Acnodes PCH 7991 User Manual

PCH 7591

15 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

PCH 7991

19 inch Atom Fanless Panel PC

User Manual

PCH 7991: 19” Industrial Fanless Panel PC with Atom N270 processor

PCH 7591

15 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

PCH 7991

19 inch Atom Fanless Panel PC

Warning!

Safety & Warranty

1. Read these safety instructions c arefully.

2. Keep this user's manua l f or later reference.

3. Discon nect this equipment from any outle t before clean ing. Do not use liquid or spray detergents for cleaning. Use a damp cloth.

4. For pluggable equipment, the p ower outlet must be installed near the equipment and must be easily accessible.

5. Keep this equ ipment away from humidity .

6. Put this equipment on a reliable surface during installation. Dropping it o r let ting it fall could cause damage.

7. The openings on the enc losure are for air convec tion. Protect the equipment from overheating.

DO NOT COVER THE OPENINGS.

8. Ma ke sure the voltage of the power source is correc t before co nnecting the equipment to the power outlet.

9. All cautions and warnings on the equipment should be noted.

10 . If the equ ipment is not used for a long time, disconnect it from the power source to avoid

damage by transien t over-voltage. 11 . Never pour any liquid into an opening. This could c au se fire or electrical sh ock. 12 . NEVER OPEN THE EQUIPMENT. FOR SAFETY REASONS, ONLY QUALIFIED SERVICE

PERSONNEL SHOULD OPEN THE EQUIPMENT. 13 . If any of the following s ituations arise s, get the equipment checked by s erv ice personnel:

The power cord or plug is damaged.

Liquid ha s penetrat ed into the equipment.

The equipment has been expos ed to mo isture.

The equipment does not work well, or you c annot get it to work according to the users manual.

The equipment has been dropped and damaged.

The equipment has obvious signs of breakage.

14 . DO NOT LEAVE THIS EQ UIPMENT IN AN ENVIRO NMENT WHERE THE STORAGE

TEMPERATURE IS BELOW -20° C OR ABOVE 70° C. IT MAY DAMAGE THE EQ UIPMENT.

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

PCH 7991

19 inch Atom Fanless Panel PC

Thi s equipment generates uses and can radiate radio frequency energy and if not installed and

us ed in accordance w ith the instructi ons manual, it may caus e interf erenc e to radi o

c ommunications.

It has been tested and found t o comply with the limits for a C lass A computing device pu rsuant to

FC C Rul es, whic h are des igned to provide reasonable protection agai nst such i nterference whe n

op erated in a commerc ial environment. Ope ration of th is equipment in a residentia l area is likel

y to c ause interferenc e in w hich case the use r at his own ex pense will be required to take whateve r m easure s may be required to correc t the interfe renc e.

El ectric S hock Hazard – Do not operate the machine w ith its back co ver removed. There are dangerous high voltage s inside.

Disclaimer

T his info rmation in this document is subject to change w ithout notice. In no ev ent shall Ac nodes C orpo ration be liable fo r damage s of any kind, whethe r inciden tal or c onsequential, arising from either the u se o r misuse o f information in this document or in any re lated materials.

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

PCH 7991

19 inch Atom Fanless Panel PC

T

a b le o f C o n te n ts

W a r n in g !… … … … … … … … … … … … … … … … … … … … … … … … … … … … … . … … . . … . 2 D is c l a i m e r… … … … … … … … … … … … … … … … … … … … … … … … … .… … … … … … … 2

C h a p t e r 1 G e t

1 . 1 F e a t u r e s … . . . . . . … … … … … . … … … … … … … … … … … … … … . . … . . … . . . … 6

1 . 2 S p e c i f i c a t i o n s … … … … … … … … … … … … … … … … . … … … … … … . . . … . . 6 1 . 3 B r i e f D e s c r i p t i o n … … … … … … … … … … … . . . … … … … … … … … … … … 8 1 . 4 C h a s s i s D i m e n s i o n s . . … … … … … … … … … … … … … … … … … … … . . … . . 9

tin

g S ta

rte

C h a p t e r 2 M a in b o a r d

2 . 1 M a in b o a r d S p ec i fi c a ti o n s … .… … … … … … … … … .… … … … … … . .. . .. .. .. . 12

2 .2 O n b o

ar

d J u m p er s an d P o r t P

in

o u ts … … … .… … … … … … . … … .… … . ... ... 18

C h a p t e r 3 A M I B IO S S e t u p

3 . 1 O p e r a t i o n s a f t e r P O S T S c r e e n . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 7

3 . 2 S t a n d a r d C M O S F e a t u r e s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 8

3 . 3 A d v a n c e d B I O S F e a t u r e s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 1

