Whirlpool AWM 8125/2 Service Manual
SERVICE
Model AWM 8125/2
Version 8570 812 10700 Page
Whirlpool Europe
Customer Services
AWM 8125/2
Service Manual
Washing machine
Frontloader
AWM 8125/2
Technical data 2 - 4
Spare part list 5 - 6
Exploded view 7 - 8
Wiring diagram 9
Circuit diagram 10
Program chart 11 - 16
Text/Legend 17 - 19
Family SC1
This documentation is only intended for qualified technicians who are aware of the respective safety regulations.
Date: 22.09.2003 Subject to modification
Document-No.: 4812 722 21024
22.09.2003 / Page 2 AWM 8125/2 Whirlpool Europe
Doc. No: 4812 722 21024 8570 812 10700 Customer Service
Technical data
SERVICE
Dimensions
Height 85 cm
Width 59.5 cm
Depth 60 cm
Weight
Without packing 73 kg
Main Connection
Voltage 230 V
Frequency 50 Hz
Power consumption 2.3 kW
Fuse rating 10 A
Drum
Volume 53 l
Wash spin 54 rpm
Ramp spin 95 rpm
Speed spinning max. 1200 rpm
Capacity of dry laundry
Nominal currents
Contacts
11 - 12 4 (4) A
11 - 14 16 (4) A
11 - 16 1 (1) A
Contact system
11 - 12 - 14 spring contact
11 - 16 sliding contact
Damping system no
Door lock
Lock time (20 ˚C) 3“ - 6’’
Unlock time 60“ - 90’’
Nominal voltage 230 V
Nominal current:
Contact 4 - 5 16 (4) A
Heating element
Kind of heating Tubularheating element
with NTC - sensor
Nominal Voltage 230 V
Nominal power 2050 W
resistance R25 22 - 28 Ω
Cotton/coloured 6 kg
Cotton rapid 3 kg
Cotton short 6 kg
Daily 3 kg
Easy care 2.5 kg
Easy care rapid 1.5 kg
Easy care short 2.5 kg
Delicate 1.5 kg
Wool 1 kg
Water Level
Level 1
Switching point 55 ± 5 mmWc
Switching back point 35 ± 5 mmWc
Overflow 280 ± 20 mmWc
Water level inside the drum
(only switching level inside the drum)
Level 1 25 - 39 mm
Overflow 267 - 306 mm
Resistance NTC :
0˚C 35.9 kΩ
30˚C 9.8 kΩ
40˚C 6.6 kΩ
50˚C 4.6 kΩ
60˚C 3.2 kΩ
70˚C 2.3 kΩ
95˚C 1.1 kΩ
Inlet valve
Water temperature max. 60 ˚C
Rated flow <1 bar 8 l/min
Pressure range 0,5 - 10 bar
Nominal voltage 220 - 240 V
Frequency 50 Hz
Starting voltage:
<6 bar 160 V
6 - 10 bar 170 V
Nominal current 35 mA
Nominal power 6 VA
Nominal (20 ˚C) 3.4 - 4.5 kΩ
SERVICE
Technical data
Whirlpool Europe AWM 8125/2 22.09.2003 / Page 3
Customer Service 8570 812 10700 Doc. No: 4812 722 21024
Drain pump (synchronous)
Nominal Voltage 230 V
Nominal current 0.3 A
Nominal power 34 W
Frequency 50 Hz
Resistor (coil) 155 Ω± 7%
Motor protection 170 ˚C
Capacity(1,25m height) 14 ± 2 l/min
Program timer
Type SC1
Timer basic 4619 710 67644
Timer programmed 4619 744 82011
Nominal voltage 230 V
Frequency 50 Hz
Ambient temperature up to 70 ˚C
Storage temperature up to 85 ˚C
Connector
OA4.1 - OA4.2 5. Option
OA4.3 - OA4.4 6. Option
OB4.1 - OB4.2 3. Option
OB4.3 - OB4.4 4. Option
OC4.1 - OC4.2 1. Option
OC4.3 - OC4.4 2. Option
SLT3.1 - SLT3.3 Temp.selector
SLS4.1 - SLS4.4 Spin speed selector
VCF3.1 - VCF3.3 Valve (cold water)
VHF3.1 - VHF3.3 Valve (hot water)
Pi5.1 = negative supply
Pi5.2 = data
Pi5.3 = clock
Pi5.4 = positive supply
Pi 5.5 = negative supply
PL3.1 - PL3.3 Pilot lamp
Connector
M7.1 - M7.7 Motor
DP2.1 - DP2.2 Pump
AQS2.1 - AQS2.2 Aquastopswitch
SET2.1 - SET2.2 NTC
DSS3.1 - DSS3.3 Door switch
PR2.1 - PR2.2 Pressostat
Spin speed
Wash speed 54 rpm
Ramp speed 95 rpm
