabled but during dispense operation the 3 leds will blink.

Main water tank fill time-out. Please check water supply to
unit. Make sure filter shut off valve to be open.
To reset status turn unit on/off through main switch inside
cabinet.

Carbonated water is disabled.
Time-out protection on carbonation pump
activated.
To reset status please turn unit off/on on
touch control panel.

Carbonated water is disabled.

bottle is empty.

CO

2

Replace CO

bottle to restore Carbonated

2

water dispensing.
Please change CO
following chapters.

bottle as described in the

2

All leds on
simultaneously

maintenance electrolux 17

All dispense buttons disabled. 2 main causes:

1. Water present on base of unit. Possible leak.

2. Water level too high inside water tank. Water discharge
blocked.

For the first case switch off and dry the base of the unit.
For the second case turn unit on/off through main switch
inside cabinet.

Should alarms repeat
themselves after all restart
attempts, please call service
assistance.

18 electrolux maintenance

Maintenance

Before any maintenance or
cleaning procedure, please
switch off the appliance and
disconnect it from main by
unplugging the power plug.

1. Pull appliance from cabinet
(Fig. 16).

2. Grab the CO

bottle and extract it

2

from it’s locking clip.

3. By holding the bottle fixed, turn
the pressure regulator clockwise to
remove from the bottle (fig. 17).

4. Place new bottle under the
regulator and screw counter
clockwise till fully tightened.

5. Lock bottle in place and close
cabinet.

bottle replacement

CO

2

When the CO

led turns on, it’s

2

necessary to replace the CO
as described below:

Fig. 16

bottle

2

Fig. 17

Sanification + filtration cartridge

When the exhaust filter led turns on, it is time to replace the filter cartridge:

1. Turn unit off through main on/off

switch (Fig. 14).

2. Pull unit from cabinet (Fig. 6) and look

for valve near the CO

3. Close valve (Fig. 18).

4. Position under the water dispense

nozzle a container and dispense water
to empty filter cartridge and tubes.

cylinder.

2

Fig. 18

5. Remove the filter cartridge form its

housing by rotating counter clock-wise
about a quarter turn (Fig. 19). This will
free the filter. Pull downward and
remove it.

6. Fill sanitizing cartridge with Neutral

Detergent. Insert the sanitizing
cartridge on the filter head by rotating
clock-wise a quarter turn.

7. Open valve on the base of the unit

(Fig. 12).

8. Dry any water from the base, that

could have leaked during this
operation.

9. Position under the water dispense

nozzle a container or large cup.

10. Turn main switch. Wait approx.

5 seconds and press “light” button until
sanitizing mode is entered. This will be
shown in the display as a moving red
led through all the buttons. During this
operation, the inside of the unit will be
sanitized. After this initial cleaning
cycle, the unit will dispense
automatically some cold and ambient
water.

maintenance electrolux 19

Fig. 19

20 electrolux maintenance

11. Shut off unit from main on/off switch.

12. Close valve on base of unit (Fig. 18).

13. Position under the water dispense

nozzle a container and dispense water
to empty sanitize cartridge and tubes.

14. Install new filter cartridge as shown on

filter cartridge instructions (Fig. 20).
Open valve near the filter cartridge.
Turn main on/off switch on and push
appliance into cabinet.

15. Wait 4 minutes before turning unit on

through the touch button.

16. Dispense 1 liter of cold, ambient and

carbonated water to fully rinse any
sanitizing residue.

The following is a troubleshooting
section for malfunctions that are not
in the Alarms list above:

SYMPTOM PROBABLE CAUSE RESOLUTION

Water is not dispensed

The unit has been on for
over 3 hours, but no cold
water nor ice is available

Low carbonation level

No power supply Check electric

Water mains inlet
solenoid valve
failure
Probabile
refrigerant gas leak
Motor fan failure Call technical

Compressor failure Call technical

Brand new
appliance

Low CO2 pressure Increase CO2

Fig. 20

power supply
Call technical
assistance

Call technical
assistance

assistance

assistance
Utilize for few days
and check
carbonation

pressure by rotating
knob on CO2
pressure regulator
clock-wise

enviroment care electrolux 21

Air inside
carbonator

Cold water occasionally
sprays CO2 gas

Non return valve on
carbonator dirty

Warning

All repairs should be carried
out by authorized
technicians.

