York 90, 120, 102, DH 078 User Manual

TECHNICAL

GUIDE

HIGH EFFICIENCY

SINGLE PACKAGE AIR CONDITIONERS AND

SINGLE PACKAGE GAS/ELECTRIC UNITS

DH 078, 090, 102, 120 and 150

6-1/2, 7-1/2, 8-1/2, 10 and 12-1/2 NOMINAL TONS

10.0-11.5 EER

246646-YTG-C-0606

®

DESCRIPTION

ASHRAE 90.1 COMPLIANT

YORK® Predator® units are convertible single packages with a common footprint cabinet and common roof curb for all 6-1/2 through 12-1/2 ton models. All units have two compressors with independent refrigeration circuits to provide 2 stages of cooling. The units were designed for light commercial applications and can be easily installed on a roof curb, slab, or frame.

All Predator® units are self-contained and assembled on rigid full perimeter base rails allowing for 3-way forklift access and overhead rigging. Every unit is completely charged, wired, piped, and tested at the factory to provide a quick and easy field installation.

All units are convertible between side and down airflow. Independent economizer designs are used on side and down discharge applications, as well as all tonnage sizes.

Predator® units are available in the following configurations: cooling only, cooling with electric heat, and cooling with gas heat. Electric heaters are available as factory-installed options or field-installed accessories.

Tested in accordance with:

FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE

246646-YTG-C-0606

TABLE OF CONTENTS

DESCRIPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 FEATURES. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 FACTORY INSTALLED OPTIONS . . . . . . . . . . . . . . . . . . . 5 FIELD INSTALLED ACCESSORIES . . . . . . . . . . . . . . . . . . 6 NOMENCLATURE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 GUIDE SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . . 46

LIST OF FIGURES

Fig. #

Pg. #

1 PREDATOR® COMPONENT LOCATION . . . . . . . . . . . . . 3 2 UNIT 4 POINT LOAD . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 3 UNIT CENTER OF GRAVITY. . . . . . . . . . . . . . . . . . . . . . 35 4 UNIT 6 POINT LOAD . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 5 UNIT DIMENSIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 6 PREDATOR® ROOF CURB DIMENSIONS . . . . . . . . . . . 37

7 SUNLINE™ TO PREDATOR® TRANSITION

ROOF CURBS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 8 BOTTOM DUCT OPENINGS . . . . . . . . . . . . . . . . . . . . . . 38 9 REAR DUCT DIMENSIONS. . . . . . . . . . . . . . . . . . . . . . . 38 10 DOWNFLOW ECONOMIZER HOOD DETAIL . . . . . . . . . 39 11 FACTORY INSTALLED DOWNFLOW ECONOMIZER . . 40

12 FIELD INSTALLED DOWNFLOW ECONOMIZER W/POWER EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . 40

13 FIELD INSTALLED HORIZONTAL ECONOMIZER W/POWER EXHAUST . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

14 SLAB ECONOMIZER DOWNFLOW W/POWER EXHAUST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

15 SLAB ECONOMIZER END RETURN W/POWER EXHAUST. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

16 COOLING UNIT WITH GAS HEAT WIRING

230 VOLT DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

17 COOLING UNIT WITH/WITHOUT ELECTRIC HEAT WIRING DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

18 COOLING UNIT WITH GAS HEAT WIRING 460,

575 VOLT 50 HZ DIAGRAM. . . . . . . . . . . . . . . . . . . . . . . 45

	LIST OF TABLES
Tbl. #		Pg. #
1	ACCESSORIES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .	. . . 8
2	DH PHYSICAL DATA . . . . . . . . . . . . . . . . . . . . . . . . . .	. . 11
3	DH CAPACITY RATINGS . . . . . . . . . . . . . . . . . . . . . .	. . 12
4	UNIT VOLTAGE LIMITATIONS . . . . . . . . . . . . . . . . . .	. . 12
5	COOLING CAPACITY DH078 (6-1/2 TON) UNIT . . . .	. . 13
6	COOLING CAPACITY DH090 (7-1/2 TON) UNIT . . . .	. . 14
7	COOLING CAPACITY DH102 (8-1/2 TON) UNIT . . . .	. . 15
8	COOLING CAPACITY DH120 (10 TON) UNIT . . . . . .	. . 16
9	COOLING CAPACITY DH150 (12-1/2 TON) UNIT . . .	. . 17

10 ELECTRICAL DATA DH078 (6-1/2 TON) HIGH EFFICIENCY W/O PWRD CONVENIENCE OUTLET . . . 18

11 ELECTRICAL DATA DH078 (6-1/2 TON) HIGH EFFICIENCY WITH PWRD CONVENIENCE OUTLET . . 18

12 ELECTRICAL DATA DH090 (7-1/2 TON) HIGH EFFICIENCY W/O PWRD CONVENIENCE OUTLET . . . 19

13 ELECTRICAL DATA DH090 (7-1/2 TON) HIGH EFFICIENCY WITH PWRD CONVENIENCE OUTLET . . 19

14 ELECTRICAL DATA DH102 (8-1/2 TON) HIGH EFFICIENCY W/O PWRD CONVENIENCE OUTLET . . . 20

15 ELECTRICAL DATA DH102 (8-1/2 TON) HIGH EFFICIENCY WITH PWRD CONVENIENCE OUTLET . . 20

16 ELECTRICAL DATA DH120 (10 TON) HIGH EFFICIENCY W/O PWRD CONVENIENCE OUTLET . . . . . . . . . . . . . . 21

17 ELECTRICAL DATA DH120 (10 TON) HIGH EFFICIENCY WITH PWRD CONVENIENCE OUTLET . . . . . . . . . . . . . 21

18 ELECTRICAL DATA DH150 (12-1/2 TON) HIGH EFFICIENCY W/O PWRD CONVENIENCE OUTLET . . . 22

19 ELECTRICAL DATA DH150 (12-1/2 TON) HIGH EFFICIENCY W/PWRD CONVENIENCE OUTLET. . . . . 22

20 ELECTRIC HEAT MULTIPLIERS . . . . . . . . . . . . . . . . . . 22

21DH078 (6-1/2) SIDE SHOT BLOWER PERFORMANCE 23

22DH090 (7-1/2 TON) SIDE SHOT BLOWER

PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

23 DH102 (8-1/2 TON) SIDE SHOT BLOWER PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

24 DH120 (10 TON) SIDE SHOT BLOWER

PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

25 DH150 (12-1/2 TON) SIDE SHOT BLOWER PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

26 DH078 (6-1/2 TON) DOWN SHOT BLOWER PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

27 DH090 (7-1/2 TON) DOWN SHOT BLOWER PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

28 DH102 (8-1/2 TON) DOWN SHOT BLOWER PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

29 DH120 (10 TON) DOWN SHOT BLOWER PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

30 DH150 (12-1/2 TON) DOWN SHOT BLOWER PERFORMANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

31ADDITIONAL STATIC RESISTANCE DH120 AND 150 . 33

32ADDITIONAL STATIC RESISTANCE DH078, 090, 102 . 33

33 ELECTRIC HEAT MINIMUM SUPPLY AIR CFM. . . . . . . 34 34 INDOOR BLOWER SPECIFICATIONS . . . . . . . . . . . . . . 34 35 POWER EXHAUST SPECIFICATIONS. . . . . . . . . . . . . . 34 36 4 POINT LOAD WEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . 35 37 6 POINT LOAD WEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . 35 38 UNIT WEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 39 UNIT HEIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 40 UNIT CLEARANCES . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 41 ECONOMIZER USAGE . . . . . . . . . . . . . . . . . . . . . . . . . . 39

2	Unitary Products Group

246646-YTG-C-0606

6LPSOLFLW\ &RQWURO %RDUG Z VFUHZ FRQQHFWRU IRU 7 VWDW ZLULQJ DQG QHWZRUN FRQQHFWLRQV

7HUPLQDO EORFN IRU KL YROWDJH FRQQHFWLRQ

6HFRQGPRGHO

QDPHSODWH

LQVLGH KLQJHG DFFHVV SDQHO

'XDO VWDJH FRROLQJ IRU PD[LPXP FRPIRUW

&RPSUHVVRU DFFHVV KLJK HIIL FLHQF\ FRPSUHVVRU Z FUDQNFDVH KHDWHU

%DVH UDLOV Z IRUNOLIW VORWV VLGHV DQG OLIWLQJ KROHV

5RRI FXUEV LQ HLJKW DQG IRXUWHHQ LQFK KHLJKWV 5RRI FXUEV IRU WUDQVLWLRQLQJ IURP <RUN 6XQOLQH IRRWSULQW WR WKH ') 6HULHV IRRWSULQWV DUH DOVR DYDLODEOHILHOG LQVWDOOHG DFFHVVRU\

'LVFRQQHFW ORFDWLRQ

RSWLRQDO GLVFRQQHFW VZLWFK )LOWHU DFFHVV

WKURZ DZD\ )LOWHU GULHUVROLG FRUH

6OLGH RXW GUDLQ SDQ ZLWK VWHHO 137 )HPDOH FRQQHFWLRQ

		&RPSUHVVRU DFFHVV
7RRO OHVV	6LGH HQWU\ SRZHU	KLJK HIILFLHQF\ FRPSUHVVRU
GRRU ODWFK	DQG FRQWURO ZLULQJ	Z FUDQNFDVH KHDWHU
	NQRFNRXWV

&RQGHQVHUVHFWLRQ

6OLGH RXW PRWRU DQG EORZHU DVVHPEO\ IRU HDV\ DGMXVWPHQW DQG VHUYLFH

%HOW GULYH

EORZHU PRWRU

3RZHU YHQWRU PRWRU

JDXJH DOXPLQL]HG VWHHO WXEXODU KHDW H[FKDQJHU IRU ORQJOLIHVWDLQOHVV VWHHO RSWLRQ

7ZR VWDJH JDV KHDWLQJ WR PDLQWDLQ ZDUP FRPIRUWDEOH WHPSHUDWXUH

,QWHOOLJHQW FRQWURO ERDUG IRU VDIH DQG HIILFLHQW RSHUDWLRQ

FIGURE 1 - PREDATOR® COMPONENT LOCATION (DH120 SHOWN)

FEATURES

•High Efficiency – High efficiency units reach as high as 11.5 EER. Gas/electric units have electronic spark ignition and power vented combustion with steady state efficiencies of 80%. These efficiencies exceed all legislated minimum levels and provide low operating costs.

