PERFORMER®
Charcoal Grill Owner’s Guide
Guía del propietario del asador - Pg 23
Guide de l’utilisateur du grill - Pg 35
Assembly, Ensamblaje, Assemblage - Pg 7
YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GAS GRILL
m DANGER
If you smell gas:
1.Shut off gas to the appliance.
2.Extinguish any open flames.
3.Open lid.
4.If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
Leaking gas may cause a fire or explosion which can cause serious bodily injury or death, or damage to property.
mWARNING
1.Do not store spare liquid propane cylinder within 10 feet (3m) of this appliance.
2.Do not store or use gasoline or other flammable liquids or vapors within 25 feet (8m) of this appliance.
#56201
mWARNING: Follow all leak-check procedures carefully in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions must be left with the owner and the owner should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY.
mWARNING: Do not try to light this appliance without reading the “Lighting” Instructions section of this manual.
mFailure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death.
56201 US 01/28/10
DANGERS AND WARNINGS
FAILURE TO HEED THESE DANGER, WARNING AND CAUTION STATEMENTS MAY CAUSE SERIOUS BODILY INJURY OR DEATH, OR A FIRE OR EXPLOSION RESULTING IN DAMAGE TO PROPERTY.
mSAFETY SYMBOLS ( m ) will alert you to important SAFETY information.
mSignal Words DANGER, WARNING, or CAUTION will be used with the SAFETY SYMBOL.
mDANGER will identify the most serious hazard.
mPlease read all safety information contained in this Owner’s Guide before operating this barbecue.
m DANGERS
mFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.
mDo not use indoors! This barbecue is designed for outdoor use only. If used indoors, toxic fumes will accumulate and cause serious bodily injury or death.
mOnly use this barbecue outdoors in a well-ventilated area. Do not use in a garage, building, breezeway or any other enclosed area.
mDo not use this barbecue under any overhead combustible construction.
mImproper assembly may be dangerous. Please follow the assembly instructions in this manual. Do not use barbecue unless all parts are in place. Make sure either the ash catcher is properly attached to the legs underneath the bowl of the barbecue, or the high capacity ash catcher is in place, before lighting the grill.
mDo not add charcoal starter fluid or charcoal impregnated with charcoal lighter fluid to hot or warm charcoal. Cap starter fluid after use, and place a safe distance away from the barbecue.
mDo not use gasoline, liquid fire starter, alcohol or other highly volatile fluids on the charcoal at any time. Do not use any form of self-lighting charcoal at any time.
mYou should exercise reasonable care when operating your barbecue. It will be hot during cooking and should never be left unattended during use.
mDo not leave infants, children or pets unattended near a hot barbecue.
mDo not attempt to move a hot barbecue.
mDo not use this barbecue within five feet of any combustible material. Combustible materials include, but are not limited to wood or treated wood decks, patios and porches.
mCombustible materials should never be within 24 inches of the top, bottom, back or sides of barbecue.
mKeep the cooking area clear of flammable vapor and liquids, such as gasoline, alcohol, etc., and combustible material.
mDo not remove ashes until all charcoal is completely burned out and are fully extinguished and grill is cool.
mAlways put charcoal in Char-Baskets™ or on top of the lower (charcoal) grate. Do not put charcoal directly in the bottom of the bowl.
mDo not wear clothing with loose flowing sleeves while lighting or using the barbecue.
mNever lean over the barbecue when lighting the gas burner.
mDo not use barbecue in high winds.
mDo not operate the barbecue if a gas leak is present.
mDo not use a flame to check for gas leaks.
mShould the burner go out at any time during operation, turn tank valve off. Remove lid and wait five minutes before attempting to relight, using the lighting instructions outlined in this Manual.
mDo not attempt to disconnect the gas regulator from the tank or any gas fitting while the barbecue is in use.
mUse only the LP gas regulator that is supplied with your barbecue.
m WARNINGS
mDo not store a spare or disconnected LP tank under or near this barbecue.
mKeep the barbecue on a secure, level surface at all times, clear of combustible materials.
mDo not put a barbecue cover or anything flammable on or in the storage area under the barbecue
mAlways remove the lid before lighting the gas burner, either manually or with the igniter. Lid must remain OFF until charcoal is fully ignited.
mNever touch the cooking or charcoal grates, ashes, charcoal or the barbecue to see if they are hot.
mDo not use lava or char rocks in this barbecue.