3 . 4 A d v a n c e d C h i p s e t F e a t u r e s S e t u p . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 4

3 .5 I n t e g r a t e d P e r i p h e r a l s . . .. . . . . . . . .. . . . . . . . .. . . . . . . .. . . . . . .. . . . . . . . .. . . . . . . . . . . .. . . . . . . . . . 3 7

3 . 6 P o w e r M a n a g e m e n t s S e t u p . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 2

3 .7 P n P / P C I C o n f i g u r a t i o n s S e t u p . . . . . . .. . . . . . . .. . . . . . .. . . . . . . .. . . . . . . .. . . . . . .. . . . . . . .. 4 5

3 . 8 P C H e a l t h S t a t u s … . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 7

3 . 9 L o a d F a i l - S a fe / O p ti m i z e d D e fa u l ts . . . . . .. . . . . . . .. . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 8

3 . 1 0 S e t A d m i n i s t r a t o r / U s e r P a s s w o r d . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 0

3 . 1 1 S a v e & E x i t S e t u p … … … … … . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 0

3 .1 2 E xi t W ith o u t S av in g … … … … … … … … … … … … … … . … … … … … … … … . 5 1

C h a p t e r 4

4. 1 S u p e r IO M o d el ... ... ...

....

... ... ... ... ... ... ... ..

....

... ... ... ... ... ... ... ... .. . ... ... ... ... ... ... ... ...

....

d

.. 52

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

4 . 2 W 8 3 6 2 7 U H G A c c e s s i n d e x p o r t . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 2

4. 3

4. 4

4. 5 So

C hapt er 5

5

C

hapt

er 6

6 . 1 I n t e l C h i p s e t D r i v e r s . . . . . … … … … … … . … … … … … … … … … … … … . 6 3

6 . 2 I n t e l Gr a p h i c s M e d i a Ac c e l e ra t o r D r i v e r … … . . … … … … … … … … … . 6 6 6 . 3 R e a l T e k G i g a b i t L A N D r i v e r … … … … … … … … … … … … … … … … . 7 0 6 . 4 R e a l t e k H D D r i v e r I n s t a l l a t i o n s … … … … … … … … … … … … … … 7 3

C

hapt

F igur es

er 7 Touch D ri ver Installation

7 .1 W 7 . 2 C o n fi g u ri n g

F i g u r e 1 . 1 : F ro n t V i e w … … … … … … … .… … … … … … … … … … … . . … … … … 8 F i g u re 1 .2 : R e a r Vi e w … … … … . .. … … … … … … … … … … … … … … … … … … … 8 F ig ure 1 .3 : F ig ure 1 .4: F ig ure 1 .5: F ig ure 2 .1 : M a in bo ar d F ig ure 2 .2 : M a in bo ard Di F ig ure 2 .3 : C on ne ct or a n d J u F ig ure 7 .1 : Bir d’s

Con

fig ure GP IO

Re

a d/w rite

ftwa

re

pro gra m mi

Wa

tc hd og S ou rc e Co de .. ... ... ... .... .. .... .. ... .... ... ... ... ... ... ... ... ... ... ... ... ... ... ... ... ... .... .5 9

ind

o ws 20 0 0/ XP Dr iv er I ns ta lla ti on for

Dim Dim Dim

reg

is te r s e qu en ce .. ... ... .... ... .. .... ... ... ... ... ... .. .... ... ... ... ... ... ... ... .5 2

GPI

O s e qu en c e… ………………… …………… ……………….. ... ..5 2

ng e xa m p le. .. ... ... ... .... ... .. .... ... ... ... ... ... ... ... ... ... ... ... ... ... ... .5 2

Pe

n M o u n t W i n do w s 2 0 0 0 /X P Dr iv e r ……… … … … …

e n si on s o f th e P e ns io ns of the P e ns io ns of t he

Ov e rvi

PCH7

ew

me

n si on s… … ………………… ………………… ……

mp

Ey e Vie

w o f Co ntr ol

Installatio

Con

tro ll er B oa rd .… …….… .7 6

CH7

59 1 … .. ... .... ..… … ……… ………………… …9

CH7

7 91 … … ………………… …… ……..

9 91 … ... ... .... .. ... .... .. .... .. ... ... ... .... ... .. .... .. .... .. 11

….…

… …………..… .… ……… ………….. ……..1 2

e r L oc at

ion

Boa rd.

s ………………… ………………… 15

... ... ... ... ... ... ... ... ... ... ... ... ... ... ... ... ... 76

n of D ri ver s

…. .…1

….

