Page 1
820 41 73 69
CHEST FREEZER
INSTRUCTION BOOK
ECM 1957 ECM 2257 ECM 3057 ECM 3857
GB
Page 2
2
Prior to Installation
Check the appliance for transport damage. Under no
circumstances should a damaged appliance be installed. In
the event of damage please contact your retailer.
Installation
This appliance is heavy. Care should be taken when
moving it.
It is dangerous to alter the specifications or attempt
to modify this product in any way.
Ensure that the appliance does not stand on the
electrical supply cable. If the supply cable is
damaged, it must be replaced by a cable available
from your local Service Force Centre.
Any electrical work required to install this appliance
should be carried out by a qualified electrician or
competent person.
Parts which heat up should not be exposed.
Whenever possible, the back of the appliance
should be close to a wall, but leaving the required
distance for ventilation, as stated in the installation
instructions.
The appliance should be left for 2 hours after
installation before it is turned on, in order to allow
the refrigerant to settle.
Child Safety
Do not allow children to tamper with the controls or
play with the product.
There is a risk of suffocation! Keep packaging
material away from children!
During Use
This appliance is designed for domestic use only,
specifically for the storage of edible foodstuffs. It is
not intended for commercial or industrial use.
Containers with flammable gases or liquids can
leak at low temperatures. Do not store any
containers of flammable materials, such as spray
cans, fire extinguisher refill cartridges etc. in the
freezer.
Frozen food should not be refrozen once it has
thawed out.
Do not place carbonated or fizzy drinks in the
freezer compartment
Ice lollies can cause 'frost/freezer burns' if
consumed straight from the freezer
Do not remove items from the freezer
compartment if your hands are damp/wet, as
this could cause skin abrasions or frost/freezer
burns.
Bottles and cans must not be placed in the
freezer compartment they can burst when the
contents freeze.
Manufacturers' recommended storage times
should be adhered to. Refer to relevant
instructions.
Maintenance and Cleaning
Before cleaning, always switch off the appliance
and disconnect from the electrical supply.
When unplugging always pull the plug from the
mains socket, do not pull on the cable.
Servicing
This product should be serviced by an
authorised engineer and only genuine spare
parts should be used.
Under no circumstances should you attempt to
repair the appliance yourself. Repairs carried
out by inexperienced persons may cause injury
or serious malfunctioning. Contact your local
Service Force Centre.
Disposing of the Appliance
When disposing of your appliance use an
authorised disposal site. Check with your local
Council or Environmental Health Office to see if
there are facilities in your area to recycle the
appliance.
Make the appliance unusable by removing the
plug and ensuring that any locks or catches are
removed, to prevent young children being
trapped inside.
Important Safety Information
These warnings are provided in the interests of your safety. Ensure that you understand them
all before installing or using this appliance. Your safety is of paramount importance. If you are
unsure about any of the meanings or these warnings contact the Customer Care Department.
Page 3
3
Instructions for the installer
Technical Specifications 16
Installation
Positioning 16
Electrical Connections 17
Contents
Instructions for the User
Important Safety Information 2
Description of the Appliance 4
Control Panel 4
Digital temperature display 5
Initial start up 5
Temperature warning 5
Temperature adjustment 5
Freezing 6
Freezing Fresh Food 6
Frozen Food Storage 6
Thawing 7
Baskets 8
Hints and Tips 9
Normal Operating Sounds 9
Food Storage 9
Energy Saving Advice 9
In the Event of a Power Failure 9
Defrosting 10
Maintenance and Cleaning 11
Internal Cleaning 11
External Cleaning 11
When the Appliance is not in Use 11
To change the Light Bulb 11
Something not Working 12
Service and Spare Parts 13
Customer Care 12
Guarantee Conditions 14
Page 4
4
Description of the Appliance
Control Panel
A - Frozen food storage
B - Freezer calendar (recommended storage times for frozen foods)
C - Compartment for freezing fresh foods
D - Dividing wall
E - Defrost water drain
1. Temperature controller knob and mains on pilot light
(green)
2. FROSTMATIC button for the super-freeze function
and FROSTMATIC pilot light (yellow)
3. WARNING OFF button (to switch off the warning
buzzer) and warning pilot light (red)
4. Digital temperature display
Page 5
5
INITIAL START UP
Stick the plug into the socket, then turn the temperature
controller away from the "off" zone, this way the green lamp
showing the energy supply will be on.