mDo not use water to control flare-ups or to extinguish charcoal, as it may damage the porcelain finish. Slightly close bottom air vents (dampers) and place lid on bowl.
mExtinguish coals when finished cooking. Close all vents (dampers) after putting lid on bowl.
mBarbecue mitts should always be worn while cooking, adjusting air vents (dampers), adding charcoal and handling the thermometer or lid.
mUse proper barbecue tools, with long, heat-resistant handles.
mSome models may include the Tuck-Away™ lid holder feature. The Tuck-Away™ lid holder is used to store the lid while checking on or turning your food. Do not use the Tuck-Away™ lid holder as a handle to lift or move the grill. Do not place a hot lid on carpeting or grass. Do not hang the lid on the bowl handle.
mNever dump hot coals where they might be stepped on or be a fire hazard. Never dump ashes or coals before they are fully extinguished. Do not store barbecue until ashes and coals are fully extinguished.
2
DANGERS AND WARNINGS (CONT’D)
m WARNINGS (cont’d)
mHandle and store hot electric starters carefully.
mKeep electrical wires and cords away from the hot surfaces of the barbecue and away from high traffic areas.
mAfter a period of storage and/or nonuse, check for gas leaks and burner obstructions before using. See instructions in this manual for correct procedures.
mThe conversion or attempted use of natural gas in this barbecue is dangerous and will void your warranty.
mA dented or rusty LP tank may be hazardous and should be checked by your liquid propane supplier. Do not use an LP tank with a damaged valve.
mAlthough your LP tank may appear to be empty, it may still contain gas. The tank should be transported and stored accordingly.
mCombustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
mPROP 65 WARNING: Handling the brass material on this product exposes you to lead, a chemical known to the State of California to cause cancer, and birth defects and other reproductive harm. Wash hands after handling this product.
mIf you see, smell or hear gas escaping from the LP tank:
1.Get away from the LP tank.
2.Do not attempt to correct the problem yourself.
3.Call your Fire Department.
m CAUTIONS
mLining the bowl with aluminum foil will obstruct the air flow. Instead, use a drip pan to catch drippings from meat when cooking by the Indirect Method.
mUsing sharp objects to clean the cooking grate or remove ashes will damage the finish.
mUsing abrasive cleaners on the cooking grates or the barbecue itself will damage the finish.
mThe barbecue should be thoroughly cleaned on a regular basis.
WARRANTY
Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows:
Cooking / Charcoal grates |
2 years |
Stainless Steel One-Touch® Cleaning System |
10 years |
Bowl and lid against rust / burn-through |
10 years |
Nylon handles |
10 years |
Thermoplastic/Thermoset Parts(Performer®) |
10 years |
|
excluding fading |
All remaining parts |
2 years |
when assembled and operated in accordance with the printed instructions accompanying it.
Weber may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE.
This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are defective. Before returning any parts, contact the Customer Service Representative in your area using the contact information on our website. If Weber confirms the defect and approves the claim, Weber will elect to replace such parts without charge. If you are required to return defective parts, transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner’s manual.
Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not
covered by this Limited Warranty.
There are no other express warrants except as set forth herein and any applicable implied warranties of merchantability and fitness are limited in duration to the period of coverage of this express written Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this limitation may not apply to you.
Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not apply to you.
Weber does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such representations are binding on Weber.
This Warranty applies only to products sold at retail.
WEBER-STEPHEN PRODUCTS CO. Customer Service Center
1890 Roselle Road, Suite 308 Schaumburg, IL 60195
USA
For replacement parts call: 1-800-446-1071
Visit www.weber.com®, select your country of origin, and register your grill today.