Environment care

The symbol on the product or
on its packaging indicates that this
product may not be treated as
household waste. Instead it shall be
handed over to the applicable
collection point for the recycling of
electrical and electronic equipment.
By ensuring this product is disposed
of correctly, you will help prevent

Dispense few liter
of carbonated water
and check
carbonation
Call technical
assistance

potential negative consequences for
the environment and human health,
which could otherwise be caused by
inappropriate waste handling of this
product. For more detailed
information about recycling of this
product, please contact your local
city office, your household waste
disposal service or the shop where
you purchased the product.

22 electrolux electric diagram

Electric diagram

EV1 Ambient water electric valve
EV2 Carbonated water electric valve
EV3 Cold water electric valve
EV4 Water main electric valve
EV5 Hot gas cycle electric valve
EV6 Ice bin water charge electric valve
SW1 Microswitch work position
SW2 Microswitch discharge position
SW3 CO2 pressure switch
SW4 Main on-off double pole switch
L1-L8 Command panel leds
L9 Light bar
P1 Carbonator pump
P2 Tank discharge pump
C1 Compressor

PR1 Ice sensor probe
PR2 Dryer filter sensor probe
PR3 Flooding probe
PR4 Minimum water tank level probe
PR5 MAX Carbonator level probe
PR6 MIN Carbonator level probe
M1 Auger motor
M2 Water ice bin motor
M3 Motor fan
F1 Flow meter
T1-T6 Command panel buttons
TR1 AC-DC adapter

Hydraulic diagram

hydraulic diagram electrolux 23

A Water inlet
B Water drainage
C Ice cube tray
D Cold water
E Carbonated/Sparkling water
F Ambient water
G Water dispense nozzle
1 Cooling coil
2 No return valve
3 Pressure reducer
4 Valve
5 CO2 Cylinder
6 Turbine
7 Electric valve
8 Pump

9 Cartridge filter
10 Carbonator device

24 electrolux guarantee/customer service

Guarantee/Customer Service

Standard guarantee conditions

We, Electrolux, undertake that if
within 12 months of the date of the
purchase this Electrolux appliance or
any part thereof is proved to be
defective by reason only of faulty
workmanship or materials, we will,
at our option repair or replace the
same FREE OF CHARGE for labour,
materials or carriage on condition
that:

- The appliance has been correctly
installed and used only on the
electricity supply stated on the
rating plate.

- The appliance has been used for
normal domestic purposes only,
and in accordance with the
manufacturer’s instructions.

- The appliance has not been
serviced, maintained, repaired,
taken apart or tampered with by
any person not authorised by us.

- Electrolux Service Force Centre
must undertake all service work
under this guarantee.

- Any appliance or defective part
replaced shall become the
Company’s property.

- This guarantee is in addition to
your statutory and other legal
rights.

Exclusions

- Damage or calls resulting from
transportation, improper use or
neglect, the replacement of any
light bulbs or removable parts of
glass or plastic.

- Costs incurred for calls to put
right an appliance which is
improperly installed or calls to

- Appliances found to be in use

- Products of Electrolux

Service and Spare Parts

In the event of your appliance
requiring service, or if you wish to
purchase spare parts, please contact
your local Service Force Centre by
telephoning 0870 5 929 929
Your telephone call will be
automatically routed to the Service
Force Centre covering your postcode
area.
For the address of your local Service
Force Centre and further information
about Service Force, please visit the
website at www.serviceforce.co.uk
Before calling out an engineer,
please ensure you have read the
details under the heading “Something
not working” When you contact the
Service Force Centre you will need to
give the following details:

1. Your name, address and

2. Your telephone number.

3.

4. The model and Serial number of

5. The purchase date. Please note a

appliances outside the United
Kingdom.

within a commercial
environment, plus those which
are subject to rental agreements.

manufacturer that are not
marketed by Electrolux.

postcode.