- If the temperature adjuster is in the "off" zone and the
plug of the device has been connected to the socket,
the device will not work, neither will the display, and the
control lamps will not be on.
- The device runs in SUPER FROST mode for 5 hours,
the yellow SUPER FROST indicator lamp will be on.
- If you want to stop the SUPER FROST mode, keep
pressing the SUPER FROST button for 2 seconds. At
this time, instead of the "SP" sign, the display will show
the inner temperature, the yellow lamp indicating
SUPER FROST will go out.
All models have a digital temperature display integrated in
the handle of the lid. In normal operation, it shows the
temperature of the frozen products in centigrade (°C).
There are however the following exceptions:
- During fast freezing FROSTMASTIC function SP is
shown.
- If there is a failure of the temperature display, a small
square can be seen in the bottom right or top right
corner. (Also see section "Something Not Working").
The temperature display indicates the temperature of
the frozen food and therefore changes relatively
slowly, if you put fresh goods in for example. If you leave the
lid open for a long time, the temperature warning may
respond, the temperature display may however remain
unchanged. In this case there is no malfunction. Press the
WARNING OFF button, to switch the warning buzzer off. The
red warning light goes out automatically after a short time.
After power-supply failure or when starting up the device
for the first time, the device switches to SUPER FROST
mode for 5 hours, if the temperature in the freezer is too
high. An "SP" sign will appear on the display. If you want
to switch it off before the 5 hours is over, keep pressing
the SUPER FROST button for 2 seconds.
TEMPERATURE WARNING
If the temperature in the freezer is too high, the warning
buzzer sounds and the red warning light flashes.
The warning buzzer and red warning light are triggered:
- if the storage temperature required has not yet been
reached when starting the freezer; if the storage
temperature is no longer maintained (malfunction);
- after inserting fresh foodstuffs in a greater quantity
than permitted by the freezing capacity (see section
on "Freezing";
- if the lid is left open too long.
You can switch off the warning buzzer with the
WARNING OFF button. The red warning light
continues to flash until it is sufficiently cold again
inside the freezer.
The warning buzzer and red warning light are not
triggered:
- if the power supply is interrupted;
- if the electronic thermostat is faulty.
Digital temperature display
Page 6
6
TEMPERATURE ADJUSTMENT
A coin has to be used to turn the temperature control
knob. This makes it more difficult to inadvertently adjust
the temperature (child protection).
Position "off" means: device switched off
Position "1" means: warmest internal temperature
Position "4" means: coldest internal temperature
Recommended position: "2 " or "3"
Turn the temperature control knob to position "2" or
"3" using a coin.
The internal temperature will be affected by the
following:
- ambient temperature
- quantity of food stored;
- frequent or prolonged opening of the lid.
Therefore regularly monitor that the optimal storage
temperature of -18 °C or colder is maintained, either
using the thermometer or the digital temperature
display depending on which model you have.
If necessary, adjust the temperature setting, until the
thermometer or the digital temperature display
shows -18 °C or colder.
From a food safety point of view, -18 °C is
considered a sufficiently cold storage temperature.
FREEZING
Tip: To freeze fresh foods use the small
freezing compartment on the right of the
dividing partition (also see section on
"Interior accessories( dividing partition").
This enables you to separate already frozen
foods from fresh foods. Always make sure
already frozen goods cannot defrost by
coming into contact with fresh products. If
the freezing compartment is too small you can freeze part
of the products in the large storage section on the left of
the dividing partition.
AAtttteennttiioonn!!
Before freezing food the temperature in the freezer
must be -18 °C or colder.
Please observe indicated freezing capacity on the
rating plate. The freezing capacity represents the
maximum amount of fresh goods that can be frozen
within 24 hours. If you freeze goods on several days,
one after the other, freeze amounts equal to 2/3 to 3/4
of the capacity indicated on the rating plate.