•Service Friendly – The Predator® incorporates a number of enhancements which improve serviceability.

The motor and blower slide out of the unit as a common assembly. This facilitates greater access to all the indoor airflow components, thus simplifying maintenance and adjustment.

Service time is reduced through the use of hinged, toolless panels. Such panels provide access to frequently inspected components and areas, including the control box, compressors, filters, indoor motor & blower, and the heating section. The panels are screwed in place at the factory to prevent access by children or other unauthorized persons. It is recommended that the panels be secured with screws once service is complete.

Service windows have been placed in both condenser section walls. Rotation of the cover allows easy access to the condenser coils for cleaning or inspection.

Both the unit control board and ignition control board utilize flash codes to aid in diagnosis of unit malfunctions. Unique alarm codes quickly identify the source of the unit alarm.

All units use the same standard filter size. This standardization removes any confusion on which filter sizes are needed for replacement.

The non-corrosive drain pan slides out of the unit to permit easy cleaning. The drain pan is accessed by removing the drain pan cover plate on the rear of the unit. Once the plate is removed, the drain pan slides out through the rear of the unit.

All Predator® units have a second model nameplate located inside the control access door. This is to prevent deterioration of the nameplate through weathering.

Unitary Products Group

3

•Environmentally Aware – For improved Indoor Air Quality, foil faced insulation is used exclusively throughout the units.

•Balanced Heating – The Predator® offers “Ultimate Heating Comfort” with a balance between 1st and 2nd stage gas heating. The first stage of a gas heat Predator® unit provides 60% of the heating capacity. Balanced heating allows the unit to better maintain desired temperatures.

•Convertible Airflow Design – The side duct openings are covered when they leave the factory. If a side supply/ return is desired, the installer simply removes the two side duct covers from the outside of the unit and installs them over the down shot openings. No panel cutting is required. Convertible airflow design allows maximum field flexibility and minimum inventory.

•System Protection - Suction line freezestats are supplied on all units to protect against loss of charge and coil frosting when the economizer operates at low outdoor air temperatures while the compressors are running. Every unit has solid-core liquid line filter-driers and high and lowpressure switches. Internal compressor protection is standard on all compressors. Crankcase heaters are standard on reciprocating compressors. Scroll compressors do not require crankcase heaters. Phase Monitors are standard on units with scroll compressors. This accessory monitors the incoming power to the unit and protects the unit from phase loss and reversed phase rotation.

•Advanced Controls - Simplicity™ control boards have standardized a number of features previously available only as options or by utilizing additional controls.

•Low Ambient - An integrated low-ambient control allows all units to operate in the cooling mode down to 0°F outdoor ambient without additional assistance. Optionally, the control board can be programmed to lockout the compressors when the outdoor air temperature is low or when free cooling is available.

•Anti-Short Cycle Protection - To aid compressor life, an anti-short cycle delay is incorporated into the standard controls. Compressor reliability is further ensured by programmable minimum run times. For testing, the anti-short cycle delay can be temporarily overridden with the push of a button.

•Fan Delays - Fan on and fan off delays are fully programmable. Furthermore, the heating and cooling fan delay times are independent of one another. All units are programmed with default values based upon their configuration of cooling and heat.

•Safety Monitoring - The control board monitors the high and low-pressure switches, the freezestats, the gas valve, if applicable, and the temperature limit switch on gas and electric heat units. The unit control board will alarm on ignition failures, compressor lockouts and repeated limit switch trips.

•Nuisance Trip Protection and Strikes - To prevent nuisance trouble calls, the control board uses a “three times, you’re out” philosophy. The high and

246646-YTG-C-0606

low-pressure switches and the freezestats must trip three times within two hours before the unit control board will lock out the associated compressor.

•On Board Diagnostics - Each alarm will energize a trouble light on the thermostat, if so equipped, and flash an alarm code on the control board LED. Each high and low-pressure switch alarm as well as each freezestat alarm has its own flash code. The control board saves the five most recent alarms in memory, and these alarms can be reviewed at any time. Alarms and programmed values are retained through the loss of power.

•Reliable – From the beginning – All units undergo computer automated testing before they leave the factory. Units are tested for refrigerant charge and pressure, unit

amperage, and 100% functionality. For the long term – All Predator® units are painted with a long lasting, powder paint that stands up over the life of the unit. The paint used has been proven by a 1000 hour salt spray test.

•Flexible Placement – All models and configurations share the same cabinet/footprint and thus the same roof curb. You have the flexibility to set one curb and choose the correct tonnage size and heating option after the internal loads have been determined.

To further simplify planning and installation, Predator® cabinets are designed to fit your roof. With the optional roof curb, the unit ductwork is designed to fit around 24” on-center joists or between 48” on-center joists.

The drain pan can be rotated to drain to either the front or the rear of the unit. Additionally, the drain pan can be fitted to drain through the roof curb. As it is sometimes difficult to have a level installation, the drain pan features a generous slope to ensure proper drainage.

•Full Perimeter Base Rails – The permanently attached base rails provide a solid foundation for the entire unit and protect the unit during shipment. The rails offer forklift access from 3 sides, and rigging holes are available so that an overhead crane can be used to place the units on a roof.

•Easy Installation – Gas and electric utility knockouts are supplied in the unit underside as well as the side of the unit. A clearly identified location is provided to mount a field supplied electrical disconnect switch. Utility connections can be made quickly and with a minimum amount of field labor.

All units are shipped with 2” throw-away filters installed.

•Wide Range of Indoor Airflows – All indoor fan motors are belt-drive type providing maximum flexibility to handle most airflow requirements. For high static applications, factory installed alternate indoor fan motors are available. With the optional indoor fan motor, all units can supply nominal airflow at a minimum of 1.5” ESP.

•Warranty - All models include a 1-year limited warranty on the complete unit. Compressors and electric heater elements each carry a 5-year warranty. Aluminized steel and stainless steel tubular heat exchangers carry a 10year warranty.

4	Unitary Products Group

246646-YTG-C-0606

FACTORY INSTALLED OPTIONS

YORK® offers several equipment options factory installed, for the Predator® line.

•Optional Factory Installed Economizers - Predator units offer a variety of optional factory installed economizers with low leak dampers. The outdoor air enthalpy sensor enables economizer operation if the outdoor enthalpy is less than the setpoint of the economizer logic module. See Table 41 to determine the correct economizer for your application.

•Downflow Economizer - (With barometric relief) - The economizer is provided with a single enthalpy input. The economizer is 2% low leakage type, and is shipped installed and wired. The installer needs only to assemble and mount the outdoor air hood (Provided). The economizer has spring return, fully modulating damper actuators and is capable of introducing up to 100% outdoor air. As the outdoor air intake dampers open, the return air dampers close. The changeover from mechanical refrigeration to economizer operation is regulated by the standard single enthalpy input. There is an optional input dual dry bulb available. To meet regulated air standards, the

economizer control accepts an optional CO2 input for demand ventilation. With single enthalpy input, the economizer control monitors outdoor air. The dual enthalpy kit provides a second input used to monitor the return air. With a dual input kit installed, the economizer control compares the values of the two enthalpy or temperature inputs and positions the dampers to provide the maximum efficiency possible.

•Horizontal Economizer - (Without barometric relief) - All features of the downflow economizer exist except you must order the duct mount barometric relief separately. You must order a 1EH0408 if you are installing a power exhaust. You can order a 1RD0411 Barometric Relief for horizontal flow economizers only.

•BAS Ready Economizer -(With barometric relief) - The economizer is provided with a Belimo actuator that requires a 0-10V DC input from an external source (i.e., field installed building automation system controller). Power exhaust options are available. The economizer is 2% low leakage type with spring return and fully modulating dampers capable of introducing up to 100% outside air. Also include 2” pleated filters.

•Slab Economizer for Energy Recovery Ventilators- (With barometric relief and Fresh Air Hood) - The economizer is provided with a single enthalpy input. The economizer is 2% low leakage type, and is shipped installed and wired. The economizer has spring return, fully modulating damper actuators and is capable of introducing up to 100% outdoor air. As the outdoor air intake dampers open, the return air dampers close. The changeover from mechanical refrigeration to economizer operation is regulated by the standard single enthalpy input. There is an optional input dual dry bulb available. To meet regulated air standards, the economizer control accepts an optional CO2 input for demand ventilation.With single enthalpy

input, the economizer control monitors outdoor air. The dual enthalpy kit provides a second input used to monitor the return air. With a dual input kit installed, the economizer control compares the values of the two enthalpy or temperature inputs and positions the dampers to provide the maximum efficiency possible.

•Power Exhaust (Downflow only) - This accessory installs in the unit with a down flow economizer.

•Motorized Outdoor Air Damper - The motorized outdoor air damper includes a slide-in/plug-in damper assembly with an outdoor air hood and filters. The outdoor air dampers open to the preset position when the indoor fan motor is energized. The damper has a range of 0% to 100% outdoor air entry. Factory installed option or field installed accessory.

•Alternate Indoor Blower Motor - For applications with high static restrictions, units are offered with optional indoor motors that provide higher static output and/or higher airflow, depending upon the installer’s needs.

•Aluminized Steel Gas Heat Exchanger - For applications in non-corrosive environments.

•Stainless Steel Gas Heat Exchanger - For applications in corrosive environments, this option provides a full stainless steel heat exchanger assembly.

•Stainless Steel Drain Pan - An optional rust-proof stainless steel drain pan is available to provide years of trou- ble-free operation in corrosive environments.

•Electric Heaters - The electric heaters range from 9kW to 54kW and are available in all the voltage options of the base units. All heaters are dual staged. All heaters are intended for single point power supply.