Clear concise details of the fault.

the appliance (found on the
rating plate).

valid purchase receipt or
guarantee documentation is
required for in guarantee service
calls.

guarantee/customer service electrolux 25

Customer Care

For general enquiries concerning your
Electrolux appliance, or for further
information on Electrolux products
please contact our Customer Care
Department by letter or telephone at
the address below or visit our
website at www.electrolux.co.uk

Customer Care Department
Electrolux Major Appliances
Addington Way
Luton
Bedfordshire, LU4 9QQ
Tel: [phone] (*)
(*) Calls may be recorded for training

purposes

26 electrolux guarantee/customer service

European Guarantee

This appliance is guaranteed by
Electrolux in each of the countries
listed at the back of this user manual,
for the period specified in the
appliance guarantee or otherwise by
law. If you move from one of these
countries to another of the countries
listed below the appliance guarantee
will move with you subject to the
following qualifications:

- The appliance guarantee starts

from the date you first purchased
the appliance which will be
evidenced by production of a valid
purchase document issued by the
seller of the appliance.

- The appliance guarantee is for the

same period and to the same
extent for labour and parts as
exists in your new country of
residence for this particular
model or range of appliances.

- The appliance guarantee is

personal to the original purchaser
of the appliance and cannot be
transferred to another user.

- The appliance is installed and

used in accordance with
instructions issued by Electrolux
and is only used within the home,
i.e. is not used for commercial
purposes.

- The appliance is installed in

accordance with all relevant
regulations in force within your

new country of residence.
The provisions of this European
Guarantee do not affect any of the
rights granted to you by law.

www.electrolux.com

guarantee/customer service electrolux 27

Þ

Albania [phone] Rr. Pjeter Bogdani Nr. 7 Tirane
Belgique/België/
Belgien

Èeská republika [phone] Budìjovická 3, Praha 4, 140 21

Danmark [phone] Sjællandsgade 2, 7000 Fredericia
Deutschland [phone] Muggenhofer Str. 135, 90429 Nürnberg
Eesti [phone] Mustamäe tee 24, 10621 Tallinn

España [phone]

France www.electrolux.fr

Great Britain [phone]

Hellas [phone] Limnou Str., 54627 Thessaloniki
Hrvatska [phone] Slavonska avenija 3, 10000 Zagreb
Ireland [phone] Long Mile Road Dublin 12

Italia [phone]

Latvija [phone] Kr. Barona iela 130/2, LV-1012, Riga
Lietuva [phone] Verkių 29, LT_09108 Vilnius
Luxembourg [phone] Rue de Bitbourg, 7, L-1273 Hamm

Magyarország [phone]

Nederland [phone]

Norge [phone] Risløkkvn. 2 , 0508 Oslo
Österreich [phone] Herziggasse 9, 1230 Wien

Polska [phone] ul. Kolejowa 5/7, Warsaw

Portugal [phone]

Romania [phone] Str. Garii Progresului 2, S4, 040671 RO

Schweiz/Suisse/
Svizzera

Slovenija [phone]

Slovensko [phone]

Suomi [phone] Konepajanranta 4, 28100 Pori

Sverige [phone]

Türkiye [phone] Tarlabaþý caddesi no : 35 TaksimIstanbul

Pоссия [phone]

 

[phone] Bergensesteenweg 719, 1502 Lembeek

Carretera M-300, Km. 29,900
Alcalá de Henares Madrid

Addington Way, Luton, Bedfordshire
LU4 9QQ

C.so Lino Zanussi, 26 -
33080 Porcia (PN)

H-1142 Budapest XIV,
Erzsébet királyné útja 87

Vennootsweg 1, 2404 CG - Alphen aan den
Rijn

Quinta da Fonte - Edificio Gonçalves
Zarco - Q 352774 - 518 Paço de Arcos

[phone] Industriestrasse 10, CH-5506 Mägenwil

Electrolux Ljubljana, d.o.o.Tržaška 132, 1000
Ljubljana
Electrolux Slovakia s.r.o., Electrolux Domáce
spotrebièe SK, Seberíniho 1,
821 03 Bratislava

Electrolux Service, S:t Göransgatan 143,S­105 45 Stockholm

129090 Мосва, Олимпийский проспект, 16,
БЦ, „Олимпик“

28 electrolux guarantee/customer service

guarantee/customer service electrolux 29

30 electrolux guarantee/customer service

guarantee/customer service electrolux 31