www.weber.com® 3
EXPLODED VIEW • Diagrama de despiece • VUE ECLATEE
1
2
3 
4 
5
6
5 
7 8 
9
10
11
12
13
14
15 
16 
17 
18 
19 
20
Performer LP US22 1/2 (57cm) 050609
21
22
23
33 lbs. Max. (15Kg )
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
4
EXPLODED VIEW LIST • LISTA DEL DIAGRAMA DE DESPIECE • LISTE DE LA VUE ECLATEE
1. |
Lid |
14. |
Hub Cap |
27. |
Burner Assembly |
|
Tapa |
|
Tapa del cubo |
|
Ensamble del quemador |
|
Couvercle |
|
Cache du moyeux |
|
Assemblage du brûleur |
2. |
Hinged Cooking Grate |
15. |
Wheel Cover |
28. Hose & Regulator with Orifice Clip |
|
|
Rejilla de cocción con bisagras |
|
Tapa de la rueda |
|
Manguera y regulador con clip del orificio |
|
Grille de cuisson avec gonds |
|
Cache de la roue |
|
Tuyau & régulateur avec pince pour l’orifice |
3. |
Charcoal Baskets |
16. |
Front Panel |
29. |
Rear Panel |
|
Canastas para carbón vegetal |
|
Panel delantero |
|
Panel posterior |
|
Paniers à charbon de bios |
|
Panneau avant |
|
Panneau arrière |
4. |
Charcoal Grate |
17. |
Logo Plate |
30. |
Frame Leg |
|
Rejilla para el carbón |
|
Placa del logotipo |
|
Pata tipo marco |
|
Grille à charbon de bois |
|
Plaque avec le logo |
|
Pied du châssis |
5. |
One Touch® Damper Assembly |
18. |
Tool Holders |
31. |
CharBin™ Hardware |
|
Ensamble del regulador de aire One Touch® |
|
Portaherramientas |
|
Herrajes del CharBin™ |
|
Assemblage du registre One Touch® |
|
Supports pour les ustensiles |
|
Matériel CharBin™ |
6. |
Lid Holder & Lower Support Assembly |
19. |
Gas Control Cover |
32. |
CharBin™ |
|
Ensamble del portatapas y soporte inferior |
|
Cubierta del control de gas |
|
CharBin™ |
|
Porte-couvercle & assemblage du couvercle |
|
Couvercle de la commande du gaz |
|
CharBin™ |
|
inférieur |
20. |
Igniter |
33. |
Casters |
|
|
||||
7. |
Ash Catcher Ring |
|
Encendedor |
|
Ruedas locas |
|
Aro del recolector de cenizas |
|
Allumeur |
|
Roulettes |
|
Anneau de l’attrape-cendre |
21. |
Lid Handle Assembly |
34. |
Caster Inserts |
|
|
||||
8. |
Ash Catcher Handle |
|
Ensamble del asa de la tapa |
|
Insertos para las ruedas locas |
|
Manivela del recolector de cenizas |
|
Assemblage de la poignée du couvercle |
|
Inserts pour les roulettes |
|
Poignée de l’attrape-cendre |
22. |
Lid Damper Assembly |
35. Leg Frame Bracket Clamp |
|
|
|
||||
9. |
High Capacity Ash Catcher |
|
Ensamble del regulador de aire de la tapa |
|
Abrazadera de la ménsula del |
|
Recolector de cenizas de alta capacidad |
|
Assemblage du registre du couvercle |
|
marco de las patas |
|
Attrape-cendre haute capacité |
23. |
Thermometer Assembly |
|
Pince du support du châssis du pied |
|
|
|
|
||
10. |
Axle |
|
Ensamble del termómetro |
36. |
Bottom Rack |
|
Eje |
|
Assemblage du thermomètre |
|
Rejilla inferior |
|
Axe |
24. |
Bowl |
|
Grille inférieure |
|
|
|
|
||
11. |
Leg Frame Bracket |
|
Tazón |
37. |
Matchlight Holder |
|
Ménsula del marco de las patas |
|
Cuve |
|
Portacerillos |
|
Support du châssis du pied |
25. |
Table |
|
Support du porte-allumettes |
|
|
|
|
||
12. |
Igniter Wire Stay |
|
Mesa |
|
|
|
Tensor del encendedor |
|
Table |
|
|
|
Câble de l’allumeur |
26. |
CharBin™ Retention Chain |
|
|
|
|
|
|
||
13. |
Wheel |
|
Cadena de retención del CharBin™ |
|
|
|
Rueda |
|
Chaîne de retenue CharBin™ |
|
|
|
Roue |
|
|
|
|
MAY INCLUDE: • PUEDE INCLUIR: • PEUT CONTENIR:
38.Sear Grate with Hinged Cooking Grate
Rejilla para dorar a fuego vivo con rejilla de cocción con bisagra.