•Disconnect Switch - For gas heat units and cooling units with electric heat, a HACR breaker sized to the unit is provided. For cooling only units, a switch sized to the largest electric heat available for the particular unit is provided. Factory installed option only.

•Convenience Outlet - (Non-Powered/Powered) - This option locates a 120V single-phase GFCI outlet with cover, on the corner of the unit housing adjacent to the compressors. The “Non-powered” option requires the installer to provide the 120V single-phase power source and wiring. The “Powered” option is powered by a stepdown transformer in the unit. Factory installed option only.

•Smoke Detectors - The smoke detectors stop operation of the unit by interrupting power to the control board if smoke is detected within the air compartment. Available for both the supply and/or return air.

Factory installed smoke detectors in the return air, may be subjected to freezing temperatures during "off" times due to out side air infiltration. These smoke detectors have an operational limit of 32 °F to 131°F. Smoke detectors installed in areas that could be out side those limitations will have to be moved to prevent having false alarms.

Unitary Products Group

5

•Phase Monitors - Designed to prevent unit damage. The phase monitor will shut the unit down in an out-of phase condition. (Standard on units with Scroll Compressors.)

•Coil Guard - Customers can purchase a coil guard kit to protect the condenser coil from damage. Additionally, this kit stops animals and foreign objects from entering the space between the inner condenser coil and the main cabinet. This is not a hail guard kit.

•Dirty Filter Switch - This kit includes a differential pressure switch that energizes the fault light on the unit thermostat, indicating that there is an abnormally high pressure drop across the filters. Factory installed option or field installed accessory.

•Technicoat Condenser Coils - The condenser coils are coated with a phenolic coating for protection against corrosion due to harsh environments.

•Technicoat Evaporator Coil - The evaporator coils are coated with a phenolic coating for protection against corrosion due to harsh environments.

•BAS - Building Automation System Controls Simplicity™ INTELLI-Comfort™ Control - The York® Simplicity™ INTELLI-Comfort™ control is factory installed. It includes a supply air sensor, a return air sensor, and an outside air sensor. There are provisions for a field installed dirty filter indicator switch, an air-proving switch, an Outside Air Humidity sensor, a Return Air Humidity sensor, an Inside IAQ sensor, and an Outside Air IAQ sensor. Construction mode operation, 365-day real time clock with 7 day programming plus holiday scheduling is built-in. Two different modes of demand ventilation are

achieved through the INTELLI-Comfort™ using CO2 sensors. It uses an inside CO2 sensor to perform Demand Ventilation. It can also use an Outside CO2 sensor to perform Differential Demand Ventilation. It uses a Patented Comfort Ventilation algorithm to provide comfortable ventilation air temperature. The patented econo- mizer-loading algorithm will protect the equipment when harsh operating conditions exist. Humidity in the occupied space or return duct can be monitored and controlled via humidity sensors and the on-board connection for hot gas re-heat system. It uses the INTELLI-Start™ algorithm to maximize energy savings by recovering the building from the Unoccupied Setpoints to the Occupied Setpoints just in time for the Occupied Time Period to begin. The Simplicity™ INTELLI-Comfort™ balances

space temperature, ventilation air temperature, CO2 and humidity for ultimate comfort.

•Simplicity™ INTELLI-Comfort™ with ModLINC Control - The York® Simplicity™ INTELLI-Comfort™ with ModLINC control is factory installed. It includes all the features of the INTELLI-Comfort™ control with an additional control to translate communications from MODBUS to the BACnet MSTP protocol.

•Novar® BAS Control - The Novar® ETC-3 building automation system controller is factory installed. Incudes

246646-YTG-C-0606

supply air sensor, return air sensor, dirty filter indicator switch, and air proving switch.

•Johnson Controls BAS Control - The Johnson Control YK-UNT-1126 building automation system controller is factory installed. Includes supply air sensor, return air sensor, dirty filter indicator switch, and air proving switch.

•CPC BAS Control - The Computer Process Controls Model 810-3060 ARTC Advanced Rooftop building automation system controller is factory installed. Includes supply air sensor, return air sensor, dirty filter indicator switch and air proving switch.

•Honeywell BAS Control - The Honeywell W7750C building automation system controller is factory installed. Includes air supply sensor, return air sensor, dirty filter indicator switch, and air proving switch.

FIELD INSTALLED ACCESSORIES

YORK® offers several equipment accessories for field installation, for the Predator® line.

•Downflow Economizer - (With barometric relief) - The economizer is provided with a single enthalpy input. The economizer is 2% low leakage type. The economizer has spring return, fully modulating damper actuators and is capable of introducing up to 100% outdoor air. As the outdoor air intake dampers open, the return air dampers close. The changeover from mechanical refrigeration to economizer operation is regulated by the standard single enthalpy input. There is an optional input dual dry bulb available. To meet regulated air standards, the econo-

mizer control accepts an optional CO2 input for demand ventilation. With single enthalpy input, the economizer control monitors outdoor air. The dual enthalpy kit provides a second input used to monitor the return air. With a dual input kit installed, the economizer control compares the values of the two enthalpy or temperature inputs and positions the dampers to provide the maximum efficiency possible

•Horizontal Economizer - (Without barometric relief) - All features of the downflow economizer exist except you must order the duct mount barometric relief separately.

You must order a 1EH0408 if you are installing a power exhaust. You can order a 1RD0411 Barometric Relief for horizontal flow economizer.

•Slab Economizer for Energy Recovery Ventilator- (Without barometric relief or Fresh Air Hood) - The economizer is provided with a single enthalpy input. The economizer is 2% low leakage type. The economizer has spring return, fully modulating damper actuators and is capable of introducing up to 100% outdoor air. As the outdoor air intake dampers open, the return air dampers close. The changeover from mechanical refrigeration to economizer operation is regulated by the standard single enthalpy input. There is an optional input dual dry bulb available. To meet regulated air standards, the economizer control accepts an optional CO2 input for demand

6	Unitary Products Group

246646-YTG-C-0606

ventilation.With single enthalpy input, the economizer control monitors outdoor air. The dual enthalpy kit provides a second input used to monitor the return air. With a dual input kit installed, the economizer control compares the values of the two enthalpy or temperature inputs and positions the dampers to provide the maximum efficiency possible.

You can order 1EH0409 Barometric Relief/FA Hood for field installations without an ERV.

•Dual Enthalpy Control, Accessory - This kit contains the required components to convert a single enthalpy economizer to dual enthalpy.

•Barometric Relief Damper - Zero to 100% capacity barometric relief dampers for use with horizontal flow, or field installed slab economizers.

•Power Exhaust - This accessory installs in the unit with a down flow economizer. Power exhaust plugs into the connector in the unit bulkhead. You must purchase

1EH0408 barometric relief when applying to a horizontal flow application.

•Manual Outdoor Air Damper - Like the motorized outdoor air damper, each manual outdoor air damper includes a slide-in damper assembly with an outdoor air hood and filters. Customers have a choice of dampers with ranges of 0% to 100% or 0% to 35% outdoor air entry.

•Motorized Outdoor Air Damper - The motorized outdoor air damper includes a slide-in/plug-in damper assembly with an outdoor air hood and filters. The outdoor air dampers open to the preset position when the indoor fan motor is energized. The damper has a range of 0% to 100% outdoor air entry. Factory installed option or field installed accessory.

•Smoke Detectors - The smoke detectors stop operation of the unit by interrupting power to the control board if smoke is detected within the air compartment.

•CO2 Sensor - Senses CO2 levels and automatically overrides the economizer when levels rise above the preset limits.

•Dirty Filter Switch - This kit includes a differential pressure switch that energizes the fault light on the unit thermostat, indicating that there is an abnormally high pressure drop across the filters.

•Coil Guard - Field installed decorative wire coil guard.

•Hail Guard - This kit includes a sloped hood which installs over the outside condenser coil and prevents damage to the coil fins from hail strikes. Field installed accessory only.

•Flue Exhaust Extension Kit - In locations with wind or weather conditions which may interfere with proper exhausting of furnace combustion products, this kit can be installed to prevent the flue exhaust from entering nearby fresh air intakes.

•-60°F Gas Heat Kit - For installations which require gas heat units to perform in low ambient temperatures, a gas section heating kit is available. This kit provides electric heat in the gas heat controls section to ensure the gas valve and controls will continue to function properly at extremely low temperatures.

•Gas Heat High Altitude Kit - This kit converts a gas heat unit to operate at high altitudes, 2,000 to 6,000 feet. Conversion kits are available for natural gas and propane.

•Gas Heat Propane Conversion Kit - This kit converts a gas-fired heater from natural gas to propane. It contains the main burner orifices and gas valve replacement springs.

•Gas Piping Kit - Contains pipe nipples, fittings and gas cock required for gas supply connection with external shut off.

•Electric Heaters - The electric heaters range from 9 kW to 54kW and are available in all the voltage options of the base units. All heaters are dual staged. Cooling units include an adapter panel for easy installation of the electric heaters. Necessary hardware and connectors are included with the heaters. All heaters are intended for single point power supply.

•Low Limit / Compressor Lockout Kit

1.Compressor Lockout (CLO): To prevent mechanical (compressorized) operation of the unit during cold outdoor conditions where there is a risk of returning liquid refrigerant back to the compressors.

2.Low Limit Control (LLC): To prevent the supply air from dropping below a specified setpoint by utilizing the units first stage heating means when there is a demand for cooling during cold outside conditions.

•Metal Frame Filter Kit - Metal frame with polyester filter medium.

•Permanent Filters - Permanent filters are available.

•Roof Curbs - The roof curbs have insulated decks and are shipped disassembled The roof curbs are available in 8” and 14” heights. For applications with security concerns, burglar bars are available for the duct openings of the roof curbs.

•Roof Curb Transition - Single Piece Adapter (10” High)

- Roof curbs for transitioning from Sunline™ units to Predator® units. Fits 7.5 to 12.5 Sunline™ roof curbs only.

•Burglar Bars - Mount in the supply and return openings to prevent entry into the duct work.

•Thermostat - The units are designed to operate with 24volt electronic and electro-mechanical thermostats. All units (with or without an economizer) operate with twostage heat/two-stage cool or two-stage cooling only thermostats, depending upon unit configuration.

