GAS HOB
ZGF 782 CTN
ZGF 782 CTX
INSTRUCTION BOOKLET
Please read this instruction booklet before using the appliance
GB IE
Important Safety Information
You MUST read these warnings carefully before installing or using the hob. If you need assistance, contact our Customer Care Department on 08705 727727
Installation
zThis appliance must be installed and serviced by a competent person as stated in the Gas Safety (Installation and Use) Regulations Current Editions and the IEE Wiring Regulations.
zFor appliances installed in the Republic of Ireland please refer to NSAI-Domestic Gas Installations I.S.813 Current Editions and the ETCI Rules for Electrical Installations.
zRemove all packaging before using the hob.
zEnsure that the gas and electrical supply complies with the type stated on the rating plate, located near the gas supply pipe.
zDo not attempt to modify the hob in any way.
Child Safety
zThis hob is designed to be operated by adults. Do not allow children to play near or with the hob.
zThe hob gets hot when it is in use.
zChildren should be kept away until it has cooled.
zChildren can also injure themselves by pulling pans or pots off the hob.
zThis appliance is not intended for use by children or other persons whose physical, sensory or mental capabilities or lack of experience and knowledge prevents them from using the appliance safely without supervision or instruction by a responsible person to ensure that they can use the appliance safely.
During Use
zThis hob is intended for domestic cooking only. It is not designed for commercial or industrial purposes.
zWhen in use a gas cooking appliance will produce heat and moisture in the room in which it has been installed. Ensure there is a continuous air supply, keeping air vents in good condition or installing a cooker hood with a venting hose.
zWhen using the hob for a long period time, the ventilation should be improved, by opening a window or increasing the extractor speed.
zDo not use this hob if it is in contact with water. Do not operate the hob with wet hands.
zEnsure the control knobs are in the ‘OFF’ position when not in use.
zWhen using other electrical appliances, ensure the cable does not come into contact with the hot surfaces of the cooking appliance.
zUnstable or misshapen pans should not be used on the hob as unstable pans can cause an accident by tipping or spillage.
zNever leave the hob unattended when cooking with oil and fats.
zNever use plastic or aluminium foil dishes on the hob.
zPerishable food, plastic items and areosols may be affected by heat and should not be stored above or below the hob unit.
Service
zThis hob should only be repaired or serviced by an authorised Service Engineer and only genuine approved spare parts should be used.
2
Contents
For the User |
|
For the Installer |
|
Important Safety Information |
2 |
Instructions for the Installer |
8 |
Description of the Hob |
4 |
Important safety requirements |
9 |
Operation |
5 |
Installation |
10 |
Maintenance and Cleaning |
6 |
Building In |
11 |
Something Not Working? |
7 |
Electrical connections |
12 |
Guarantee/Customer Service |
16 |
Wiring Diagram |
13 |
European Garantee |
17 |
Fault Finding |
13 |
|
|
Commissioning |
15 |
|
|
Conversion from Natural Gas to LPG |
15 |
Environmental Information
zAfter installation, please dispose of the packaging with due regard to safety and the environment.
zWhen disposing of an old appliance, make it unusable, by cutting off the cable.
zThe symbol 
on the product or on its packaging indicates that this product may not be treated as household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment. By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by inappropriate waste handling of this product. For more detailed information about recycling of this product, please contact your local city office, your household waste disposal service or the shop where you purchased the product.
Keep this instruction book for future reference and ensure it is passed on to any new owner.
Guide to Use the instructions
The following symbols will be found in the text to guide you throughout the Instructions:
Safety Instructions
)Step by step instructions for an operation
Hints and Tips
Environmental Information
This appliance complies with the following
E.E.C. Directives:
*73/23 - 90/683
(Low VoltageDirective);
*93/68 (General Directives);
*89/336 (Electromagnetical Compatibility Directive);
*90/396 (Gas Appliances), and subsequent modifications
3
Description of the Hob
2
3
1
2
5
4
1.Auxiliary Burner
2.Semi-rapid Burners
3.Ultra-rapid Triple-crown Burner
4.RapidBurner
5.Control knobs
4
Operation
Hob burners
)To light a burner:
z turn the relevant control knob anticlockwise to the maximum position, then push it down to ignite the burner;
z upon ignition, keep the knob pushed down about 5 seconds. This will allow the "thermocouple" (Fig. 1, D) to be heated and the safety device to be switched off, otherwise the gas supply would be interrupted.
z then, check the flame is regular and adjust it as required.
If you cannot light the flame even after several attempts, check the "cap" and “crown” (Fig. 1, A-B) are in the correct position.
To put the flame out, turn the knob to the symbol z.
When switching on the mains, after installation or a power cut, it is quite normal for the spark generator to be activated automatically.
To ensure maximum burner efficiency, you should only use pots and pans with a flat bottom fitting the size of the burner used (see table).
Burner |
minimum |
maximum |
|
diameter |
diameter |
|
|
|
Ultra-rapid |
|
|
(triple-crown) |
180 mm |
260 mm |
Large(rapid) |
180 mm |
260 mm |
Medium (semi-rapid) |
120 mm |
220 mm |
Small (auxiliary) |
80 mm |
160 mm |
|
|
|
If you use a saucepan which is smaller than the recommended size, the flame will spread beyond the bottom of the vessel, causing the handle to overheat.
Take care when frying food in hot oil or fat, as the overheated splashes could easily ignite.
As soon as a liquid starts boiling, turn down the flame so that it will barely keep the liquid simmering.
If the control knobs become difficult to turn, please contact your local Service Force Centre.
Using the Wok Stand
A wok stand is provided to enable you to use a round bottomed wok on the hob. The wok stand must only be used on the central burner, and should not be used with any other type of wok or pan. When fitting the wok stand, ensure the recesses in the frame fit securely onto the bars of the pan supports, as shown in the diagram.
Triple-crown Burner
A
B
D
C
A - Burner cap |
Fig. 1 |
|
B - Burner crown |
|
|
C - |
Ignition electrode |
|
D - |
Thermocouple |
|
5 |
Maintenance and Cleaning
Before any maintenance or cleaning can be carried out, you must DISCONNECT the hob from the electricity supply.
The hob is best cleaned whilst it is still warm, as spillage can be removed more easily than if it is left to cool.
The Hob Top
Regularly wipe over the hob top using a soft cloth well wrung out in warm water to which a little washing up liquid has been added. Avoid the use of the following:
-household detergent and bleaches;
- impregnated pads unsuitable for non-stick saucepans;
-steel wool pads;
-bath/sink stain removers.
Should the hob top become heavily soiled, it is recommended that a cleaning product such as Hob Brite or Bar Keepers Friend is used.
The Burners
Theburnercapsandcrownscanberemovedforcleaning. Wash the burner caps and crowns using hot soapy water, and remove marks with a mild paste cleaner. A well moistened soap impregnated steel wool pad can be used with caution, if the marks are particularly difficult to remove.
After cleaning, be sure to wipe dry with a soft cloth.
Ignition electrode
The electric ignition is obtained through a ceramic and metal electrode (Fig. 1 - letter C). Keep these components very clean, to avoid lighting difficulties, and check that the burner crown holes are not obstructed.
6
Loading...