Thawed foods which have not been processed
further (cooked into meals) must not under any
circumstances be frozen a second time.
In order to utilize the maximum freezing capacity,
keep pressing the SUPER FROST button for 2
seconds 24 hours before the freezing, in the case
of smaller quantity, 4-6 hours before the freezing.
At this point, the yellow warning light lights up, the
"SP" sign will appear on the display.
The FROSTMATIC button need not be pressed
for freezing of small quantities of up to 3 kg.
All foods must be packed air tight prior to
freezing, so that they do not dry out or lose their
flavour, and so that no flavour contamination of
other frozen goods occurs.
CCaauuttiioonn!!
Do not touch the frozen foods with wet hands.
Hands can freeze to the goods.
Place the packed food products into the freezer.
Ensure they come into contact with the side walls.
Unfrozen goods may not come into contact with
already frozen goods, otherwise the frozen goods
may start to thaw.
If more products are to be frozen, keep fast freeze
FROSTMATIC function switched on, if not switch
it off about 24 hours after placing the food in the
freezer. For smaller quantities, it can be switched
off sooner. To do this, press the FROSTMATIC
button again. The yellow FROSTMATIC display
goes out.
If you do not switch off the "SUPER FROST"
mode by pressing the "SUPER FROST" button,
the device will automatically switch back to
normal operation after 48 hours (the yellow
warning lamp goes out, the temperature of the
inner space will appear on the display instead of
the "SP" sign). After this, the device will cool the
inside compartment according to the value
specified by the temperature controller.
TTiippss::
The following are suited for the packaging of frozen
goods:
- freezer bags and polyethylene wraps;
- special cans for frozen goods;
- extra-thick aluminium foil
The following are suitable for closing bags and foil:
plastic clips, rubber bands or adhesive tape.
Before closing press out the air from the bags and
foil, as air make the frozen products dry out more
easily and wastes space.
Make flat packages, because these freeze more
quickly.
Do not fill cans for frozen goods to the brim with
liquid or paste-like goods, because liquids expand
during freezing.
NNoottee ffoorr iinnssppeeccttiioonn aauutthhoorriittiieess::
Batch plans for the determination of freezing
performance or warm-up time can be requested
directly from the manufacturer.
Page 7
7
It is important that fresh food placed in the freezer is frozen
quickly and that the food already in the freezer is heated as
little as possible.
Frozen Food Storage
When first starting the freezer or if the freezer has been out
of use for some time, we advise you to run your appliance
for at least 2 hours before storing frozen food.
Do not exceed the storage period indicated by the
manufacturer.
Do not open the lid frequently or leave it open longer than
is necessary.
Important
Do not put carbonated liquids in the freezer.
Ice lollies, if consumed immediately after removal from
the freezer can cause a low temperature skin burn.
Do not remove items from the freezer if your hands are
damp/wet, as this could cause skin abrasions or
frost/freezer burns.
In the event of a power cut, do not open the lid. The food
in the freezer will not be affected if the power cut is short
and the freezer is full. Should the food begin to thaw it
must be consumed quickly and must not be re-frozen.
(See Hints and Tips)
Thawing
Frozen food, prior to being used, can be thawed in the
fridge or at room temperature, depending on the time
available. Small food items may even be cooked from
frozen, in this case cooking will take longer.
Any frozen food which is allowed to thaw accidentally
should either be eaten as soon as possible, or thrown away.
Alternatively, if the food is uncooked and has not been
completely defrosted it can be cooked and then refrozen.
Defrosted cooked food must never be
refrozen.
Page 8
8
Baskets
The baskets are designed for the storage of food which has
already been frozen. The handles can be placed in two
positions, as shown.
The baskets can either be placed inside the freezer or hung
on the edge of the casing.
The following spare parts can be ordered from your local
Service force Centre. Please note that 2 handles must be
ordered for each basket.
A Basket 291263000/1
B Basket 291263001/5
Handle 291340004/6 (2 required).
The following illustrations show how many baskets can be
placed in various freezer models.