Grille à saisir avec grille de cuisson avec gonds
www.weber.com® 5
PARTS LIST • LISTA DE PARTES • LISTE DES PIECES
3/8”
1-
4- 
2-
8- 
6
|
ASSEMBLY • ENSAMBLAJE • ASSEMBLAGE |
1 |
2 |
4 - 
3 |
4 |
|
4 - |
www.weber.com® 7
5
7
ASSEMBLY • ENSAMBLAJE • ASSEMBLAGE
|
6 |
4 - |
1- |
1- 
8
ASSEMBLY • ENSAMBLAJE • ASSEMBLAGE
8
Aa |
Aa |
Ba |
Ba |
Ca |
Ca |
www.weber.com® 9
9
10
ASSEMBLY • ENSAMBLAJE • ASSEMBLAGE
4-
4 - 
10
ASSEMBLY • ENSAMBLAJE • ASSEMBLAGE
11
A
B
m WARNING
Prior to use, pull the gas hose and orifice to make sure that the retaining clip is in place and that the gas hose and orifice is securely attached inside the burner tube.
A missing retaining clip can cause the gas hose and orifice to move out of the burner tube.This can cause a fire resulting in serious bodily injury or death and damage to property.
m DANGER
Do not use the gas ignition feature if the retaining clip (1) securing the gas line and orifice into the burner tube is missing.
A missing retaining clip can cause the gas hose and orifice to move out of the burner tube.This can cause a fire resulting in serious bodily injury or death and damage to property.
1 -
m ADVERTENCIA
Antes de utilizarse, hale la manguera de gas y el orificio para asegurarse de que el clip de retención esté en su lugar y el orificio esté bien sujeto dentro del tubo quemador.
Un clip de retención faltante puede ocasionar que la manguera de gas y el orificio se salgan del tubo quemador. Esto podría resultar en un incendio causante de heridas corporales graves y daños materiales.
m PELIGRO
No utilice la función de encendido del gas si faltase el clip de retención (1) que sujeta la línea de gas y el orificio dentro del quemador de gas.
Un clip de retención faltante puede ocasionar que la manguera de gas y el orificio se salgan del tubo quemador. Esto podría resultar en un incendio causante de heridas corporales graves y daños materiales.
m MISE EN GARDE
Avant utilisation, tirez sur le tuyau de gaz et sur l’orifice pour vous assurer que la pince de retenue est en place et que le tuyau de gaz et l’orifice sont solidement fixés à l’intérieur du tube du brûleur.
Une pince de retenue manquante peut provoquer la sortie du tuyau de gaz et de l’orifice hors du tube du brûleur. Ceci peut provoquer un incendie avec pour conséquence des blessures graves ou un décès ainsi que des dégâts matériels.
m DANGER
N’utilisez pas la fonction d’allumage du gaz si la pince de retenue (1) qui fixe la conduite de gaz et l’orifice à l’intérieur du tube du brûleur est manquante.
Une pince de retenue manquante peut provoquer la sortie du tuyau de gaz et de l’orifice à l’extérieur du tube du brûleur. Ceci peut provoquer un incendie avec pour conséquence des blessures graves ou un décès ainsi que des dégâts matériels.
www.weber.com® 11
ASSEMBLY • ENSAMBLAJE • ASSEMBLAGE
12
3/8” 2 
1 
13
A B
14
A 
B
4 - 
33 lbs. Max. (15Kg )
12
15
16
ASSEMBLY • ENSAMBLAJE • ASSEMBLAGE
30lb bag
Charcoal
30lb / 13.7kg
mMaximum 30 lbs. / 13.7 kg. bag of charcoal.
The bag of charcoal should be placed directly in the CharBin™ Storage Container.
mMáximo una bolsa de 30 lbs. / 13.7 kg. de carbón vegetal. La bolsa de carbón vegetal debe colocarse directamente en el recipiente de almacenaje CharBin™.
mSac de charbon de bois 30 lbs. / 13,7 kg. maximum. Le sac de charbon de bois devrait être placé directement dans le Conteneur de stockage CharBin™.
1-
www.weber.com® 13
GENERAL INSTRUCTIONS
•These instructions will give you the minimum requirements for assembling your
Weber® gas barbecue. Please read the instructions carefully before using your Weber® gas barbecue. Improper assembly can be dangerous.
•Not for use by children.
•The installation must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58; or CSA B149.1, Natural Gas and Propane Installation Code.
•The pressure regulator supplied with the Weber® gas barbecue must be used. This regulator is set for 11 inches of water column (pressure).
•This Weber® gas barbecue is designed for use with liquid propane (LP) gas only. Do not use with natural (piped in city) gas. The valves, orifices, hose and regulator are for LP gas only.
•This appliance is not intended for commercial use.
•Check that the area under the control panel and the bottom tray are free from debris that might obstruct the flow of combustion or ventilation air.
