Page 1
MATERIAL SAFETY DATA SHEET
THE HALLSTAR COMPANY
Section 1 - Identification of Substance and Company
Product Name: MONOPLEX® DOS Product Code: 3143
Chemical Name: Di-2-ethylhexyl Sebacate
(1)
Supplier: The HallStar Company
120 S. Riverside Plaza Suite 1620 Health: 1
Chicago, IL 60606 PH: 877-427-4255 Flammability: 1
USA Reactivity: 0
Emergency Phone Numbers: The HallStar Company (708)594-5999
Chemical Name CAS#
Di-2-ethylhexyl Sebacate 122-62-3
HMIS
Gloves & Safety Glasses
CHEMTREC (transportation) (800)424-9300
Section 2 - Information on Ingredients
Section 3 - Hazard Identification
Appearance/Odor: Clear straw colored liquid; mild inoffensive odor.
Potential Health Effects
Skin Contact: Repeated or prolonged skin contact may cause skin irritation.
Eye Contact: May cause slight eye irritation of susceptible persons.
Ingestion: Substance may be harmful if swallowed. May irritate mouth, throat and stomach.
Inhalation: May cause dizziness.
Section 4 - First Aid Measures
Skin Contact: Wash affected skin with soap and water. Seek medical attention if symptoms persist.
Eye Contact: Flush eyes with large amounts of water for at least 15 minutes. If irritation persists,
consult a physician.
Ingestion: Seek medical advice.
Inhalation: Person should be moved to a fresh air environment.
Section 5 - Explosion and Fire-Fighting Measures
Extinguishing Media: CO2, Dry Chemical, Water Fog
Special Fire-Fighting Procedures: A MSHA/NIOSH approved self-contained breathing apparatus should be worn.
Unusual Fire and Explosion Hazards: Solid streams of water directed at burning liquid may cause frothing.
Page 1 of 3
Revision: 02/13
Page 2
Product Name: MONOPLEX® DOS
Section 6 - Accidental Release/Spill Procedures
Steps to be Taken in Case Material is Released or Spilled: Dike and contain the spill with inert material (i.e., sand,
earth, sawdust) and transfer liquid and solid diking material to separate containers for recovery or disposal. Wash
floor area with hot water solution. Remove contaminated clothing and wash before reuse. Wash affected skin areas
with soap and water. Keep spills out of all sewers and bodies of water.
Section 7 - Handling and Storage
Any use of this product in an elevated process should be evaluated to establish and maintain safe operating
procedures.
Containers should be kept tightly closed and stored in a dry well-ventilated place
Section 8 - Personal Protection
OSHA Permissible Exposure Limit (PEL): None established
Hand Protection: Impervious gloves
Respiratory Protection: None required for normal operation.
Eye Protection: Safety glasses
Engineering Measures: For normal operation, local exhaust ventilation should suffice. Direct exhaust when
material becomes heated and vapors are given off.
Other: Eyewash facility in vicinity.
Section 9 - Physical and Chemical Properties
Boiling Point: 450-480°F Specific Gravity@25°°°°C : 0.908-0.916
Flash Point (COC): >419°F Evaporation Rate: N/A
Vapor Density (Air=1): N/A Solubility in Water: Negligible
Vapor Pressure (150°°°°C): N/A pH: N/A
Appearance and Odor: Clear straw colored liquid; mild inoffensive odor.
Section 10 - Stability and Reactivity
Stability: This product is stable under normal conditions.
Conditions to Avoid: Unknown
Hazardous Polymerization: Will not occur under normal circumstances.
Section 11 - Toxicological Information
No information is available at this time.
Page 2 of 3
Revision: 02/13
Page 3
Product Name: MONOPLEX® DOS
Section 12 - Ecological Information
This product does not contain any ozone depleting compounds (ODC’s).
Section 13 - Disposal Considerations
Waste Disposal Methods: Material should be disposed of in accordance to current local and national regulations.
Contacting a waste disposal service is recommended.
Section 14 - Transport Information
Not classified as hazardous according to the Department of Transportation.
Section 15 - Regulatory Information
Toxic Substances Control Act (TSCA): This product is in compliance with the TSCA regulation of the United States.
Domestic Substance List (DSL): This product is listed on the DSL inventory of Canada.
European Inventory of Existing Chemical Substances (EINECS): This product is listed on the EINECS inventory of Europe.
Registration #: 204-558-8.
Australian Inventory of Chemical Substances (AICS): This product is listed on the AICS inventory of Australia.
Superfund Amendments and Reauthorization Act (SARA): This product has the following hazards as defined in Section
311/312 of 40 CFR Part 372:
Hazards
None
This product contains the following chemicals subject to the reporting requirements of Section 313 or Title III of SARA and 40
CFR Part 372:
Ingredients
None
California Proposition 65: This product contains the following substances known to the State of California to cause cancer, birth
defects, or other reproductive harm per the Safe Drinking Water and Toxic Enforcement Act of 1986:
Ingredients
None
Section 16 - Other Information
Prepared By: JPM
All information is presented in good faith using available information. The HallStar Company makes no representation of the accuracy or
completeness of the information. The user should consider this information as a supplement to other information that may be available. User
should also determine suitability of information in their situation to determine proper use and disposal, protection of persons and the
environment.
Revision Date:
Supersedes:
02/13
03/10
(1)
Affiliated companies include RTD*HallStar Company, HallStar Solutions Corp., Ester Solutions Company, Memphis Solutions Company and
Marine Magnesium & Minerals Company.
Page 3 of 3
Revision: 02/13
Loading...