AEG EDB715GR User Manual

Model EDB715

33

IMPORTANT SAFETY INFORMATION

These warnings are provided in the interests of your safety. Ensure that you understand them all
before installing or using the cooker. Your safety is of paramount importance. If you are unsure about
any of the meanings of these warnings contact the Customer Care Department. The address is on the
back page of this book.

INSTALLATION

The cooker must be installed according to the
instructions supplied. The installation work must be
undertaken by a qualified electrician/competent
person.
The cooker must be installed in an adequately
ventilated room.
NOTE: It is imperative that the appliance is left in
the base to protect both the appliance and the floor.
This cooker is heavy and care must be taken when
moving it. Do not try to move the cooker by pulling
the door handles.
Warning: Do Not attempt to lift this appliance by the
handles.
All packaging, both inside and outside the cooker
must be removed before the cooker is used.
It is dangerous to alter the specifications or modify

the cooker in any way.
After installation please dispose of the packaging
with due regard for safety and the environment.
Your local authority can arrange this.

CHILD SAFETY

Do not allow young children to play with any part of

the packaging.

This cooker is designed to be operated by adults.

Young children must not be allowed to tamper with

the controls or play near or with the cooker.

During use the cooker becomes hot, care should be

taken to avoid touching heating elements inside the

oven.

The cooker and accessible parts especially around

the grill area become hot when the cooker is in use.

Keep children away until it has cooled.

DURING USE

This cooker has been designed for domestic use to

cook edible foodstuffs only, and must not be used

for any other purpose.

Take great care when heating fats and oils as they

will ignite if they become too hot.

Never place plastic or any other material which may

melt in or on the oven.

Do not stand too close to the oven or grill while in

use as warm air will exhaust from the grill cavity and

the vents on the front frame of the cooker.

Do not leave the grill pan handle in position when

grilling and ensure oven gloves are used to remove

and replace the handle, as it will become hot.

Always use oven gloves to remove and place food

in the oven.

Ensure that all vents are left unobstructed to ensure

ventilation of the oven cavity.

Never line any part of the cooker with aluminium
foil.
Stand clear when opening the drop down oven
doors. Support the doors using the handles until
fully open.

Never leave the cooker unattended when the
oven door is open.

Do not place sealed cans or aerosols inside the
oven. They may explode if they are heated.
Ensure that all control knobs are in the OFF position
when not in use.
Do not stand on the cooker or on the open oven
doors.
Do not hang towels, dishcloths or clothes from the
cooker or its handles. They are a safety hazard.

CLEANING AND MAINTENANCE

The cooker is heavy and care must be taken when
moving it.

For Hygiene and safety reasons this cooker
should be kept clean at all times. A build-up of
fats or other foodstuffs could result in a fire
especially in the grill pan.

Do not leave cookware containing foodstuffs, e.g.
fat or oil in the cooker in case it is inadvertently
switched on.
Always allow the cooling fan to cool the cooker
down before switching off at the wall prior to
carrying out any cleaning / maintenance work.
Only clean this cooker in accordance with the
instructions given in this book.

SERVICE

Repairs should not be carried out by inexperienced
persons as this may cause injury or serious
malfunction. This cooker should be serviced by an
authorised Service Engineer and only genuine
approved spare parts should be used. Details of
servicing and repair arrangements are supplied on
page 37

of this book.

AT THE END OF THE COOKERS LIFE

When the time comes to dispose of your cooker
please contact your local Council Authority. They
can arrange to dispose of the cooker in a safe and
controlled manner.

The number will be in the telephone book.

Please read this

instruction book carefully

before use and retain

for future reference.

CONTENTS

FOR THE USER

Important Safety Information 2
Description of the Cooker 5

Getting to Know Your Oven 6
The Cooling Fan for the Controls 7
Control Panel Indicator Neons 7
Before Using The Cooker 8
Rating Plate 8
When First Switching On 8
Condensation and Steam 8
Cookware 9
The Trivet 9
Grill and Oven Furniture 10

The Electronic Timer 11
The Dual Grill 15

Uses of the Grill 15
How To Use the Dual Grill 15
Things To Note 15
The Grill Pan and Handle 16
Hints and Tips 16
Grilling Chart 18

The Top Oven 19
Uses of the Top Oven 19
How To Use the Top Oven 19
Things To Note 19
To Fit the Oven Shelf 19
Hints and Tips 20
Oven Cooking Chart 21