Unitary Products Group

7

	246646-YTG-C-0606
TABLE 1: ACCESSORIES
Part Number	Description	Weight
1RC0470	Roof Curb, 8" Height	-
1RC0471	Roof Curb, 14" Height	-
1RC0472	Roof Curb, Transition (7.5 T through 12.5 T)	-
1BD0408	Burglar Bars, Downflow	-
2TP04520925	Electric Heat 9kW 230V	-
2TP04521825	Electric Heat 18kW 230V	-
2TP04522425	Electric Heat 24kW 230V	-
2TP04523625	Electric Heat 36kW 230V	-
2TP04525425	Electric Heat 54kW 230V	-
2TP04520946	Electric Heat 9kW 460V	-
2TP04521846	Electric Heat 18kW 460V	-
2TP04522446	Electric Heat 24kW 460V	-
2TP04523646	Electric Heat 36kW 460V	-
2TP04525446	Electric Heat 54kW 460V	-
2TP04520958	Electric Heat 9kW 575V	-
2TP04521858	Electric Heat 18kW 575V	-
2TP04522458	Electric Heat 24kW 575V	-
2TP04523658	Electric Heat 36kW 575V	-
2TP04525458	Electric Heat 54kW 575V	-
2TP04540925	Electric Heat 9kW 230V, 42" Tall Cabinet	-
2TP04541825	Electric Heat 18kW 230V, 42" Tall Cabinet	-
2TP04542425	Electric Heat 24kW 230V, 42" Tall Cabinet	-
2TP04543625	Electric Heat 36kW 230V, 42" Tall Cabinet	-
2TP04540946	Electric Heat 9kW 460V, 42" Tall Cabinet	-
2TP04541846	Electric Heat 18kW 460V, 42" Tall Cabinet	-
2TP04542446	Electric Heat 24kW 460V, 42" Tall Cabinet	-
2TP04543646	Electric Heat 36kW 460V, 42" Tall Cabinet	-
2TP04540958	Electric Heat 9kW 575V, 42" Tall Cabinet	-
2TP04541858	Electric Heat 18kW 575V, 42" Tall Cabinet	-
2TP04542458	Electric Heat 24kW 575V, 42" Tall Cabinet	-
2TP04543658	Electric Heat 36kW 575V, 42" Tall Cabinet	-
1FA0411	Manual Outside Air Damper 0-35%, Downflow (Incl. Hood, Damper & Filters, No Barometric Relief)	-
1FA0412	Manual Outside Air Damper 0-100%, Downflow (Incl. Hood, Damper & Filters, No Barometric Relief)	-
2MD04702724	Motorized Damper, Downflow (Incl. Hood, Damper & Filter, no Barometric Relief)	-
2MD04703324	Motorized Damper, Horizontal (Incl. Hood, Damper & Filter, no Barometric Relief)
2EE04705424	Economizer, Downflow (Incl. Barometric Relief & All Hoods)	124 lbs.
2EE04705524	Economizer, Horizontal (Incl. Dampers & Hoods, no Barometric Relief)	97 lbs.
2EE04705224	Economizer, Slab, Downflow (Incl. Dampers only no Hoods or Barometric Relief)
2EE04705624	"Downflow Economizer, Slab type for ERV (no Barometric Relief or FA hood)", 42" Tall Cabinet	-
2PE04703225	Power Exhaust, Downflow, 230V (For Units with Economizer only)	-
2PE04703246	Power Exhaust, Downflow, 460V(For Units with Economizer only)	-
2PE04703258	Power Exhaust, Downflow, 580V (For Units with Economizer only)	-
2EC04700924	Dual Enthalpy Control (Use with Single Enthalpy Economizer)	-
1EH0407	Hood Kit, Downflow Economizer (Included with all Downflow Economizers)
1RD0411	Barometric Relief Kit, Ductmount for Horizontal Application (Incl. Damper & Hood)
1EH0408	Barometric Relief Kit, Ductmount for Horizontal Application w/Power Exhaust (Incl. Damper & Hood)	25 lbs.
1EH0409	Barometric Relief / Hood Kit, for Field Installed Slab Econ. w/o ERV (Incl. Barometric Relief & FA Hood)	-
2AQ04700424	CO2 Detector Unit Mount	-
2AQ04700324	CO2 Detector Space Mount	-
2SD04700424	Smoke Detector, Supply or Return (Return Not Available with Horizontal Economizer)	-
2MK04700624	Low Limit / Compressor Lockout Kit
1CG0419	Coil Guard (Electric / Electric & HP models)	-

8	Unitary Products Group

246646-YTG-C-0606

TABLE 1: ACCESSORIES (CONTINUED)

Part Number	Description	Weight
1CG0420	Coil Guard (Gas / Electric models)	-
1CG0427	Coil Guard (Electric / Electric & HP Models), 42" Tall Cabinet	-
1CG0428	Coil Guard (Gas / Electric Models), 42" Tall Cabinet	-
1HG0411	Hail Guard Kit	-
1HG0415	Hail Guard Kit, 42" Tall Cabinet	-
1GP0405	Gas Piping Kit	-
1NP0442	Propane Conversion Kit	-
1HA0442	High Altitude Kit for Natural Gas	-
1HA0443	High Altitude Kit for Propane	-
1FE0412	Flue Exhaust Extension Kit	-
2BC04700106	Gas Heat Kit, -60 deg F, 230V	-
2BC04700151	Gas Heat Kit, -60 deg F, 460V	-
2BC04700154	Gas Heat Kit, -60 deg F, 575V	-
1FL0402	Permanent Filter Kit	-
1FL0423	Permanent Filter Kit, 42" Tall Cabinet	-
2DF0401	Dirty Filter Switch	-
1FF0410	Filter Frame Kit, Metal	-
1FF0411	Metal Filter Frame Kit, 42" Tall Cabinet	-

Unitary Products Group

9

246646-YTG-C-0606

NOMENCLATURE

6.5-12.5 Ton York® Model Number Nomenclature

D H 090 N10 A 2 A AA 3 0 1 2 4 A

Product Category

D = A/C, Single Pkg., R-22

Product Identifier

H = 11.0+ EER A/C

Nominal Cooling Capacity

078 = 6.5 Ton

090 = 7.5 Ton

102 = 8.5 Ton

120 = 10.0 Ton

150 = 12.5 Ton

Heat Type and Nominal Heat Capacity

C00 = Cooling Only. No heat installed

Gas Heat Options

N10 = 100 MBH Output Aluminized Steel

N15 = 150 MBH Output Aluminized Steel

N20 = 200 MBH Output Aluminized Steel

S10 = 100 MBH Output Stainless Steel

S15 = 150 MBH Output Stainless Steel

S20 = 200 MBH Output Stainless Steel

Electric Heat Options

E09 = 9 KW

E18 = 18 KW

E24 = 24 KW

E36 = 36 KW

E54 = 54 KW

Airflow

A = Std. Motor

B = Std. Motor/Econo./Barometric Relief (Downflow

Only)

C = Std. Motor/Econo./Power Exhaust (Downflow Only)

D = Std. Motor/Motorized Damper (Downflow Only)

E = Std. Motor/Horizontal Economizer (No Baro.)

F = Std. Motor/Slab Econo./Power Exhaust

(Downflow Only)

G = Std. Motor/Slab Econo./Barometric Relief

(Downflow Only)

N = Hi Static Mtr.

P = Hi Static Mtr./Econo./Barometric Relief

(Downflow Only)

Q = Hi Static Mtr./Econo./Power Exhaust

(Downflow Only)

R = Hi Static Mtr./Motorized Damper (Downflow Only)

S = Hi Static Mtr./Horizontal Economizer (No Baro.)

T = Hi Static Mtr./Slab Econo./Power Exhaust

(Downflow Only)

U = Hi Static Mtr./Slab Econo./Barometric Relief

(Downflow only)

Voltage

2 = 208/230-3-60

4 = 460-3-60

5 = 575-3-60

Product Style

A = Style A

B = Style B

C = Style C

Configuration Options (not required for all units)

These four digits will not be assigned until a quote is requested, or an order placed.

SS Drain Pan

CPC Controller, DFS, APS

Johnson Controller, DFS, APS

Honeywell Controller, DFS, APS

Novar Controller, DFS, APS

Simplicity IntelliComfort Controller

Simplicity IntelliComfort Controller w/ModLinc

2" Pleated filters

BAS Ready Unit with Belimo Economizer

Shipping Bag

Any Combination of Additional Options that Don’t Have an Option Code Pre-assigned

Product Generation

3 = Third Generation

4 = Fourth Generation

5 = Fifth Generation

	Additional Options
AA = None		RC = Coil Guard, Shipping Bag & American Flag
AB = Phase Monitor		TA = Technicoat Condenser Coil
AC = Coil Guard		TJ = Technicoat Evaporator Coil
AD = Dirty Filter Switch		TS = Technicoat Evaporator & Condenser Coils
AE = Phase Monitor & Coil Guard
AF = Phase Monitor & Dirty Filter Switch
AG = Coil Guard & Dirty Filter Switch
AH = Phase Monitor, Coil Guard & Dirty Filter Switch

ZZ= If desired option combination is not listed above, ZZ will be assigned and configuration options will be located in digits 15-18.

Installation Options

A = No Options Installed

B = Option 1

C = Option 2

D = Options 1 & 2

E = Option 3

F = Option 4

G = Options 1 & 3

H = Options 1 & 4

J = Options 1, 2 & 3

K = Options 1, 2, & 4

L = Options 1,3 & 4

M = Options 1, 2, 3, & 4

N = Options 2 & 3

P = Options 2 & 4

Q = Options 2, 3, & 4

R = Options 3 & 4

S = Option 5

T = Options 1 & 5

U = Options 1, 3, & 5

V = Options 1, 4, & 5

W = Options 1, 3, 4, & 5

X = Options 3 & 5

Y = Options 4 & 5

Z = Options 3, 4 & 5

Options

1 = Disconnect

2 = Non-Pwr'd Conv. Outlet

3 = Smoke Detector S.A.