The number above each illustration shows the width of the
freezer in millimetres.
Page 9
9
Normal Operating Sounds
You may hear faint gurgling or bubbling sounds when the
refrigerant is pumped through the coils or tubing.
When the compressor is on, the refrigerant is being
pumped round and you will hear a whirring sound or
pulsating noise from the compressor.
A thermostat controls the compressor and you will hear
a faint 'click' when the thermostat cuts in and out.
Food Storage
To obtain the best performance from your freezer:
Do not store warm food or evaporating liquid.
Avoid buying frozen food if you cannot store it straight
away. The use of an insulated container is advisable.
When you arrive home, place the frozen food in the
freezer immediately.
Do not push food together too much, try to allow air to
circulate around each item.
Do not store food uncovered.
Ensure that food placed in the freezer is dated and
labelled and used in date order to ensure that food is
consumed at its best.
Lean food keeps better and longer than fatty food, salt
reduces the storage time.
Wrap the food in polythene or aluminium freezing bags
or foil so that they adhere to the food and provide an
airtight seal.
Packaging which is swollen or has traces of refrozen
water droplets on the pack could indicate that the
product has not been kept at a suitable temperature and
that it may have lost its original quality. Partially thawed
food must not be refrozen, it must be consumed within
24 hours. Never exceed the storage times indicated by
the manufacturer.
Energy Saving Advice
Do not install the appliance close to sources of heat,
such as a boiler or radiator.
Locate the appliance in a cool well ventilated room and
make sure that the opening of the appliance is not
obstructed.
Avoid unnecessary frosting in the cabinet by packing all
foodstuffs into airtight packages before placing them in
the freezer.
Food which is to be frozen (when cool) should be placed
in the fridge before being transferred to the freezer.
Try to avoid keeping the lid open for long periods or
opening the lid too frequently as warm air will enter the
cabinet and cause the compressor to switch on
unnecessarily often.
Ensure there are no obstructions preventing the lid from
closing properly.
In the Event of a Power Failure
If there is a power failure during the storage of frozen
foods, keep the lid closed. If the temperature within your
freezer should rise, do not refreeze the food without
checking its condition. The following guidelines should
assist you:
Ice Cream: Once thawed should be
discarded.
Fruits & Vegetables: If soft should be cooked and
used up.
Breads & Cakes: Can be refrozen without danger.
Shellfish: Should be refrigerated and used
up quickly.
Cooked Dishes: i.e. casseroles should be
refrigerated and used up.
Large Pieces Can be refrozen providing there
of Meat: are still ice crystals remaining
within them.
Small Joints: Should be cooked and can then
be refrozen as cooked dishes.
Chicken: Should also be cooked and
refrozen as a fresh dish.
Hints & Tips
Page 10
10
Defrosting
The freezer compartment will become progressively
covered with frost. This should be removed with the
special plastic scraper provided, whenever the
thickness of frost exceeds ¼".
During this operation it is not necessary to switch off the
power supply or to remove the foodstuffs.
However, when the ice becomes very thick on the inner
liner, complete defrosting should be carried out and it is
advisable to perform this operation when the appliance is
empty.
To carry out complete defrosting:
1. Disconnect the appliance from the electrical supply.
2. Remove any stored food, wrap in several layers of
newspaper and store in a cool place.
3. Leave the lid open.
4. Remove the plug from the drip water drain.
5. To accelerate the defrosting process place a bowl of hot
(not boiling) water inside the freezer and close the lid.
6. The defrost water can be collected in a bowl, as
shown.
7. When defrosting is completed, dry the interior
thoroughly and replace the plug on the drip water drain.
8. Turn the thermostat control back to a medium setting
and leave to run for at least 2 hours.
9. Replace the previously removed food.
Important
A temperature rise of the frozen food packs during
defrosting may shorten their safe storage life.
Never use sharp metal tools to scrape off frost from the
evaporator as this could damage the appliance beyond
repair.
Page 11
11
Before any maintenance or cleaning is carried
out you must DISCONNECT the appliance from
the electricity supply
Internal Cleaning
Clean the inside and accessories with warm water and
bicarbonate of soda (5ml to 0.5 litre of water).