Care and Cleaning 28
Cleaning Materials 28
Cleaning the Outside of the Cooker 28
Cleaning the Outer and Inner Door
Glass Panels 29
Cleaning Inside the Ovens 30
To Remove the Wirework Runners 31
Cleaning the Shelves, Wirework Runners
and Oven Furniture 31
Care of Stayclean Surfaces 31
The Oven Cleaning Cycle 32
Things to Note 32
Hints and Tips 32
Replacing an Oven Light Bulb 33

If Something Doesn't Work 34
Guarantee Conditions 36
Service and Spare Parts 37
Customer Service Centres 38

Please read the whole instruction book before
using the cooker. To help you the following
symbols will be found in the text.

Safety Instructions

Step by Step Instructions

The Fan Oven 22
Uses of the Fan Oven 22
How To Use the Fan Oven 22
Things to Note 22
To Fit the Fan Oven Shelves 23
Hints and Tips 23

Fan Oven Cooking Chart 24
Roasting Chart 25

Defrost Feature 26

Uses of Defrost Feature 26
How To Defrost 26
Things to Note 26
Hints and Tips 26

Hints and Tips

3

FOR THE INSTALLER

Technical Details 40
Things You Need to Know 41
Warnings 41
Things to Note 41

Getting Things Ready 42
Choice of Electrical Connection 42
Preparing Cabinet for Fitting Oven 43
Recommended Cabinet Dimensions 43
How to Finish Unpacking 44
Tools Required 44

Making the Electrical Connections 45
Preparing Cable 45
To Remove Cover of Mains Terminal 45
Connecting to the Mains Terminal 46
Checking Electrical Connections 47
Connecting to a Hob or Cooker Point 47

.

4

DESCRIPTION OF THE COOKER

Built in electric double oven

WARNING: THIS COOKER MUST BE EARTHED

Electronic
Timer

Dual
Grill

Top Oven

Main Fan
Oven

Your built in cooker comprises of a conventional oven and dual grill in the top compartment. The top
oven is convenient and economical for mid-week use because of its size.
The main fan oven is the larger of the two ovens. It is particularly suitable for cooking larger quantities
of food.
The main fan oven can be automatically controlled by the electronic timer.

5

GETTING TO KNOW YOUR OVEN

The Control Panel

Electronic Timer

Dual Grill Control

Top Oven
Temperature Control

Main Fan Oven
Temperature Control

Grill Indicator Neon

Top Oven
Indicator Neon

Main Fan Oven
Indicator Neon

6

THE COOLING FAN FOR THE CONTROLS

Your cooker has a cooling fan fitted behind the
controls to prevent them from overheating.
The cooling fan will come on immediately when
the grill is switched on and after a short time
when either of the ovens are in use.
The cooling fan may turn on and off when the
cooker is in use. This is quite normal.

The cooling fan may run on after the ovens or
grill are switched off for a period of time to cool
the cooker down. It may continue to switch on
and off until the cooker is cool.

Always allow the cooling fan to cool
the cooker down before switching off
at the wall prior to carrying out any
cleaning or maintenance work.

NOTE

The action of the cooling fan will depend on
how long the ovens or grill have been used and
at what temperature. It may not switch in at all
at lower temperature settings nor run on where
the grill or oven has only been used for a short
time.

CONTROL PANEL INDICATOR
NEONS

These lights indicate whether the ovens or grill
are switched on. In the case of the ovens, the
Top and Main Fan oven neons also indicate
when the set temperature has been reached.
They will turn on and off during use to show
that the temperature is being maintained.

The grill neon does not turn on and off when
the grill is in use.

The Main Fan oven neon does not operate with
the Defrost setting.

If the neons do not operate as the instructions
indicate the controls have been incorrectly set.
Return all controls to zero and re-set following
the instructions for the required setting.

7

BEFORE USING THE COOKER

WHEN FIRST SWITCHING ON

The timer must be set to manual operation
before the Main Fan oven can be operated.
This must be done whenever the cooker is
switched off at the wall or when there has been
a power failure. For instructions on how to set
the timer see page 11.

If the Main Fan oven indicator neon does not
glow when the oven controls are switched on, it
is most likely that the timer is set for automatic
cooking.
The Top Oven and the Dual Grill are not
controlled by the electronic timer.