…1

. 7 6

0

3

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

S ys te m

Pro ce s so r

In te l A to m Pro ce ss o r N 2 7 0 1 .6 G Hz b u ilt-in , F SB 5 3 3 M Hz

Sys te m M e m o ry

1 x 2 0 0 -p in SO -D IM M s o ck e t, su p p o rt 5 3 3 M Hz u p to 2 G B S DR AM

Sys te m Ch ip se t

In te l 9 4 5 G S E + In te l ICH7 M

Ext e rn a l I/O Po rt

Sta n d a rd I/O :

2 x U SB 2 .0 co n n e cto rs 1 x R J-4 5 L AN co n n e cto r 1 x D B-9 RS -2 3 2 (CO M 1 ) co n n e cto r 1 x D B-9 RS -2 3 2 /4 2 2 /4 8 5 co n n e cto r (CO M 2 ), De fa u lt RS -2 3 2 1 x D C P o we r in p u t

Fu l l F u n ctio n I/O :

1 x V G A DB -1 5 p o rt 1 x Au d i o L i n e -o u t p o rt

So l id Sto ra g e Disk

1 x CF Sl o t (in te rn a l)

1 x 2 .5 ” HDD b a y fo r SATA H DD

O S Su p p o rt

W ind o w s XP Pro fe s sio n a l, XP Em be dd e d

Chapter 1

1.1

Featu

F a n le s s De si g n In te l At om N2 7 0 1 .6 G Hz P ro ce sso r, FS B 5 3 3 M Hz O n e 2 0 0 Pin S O -DIM M so c ke t, u p to 2 G B DDR 2 5 3 3 M Hz S DR AM 11 ~ 3 2 V D C wi d e ra n ge p o we r in p u t To ta l NE M A 4 /IP6 5 co m p li a n t S e a le d 5 -W ire Re sis tive To u ch S cre e n , O p tio n a l fo r G F G R e sistiv e To u ch Sc re e n

res

1.2 Sp eci fications

S ys te m

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

LCD

Dis play Type

TFT-LCD

Max. Reso lution

15” 10 24 x768 (PCH 7591) 17”/19 ” 1280x1024 (PCH7791 /79 91)

Max. Colo r

262K

Luminance (cd/m2)

350 (c d/m2) (PC H7591) 300 (c d/m2) (PC H7791/7991)

View Angle

H:120° / V:100° (PCH 7591) H:160° / V:170° (PCH 7791) H:160° / V:160° (PCH 7991)

Bac klight Lifet ime

50,000hrs

Touch Screen

Type

Resis tive Type

Light Transmission

80%

Pow er Supply

Pow er Input

DC 11~32V

Mechanical

Construction

Stainless Steel

IP R ating

Total IP65

Mounting

VESA 75x75 (PCH7 591 /7791) VESA 100x100 (PCH 79 91)

Dimension

399 (W) x324(H) x 53 (D) mm (PC H7591) 432 (W) x358(H) x 57 (D) mm (PC H7791)

470 (W) x389(H) x 60 (D) mm (PC H7991)

Environmental

Operating Temperature

0~50 ﾟ C

Storage Temper ature

-20~60 ﾟ C

Storage Hu midity

10~90% @40 non-c ondensing

Certificate

Me et CE/FC C C lass A

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

1.3 Brief Description of the PCH 7X91

The c ha ssis of the PCH 7X91 is m ade of stainless steel with an ultra slim profil e. I t i s built in the Intel A tom N2 70 1.6GHz, FS B 533M H z, it is fan less. The m odel com es with a 15” ~19” inch TFT LCD d isplay, total N EM A 4/IP 65 com pliant, s pace for one 2.5-inch H DD, resi stive touch s cree n, a D C 11~ 32V wide range power input. This industrial panel PC also features 2 CO M po rts, 2 U SB ports and 1 x Gigabit LA N port. It is ideal for use as a P C-based controll er for A utom otive, Logis tic P roc ess, M ate rial s Handl ing, and Kios k applicati ons.

Figu re 1.1: Front View of

Figure 1.2: Rear View of

PCH7991

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

1.4 Chassis Dimensions

Figure 1.3: Dimensions of the PCH7591

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Figure 1.4 Dimensions of the PCH7791

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Figure 1.5 Dimensions of the PCH7991

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Chapter 2

2.1 Mainboard Specifications

Figure 2.1: Mainboard Overview

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

PCH 7991

19 inch Atom Fanless Panel PC

Figure 2.3: Connector and Jumper Locations

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

PCH 7991

19 inch Atom Fanless Panel PC

Speci ficatio

ns

Board S ize

165 x 115 mm

CP U S upport

Intel Atom N 270 1.6 GHz w ith 533MHz FS B

Chipset

Intel 9 45G SE + Intel IC H7M

Mem ory S upport

1x 200pin 533/400MHz DDR 2 SO -D IMM support, up to 2GB S DR AM

Graphics

Intel Graphics Media Accel era tor 950V GA integrated in Intel 94 5GSE

18 -bit dua l-c hannel LVD S integrated i n In tel 945GS E 18 /24 bit dual-channel LVD S s upport by Chron tel CH 7308B