4 = Smoke Detector R.A.

5 = Pwr'd Conv. Outlet

10	Unitary Products Group

246646-YTG-C-0606

TABLE 2: DH PHYSICAL DATA

	Component				Models
			078	090	102	120	150
		Blower, Centrifugal	12 x 12	12 x 12	12 X 12	15 x 15	15 x 15
	Evaporator	(Dia. X Wd. in.)
	Blower	Motor, Standard (HP)	1-1/2	2	3	2	3
		Motor, Optional (HP)	2	3	3	3	5
		Rows	3	3	3	4	4
	Evaporator	Fins per Inch	15	15	15	15	15
	Coil	Height (in.)	32	32	32	40	40
		Face Area (ft.2 each)	10.67	10.67	10.67	13.2	13.2
		Propeller Dia.	24	24	24	24	24
	Condenser	(in., each)
	Fan
		Motor (HP, each)	1/3	1/3	1/3	3/4	3/4
	(2 per Unit)
		CFM, Nominal (each)	3400	3400	3400	4400	4400
		Rows (each)	Sys 1: 2 Row	2	2	2	2
	Condenser		Sys 2: 1 Row
	Coil	Fins per Inch	20	20	20	20	20
	(2 per unit)
		Height (in., each)	36	36	36	44	44
		Face Area (ft.2 each)	12	12	12	14.5	14.5
	Refrigerant	System 1 (lb./oz.)	8/0	8/12	9/8	12/0	9/14
	Charge	System 2 (lb./oz.)	4/12	9/0	8/2	11/0	9/4
	Compressors	Quantity	2	2	2	2	2
		Type	Recip.	Recip	Recip.	Recip	Scroll
		Size (Wd. x Ht. x	25x16x2	25x16x2	25x16x2	25x20x2	25x20x2
	Air Filters	Thickness in.)
		Number Per Unit	4	4	4	4	4

Unitary Products Group

11

246646-YTG-C-0606

TABLE 3: DH CAPACITY RATINGS

			Cooling Capacity					Nominal		Gas Heat Capacity			Gas
			ARI Ratings1				Sound
	Size							Electric
		Model				CFM	Rating	Heat					Line
	(Tons)										Seasonal	Temp.	Size
			MBH	EER	IPLV		(dB)2	Capacity3	Input	Output
											Efficiency	Rise	(in. OD)
								(kW)	(MBH)	(MBH)
											(%)	(°F)
		Cooling						-	-	-	-	-	-
		Only
	078
		Electric	75	11.5	11.90	2421	84	9, 18, 24,	-	-	-	-	-
	(6-1/2)	Heat						36
		Gas Heat						-	120	96	80	20-50	3/4
		Gas Heat						-	180	144	80	35-65	3/4
		Cooling						-	-	-	-	-	-
		Only
	090	Electric	89	11.5	12.0	3000	84	18, 36	-	-	-	-	-
	(7-1/2)	Heat
		Gas Heat						-	120	96	80	15-45	3/4
		Gas Heat						-	180	144	80	30-60	3/4
		Cooling						-	-	-	-	-	-
		Only
	102	Electric	99	11.0	11.50	2692	84	9, 18, 24,	-	-	-	-	-
	(8-1/2)	Heat						36
		Gas Heat						-	120	96	80	15-45	3/4
		Gas Heat						-	180	144	80	30-60	3/4
		Cooling						-	-	-	-	-	-
		Only
	120	Electric	115	11.0	11.70	3840	90	18, 24, 36,	-	-	-	-	-
	(10)	Heat						54
		Gas Heat						-	180	144	80	20-50	3/4
		Gas Heat						-	240	192	80	35-65	3/4
		Cooling						-	-	-	-	-	-
		Only
	150	Electric	146	10.0	10.70	4100	90	18, 24, 36,	-	-	-	-	-
	(12-1/2)	Heat						54
		Gas Heat						-	180	144	80	10-40	3/4
		Gas Heat						-	240	192	80	25-55	3/4

1Rated at 95°F ambient 80°F dry bulb and 67°F wet bulb.

2Rated in accordance with ARI 270 standard.

3See Table 20.