RATING PLATE

Record the model, product and serial numbers
of your cooker on the back page of this
instruction book for future reference. You can
find these numbers on the rating plate on the
front frame of the cooker upon opening the top
oven door.
The cooker must be protected by a suitably
rated fuse or circuit breaker. The rating of the
cooker is given on the rating plate.

Do not remove the rating plate from the
cooker as this may invalidate the guarantee.

PREPARING TO USE YOUR
COOKER

Wipe over the base of the ovens with a soft
cloth and hot soapy water and wash the grill
and oven furniture before use.
We suggest that you run the oven elements for
10 - 15 minutes at 220°C to burn off any
residue from their surfaces.
The procedure should be repeated with the grill
for approximately 5 - 10 minutes.
During this period an odour may be emitted, it is
therefore advisable to open a window for
ventilation.

CONDENSATION AND STEAM

When food is heated it produces steam in the
same way as a boiling kettle does. The ovens
are vented to allow some of this steam to
escape. However, always stand back from the
cooker when opening the oven doors to allow
any build up of steam or heat to release. If the
steam comes into contact with a cool surface
on the outside of the cooker, e.g. a trim, it will
condense and produce water droplets. This is
quite normal and is not caused by a fault on the
cooker.
To prevent discolouration occurring, regularly
wipe away condensation and any soilage from
the cooker surfaces.

8

COOKWARE

Baking trays, dishes etc., should not be placed
directly against the grid covering the fan at the
back of the oven.

Do not use baking trays larger than 30cm x
35cm (12" x 14") as they will restrict the
circulation of heat and may affect performance.
Advice on the effect of different materials and
finishes of bakeware is given in 'Hints and Tips'
in the appropriate oven section.

THE TRIVET

When roasting we recommend that you use the
trivet in the meat tin. Fat and meat juices will
drain into the meat tin below and can be used
to make gravy. The trivet also prevents
splashes of fat from soiling the oven interior.

Note. The meat tin should not be placed on a
heated hotplate as this may cause the enamel
to crack.

9

GRILL AND OVEN FURNITURE

The following items of oven furniture have been
supplied with the cooker.

1 grill pan

1 grill pan handle

1 grill pan grid

1 trivet

1 meat tin

2 shelves for Fan
oven cooking

1 shelf for grilling and
top oven
cooking

10

Scuffing of the Stayclean sides and
back panel by the oven furniture pack
may occur during transit.
These marks will disappear after the
oven has been used for the first time.

THE ELECTRONIC TIMER

The electronic timer can indicate the time of
day, operate as a minute minder and
automatically time the Main Fan oven.

A Auto Symbol ( automatic cooking )

Bell Symbol ( minute minder )
Cookpot Symbol ( manual cooking )

Please note that this is a 24 hour clock, for
example 2pm is shown as 14.00.

If the oven is switched off at the wall or there is
loss of power the clock will stop and you will not
be able to use the cooker. When you first switch
the electricity supply on, the timer display will
flash.

Auto

Cookpot Symbol

Symbol

Bell
Symbol

TO SET THE TIME OF DAY

1.Press buttons and together.
Release the buttons.

2. Within 5 seconds press the button until
the time of day shows in the display.

The cookpot symbol ( ) will be showing.

THE MINUTE MINDER

1.Press and release the button.

2. Within 5 seconds press the button until
the display shows the time you want.

Our diagram shows the timer set to 5 minutes.
After a few seconds the time of day will show in
the display.

When you are using the minute minder you can
check the number of minutes remaining by
pressing the button.
At the end of the timed period an alarm will
sound. Switch off the alarm by pressing the
button.
After a few seconds the time of day shows in
the display.

11

AUTOMATIC TIMER CONTROL

The automatic timer can be used with the Main
Fan oven only.

TO SWITCH THE MAIN FAN

OVEN ON AND OFF

1. Ensure the clock is showing the correct time
of day.

2.Place food in the Main Fan oven.

3. Set the length of time you want the food to
cook for by pressing and releasing the
button and then pressing the button until
the correct cooking time is displayed.
This must be completed within 5 seconds of
pressing the button.

The maximum cooking time is 23 hours 59
minutes.

The Cookpot and Auto symbols will show in the
display. Our diagram shows the cooking time
set for 2 hours 30 minutes.

After a few seconds the time of day shows in
the display.

AUTOMATICALLY

4.To set the time you want the food to be
cooked by, press and release the button.
This will show you the earliest possible stop
time.