Spin speed 1200 rpm
Resistence (at the selector)
1160 rpm 4.7 kΩ
960 rpm 3.6 kΩ
780 rpm 2.7 kΩ
580 rpm 1.8 kΩ
440 rpm 1.1 kΩ
95 rpm 0.68 kΩ
00
Without resistor on push button switch
released 1160 rpm
pushed 580 rpm
Output
Motor M7.6 - DSS3.2 >40 V
Aquastop AQ2.2 - DSS3.2 230 V
in pump step AQ2.1 - DSS3.2 230 V
NTC not measurable
Pump DP2.1 - DP2.2 230 V
Doorlock DSS3.1 - DSS3.3 230 V
Pressostat E4 - E2 230 V
- empty PR2.1 - E2 230 V
- full PR2.2 - E2 230 V
Valve (Rast 2,5) V2.1 - V2.2 >170 V
Options not measurable
Display module Pi5.1 - Pi5.4 5 V
Pi5.4 - Pi5.5 12 V
Motor
Type MCA 61/64 - 148 t.f./
WHE 0
Belt ratio i = 1:13.3
Resistance contacts
6 - 7 68.7 Ω ± 7%
4 - 5 1.78 Ω ± 7%
2 - 3 1.86 Ω ± 7%
1 - 3 0.99 Ω ± 7%
Single connector
HE2.1 - HE2.2 Heating element
PS2.1 - PS2.2 Pressostat
SM3.2 - SM3.3 mains switch
(3 fold connector)
22.09.2003 / Page 4 AWM 8125/2 Whirlpool Europe
Doc. No: 4812 722 21024 8570 812 10700 Customer Service
SERVICE
Technical data
Radio interference supression
Type ISKRA - KPB 7325
Nominal voltage 230 V
Nominal capacity 250 nF X1 + 2 x 22 nF Y2 ± 20%
Derivation current ≥ 4.15 mA (2 x 2.075 mA) at 250V 50Hz
Nominal resistance 1 MΩ ± 5%
Push button switch
Switch start SST
Switch start delay STD
Switch + ST+
Switch - ST Switch easy ironing SEI
Switch pre wash SPW
Switch rinse intensive SRI
Switch rinse stop SRS
Switch spin reduction SSR
Indication
- Remaining time indication
Whirlpool Europe AWM 8125/2 22.09.2003 / Page 5
SERVICE
Customer Service 8570 812 10700 Doc. No: 4812 722 21024
Spare part list
Model AWM 8125/2
Service No. 857081210700
Version 857081210700
Pos. No. 12NC Code Description
001 0 4812 440 10784 Cabinet GW
002 0 4812 440 10876 Flap Filter round + Holder GW
004 0 4812 440 18993 Drip tray assy
011 0 4812 462 48421 Adjust.foot
021 0 4812 440 10897 Front round Flap GW
024 0 4812 440 18998 Panel, rear
025 0 4812 404 38551 Support control board VBL WH
030 0 4812 310 18937 Table top VBL WH GW
040 0 4812 417 18787 Hinge
050 0 4812 440 10823 Plinth GW
061 0 4812 466 88458 Counter weight upper
061 1 4812 466 88607 Counter weight front
061 2 4819 310 39227 Mounting kit Weight top
061 3 4819 310 39228 Mounting kit Weight bottom
081 0 4812 466 48088 Shock absorber 1400
084 0 4812 466 58001 Silent bloc
086 1 4812 401 18413 Holder Shock absorber
086 2 4812 401 18412 Stopper
110 0 4812 498 18261 Handle,door GW
130 0 4812 417 28047 Plate Door lock
130 1 4812 417 28048 Plate Doorlock Lower
131 0 4812 417 28046 Lock Door
131 1 4812 417 28045 Pin Door Lock
131 2 4812 492 58022 Spring Door Lock
135 1 4812 498 18262 Knob Door safety GW
Pos. No. 12NC Code Description
409 0 4812 362 48004 Brush,carbon motor CESET
421 0 4812 121 18142 Interf.filter 1,00 µ F
430 0 4812 310 28144 Pump,draining KIT
451 0 4812 259 28759 Heating element 2050W + NTC
480 0 4812 321 78109 Cable Motor SC1/OMEGA PP/ALPHA
490 0 4819 321 18136 Cable,mains 2m SA
491 0 4812 321 28367 Strain relief
491 1 4812 502 38152 Screw 4.8x19
500 0 4812 282 19426 Timer SC1 (EI,PW,IR,RH)
571 0 4812 271 28375 Valve,magnet Single
581 0 4812 276 18327 Pressostat 55/35
620 0 4812 239 58002 Module "A" C/DS
630 0 4812 280 58019 Door lock
631 0 4812 271 38358 Switch MICRO