TABLE 4: UNIT VOLTAGE LIMITATIONS

POWER RATING	MIN.	MAX.
208/230-3-60	187	252
460-3-60	432	504
575-3-60	540	630

12	Unitary Products Group

246646-YTG-C-0606

TABLE 5: COOLING CAPACITY DH078 (6-1/2 TON) UNIT

Air On			Temperature of Air on Condenser Coil 75°F												Temperature of Air on Condenser Coil 85°F
Evap. Coil
	WB	Tot.		Tot.		Sensible Capacity (MBH)*								Tot.	Tot.		Sensible Capacity (MBH)*
CFM		Cap.1		Input2			Return Dry Bulb (°F)							Cap.1	Input2			Return Dry Bulb (°F)
	(°F)
		(MBH)		(kW)	86	83		80	77	74		71	68	(MBH)	(kW)	86	83		80	77	74		71	68
	72	88.9		4.8	51.3	45.8		40.2	34.6	29.1		-	-	84.6	5.3	49.4	43.9		38.3	32.7	27.2		-	-
1950	67	85.5		4.8	65.4	59.9		54.3	48.7	43.2		37.6	32.1	79.8	5.2	62.9	57.4		51.8	46.2	40.7		35.1	29.6
	62	80.0		4.7	80.0	73.8		68.2	62.7	57.1		51.5	46.0	74.2	5.1	74.2	69.8		64.3	58.7	53.1		47.6	42.0
	57	78.2		4.7	78.2	76.8		71.3	65.7	60.2		54.6	49.0	73.1	5.1	73.1	71.6		66.0	60.5	54.9		49.4	43.8
	72	91.3		4.8	56.3	49.7		43.2	36.6	30.0		-	-	87.1	5.3	54.5	47.9		41.4	34.8	28.2		-	-
2275	67	87.9		4.8	71.4	64.9		58.3	51.7	45.1		38.6	32.0	82.2	5.3	69.1	62.5		56.0	49.4	42.8		36.2	29.7
	62	82.2		4.7	82.2	79.1		73.3	66.7	60.1		53.5	47.0	76.4	5.2	76.4	74.2		69.4	62.8	56.3		49.7	43.1
	57	80.4		4.7	80.4	79.7		76.5	70.0	63.4		56.8	50.3	75.2	5.2	75.2	74.5		71.3	64.8	58.2		51.6	45.0
	72	93.8		4.8	61.3	53.7		46.1	38.5	30.9		-	-	89.6	5.4	59.6	52.0		44.4	36.9	29.3		-	-
2600	67	90.2		4.8	77.4	69.9		62.3	54.7	47.1		39.5	31.9	84.5	5.3	75.3	67.7		60.1	52.5	44.9		37.4	29.8
	62	84.4		4.8	84.4	84.4		78.3	70.7	63.1		55.5	47.9	78.6	5.2	78.6	78.6		74.6	67.0	59.4		51.8	44.2
	57	82.6		4.7	82.6	82.6		81.8	74.2	66.6		59.1	51.5	77.4	5.2	77.4	77.4		76.6	69.0	61.5		53.9	46.3
	72	94.5		4.8	65.3	56.6		48.0	39.4	30.7		-	-	90.5	5.4	63.7	55.1		46.5	37.8	29.2		-	-
2925	67	90.9		4.8	83.2	73.5		64.8	56.2	47.6		38.9	30.3	85.4	5.3	80.1	71.5		62.8	54.2	45.6		36.9	28.3
	62	85.0		4.8	85.0	85.0		82.0	73.3	64.7		56.0	47.4	79.4	5.2	79.4	79.4		77.4	68.8	60.1		51.5	42.9
	57	83.1		4.7	83.1	83.1		82.8	74.1	65.5		56.9	48.2	78.2	5.2	78.2	78.2		77.8	69.2	60.5		51.9	43.3
	72	95.1		4.9	69.3	59.6		49.9	40.2	30.5		-	-	91.4	5.4	67.8	58.2		48.5	38.8	29.1		-	-
3250	67	91.5		4.8	88.9	77.1		67.4	57.7	48.0		38.3	28.6	86.3	5.3	84.9	75.2		65.6	55.9	46.2		36.5	26.8
	62	85.6		4.8	85.6	85.6		85.6	75.9	66.3		56.6	46.9	80.2	5.2	80.2	80.2		80.2	70.6	60.9		51.2	41.5
	57	83.7		4.7	83.7	83.7		83.7	74.0	64.4		54.7	45.0	79.0	5.2	79.0	79.0		79.0	69.3	59.6		49.9	40.2
				Temperature of Air on Condenser Coil 95°F											Temperature of Air on Condenser Coil 105°F
	72	80.3		5.8	47.5	42.0		36.4	30.8	25.3		-	-	74.6	6.3	45.1	39.6		34.0	28.5	22.9		-	-
1950	67	74.1		5.7	60.4	54.9		49.3	43.7	38.2		32.6	27.1	67.4	6.1	57.6	52.1		46.5	40.9	35.4		29.8	24.3
	62	68.5		5.6	68.5	65.8		60.3	54.7	49.2		43.6	38.0	63.3	6.0	63.3	60.8		55.2	49.7	44.1		38.6	33.0
	57	68.0		5.6	68.0	66.4		60.8	55.2	49.7		44.1	38.6	63.0	6.1	63.0	61.2		55.6	50.1	44.5		39.0	33.4
	72	82.8		5.8	52.7	46.2		39.6	33.0	26.4		-	-	76.8	6.3	50.2	43.7		37.1	30.5	23.9		-	-
2275	67	76.5		5.7	66.8	60.2		53.6	47.0	40.5		33.9	27.3	69.4	6.2	63.0	57.3		50.7	44.1	37.6		31.0	24.4
	62	70.7		5.6	70.7	69.4		65.6	59.0	52.4		45.8	39.3	65.2	6.1	65.2	63.9		60.2	53.7	47.1		40.5	33.9
	57	70.1		5.6	70.1	69.3		66.1	59.6	53.0		46.4	39.8	64.8	6.1	64.8	63.9		60.7	54.1	47.5		40.9	34.4
	72	85.4		5.9	57.9	50.4		42.8	35.2	27.6		-	-	78.9	6.4	55.3	47.7		40.2	32.6	25.0		-	-
2600	67	78.8		5.8	73.1	65.5		57.9	50.4	42.8		35.2	27.6	71.3	6.2	68.5	62.5		54.9	47.3	39.7		32.2	24.6
	62	72.9		5.7	72.9	72.9		70.8	63.2	55.7		48.1	40.5	67.0	6.1	67.0	67.0		65.2	57.6	50.1		42.5	34.9
	57	72.2		5.7	72.2	72.2		71.5	63.9	56.3		48.7	41.1	66.6	6.2	66.6	66.6		65.7	58.1	50.5		42.9	35.3
	72	86.5		5.9	62.2	53.6		44.9	36.3	27.6		-	-	80.0	6.4	59.6	50.9		42.3	33.7	25.0		-	-
2925	67	79.9		5.8	77.0	69.5		60.8	52.2	43.6		34.9	26.3	72.3	6.3	70.8	66.0		57.8	49.2	40.6		31.9	23.3
	62	73.9		5.7	73.9	73.9		72.8	64.2	55.6		46.9	38.3	67.9	6.2	67.9	67.9		67.0	58.4	49.7		41.1	32.5
	57	73.2		5.7	73.2	73.2		72.8	64.2	55.6		46.9	38.3	67.5	6.2	67.5	67.5		67.0	58.4	49.7		41.1	32.5
	72	87.7		5.9	66.4	56.7		47.1	37.4	27.7		-	-	81.0	6.4	63.8	54.1		44.4	34.8	25.1		-	-
3250	67	81.0		5.8	81.0	73.4		63.7	54.0	44.4		34.7	25.0	73.2	6.3	73.2	69.4		60.8	51.1	41.4		31.7	22.0
	62	74.9		5.7	74.9	74.9		74.9	65.2	55.5		45.8	36.1	68.8	6.2	68.8	68.8		68.8	59.1	49.4		39.7	30.0
	57	74.2		5.7	74.2	74.2		74.2	64.5	54.9		45.2	35.5	68.4	6.2	68.4	68.4		68.4	58.7	49.0		39.3	29.6
				Temperature of Air on Condenser Coil 115°F											Temperature of Air on Condenser Coil 125°F
	72	69.0		6.8	42.8	37.2		31.6	26.1	20.5		-	-	63.3	7.3	40.4	34.8		29.2	23.7	18.1		-	-
1950	67	60.7		6.6	54.8	49.3		43.7	38.2	32.6		27.0	21.5	54.0	7.1	52.0	46.5		40.9	35.4	29.8		24.2	18.7
	62	58.2		6.5	58.2	55.8		50.2	44.7	39.1		33.5	28.0	53.0	7.0	53.0	50.7		45.2	39.6	34.1		28.5	23.0
	57	58.0		6.6	58.0	56.0		50.5	44.9	39.3		33.8	28.2	53.0	7.1	53.0	50.9		45.3	39.7	34.2		28.6	23.1
	72	70.7		6.8	47.7	41.2		34.6	28.0	21.4		-	-	64.6	7.4	45.2	38.7		32.1	25.5	18.9		-	-
2275	67	62.3		6.7	59.3	54.4		47.8	41.2	34.7		28.1	21.5	55.2	7.1	55.2	51.5		44.9	38.3	31.8		25.2	18.6
	62	59.6		6.6	59.6	58.5		54.9	48.3	41.8		35.2	28.6	54.1	7.1	54.1	53.0		49.6	43.0	36.4		29.9	23.3
	57	59.4		6.7	59.4	58.5		55.2	48.6	42.0		35.5	28.9	54.1	7.2	54.1	53.1		49.7	43.1	36.6		30.0	23.4
	72	72.5		6.9	52.7	45.1		37.5	30.0	22.4		-	-	66.0	7.4	50.1	42.5		34.9	27.3	19.8		-	-
2600	67	63.8		6.7	63.8	59.5		51.9	44.3	36.7		29.1	21.6	56.3	7.2	56.3	56.3		48.9	41.3	33.7		26.1	18.5
	62	61.1		6.6	61.1	61.1		59.6	52.0	44.4		36.9	29.3	55.3	7.1	55.3	55.3		54.0	46.4	38.8		31.2	23.7
	57	60.9		6.7	60.9	60.9		59.9	52.3	44.7		37.2	29.6	55.3	7.2	55.3	55.3		54.1	46.5	39.0		31.4	23.8
	72	73.4		6.9	57.0	48.3		39.7	31.0	22.4		-	-	66.8	7.5	54.3	45.7		37.1	28.4	19.8		-	-
2925	67	64.6		6.7	64.6	62.5		54.8	46.2	37.6		28.9	20.3	57.0	7.2	57.0	57.0		51.8	43.2	34.6		25.9	17.3
	62	61.9		6.7	61.9	61.9		61.2	52.5	43.9		35.2	26.6	55.9	7.1	55.9	55.9		55.3	46.7	38.0		29.4	20.8
	57	61.7		6.7	61.7	61.7		61.2	52.6	43.9		35.3	26.7	55.9	7.3	55.9	55.9		55.4	46.7	38.1		29.5	20.8
	72	74.3		7.0	61.2	51.5		41.8	32.1	22.4		-	-	67.6	7.5	58.6	48.9		39.2	29.5	19.8		-	-
3250	67	65.5		6.8	65.5	65.5		57.8	48.1	38.4		28.7	19.0	57.7	7.3	57.7	57.7		54.8	45.1	35.5		25.8	16.1
	62	62.7		6.7	62.7	62.7		62.7	53.0	43.3		33.6	23.9	56.6	7.2	56.6	56.6		56.6	46.9	37.2		27.6	17.9
	57	62.5		6.8	62.5	62.5		62.5	52.8	43.1		33.4	23.7	56.6	7.3	56.6	56.6		56.6	46.9	37.2		27.6	17.9

1These capacities are gross ratings. For net capacity, deduct air blower motor, MBh = 3.415 x kW. Refer to the appropriate Blower Performance Table for the kW of the supply air blower motor.

2These ratings include the condenser fan motors (total 1 kW) and the compressor motors but not the supply air blower motor.