Rinse and dry thoroughly.
NEVER use detergents, abrasive powders,
highly perfumed cleaning products or wax
polishes to clean the interior as these will
damage the surface and leave a strong odour.
To Change the Light Bulb
Before changing the bulb, isolate the appliance from the
electricity supply.
Unscrew the bulb, and replace it with a new bulb (max. 15W).
Then reconnect the electricity supply. Extra bulbs are
available from your local Zanussi Service Force Centre.
External Cleaning
Wash the outer cabinet with warm soapy water.
When the Appliance is not in Use
When the appliance is not in use for long periods - In order
to switch off the device, turn the temperature controller
button anti-clockwise, till it hits the "off" zone. At this point,
the green lamp will go out - after disconnect from the
electricity supply, empty all foods and clean the appliance,
leaving the lid open to prevent unpleasant smells.
Maintenance and Cleaning
Page 12
12
Something not Working
If the appliance is not working correctly, please carry out the following checks before contacting your local Electrolux
Service Force Centre
SYMPTOM
No power to the appliance
The temperature in the freezer is too high
The freezer lid will not open
Excessive frost and ice has built up
Noise
A small square can be seen on the bottom right or top
right corner of the display, but the device is functioning.
SOLUTION
Check there is power at the socket
Check there is not a power cut by checking the
household lights.
Check the mains fuse has not blown.
Check the temperature regulator knob.
("off" zone switched off state)
Check the thermostat is turned to the correct setting
relevant to ambient conditions.
Check the temperature regulator knob.
("off" zone switched off state)
Check the ambient temperature is within the
appliance's operating limits of 10° 32°C.
Has the lid just been opened? If so leave for a few
minutes to allow the air pressure to equalise.
Adjust the thermostat to give correct temperature
control. See 'Temperature Control'.
Large quantities of food have recently been placed in
the cabinet/and or the lid is frequently opened.
Check that air ventilation is not obstructed.Ensure the
lid has not been left open.
Check that nothing is preventing the lid from closing.
Is the lid gasket intact and clean?
Has advised periodic defrosting been carried out.
Refer to 'Normal Operating Sounds'
Call the service, sensor failure.
If after all these checks your appliance still does not operate
correctly, contact your local Electrolux Service Force
Centre.
Please note that it will be necessary to provide proof of
purchase for any in-guarantee service calls.
In-guarantee customers should ensure that the above
checks have been made, as the engineer will make a
charge if the fault is not a mechanical or electrical
breakdown.
Page 13
13
Service and Spare Parts
In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact you local Electrolux
Service Force Centre by telephoning:
0870 5 929929
Your telephone call will be automatically routed to the Service Force Centre covering your post code area. For
the address of your local Service Force Centre and further information about Service Force please visit the
website at www.serviceforce.co.uk.
Customer Care Department
For general enquiries concerning your Electrolux appliance or for further information on Electrolux products, you are
invited to contact our Customer Care Department by letter or telephone at the address below or visit the website at
www.electrolux.co.uk:
Customer Care Department
Electrolux
55-77 High Street
Slough
Berkshire
SL1 1DZ
Tel: 08705 950 950*
* calls to this number may be recorded for training purposes
Page 14
14
Guarantee Conditions
We, Electrolux undertake that if within 12 months of the date of the purchase this Electrolux appliance or any part thereof
is proved to be defective by reason only of faulty workmanship or materials, the company will, at our option repair or
replace the same FREE OF CHARGE for labour, materials or carriage on condition that:
The appliance has been correctly installed and used only on the electrical supply stated on the rating plate.
The appliance has been used for normal domestic purposes only, and in accordance with the manufacturer's
instructions.
The appliance has not been serviced, maintained, repaired, taken apart or tampered with by any person not authorised
by us.
All service work under this guarantee must be undertaken by a Electrolux Service Force Centre.
Any appliance or defective part replaced shall become the Company's property.
Home visits are made between 8.30am and 5.30pm Monday to Friday. Visits may be available outside these hours in
which case a premium will be charged.