631 1 4812 360 58112 Floater Kit BK,WH
691 0 4812 282 18702 Sensor NTC(SC1,OMEGAPL,ACCESS)
701 0 4812 530 28781 Hose, inlet 3.8 m (Eltek)
701 0 4819 530 28926 Hose, inlet 2.5 m (Eltek)
701 1 4819 466 69704 Gasket and filter
702 0 4819 530 29019 Hose intern
707 0 4812 526 48033 Nozzle Distribution 4
707 1 4812 526 48028 Nozzle
708 1 4812 530 48143 Bend
711 0 4812 418 88055 Detergent disp. 4 ch. 53 l
712 0 4812 418 79703 Drawer 4 VBL ASS
135 2 4812 491 48004 Spring
135 3 4812 290 68153 Holder,adjust. Door Safety
140 0 4812 450 68219 Door glass
143 0 4812 440 10817 Glassdoor frame VBL WH GW
144 0 4812 440 10833 Frame,door glas GW
191 0 4812 460 68527 Door bellow standard
191 0 4812 460 68532 Door bellow WH grease resistance
191 1 4812 492 18017 Strap
191 2 4819 530 58059 Ring
200 1 4812 418 18283 Tub 53l front
200 2 4812 418 18305 Tub 53l rear
200 4 4812 290 88054 Clamp for tub
220 0 4812 418 18288 Drum 53l, 1200
271 0 4819 358 18152 Belt
272 0 4812 528 58027 Pulley DIAM.298
272 2 4812 532 18024 Washer
272 3 4812 505 18371 Nut M 12
292 0 4812 530 58101 Gasket Tub
301 0 4812 452 14158 Control panel AWM 8125/2
303 0 4812 498 78516 Handle, drawer GW
321 0 4812 452 14055 Insert panel
321 1 4812 532 98011 Fastener f. Inlay
331 0 4812 414 58201 Knob,timer VBL WH GW
332 1 4812 513 18126 Push button Start VBL WH GW
332 2 4812 513 18127 Push buttonspin speed VBL WH GW
713 0 4812 418 89019 Flap Detergent Cont. GW
717 0 4812 418 78925 Bowden cable
717 1 4812 321 38013 Lever , Nozzle
717 2 4812 321 38012 Holder,adjust.
717 3 4812 278 88018 Slide
717 4 4812 492 38359 Spring , Nozzle
717 5 4812 282 18806 Cam 4 C. SC1/VBL/WH
718 0 4812 526 48051 Siphon
718 1 4812 418 88024 Accessory 4ch
753 1 4819 418 68234 Chamber,air
754 0 4812 530 28826 Drainhose
754 1 4812 530 28832 Lock eco
754 2 4812 530 28829 Flange eco
760 0 4812 480 58105 Filter set pump
781 0 4819 530 28847 Hose,draining
782 0 4812 530 28827 Hose Pressostat
783 1 4812 530 28822 Hose
787 0 4812 530 28813 Steam hose
787 2 4819 401 18868 Clamp,hose 26.8 mm
794 5 4812 530 58098 Gasket Airtrap
900 0 4812 255 18204 Holder Hose outlet
900 1 4812 290 88086 Bracket
900 2 4812 290 88077 Cable clamp
900 3 4812 401 18446 Cable clamp
900 4 4819 401 18872 Clamp,hose
332 3 4812 513 18128 Push button option VBL WH GW
332 4 4812 513 18129 Push button temp. + VBL WH GW
332 5 4812 513 18131 Push button temp. - VBL WH GW
400 0 4812 361 58388 Motor MCA 61/64-148/WHE0
400 1 4812 502 18401 Screw M8X 35
900 5 4819 401 18529 Clamp,hose
900 6 4812 401 18444 Support Heating element
900 7 4812 256 98031 Holder pressostat
900 8 4819 401 18823 Clamp
901 3 4812 401 18549 Clamp,hose
22.09.2003 / Page 6 AWM 8125/2 Whirlpool Europe
Doc. No: 4812 722 21024 8570 812 10700 Customer Service
Spare part list
Model AWM 8125/2
Service No. 857081210700
Version 857081210700
Pos. No. 12NC Code Description
910 5 4812 502 18516 Screw 4,2 x 13
930 0 4819 492 38139 Spring Suspension
941 0 4812 520 28004 Bearing,ball 6206
941 1 4812 520 28072 Bearing,ball 6303
953 0 4812 530 58099 Shaft seal 1200
961 0 4819 532 68829 Spacer
965 0 4812 466 68545 Cover BK/WH
993 0 4819 530 29028 Bow
993 3 4812 395 58004 Tool
SERVICE
Loading...