•The areas around the LP cylinder must be free and clear from debris.
•Replacement pressure regulators and hose assemblies must be those specified by the outdoor cooking gas appliance manufacturer.
•Place dust caps on cylinder valve outlets when cylinder is not in use.
Important Cylinder Information
mNEVER store a spare LP Cylinder under or near this barbecue.
Note: Your Weber® gas grill is equipped for a cylinder supply system designed for vapor withdrawal.
•The LP-gas supply cylinder to be used must be constructed and marked in accordance with the specifications for LP - gas cylinders of the U.S. Department of Transportation (D.O.T.) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods.
FEATURES: |
|
|
|
|
|
A) Exclusive Touch-N-Go™ Gas Ignition System takes the hassle out of lighting |
7 |
10 |
9 |
3 |
|
charcoal briquets (1). Simply push a button and the system’s gas burner ignites, |
|||||
|
|||||
starting the charcoal for you. No dangerous liquid starters to use or store, and no |
|
|
|
|
|
more liquid starter aftertaste. |
|
|
|
|
B)CharBin™ Storage Container holds a bag of charcoal with a maximum weight of
30 lbs./13.7 kg (2). The bag of charcoal should be placed directly in the CharBin™ |
8 |
Storage Container. |
C) Thermoset work surface serves as a great work area and covers the CharBin™
Storage Container to keep briquets dry (3).
D)Convenient bottom rack for storage (4).
E) |
High-capacity ash catcher locks in place, eliminating blowing ashes (5). |
|
|
|
F) |
One-Touch® Cleaning System easily sweeps out ashes, or opens and closes the |
|
|
|
|
vents (6). |
|
|
|
G) |
Thermometer monitors the cooking temperature inside the grill (7). |
|
|
|
H) |
Tuck-Away™ Lid slides back into the stainless steel lid holder and acts as a |
|
|
|
|
windshield when lighting briquets (8). |
|
|
|
I) |
Hinged access flaps swing open on cooking grate for easy addition of briquets or |
|
|
|
|
wood chips during cooking (9). |
|
|
|
J) |
Char-Basket™ Fuel Holders allow convenient indirect and concentrated direct |
|
|
1 |
|
cooking flexibility with wood or charcoal (10). |
|
|
|
|
5 |
6 |
4 |
2 |
Operating area
mWARNING: Only use this barbecue outdoors in a wellventilated area. Do not use in a garage, building, breezeway or any other enclosed area.
mThe use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.
mNever operate the barbecue under any overhead combustible construction.
mYour Weber® Barbecue is not intended to be installed in or on recreational vehicles and/or boats.
mDo not use combustible materials within 24 inches of the top, bottom, back or sides of the grill.
mThe entire barbecue gets hot when in use. Do not leave unattended.
mKeep any electrical supply cord and the fuel supply hose away from any heated surface.
mKeep the cooking area clear of flammable vapors and liquids, such as gasoline, alcohol, etc., and combustible materials.
mDo not move the appliance during use. Allow the grill to cool before moving.
mThis appliance is not intended for and should never be used as a heater.
mWhen cooking, the appliance must be on a level, stable surface in an area clear of combustible material.
mMaximum 30 lbs. / 13.7 kg. bag of charcoal.
The bag of charcoal should be placed directly in the CharBin™ Storage Container.
14
GAS INSTRUCTIONS
Attach Propane Cylinder
Use disposable propane cylinders with a capacity of either 14.1 oz. or 16.4 oz. equipped with a CGA #600 connection.
m CAUTION: Use cylinders that are marked “Propane fuel” only.
Push propane cylinder into regulator and turn clockwise until tight.
m WARNING: Hand tighten only. Using excessive force could damage the regulator coupling and could cause a leak.
Check for gas leaks:
m DANGER
Do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or flames will result in a fire or explosion which can cause serious bodily injury or death, and damage to property.
A) Regulator to propane cylinder connection.
mWARNING: If there is a leak at connection (1), remove propane cylinder by turning counterclockwise. Do not operate grill. Use a different propane cylinder and recheck for leaks with soap and water solution. If a leak persists after retightening the propane cylinder, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.
B) Regulator-to-hose connections.
m WARNING: If there is a leak at connection (2) turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.
When leak checks are complete, turn gas supply OFF at the source and rinse connections with water.
m DANGER
Do not store a spare LP-gas cylinder under or near this appliance.
1 |
2
www.weber.com® 15
Loading...