1 x DB 15 Female connecto r for external

Super I/O

W inbond W 83627UHG

BIOS

A ward BI OS

Storage

2 x S ATA C onnector

1 x Compact Flash II S lot

1 x 44-pin ID E C onnector

Network

2 x Gigabit E thernet Port by R J45 with LE D i ndicators E thernet controller :

2 x P CIe by one bu s Realtek 8111D

USB

4 x U SB 2.0 stack p ort for external

2 x US B 2.0 header for inte rnal

Serial

1 x R S23 2 po rt, D B9 connec tor for external (CO M1 ),

pin 9 w/5V /12V /Ring sel ect

1 x RS 232/422/485 sel ect header for i nternal (C OM2),

def au lt RS 232

4 x RS 232 header for internal (COM3 – C OM6)

Digital I/O

8-bit di gi tal I/O by header

4-bit di gi tal Input

4-bit digital O utput

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Battery

Support CR2 477 ba ttery by 2-pin header

Audio

Support Audio via Realtek ALC662 HD audio decoder

Support L ine-in, Line-out, MIC by 2x5-pin header

Printer

1x LPT port by 2x13-pin header

Keyboa rd /Mouse

1x PS2 keyboard/mouse by 1x6 -pin wafer connector

Expansion Bus

1x PC 10 4+ connec tor (PCI master 4, jumper f or +3.3V &

5V se lect)

1x PCIe ( PCI-e 1x +SMBUS+USB2. 0 ) mini ca rd

Pow er Management

DC12V input

Front I/O

by 2x5-pin header Power on /off switc h Reset switch

Power LED status HDD LED status Buzzer

Watchdog Timer

Software programmable 1 – 255 second by Super I/O

External I/O port

1 x COM Port (COM1)

4 x USB 2.0 Ports (stac k)

2 x RJ45 Gb E Port (10/100/1000Mbps)

1 x VGA Port

Temperature

Operating: 0 – 60 degre e C

Storage: -20 – 80 degree C

Humidity

5% - 95%, non-condensing, operating

Pow er Consumption

12 V @1.45A (Intel N270 processor with 1GB DDR2 DRAM)

EMI /EMS

CE/FCC clas s A

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

JVC CIO

PCI-104 VCCIO

Voltage

CLOSE 1-2

+3.3V (defaul t)

CLOSE 2-3

+5V

JCLR _CMOS

CMOS

CLOSE 1-2

NO RMAL (de fault)

CLOSE 2 -3

CLEAR CMO S

2.2 Onboard Jumpers and Port Pinouts

1. JVCC IO (2.0 MM 1X3) PCI-104 port voltage selection jumper: selec t voltage for PC I-104+ device

2. JC LR _CMOS (2.0MM 1X3) CMOS clear jumper: CMOS clear operation will perm anently reset old

BIOS settings to factory defaults .

Procedures of C MOS c lear:

1. Turn off the system and unplug the power cord from the power outlet;

2. To clear the C MOS settings, us e the jumper cap to close pins 2 a nd 3 for about 3 seconds then reinstall the jumper clip b ack to pins 1 and 2.

3. Pow er o n th e s ystem again;

4. When entering the POST sc reen, press the <D EL> ke y to enter CMOS Setup U tility to load optimal defaults;

5. After the above operations, s ave changes and exit BIOS Setup.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Pin #

Sign al Name

1

KBDATA

2

MSD ATA

3

Ground

4

+5V

5

KBCLK

6

MSC LK

PIN#

Signal Name

PIN1

VBAT

PIN2

Ground

Signal N ame

Pin#

Signal N ame

D CD

1 2 R XD

TXD

3 4 D TR

G round

5 6 D SR

RTS

7 8 C TS

R I 9 10

N C

3. BAT (1.25.0MM 1X2) Ext. Battery port: a 3.3V battery is embedded to provide po wer for C MOS.

4.CO M2-C OM6 (2.0MM 2 X5) CO M2~COM6 port: up to 5 s tandard RS232 ports are provided. The y

can be use d direc tly via C OM adapter cable connection.

Note: C OM2 port is controlled by p ins No.8~1 0 of JCOM. For details, please refer to

desc ript ion of JCO M.