Unitary Products Group

13

																		246646-YTG-C-0606
TABLE 6: COOLING CAPACITY DH090 (7-1/2 TON) UNIT
Air On			Temperature of Air on Condenser Coil 75°F									Temperature of Air on Condenser Coil 85°F
Evap. Coil
	WB	Tot.	Tot.		Sensible Capacity (MBH)*							Tot.		Tot.		Sensible Capacity (MBH)*
CFM		Cap.1	Input2		Return Dry Bulb (°F)							Cap.1		Input2		Return Dry Bulb (°F)
	(°F)
		(MBH)	(kW)	86	83	80	77	74		71	68	(MBH)		(kW)	86	83	80	77	74	71	68
	72	102.7	5.7	60.1	53.7	47.3	40.9	34.5		-	-	98.5		6.2	58.2	51.8	45.4	39.0	32.5	-	-
2250	67	98.7	5.6	75.6	69.2	62.8	56.4	50.0		43.5	37.1	93.0		6.1	73.4	67.0	60.5	54.1	47.7	41.3	34.9
	62	95.0	5.6	95.0	87.3	80.9	74.5	68.0		61.6	55.2	88.7		6.1	88.7	82.4	76.0	69.6	63.2	56.8	50.4
	57	96.7	5.5	96.7	90.6	84.1	77.7	71.3		64.9	58.5	88.4		6.0	88.4	84.3	77.9	71.5	65.0	58.6	52.2
	72	105.1	5.7	65.5	57.9	50.3	42.8	35.2		-	-	100.9		6.2	63.8	56.2	48.6	41.1	33.5	-	-
2625	67	101.0	5.6	82.0	74.4	66.8	59.2	51.6		44.0	36.5	95.2		6.1	80.1	72.5	64.9	57.3	49.7	42.2	34.6
	62	97.2	5.6	97.2	93.4	86.1	78.5	70.9		63.3	55.7	90.8		6.1	90.8	87.7	81.5	73.9	66.3	58.8	51.2
	57	98.9	5.5	98.9	95.9	89.6	82.0	74.4		66.8	59.2	90.5		6.1	90.5	88.5	83.5	75.9	68.3	60.7	53.2
	72	107.5	5.7	70.9	62.1	53.4	44.6	35.9		-	-	103.2		6.3	69.4	60.7	51.9	43.2	34.4	-	-
3000	67	103.3	5.6	88.3	79.5	70.8	62.0	53.3		44.5	35.8	97.4		6.2	86.8	78.0	69.3	60.5	51.8	43.0	34.3
	62	99.4	5.6	99.4	99.4	91.2	82.5	73.8		65.0	56.3	92.9		6.1	92.9	92.9	87.0	78.2	69.5	60.7	52.0
	57	101.2	5.5	101.2	101.2	95.0	86.2	77.5		68.7	60.0	92.6		6.1	92.6	92.6	89.1	80.3	71.6	62.8	54.1
	72	108.5	5.7	75.3	65.4	55.4	45.4	35.5		-	-	104.6		6.3	74.2	64.3	54.3	44.3	34.4	-	-
3375	67	104.3	5.6	94.8	83.4	73.5	63.5	53.6		43.6	33.6	98.7		6.2	92.4	82.4	72.5	62.5	52.5	42.6	32.6
	62	100.4	5.6	100.4	100.4	95.9	85.9	76.0		66.0	56.0	94.2		6.1	94.2	94.2	91.0	81.0	71.0	61.1	51.1
	57	102.2	5.5	102.2	102.2	99.1	89.2	79.2		69.2	59.3	93.9		6.1	93.9	93.9	92.1	82.1	72.2	62.2	52.3
	72	109.6	5.7	79.8	68.6	57.4	46.2	35.1		-	-	106.0		6.3	79.0	67.9	56.7	45.5	34.3	-	-
3750	67	105.4	5.6	101.3	87.3	76.2	65.0	53.8		42.6	31.5	100.1		6.2	98.0	86.8	75.6	64.5	53.3	42.1	30.9
	62	101.4	5.6	101.4	101.4	100.5	89.4	78.2		67.0	55.8	95.4		6.1	95.4	95.4	95.0	83.8	72.6	61.4	50.3
	57	103.3	5.5	103.3	103.3	103.3	92.1	80.9		69.7	58.6	95.1		6.1	95.1	95.1	95.1	83.9	72.8	61.6	50.4
			Temperature of Air on Condenser Coil 95°F										Temperature of Air on Condenser Coil 105°F
	72	94.3	6.7	56.3	49.8	43.4	37.0	30.6		-	-	87.5		7.3	53.7	47.2	40.8	34.4	28.0	-	-
2250	67	87.3	6.7	71.1	64.7	58.3	51.9	45.5		39.1	32.7	79.7		7.2	67.8	61.4	55.0	48.6	42.2	35.8	29.4
	62	82.4	6.5	82.4	77.6	71.2	64.8	58.4		51.9	45.5	76.0		7.1	76.0	71.7	65.3	58.9	52.4	46.0	39.6
	57	80.1	6.5	80.1	78.0	71.6	65.2	58.8		52.4	46.0	74.0		7.1	74.0	72.0	65.6	59.2	52.7	46.3	39.9
	72	96.6	6.8	62.1	54.5	46.9	39.4	31.8		-	-	89.8		7.4	59.6	52.0	44.4	36.8	29.3	-	-
2625	67	89.4	6.7	78.2	70.6	63.0	55.4	47.9		40.3	32.7	81.8		7.2	74.3	67.4	59.9	52.3	44.7	37.1	29.5
	62	84.4	6.6	84.4	82.0	76.9	69.4	61.8		54.2	46.6	78.0		7.1	78.0	75.8	71.0	63.4	55.8	48.3	40.7
	57	82.1	6.6	82.1	81.0	77.4	69.8	62.2		54.7	47.1	75.9		7.1	75.9	74.9	71.3	63.8	56.2	48.6	41.0
	72	98.9	6.8	67.9	59.2	50.5	41.7	33.0		-	-	92.1		7.4	65.5	56.8	48.0	39.3	30.5	-	-
3000	67	91.5	6.7	85.2	76.5	67.7	59.0	50.2		41.5	32.8	83.8		7.3	80.7	73.5	64.7	56.0	47.2	38.5	29.7
	62	86.4	6.6	86.4	86.4	82.7	73.9	65.2		56.4	47.7	80.0		7.2	80.0	80.0	76.7	68.0	59.2	50.5	41.7
	57	84.0	6.6	84.0	84.0	83.2	74.4	65.7		57.0	48.2	77.8		7.2	77.8	77.8	77.1	68.3	59.6	50.8	42.1
	72	100.6	6.9	73.1	63.2	53.2	43.2	33.3		-	-	93.4		7.4	70.8	60.8	50.8	40.9	30.9	-	-
3375	67	93.1	6.8	90.0	81.4	71.4	61.5	51.5		41.5	31.6	85.1		7.3	83.5	77.8	68.5	58.6	48.6	38.6	28.7
	62	87.9	6.7	87.9	87.9	86.1	76.1	66.1		56.2	46.2	81.2		7.2	81.2	81.2	79.6	69.6	59.6	49.7	39.7
	57	85.5	6.6	85.5	85.5	85.1	75.1	65.2		55.2	45.2	79.0		7.2	79.0	79.0	78.6	68.7	58.7	48.7	38.8
	72	102.4	6.9	78.3	67.1	55.9	44.8	33.6		-	-	94.8		7.5	76.0	64.9	53.7	42.5	31.3	-	-
3750	67	94.7	6.8	94.7	86.3	75.1	63.9	52.8		41.6	30.4	86.4		7.3	86.4	82.2	72.4	61.2	50.0	38.8	27.6
	62	89.4	6.7	89.4	89.4	89.4	78.2	67.1		55.9	44.7	82.4		7.2	82.4	82.4	82.4	71.2	60.0	48.9	37.7
	57	87.0	6.7	87.0	87.0	87.0	75.8	64.6		53.4	42.2	80.2		7.2	80.2	80.2	80.2	69.0	57.8	46.6	35.5
			Temperature of Air on Condenser Coil 115°F										Temperature of Air on Condenser Coil 125°F
	72	80.6	7.9	51.1	44.6	38.2	31.8	25.4		-	-	73.7		8.4	48.4	42.0	35.6	29.2	22.8	-	-
2250	67	72.0	7.7	64.6	58.1	51.7	45.3	38.9		32.5	26.1	64.4		8.2	61.3	54.8	48.4	42.0	35.6	29.2	22.8
	62	69.6	7.6	69.6	65.8	59.4	52.9	46.5		40.1	33.7	63.2		8.1	63.2	59.9	53.5	47.0	40.6	34.2	27.8
	57	67.8	7.6	67.8	66.0	59.5	53.1	46.7		40.3	33.9	61.6		8.2	61.6	59.9	53.5	47.1	40.7	34.3	27.8
	72	82.9	7.9	57.1	49.5	41.9	34.3	26.7		-	-	76.0		8.5	54.5	47.0	39.4	31.8	24.2	-	-
2625	67	74.1	7.7	70.3	64.3	56.7	49.1	41.5		34.0	26.4	66.4		8.2	66.4	61.1	53.5	46.0	38.4	30.8	23.2
	62	71.6	7.7	71.6	69.7	65.1	57.5	49.9		42.3	34.7	65.2		8.2	65.2	63.5	59.1	51.6	44.0	36.4	28.8
	57	69.7	7.7	69.7	68.8	65.3	57.7	50.1		42.5	34.9	63.5		8.2	63.5	62.7	59.2	51.6	44.0	36.4	28.9
	72	85.2	8.0	63.1	54.3	45.6	36.8	28.1		-	-	78.3		8.5	60.6	51.9	43.1	34.4	25.6	-	-
3000	67	76.1	7.8	76.1	70.4	61.7	52.9	44.2		35.4	26.7	68.4		8.3	68.4	67.4	58.6	49.9	41.1	32.4	23.6
	62	73.6	7.7	73.6	73.6	70.8	62.0	53.3		44.5	35.8	67.2		8.2	67.2	67.2	64.8	56.1	47.3	38.6	29.8
	57	71.6	7.7	71.6	71.6	71.0	62.2	53.5		44.7	36.0	65.4		8.3	65.4	65.4	64.9	56.1	47.4	38.6	29.9
	72	86.2	8.0	68.4	58.5	48.5	38.5	28.6		-	-	79.0		8.6	66.1	56.1	46.1	36.2	26.2	-	-
3375	67	77.1	7.8	77.1	74.2	65.6	55.7	45.7		35.7	25.8	69.0		8.4	69.0	69.0	62.7	52.8	42.8	32.8	22.9
	62	74.5	7.7	74.5	74.5	73.1	63.1	53.2		43.2	33.2	67.8		8.3	67.8	67.8	66.6	56.6	46.7	36.7	26.8
	57	72.5	7.8	72.5	72.5	72.2	62.2	52.3		42.3	32.3	66.0		8.3	66.0	66.0	65.8	55.8	45.8	35.9	25.9
	72	87.3	8.1	73.8	62.6	51.4	40.2	29.1		-	-	79.7		8.7	71.5	60.3	49.2	38.0	26.8	-	-
3750	67	78.0	7.9	78.0	78.0	69.6	58.4	47.2		36.1	24.9	69.7		8.4	69.7	69.7	66.8	55.6	44.5	33.3	22.1
	62	75.4	7.8	75.4	75.4	75.4	64.2	53.0		41.9	30.7	68.4		8.3	68.4	68.4	68.4	57.2	46.0	34.8	23.7
	57	73.4	7.8	73.4	73.4	73.4	62.2	51.0		39.9	28.7	66.6		8.4	66.6	66.6	66.6	55.4	44.3	33.1	21.9

1These capacities are gross ratings. For net capacity, deduct air blower motor, MBh = 3.415 x kW. Refer to the appropriate Blower Performance Table for the kW of the supply air blower motor.

2These ratings include the condenser fan motors (total 1 kW) and the compressor motors but not the supply air blower motor.