EXCLUSIONS
This Guarantee does not cover:
Damage or calls resulting from transportation, improper use or neglect, the replacement of any light bulbs or removable
parts of glass or plastic.
Costs incurred for calls to put right an appliance improperly installed or calls to appliances outside the United
Kingdom.
Appliances found to be in use within a commercial environment, plus those which are the subject of rental agreements.
Products of Electrolux manufacture which are not marked by Electrolux.
This guarantee is in addition to your statutory and legal rights.
ELECTROLUX EUROPEAN GUARANTEE
If you should move to another country within Europe then your guarantee moves with you to your new home subject to
the following qualifications:
The guarantee starts from the date you first purchased your product.
The guarantee is for the same period and to the same extent for labour and parts as exists in the new country of use
for this brand or range of products.
This guarantee relates to you and cannot be transferred to another user.
Your new home is within the European Community (EC) or European Free Trade Area
The product is installed and used in accordance with our instructions and is only used domestically, i.e. a normal
household.
The product is installed taking into account regulations in your new country.
Before you move please contact your nearest Customer Care Centre, list below, to give them details of your new home.
They will then ensure that the local Service Organisation is aware of your move and able to look after you and your
appliances.
France Senlis +33 (0)3 44 62 22 22
Germany Nurenberg +49 (0)911 323 2600
Italy Pordenone +39 (0)1678 47053
Sweden Stockholm +46 (0)20 78 77 55
UK Slough +44 (0)1753 219 898
Page 15
15
Positioning
Place the freezer horizontally on a firm surface, resting
on all four wheels. Use a wooden block or similar object
to compensate for any bumps/holes in the floor's
surface.
The room should be dry and adequately ventilated.
If the room temperature exceeds 32°C, or falls below
freezing point, the freezer will not function as it should.
Do not place the freezer close to sources of heat,
radiators, chimneys, etc. and do not place the freezer in
direct sunlight.
If the freezer has been handled standing on end, it
should be allowed to stand in the normal position for
about 12 hours before switching it on.
Ensure that the appliance is installed where it is easily
accessible for the engineer in the event of a breakdown.
Technical Specifications
Installation
Model ECM 1957 ECM 2257 ECM 3057 ECM 3857
Volume (gross) litres
Volume (net) litres
Height without/with roller cm
Width cm
Depth cm
Weight kg
Energy consumpt./24h kWh
Freezing capacity kg/24h
Hold-over time hours
Rated power W
189
184
87,6/88,3
93,5
66,5
49
0,53
23
43
75
221
216
87,6/88,3
105
66,5
52
0,58
24
46
80
299
292
87,6/88,3
132,5
66,5
59
0,69
28
49
120
378
368
87,6/88,3
160
66,5
68
0,80
29
55
140
Page 16
Printed by Xerox Hungary Ltd.
© Electrolux Household Appliances Limited 2000
Any electrical work required to install this
appliance should be carried out by a qualified
electrician or competent person.
This appliance must be earthed.
The manufacturer declines any liability should these
safety measures not be observed.
Electrical Requirements
Before switching on, make sure the electricity supply
voltage is the same as that indicated on the appliance rating
plate.
The appliance is supplied with a 13amp plug fitted. In the
event of having to change the fuse in the plug supplied, a
13amp ASTA approved (BS1362) fuse must be
used.Should the plug need to be replaced for any reason.
The wires in the mains lead are coloured in accordance with
the following code:
Green and Yellow: Earth
Blue: Neutral
Brown: Live
The wire coloured green and yellow must be connected to
the terminal marked with the letter "E" or by the earth
symbol or coloured green and yellow.
The wire coloured blue must be connected to the terminal
"N" or coloured black.
The wire coloured brown must be connected to the terminal
marked "L" or coloured red.
Upon completion there must be no cut, or stray strands of
wire present and the cord clamp must be secure over the
outer sheath.
Electrical Connection
2003. 04. 10.
GREEN & YELLOW
BLUE
P1041
E
13 A
N
L
BROWN
CORD CLAMP
Loading...