5.KB /MS (2.0MM 1X6 ) PS/2 ke yboard/mous e port: the port can be connected to PS/2 keyboard or mouse via a dedicated adapter cable for direct use.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Signa l Name

Pin#

Signa l N ame

PSTB#

1 2 PD0

PD 1

3 4 D P2

DP3

5 6 D P4

DP5

7 8 D P6

DP7

9

10

ACK#

BU SY

11

12

PE

SL CT

13

14

AFD#

ER R#

15

16

INIT#

SL IN#

17

18

Ground

19

20

Ground

21

22

Ground

23

24

Ground

25

26

Ground

Signa l Name

Pin#

Signa l N ame

GPIO20

1 2 G PIO 60

GPIO21

3 4 G PIO 61

GPIO22

5 6 G PIO 62

GPIO23

7 8 G PIO 63

Ground

9

10

+5V

6. LPT (2.0MM 2X13) Parall el port: a standard 26 pin parallel port is prov ided to connect parallel peripherals as required.

7. GPIO (2.0MM 2X5) General-purpose input/output port: it provides a gro up of self-programming interfaces t o customers for flexible use.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

S ig n a l N a m e

P in #

S ig n a l N a m e

A

1 2 Te r m in a l R e s is t a n c e

B

3 4 Te r m in a l R e s is t a n c e

Z

5 6 N C

Y

7 8 N C

G r o u n d

9

1 0

N C

S ig n a l N a m e

P in #

S ig n a l N a m e

+ 5 V

1 2 + 5 V

U S B _ P 6 _ D N

3 4 U S B _ P 7 _ D N

U S B _ P 6 _ D P

5 6 U S B _ P 7 _ D P

G r o u n d

7 8 G ro u n d

N C 9 1 0

G ro u n d

J C O M

F u n c t i o n

C L O S E 1 - 2

C O M 1 P i n 9 = R I (d e f a u l t )

C L O S E 3 - 4

C O M 1 P in 9 = + 5 V

C L O S E 5 - 6

C O M 1 P in 9 = + 1 2 V

C L O S E 7 - 9 C L O S E 8 - 1 0

C O M 2 F O R R S 2 3 2 F R O M C O M 2 (d e f a u l t)

C L O S E 9 - 11 C L O S E 1 0 - 1 2

C O M 2 F O R R S 4 8 5 / R S 4 2 2 F R O M C O M 2 2

8 . C O M 2 2 (2 . 0 M M 2 X 5 ) : it p r o v id e s s e le c t a b le R S 4 2 2 / 4 8 5 s e r ia l s ig n a l o u t p u t .

9 . U S B 4 (2 . 0 M M 2 X 5 ) F r o n t U S B c o n n e c t o r : it p r o v id e s t w o U S B p o rt s v ia a d e d ic a t e d U S B

a d a p t e r c a b le .

N o t e :

B e f o r e c o n n e c t io n , m a k e s u re t h at p in o u t o f t h e U S B a d a p t e r is in a c c o rd a n c e w it h t h a t o f t h e s a i d t a b le s . A n y in c o n f o r m it y m a y c a u s e s y s t e m d o w n a n d e v e n h a rd w a re d am a g e s .

1 0 . J C O M (2 . 0 M M 2 X 6 ) C O M 1 / 2 s e t u p j u m p e r: p i n 1 ~ 6 a r e u s e d t o s e le c t s ig n a l o u t o f p in 9 o f C O M 1 p o r t ; p in 7 ~ 1 2 a r e u s e d t o s e le c t o u t p u t t y p e f o r C O M 2 p o r t (R S 2 3 2 o r R S 42 2 /4 8 5 ).

N o t e :

1 . A s d e t e r m in e d b y i ts h a r d w a r e d e s ig n , th e b o a r d f e a t u r e s f u ll- d u p le x R S 4 8 5 c o m m u n ic a t io n . L ik e

R S 4 2 2 , a f o u r - w ir e c o n n e c t io n i s n e c e s s a r y.

2 . S in c e C O M 2 a nd C O M 2 2 u s e t h e s a m e a d d r e s s , th e y c a n n o t w o r k a t t h e s a m e t im e .

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Signa l N ame

Pin#

Sign al Name

R ESET

1 2 Ground

ID E_PDD 7

3 4 IDE_PD D8

ID E_PDD 6

5 6 IDE_PD D9

ID E_PDD 5

7 8 IDE_PD D10

ID E_PDD 4

9

10

IDE_PD D11

ID E_PDD 3

11

12

IDE_PD D12

ID E_PDD 2

13

14

IDE_PD D13

ID E_PDD 1

15

16

IDE_PD D14

ID E_PDD 0

17

18

IDE_PD D15

Ground

19

20

NC

D REQ

21

22

Ground

IOW#

23

24

Ground

IOR #

25

26

Ground

IOC HR DY

27

28

Ground

D AC K#

29

30

Ground

IR Q14

31

32

NC

Address 1

33

34

IDE_PD IAG

Address 0

35

36

Add res s 2

C hip selec t 0

37

38

Chip s elect 1

Activit y

39

40

Ground

+5V

41

42

+5V

Ground

43

44

NC

11. I DE (2.0MM 2X22) IDE connector: the motherboard pro vides a 44-pin IDE connect or for

connec tion of 2.5' IDE ha rd disk drivers and supports up to 2 IDE devices .