14	Unitary Products Group

246646-YTG-C-0606

TABLE 7: COOLING CAPACITY DH102 (8-1/2 TON) UNIT

Air On			Temperature of Air on Condenser Coil 75°F												Temperature of Air on Condenser Coil 85°F
Evap. Coil
	WB	Tot.		Tot.		Sensible Capacity (MBH)*								Tot.	Tot.		Sensible Capacity (MBH)*
CFM		Cap.1		Input2			Return Dry Bulb (°F)							Cap.1	Input2			Return Dry Bulb (°F)
	(°F)
		(MBH)		(kW)	86	83		80	77	74		71	68	(MBH)	(kW)	86	83		80	77	74		71	68
	72	117.0		1.8	66.8	59.5		52.2	44.9	37.7		-	-	112.5	7.6	64.3	57.0		49.8	42.5	35.2		-	-
2550	67	112.1		1.9	85.1	77.8		70.5	63.2	56.0		48.7	41.4	106.1	7.5	82.2	74.9		67.7	60.4	53.1		45.8	38.6
	62	104.1		2.0	104.	99.2		92.0	84.7	77.4		70.2	62.9	98.1	7.4	98.1	93.4		86.1	78.8	71.6		64.3	57.0
	57	104.5		1.9	104.	103.		96.0	88.7	81.5		74.2	66.9	97.5	7.4	97.5	96.7		89.4	82.2	74.9		67.6	60.4
	72	120.7		4.3	72.7	64.1		55.5	46.9	38.3		-	-	116.0	7.6	70.5	61.9		53.3	44.7	36.1		-	-
2975	67	115.7		4.3	92.1	83.5		75.0	66.4	57.8		49.2	40.6	109.4	7.5	89.6	81.0		72.4	63.9	55.3		46.7	38.1
	62	107.5		4.4	107.	105.		97.8	89.2	80.6		72.0	63.4	101.1	7.4	101.	98.8		92.2	83.6	75.0		66.4	57.8
	57	107.8		4.4	107.	107.		102.	93.5	84.9		76.3	67.7	100.6	7.4	100.	100.		95.8	87.2	78.6		70.0	61.4
	72	124.5		6.8	78.6	68.7		58.8	48.9	39.0		-	-	119.6	7.6	76.6	66.7		56.8	46.9	37.0		-	-
3400	67	119.3		6.8	99.2	89.3		79.4	69.5	59.6		49.6	39.7	112.7	7.5	97.1	87.1		77.2	67.3	57.4		47.5	37.6
	62	110.8		6.9	110.	110.		103.	93.7	83.8		73.9	63.9	104.2	7.4	104.	104.		98.3	88.4	78.5		68.6	58.6
	57	111.2		6.8	111.	111.		108.	98.3	88.3		78.4	68.5	103.7	7.4	103.	103.		102.	92.2	82.3		72.4	62.4
	72	125.4		6.9	83.4	72.2		60.9	49.6	38.3		-	-	120.8	7.7	81.8	70.5		59.2	47.9	36.6		-	-
3825	67	120.2		6.9	104.	93.5		82.2	70.9	59.6		48.3	37.0	113.9	7.6	103.	91.8		80.5	69.2	57.9		46.6	35.4
	62	111.6		6.9	111.	111.		108.	96.7	85.4		74.1	62.8	105.3	7.5	105.	105.		102.	91.1	79.8		68.5	57.2
	57	112.0		6.9	112.	112.		110.	99.2	87.9		76.6	65.3	104.7	7.5	104.	104.		104.	92.7	81.4		70.1	58.8
	72	126.3		6.9	88.3	75.6		62.9	50.3	37.6		-	-	122.1	7.7	87.0	74.3		61.6	49.0	36.3		-	-
4250	67	121.0		6.9	110.	97.6		85.0	72.3	59.6		46.9	34.3	115.1	7.6	109.	96.5		83.8	71.1	58.5		45.8	33.1
	62	112.4		7.0	112.	112.		112.	99.8	87.1		74.4	61.8	106.4	7.5	106.	106.		106.	93.8	81.1		68.4	55.8
	57	112.8		6.9	112.	112.		112.	100.	87.5		74.8	62.2	105.8	7.5	105.	105.		105.	93.2	80.5		67.8	55.2
				Temperature of Air on Condenser Coil 95°F											Temperature of Air on Condenser Coil 105°F
	72	108.0		13.4	61.8	54.6		47.3	40.0	32.8		-	-	99.4	11.5	59.2	52.0		44.7	37.4	30.2		-	-
2550	67	100.0		13.1	79.3	72.1		64.8	57.5	50.3		43.0	35.7	90.8	11.2	75.4	68.1		60.8	53.6	46.3		39.0	31.7
	62	92.0		12.8	92.0	87.5		80.3	73.0	65.7		58.5	51.2	82.0	11.0	82.0	79.8		72.7	65.4	58.2		50.9	43.6
	57	90.5		12.9	90.5	90.2		82.9	75.6	68.3		61.1	53.8	83.3	11.1	83.3	82.3		75.1	67.8	60.5		53.2	46.0
	72	111.3		10.9	68.2	59.7		51.1	42.5	33.9		-	-	102.8	10.3	65.7	57.2		48.6	40.0	31.4		-	-
2975	67	103.1		10.7	87.1	78.5		69.9	61.4	52.8		44.2	35.6	93.9	10.0	83.3	74.7		66.1	57.5	48.9		40.3	31.7
	62	94.8		10.4	94.8	92.6		86.6	78.0	69.4		60.9	52.3	84.8	9.8	84.8	83.7		79.0	70.4	61.8		53.2	44.6
	57	93.3		10.5	93.3	93.1		89.5	80.9	72.3		63.7	55.1	86.2	9.9	86.2	85.7		81.5	72.9	64.3		55.7	47.1
	72	114.7		8.4	74.6	64.7		54.8	44.9	35.0		-	-	106.2	9.1	72.3	62.3		52.4	42.5	32.6		-	-
3400	67	106.2		8.2	94.9	85.0		75.1	65.2	55.3		45.3	35.4	97.0	8.9	91.2	81.2		71.3	61.4	51.5		41.6	31.7
	62	97.7		8.0	97.7	97.7		93.0	83.1	73.2		63.3	53.3	87.6	8.7	87.6	87.6		85.2	75.3	65.4		55.5	45.6
	57	96.1		8.1	96.1	96.1		96.0	86.1	76.2		66.3	56.4	89.1	8.7	89.1	89.1		88.0	78.1	68.1		58.2	48.3
	72	116.3		8.4	80.2	68.9		57.6	46.3	35.0		-	-	107.6	9.1	78.0	66.7		55.4	44.1	32.9		-	-
3825	67	107.7		8.3	101.	90.2		78.9	67.6	56.3		45.0	33.7	98.2	8.9	95.0	86.7		75.4	64.1	52.8		41.6	30.3
	62	99.1		8.1	99.1	99.1		96.7	85.4	74.1		62.8	51.6	88.8	8.7	88.8	88.8		87.6	76.3	65.0		53.7	42.4
	57	97.5		8.1	97.5	97.5		97.4	86.2	74.9		63.6	52.3	90.2	8.8	90.2	90.2		89.7	78.4	67.1		55.8	44.5
	72	117.9		8.4	85.7	73.0		60.3	47.7	35.0		-	-	108.9	9.2	83.8	71.1		58.5	45.8	33.1		-	-
4250	67	109.2		8.3	108.	95.3		82.7	70.0	57.3		44.7	32.0	99.5	8.9	98.9	92.2		79.5	66.9	54.2		41.5	28.9
	62	100.5		8.1	100.	100.		100.	87.8	75.1		62.4	49.8	89.9	8.8	89.9	89.9		89.9	77.2	64.6		51.9	39.2
	57	98.9		8.1	98.9	98.9		98.9	86.2	73.5		60.8	48.2	91.3	8.8	91.3	91.3		91.3	78.7	66.0		53.3	40.7
				Temperature of Air on Condenser Coil 115°F											Temperature of Air on Condenser Coil 125°F
	72	90.8		9.6	56.6	49.4		42.1	34.8	27.5		-	-	82.2	7.8	54.0	46.8		39.5	32.2	24.9		-	-
2550	67	81.6		9.4	71.4	64.1		56.8	49.6	42.3		35.0	27.8	72.3	7.5	67.4	60.1		52.9	45.6	38.3		31.0	23.8
	62	72.1		9.2	72.1	72.1		65.1	57.9	50.6		43.3	36.0	62.1	7.3	62.1	62.1		57.6	50.3	43.0		35.7	28.5
	57	76.2		9.3	76.2	74.5		67.2	59.9	52.7		45.4	38.1	69.0	7.5	69.0	66.7		59.4	52.1	44.8		37.6	30.3
	72	94.3		9.7	63.3	54.7		46.1	37.5	28.9		-	-	85.8	9.1	60.8	52.2		43.6	35.0	26.4		-	-
2975	67	84.7		9.4	79.4	70.8		62.2	53.6	45.0		36.4	27.8	75.4	8.8	75.4	66.9		58.3	49.8	41.2		32.6	24.0
	62	74.8		9.2	74.8	74.8		71.3	62.7	54.1		45.5	36.9	64.8	8.6	64.8	64.8		63.6	55.0	46.4		37.8	29.2
	57	79.1		9.3	79.1	78.2		73.6	65.0	56.4		47.8	39.2	71.9	8.8	71.9	70.8		65.6	57.0	48.4		39.8	31.3
	72	97.7		9.8	69.9	60.0		50.0	40.1	30.2		-	-	89.3	10.5	67.5	57.6		47.7	37.7	27.8		-	-
3400	67	87.8		9.5	87.4	77.5		67.6	57.7	47.8		37.8	27.9	78.6	10.1	78.6	73.7		63.8	53.9	44.0		34.1	24.2
	62	77.6		9.3	77.6	77.6		77.4	67.5	57.6		47.7	37.8	67.5	9.9	67.5	67.5		67.5	59.7	49.8		39.9	30.0
	57	82.0		9.4	82.0	82.0		79.9	70.0	60.1		50.2	40.3	74.9	10.1	74.9	74.9		71.9	62.0	52.0		42.1	32.2
	72	98.8		9.8	75.9	64.6		53.3	42.0	30.7		-	-	90.1	10.6	73.7	62.5		51.2	39.9	28.6		-	-
3825	67	88.8		9.5	88.6	83.3		72.0	60.7	49.4		38.1	26.8	79.3	10.2	79.3	79.3		68.5	57.2	46.0		34.7	23.4
	62	78.5		9.4	78.5	78.5		78.4	67.1	55.8		44.5	33.2	68.2	10.0	68.2	68.2		68.2	57.9	46.6		35.3	24.1
	57	82.9		9.5	82.9	82.9		81.9	70.6	59.3		48.0	36.7	75.6	10.1	75.6	75.6		74.1	62.8	51.5		40.2	28.9
	72	100.0		9.9	81.9	69.2		56.6	43.9	31.2		-	-	91.0	10.6	80.0	67.3		54.7	42.0	29.3		-	-
4250	67	89.8		9.6	89.8	89.1		76.4	63.7	51.0		38.4	25.7	80.0	10.3	80.0	80.0		73.2	60.6	47.9		35.2	22.6
	62	79.3		9.4	79.3	79.3		79.3	66.7	54.0		41.3	28.7	68.8	10.1	68.8	68.8		68.8	56.1	43.5		30.8	18.1
	57	83.8		9.5	83.8	83.8		83.8	71.2	58.5		45.8	33.2	76.3	10.2	76.3	76.3		76.3	63.7	51.0		38.3	25.6

1These capacities are gross ratings. For net capacity, deduct air blower motor, MBh = 3.415 x kW. Refer to the appropriate Blower Performance Table for the kW of the supply air blower motor.

2These ratings include the condenser fan motors (total 1 kW) and the compressor motors but not the supply air blower motor.

Unitary Products Group

15