www.ActiveForever.com
Table of Contents
Page
About the AZ-1 Portable Hand control 2
AZ-1 Features 2
Package Contents 3
Safety Information 4
Operator type and usage 5
Installation Instructions 5-7
Removing Instructions 7
Operation 7-8
Accessories 9
Maintenance and Service Instructions 9
100% Money Back Guarantee 9
Warranty 9
Safety Information 9
Warning 10
2
About the AZ-1 Portable Hand control
www.ActiveForever.com
When you travel away from your standard car with permanent hand controls you might
require a portable set of hand controls. For added convenience, If you are looking for a
portable hand control system to use when traveling abroad then the AZ-1 might be what you
are looking for. The AZ-1 portable hand control is made for use on automatic vehicles for
disabled drivers with a high amount of hand control and function. If you are able to use the
pedals on a vehicle then these portable hand controls are not recommended for use. It is
essential that the drivers have strong grip and finger function on both hands to operate the
AZ-1 portable hand control. If you are unable to operate or have limited function this portable
hand control is not for you!! The AZ-1 is for a portable application for periodic use. These
controls are not for regular everyday use.
AZ-1 Features
The AZ-1 is made to ease the lifestyle of the consumer. Some important features are as
follows.
Strong & Lightweight – material is Aerospace Alum. 6061 T-6
Adjustable Length – the length can be adjusted to suit each users needs
Collapsible Design – the controls are made to collapse for storage when
traveling.
Professional Grip - the handgrip is a professional grip that won’t heat up when
your car gets hot.
Easy Installation - the AZ-1 is easy to install and remove on most vehicles.
3
Package Contents
www.ActiveForever.com
Package contents will include the complete assembled portable hand control system. Note:
when portable hand control is shipped it is adjusted to it narrowest adjustment. It is essential
that you follow the assembly instructions that suit each individual driver. Contents are as
follows:
4
Safety Information
www.ActiveForever.com
WARNING Safety is of the utmost importance when installing and operating with
portable hand controls. If you are unsure about the installation or operating of the
vehicle with portable hand control DO NOT OPERATE THE VEHICLE.
AZ-1 Portable Hand Controls are only made for people with excellent hand function. If
you do not have strong hands DO NOT OPERATE THE VEHICLE with the AZ-1
portable hand controls.
The AZ-1 is only recommended to be used on vehicles with an emergency brake that
is accessible by hand. This is in the event that an emergency occurs and the AZ-1
fails and you must stop the vehicle with the vehicles emergency brake. Therefore
when renting or operating a vehicle, be sure to verify that the car has a hand pull
emergency brake. If the car does not have the hand pull emergency brake DO NOT
OPERATE THE VEHICLE with the AZ-1 portable hand controls.
Your local DMV (Department of Motor Vehicle) might require that you receive testing
to operate the portable hand controls. You must contact your local DMV to determine
if it is required to receive approval to drive with the AZ-1 portable hand control system.
In addition, you must have a valid drivers license to purchase and operate the AZ-1
portable hand controls.
When first using the AZ-1 portable hand control be sure to find a safe location to
operate the vehicle. As when you first learn to drive a car it is imperative that a
qualified member supervises the use of the hand control prior to your independent
use. It is recommended that you visit a qualified driver training class in your local area
to obtain a formal approval to use the AZ-1 portable hand control.
The adjustment of the AZ-1 is important for safe use. Each time you drive the vehicle
you must check the nuts, bolts, pins and finger screws to verify that they are tightened
correctly. If they are loose or appear to be insecure DO NOT OPERATE THE
VEHICLE with the AZ-1 portable hand controls.
Always wear your seat belt when operating the AZ-1 portable hand controls.
Always follow the local, state and federal laws when operating the AZ-1 portable hand
controls.
5
Operator type and usage
www.ActiveForever.com
The AZ-1 is only produced for disabled drivers with strong hand function and good upper
mobility. And the AZ-1 is for portable use. It is not recommended to use the AZ-1 for daily
use while operating your everyday vehicle.
Installation Instructions
When installing the AZ-1 portable hand control take great care.
1. First verify that the vehicle you are driving has the following:
a. Automatic Transmission
b. Power brakes
c. Hand operated emergency brake
d. Adequate space for operator to use portable AZ-1 hand controls. Some
drivers are overweight and vehicles have small driver compartments. It is
essential that adequate space is required for a comfortable amount of hand
use while operating the AZ-1 portable hand control system. If adequate
space is not available DO NOT OPERATE THE VEHICLE with the AZ-1
portable hand controls.
2. First verify that the pedals are sufficient size to mount the clamps for the brake and
accelerator. If the pedals are not large enough to mount the portable hand controls
securely DO NOT OPERATE THE VEHICLE with the AZ-1 portable hand controls.
Brake pedal must have a design that allows safe mounting of the AZ-1.
3. You should be able to slide the brake mount over the pedal in a vertical placement.
Then tighten finger screws evenly and verify that the clamps are secure. Be sure
that the AZ-1 portable hand control system doesn’t interfere with anything that
would compromise safety. If the AZ-1 cannot be adjusted to the proper length
contact the company where you purchased and return for replacement
immediately.