If this is different to the time you want the food
to be cooked by, press the button within 5
seconds until the correct stop time shows in the
display. Our diagram shows the food is to be
cooked by 18.00 hours (6pm).
After a few seconds the time of day shows in
the display and the Cookpot symbol goes out.

The 'Stop' time must not be more than 23 hours
59 minutes from the time of day. For example, if
the time of day is 09.00 hours (9.00am) the
latest 'Stop' time will be 08.59 (8.59am) the next
day.

12

5.Turn the Main Fan oven control to the correct
temperature.

The clock will work out what time the oven will
switch itself on and will switch the oven off at
the end. An audible signal will sound when
cooking is complete. To cancel the sound, see
below.

RETURNING THE COOKER TO
MANUAL OR TO CANCEL AN
AUTOMATIC PROGRAMME

Once automatic cooking is complete an alarm
will sound and the Auto symbol will flash to
remind you that the oven needs to be set for
manual operation.

1.To do this press buttons and together.

After a few seconds the timer will show the
time of day. The cookpot will show in the
display and the oven will switch on again.

2.Turn off the oven control.

TO SET THE TIMER TO
SWITCH OFF ONLY

This is useful if you want to begin cooking
immediately but have the Main Fan oven switch
off whilst you are out.

1. Ensure the clock is showing the correct time

of day.

2.Place food in the oven.

3. Set the length of time you want the food to

cook for. Press and release the button
and then within 5 seconds press the
button until the correct cook time is showing.

Our diagram shows the timer set for 2 hours 30
minutes.

After a few seconds the time of day shows in
the display.

4.Turn the oven temperature control to the

required setting. The oven indicator neon will

come on.
If you want to check the time the oven will
switch off simply press the button and the
'Stop' time will be displayed.

13

At the end of the cooktime the oven will switch
off, the alarm will sound and the auto symbol
will flash.

5.To cancel and return to manual operation

press buttons and together.

6.Turn off the oven temperature control.

14

THE DUAL GRILL

WARNING - Accessible parts become
hot when the grill is in use. Keep
children away.

USES OF THE GRILL

The grill is situated in the Top oven
compartment.
The grill is a dual circuit grill which means that
the full area of the grill or the centre section
only can be used. Use the full grill for cooking
larger quantities of food. Use the centre section
for economy purposes when cooking smaller
quantities.

DUAL GRILL

HOW TO USE THE DUAL

1.Open the Grill / Top Oven door.

2. Turn the grill control clockwise for full grill or

anticlockwise for the centre section only.

3.Ensure the Top Oven control is in the Off

position ' 0 '.

The grill door must be left open when
grilling.

GRILL

THINGS TO NOTE

The cooling fan for the controls will operate

as soon as the grill control is turned. For

more information on the operation of the

cooling fan turn to page 7.

The outer section of the grill element may

appear to glow brighter than the inner

section. This is quite normal.

The grill indicator neon will glow until the

desired power level has been reached. It will

turn ON and OFF periodically during cooking

showing the temperature is being maintained.

We recommend you use the grill pan on the

shelf in positions 3 or 5 only.

If you use the grill pan in position 3 the shelf

must be withdrawn before the pan can be

located or removed.

TOP OVEN

5
4
3
2
1

Ensure the grill pan is properly
located.

15

THE GRILL PAN AND HANDLE

The grill pan has a removable handle.
To insert the handle, press the button on the

handle with the thumb and pivot the handle
slightly upwards inserting the lip into widest part
of the bracket. Move the handle towards the
left, lower into position and release the button.

Ensure the handle is positively located.

To remove the handle, press the button on the
handle with the thumb and pivot the handle
slightly upwards and towards the right to
remove from the bracket.

Protect your hands when removing the
grill pan handle.

Always remove the grill pan handle
during grilling.

To correctly locate the grill pan on the shelf,
ensure that the cut out on the underside of the
handle bracket locates over the front bar of the
shelf.

The Grill Pan must not be located in
the shelf runners

To check the progress of the food being grilled,
the grill pan should be withdrawn on the shelf to
attend to food during cooking.

Ensure that you support the grill pan
when it is withdrawn.

HINTS AND TIPS

Most foods should be placed on the grilling

grid in the grill pan. This allows maximum

circulation of air by raising the food out of fats

and juices.

Adjust the grid and grill pan runner position to

allow for different thicknesses of food.

Position the food close to the element for

faster cooking and further away for more

gentle cooking.

16