N ote:

If tw o IDE devices are connecte d, C F card connection cannot be realized.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

S ig n a l N a m e

P in #

S ig n a l N a m e

H D L E D +

1 2 P O W E R L E D +

H D L E D -

3 4 P O W E R L E D -

G r o u n d

5 6 P W R B T N

R E S E T

7 8 G ro u n d

B U ZZ E R +

9

1 0

B U Z Z E R -

S ig n a l N a m e

P i n #

S ig n a l N a m e

F R O N T- O U T- L

1 2 L IN E IN _ R

A U D _ A G N D

3 4 A U D _ A G N D

F R O N T- O U TR

5 6 L IN E IN _ L A U D _ A G N D

7 8 A U D _ A G N D

F R O N T- M IC 1

9

1 0

A U D _ A G N D

1 2 . F _

PA

N E L (2 .0 M M 2 X 5 ) F ro n t pa n e l c o nn e c t o r

P IN 1 & 3 : Th e y a re u s e d to c o n n e c t h a r d d is k a c tiv ity L E D . T h e L E D b lin k s w h e n th e h a r d d is k r

e a d in g o r w r

itin

g d a ta . P IN 2 & 4 : Th e y a re u s e d t o c o n ne c t p o w e r L E D . W h e n th e s y s te m i s p o w e r e d o n o r u n d e r S 0 th e L E D is n o rm a l ly o n ; w h e n th e s y s te m is u n d e r S 4

/S

5 s ta te , th e L E D is off.

is

/S

1 s ta te ,

P IN 5 & 6 : T h e y a r e u s e d to c o n n e c t p o w e r s w itc h b u tto n . T h e tw o p in s a r e d is c o n n e c te d u n d e r n o r m a l c o n d

itio

n .

Yo

u m a y s h o r t th e m te m p o r a r ily to r e a

liz

e s y s te m s ta r tu p & s h u td o w n o r a w a k e n th e s y s te m fr o m s le e p s ta te . P IN 7 & 8 : Th e y a re u s e d to c o n n e c t r e s e t b u tto n . T he tw o p in s a r e d is c o n n e c te d u n d e r n o rm a l c o n d

itio

n .

Yo

u m a y s h o r t th e m te m p o r a r ily to r e a

liz

e s y s te m r e s e t.

P IN 9 & 1 0 : Th e y a re u s e d to c o n n e c t a n e x te r n a l b u z z e r.

N o te :

W h e n c o n n e c tin g L E D s a n d b u z z e r, p a y s p e c ia l a tte n tio n to th e s ig n a l p o la ri ty. M a k e s u re th a t th e c o nn e c to r p i n s h a v e a o n e - to - o ne c o r re s po n de n c e w ith c h a s s is w i ri n g , o r i t m a y c a u s e b o o t u p fa ilu r e .

1 3 . F _ A U D IO (2 .0 M M 2 X 5 ) Fr o n t A u d io: A n o n b o a r d R E A LTEL A L C 6 6 2 C O D E C is u s e d to p ro v i d e h ig h - q u a lity a u d i o I/O p o r ts ; L in e O u t c a n b e c o n n e c te d to a h e a d p h o n e o r a m p lif ie r; L in e In is u s e d f o r th e c o n ne c tio n o f e x te r n a l a u d io s o u r c e v i a a L in e in c a b le ; M ic is th e p o r t fo r m ic r o p h o n e in p u t a u d io .

N o te :

T h e b o a r d o n ly s u p p o r ts m o n o m ic ro p h o n e in p u t.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

4.2.2 UNPACKING PROCEDURE

To unpack the APM series industrial monitor, follow the steps below: WARNING:

The front side LCD screen has a protective plastic cover stuck to the screen. Only remove the plastic cover after the APM series industrial monitor has been properly installed. This ensures the screen is protected during the installation process.

Step 1: Use box cutters, a knife or a sharp pair of scissors to open the seal on the top side of the external (second) box.

Step 2: Open the external (second) box. Step 3: Use box cutters, a knife or a sharp pair of scissors the seal on the top side of the internal (first)

box. Step 4: Lift the monitor out of the boxes. Step 5: Remove both polystyrene ends, one from each side. Step 6: Pull the plastic cover off the APM series industrial monitor. Step 7: Make sure all the components listed in the packing list are present.