6
www.ActiveForever.com
4. You should be able to slide the accelerator mount over the pedal in a horizontal or
slightly vertical placement. It is important to assure that adequate clearance is
available to operate the accelerator freely. Then tighten finger screws evenly and
verify that the clamps are secure. Be sure that the AZ-1 portable hand control
system doesn’t interfere with anything that would compromise safety If sufficient
clearance is not available DO NOT OPERATE THE VEHICLE with the AZ-1
portable hand controls.
5. Next you must position your seat in a safe position. When you have positioned it in
a safe position you must first adjust the length of the brake tube. By unfastening
the snap pin you can slide the brake tube to the safe length. After locating the
length reinstall the quick release snap pin. Be sure that the pin is latched safely.
Test by pulling to verify that the snap pin is attached correctly. If for any reason
that snap pin is not securely fastened DO NOT OPERATE THE VEHICLE with the
AZ-1 portable hand controls. Test the brake with the vehicle in park before driving.
If the AZ-1 cannot be adjusted to the proper length contact the company where you
purchased and return for replacement immediately.
7
6. Now you must adjust the length of the accelerator tube. By unfastening the snap
www.ActiveForever.com
pin you can slide the accelerator tube to the safe length. The accelerator should by
approx. 2” higher then the brake handle for depression with your thumb. After
locating the length reinstall the quick release snap pin. Be sure that the pin is
latched safely. Test by pulling to verify that the snap pin is attached correctly. If for
any reason that snap pin is not securely fastened DO NOT OPERATE THE
VEHICLE with the AZ-1 portable hand controls. Test the accelerator with the
vehicle in park before driving. If the AZ-1 cannot be adjusted to the proper length
contact the company where you purchased and return for replacement
immediately.
Removing Instructions
To remove the AZ-1 portable hand controls loosen (do not remove) the finger screws to slide
the clamps over the pedals. If storing in a bag for travel it is not recommended to
disassemble the AZ-1 portable hand control. To collapse for storage remove pins and slide
the tubes to the smallest design.
Operation
Braking
• When operating the vehicle the AZ-1 portable hand controls will enable the
driver to press the power brake and accelerator with a single left hand only.
8
Accelerating
www.ActiveForever.com
• While firmly gripping the brake handle use your thumb on left hand to depress
the accelerator.
General
• Always keep you left hand on the AZ-1 portable hand control. Do not remove
your hand from the hand control unless the vehicle is safely positioned in park.
• Never depress the accelerator while you are braking.
• The AZ-1 portable hand control must be positioned between your legs to safely
operate.
• If your disability doesn’t allow motionless sitting then you should not attempt to
operate a vehicle the AZ-1 portable hand controls. Example, some people have
uncontrollable spasm that prevent safe driving. If you suffer from uncontrollable
muscle spasm DO NOT OPERATE THE VEHICLE with the AZ-1 portable hand
controls.
• The car must be steered with your right hand and the remaining left hand will
control the AZ-1 portable hand control. No exceptions are allowed.
9
www.ActiveForever.com
Accessories and Replacement Parts
Grip – heat resistant
Snap Pins .250” (¼”)
Snap Pins .3125” (5/16”)
Maintenance and Service Instructions
While in use the AZ-1 requires daily safety checks. On each daily use of the vehicle verify
the following before using the AZ-1 portable hand controls.
• Make sure that all nuts, bolts, pins and finger screws are tight and secure. It is
necessary to always keep the correct wrenches to tighten the hardware as
necessary. If anything is unsafe or unsecured DO NOT OPERATE THE
VEHICLE with the AZ-1 portable hand controls.
• Verify that the location of the clamps while mounted on vehicle pedals is safely
located each time you drive the vehicle.
• When storing the AZ-1 portable hand controls be sure to keep all components
together. Do not substitute other hardware or parts in place of the standard
material provided. If for any reason that a part in misplaced or damaged
contact Hand Control Inc. or your local supplier for replacement parts. See
parts list for correct identification.
Warranty
Hand Control, Inc. warranties that AZ-1 portable hand control for the life of the user that
purchases the item. You must complete the warranty registration card within 90 days of
purchase to qualify for the warranty. Shipping is not included for warranty replacements.
Safety Information
Contact your local Deparment of Motor Vehicle for requirements in your state. Each state
has different requirements for use of portable hand controls while driving a vehicle.
10
www.ActiveForever.com
Warning
Do not allow other people to drive with your portable hand controls.
Always remove the AZ-1 portable hand controls when other people are driving your car. This
includes but is not limited to friends, family and valet drivers.
You must have a valid drivers license to operate a vehicle.
Caution
If anything appears unsafe in the use of AZ-1 do not operate vehicle with the portable hand
control system. Automobiles can cause death and or serious injury during operation.
Unsecured controls will limit or eliminate the opportunity to control your vehicle. Therefore,
do not operate if any thing appears unsafe or unsecured.
Loading...