4.2.3 PACKING LIST

All the monitors in the APM series are shipped with the following components:

APM5121 / APM5151 industrial LCD monitor 1 x Power cable for terminal block 1 x VGA cable 1 x Screw set 1 x User manual on CD-ROM 1 x Touch screen RS-232 cable / touch pen / driver CD-ROM *1 x 45W AC power adapter with AC 90V ~ 264V @ 1A input and DC +12V @3.75A output / AC power cord * External 45W power adapter only supports 0°C ~ 40°C operating temperature If any of these items are missing or damaged, contact the distributor or sales representative imme diately.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Pin#

Signa l Name

1

Ground

2

+12V

3

Rotation detection

Pin#

Signa l N ame

1

+12V

2

G round

14. U SB 1/2 R ear USB connector: it provide s up to 4 USB2.0 po rts.

15. LAN 1/2 R ear LAN connectors: 2 standard 1000M RJ-45 Ethernet ports are provided. LIN K

LED (green) and AC TIVE LED (yellow) respec tively loc ated at the left-hand and righ t-hand side of the Ethernet port indicate the activity and transmission state of LAN .

16. VGA (Video Graphic Arra y): GMA950 GPU is integrated to provide high-quali ty video ou tpu t.

17. C OM1 R ear serial port: standard DB9 serial port is provided to mak e a d irec t connection to s eria l

devices.

18. FAN (2.54MM 1X3) Fan connector: cooling fans can be connected direc tly for use. You may set the rotation condit ion of cooling fan in PC H ea lth Status menu of BIOS Setup.

N ote: Output po wer of coo ling fan must be limit ed under 5W.

19. AT12V (5.0MM 1X2) 12V System power input connector

N ote:

Make s ure that the vo ltage of po wer supply is DC(12±5%)V before power on, or it may caus e boot up failure a nd even system damage.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Signal Name

Pin#

Signa l Nam e

+5V

1 2 +5V

Gro und

3 4 Ground

+3.3V

5 6 +3.3 V

A0M

7 8 A4M

A0P

9

1 0

A4P

Gro und

11

1 2

Ground

A1M

13

1 4

A5M

A1P

15

1 6

A5P

Gro und

17

1 8

Ground

A2M

19

2 0

A6M

A2P

21

2 2

A6P

Gro und

23

2 4

Ground

CLK1M

25

2 6

CLK2M

CLK1P

27

2 8

CLK2P

Gro und

29

3 0

Ground

SC _DDC

31

3 2

SD_DD C

Gro und

33

3 4

Ground

A3M

35

3 6

A7M

A3P

37

A3M

A7P

NC

39

4 0

NC

20. LVD S2 for dual 24 bit 24-bit LVDS output connector: Fully s upported b y C HR ONTEL CH 7038B chips et, the interf ace features single and dual channel 18-bit and 24-bit output with max imum resolution support up to 1600*1200. The format of conne cted displ ay screen is OPENLDI. Model name of the in terface con nec tor is Hirose D F13-4 0DP-1.25V.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Signal

Nam

e

Pin#

Signal

Nam

e

LVDS

1_V DD 5

1 2 LVD

S1_V

DD 5

Ground

3 4 Ground

LVDS

1_V DD 3

3

5 6 LVD

S1_V

DD 3

3

LAD ATA N0

7 8 LBD ATA N0

LAD ATA P0

9

10

LBD ATA P0

LAD ATA N1

11

12

LBD ATA N1

LAD ATA P1

13

14

LBD ATA P1

LAD ATA N2

15

16

LBD ATA N2

LAD ATA P2

17

18

LBD ATA P2

LAC LKN

19

20

LBC LKN

LAC LKP

21

22

LBC LKP

LDD C _CLK

23

24

LDD C _DATA

LBK LT _EN

25

26

J LVD S_C T RL

Ground

27

28

Ground

+V 12S

29

30

+V 12S

21. LVD S1 fo r d u al 18 b it

the interface features 1600*1200. T he form at of connected di splay screen i s SP W G. M odel nam e of the i nterface c onnector is H irose DF

13-30DP

18-b

it LV DS ou tp ut co n

singl

e and dual channel 18 -bit output w ith m

necto

-1.25V.

r : Ful ly supported by INT

axim

um resolution support u p to

EL945G

SE chipset,

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Pin#

Signa l N ame

1

+12V

2

+12V

3

G rou nd

4

G rou nd

5

EN ABKL

6

CTRBKL

JBGT_CTR L

Function

C lose 1 -2

LEVEL

C lose 2-3

PWM

JBKLT_EN

Function

C lose 1 -2

LVD S1

C lose 2-3

LVD S2

22. B KL (2.0MM 1X5) Backlight control connecto r for LVDS1/2

N ote

Pin# 6, Backlight control voltage from 0~ 5V

23. JB GT_CTRL (2.0MM 1X6) Backlight Control jum per set ting for LVDS1/2

N ote: please ch eck first your LVD S panel back light control by LEVEL or PWM?

24. JB KLT_EN (2.0MM 1X3) Selection of LVDS1/2

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Product description and product specifications are subj ect to ch ange with out notice. For l atest product inform ati on, please visit Acnodes’ web site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Pin#

Signa l Nam e

1

+5V

2

Ground

25. SATA1/2 SATA Connectors: two SATA connectors are provided, with tran sfer speed up to

3.0Gb/s .

26. C N1 (2.5MM 1X2 ): an onboard 5V outp ut connector is reserved to provide power for IDE/SATA devices.

N ote:

Output current of the connec tor mus t n ot b e abov e 1A.

27. B Z Buzz er: onboard buzzer

28. PCI- 104+ PCI-104 connector: it conforms to standard PC I-104 (PCI only) spec ification .

29. SO-DIMM Memory socket: the socket is located at the bac kside of the board and supports

200PIN 1.8V DD RII400/533 SO-DIMM memory module up to 2G. If a DDR II667/800 memory m odule is installed, the sy stem will redu ce the DRAM frequency to 533MHz .

30. MPCIE Mini PC I-E slot: it supports MINI PCI-E devices with USB2.0, SMBU S and PCI-E signal.

31. CF CF Card Slot: it is located at the backs ide of the board and s erve s as an insert interface for

Type I and Type II Compact Fla sh card. The o peratin g voltage of CF c ard can be set as 3. 3V or 5V. The default setting of the produc t is 3.3V.

PCH 7991

19 inch Atom Fanless Panel PC

© Copyrigh t 2012 Acnodes, Inc. All rights reserved. Prod uct desc ript ion and product spe cificati ons are subj ect to ch ange with out notice . For latest produ ct in format ion, please visit Acnodes’ we b site at www.acnodes.com.

14628 Central Ave. Chin o, CA91710 Tel:909.597.7588, Fax:909. 597.1939

Chapter 3

3.1 Operations after POST Screen

After CMOS dis charge or BIO S flashing operation, the s ystem will display the following screen for your fu rther operation. Pres s F1 key to continue or Del key to enter CMOS Setup.

Phoeni x – AwardBIOS v6.00PG,

ASB-L

701 V

Main

Processor : Intel®

M

emory Testing CPU Brand Name : Intel®

C1E BIOS Supported

Hyper-Threading

1984-2007,

019

Atom™ 1.60GHz(133x12)

:515008K OK + 8M

Atom™ CPU N270

Technolog

M

emory Frequ ency

IDE

Channel 0 Mas ter : N

I

DE

Channel 0 Slave

IDE

Channel 1 Mas ter : N

I

DE

Channel 1 Slave

For DDR 2 533

: None

CMOS

checksum

error – Defaults

Press

F1

to conti

08/14/

2010-

nue, DEL to enter SETUP

Silv

erthrone-6A7

After optimizing an d e xiting CMOS Setup, the PO ST screen display ed f or the first time is as follows a nd includes bas ic information on BIOS, C PU , memory, and storage d evices.

Phoeni x – AwardBIOS v6.00PG,

1984-2007,

An Energy Star Ally

Phoenix T

y CPU D

one

9KAPXC-00

Phoenix T

echnologies,

shared memo

etected (Hyper-Threading Technology

loaded

An Energy Star Ally

echnologies,

LTD

ry

@1.60GHz

LTD

Enabled)

ASB-L

701 V

019

Main

Processor : Intel®

M

emory Testing CPU Brand Name : Intel®

C1E BIOS Supported

Hyper-Threading

Atom™ 1.60GHz(133x12)

:515008K OK + 8M

Atom™ CPU N270

Technolog

y CPU D

shared memo

etected (Hyper-Threading Technology

M

emory Frequ ency

IDE

Channel 0 Master : N

I

DE

Channel 0 Slave

IDE

Channel 1 Master : N

I

DE

Channel 1 Slave

For DDR2 533

one

: None

one

: None

Press

DEL

to

08/14/

enter SETUP, F12 to

2010-

Silv

erthrone-6A7

Enter Boot

9KAPXC-00

Press F12 key to enter Boot Menu during POST, as s ho wn by the follow ing figure.

== Select a Boot First de vice ==

@1.60GHz

Menu

Boot Menu

ry

Enabled)